Measuring endotracheal tube intracuff pressure: no room for complacency

'Sealing the deal': An innovative use of the endotracheal cuff manometer

Introduction

Intraoperative air leakage from the endotracheal tube (ETT) cuff can lead to significant complications, including compromised tidal volume delivery, ineffective ventilation, and an increased risk of pulmonary aspiration. These issues, if unrecognized and unmanaged, contribute to heightened perioperative morbidity and mortality. While structural defects in the ETT cuff or pilot balloon system are common causes of leakage, additional factors such as cuff malposition, excessive airway pressure, and material degradation can also contribute. Early identification of the underlying etiology is critical for implementing appropriate interventions, mitigating airway-related complications, and ensuring surgical continuity.

Case Report

This report presents a case of intraoperative ETT cuff leakage identified after surgical positioning in the prone position. To address this challenge, an innovative approach utilizing an ETT cuff manometer was employed, allowing for continuous monitoring of cuff pressure. This strategy enabled real-time detection of pressure deviations and facilitated prompt reinflation whenever the cuff pressure dropped below 20 cm H₂O or a fresh gas flow leak was observed. This technique effectively maintained adequate cuff inflation, preventing intraoperative airway compromise.

Discussion

ETT cuff leaks can be categorized into two primary mechanisms: (1) those resulting from structural failure of the cuff or inflation system and (2) those occurring due to inadequate sealing despite an intact cuff. Intraoperative air leaks pose risks to the patient-through impaired ventilation and aspiration risk-and to operating room personnel by potentially exposing them to unfiltered anesthetic gases. Various strategies for managing ETT leaks have been described, including conservative approaches such as pharyngeal packing, application of lubricating agents like lidocaine jelly, and continuous inflation via an oxygen flowmeter. In cases where these measures fail, ETT replacement remains the definitive intervention. However, exchanging the ETT presents a significant challenge in prone-positioned patients, necessitating a thorough risk-benefit assessment before attempting tube replacement or repositioning the patient. While previous studies have explored methods for addressing intraoperative ETT leaks, continuous quantitative monitoring of cuff pressure using a manometer has not been widely reported. This technique provides a dynamic assessment of cuff integrity and allows for proactive management of intraoperative air leaks.

Conclusion

In this case, the application of an ETT cuff manometer enabled continuous, quantitative assessment of cuff pressure, facilitating early leak detection and effective management. This approach represents a valuable adjunct in the intraoperative setting, enhancing patient safety and reducing the likelihood of airway-related complications. Further research is warranted to explore the broader clinical implications of continuous ETT cuff pressure monitoring in perioperative airway management.

Design considerations for development of cuffed endotracheal tube for small airways

Endotracheal tubes (ETTs) are life-supporting devices that are designed to maintain a patent airway in patients who are unable to sustain an airway due to illness or injury. Patients with small airways, such as neonates and pediatrics, have unique structural and functional features, making it essential that ETT design considers and executes on these particular needs. Though uncuffed ETTs have historically been preferred for patients younger than eight years of age, advances in cuffed ETT design and construction can be utilized to manufacture ETTs that are optimized for the smallest, most fragile airways. The purpose of this article is to discuss certain design features of cuffed ETTs in respect to small airways.

Intracuff Lidocaine and Postoperative Throat Mucosal Injuries: An Evidence-based Review

PURPOSE

Examine the effectiveness of using intracuff lidocaine to minimize postoperative complications.

DESIGN

Systematic review.

METHODS

This review was conducted using the Preferred Reporting Items for Systematic Reviews and Meta-Analyses Guidelines. PubMed, CINAHL, Cochrane, Google Scholar, and gray literature databases were searched to obtain eligible studies and minimize selection bias. The Johns Hopkins Nursing Evidence-Based Practice Model was used to appraise the level of evidence for the varying studies. Only randomized controlled trials (RCT) and systematic reviews with meta-analyses of RCTs were included in the review.

FINDINGS

Three RCTs and three systematic reviews with meta-analyses incorporating a total of 2,337 patients were included in this review. Intracuff lidocaine (alkalinized and nonalkalinized) had the lowest incidence of postoperative sore throat in the early and late postoperative periods compared to intracuff air or intracuff saline. Furthermore, the evidence suggested that the use of intracuff lidocaine reduced postextubation cough and the incidence of hoarseness but had little or no effect on dysphagia. All studies were Level 1 and Grade A, indicating clinically solid evidence in analyzing intracuff lidocaine's effect on all outcomes measured.

CONCLUSIONS

The current literature suggests the feasibility of using intracuff lidocaine as an effective method to reduce the incidence of postoperative sore throat, postextubation cough, and hoarseness. The implications to practice include improving the norm of postoperative throat mucosal injuries by implementing an evidence-based practice intervention of intracuff lidocaine.

