Differences in hydrolytic abilities of two crude lipases from Geotrichum candidum 4013

Lipase activity of recombinant KmYJR107Wp and KmLIP3p enzymes expressed in Saccharomyces cerevisiae BY4742 from Kluyveromyces marxianus L2029

Lipases are used in many food, energy, and pharmaceutical processes. Thus, new systems have been sought to synthesize alternative lipases with potential biotechnological applications. Kluyveromyces marxianus is a yeast with recognized lipase activity; at least ten putative lipases/esterases in its genome have been detected, and two of them possess a signal peptide for extracellular secretion. The study of extracellular lipases becomes more relevant since they usually have higher activity rates than intracellular lipases and simpler purification mechanisms. For these reasons, this study aimed to characterize the production and lipase activity of the putative extracellular lipases of the K. marxianus L-2029 strain, encoded in the genes LIP3 and YJR107W. Both genes were heterologously expressed in Saccharomyces cerevisiae BY4742 (yeast strain without extracellular lipase activity) using a pYES2.1/V5-His-TOPO® plasmid. Herein, we show evidence that the strain transformed with the LIP3 gene did not show lipase activity during flask galactose induction. On the other hand, the strain transformed with the YJR107W gene showed a specific activity of 0.397 U/mg, with an optimum temperature of 37 °C and pH 6. For maximum cell production, glucose and yeast extract concentrations were evaluated by a 22 factorial design, followed by the validation of the best concentrations predicted by a statistical model; a 22 factorial design was also carried out to evaluate the concentration of the inducer galactose on the transformed strains, and the intracellular and extracellular lipase specific activities were quantified. Finally, the biomass and lipase production were determined for each strain, which was grown in a stirred tank bioreactor with a working volume of 1.5 L. The specific activities of the transformed strains obtained in the bioreactor were 1.36 U/mg for the LIP3 transformant and 1.25 U/mg for the YJR107W transformant, respectively.

Sucrose-Powered Liposome Nanosensors for Urinary Glucometer-Based Monitoring of Cancer

Timely detection of early-stage cancer holds immense potential in enhancing prognostic outcomes. There is an increasing desire for versatile tools to enable simple, sensitive, and cost-effective cancer detection. By exploiting the extraintestinal metabolic inertness and efficiency renal clearance of sucrose, we designed a liposome nanosensor using sucrose as a messenger to convert tumor-specific esterase activity into glucose meter readout, enabling economical and sensitive urinalysis for cancer detection in point-of-care testing (POCT). Our results demonstrate that the nanosensors exhibited significant signal differences between tumor-bearing and healthy mice in both orthotopic and metastatic tumor models. Additionally, efficient elimination of the nanosensors through the hepatobiliary pathway was observed with no significant toxicity. Such a non-invasive diagnostic modality significantly assists in personalized pharmacological treatment and follow-up efficacy assessment. We envision that this modular liposome nanosensor platform might be applied for economically detecting diverse diseases via a simple urinary test.

Uncovering the Biotechnological Importance of Geotrichum candidum

Fungi make a fundamental contribution to several biotechnological processes, including brewing, winemaking, and the production of enzymes, organic acids, alcohols, antibiotics, and pharmaceuticals. The present review explores the biotechnological importance of the filamentous yeast-like fungus Geotrichum candidum, a ubiquitous species known for its use as a starter in the dairy industry. To uncover G. candidum's biotechnological role, we performed a search for related work through the scientific indexing internet services, Web of Science and Google Scholar. The following query was used: Geotrichum candidum, producing about 6500 scientific papers from 2017 to 2022. From these, approximately 150 that were associated with industrial applications of G. candidum were selected. Our analysis revealed that apart from its role as a starter in the dairy and brewing industries, this species has been administered as a probiotic nutritional supplement in fish, indicating improvements in developmental and immunological parameters. Strains of this species produce a plethora of biotechnologically important enzymes, including cellulases, β-glucanases, xylanases, lipases, proteases, and α-amylases. Moreover, strains that produce antimicrobial compounds and that are capable of bioremediation were identified. The findings of the present review demonstrate the importance of G. candidum for agrifood- and bio-industries and provide further insights into its potential future biotechnological roles.

