1
|
Ban Q, Wang J, Guo P, Yue J, Zhang L, Li J. Improved biohydrogen production by co-fermentation of corn straw and excess sludge: Insights into biochemical process, microbial community and metabolic genes. ENVIRONMENTAL RESEARCH 2024:119171. [PMID: 38763281 DOI: 10.1016/j.envres.2024.119171] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/23/2024] [Revised: 05/15/2024] [Accepted: 05/16/2024] [Indexed: 05/21/2024]
Abstract
The global climate change mainly caused by fossil fuels combustion promotes that zero-carbon hydrogen production through eco-friendly methods has attracted attention in recent years. This investigation explored the biohydrogen production by co-fermentation of corn straw (CS) and excess sludge (ES), as well as comprehensively analyzed the internal mechanism. The results showed that the optimal ratio of CS to ES was 9:1 (TS) with the biohydrogen yield of 101.8 mL/g VS, which was higher than that from the mono-fermentation of CS by 1.0-fold. The pattern of volatile fatty acids (VFAs) indicated that the acetate was the most preponderant by-product in all fermentation systems during the biohydrogen production process, and its yield was improved by adding appropriate dosage of ES. In addition, the content of soluble COD (SCOD) was reduced as increasing ES, while concentration of NH4+-N showed an opposite tendency. Microbial community analysis revealed that the microbial composition in different samples showed a significant divergence. Trichococcus was the most dominant bacterial genus in the optimal ratio of 9:1 (CS/ES) fermentation system and its abundance was as high as 41.8%. The functional genes prediction found that the dominant metabolic genes and hydrogen-producing related genes had not been significantly increased in co-fermentation system (CS/ES=9:1) compared to that in the mono-fermentation of CS, implying that enhancement of biohydrogen production by adding ES mainly relied on balancing nutrients and adjusting microbial community in this study. Further redundancy analysis (RDA) confirmed that biohydrogen yield was closely correlated with the enrichment of Trichococcus.
Collapse
Affiliation(s)
- Qiaoying Ban
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China; College of Environmental and Resource Sciences, Shanxi University, Taiyuan 030006, China.
| | - Jiangwei Wang
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan 030006, China
| | - Panpan Guo
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan 030006, China
| | - Jiaxin Yue
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan 030006, China
| | - Liguo Zhang
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan 030006, China
| | - Jianzheng Li
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China
| |
Collapse
|
2
|
Zhu S, Deng J, Jin X, Wu H, Wei C, Qiu G, Preis S, Wei C. Diverse and distinct bacterial community involved in a full-scale A/O1/H/O2 combination of bioreactors with simultaneous decarbonation and denitrogenation of coking wastewater. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2023; 30:2103-2117. [PMID: 35930152 DOI: 10.1007/s11356-022-22103-y] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/04/2022] [Accepted: 07/14/2022] [Indexed: 06/15/2023]
Abstract
Taking into account difficulties in exhaustive simultaneous decarbonation and denitrogenation in biological treatment of coking wastewater (CWW), a novel full-scale CWW biological treatment sequentially combining anaerobic, aerobic, hydrolytic, and aerobic reactors (A/O1/H/O2) was designed performing excellent removal of carbon-containing pollutants in the bioreactors A and O1, while the nitrogen-containing compounds in the bioreactors H and O2. To provide an effective tool for the CWW treatment monitoring and control, the succession of microbial community in this unique toxic CWW habitat should be established and characterized in detail. The results of 16S rRNA genes revealed Acidobacteria dominating in the unique CWW habitat. The dominant groups in bioreactors A and O1 include Proteobacteria, Firmicutes, and Acidobacteria, while Proteobacteria, Acidobacteria, Nitrospirae, and Planctomycetes dominate in reactors H and O2. The genera of Rhodoplanes, Bacillus, and Leucobacter are rich in genes responsible for the xenobiotics biodegradation and metabolism pathway. The Mantel test and PCA results showed the microbial communities of A/O1/H/O2 sequence correlating strongly with SRT, and COD load and removal. The co-occurrence network analysis indicated decarbonation and denitrogenation driven by two network modules having the keystone taxa belonging to the Comamonadaceae and Hyphomicrobiaceae families. The results significantly expanded the knowledge on the diversity, structure, and function of the CWW active sludge differentiating the relationships between bacterial communities and environmental variables in CWW treatment.
Collapse
Affiliation(s)
- Shuang Zhu
- Guangdong Province Key Laboratory for Biotechnology Drug Candidates, School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, People's Republic of China
| | - Jinsi Deng
- Guangdong Province Key Laboratory for Biotechnology Drug Candidates, School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, People's Republic of China
| | - Xiaobao Jin
- Guangdong Provincial Key Laboratory of Pharmaceutical Bioactive Substances, School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, People's Republic of China
| | - Haizhen Wu
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou, People's Republic of China
| | - Cong Wei
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, People's Republic of China
| | - Guanglei Qiu
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, People's Republic of China
| | - Sergei Preis
- Department of Materials and Environmental Technology, Tallinn University of Technology, Tallinn, Estonia
| | - Chaohai Wei
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, People's Republic of China.
| |
Collapse
|
3
|
Zhang L, Ban Q, Li J, Wang T. Simultaneous production of hydrogen-methane and spatial community succession in an anaerobic baffled reactor treating corn starch processing wastewater. CHEMOSPHERE 2022; 300:134503. [PMID: 35395259 DOI: 10.1016/j.chemosphere.2022.134503] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/10/2021] [Revised: 03/11/2022] [Accepted: 03/31/2022] [Indexed: 06/14/2023]
Abstract
Corn starch processing wastewater (CSPW) is a high-strength organic wastewater and biological treatment is considered as the dominant process. The present work investigated the effects of pH on the bioenergy production and spatial succession of microbial community in an anaerobic baffled reactor (ABR) treating CSPW. The results showed that above 90.5% of COD removal and above 16.6 L d-1 of methane were achieved at the influent pHs of 8.0 and 7.0 under organic loading rate of 4.0 kg COD·m-3·L-1 condition. Further decreasing the influent pH to 6.0 resulted in the COD removal decreased to 89.7%. Besides, 9.2 L d-1 of hydrogen and 13.0 L d-1 of methane were obtained. There was significant difference in the volatile fatty acids profiles during the variation of pH. Illumina Miseq sequencing showed that Clostridium, Ethanoligenens, Megasphaera, Prevotella and Trichococcus with relative abundance of 2.1%∼28.1% were the dominant hydrogen-producing bacteria in C1. Methanogens (Methanothrix and Methanobacterium) dominated in the last three compartments. Function predicted analysis revealed that the abundance of metabolic-related gene families containing carbohydrate, amino acids and energy in the last three compartments were higher than that in C1. A deduced biodegradation model of CSPW in ABR revealed that the anaerobic sludge in C1 mainly produced hydrogen. Microbial population in C3 was responsible for COD removal and methane production. The redundancy analysis revealed that hydrogen production was highly correlated with some hydrogen-producing bacteria in C1, whereas methane production was positively correlated with microbial group in C2∼ C4.