Reevaluating 30 cmH2O endotracheal tube cuff pressure: risks of airway mucosal damage during prolonged mechanical ventilation

Background

The optimal endotracheal tube (ETT) cuff pressure remains contentious. In the traditional consideration that the level 30 cmH2O is considered safe, balancing the prevention of reflux aspiration against airway mucosal damage. Whether this pressure level can cause potential damage to the airway mucosa remains to be discussed.

Methods

Airway mucosa damage and structural changes at 30 cmH2O were examined in patients under general anesthesia and in rabbit mechanical ventilation models. Prior to this, we also interviewed some anesthesiologists about the level of concern about ETT cuff pressure.

Results

A total of 634 valid questionnaires suggested that anesthesiologists generally do not pay enough attention to ETT cuff pressure and the average established cuff pressure significantly exceeded 30 cmH2O. Airway mucosa images of 100 general anesthesia patients with different ventilation duration indicated that maintaining the pressure at 30 cmH2O did not cause significant damage to airway mucosa in a short period of time, while it still caused damage to airway mucosa in patients with long-term ventilation, with damage severity increasing with longer ventilation periods. This correlated strongly with postoperative sore throat (R 2 = 0.3884, p < 0.001). In rabbits, 4 h of ventilation at this pressure resulted in significant loss of ciliated epithelium and inflammation. Calculations suggested an effective dose (ED50) to prevent mucosal injury at a cuff pressure of 25.64 cmH2O (95% CI: 19.268-29.367 cmH2O).

Conclusion

The currently established cuff pressure of 30 cmH2O is associated with airway mucosal damage in both clinical and animal models. Lowering the safety threshold of cuff pressure may be necessary to mitigate mucosal injury.

A comparative analysis of elevated endotracheal tube cuff pressure incidence in laparoscopic abdominal surgery: saline versus air inflation

BACKGROUND

Endotracheal intubation is a frequently performed procedure in anesthesia practice, and ensuring the correct inflation of the cuff is essential for maintaining the airway seal. Overinflation of endotracheal tube (ETT) cuffs can lead to complications, such as postoperative sore throat. This study aimed to compare the incidence of elevated ETT cuff pressure between saline and air inflation in elective laparoscopic abdominal surgery.

METHODS

The study involved 60 participants ranging in age from 18 to 65, with American Society of Anesthesiologists physical status levels 1-2, who underwent laparoscopic abdominal surgery. We randomly assigned patients to two groups: Group A (air-filled ETT cuffs, N.=30) and Group S (saline-filled ETT cuffs, N.=30). Intra-cuff pressure was recorded before and after CO2 insufflation, as well as during changes in patient position. The number of interventions to restore intra-cuff pressure to 18 mmHg was documented. Peak airway pressure, plateau pressure, and positive end-expiratory pressure (PEEP) were measured at 15-minute intervals.

RESULTS

The number of interventions needed to maintain intra-cuff pressure was significantly lower in the saline group compared to the air group. All patients started with initial cuff pressures above 20 mmHg. After insufflation, the first-minute cuff pressures were higher in the air group (P=0.001). Both groups experienced a significant increase in intra-cuff pressure with the Trendelenburg position, and after moving to the reverse Trendelenburg position (saline and air groups, P=0.001 and 0.012, respectively), the air group had higher intra-cuff pressure than the saline group (P=0.002). There were no significant differences between groups in peak airway pressure, plateau pressure, and PEEP.

CONCLUSIONS

Inflating ETT cuffs with saline instead of air during laparoscopic abdominal surgeries led to a reduced requirement for interventions in maintaining pressure. This indicates that the use of saline inflation may significantly lower the risk of high cuff pressure and related complications.

Continuous Versus Intermittent Control Cuff Pressure for Preventing Ventilator-Associated Pneumonia: An Updated Meta-Analysis

OBJECTIVE

This study aimed to evaluate the effect of continuous control cuff pressure (CCCP) versus intermittent control cuff pressure (ICCP) for the prevention of ventilator-associated pneumonia (VAP) in critically ill patients.

METHODS

Relevant literature was searched in several databases, including PubMed, Embase, Web of Science, ProQuest, the Cochrane Library, Wanfang Database and China National Knowledge Infrastructure between inception and September 2022. Randomized controlled trials were considered eligible if they compared CCCP with ICCP for the prevention of VAP in critically ill patients. This meta-analysis was performed using the RevMan 5.3 and Trial Sequential Analysis 0.9 software packages. The Grading of Recommendations Assessment, Development and Evaluation (GRADE) framework was used to assess the level of evidence.

