Electrophoretic karyotyping of wild-type and mutant Trichoderma longibrachiatum (reesei) strains

Protein O-mannosylation affects protein secretion, cell wall integrity and morphogenesis in Trichoderma reesei

Protein O-mannosyltransferases (PMTs) initiate O-mannosylation of proteins in the ER. Trichoderma reesei strains displayed a single representative of each PMT subfamily, Trpmt1, Trpmt2 and Trpmt4. In this work, two knockout strains ΔTrpmt1and ΔTrpmt4were obtained. Both mutants showed retarded growth, defective cell walls, reduced conidiation and decreased protein secretion. Additionally, the ΔTrpmt1strain displayed a thermosensitive growth phenotype, while the ΔTrpmt4 strain showed abnormal polarity. Meanwhile, OETrpmt2 strain, in which the Trpmt2 was over-expressed, exhibited increased conidiation, enhanced protein secretion and abnormal polarity. Using a lectin enrichment method and MS/MS analysis, 173 O-glycoproteins, 295 O-glycopeptides and 649 O-mannosylation sites were identified as the targets of PMTs in T. reesei. These identified O-mannoproteins are involved in various physiological processes such as protein folding, sorting, transport, quality control and secretion, as well as cell wall integrity and polarity. By comparing proteins identified in the mutants and its parent strain, the potential specific protein substrates of PMTs were identified. Based on our results, TrPMT1 is specifically involved inO-mannosylation of intracellular soluble proteins and secreted proteins, specially glycosidases. TrPMT2 is involved inO-mannosylation of secreted proteins and GPI-anchor proteins, and TrPMT4 mainly modifies multiple transmembrane proteins. The TrPMT1-TrPMT4 complex is responsible for O-mannosylation of proteins involved in cell wall integrity. Overexpression of TrPMT2 enhances protein secretion, which might be a new strategy to improve expression efficiency in T. reesei.

Studies of Cellulose and Starch Utilization and the Regulatory Mechanisms of Related Enzymes in Fungi

Polysaccharides are biopolymers made up of a large number of monosaccharides joined together by glycosidic bonds. Polysaccharides are widely distributed in nature: Some, such as peptidoglycan and cellulose, are the components that make up the cell walls of bacteria and plants, and some, such as starch and glycogen, are used as carbohydrate storage in plants and animals. Fungi exist in a variety of natural environments and can exploit a wide range of carbon sources. They play a crucial role in the global carbon cycle because of their ability to break down plant biomass, which is composed primarily of cell wall polysaccharides, including cellulose, hemicellulose, and pectin. Fungi produce a variety of enzymes that in combination degrade cell wall polysaccharides into different monosaccharides. Starch, the main component of grain, is also a polysaccharide that can be broken down into monosaccharides by fungi. These monosaccharides can be used for energy or as precursors for the biosynthesis of biomolecules through a series of enzymatic reactions. Industrial fermentation by microbes has been widely used to produce traditional foods, beverages, and biofuels from starch and to a lesser extent plant biomass. This review focuses on the degradation and utilization of plant homopolysaccharides, cellulose and starch; summarizes the activities of the enzymes involved and the regulation of the induction of the enzymes in well-studied filamentous fungi.

Integrated Translatome and Proteome: Approach for Accurate Portraying of Widespread Multifunctional Aspects of Trichoderma

Genome-wide studies of transcripts expression help in systematic monitoring of genes and allow targeting of candidate genes for future research. In contrast to relatively stable genomic data, the expression of genes is dynamic and regulated both at time and space level at different level in. The variation in the rate of translation is specific for each protein. Both the inherent nature of an mRNA molecule to be translated and the external environmental stimuli can affect the efficiency of the translation process. In biocontrol agents (BCAs), the molecular response at translational level may represents noise-like response of absolute transcript level and an adaptive response to physiological and pathological situations representing subset of mRNAs population actively translated in a cell. The molecular responses of biocontrol are complex and involve multistage regulation of number of genes. The use of high-throughput techniques has led to rapid increase in volume of transcriptomics data of Trichoderma. In general, almost half of the variations of transcriptome and protein level are due to translational control. Thus, studies are required to integrate raw information from different “omics” approaches for accurate depiction of translational response of BCAs in interaction with plants and plant pathogens. The studies on translational status of only active mRNAs bridging with proteome data will help in accurate characterization of only a subset of mRNAs actively engaged in translation. This review highlights the associated bottlenecks and use of state-of-the-art procedures in addressing the gap to accelerate future accomplishment of biocontrol mechanisms.

Proximity ligation scaffolding and comparison of two Trichoderma reesei strains genomes

BACKGROUND

The presence of low complexity and repeated regions in genomes often results in difficulties to assemble sequencing data into full chromosomes. However, the availability of full genome scaffolds is essential to several investigations, regarding for instance the evolution of entire clades, the analysis of chromosome rearrangements, and is pivotal to sexual crossing studies. In non-conventional but industrially relevant model organisms, such as the ascomycete Trichoderma reesei, a complete genome assembly is seldom available.

RESULTS

The chromosome scaffolds of T. reesei QM6a and Rut-C30 strains have been generated using a contact genomic/proximity ligation genomic approach. The original reference assembly, encompassing dozens of scaffolds, was reorganized into two sets of seven chromosomes. Chromosomal contact data also allowed to characterize 10-40 kb, gene-free, AT-rich (76%) regions corresponding to the T. reesei centromeres. Large chromosomal rearrangements (LCR) in Rut-C30 were then characterized, in agreement with former studies, and the position of LCR breakpoints used to assess the likely chromosome structure of other T. reesei strains [QM9414, CBS999.97 (1-1, re), and QM9978]. In agreement with published results, we predict that the numerous chromosome rearrangements found in highly mutated industrial strains may limit the efficiency of sexual reproduction for their improvement.

CONCLUSIONS

The GRAAL program allowed us to generate the karyotype of the Rut-C30 strain, and from there to predict chromosome structure for most T. reesei strains for which sequence is available. This method that exploits proximity ligation sequencing approach is a fast, cheap, and straightforward way to characterize both chromosome structure and centromere sequences and is likely to represent a popular convenient alternative to expensive and work-intensive resequencing projects.