Valorization of xylose-rich hydrolysate from rice straw, an agroresidue, through biosurfactant production by the soil bacterium Serratia nematodiphila

Biosurfactants, amphiphilic compounds that reduce interfacial tension in oil-aqueous mixtures, are used in the petroleum, pharmaceutical, food, and agriculture industries. Fermentative production of biosurfactants requires expensive sugar or lipid substrates. Lignocellulosic biomass is a relatively cheap and abundant agricultural residue that can be used as an alternative substrate. Currently, several million tonnes of rice and wheat straw are generated globally as agricultural residues, most of which is disposed by open-field burning thereby leading to severe environmental pollution. This study aimed to produce biosurfactants in xylose-rich hydrolysates generated from rice straw. The hydrolysate is also a byproduct of 2G biofuel processes that often goes underutilized. A soil bacterium capable of growing and producing biosurfactants in rice straw hydrolysates, which typically contain growth-inhibitory compounds such as furfural and hydroxymethyl furfural, was isolated. Interestingly, the organism, identified as Serratia nematodiphila, exhibited higher glycolipid formation (4.5 ± 0.6 gL^-1) in xylose-rich hydrolysate than in glucose-rich enzymatic hydrolysate (3.1 ± 0.2 gL^-1) despite the higher bacterial cell density observed with the latter. The biosurfactants were thermostable and possessed promising emulsifying property and anti-microbial activity against bacteria and yeast. Further optimization of C:N resulted in a 2.8-fold increase in glycolipid production from xylose-rich hydrolysates. This study demonstrates the production of glycolipid biosurfactants from lignocellulosic biomass, a low-cost substrate and offers a plausible strategy for the management of these residues. Further, it also provides insights into the generation of additional high-value compounds in a bioethanol biorefinery to improve its commercial feasibility.

Studies on the catalytic behavior of a membrane-bound lipolytic enzyme from the microalgae Nannochloropsis oceanica CCMP1779

The catalytic behavior of a membrane-bound lipolytic enzyme (MBL-Enzyme) from the microalgae Nannochloropsis oceanica CCMP1779 was investigated. The biocatalyst showed maximum activity at 50 °C and pH 7.0, and was stable at pH 7.0 and temperatures from 40 to 60 °C. Half-lives at 60 °C, 70 °C and 80 °C were found 866.38, 150.67 and 85.57 min respectively. Thermal deactivation energy was 68.87 kJ mol^-1. The enzyme's enthalpy (ΔΗ*), entropy (ΔS*) and Gibb's free energy (ΔG*) were in the range of 65.86-66.27 kJ mol^-1, 132.38-140.64 J mol^-1 K^-1 and 107.80-115.81 kJ mol^-1, respectively. Among p-nitrophenyl esters of fatty acids tested, MBL-Enzyme exhibited the highest hydrolytic activity against p-nitrophenyl palmitate (pNPP). The K_m and V_max values were found 0.051 mM and of 0.054 mmole pNP mg protein^-1 min^-1, respectively with pNPP as substrate. The presence of Mn²⁺ increased lipolytic activity by 68.25%, while Fe³⁺ and Cu²⁺ ions had the strongest inhibitory effect. MBL-Enzyme was stable in the presence of water miscible (66% of the initial activity in ethanol) and water immiscible (71% of the initial activity in n-octane) solvents. Myristic acid was found to be the most efficient acyl donor in esterification reactions with ethanol. Methanol was the best acyl acceptor among the primary alcohols tested.

Engineering aspects of immobilized lipases on esterification: A special emphasis of crowding, confinement and diffusion effects

Cross-linked enzyme crystal (CLEC) and sol-gel entrapped pseudomonas sp. lipase were investigated for the esterification of lauric acid with ethanol by considering the effects of reaction conditions on reaction rate. The activation energy for the reaction was estimated to be 1097.58 J/mol and 181.75 J/mol for sol-gel and CLEC entrapped lipase respectively. CLEC lipase exhibited a marginal internal diffusion effect on reaction rate over sol-gel lipases and found to be interesting. The overall reaction mechanism was found to conform to the Ping Pong Bi Bi mechanism. The higher efficiency of sol-gel lipases over CLEC lipases in esterification reaction is mainly due to the combined effects of crowding, confinement and diffusional limitations.