RESULTS

We identified 14 randomized control trials with a total of 2080 patients. Meta-analysis revealed that CCCP was associated with a significantly lower incidence of VAP compared with ICCP (relative risk [RR] = 0.52; 95% confidence interval [CI]: 0.37-0.74; P < 0.001), although considerable heterogeneity was observed (I2 = 71%). Conducting trial sequential analysis confirmed the finding, and the GRADE level was moderate. Subgroup analysis demonstrated that CCCP combined with subglottic secretion drainage (SSD) had a more significant effect on reducing VAP (RR = 0.39; 95% CI = 0.29-0.52; P < 0.001). The effect of CCCP on ventilator-associated respiratory infection (VARI) incidence was uncertain (RR = 0.81; 95% CI = 0.53-1.24; P = 0.34; I2 = 61%). Additionally, CCCP significantly reduced the duration of mechanical ventilation (MV) (mean difference [MD] = -2.42 days; 95% CI = -4.71-0.12; P = 0.04; I2 = 87%). Descriptive analysis showed that CCCP improved the qualified rate of cuff pressure. However, no significant differences were found in the length of intensive care unit (ICU) stay (MD = 2.42 days; 95% CI = -1.84-6.68; P = 0.27) and ICU mortality (RR = 0.86; 95% CI = 0.74-1.00; P = 0.05).

CONCLUSION

Our findings suggest that the combination of CCCP and SSD can reduce the incidence of VAP and the duration of MV and maintain the stability of cuff pressure. A combination of CCCP and SSD applications is suggested for preventing VAP.

Battle of the Gases: How Air and Nitrous Oxide Affect Endotracheal Tube Cuff Pressure During General Anesthesia

Background Endotracheal tube (ETT) cuff pressure changes during general anesthesia. Endotracheal cuff pressure ideally should be maintained between 20 and 30 cm of H2O. Cuff pressure of less than 25 cm of H2O increases the chances of aspiration while pressure of more than 40 cm of H2O causes tracheal mucosa damage. The study aimed to monitor and compare variations of endotracheal cuff pressure during general anesthesia with oxygen-air or oxygen-nitrous oxide. Methods This prospective, randomized, double-blinded, observational study was conducted on 40 patients. After approval from the institutional ethics subcommittee, 40 patients of either gender, aged 18-60 years, belonging to ASA grades I and II, who were undergoing elective surgery under general anesthesia, were enrolled in this study. The patients were randomly divided into two groups, with 20 in each group. In Group A, oxygen-air and Group N, oxygen-nitrous oxide was used as a gaseous mixture in general anesthesia with ETT. The ETT cuff pressure was recorded with the help of a cuff manometer at intervals of five, 10, 20, 30, 40, 50, 60, 70, 80, and 90 minutes after intubation. If pressure was more than 40 cm of H2O, it was reduced to 25-30 cm of H2O. Data were collected and analyzed using methods described in Primer of Biostatistics by Stanton A. Glantz. Quantitative data were analyzed using the Student's t-test. Qualitative data were analyzed using the chi-square test. Results An increase in cuff pressure was noted more in Group N as compared to Group A. The pressure in the endotracheal cuff started to gradually increase after 30-40 minutes in Group N after intubation, while in Group A, there was no significant increase. The average number of times the cuff deflated was 0.2 ± 0.41 in Group A and 1.55 ± 0.51 in Group N, which was highly significant. Conclusion Changes in endotracheal cuff pressure were observed when using different gas mixtures for inflation. Specifically, cuff pressure increased with oxygen and nitrous oxide compared to oxygen with air. This suggests that anesthetic gas composition can impact cuff pressure, potentially affecting tracheal mucosal perfusion and patient safety. Therefore, regular monitoring and adjustment of cuff pressure is crucial, especially when using nitrous oxide, to prevent complications and ensure optimal patient care.

Effect of varying cuff sizes with identical inner diameter on endotracheal intubation in critically ill adults: A sealed tracheal controlled trial

BACKGROUND

The present study aims to determine the impact of different cuff diameters on the cuff pressure of endotracheal tubes (ETTs) when the trachea is adequately sealed.

METHODS

In the present single-center clinical trial, adult patients who underwent cardiothoracic surgery were assigned to use ETTs from 2 brands (GME and GZW). The primary endpoint comprised of the following: cuff diameter, inner diameter of the ETT, manufacturer, and the number of subjects with tracheal leakage when the cuff pressure was 30 cm H2O.

RESULTS

A total of 298 patients were assigned into 2 groups, based on the 2 distinct brands of ETTs: experimental group (n = 122, GME brand) and control group (n = 176, GZW brand). There were no significant differences in baseline characteristics. However, the cuff diameter was significantly smaller in the control group, when compared to the experimental group (P = .001), and the incidence of tracheal leakage was significantly higher in the control group (P = .001). Furthermore, the GME brand ETT had a significantly larger cuff diameter, when compared to the GZW brand ETT.

CONCLUSION

The cuff size would mismatch the tracheal area in clinical practice. Therefore, chest computed tomography is recommended to routinely evaluate the tracheal cross-sectional area during anesthesia, in order to ensure the appropriate cuff size selection.