RNA Sequencing Reveals Xyr1 as a Transcription Factor Regulating Gene Expression beyond Carbohydrate Metabolism

Xyr1 has been demonstrated to be the main transcription activator of (hemi)cellulases in the well-known cellulase producer Trichoderma reesei. This study comprehensively investigates the genes regulated by Xyr1 through RNA sequencing to produce the transcription profiles of T. reesei Rut-C30 and its xyr1 deletion mutant (Δxyr1), cultured on lignocellulose or glucose. xyr1 deletion resulted in 467 differentially expressed genes on inducing medium. Almost all functional genes involved in (hemi)cellulose degradation and many transporters belonging to the sugar porter family in the major facilitator superfamily (MFS) were downregulated in Δxyr1. By contrast, all differentially expressed protease, lipase, chitinase, some ATP-binding cassette transporters, and heat shock protein-encoding genes were upregulated in Δxyr1. When cultured on glucose, a total of 281 genes were expressed differentially in Δxyr1, most of which were involved in energy, solute transport, lipid, amino acid, and monosaccharide as well as secondary metabolism. Electrophoretic mobility shift assays confirmed that the intracellular β-glucosidase bgl2, the putative nonenzymatic cellulose-attacking gene cip1, the MFS lactose transporter lp, the nmrA-like gene, endo T, the acid protease pepA, and the small heat shock protein hsp23 were probable Xyr1-targets. These results might help elucidate the regulation system for synthesis and secretion of (hemi)cellulases in T. reesei Rut-C30.

Deciphering the molecular mechanisms behind cellulase production in Trichoderma reesei, the hyper-cellulolytic filamentous fungus

The filamentous fungus Trichoderma reesei is a potent cellulase producer and the best-studied cellulolytic fungus. A lot of investigations not only on glycoside hydrolases produced by T. reesei, but also on the machinery controlling gene expression of these enzyme have made this fungus a model organism for cellulolytic fungi. We have investigated the T. reesei strain including mutants developed in Japan in detail to understand the molecular mechanisms that control the cellulase gene expression, the biochemical and morphological aspects that could favor this phenotype, and have attempted to generate novel strains that may be appropriate for industrial use. Subsequently, we developed recombinant strains by combination of these insights and the heterologous-efficient saccharifing enzymes. Resulting enzyme preparations were highly effective for saccharification of various biomass. In this review, we present some of the salient findings from the recent biochemical, morphological, and molecular analyses of this remarkable cellulase hyper-producing fungus.

Characterization of the Ca(2+) -responsive signaling pathway in regulating the expression and secretion of cellulases in Trichoderma reesei Rut-C30

Calcium signaling plays pivotal roles in the hyphal growth, conidiation, and osmosis sensitivity of fungi through the Ca(2+) /calmodulin-calcineurin-dependent pathway. This study found that an appropriate extracellular Ca(2+) concentration markedly stimulated the hyphal growth, cellulase production, and total protein secretion of the cellulase hyper-producing strain, Trichoderma reesei Rut-C30. Transcription analysis revealed upregulation of not only encoding genes of cellulases and the transcriptional activator XYR1 but also several genes encoding endoplasmic reticulum-chaperones after Ca(2+) addition. The function of CRZ1, T. reesei calcineurin-responsive zinc finger transcription factor 1, was further characterized by gene disruption. Electrophoretic mobility shift assays (EMSAs) in combination with chromatin immunoprecipitation (ChIP) verified that CRZ1 could bind directly to the upstream regions of xyr1 and cbh1 (cellobiohydrolase I-encoding gene) in response to Ca(2+) . A DNase I footprinting assay identified its putative binding consensus site (5'-[T/G]GGCG-3' or 5'-GGGC[G/T]-3'). EMSAs confirmed that CRZ1 competed for occupancy of the xyr1 promoter with another transcription factor, ACE1. These results revealed putative signaling pathways downstream of calcineurin in response to extracellular Ca(2+) involved in upregulation of cellulose degradation-related genes, reflecting progress in the study of Ca(2+) signaling in filamentous fungi. This study also provides insight that will facilitate further improvement of (hemi-)cellulase production by T. reesei.

Familiar Stranger: Ecological Genomics of the Model Saprotroph and Industrial Enzyme Producer Trichoderma reesei Breaks the Stereotypes

The filamentous fungus Trichoderma reesei (Hypocreales, Ascomycota) has properties of an efficient cell factory for protein production that is exploited by the enzyme industry, particularly with respect to cellulase and hemicellulase formation. Under conditions of industrial fermentations it yields more than 100g secreted protein L(-1). Consequently, T. reesei has been intensively studied in the 20th century. Most of these investigations focused on the biochemical characteristics of its cellulases and hemicellulases, on the improvement of their properties by protein engineering, and on enhanced enzyme production by recombinant strategies. However, as the fungus is rare in nature, its ecology remained unknown. The breakthrough in the understanding of the fundamental biology of T. reesei only happened during 2000s-2010s. In this review, we compile the current knowledge on T. reesei ecology, physiology, and genomics to present a holistic view on the natural behavior of the organism. This is not only critical for science-driven further improvement of the biotechnological applications of this fungus, but also renders T. reesei as an attractive model of filamentous fungi with superior saprotrophic abilities.

A complete annotation of the chromosomes of the cellulase producer Trichoderma reesei provides insights in gene clusters, their expression and reveals genes required for fitness

BACKGROUND

Investigations on a few eukaryotic model organisms showed that many genes are non-randomly distributed on chromosomes. In addition, chromosome ends frequently possess genes that are important for the fitness of the organisms. Trichoderma reesei is an industrial producer of enzymes for food, feed and biorefinery production. Its seven chromosomes have recently been assembled, thus making an investigation of its chromosome architecture possible.

