1
|
Roobab U, Fidalgo LG, Arshad RN, Khan AW, Zeng XA, Bhat ZF, Bekhit AEDA, Batool Z, Aadil RM. High-pressure processing of fish and shellfish products: Safety, quality, and research prospects. Compr Rev Food Sci Food Saf 2022; 21:3297-3325. [PMID: 35638360 DOI: 10.1111/1541-4337.12977] [Citation(s) in RCA: 10] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/28/2021] [Revised: 04/06/2022] [Accepted: 04/20/2022] [Indexed: 12/20/2022]
Abstract
Seafood products have been one of the main drivers behind the popularity of high-pressure processing (HPP) in the food industry owing to a high demand for fresh ready-to-eat seafood products and food safety. This review provides an overview of the advanced knowledge available on the use of HPP for production of wholesome and highly nutritive clean label fish and shellfish products. Out of 653 explored items, 65 articles published during 2016-2021 were used. Analysis of the literature showed that most of the earlier work evaluated the HPP effect on physicochemical and sensorial properties, and limited information is available on nutritional aspects. HPP has several applications in the seafood industry. Application of HPP (400-600 MPa) eliminates common seafood pathogens, such as Vibrio and Listeria spp., and slows the growth of spoilage microorganisms. Use of cold water as a pressure medium induces minimal changes in sensory and nutritional properties and helps in the development of clean label seafood products. This technology (200-350 MPa) is also useful to shuck oysters, lobsters, crabs, mussels, clams, and scallops to increase recovery of the edible meat. High-pressure helps to preserve organoleptic and functional properties for an extended time during refrigerated storage. Overall, HPP helps seafood manufacturers to maintain a balance between safety, quality, processing efficiency, and regulatory compliance. Further research is required to understand the mechanisms of pressure-induced modifications and clean label strategies to minimize these modifications.
Collapse
Affiliation(s)
- Ume Roobab
- School of Food Science and Engineering, South China University of Technology, Guangzhou, Guangdong, China.,Overseas Expertise Introduction Center for Discipline Innovation of Food Nutrition and Human Health (111 Center), Guangzhou, Guangdong, China
| | - Liliana G Fidalgo
- Department of Technology and Applied Sciences, School of Agriculture, Polytechnic Institute of Beja, Beja, Portugal.,LAQV-REQUIMTE, Department of Chemistry, University of Aveiro, Aveiro, Portugal
| | - Rai Naveed Arshad
- Institute of High Voltage & High Current, School of Electrical Engineering, Faculty of Engineering, Universiti Teknologi Malaysia, Skudai, Johor, Malaysia
| | - Abdul Waheed Khan
- School of Food Science and Engineering, South China University of Technology, Guangzhou, Guangdong, China
| | - Xin-An Zeng
- School of Food Science and Engineering, South China University of Technology, Guangzhou, Guangdong, China.,Guangdong Key Laboratory of Food Intelligent Manufacturing, Foshan University, Foshan, Guangdong, China
| | - Zuhaib F Bhat
- Division of Livestock Products Technology, SKUAST-Jammu, Jammu and Kashmir, India
| | - Ala El-Din A Bekhit
- Department of Food Sciences, University of Otago, Dunedin, Otago, New Zealand
| | - Zahra Batool
- School of Food Science and Engineering, South China University of Technology, Guangzhou, Guangdong, China
| | - Rana Muhammad Aadil
- National Institute of Food Science and Technology, University of Agriculture, Faisalabad, Pakistan
| |
Collapse
|
2
|
Zhou P, Chu Y, Lv Y, Xie J. Quality of frozen mackerel during storage as processed by different freezing methods. INTERNATIONAL JOURNAL OF FOOD PROPERTIES 2022. [DOI: 10.1080/10942912.2022.2053154] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 10/18/2022]
Affiliation(s)
- Pengcheng Zhou
- College of Food Science and Technology, Shanghai Ocean University, Shanghai, China
- b Shanghai Professional Technology Service Platform on Cold Chain Equipment Performance and Energy Saving Evaluation, Shanghai Ocean University, Shanghai, China
- National Experimental Teaching Demonstration Centre for Food Science and Engineering, Shanghai Ocean University, Shanghai, China
| | - Yuanming Chu
- College of Food Science and Technology, Shanghai Ocean University, Shanghai, China
- b Shanghai Professional Technology Service Platform on Cold Chain Equipment Performance and Energy Saving Evaluation, Shanghai Ocean University, Shanghai, China
- National Experimental Teaching Demonstration Centre for Food Science and Engineering, Shanghai Ocean University, Shanghai, China
| | - Ying Lv
- College of Food Science and Technology, Shanghai Ocean University, Shanghai, China
- b Shanghai Professional Technology Service Platform on Cold Chain Equipment Performance and Energy Saving Evaluation, Shanghai Ocean University, Shanghai, China
- National Experimental Teaching Demonstration Centre for Food Science and Engineering, Shanghai Ocean University, Shanghai, China
| | - Jing Xie
- College of Food Science and Technology, Shanghai Ocean University, Shanghai, China
- b Shanghai Professional Technology Service Platform on Cold Chain Equipment Performance and Energy Saving Evaluation, Shanghai Ocean University, Shanghai, China
- National Experimental Teaching Demonstration Centre for Food Science and Engineering, Shanghai Ocean University, Shanghai, China
- Collaborative Innovation Centre of Seafood Deep Processing, Ministry of Education, Dalian Polytechnic University, Dalian, China
| |
Collapse
|
3
|