Airway management of a patient with Mounier-Kuhn syndrome during general anesthesia - A case report

BACKGROUND

Mounier-Kuhn syndrome (MKS) is a rare disorder characterized by abnormal dilation of the trachea and main bronchi. MKS can be easily missed on chest X-rays, making diagnosis difficult. Under general anesthesia, challenges such as airway leakage or collapse during mechanical ventilation may complicate the achievement of adequate tidal volumes.

CASES

A 94-year-old woman requiring emergency hemiarthroplasty of the hip under general anesthesia was admitted. Preoperative chest X-rays revealed dilation of the trachea and main bronchi, but the patient exhibited no respiratory symptoms. We diagnosed her with MKS and opted for an 8.0-mm-inner-diameter reinforced tracheal tube. We positioned the cuff in the subglottic area, inflating it while monitoring for air leakage. Throughout the surgery, adequate tidal volume was maintained.

CONCLUSIONS

Anesthesiologists must conduct a comprehensive evaluation of patients with MKS, including a review of chest radiographs, and establish a meticulous anesthesia plan prior to surgery.

Unifying Endotracheal Intracuff-Pressure Monitoring in the Intensive Care Unit: Bridging the Gap Between Standardization and Neglect

Endotracheal cuff-pressure monitoring is a critical component of patient care in the intensive care unit, ensuring the safety and efficacy of mechanical ventilation. Despite its importance, there remains a lack of standardized protocols regarding optimal pressure targets and documentation practices. This editorial examines the significance of endotracheal intracuff-pressure monitoring in enhancing patient outcomes, highlighting the challenges and potential solutions in clinical practice.

Endotracheal tube cuff pressure assessment: expectations versus reality

BACKGROUND

Damage to the trachea, although rare, is a serious complication in anesthesiology and intensive care. The main mechanism of such injury is a direct mechanical action associated with excessive pressure in the cuff of the endotracheal tube (ETT). The aim of the study was to evaluate the actual pressure in the cuffs during surgical interventions, correlate this measure with the subjective assessment of the anesthesiologist, and compare different methods of inflating the ETT cuff.

METHODS

Ninety patients were randomly divided into two equal groups. In the study group, the "minimum leakage" technique was used to inflate the cuff. In the control group, the adequacy of pressure was determined by palpation of the cuff balloon. In both groups, the actual pressure was then measured using a mechanical manometer connected to the cuff.

RESULTS

The average ETT cuff pressure was 30.4 ± 4.9 cmH 2 O (2.98 ± 0.48 kPa) in the study group and 68.9 ± 23.3 cmH 2 O (6.75 ± 2.28 kPa) in the control group. The pressure in the ETT cuffs was within the standard safe range (i.e. 20-30 cmH 2 O) in 2/45 (4.4%) and 23/45 (51.1%) patients in the control and the study group, respectively.

CONCLUSIONS

In the majority of cases, the pressure achieved via evaluation by the me-thod of palpation of the control cuff was not adequate. Among various non-mechanical methods of measuring and controlling pressure in the cuff of the intubation tube, the minimum occlusion volume technique deserves attention.

Endotracheal Cuff-pressure Monitoring in ICU: A Standard of Care Yet to be Standardized, and Often Neglected

How to cite this article: Kumar AKA. Endotracheal Cuff-pressure Monitoring in ICU: A Standard of Care Yet to be Standardized, and Often Neglected. Indian J Crit Care Med 2024;28(1):8-10.

Airway ultrasound to detect subglottic secretion above endotracheal tube cuff

BACKGROUND

Subglottic secretion had been proven as one of the causes of microaspiration and increased risk of ventilator-associated pneumonia (VAP). The role of ultrasound to detect subglottic secretion has not yet been established.

PURPOSE

The purpose of this study is to determine the sensitivity and specificity of upper airway ultrasound (US) in the detection of subglottic secretions as compared to computed tomography (CT) scanning.

MATERIAL AND METHODS

A prospective observational study was carried out in adult trauma patients requiring mechanical ventilation and cervical CT scan. All patients had an endotracheal tube cuff-pressure maintained between 20 and 30 cm H₂O. Airway US was performed at the bedside immediately before the patient was transferred to the CT scan suite. The sensitivity, specificity, and positive/negative predictive values (PPV, NPV) of the upper airway US detection of subglottic secretions were then calculated and compared with CT findings.

RESULTS

Fifty participants were consecutively included. Subglottic secretions were detected in 31 patients using upper airway US. The sensitivity and specificity of upper airway US in detecting subglottic secretion were 96.7% and 90%, respectively (PPV 93.5%, NPV 94.7%). 18 (58%) patients with subglottic secretions developed VAP during their ICU stay (p = 0.01). The area under the receiver operating curve (AUROC) was 0.977 (95% CI 0.936-1.00).