RESULTS

We manually annotated and mapped 9194 ORFs on their respective chromosomes and investigated the clustering of the major gene categories and of genes encoding carbohydrate-active enzymes (CAZymes), and the relationship between clustering and expression. Genes responsible for RNA processing and modification, amino acid metabolism, transcription, translation and ribosomal structure and biogenesis indeed showed loose clustering, but this had no impact on their expression. A third of the genes encoding CAZymes also occurred in loose clusters that also contained a high number of genes encoding small secreted cysteine-rich proteins. Five CAZyme clusters were located less than 50 kb apart from the chromosome ends. These genes exhibited the lowest basal (but not induced) expression level, which correlated with an enrichment of H3K9 methylation in the terminal 50 kb areas indicating gene silencing. No differences were found in the expression of CAZyme genes present in other parts of the chromosomes. The putative subtelomeric areas were also enriched in genes encoding secreted proteases, amino acid permeases, enzyme clusters for polyketide synthases (PKS)-non-ribosomal peptide synthase (NRPS) fusion proteins (PKS-NRPS) and proteins involved in iron scavenging. They were strongly upregulated during conidiation and interaction with other fungi.

CONCLUSIONS

Our findings suggest that gene clustering on the T. reesei chromosomes occurs but generally has no impact on their expression. CAZyme genes, located in subtelomers, however, exhibited a much lower basal expression level. The gene inventory of the subtelomers suggests a major role of competition for nitrogen and iron supported by antibiosis for the fitness of T. reesei. The availability of fully annotated chromosomes will facilitate the use of genetic crossings in identifying still unknown genes responsible for specific traits of T. reesei.

Trichoderma reesei meiosis generates segmentally aneuploid progeny with higher xylanase-producing capability

BACKGROUND

Hypocrea jecorina is the sexual form of the industrial workhorse fungus Trichoderma reesei that secretes cellulases and hemicellulases to degrade lignocellulosic biomass into simple sugars, such as glucose and xylose. H. jecorina CBS999.97 is the only T. reesei wild isolate strain that is sexually competent in laboratory conditions. It undergoes a heterothallic reproductive cycle and generates CBS999.97(1-1) and CBS999.97(1-2) haploids with MAT1-1 and MAT1-2 mating-type loci, respectively. T. reesei QM6a and its derivatives (RUT-C30 and QM9414) all have a MAT1-2 mating type locus, but they are female sterile. Sexual crossing of CBS999.97(1-1) with either CBS999.97(1-2) or QM6a produces fruiting bodies containing asci with 16 linearly arranged ascospores (the sexual spores specific to ascomycetes). This sexual crossing approach has created new opportunities for these biotechnologically important fungi.

RESULTS

Through genetic and genomic analyses, we show that the 16 ascospores are generated via meiosis followed by two rounds of postmeiotic mitosis. We also found that the haploid genomes of CBS999.97(1-2) and QM6a are similar to that of the ancestral T. reesei strain, whereas the CBS999.97(1-1) haploid genome contains a reciprocal arrangement between two scaffolds of the CBS999.97(1-2) genome. Due to sequence heterozygosity, most 16-spore asci (>90%) contain four or eight inviable ascospores and an equal number of segmentally aneuploid (SAN) ascospores. The viable SAN progeny produced higher levels of xylanases and white conidia due to segmental duplication and deletion, respectively. Moreover, they readily lost the duplicated segment approximately two weeks after germination. With better lignocellulosic biomass degradation capability, these SAN progeny gain adaptive advantages to the natural environment, especially in the early phase of colonization.

CONCLUSIONS

Our results have not only further elucidated T. reesei evolution and sexual development, but also provided new perspectives for improving T. reesei industrial strains.

High-quality genome (re)assembly using chromosomal contact data

Closing gaps in draft genome assemblies can be costly and time-consuming, and published genomes are therefore often left ‘unfinished.’ Here we show that genome-wide chromosome conformation capture (3C) data can be used to overcome these limitations, and present a computational approach rooted in polymer physics that determines the most likely genome structure using chromosomal contact data. This algorithm—named GRAAL—generates high-quality assemblies of genomes in which repeated and duplicated regions are accurately represented and offers a direct probabilistic interpretation of the computed structures. We first validated GRAAL on the reference genome of Saccharomyces cerevisiae, as well as other yeast isolates, where GRAAL recovered both known and unknown complex chromosomal structural variations. We then applied GRAAL to the finishing of the assembly of Trichoderma reesei and obtained a number of contigs congruent with the know karyotype of this species. Finally, we showed that GRAAL can accurately reconstruct human chromosomes from either fragments generated in silico or contigs obtained from de novo assembly. In all these applications, GRAAL compared favourably to recently published programmes implementing related approaches.

The correct assembly of genomes from sequencing data remains a challenge due to difficulties in correctly assigning the location of repeated DNA elements. Here the authors describe GRAAL, an algorithm that utilizes genome-wide chromosome contact data within a probabilistic framework to produce accurate genome assemblies.

Heterologous protein expression in Hypocrea jecorina: a historical perspective and new developments

Hypocrea jecorina, the sexual teleomorph of Trichoderma reesei, has long been favored as an industrial cellulase producer, first utilizing its native cellulase system and later augmented by the introduction of heterologous enzymatic activities or improved variants of native enzymes. Expression of heterologous proteins in H. jecorina was once considered difficult when the target was an improved variant of a native cellulase. Developments over the past nearly 30 years have produced strains, vectors, and selection mechanisms that have continued to simplify and streamline heterologous protein expression in this fungus. More recent developments in fungal molecular biology have pointed the way toward a fundamental transformation in the ease and efficiency of heterologous protein expression in this important industrial host. Here, 1) we provide a historical perspective on advances in H. jecorina molecular biology, 2) outline host strain engineering, transformation, selection, and expression strategies, 3) detail potential pitfalls when working with this organism, and 4) provide consolidated examples of successful cellulase expression outcomes from our laboratory.

A highly sensitive in vivo footprinting technique for condition-dependent identification of cis elements

Knowing which regions of a gene are targeted by transcription factors during induction or repression is essential for understanding the mechanisms responsible for regulation. Therefore, we re-designed the traditional in vivo footprinting method to obtain a highly sensitive technique, which allows identification of the cis elements involved in condition-dependent gene regulation. Data obtained through DMS methylation, HCl DNA cleavage and optimized ligation-mediated PCR using fluorescent labelling followed by capillary gel electrophoresis are analysed by ivFAST. In this work we have developed this command line-based program, which is designed to ensure automated and fast data processing and visualization. The new method facilitates a quantitative, high-throughput approach because it enables the comparison of any number of in vivo footprinting results from different conditions (e.g. inducing, repressing, de-repressing) to one another by employing an internal standard. For validation of the method the well-studied upstream regulatory region of the Trichoderma reesei xyn1 (endoxylanase 1) gene was used. Applying the new method we could identify the motives involved in condition-dependent regulation of the cbh2 (cellobiohydrolase 2) and xyn2 (endoxylanase 2) genes.