Collapse
Affiliation(s)
- Liguo Zhang
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan, 030006, China; Shanxi Laboratory for Yellow River, Taiyuan, 030006, China
| | - Qiaoying Ban
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan, 030006, China; Shanxi Laboratory for Yellow River, Taiyuan, 030006, China.
| | - Jianzheng Li
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China
| | - Tongtong Wang
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan, 030006, China
| |
Collapse
|
4
|
Zhang L, Ban Q, Li J, Zhang S. An enhanced excess sludge fermentation process by anthraquinone-2-sulfonate as electron shuttles for the biorefinery of zero-carbon hydrogen. ENVIRONMENTAL RESEARCH 2022; 210:113005. [PMID: 35231458 DOI: 10.1016/j.envres.2022.113005] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/30/2021] [Revised: 02/13/2022] [Accepted: 02/20/2022] [Indexed: 05/23/2023]
Abstract
Excess sludge (ES) largely produced in municipal wastewater treatment plants is known as a waste biomass and the traditional treatment processes such as landfill and incineration are considered as unsustainable due to the negative environmental impact. Fermentation process of ES for the biorefinery of zero-carbon hydrogen has attracted an increasing interesting and was extensively researched in the last decades. However, the technology is far from commercial application due to the insufficient effectivity. In the present study, anthraquinone-2-sulfonate (AQS) as electron shuttles was introduced into the fermentation process of ES for mediating the composition and activity of bacterial community to get an enhanced biohydrogen production. Inoculated with the same anaerobic activated sludge of 1.12 gVSS/L, a series of batch anaerobic fermentation systems with various dosage of AQS were conducted at the same ES load of 2.75 gVSS/L, initial pH 6.5 and 35 °C. The results showed that the fermentation process was remarkably enhanced by the introduction of 100 mg/L AQS, accompanying the lag phase was shortened to 1.35 h from 7.62. The obtained biohydrogen yield and the specific biohydrogen production rate were also remarkably enhanced to 24.9 mL/gVSS and 0.3 mL/(gVSS·h), respectively. Illumina Miseq sequencing showed that Longilinea and Guggenheimella as the dominant genera had been enriched from 9.2% to 0-12.0% and 4.7%, respectively, in the presence of 100 mg/L AQS. Function predicted analysis suggested that the presence of AQS had increased the abundance of genes involved in the transport and metabolism of carbohydrate, amino acid and energy production. Further redundancy analysis (RDA) revealed that the enhanced hydrogen production was highly positively correlated with the enrichment of genera such as Longilinea and Guggenheimella. The research work presents a novel potential biorefinery of ES for the effective production of zero-carbon hydrogen.
Collapse
Affiliation(s)
- Liguo Zhang
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan, 030006, China; Shanxi Laboratory for Yellow River, Taiyuan, 030006, China
| | - Qiaoying Ban
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan, 030006, China; Shanxi Laboratory for Yellow River, Taiyuan, 030006, China.
| | - Jianzheng Li
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China.
| | - Siyu Zhang
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan, 030006, China
| |
Collapse
|
5
|
Ban Q, Zhang L, Li J. Correlating bacterial and archaeal community with efficiency of a coking wastewater treatment plant employing anaerobic-anoxic-oxic process in coal industry. CHEMOSPHERE 2022; 286:131724. [PMID: 34388873 DOI: 10.1016/j.chemosphere.2021.131724] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/12/2020] [Revised: 07/24/2021] [Accepted: 07/28/2021] [Indexed: 06/13/2023]
Abstract
Coking wastewater (CWW) contains various complex pollutants, and biological treatment processes are frequently applied in the coking wastewater treatment plants (CWWTPs). The present work is to evaluate the contaminants removal of a full-scale CWWTP with an anaerobic-anoxic-oxic process (A/A/O), to reveal function of bacterial and archaeal community involved in different bioreactors, and to clarify the relationship between the performance and microbial community. Illumina Miseq sequencing of bacteria showed that β-proteobacteria dominated in three bioreactors with relative abundance of 60.2%~81.7%. 75.2% of sequences were assigned to Petrobacter in the bioreactor A1, while Thiobacillus dominated in A2 and O with relative abundance of 31.8% and 38.7%, respectively. Illumina Miseq sequencing of archaea revealed a high diversity of methanogens existed in A1 and A2 activated sludge. Moreover, Halostagnicola was the dominant archaea in A1 and A2 activated sludge with relative abundance of 41.8% and 66.5%, respectively. Function predicted analysis explored that function of bacteria was similar to that of archaea but the relative abundance differed from each other. A putative biodegradation model of CWW treatment in A/A/O process indicated that A1 and A2 activated sludge mainly reduced carbohydrate, protein, TN, phenol and cyanide, as well as methane production. Bacteria in the bioreactor O were responsible for aerobic biotransformation of residual carbohydrates, refractory organics and nitrification. The redundancy analysis (RDA) further revealed that removal of COD, TN, and NO3--N, phenol and cyanides were highly correlated with some anaerobic bacteria and archaea, whereas the transformation of NH4+-N was positively correlated with some aerobic bacteria.
Collapse
Affiliation(s)
- Qiaoying Ban
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan, 030006, PR China; Shanxi Laboratory for Yellow River, Taiyuan, 030006, China
| | - Liguo Zhang
- College of Environmental and Resource Sciences, Shanxi University, Taiyuan, 030006, PR China; Shanxi Laboratory for Yellow River, Taiyuan, 030006, China
| | - Jianzheng Li
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, PR China.
| |
Collapse
|
6
|
Tamang M, Paul KK. Advances in treatment of coking wastewater - a state of art review. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2022; 85:449-473. [PMID: 35050895 DOI: 10.2166/wst.2021.497] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/14/2023]
Abstract
Coking wastewater poses a serious threat to the environment due to the presence of a wide spectrum of refractory substances such as phenolic compounds, polycyclic aromatic hydrocarbons and heterocyclic nitrogenous compounds. These toxic substances are difficult to treat using conventional treatment methods alone. In recent years much attention has been given to the effective treatment of coking wastewater. Thus, this review seeks to provide a brief overview of recent developments that have taken place in the treatment of coking wastewater. In addition, this article addresses the complexity and the problems associated with treatment followed by a discussion on biological methods with special focus on bioaugmentation. As coking wastewater is refractory in nature, some of the studies have been related to improving the biodegradability of wastewater. The final section focuses on the integrated treatment methods that have emerged as the best solution for tackling the highly unmanageable coking wastewater. Attention has also been given to emerging microwave technology which has tremendous potential for treatment of coking wastewater.