CONCLUSIONS

Upper airway US is a useful tool for detecting subglottic secretions with high sensitivity and specificity.

CLINICAL IMPLICATIONS

This study shows: 1. Upper airway US may aid in detecting subglottic secretions, which are linked to VAP. 2. Detecting subglottic secretions at the bedside aids in determining the best frequency of subglottic aspiration to clean the subglottic trachea. 3. Upper airway US may also aid in detecting the correct ETT position. Trial registration Clinicaltrials.gov.

CLINICALTRIALS

gov identifier NCT04739878 Date of registration 2nd May 2021 URL of trial registry record https://clinicaltrials.gov/ct2/show/NCT04739878 .

Evaluation of Four Techniques to Administer Laryngeal Mask Airway

Background

Laryngeal mask airway (LMA) plays a crucial role in the field of modern anesthesia. There are different techniques to administer LMA. Here we aimed to compare the four methods of standard, 90° rotation, 180° rotation, and thumb placement in LMA mast placement.

Materials and Methods

This is a clinical trial that was performed on 257 candidates of elective surgical operations requiring general anesthesia. All patients were categorized into four groups of LMA placement with index finger (standard method), mask placement with 90° rotation, 180° rotation method, and thumb finger group. We collected data regarding the success rates of LMA placement, the need for any manipulation when placing the mask, LMA placement time, failure of mask placement, presence of blood on the LMA, and laryngospasm and sore throats 1 hour after surgery in patients.

Results

The 90° rotation method had a significantly higher first attempt success rate than that in the other three methods (98.4%, P = 0.02). Total success rate in 90° rotation method was also significantly higher than the other techniques (100%, P < 0.001). The need for any manipulation when placing the mask (1.6%, P = 0.01), presence of blood on the LMA mask (1.6%, P = 0.33), and frequency of sore throats 1 hour after surgery (21.9%, P = 0.14) were also lower in 90° rotation method than that in the other methods.

Conclusion

The 90° rotation method had significantly higher success rate and lower failure rate regarding the mask placement compared to other three methods.

Factors associated with lack of tracheal sealing by a cuff inflated to more than 30 cmH2O during mechanical ventilation: A cross-sectional study

Objectives

The cuff pressures > 30 cmH2O may create a seal in the trachea. The objective of this study was to identify risk factors associated with lack of tracheal sealing by an endotracheal cuff inflated to > 30 cmH2O in patients undergoing mechanical ventilation.

Methods

This prospective cross-sectional study was conducted from 2019 to 2020 in the cardiothoracic intensive care unit and respiratory medical care unit of a Hospital in Nantong, China. Patients aged >16 years undergoing cardiothoracic surgery with mechanical ventilation using endotracheal intubation were included. Patient characteristics and ventilator parameters were analyzed. Cuff pressure was maintained with the minimum leak technique (MLT) and measured with a cuff pressure gauge. Cuff pressure was measured for 30 seconds when ventilation was accompanied by no leak, simultaneously detected by the ventilator or auscultation with a stethoscope.

Result

Of 352 patients undergoing mechanical ventilation, 51 patients (14.5%) had a cuff pressure of >30 cmH2O. Multivariable analysis showed that cuff manufacturer (Guangzhou Weili) and nasal endotracheal intubation significantly increased the risk of an unsealed trachea. Peak inspiratory pressure, cuff diameter and male sex had a strong inverse association with an unsealed trachea.

Conclusions

These findings suggest that an endotracheal cuff pressure of 20 to 30 cmH2O is adequate for most patients, but lack of a tracheal seal still occurs in a small number of people. An unsealed trachea is most likely because cuff and tracheal diameters do not match. Clinical Trial Registration: http://www.chictr.org.cn/index.aspx Unique identifier: ChiCTR-COC-15006459.

Objective and Subjective Evaluation of Endotracheal Tube Cuff Pressure between Different Levels of Anesthesia Experiences

Objective: After endotracheal intubation (ETI), the endotracheal tube cuff (ETTc) should be inflated at sufficient pressure to function, and high pressure should be avoided to prevent complications. In our study, the effect of professional experience on the estimation of ETTcP by palpation is investigated. Method: The study included 75 adult patients with physical status I-III of the American Society of Anesthesiology (ASA) scheduled for ETI. Anesthesia residents were divided into two groups of 20, each with 1 month to 1 year of experience (Group 1) and those with more than 4 years of experience (Group 2). After the ETI, one participant in both groups was asked to inflate the ETTc to an estimated 25 cm H2O by cuff palpation. Then the actual ETTcP was measured with a manometer. Results: The median ETTcP value was 42,00 cm H2O in Group 1 and 32,00 cm H2O in Group 2, (p=0.012). Although the data of both groups were significantly higher than the target value, the values obtained in Group 1 were further away from Group 2 (p&lt;0.001, p&lt;0.001). Conclusion: Professional experience has no effect on the correct estimation of the ETTcP. It is more convenient to measure the actual pressure to avoid undesirable effects of ETTcP outside the target.