Development and Optimization of a High-Throughput Screening Assay for Rapid Evaluation of Lipstatin Production by Streptomyces Strains

Pancreatic lipase inhibitors, such as tetrahydrolipstatin (orlistat), are used in anti-obesity treatments. Orlistat is the only anti-obesity drug approved by the European Medicines Agency (EMA). The drug is synthesized by saturation of lipstatin, a β-lactone compound, isolated from Streptomyces toxytricini and S. virginiae. To identify producers of novel pancreatic lipase inhibitors or microbial strains with improved lipstatin production and higher chemical purity remains still a priority. In this study, a high-throughput screening method to identify Streptomyces strains producing potent pancreatic lipase inhibitors was established. The assay was optimized and validated using S. toxytricini NRRL 15443 and its mutants. Strains grew in 24-well titer plates. Lipstatin levels were assessed directly in culture medium at the end of cultivation by monitoring lipolytic activity in the presence of a chromogenic substrate, 1,2-Di-O-lauryl-rac-glycero-3-glutaric acid 6-methylresorufin ester (DGGR). The lipase activity decreased in response to lipstatin production, and this was demonstrated by accumulation of red-purple methylresorufin, a product of DGGR digestion. The sensitivity of the assay was achieved by adding a lipase of high lipolytic activity and sensitivity to lipstatin to the reaction mixture. In the assay, the fungal lipase from Mucor javanicus was used as an alternative to the human pancreatic lipase. Many fungal lipases preserve high lipolytic activity in extreme conditions and are not colipase dependent. The assay proved to be reliable in differentiation of strains with high and low lipstatin productivity.

New lipases by mining of Pleurotus ostreatus genome

The analysis of Pleurotus ostreatus genome reveals the presence of automatically annotated 53 lipase and 34 carboxylesterase putative coding-genes. Since no biochemical or physiological data are available so far, a functional approach was applied to identify lipases from P. ostreatus. In the tested growth conditions, four lipases were found expressed, with different patterns depending on the used C source. Two of the four identified proteins (PleoLip241 and PleoLip369), expressed in both analysed conditions, were chosen for further studies, such as an in silico analysis and their molecular characterization. To overcome limits linked to native production, a recombinant expression approach in the yeast Pichia pastoris was applied. Different expression levels were obtained: PleoLip241 reached a maximum activity of 4000 U/L, whereas PleoLip369 reached a maximum activity of 700 U/L. Despite their sequence similarity, these enzymes exhibited different substrate specificity and diverse stability at pH, temperature, and presence of metals, detergents and organic solvents. The obtained data allowed classifying PleoLip241 as belonging to the “true lipase” family. Indeed, by phylogenetic analysis the two proteins fall in different clusters. PleoLip241 was used to remove the hydrophobic layer from wool surface in order to improve its dyeability. The encouraging results obtained with lipase treated wool led to forecast PleoLip241 applicability in this field.

Lipases as tools in the synthesis of prodrugs from racemic 9-(2,3-dihydroxypropyl)adenine

Lipases from Geotrichum candidum 4013 (extracellular lipase and cell-bound lipase) were immobilized by adsorption on chitosan beads. The enzyme preparations were tested in the synthesis of ester prodrugs from racemic 9-(2,3-dihydroxypropyl)adenine in dimethylformamide with different vinyl esters (acetate, butyrate, decanoate, laurate, palmitate). The transesterification activities of these immobilized enzymes were compared with commercially available lipases (lipase from hog pancreas, Aspergillus niger, Candida antarctica, Pseudomonas fluorescens). Lipase from Candida antarctica was found to be the most efficient enzyme regarding chemical yield of the desired products, while transesterification by lipase from Aspergillus niger resulted in lower yields.