Collapse
Affiliation(s)
- Markus Tamang
- Civil Engineering Department, National Institute of Technology, Rourkela, India E-mail:
| | - Kakoli Karar Paul
- Civil Engineering Department, National Institute of Technology, Rourkela, India E-mail:
| |
Collapse
|
7
|
Fan L, Yao H, Deng S, Jia F, Cai W, Hu Z, Guo J, Li H. Performance and microbial community dynamics relationship within a step-feed anoxic/oxic/anoxic/oxic process (SF-A/O/A/O) for coking wastewater treatment. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 792:148263. [PMID: 34144239 DOI: 10.1016/j.scitotenv.2021.148263] [Citation(s) in RCA: 11] [Impact Index Per Article: 3.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/24/2021] [Revised: 05/27/2021] [Accepted: 05/31/2021] [Indexed: 06/12/2023]
Abstract
A step-feed anoxic/oxic/anoxic/oxic (SF-A/O/A/O) was developed and successfully applied to full-scale coking wastewater treatment. The performance and microbial community were evaluated and systematically compared with the anoxic/oxic/oxic (A/O/O) process. SF-A/OA/O process exhibited efficient removal of COD, NH4+-N, TN, phenols, and cyanide with corresponding average effluent concentrations of 317.9, 1.8, 46.2, 1.1, and 0.2 mg·L-1, respectively. In particular, the TN removal efficiency of A/O/O process was only 7.8%, with an effluent concentration of 300.6 mg·L-1. Furthermore, polycyclic aromatic hydrocarbons with high molecular weight were the dominant compounds in raw coking wastewater, which were degraded to a greater extent in SF-A/OA/O. The abundance in Thiobacillus, SM1A02, and Thauera could be the main reason why SF-A/O/A/O was superior to A/O/O in treating TN. The microbial community structure of SF-A/O/A/O was similar among stages in system (P ≥ 0.05, Welch's t-test) and was less affected by environmental factors, which may have been one of the important factors in the system's strong stability.
Collapse
Affiliation(s)
- Liru Fan
- Beijing International Scientific and Technological Cooperation Base of Water Pollution Control Techniques for Antibiotics and Resistance Genes, Beijing Key Laboratory of Aqueous Typical Pollutants Control and Water Quality Safeguard, School of Civil Engineering, Beijing Jiaotong University, Beijing 100044, PR China
| | - Hong Yao
- Beijing International Scientific and Technological Cooperation Base of Water Pollution Control Techniques for Antibiotics and Resistance Genes, Beijing Key Laboratory of Aqueous Typical Pollutants Control and Water Quality Safeguard, School of Civil Engineering, Beijing Jiaotong University, Beijing 100044, PR China.
| | - Shihai Deng
- Department of Civil and Environmental Engineering, National University of Singapore, 1 Engineering Drive 2, Singapore 117576, Singapore
| | - Fangxu Jia
- Beijing International Scientific and Technological Cooperation Base of Water Pollution Control Techniques for Antibiotics and Resistance Genes, Beijing Key Laboratory of Aqueous Typical Pollutants Control and Water Quality Safeguard, School of Civil Engineering, Beijing Jiaotong University, Beijing 100044, PR China
| | - Weiwei Cai
- Beijing International Scientific and Technological Cooperation Base of Water Pollution Control Techniques for Antibiotics and Resistance Genes, Beijing Key Laboratory of Aqueous Typical Pollutants Control and Water Quality Safeguard, School of Civil Engineering, Beijing Jiaotong University, Beijing 100044, PR China
| | - Zhifeng Hu
- Beijing International Scientific and Technological Cooperation Base of Water Pollution Control Techniques for Antibiotics and Resistance Genes, Beijing Key Laboratory of Aqueous Typical Pollutants Control and Water Quality Safeguard, School of Civil Engineering, Beijing Jiaotong University, Beijing 100044, PR China
| | - Jianhua Guo
- Advanced Water Management Centre (AWMC), University of Queensland, St Lucia, Brisbane, QLD 4072, Australia
| | - Huan Li
- Beijing International Scientific and Technological Cooperation Base of Water Pollution Control Techniques for Antibiotics and Resistance Genes, Beijing Key Laboratory of Aqueous Typical Pollutants Control and Water Quality Safeguard, School of Civil Engineering, Beijing Jiaotong University, Beijing 100044, PR China
| |
Collapse
|
8
|
|
9
|
Deng J, Zhang B, Xie J, Wu H, Li Z, Qiu G, Wei C, Zhu S. Diversity and functional prediction of microbial communities involved in the first aerobic bioreactor of coking wastewater treatment system. PLoS One 2020; 15:e0243748. [PMID: 33301488 PMCID: PMC7728250 DOI: 10.1371/journal.pone.0243748] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/18/2020] [Accepted: 11/26/2020] [Indexed: 11/19/2022] Open
Abstract
The pre-aerobic process of coking wastewater treatment has strong capacity of decarbonization and detoxification, which contribute to the subsequent dinitrogen of non-carbon source/heterotrophic denitrification. The COD removal rate can reach > 90% in the first aerobic bioreactor of the novel O/H/O coking wastewater treatment system during long-term operation. The physico-chemical characteristics of influent and effluent coking wastewater in the first aerobic bioreactor were analyzed to examine how they correlated with bacterial communities. The diversity of the activated sludge microbial community was investigated using a culture-independent molecular approach. The microbial community functional profiling and detailed pathways were predicted from the 16S rRNA gene-sequencing data by the PICRUSt software and the KEGG database. High-throughput MiSeq sequencing results revealed a distinct microbial composition in the activated sludge of the first aerobic bioreactor of the O/H/O system. Proteobacteria, Bacteroidetes, and Chlorobi were the decarbonization and detoxification dominant phyla with the relative abundance of 84.07 ± 5.45, 10.89 ± 6.31, and 2.96 ± 1.12%, respectively. Thiobacillus, Rhodoplanes, Lysobacter, and Leucobacter were the potential major genera involved in the crucial functional pathways related to the degradation of phenols, cyanide, benzoate, and naphthalene. These results indicated that the comprehensive understanding of the structure and function diversity of the microbial community in the bioreactor will be conducive to the optimal coking wastewater treatment.