Trichoderma reesei RUT-C30--thirty years of strain improvement

The hypersecreting mutant Trichoderma reesei RUT-C30 (ATCC 56765) is one of the most widely used strains of filamentous fungi for the production of cellulolytic enzymes and recombinant proteins, and for academic research. The strain was obtained after three rounds of random mutagenesis of the wild-type QM6a in a screening program focused on high cellulase production and catabolite derepression. Whereas RUT-C30 achieves outstanding levels of protein secretion and high cellulolytic activity in comparison to the wild-type QM6a, recombinant protein production has been less successful. Here, we bring together and discuss the results from biochemical-, microscopic-, genomic-, transcriptomic-, glycomic- and proteomic-based research on the RUT-C30 strain published over the last 30 years.

Array comparative genomic hybridization analysis of Trichoderma reesei strains with enhanced cellulase production properties

Background

Trichoderma reesei is the main industrial producer of cellulases and hemicellulases that are used to depolymerize biomass in a variety of biotechnical applications. Many of the production strains currently in use have been generated by classical mutagenesis. In this study we characterized genomic alterations in high-producing mutants of T. reesei by high-resolution array comparative genomic hybridization (aCGH). Our aim was to obtain genome-wide information which could be utilized for better understanding of the mechanisms underlying efficient cellulase production, and would enable targeted genetic engineering for improved production of proteins in general.

Results

We carried out an aCGH analysis of four high-producing strains (QM9123, QM9414, NG14 and Rut-C30) using the natural isolate QM6a as a reference. In QM9123 and QM9414 we detected a total of 44 previously undocumented mutation sites including deletions, chromosomal translocation breakpoints and single nucleotide mutations. In NG14 and Rut-C30 we detected 126 mutations of which 17 were new mutations not documented previously. Among these new mutations are the first chromosomal translocation breakpoints identified in NG14 and Rut-C30. We studied the effects of two deletions identified in Rut-C30 (a deletion of 85 kb in the scaffold 15 and a deletion in a gene encoding a transcription factor) on cellulase production by constructing knock-out strains in the QM6a background. Neither the 85 kb deletion nor the deletion of the transcription factor affected cellulase production.

Conclusions

aCGH analysis identified dozens of mutations in each strain analyzed. The resolution was at the level of single nucleotide mutation. High-density aCGH is a powerful tool for genome-wide analysis of organisms with small genomes e.g. fungi, especially in studies where a large set of interesting strains is analyzed.

An accurate normalization strategy for RT-qPCR in Hypocrea jecorina (Trichoderma reesei)

Hypocrea jecorina is an important, filamentous fungus due to its effective production of hydrolytic enzymes. Gene expression studies provide deeper insight into environment sensing and cellular response mechanisms. Reverse transcription-quantitative PCR is a gene-specific and powerful tool to measure even minor changes in mRNA composition. An accurate normalization strategy is absolutely necessary for appropriate interpretation of reverse transcription-quantitative PCR results. One frequently applied strategy is the usage of a reference gene. Adequate reference genes for Hypocrea have not been published so far. By using the NormFinder and geNorm softwares, we evaluated the most stable genes amongst six potential reference genes in 34 samples from diverse cultivation conditions. Under those experimental conditions, sar1 encoding for a small GTPase was found to be the most stable gene, whereas act encoding for actin was not amongst the best validated ones. The influence of the reference system on the expression data is demonstrated by analysis of two target genes, encoding for the Xylanase regulator 1 and for Xylanase II. We further validated obtained xylanase 2 transcription rates with the corresponding enzyme activity.

Translational research on Trichoderma: from 'omics to the field

Structural and functional genomics investigations are making an important impact on the current understanding and application of microbial agents used for plant disease control. Here, we review the case of Trichoderma spp., the most widely applied biocontrol fungi, which have been extensively studied using a variety of research approaches, including genomics, transcriptomics, proteomics, metabolomics, etc. Known for almost a century for their beneficial effects on plants and the soil, these fungi are the subject of investigations that represent a successful case of translational research, in which 'omics-generated novel understanding is directly translated in to new or improved crop treatments and management methods. We present an overview of the latest discoveries on the Trichoderma expressome and metabolome, of the complex and diverse biotic interactions established in nature by these microbes, and of their proven or potential importance to agriculture and industry.

Tracking the roots of cellulase hyperproduction by the fungus Trichoderma reesei using massively parallel DNA sequencing

Trichoderma reesei (teleomorph Hypocrea jecorina) is the main industrial source of cellulases and hemicellulases harnessed for the hydrolysis of biomass to simple sugars, which can then be converted to biofuels such as ethanol and other chemicals. The highly productive strains in use today were generated by classical mutagenesis. To learn how cellulase production was improved by these techniques, we performed massively parallel sequencing to identify mutations in the genomes of two hyperproducing strains (NG14, and its direct improved descendant, RUT C30). We detected a surprisingly high number of mutagenic events: 223 single nucleotides variants, 15 small deletions or insertions, and 18 larger deletions, leading to the loss of more than 100 kb of genomic DNA. From these events, we report previously undocumented non-synonymous mutations in 43 genes that are mainly involved in nuclear transport, mRNA stability, transcription, secretion/vacuolar targeting, and metabolism. This homogeneity of functional categories suggests that multiple changes are necessary to improve cellulase production and not simply a few clear-cut mutagenic events. Phenotype microarrays show that some of these mutations result in strong changes in the carbon assimilation pattern of the two mutants with respect to the wild-type strain QM6a. Our analysis provides genome-wide insights into the changes induced by classical mutagenesis in a filamentous fungus and suggests areas for the generation of enhanced T. reesei strains for industrial applications such as biofuel production.