Disposable Airway Pressure Manometers for Endotracheal Tube Cuff Inflation

This study aimed to assess the performance, accuracy, precision and repeatability of two single-use airway pressure manometers as a cost-effective alternative for inflation of endotracheal tubes with high-volume, low-pressure cuffs. The manometers were tested in a bench top model against a U-tube manometer. Eighteen units of each device were tested. Three consecutive measurements were performed at pressures of 20, 25 and 30 cmH₂O each. The mean ± SD of the recorded pressures and maximum deviation from the target pressures were calculated for each device and each target pressure. For device A, the mean ± SD pressures were 19.6 ± 0.7, 23.6 ± 0.8 and 28.3 ± 0.8 cmH₂O; for device B, the mean ± SD pressures were 19.3 ± 0.6, 24.3 ± 0.9 and 29.2 ± 0.67 cmH₂O for target pressures of 20, 25 and 30 cmH₂O, respectively. The bias for device A was -0.4, -1.4, and -1.7 cmH₂O and for device B, -0.7, -0.7, and -0.8 cmH₂O for target pressures of 20, 25, and 30 cmH₂O, respectively. Both devices showed results comparable to those reported for commercial cuff manometers. They represent inexpensive tools that provide clinically sufficient accuracy, precision and repeatability for ETT cuff inflation between pressures of 20 and 30 cmH₂O.

Endotracheal Tube Cuff Pressures in the Operating Room of a Pediatric Hospital: A Quality Improvement Initiative

Endotracheal tube (ETT) cuff pressures are frequently out of the recommended range of 20-30 cm H₂O. This can lead to multiple iatrogenic complications ranging from cough, sore throat, and tracheal edema to more serious medical issues such as tracheal stenosis, aspiration, nerve injuries, and tracheal rupture. Additionally, current methods to inflate ETT cuffs vary between anesthesia providers and are not consistent in the recommended range. The objective of this quality improvement project was to increase the percentage of cuff pressures between 20 and 30 cm H₂O.

METHODS

Four plan-do-study-act (PDSA) cycles were completed in the operating rooms at Nationwide Children's Hospital over 9 months to assess ways to improve the accuracy of obtaining recommended ETT cuff pressures. Control charts were used to evaluate the primary outcome measure.

RESULTS

Preimplementation, ETT cuff pressures were out of the recommended range 76% of the time. Cuff pressures were out of the recommended range 64% of the time with the addition of the air method, 84% of the time in the tidal volume ratio cycle, and 50% of the time using the removal of air technique. The removal of air method was the most effective in achieving cuff pressures within the recommended pressure range (P < 0.001).

CONCLUSIONS

Using quality improvement methodology, the percentage of ETT cuff pressures falling within the recommended pressure range increased using the removal of air technique. This approach is a simple and practical method that can be easily implemented in the clinical setting and would provide additional safety in the anesthetic management of pediatric patients.

The impact of esophageal device insertion on cuff pressure of endotracheal tube: a literature review and meta-analysis

The impact of intraoperative esophageal device insertion (EDI) on endotracheal tube (ET) cuff inflation pressure remains unclear. Electronic databases including Medline, Embase, Google scholar, Web of Science™ and Cochrane Central Register of Controlled Trials were searched for studies involving EDI after placement of ETs from inception to July 7, 2022. The primary outcome was risk of high cuff pressure, while the secondary outcomes were increases in cuff pressure following EDI. Difference between adults and children was investigated with subgroup analysis. There were ten eligible studies (observation study, n = 9, randomized controlled study, n = 1) involving a total of 468 participants. EDI notably increased the risk of high cuff pressure (n = 7, risk ratio: 12.82, 95% confidence interval: 4.9 to 33.52, subgroup analysis: p = 0.008). There were significant elevations in cuff pressure in adults and children both during (13.42 and 7.88 cmH₂O, respectively, subgroup analysis: p = 0.15) and after (10.09 and 3.99 cmH₂O, respectively, subgroup analysis: p = 0.0003) EDI. Our results revealed an over 12-fold increase in the risk of high endotracheal tube cuff pressure in patients, especially adults, receiving EDI under endotracheal anesthesia. There were significant increases in both adults and children despite a higher increase in the former after device insertion.