Collapse
Affiliation(s)
- Jinsi Deng
- Guangdong Province Key Laboratory for Biotechnology Drug Candidates, School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, China
| | - Baoshan Zhang
- Guangdong Province Key Laboratory for Biotechnology Drug Candidates, School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, China
| | - Junting Xie
- Guangdong Province Key Laboratory for Biotechnology Drug Candidates, School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, China
| | - Haizhen Wu
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou, China
| | - Zemin Li
- School of Environment and Energy, South China University of Technology, Guangzhou, China
| | - Guanglei Qiu
- School of Environment and Energy, South China University of Technology, Guangzhou, China
| | - Chaohai Wei
- School of Environment and Energy, South China University of Technology, Guangzhou, China
| | - Shuang Zhu
- Guangdong Province Key Laboratory for Biotechnology Drug Candidates, School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, China
| |
Collapse
|
10
|
Li K, Wu H, Wei J, Qiu G, Wei C, Cheng D, Zhong L. Simultaneous decarburization, nitrification and denitrification (SDCND) in coking wastewater treatment using an integrated fluidized-bed reactor. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2019; 252:109661. [PMID: 31634728 DOI: 10.1016/j.jenvman.2019.109661] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/02/2019] [Revised: 08/14/2019] [Accepted: 09/29/2019] [Indexed: 06/10/2023]
Abstract
There are two problems in biological treatment of coking wastewater (CWW): incapability of pre-anaerobic treatment to eliminate the toxicity in wastewater, and the lack of carbon source for subsequent denitrification in pre-aerobic treatment. To achieve simultaneous decarburization, nitrification and denitrification (SDCND) in CWW treatment, biological carrier materials was used to build an integrated fluidized-bed reactor (Reactor B, RB). A conventional fluidized-bed reactor (Reactor A, RA) was used as a control reactor under the same condition. The results showed that RB was more advantageous since its removal efficiencies of COD and TN were 90% and 87%, respectively, which were significantly higher than these in RA (82% and 45%), at a hydraulic retention time (HRT) of 60 h. Microelectrode measurement indicated that oxygen transfer was limited inside the carrier where the formation of a dissolved oxygen (DO) concentration gradient was observed. Microbial community analysis showed that the aerobic and anoxic microenvironments in RB promoted the co-existence of a wider variety of bacteria, thus achieving SDCND. These results indicated the integrated fluidized-bed reactor exhibited promising feasibility for simultaneous carbon and nitrogen removal in CWW treatment under the same aeration driven conditions. The SDCND process realized by fluidized-bed reactor provided a reference for the treatment of toxic industrial wastewater with high carbon to nitrogen ratio.
Collapse
Affiliation(s)
- Kui Li
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou, 510006, PR China
| | - Haizhen Wu
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou, 510006, PR China.
| | - Jingyue Wei
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China; River Basin Research Center, Gifu University, Gifu, 501-1193, Japan
| | - Guanglei Qiu
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China
| | - Chaohai Wei
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China
| | - Dangyu Cheng
- Huaxin Environmental Technology Company, Shaoguan, 512122, PR China
| | - Lianwen Zhong
- Huaxin Environmental Technology Company, Shaoguan, 512122, PR China
| |
Collapse
|
11
|
Zhu S, Wu H, Wu C, Qiu G, Feng C, Wei C. Structure and function of microbial community involved in a novel full-scale prefix oxic coking wastewater treatment O/H/O system. WATER RESEARCH 2019; 164:114963. [PMID: 31421512 DOI: 10.1016/j.watres.2019.114963] [Citation(s) in RCA: 37] [Impact Index Per Article: 7.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/02/2019] [Revised: 08/06/2019] [Accepted: 08/07/2019] [Indexed: 06/10/2023]
Abstract
A novel full-scale prefix oxic coking wastewater (CWW) biological treatment O/H/O system had been operated steadily six years with the effluent quality meeting national discharge standard. Comparing to the traditional CWW biological treatment process, which usually have an anaerobic unit at the start of the process, here the O/H/O system has obvious advantages in COD removal, total nitrogen removal and reduced energy consumption. It is very necessary to illustrate the structure and function of the microbial community involved in different bioreactors of the O/H/O system. High-throughput MiSeq sequencing was used to examine the 16S rRNA genes in this system. Results revealed a contrasting microbial composition among the activated sludge samples of three sequential bioreactors: the β-Proteobacteria related sequences dominated in the O1 activated sludge with the relative abundance of 56.44% while 7.53% of the sequences were assigned to Thiobacillus; Rhodoplanes related sequences dominated in the bioreactor H and O2 activated sludge with relative abundance of 8.86% and 8.92%, respectively. The physico-chemical characteristics of CWW were analyzed by standard methods and the operational parameters were routinely monitored to examine their effects on the microbial communities. The bioinformatics software package of phylogenetic investigation of communities by reconstruction of unobserved states (PICRUSt) was used to predict the microbial community functional profiling and found three dominant genera of Rhodoplanes, Lysobacter and Leucobacter enriched the xenobiotics biodegradation and metabolism pathway. The diverse and distinct microbial community involved in biological treatment processes of CWW treatment indicating that water characteristics and operational parameters determined the microbial community composition. These results significantly expanded our knowledge of the biodiversity and population dynamics of microorganisms and discerned the relationships between bacterial communities and environmental variables in the biological treatment processes. Moreover, in this study, we proposed a comprehensive biodegradation model of CWW treatment and defined as O/H/O system.
Collapse
Affiliation(s)
- Shuang Zhu
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China; Center for Bioresources & Drug Discovery and School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, 510006, PR China
| | - Haizhen Wu
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou, 510006, PR China
| | - Chaofei Wu
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China
| | - Guanglei Qiu
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China
| | - Chunhua Feng
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China
| | - Chaohai Wei
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China.
| |
Collapse
|
12
|
Hassan M, Essam T, Mira A, Megahed S. Biomonitoring detoxification efficiency of an algal-bacterial microcosm system for treatment of coking wastewater: Harmonization between Chlorella vulgaris microalgae and wastewater microbiome. THE SCIENCE OF THE TOTAL ENVIRONMENT 2019; 677:120-130. [PMID: 31055095 DOI: 10.1016/j.scitotenv.2019.04.304] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/06/2019] [Revised: 04/20/2019] [Accepted: 04/20/2019] [Indexed: 06/09/2023]
Abstract
Nowadays, due to worldwide water shortage, water utilities are forced to re-evaluate treated wastewater. Consequently, wastewater treatment plants need to conduct biomonitoring. Coking wastewater (CWW) has toxic, mutative and carcinogenic components with threatening effect on the environment. CWW was selected as a model for complex highly toxic industrial wastewater that should be treated. CWW from Egypt was treated in a nine-liter photobioreactor using an algal-bacterial system. The photobioreactor was operated for 154 days changing different parameters (toxic load and light duration) for optimization. Optimized conditions achieved significant reduction (45%) in the operation cost. The algal-bacterial system was monitored using chemical assays (chemical oxygen demand and phenol analysis), bioassays (phytotoxicity, Artemia-toxicity, cytotoxicity, algal-bacterial ratio and settleability) and Illumina-MiSeq sequencing of 16S rRNA gene. The algal-bacterial system detoxified (in terms of phytotoxicity, cytotoxicity and Artemia-toxicity) CWW introduced as influent through all phases. A significant difference was recorded in the microbial diversity between influent and effluent samples. Four phyla dominated influent samples; Proteobacteria (77%), Firmicutes (11%), Bacteroidetes (5%) and Deferribacteres (3%) compared to only two in effluent samples; Proteobacteria (66%) and Bacteroidetes (26%). The significant relative-abundance of versatile aromatic degraders (Comamonadaceae and Pseudomonadaceae families) in influent samples conformed to the nature of CWW. Microbial community shifted and promoted the activity of catabolically versatile and xenobiotics degrading families (Chitinophagaceae and Xanthomonadaceae). Co-culture of microalgae had a positive effect on the biodegrading bacteria that was reflected by enhanced treatment efficiency, significant increase in relative abundance of bacterial genera with cyanide-decomposing potential and negative effect on waterborne pathogens.