Transcriptional regulation of xyr1, encoding the main regulator of the xylanolytic and cellulolytic enzyme system in Hypocrea jecorina

In Hypocrea jecorina, Xyr1 (xylanase regulator 1) is the main transcription activator of hydrolase-encoding genes, such as xyn1, xyn2, bxl1, cbh1, cbh2, egl1, and bgl1. Even though Xyr1 mediates the induction signal for all these genes derived from various inducing carbon sources and compounds, xyr1 transcription itself is not inducible by any of these substances. However, cultivation on glucose as the carbon source provokes carbon catabolite repression of xyr1 transcription mediated by Cre1. In addition, xyr1 transcription is repressed by the specific transcription factor Ace1. Moreover, Xyr1 is permanently available in the cell, and no de novo synthesis of this factor is needed for a first induction of xyn1 transcription. The constitutive expression of xyr1 leads to a significant elevation/deregulation of the xyn1, xyn2, and bxl1 transcription compared to what is seen for the parental strain. Overall, the corresponding xylanolytic enzyme activities are clearly elevated in a constitutively xyr1-expressing strain, emphasizing this factor as an auspicious target for genetically engineered strain improvement.

The Hypocrea jecorina (Trichoderma reesei) hypercellulolytic mutant RUT C30 lacks a 85 kb (29 gene-encoding) region of the wild-type genome

Background

The hypercellulolytic mutant Hypocrea jecorina (anamorph Trichoderma reesei) RUT C30 is the H. jecorina strain most frequently used for cellulase fermentations and has also often been employed for basic research on cellulase regulation. This strain has been reported to contain a truncated carbon catabolite repressor gene cre1 and is consequently carbon catabolite derepressed. To date this and an additional frame-shift mutation in the glycoprotein-processing β-glucosidase II encoding gene are the only known genetic differences in strain RUT C30.

Results

In the present paper we show that H. jecorina RUT C30 lacks an 85 kb genomic fragment, and consequently misses additional 29 genes comprising transcription factors, enzymes of the primary metabolism and transport proteins. This loss is already present in the ancestor of RUT C30 – NG 14 – and seems to have occurred in a palindromic AT-rich repeat (PATRR) typically inducing chromosomal translocations, and is not linked to the cre1 locus. The mutation of the cre1 locus has specifically occurred in RUT C30. Some of the genes that are lacking in RUT C30 could be correlated with pronounced alterations in its phenotype, such as poor growth on α-linked oligo- and polyglucosides (loss of maltose permease), or disturbance of osmotic homeostasis.

Conclusion

Our data place a general caveat on the use of H. jecorina RUT C30 for further basic research.

Reidentification of cellulolytic enzyme-producing Trichoderma strains W-10 and G-39

Strain W-10, originally identified as Trichoderma koningii, and its supposed mutant G-39, published for production and gene expression of cellulase and xylanase, demonstrated morphological characteristics distinct from those of T. koningii, respectively. To clarify the identification derived from morphological characteristics, several methods were used, including electrophoretic karyotyping, internal transcribed spacer (ITS) analysis of rDNA, and polymerase chain reaction (PCR) fingerprinting using the universal primer L45. All the molecular characteristics showed that strains G-39 and W-10 were identical to T. reesei and T. longibrachiatum, respectively. The results strongly supported that T. koningii G-39 and W-10 should be reassigned as T. reesei and T. longibrachiatum, respectively. Strain G-39 should be considered a mutant from T. reesei QM9414 whose spores were contaminated with those of strain W-10 during a laboratory operation. According to this, we declare that T. koningii G-39 and W-10 must be renamed as T. reesei and T. longibrachiatum, respectively.Key words: PCR fingerprinting, electrophoretic karyotypes, ITS, Trichoderma.

The xylanolytic enzyme system from the genus Penicillium

In nature, there are numerous microorganisms that efficiently degrade xylan, a major component of lignocellulose. In particular, filamentous fungi have demonstrated a great capability for secreting a wide range of xylanases, being the genus Aspergillus and Trichoderma the most extensively studied and reviewed among the xylan-producing fungi. However, an important amount of information about the production and genetics of xylanases from fungi of the genus Penicillium has accumulated in recent years. A great number of Penicillia are active producers of xylanolytic enzymes, and the use of xylanases from these species has acquired growing importance in biotechnological applications. This review summarizes our current knowledge about the properties, genetics, expression and biotechnological potential of xylanases from the genus Penicillium.

Pulsed-field gel electrophoresis: a versatile tool for analysis of fungal genomes. A review

The separation of chromosome-size DNA molecules by pulsed-field gel electrophoresis (PFGE) has become a well-established technique in recent years. Although it has very wide-ranging applications, it made a real breakthrough for fungal genome analysis. Because of the small size of fungal chromosomes, their investigation was not possible earlier. Different PFGE approaches allowed the separation of DNA molecules larger than 10 megabase pairs in size, and electrophoretic karyotypes for numerous previously genetically uncharacterized fungal species could be established. This review discusses the applicability of these electrophoretic karyotypes for the investigation of genome structure, for strain identification and for species delimitation.

Characterization of secretory genes ypt1/yptA and nsf1/nsfA from two filamentous fungi: induction of secretory pathway genes of Trichoderma reesei under secretion stress conditions

Two genes involved in protein secretion, encoding the Rab protein YPT1/YPTA and the general fusion factor NSFI/NSFA, were characterized from two filamentous fungi, Trichoderma reesei and Aspergillus niger var. awamori. The isolated genes showed a high level of conservation with their Saccharomyces cerevisiae and mammalian counterparts, and T. reesei ypt1 was shown to complement yeast Ypt1p depletion. The transcriptional regulation of the T. reesei ypt1, nsf1, and sar1 genes, involved in protein trafficking, was studied with mycelia treated with the folding inhibitor dithiothreitol (DTT) and with brefeldin A, which inhibits membrane traffic between the endoplasmic reticulum and Golgi complex. The well-known inducer of the yeast and T. reesei unfolded protein response (UPR), DTT, induced the nsf1 gene and the protein disulfide isomerase gene, pdi1, in both of the experiments, and sar1 mRNA increased in only one experiment under strong UPR induction. The ypt1 mRNA did not show a clear increase during DTT treatment. Brefeldin A strongly induced pdi1 and all of the intracellular trafficking genes studied. These results suggest the possibility that the whole secretory pathway of T. reesei could be induced at the transcriptional level by stress responses caused by protein accumulation in the secretory pathway.