Endotracheal Tube Overinflation Leading to Hypoxic Cardiac Arrest: A Case Report and Review of the Literature

Endotracheal tube cuff overinflation has been shown to produce airway obstruction and subsequent ventilatory and hemodynamic compromise. Although rare, this complication is reversible and its prompt identification is paramount. We describe a case of a 68-year-old woman undergoing microlaryngoscopy and vocal cord lesion biopsy, who developed ventilatory failure and cardiac arrest following endotracheal tube overinflation intraoperatively. The patient was successfully resuscitated and was able to be ventilated after endotracheal tube replacement. We present a literature review and evidence-based management insights for endotracheal tube obstruction due to cuff overinflation.

The Relationship between Cuff Pressure and Air Injection Volume of Endotracheal Tube: A Study with Sheep Trachea Ex Vivo

Background

Endotracheal intubation is a widely used treatment. Excessive pressure of the endotracheal tube cuff leads to a series of complications. Here, we used tracheae of sheep to analyze the relationship between the air injection volume and endotracheal tube cuff pressure so as to guide the doctors and nurses in controlling the pressure of the endotracheal tube cuff during clinical work and minimise the risk of complications.

Materials and Methods

Forty sheep tracheae were utilised and were divided into five groups according to their diameters. Different sizes of endotracheal tubes were inserted into each trachea, and the cuff pressure with the increase of air injection volume was recorded. The formulas that reflect the relationship between air injection volume and cuff pressure were obtained. Then, sheep tracheae were randomly selected; different types of tubes were inserted, and the stipulated volume of air was injected. The actual pressure was measured and compared with the pressure predicted from the formulas. Statistical analysis was conducted to verify whether the formulas obtained from the first part of the experiment were in accordance with the expert evaluation table, which consists of opinions of several experts.

Results

After obtaining 15 formulas, we collected the differences between the theoretical cuff pressure and the actual cuff pressure that satisfied the expert evaluation. Relying on the formulas, the medical turntable was obtained, which is a tool that consists of two round cards with data on them. The top card has a notch. The two cards are stacked together, and as the top card rotates, the data on the bottom card can be easily seen in a one-to-one relationship.

Conclusion

The formulas are capable of showing the relationship between the cuff air injection volume and pressure of endotracheal tube cuff. The medical turntable can estimate the air injection volume to ensure that the pressure stays in an acceptable range.

Nursing care recommendation for pediatric COVID-19 patients in the hospital setting: A brief scoping review

BACKGROUND

The hospitalization of children during the COVID-19 pandemic has affected their physical and mental health. Pediatric nurses have faced challenges in providing high-quality nursing care for children and their families. However, the pediatric nursing care recommendations for COVID-19 patients in the hospital setting remain unclear. The current scoping review provides recommendations for nursing interventions for pediatric COVID-19 patients in the hospital setting.

METHODS AND FINDINGS

The selected articles containing management and nursing recommendations for COVID-19 that have occurred in pediatric patients ages 0-19 years old. A search strategy was developed and implemented in seven databases. We included peer-reviewed articles that reported observational or interventional studies, as well as policy papers, guides or guidelines, letters and editorials, and web articles. A total of 134 articles and other documents relevant to this review were included. We categorized the results based on The Nursing Intervention Classification (NIC) taxonomy which consists of six domains (e.g., Physiological: Basic); eleven classes (e.g., Nutrition Support); and eighteen intervention themes (e.g., Positioning, Family Presence Facilitation, Family Support, and Discharge Planning).

CONCLUSION

Apart from the intervention of physical problems, there is a need to promote patient- and family-centered care, play therapy, and discharge planning to help children and families cope with their new situation.

Cuffed versus uncuffed endotracheal tubes for neonates

BACKGROUND

Endotracheal intubation is a commonly performed procedure in neonates, the risks of which are well-described. Some endotracheal tubes (ETT) are equipped with a cuff that can be inflated after insertion of the ETT in the airway to limit leak or aspiration. Cuffed ETTs have been shown in larger children and adults to reduce gas leak around the ETT, ETT exchange, accidental extubation, and exposure of healthcare workers to anesthetic gas during surgery. With improved understanding of neonatal airway anatomy and the widespread use of cuffed ETTs by anesthesiologists, the use of cuffed tubes is increasing in neonates.

OBJECTIVES

To assess the benefits and harms of cuffed ETTs (inflated or non-inflated) compared to uncuffed ETTs for respiratory support in neonates.

SEARCH METHODS

We searched CENTRAL, PubMed, and CINAHL on 20 August 2021; we also searched trial registers and checked reference lists to identify additional studies.

SELECTION CRITERIA

We included randomized controlled trials (RCTs), quasi-RCTs, and cluster-randomized trials comparing cuffed (inflated and non-inflated) versus uncuffed ETTs in newborns. We sought to compare 1. inflated, cuffed versus uncuffed ETT; 2. non-inflated, cuffed versus uncuffed ETT; and 3. inflated, cuffed versus non-inflated, cuffed ETT.