Collapse
Affiliation(s)
- Mariam Hassan
- Department of Microbiology and Immunology, Faculty of Pharmacy, Cairo University, Cairo, Egypt.
| | - Tamer Essam
- Department of Microbiology and Immunology, Faculty of Pharmacy, Cairo University, Cairo, Egypt
| | - Alex Mira
- Department of Genomics and Health, Center for Advanced Research in Public Health, FISABIO Foundation, Valencia, Spain
| | - Salwa Megahed
- Department of Microbiology and Immunology, Faculty of Pharmacy, Cairo University, Cairo, Egypt; Department of Microbiology and Immunology, Faculty of Pharmacy, October University for Modern Sciences and Arts (MSA), Cairo, Egypt
| |
Collapse
|
13
|
Wu H, Wang M, Zhu S, Xie J, Preis S, Li F, Wei C. Structure and function of microbial community associated with phenol co-substrate in degradation of benzo[a]pyrene in coking wastewater. CHEMOSPHERE 2019; 228:128-138. [PMID: 31029958 DOI: 10.1016/j.chemosphere.2019.04.117] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/09/2018] [Revised: 04/04/2019] [Accepted: 04/14/2019] [Indexed: 06/09/2023]
Abstract
Coking wastewater (CWW) contains high contents of phenols and other toxic and refractory compounds including polycyclic aromatic hydrocarbons (PAHs) with the most carcinogenic benzo[a]pyrene (BaP) among them. The mechanism of PAHs/BaP degradation in activated sludge of CWW treatment with phenol as co-substrate was studied. For characterizing the structure and functions of microbial community associated with BaP degradation with phenol as co-substrate, high-throughput MiSeq sequencing was used to examine the 16S rRNA genes of microbiology, revealing noticeable shifts in CWW activated sludge bacterial populations. Major genera involved in anaerobic degradation were Tissierella_Soehngenia, Diaphorobacter and Geobacter, whereas in aerobic degradation Rhodanobacter, Dyella and Thauera prevailed. BaP degradation with phenol as co-substrate induced bacterial diversification in CWW activated sludge in opposite trends when anaerobic and aerobic conditions were applied. In order to predict the microbial community functional profiling, a bioinformatics software package of phylogenetic investigation of communities by reconstruction of unobserved states (PICRUSt) was run to find that some dominant genera enriched in the BaP pathway may own the ability to degrade PAHs/BaP. Further experiments should focus on testing the dominant genera in BaP degradation at different oxygen levels.
Collapse
Affiliation(s)
- Haizhen Wu
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou, 510006, PR China
| | - Ming Wang
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China
| | - Shuang Zhu
- Center for Bioresources & Drug Discovery and School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, 510006, PR China.
| | - Junting Xie
- Center for Bioresources & Drug Discovery and School of Biosciences and Biopharmaceutics, Guangdong Pharmaceutical University, Guangzhou, 510006, PR China
| | - Sergei Preis
- Department of Materials and Environmental Technology, Tallinn University of Technology, Tallinn, 19086, Estonia
| | - Fusheng Li
- River Basin Research Center, Gifu University, 1-1 Yanagido, Gifu, 501-1193, Japan
| | - Chaohai Wei
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China.
| |
Collapse
|
14
|
Zhou H, Wei C, Zhang F, Hu Y, Wu H, Kraslawski A. A comprehensive evaluation method for sludge pyrolysis and adsorption process in the treatment of coking wastewater. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2019; 235:423-431. [PMID: 30710852 DOI: 10.1016/j.jenvman.2019.01.093] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/14/2018] [Revised: 01/19/2019] [Accepted: 01/25/2019] [Indexed: 06/09/2023]
Abstract
This study proposes a new evaluation method based on expert scoring and data normalization to optimize operational conditions of sludge pyrolysis and assess the comprehensive benefits of the adsorption process in coking wastewater treatment. Pyrolysis temperature, holding time and heating rate were considered as the experimental parameters in sludge pyrolysis. They were optimized by the proposed method, considering raw material cost, net energy consumption, carbon emission and adsorption capacity of sludge-derived bio-char (SB). Two operational modes (cyclic centralized and traditional distributed) were compared to identify a better solution for coking wastewater treatment. The results showed that the optimized operational conditions of coking sludge pyrolysis were that temperature of 550 °C, holding time of 60 min and heating rate of 20 °C/min, using the proposed method. Cyclic centralized mode has been demonstrated as the better mode for wastewater treatment by the proposed method, due to the higher comprehensive score of -0.296. It is a promising technology for sustainable wastewater treatment in terms of sludge recycling, energy saving and carbon emission reduction.
Collapse
Affiliation(s)
- Hongtao Zhou
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China
| | - Chaohai Wei
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China; Key Lab of Pollution Control and Ecosystem Restoration in Industry Clusters, Ministry of Education, Guangzhou, 510006, PR China.
| | - Fengzhen Zhang
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China
| | - Yun Hu
- School of Environment and Energy, South China University of Technology, Guangzhou, 510006, PR China; Key Lab of Pollution Control and Ecosystem Restoration in Industry Clusters, Ministry of Education, Guangzhou, 510006, PR China
| | - Haizhen Wu
- School of Biology and Biological Engineering, South China University of Technology, Guangzhou, 510006, PR China.
| | - Andrzej Kraslawski
- School of Business and Management, Lappeenranta University of Technology, Lappeenranta, 53851, Finland
| |
Collapse
|
15
|
Li R, Wang J, Li H. Isolation and characterization of organic matter-degrading bacteria from coking wastewater treatment plant. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2018; 78:1517-1524. [PMID: 30427792 DOI: 10.2166/wst.2018.427] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/09/2023]
Abstract
As a step toward bioaugmentation of coking wastewater treatment 45 bacteria strains were isolated from the activated sludge of a coking wastewater treatment plant (WWTP). Three strains identified as Bacillus cereus, Pseudomonas synxantha, and Pseudomonas pseudoaligenes exhibited high dehydrogenase activity which indicates a strong ability to degrade organic matter. Subsequently all three strains showed high naphthalene degradation abilities. Naphthalene is a refractory compound often found in coking wastewater. For B. cereus and P. synxantha the maximum naphthalene removal rates were 60.4% and 79.8%, respectively, at an initial naphthalene concentration of 80 mg/L, temperature of 30 °C, pH of 7, a bacteria concentration of 15% (V/V), and shaking speed of 160 r/min. For P. pseudoaligenes, the maximum naphthalene removal rate was 77.4% under similar conditions but at 35 °C.