Electrophoretic karyotype analysis in fungi

The resolution of chromosomal-sized DNAs by PFGE has many applications that include karyotyping, strain identification of similar species, characterization of transformed strains, building of linkage maps, and preparation of DNA for genomic analysis. Successful electrophoretic separation of chromosomes is an empiric process in which the initial concentration of intact chromosome-sized DNA and the optimization of electrophoretic parameters are the most important experimental variables. Nonetheless, inherent attributes of the genome architecture of certain species may thwart success. When a karyotype contains numerous chromosomes of the same size and/or many large (greater than 8 Mb) chromosomes, no amount of manipulation of the electrophoretic parameters will resolve individual chromosome bands using present technology. Further, fungi display a surprising amount of intraspecific variation in both chromosome number and size, making it difficult to establish a standard "reference" karyotype for many species. Although PFGE is not a panacea for bringing genetics to species that lack classical genetic systems, it often does provide a way for developing a molecular linkage map in the absence of a formal genetic system. It is far faster than parasexual analysis in the discovery of linkage relationships. For genomics projects, DNA can be recovered from pulsed field gels and used to prepare chromosome-specific libraries. Where whole genome sequencing strategies are used, chromosomes separated by PFGE provide an anchor for sequencing data. Electrophoretic karyotypes can be probed with anonymous pieces of DNA from bacterial artificial chromosome (BAC) contigs, thereby facilitating the building of physical maps. In conclusion, despite its shortcomings, the PFGE technique underlies much of our current understanding of the physical nature of the fungal genome.

Characterisation of two 14-3-3 genes from Trichoderma reesei: interactions with yeast secretory pathway components

The 14-3-3 proteins are highly conserved, ubiquitously expressed proteins taking part in numerous cellular processes. Two genes encoding 14-3-3 proteins, ftt1 and ftt2, were isolated and characterised from the filamentous fungus Trichoderma reesei. FTTI showed the highest sequence identity (98% at the amino acid level) to the Trichoderma harzianum protein Th1433. FTTII is relatively distinct from FTTI, showing approximately 75% identity to other fungal 14-3-3 proteins. Despite their sequence divergence, both of the T. reesei ftt genes were equally able to complement the yeast bmh1 bmh2 double disruption. The T. reesei ftt genes were also found to be quite closely linked in the genomic DNA. A C-terminally truncated version of ftt1 (ftt1DeltaC) was first isolated as a multicopy suppressor of the growth defect of the temperature-sensitive yeast secretory mutant sec15-1. Overexpression of ftt1DeltaC also suppressed the growth defect of sec2-41, sec3-101, and sec7-1 strains. Overexpression of ftt1DeltaC in sec2-41 and sec15-1 strains could also rescue the secretion of invertase at the restrictive temperatures, and overexpression of full-length ftt1 enhanced invertase secretion by wild-type yeast cells. These findings strongly suggest that the T. reesei ftt1 has a role in protein secretion.

Electrophoretic karyotype of the filamentous fungus Penicillium purpurogenum and chromosomal location of several xylanolytic genes

The electrophoretic karyotype of the filamentous fungus Penicillium purpurogenum has been resolved. Using contour-clamped homogeneous electric field gel electrophoresis, five chromosomal bands were separated, with estimated sizes of 7.1, 5.2, 3.7, 2.9 and 2.3 Mbp, giving a total genome size of 21.2 Mbp. To our knowledge, this is the smallest Penicillium genome determined so far. By Southern blots and using homologous probes, the chromosomal location of five xylanolytic genes from P. purpurogenum was determined: axeI (acetyl xylan esterase I), xynB (endoxylanase B) and abf1 (arabinofuranosidase 1) in chromosome I, xynA (endoxylanase A) in chromosome II, and axeII (acetyl xylan esterase II) in chromosome III. This is the first study where the location of xylanase genes in a Penicillium genome has been established.

Recovery of Mutants Impaired in Pathogenicity After Transposition of Impala in Fusarium oxysporum f. sp. melonis

ABSTRACT The ability of transposon impala to inactivate genes involved in pathogenicity was tested in Fusarium oxysporum f. sp. melonis. Somatic excision of an impala copy inserted in the nitrate reductase-encoding niaD gene was positively selected through a phenotypic assay based on the restoration of nitrate reductase activity. Independent excision events were analyzed molecularly and shown to carry reinsertedimpala in more than 70% of the cases. Mapping of reinserted impala elements on large NotI-restriction fragments showed that impala transposes randomly. By screening 746 revertants on plants, a high proportion (3.5%) of mutants impaired in their pathogenic potential was recovered. According to the kinetics of wilt symptom development, the strains that were impaired in pathogenicity were clustered in three classes: class 1 grouped two strains that never induced Fusarium wilt symptoms on the host plant; class 2 and class 3 grouped 15 and 9 revertants which caused symptoms more than 50 and 30 days after inoculation, respectively. The first results demonstrate the efficiency of transposition in generating mutants affected in pathogenicity, which are usually difficult to obtain by classical mutagenesis, and open the possibility to clone the altered genes with impala as a tag.

Isolation of the ace1 gene encoding a Cys(2)-His(2) transcription factor involved in regulation of activity of the cellulase promoter cbh1 of Trichoderma reesei

A genetic selection method was developed for the cloning of positive-acting transcriptional regulatory genes in Saccharomyces cerevisiae. The method was applied for the isolation of activators of Trichoderma reesei (Hypocrea jecorina) cellulase genes. Activator genes were isolated from a T. reesei expression cDNA library on the basis of the ability of their translation products to activate transcription from the full-length T. reesei cbh1 promoter coupled to the S. cerevisiae HIS3 gene and to support the growth of the yeast colonies in the absence of histidine. Among the clones obtained was the ace1 gene encoding a novel polypeptide, ACEI, that contains three zinc finger motifs of Cys(2)-His(2) type. Possible ACEI homologues were found among expressed sequence tags of Aspergillus and Neurospora. The ability of ACEI to bind to the cbh1 promoter was further confirmed in the yeast one-hybrid system. In vitro binding and gel mobility shift assays revealed several binding sites for the ACEI protein in the cbh1 promoter. Disruption of the ace1 gene in T. reesei resulted in retarded growth of the fungus on a cellulose-containing medium, on which cellulases are normally highly expressed.