Brown P, Dave D. Current freezing and thawing scenarios employed by North Atlantic fisheries: their potential role in Newfoundland and Labrador's northern cod ( Gadus morhua) fishery. PeerJ 2021; 9:e12526. [PMID: 34966580 PMCID: PMC8667752 DOI: 10.7717/peerj.12526] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/16/2021] [Accepted: 10/30/2021] [Indexed: 11/30/2022] Open
Abstract
Seafood is very perishable and can quickly spoil due to three mechanisms: autolysis, microbial degradation, and oxidation. Primary commercial sectors within the North Atlantic fisheries include demersal, pelagic, and shellfish fisheries. The preservation techniques employed across each sector can be relatively consistent; however, some key differences exist across species and regions to maintain product freshness. Freezing has long been employed as a preservation technique to maintain product quality for extended periods. Freezing allows seafood to be held until demand improves and shipped long distances using lower-cost ground transportation while maintaining organoleptic properties and product quality. Thawing is the opposite of freezing and can be applied before additional processing or the final sale point. However, all preservation techniques have limitations, and a properly frozen and thawed fish will still suffer from drip loss. This review summarizes the general introduction of spoilage and seafood spoilage mechanisms and the latest preservation techniques in the seafood industry, focusing on freezing and thawing processes and technologies. This review also considers the concept of global value chains (GVC) and the points to freeze and thaw seafood along the GVC to improve its quality with the intention of helping Newfoundland and Labrador’s emerging Northern cod (Gadus morhua) fisheries enhance product quality, meet market demands and increase stakeholder value.
Collapse
Affiliation(s)
- Pete Brown
- Centre for Aquaculture and Seafood Development, Fisheries and Marine Institute of Memorial University, Memorial University of Newfoundland, St. John's, NL, Canada
| | - Deepika Dave
- Centre for Aquaculture and Seafood Development, Fisheries and Marine Institute of Memorial University, Memorial University of Newfoundland, St. John's, NL, Canada
| |
Collapse
|
4
|
Valerievna DN, Dmitrievich BV, Valentenovna SO, Vladimirovna FE. Improving the technology of chilled semi-finished products from Japanese mackerel with an extended shelf life. BRAZILIAN JOURNAL OF FOOD TECHNOLOGY 2021. [DOI: 10.1590/1981-6723.26318] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
Abstract
Abstract One of the actual areas of processing the aquatic biological resources is the production of chilled fish semi-finished products, the most prepared for heat treatment. Such products have a very limited shelf life, because fish raw materials have high enzymatic activity. This research work aimed to improve the technology of chilled fish semi-finished products from Japanese mackerel with an extended shelf life. To achieve this goal, Japanese mackerel was injected with multicomponent salting media, containing food additives that slow down microbial contamination, have a bacteriostatic effect and assist in improving the organoleptic characteristics of the finished product. New receptions of salting multicomponent compositions provide faster salting and ripening of raw materials compared to the control sample. Salt concentration in fish, amine nitrogen and peroxide value were determined by titration methods. The total number of mesophilic aerobic and facultative anaerobic microorganisms (КMAFAnM) in fish semi-finished products was determined by identifying the number of grown colonies of microorganisms on nutrient media from agar. The treatment of Japanese mackerel with developed salting media, including moisture-retaining components, organic acids and flavoring additives with anti-bactericidal properties, improves the organoleptic characteristics of the finished product, promotes more salting and maturation of fish, as well as reducing the number of microorganisms (KMAFAnM). The increase in amine nitrogen content ranged from 1.4 g/kg (at the beginning of the salting) to 1.55 g/kg in the control and up to 3.05 g/kg in the test samples by the end of the salting. Salt concentration in Japanese mackerel treated with control salting media amounted to 1.19%, new developed salting media - from 2.84% to 3.17%. The total abundance of microorganisms in Japanese mackerel was 2.0 x 102 CFU/g, after salting it decreased to 0.1 to 3.0 x 101 CFU/g depending on the formulation of media for salting. According to the research results, the rational duration of the salting of Japanese mackerel, with new media for salting was 4 to 5 h at a temperature of 6 °С to 8 °С. Along with the salting media developed by us, the use of modern packaging materials in the technology provided chilled culinary semi – finished products from Japanese mackerel with longer shelf life of up to 20 days at a temperature of 0 °С to 5 °C, and humidity 95% to 98%.
Collapse
|
5
|
Influence of high-pressure processing on quality attributes of haddock and mackerel minces during frozen storage, and fishcakes prepared thereof. INNOV FOOD SCI EMERG 2020. [DOI: 10.1016/j.ifset.2019.102236] [Citation(s) in RCA: 23] [Impact Index Per Article: 5.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/30/2023]
|
6
|
Hwang JH, Kim Y, Choi H, Lee KG. ATP degradation products as freshness indicator of flatfish during storage. Food Sci Biotechnol 2019; 28:1891-1897. [DOI: 10.1007/s10068-019-00615-7] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/19/2018] [Revised: 04/06/2019] [Accepted: 04/09/2019] [Indexed: 11/29/2022] Open
|