Collapse
Affiliation(s)
- Riqiang Li
- College of Environmental & Resources Sciences, Shanxi University, 92 Wu-cheng Road, Taiyuan 030006, China E-mail:
| | - Jianxing Wang
- College of Environmental & Resources Sciences, Shanxi University, 92 Wu-cheng Road, Taiyuan 030006, China E-mail:
| | - Hongjiao Li
- College of Environmental & Resources Sciences, Shanxi University, 92 Wu-cheng Road, Taiyuan 030006, China E-mail:
| |
Collapse
|
16
|
Zhu Y, Xu J, Cao X, Cheng Y. Characterization of functional microbial communities involved in different transformation stages in a full-scale printing and dyeing wastewater treatment plant. Biochem Eng J 2018. [DOI: 10.1016/j.bej.2018.05.026] [Citation(s) in RCA: 27] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
17
|
Liu M, Preis S, Kornev I, Hu Y, Wei CH. Pulsed corona discharge for improving treatability of coking wastewater. J Environ Sci (China) 2018; 64:306-316. [PMID: 29478652 DOI: 10.1016/j.jes.2017.07.003] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/08/2017] [Revised: 07/03/2017] [Accepted: 07/04/2017] [Indexed: 06/08/2023]
Abstract
Coking wastewater (CW) contains toxic and macromolecular substances that inhibit biological treatment. The refractory compounds remaining in biologically treated coking wastewater (BTCW) provide chemical oxygen demand (COD) and color levels that make it unacceptable for reuse or disposal. Gas-phase pulsed corona discharge (PCD) utilizing mostly hydroxyl radicals and ozone as oxidants was applied to both raw coking wastewater (RCW) and BTCW wastewater as a supplemental treatment. The energy efficiency of COD, phenol, thiocyanate and cyanide degradation by PCD was the subject of the research. The cost-effective removal of intermediate oxidation products with addition of lime was also studied. The energy efficiency of oxidation was inversely proportional to the pulse repetition frequency: lower frequency allows more effective utilization of ozone at longer treatment times. Oxidative treatment of RCW showed the removal of phenol and thiocyanate at 800 pulses per second from 611 to 227mg/L and from 348 to 86mg/L, respectively, at 42kWh/m3 delivered energy, with substantial improvement in the BOD5/COD ratio (from 0.14 to 0.43). The COD and color of BTCW were removed by 30% and 93%, respectively, at 20kWh/m3, showing energy efficiency for the PCD treatment exceeding that of conventional ozonation by a factor of 3-4. Application of lime appeared to be an effective supplement to the PCD treatment of RCW, degrading COD by about 28% at an energy input of 28kWh/m3 and the lime dose of 3.0kg/m3. The improvement of RCW treatability is attributed to the degradation of toxic substances and fragmentation of macromolecular compounds.
Collapse
Affiliation(s)
- Ming Liu
- School of Environment and Energy, South China University of Technology, Guangzhou 510006, China; Guangdong Provincial Engineering and Technology Research Centre for Environmental Risk Prevention and Emergency Disposal, Guangzhou 510006, China.
| | - Sergei Preis
- School of Environment and Energy, South China University of Technology, Guangzhou 510006, China.
| | - Iakov Kornev
- Institute of High Technology Physics, National Research Tomsk Polytechnic University, 30 Lenin Ave., Tomsk 634050, Russian Federation
| | - Yun Hu
- School of Environment and Energy, South China University of Technology, Guangzhou 510006, China; Guangdong Provincial Engineering and Technology Research Centre for Environmental Risk Prevention and Emergency Disposal, Guangzhou 510006, China
| | - Chao-Hai Wei
- School of Environment and Energy, South China University of Technology, Guangzhou 510006, China; Guangdong Provincial Engineering and Technology Research Centre for Environmental Risk Prevention and Emergency Disposal, Guangzhou 510006, China
| |
Collapse
|
18
|
Joshi DR, Zhang Y, Zhang H, Gao Y, Yang M. Characteristics of microbial community functional structure of a biological coking wastewater treatment system. J Environ Sci (China) 2018; 63:105-115. [PMID: 29406094 DOI: 10.1016/j.jes.2017.07.011] [Citation(s) in RCA: 8] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/26/2017] [Revised: 07/18/2017] [Accepted: 07/19/2017] [Indexed: 06/07/2023]
Abstract
Nitrogenous heterocyclic compounds are key pollutants in coking wastewater; however, the functional potential of microbial communities for biodegradation of such contaminants during biological treatment is still elusive. Herein, a high throughput functional gene array (GeoChip 5.0) in combination with Illumina HiSeq2500 sequencing was used to compare and characterize the microbial community functional structure in a long run (500days) bench scale bioreactor treating coking wastewater, with a control system treating synthetic wastewater. Despite the inhibitory toxic pollutants, GeoChip 5.0 detected almost all key functional gene (average 61,940 genes) categories in the coking wastewater sludge. With higher abundance, aromatic ring cleavage dioxygenase genes including multi ring1,2diox; one ring2,3diox; catechol represented significant functional potential for degradation of aromatic pollutants which was further confirmed by Illumina HiSeq2500 analysis results. Response ratio analysis revealed that three nitrogenous compound degrading genes- nbzA (nitro-aromatics), tdnB (aniline), and scnABC (thiocyanate) were unique for coking wastewater treatment, which might be strong cause to increase ammonia level during the aerobic process. Additionally, HiSeq2500 elucidated carbozole and isoquinoline degradation genes in the system. These findings expanded our understanding on functional potential of microbial communities to remove organic nitrogenous pollutants; hence it will be useful in optimization strategies for biological treatment of coking wastewater.
Collapse
Affiliation(s)
- Dev Raj Joshi
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Yu Zhang
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China.
| | - Hong Zhang
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| | - Yingxin Gao
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Min Yang
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| |
Collapse
|
19
|
Zhou J, Li H, Chen X, Wan D, Mai W, Sun C. Cometabolic degradation of low-strength coking wastewater and the bacterial community revealed by high-throughput sequencing. BIORESOURCE TECHNOLOGY 2017; 245:379-385. [PMID: 28898834 DOI: 10.1016/j.biortech.2017.08.119] [Citation(s) in RCA: 58] [Impact Index Per Article: 8.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/19/2017] [Revised: 08/14/2017] [Accepted: 08/18/2017] [Indexed: 06/07/2023]
Abstract
Cometabolism technology was employed to degrade low-strength coking wastewater (CWW) in Sequencing Batch Reactor (SBR). The bacterial community compositions were monitored by high-throughput sequencing. Cometabolic substrate effectively improved the chemical oxygen demand (COD) removal efficiency in glucose-added system (A1) compared to glucose-free system (A0). Meanwhile, A1 exhibited larger biomass, better settlement performance, and higher dehydrogenase activity (DHA). More importantly, high-throughput sequencing revealed that dominant populations in A1 were quite different with A0. Thauera (9.27%), Thermogutta (7.58%), and Defluviimonas (4.6%) began to enrich in A1 after cometabolic substrate supplement. Especially, Thauera, as the most dominant populations in Al, could degrade a wide spectrum of aromatic compounds, which may contribute to the better system performance. This work would provide a novel option to treat low-strength CWW, discern the relationship between bacterial community and CWW quality, and further explore the cometabolic degradation through bacterial community structures.