Transposition of the autonomous Fot1 element in the filamentous fungus Fusarium oxysporum

Autonomous mobility of different copies of the Fot1 element was determined for several strains of the fungal plant pathogen Fusarium oxysporum to develop a transposon tagging system. Two Fot1 copies inserted into the third intron of the nitrate reductase structural gene (niaD) were separately introduced into two genetic backgrounds devoid of endogenous Fot1 elements. Mobility of these copies was observed through a phenotypic assay for excision based on the restoration of nitrate reductase activity. Inactivation of the Fot1 transposase open reading frame (frameshift, deletion, or disruption) prevented excision in strains free of Fot1 elements. Molecular analysis of the Nia+ revertant strains showed that the Fot1 element reintegrated frequently into new genomic sites after excision and that it can transpose from the introduced niaD gene into a different chromosome. Sequence analysis of several Fot1 excision sites revealed the so-called footprint left by this transposable element. Three reinserted Fot1 elements were cloned and the DNA sequences flanking the transposon were determined using inverse polymerase chain reaction. In all cases, the transposon was inserted into a TA dinucleotide and created the characteristic TA target site duplication. The availability of autonomous Fot1 copies will now permit the development of an efficient two-component transposon tagging system comprising a trans-activator element supplying transposase and a cis-responsive marked element.

The molecular biology of secreted enzyme production by fungi

Enzymes from filamentous fungi are already widely exploited, but new applications for known enzymes and new enzymic activities continue to be found. In addition, enzymes from less amenable non-fungal sources require heterologous production and fungi are being used as the production hosts. In each case there is a need to improve production and to ensure quality of product. While conventional, mutagenesis-based, strain improvement methods will continue to be applied to enzyme production from filamentous fungi the application of recombinant DNA techniques is beginning to reveal important information on the molecular basis of fungal enzyme production and this knowledge is now being applied both in the laboratory and commercially. We review the current state of knowledge on the molecular basis of enzyme production by filamentous fungi. We focus on transcriptional and post-transcriptional regulation of protein production, the transit of proteins through the secretory pathway and the structure of the proteins produced including glycosylation.

The glucose repressor gene cre1 of Trichoderma: isolation and expression of a full-length and a truncated mutant form

The cre1 genes of the filamentous fungi Trichoderma reesei and T. harzianum were isolated and characterized. The deduced CREI proteins are 46% identical to the product of the glucose repressor gene creA of Aspergillus nidulans, encoding a DNA-binding protein with zinc fingers of the C2H2 type. The cre1 promoters contain several sequence elements that are identical to the previously identified binding sites for A. nidulans CREA. Steady-state mRNA levels for cre1 of the T. reesei strain QM9414 varied depending on the carbon source, being low on glucose-containing media. These observations suggest that cre1 expression may be autoregulated. The T. reesei strain Rut-C30, a hyper-producer of cellulolytic enzymes, was found to express a truncated form of the cre1 gene (cre1-1) with an ORF corresponding to a protein of 95 amino acids with only one zinc finger. Unlike QM9414 the strain Rut-C30 produced cellulase mRNAs on glucose-containing medium and transformation of the full-length cre1 gene into this strain caused glucose repression of cbh1 expression, demonstrating that cre1 regulates cellulase expression.

Chromosome-length polymorphism in fungi

The examination of fungal chromosomes by pulsed-field gel electrophoresis has revealed that length polymorphism is widespread in both sexual and asexual species. This review summarizes characteristics of fungal chromosome-length polymorphism and possible mitotic and meiotic mechanisms of chromosome length change. Most fungal chromosome-length polymorphisms are currently uncharacterized with respect to content and origin. However, it is clear that long tandem repeats, such as tracts of rRNA genes, are frequently variable in length and that other chromosomal rearrangements are suppressed during normal mitotic growth. Dispensable chromosomes and dispensable chromosome regions, which have been well documented for some fungi, also contribute to the variability of the fungal karyotype. For sexual species, meiotic recombination increases the overall karyotypic variability in a population while suppressing genetic translocations. The range of karyotypes observed in fungi indicates that many karyotypic changes may be genetically neutral, at least under some conditions. In addition, new linkage combinations of genes may also be advantageous in allowing adaptation of fungi to new environments.

Mitochondrial functions mediate cellulase gene expression in Trichoderma reesei

We examined the effects of inhibition of mitochondrial functions on the expression of two nuclear genes encoding the extracellular cellobiohydrolase I (cbh1) and endoglucanase I (egl1) of the cellulase system of the filamentous fungus Trichoderma reesei. The cbh1 and egl1 transcripts are repressed at a low oxygen tension, and by glucose at a concentration known to repress mitochondrial respiration. The transcripts are also down-regulated by chemical agents known to dissipate the proton electrochemical gradient of the inner mitochondrial membrane and blocking of the electron-transport chain, such as DNP and KCN, respectively. These results suggest that expression of those transcripts is influenced by the physiological state of the mitochondria. In addition, heterologous gene fusion shows that the sensitivity of the expression of those transcripts to the functional state of the mitochondria is transcriptionally controlled through the 5'-flanking DNA sequence of those genes.

Molecular techniques and their potential application in monitoring the microbiological quality of indoor air

Health effects associated with poor indoor air quality have created a need for accurate, reproducible methods of monitoring the microbiological content of indoor air. Improved methods of detection may allow researchers to clarify the effect of individual species present in the indoor environment on human health. This review discusses the shortcomings of current methods of identification and detection and focuses on the potential for molecular techniques in this emerging field. Probe techniques, restriction endonuclease analysis, karyotyping, and DNA and polymerase chain reaction fingerprinting methods available to detect and identify bacteria and fungi significant in the indoor air environment are discussed. Problems that may be encountered using these techniques are also considered. The authors have included a brief discussion on current air sampling techniques as well as adapting these techniques for use with molecular detection methods.