Collapse
Affiliation(s)
- Jia Zhou
- College of Public Health, Zhengzhou University, Zhengzhou 450001, China
| | - Haisong Li
- School of Chemical Engineering and Energy, Zhengzhou University, Zhengzhou 450001, China.
| | - Xiaolei Chen
- ZhiHe Environmental Science and Technology Co., Ltd., Zhengzhou 450001, China
| | - Dongjin Wan
- School of Chemistry and Chemical Engineering, Henan University of Technology, Zhengzhou 450001, China
| | - Wenning Mai
- College of Public Health, Zhengzhou University, Zhengzhou 450001, China; School of Water Conservancy and Environment, Zhengzhou University, Zhengzhou 450001, China
| | - Changqing Sun
- College of Public Health, Zhengzhou University, Zhengzhou 450001, China.
| |
Collapse
|
20
|
Novel MBR_based main stream biological nutrient removal process: high performance and microbial community. Biodegradation 2017; 29:11-22. [PMID: 29080942 DOI: 10.1007/s10532-017-9810-0] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/01/2017] [Accepted: 10/23/2017] [Indexed: 10/18/2022]
Abstract
For municipal wastewater treatment, main stream biological nutrient removal (BNR) process is becoming more and more important. This lab-scale study, novel MBR_based BNR processes (named A2N-MBR and A2NO-MBR) were built. Comparison of the COD removal, results obtained demonstrated that COD removal efficiencies were almost the same in three processes, with effluent concentration all bellowed 30 mg L-1. However, the two-sludge systems (A2N-MBR and A2NO-MBR) had an obvious advantage over the A2/O for denitrification and phosphorus removal, with the average TP removal rates of 91.20, 98.05% and TN removal rates of 73.00, 79.49%, respectively, higher than that of 86.45 and 61.60% in A2/O process. Illumina Miseq sequencing revealed that Candidatus_Accumulibacter, which is capable of using nitrate as an electron acceptor for phosphorus and nitrogen removal simultaneously, was the dominant phylum in both A2N-MBR and A2NO-MBR process, accounting for 28.74 and 23.98%, respectively. Distinguishingly, major organism groups related to nitrogen and phosphorus removal in A2/O system were Anaerolineaceae_uncultured, Saprospiraceae_uncultured and Thauera, with proportions of 11.31, 8.56 and 5.00%, respectively. Hence, the diversity of dominant PAOs group was likely responsible for the difference in nitrogen and phosphorus removal in the three processes.
Collapse
|
21
|
Felföldi T, Fikó RD, Mentes A, Kovács E, Máthé I, Schumann P, Tóth E. Quisquiliibacterium transsilvanicum gen. nov., sp. nov., a novel betaproteobacterium isolated from a waste-treating bioreactor. Int J Syst Evol Microbiol 2017; 67:4742-4746. [PMID: 28950929 DOI: 10.1099/ijsem.0.002368] [Citation(s) in RCA: 11] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022] Open
Abstract
A new betaproteobacterium, CGI-09T, was isolated from an activated sludge bioreactor which treated landfill leachate. Based on 16S rRNA gene sequence analysis, the new strain shared the highest pairwise similarity values with members of the order Burkholderiales: Derxia gummosa IAM 13946T (family Alcaligenaceae), 93.7 % and Lautropia mirabilis DSM 11362T (family Burkholderiaceae), 93.6 %. Cells of strain CGI-09T were rod-shaped and non-motile. The new strain was oxidase and catalase positive and capable of reducing nitrate to nitrite. The predominant fatty acids were C16 : 1 ω7c, C16 : 0, cycloC17 : 0 and C18 : 1 ω7c, the major respiratory quinone was Q-8, and the detected polar lipids were phosphatidylglycerol, diphosphatidylglycerol, phosphatidylethanolamine and an unknown phospholipid. The G+C content of the genomic DNA of strain CGI-09T was 70.2 mol%. The new bacterium can be distinguished from the members of genera Derxia and Lautropia based on its non-motile cells, arginine dihydrolase activity, its high cyclo C17 : 0 fatty acid content and the lack of hydroxy fatty acids. On the basis of the phenotypic, chemotaxonomic and molecular data, strain CGI-09T is considered to represent a new genus and species within the family Burkholderiaceae, for which the name Quisquiliibacterium transsilvanicum gen. nov., sp. nov. is proposed. The type strain is CGI-09T (=DSM 29781T=JCM 31785T).
Collapse
Affiliation(s)
- Tamás Felföldi
- Department of Microbiology, ELTE Eötvös Loránd University, Pázmány Péter stny. 1/c, 1117 Budapest, Hungary.,Department of Bioengineering, Sapientia Hungarian University of Transylvania, Piaţa Libertăţii 1, 530104 Miercurea Ciuc, Romania
| | - Róbert Dezső Fikó
- Department of Bioengineering, Sapientia Hungarian University of Transylvania, Piaţa Libertăţii 1, 530104 Miercurea Ciuc, Romania
| | - Anikó Mentes
- Department of Microbiology, ELTE Eötvös Loránd University, Pázmány Péter stny. 1/c, 1117 Budapest, Hungary
| | - Erika Kovács
- Department of Bioengineering, Sapientia Hungarian University of Transylvania, Piaţa Libertăţii 1, 530104 Miercurea Ciuc, Romania
| | - István Máthé
- Department of Bioengineering, Sapientia Hungarian University of Transylvania, Piaţa Libertăţii 1, 530104 Miercurea Ciuc, Romania
| | - Peter Schumann
- Leibniz Institute DSMZ - German Collection of Microorganisms and Cell Cultures, Inhoffenstraße 7B, 38124 Braunschweig, Germany
| | - Erika Tóth
- Department of Microbiology, ELTE Eötvös Loránd University, Pázmány Péter stny. 1/c, 1117 Budapest, Hungary
| |
Collapse
|
22
|
Joshi DR, Zhang Y, Gao Y, Liu Y, Yang M. Biotransformation of nitrogen- and sulfur-containing pollutants during coking wastewater treatment: Correspondence of performance to microbial community functional structure. WATER RESEARCH 2017; 121:338-348. [PMID: 28570873 DOI: 10.1016/j.watres.2017.05.045] [Citation(s) in RCA: 15] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/13/2017] [Revised: 05/18/2017] [Accepted: 05/21/2017] [Indexed: 06/07/2023]
Abstract
Although coking wastewater is generally considered to contain high concentration of nitrogen- and sulfur-containing pollutants, the biotransformation processes of these compounds have not been well understood. Herein, a high throughput functional gene array (GeoChip 5.0) in combination with Illumina MiSeq sequencing of the 16S rRNA gene were used to identify microbial functional traits and their role in biotransformation of nitrogen- and sulfur-containing compounds in a bench-scale aerobic coking wastewater treatment system operated for 488 days. Biotransformation of nitrogen and sulfur-containing pollutants deteriorated when pH of the bioreactor was increased to >8.0, and the microbial community functional structure was significantly associated with pH (Mantels test, P < 0.05). The release of ammonia nitrogen and sulfate was correlated with both the taxonomic and functional microbial community structure (P < 0.05). Considering the abundance and correlation with the release of ammonia nitrogen and sulfate, aromatic dioxygenases (e.g. xylXY, nagG), nitrilases (e.g. nhh, nitrilase), dibenzothiophene oxidase (DbtAc), and thiocyanate hydrolase (scnABC) were important functional genes for biotransformation of nitrogen- and sulfur-containing pollutants. Functional characterization of taxa and network analysis suggested that Burkholderiales, Actinomycetales, Rhizobiales, Pseudomonadales, and Hydrogenophiliales (Thiobacillus) were key functional taxa. Variance partitioning analysis showed that pH and influent ammonia nitrogen jointly explained 25.9% and 35.5% of variation in organic pollutant degrading genes and microbial community structure, respectively. This study revealed a linkage between microbial community functional structure and the likely biotransformation of nitrogen- and sulfur-containing pollutants, along with a suitable range of pH (7.0-7.5) for stability of the biological system treating coking wastewater.
Collapse
Affiliation(s)
- Dev Raj Joshi
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, 100085, China; University of Chinese Academy of Sciences, Beijing, 100049, China
| | - Yu Zhang
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, 100085, China; University of Chinese Academy of Sciences, Beijing, 100049, China.
| | - Yinxin Gao
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, 100085, China; University of Chinese Academy of Sciences, Beijing, 100049, China
| | - Yuan Liu
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, 100085, China
| | - Min Yang
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, 100085, China; University of Chinese Academy of Sciences, Beijing, 100049, China
| |
Collapse
|
23
|
Na C, Zhang Y, Quan X, Chen S, Liu W, Zhang Y. Evaluation of the detoxification efficiencies of coking wastewater treated by combined anaerobic-anoxic-oxic (A 2O) and advanced oxidation process. JOURNAL OF HAZARDOUS MATERIALS 2017; 338:186-193. [PMID: 28554110 DOI: 10.1016/j.jhazmat.2017.05.037] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/10/2017] [Revised: 05/18/2017] [Accepted: 05/21/2017] [Indexed: 06/07/2023]
Abstract
Coking wastewater contains many types of toxic and hazardous pollutants that have serious toxic effects on human beings as well as aquatic organisms. However, few studies have evaluated the detoxification efficiencies of the treatment processes that are extensively performed in operational coking wastewater treatment plants (WWTPs). This study investigates the detoxification efficiencies of a combined anaerobic-anoxic-oxic (A2O)-ozonation and A2O-Fenton oxidation process in two coking WWTPs using an acute immobilization test for Daphnia magna, acute toxicity test for adult zebrafish, embryo toxicity test for zebrafish and the comet assay. The raw coking wastewaters displayed high acute daphnia and fish toxicity, zebrafish embryo toxicity and genotoxicity. The A2O processing unit effectively removed acute and embryo toxicity, but not genotoxicity. In addition, the A2O effluent quality did not meet the integrated wastewater discharge standard in China (GB18918-2002). The ozonation and Fenton oxidation units used as post-treatments in these two plants not only treated the coking wastewater to the discharge standard but also reduced the genotoxicity. However, the final effluents still showed potential genotoxicity after high dilution. The results suggest that the discharge of treated coking wastewater probably poses potential risks to human health and the environment even if it met regulatory standards.
Collapse
Affiliation(s)
- Chunhong Na
- Key Laboratory of Industrial Ecology and Environmental Engineering (Ministry of Education, China), School of Environmental Science and Technology, Dalian University of Technology, Dalian 116024, China
| | - Ying Zhang
- Key Laboratory of Industrial Ecology and Environmental Engineering (Ministry of Education, China), School of Environmental Science and Technology, Dalian University of Technology, Dalian 116024, China
| | - Xie Quan
- Key Laboratory of Industrial Ecology and Environmental Engineering (Ministry of Education, China), School of Environmental Science and Technology, Dalian University of Technology, Dalian 116024, China.
| | - Shuo Chen
- Key Laboratory of Industrial Ecology and Environmental Engineering (Ministry of Education, China), School of Environmental Science and Technology, Dalian University of Technology, Dalian 116024, China
| | - Wei Liu
- Key Laboratory of Industrial Ecology and Environmental Engineering (Ministry of Education, China), School of Environmental Science and Technology, Dalian University of Technology, Dalian 116024, China
| | - Yaobin Zhang
- Key Laboratory of Industrial Ecology and Environmental Engineering (Ministry of Education, China), School of Environmental Science and Technology, Dalian University of Technology, Dalian 116024, China
| |
Collapse
|
24
|
Performance and microbial community composition in a long-term sequential anaerobic-aerobic bioreactor operation treating coking wastewater. Appl Microbiol Biotechnol 2016; 100:8191-202. [PMID: 27221291 DOI: 10.1007/s00253-016-7591-8] [Citation(s) in RCA: 29] [Impact Index Per Article: 3.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/31/2016] [Revised: 04/25/2016] [Accepted: 04/28/2016] [Indexed: 10/21/2022]
Abstract
The combined anaerobic-aerobic biosystem is assumed to consume less energy for the treatment of high strength industrial wastewater. In this study, pollutant removal performance and microbial diversity were assessed in a long-term (over 300 days) bench-scale sequential anaerobic-aerobic bioreactor treating coking wastewater. Anaerobic treatment removed one third of the chemical oxygen demand (COD) and more than half of the phenols with hydraulic retention time (HRT) of 42 h, while the combined system with total HRT of 114 h removed 81.8, 85.6, 99.9, 98.2, and 85.4 % of COD, total organic carbon (TOC), total phenols, thiocyanate, and cyanide, respectively. Two-dimensional gas chromatography with time-of-flight mass spectrometry showed complete removal of phenol derivatives and nitrogenous heterocyclic compounds (NHCs) via the combined system, with the anaerobic process alone contributing 58.4 and 58.6 % removal on average, respectively. Microbial activity in the bioreactors was examined by 454 pyrosequencing of the bacterial, archaeal, and fungal communities. Proteobacteria (61.2-93.4 %), particularly Betaproteobacteria (34.4-70.1 %), was the dominant bacterial group. Ottowia (14.1-46.7 %), Soehngenia (3.0-8.2 %), and Corynebacterium (0.9-12.0 %), which are comprised of phenol-degrading and hydrolytic bacteria, were the most abundant genera in the anaerobic sludge, whereas Thiobacillus (6.6-43.6 %), Diaphorobacter (5.1-13.0 %), and Comamonas (0.2-11.1 %) were the major degraders of phenol, thiocyanate, and NHCs in the aerobic sludge. Despite the low density of fungi, phenol degrading oleaginous yeast Trichosporon was abundant in the aerobic sludge. This study demonstrated the feasibility and optimization of less energy intensive treatment and the potential association between abundant bacterial groups and biodegradation of key pollutants in coking wastewater.
Collapse
|