Cloning and expression in Saccharomyces cerevisiae of a Trichoderma reesei beta-mannanase gene containing a cellulose binding domain

beta-Mannanase (endo-1,4-beta-mannanase; mannan endo-1,4-beta-mannosidase; EC 3.2.1.78) catalyzes endo-wise hydrolysis of the backbone of mannan and heteromannans, including hemicellulose polysaccharides, which are among the major components of plant cell walls. The gene man1, which encodes beta-mannanase, of the filamentous fungus Trichoderma reesei was isolated from an expression library by using antiserum raised towards the earlier-purified beta-mannanase protein. The deduced beta-mannanase consists of 410 amino acids. On the basis of hydrophobic cluster analysis, the beta-mannanase was assigned to family 5 of glycosyl hydrolases (cellulase family A). The C terminus of the beta-mannanase has strong amino acid sequence similarity to the cellulose binding domains of fungal cellulases and is preceded by a serine-, threonine-, and proline-rich region. Consequently, the beta-mannanase is probably organized similarly to the T. reesei cellulases, having a catalytic core domain separated from the substrate-binding domain by an O-glycosylated linker. Active beta-mannanase was expressed and secreted by using the yeast Saccharomyces cerevisiae as the host. The results indicate that the man1 gene encodes the two beta-mannanases with different isoelectric points (pIs 4.6 and 5.4) purified earlier from T. reesei.

Electrophoretic karyotype of Mucor circinelloides

Contour-clamped homogeneous electric field (CHEF) gel electrophoresis was used to separate chromosomal size DNA molecules of two Mucor circinelloides strains. Electrophoretic karyotypes revealed the presence of eight distinct bands for the M. circinelloides f. lusitanicus strain, and four, presumably multiple, bands for the M. circinelloides f. gryseo-cyanus strain. The approximate sizes of the resolved chromosomal DNA bands ranged from 2.3 to 8.1 Mb, giving estimated genome sizes of 38.7 and 32.6 Mb, respectively. Hybridisation techniques were used to assign the leuA gene to a chromosome.

A novel, small endoglucanase gene, egl5, from Trichoderma reesei isolated by expression in yeast

A method is presented for the isolation of genes encoding hydrolytic enzymes without any knowledge of the corresponding proteins. cDNA made from the organism of interest is cloned into a yeast vector to construct an expression library in the yeast Saccharomyces cerevisiae. Colonies producing hydrolytic enzymes are screened by activity plate assays. In this work, we constructed a yeast expression library from the filamentous fungus Trichoderma reesei and isolated a new beta-1,4-endoglucanase gene on plates containing beta-glucan. This gene, egl5, codes for a previously unknown small protein of 242 amino acids. Despite its small size, the protein contains two conservative domains found in Trichoderma cellulases, namely the cellulose-binding domain (CBD) and the linker region that connects the CBD to the catalytic core domain. Molecular modelling of the EGV CBD revealed some interesting structural differences compared to the CBD of the major cellulase CBHI from T. reesei. The catalytic core of EGV is unusually small for a cellulase and represents a new family of cellulases (Family K) and of glycosyl hydrolases (Family 45) together with the endoglucanase B of Pseudomonas fluorescens and the endoglucanase V of Humicola insolens on the basis of hydrophobic cluster analysis.

Molecular cloning and sequence analysis of the cellobiohydrolase I gene from Trichoderma koningii G-39

The cellobiohydrolase I gene, cbh1, has been cloned from an enhanced cellulase-producing strain, Trichoderma koningii G-39. Sequence comparisons show that T. koningii cbh1 is identical to that of T. reesei with the exception of 6 bp--two causing silent substitutions in the coding region, three differing in one of the introns, and one in 5'-noncoding region. Thus, it should encode an identical CBHI to that of T. reesei despite the differences in morphological characters of the two species. Analysis of approximately 1.4 kb of the 5' flanking region shows a number of surprisingly interesting putative regulatory features. There are no unusual features within about 600 bp upstream of the translation start ATG. However, prior to the 600-bp region, there are seven CAAT sequences, a number of direct and inverted repeats, and two C/T-rich regions. Also, there are five consensus 5'-(G/C)PyGGGG-3' sequences that have been identified to be carbon catabolite repressor binding sites of Aspergillus nidulans CREA and Saccharomyces cerevisiae MIG1 repressors. The structural organization around these consensus sequence regions is similar to those of A. nidulas alcR and alcA promoters. While the production of large amounts of CBHI by T. koningii upon induction apparently correlates with the large number of CAAT boxes in the 5' upstream untranslated region of cbh1, the presence of five CREA/MIG1 repressor-binding consensus sequences in the region suggests the wide-domain carbon catabolite repression regulatory system that controls the A. nidulans ethanol regulon, and yeast GAL genes transcription might also be operative and responsible for regulation of T. koningii cbh1 transcription.

Electrophoretic karyotypes and gene mapping in eight species of the Fusarium sections Arthrosporiella and Sporotrichiella

Pulsed-field gel electrophoresis was used to identify karyotypes for eight species of the Fusarium sections Arthrosporiella and Sporotrichiella. The total number of chromosome-sized DNA molecules varied from six to nine, depending on the species. The sizes of chromosomes ranged from 0.4 to approximately 6.5 Mb which gave estimates of genome size of between 27.0 and 29.9 Mb. When fractionated chromosomes of the eight species were probed with Tox5, a gene coding for the key-enzyme of trichothecene biosynthesis, strong hybridization signals developed in F. poae and F. sporotrichioides, suggesting that of the eight species examined only these two have the genetic potentiality to produce trichothecene mycotoxins. By using heterologous probes from Aspergillus different rRNA loci have also been mapped on Fusarium chromosomes.

Electrophoretic karyotype and gene assignment to resolved chromosomes of Trichoderma spp

A molecular karyotype for three different Trichoderma species (T. harzianum, T. viride, and T. reesei) was determined by using two different systems: countour-clamped electric-field and rotating-electrode electrophoresis. Six chromosomal DNA bands were observed in T. harzianum and T. reesei and five in T. viride. The sizes of these molecules were estimated by their mobility relative to the Schizosaccharomyces pombe chromosomes and ranged between 2.2 and 7.4 megabase pairs (mbp). The estimated genome sizes range from 31 to 39 mbp. A number of genes were located in the different chromosomes by means of Southern analysis. The implications of these findings are discussed.