DATA COLLECTION AND ANALYSIS

We used the standard methods of Cochrane Neonatal. Two review authors independently assessed studies identified by the search strategy for inclusion, extracted data, and assessed risk of bias. We used the GRADE approach to assess the certainty of evidence.

MAIN RESULTS

We identified one eligible RCT for inclusion that compared the use of cuffed (inflated if ETT leak greater than 20% with cuff pressure 20 cm H₂O or less) versus uncuffed ETT. The author provided a spreadsheet with individual data. Among 76 infants in the original manuscript, 69 met the inclusion and exclusion criteria for this Cochrane Review. We found possible bias due to lack of blinding and other bias. We are very uncertain about frequency of postextubation stridor, because the confidence intervals (CI) of the risk ratio (RR) were very wide (RR 1.36, 95% CI 0.35 to 5.25; risk difference (RD) 0.03, -0.11 to 0.18; 1 study, 69 participants; very low-certainty evidence). No neonate was diagnosed with postextubation subglottic stenosis; however, endoscopy was not available to confirm the clinical diagnosis. We are very uncertain about reintubation for stridor or subglottic stenosis because the CIs of the RR were very wide (RR 0.27, 95% CI 0.01 to 6.49; RD -0.03, 95% CI -0.11 to 0.05; 1 study, 69 participants; very low-certainty evidence). No neonate had surgical intervention (e.g. endoscopic balloon dilation, cricoid split, tracheostomy) for stridor or subglottic stenosis (1 study, 69 participants). Neonates randomized to cuffed ETT may be less likely to have a reintubation for any reason (RR 0.06, 95% CI 0.01 to 0.45; RD -0.39, 95% CI -0.57 to -0.21; number needed to treat for an additional beneficial outcome 3, 95% CI 2 to 5; 1 study, 69 participants; very low-certainty evidence). We are very uncertain about accidental extubation because the CIs of the RR were wide (RR 0.82, 95% CI 0.12 to 5.46; RD -0.01, 95% CI -0.12 to 0.10; 1 study, 69 participants; very low-certainty evidence). We are very uncertain about all-cause mortality during initial hospitalization because the CIs of the RR were extremely wide (RR 2.46, 95% CI 0.10 to 58.39; RD 0.03, 95% CI -0.05 to 0.10; 1 study, 69 participants; very low-certainty evidence). There is one ongoing trial. We classified two studies as awaiting classification because outcome data were not reported separately for newborns and older infants.

AUTHORS' CONCLUSIONS

Evidence for comparing cuffed versus uncuffed ETTs in neonates is limited by a small number of babies in a single RCT with possible bias. There is very low certainty evidence for all outcomes of this review. CIs of the estimate for postextubation stridor were wide. No neonate had clinical evidence for subglottic stenosis; however, endoscopy results were not available to assess the anatomy. Additional RCTs are necessary to evaluate the benefits and harms of cuffed ETTs (inflated and non-inflated) in the neonatal population. These studies must include neonates and be conducted both for short-term use (in the setting of the operating room) and chronic use (in the setting of chronic lung disease) of cuffed ETTs.

The Royal College of surgeons multidisciplinary guidelines on elective tracheostomy insertion in COVID-19 ventilated patients

BACKGROUND

The current COVID-19 pandemic has placed enormous strain on healthcare systems worldwide. Understanding of COVID-19 is rapidly evolving. Pneumonia associated with COVID-19 may lead to respiratory failure requiring mechanical ventilation. The rise in patients requiring mechanical ventilation may lead to an increase in tracheostomies being performed in patients with COVID-19. Performing tracheostomy in patients with active SARS-CoV-2 infection poses a number of challenges.

METHODS

These guidelines were written following multidisciplinary agreement between Otolaryngology, Head and Neck Surgery, Respiratory Medicine and the Department of Anaesthetics and Critical Care Medicine in the Royal College of Surgeons in Ireland. A literature review was performed and a guideline for elective tracheostomy insertion in patients with COVID-19 proposed.

CONCLUSION

The decision to perform tracheostomy in patients with COVID-19 should be undertaken by senior members of the multidisciplinary team. Steps should be taken to minimise risks to healthcare workers.

Incidence of Laryngotracheal Lesions After Orotracheal Intubation in Coronavirus Disease Patients

OBJECTIVES/HYPOTHESIS

To evaluate the incidence of lesions and severe sequelae and the risk factors for the development of laryngotracheal lesions after orotracheal intubation (OTI) in coronavirus disease (COVID-19) patients.

STUDY DESIGN

Prospective cohort study.

METHODS

In this prospective cohort study, we evaluated patients diagnosed with COVID-19 who were consecutively admitted to a tertiary hospital and required OTI from March 1, 2020 to October 31, 2020. Patients discharged were called for outpatient follow-up and endoscopic examination.

RESULTS

A total of 1,357 patients diagnosed with COVID-19, as confirmed by nasal swab reverse transcription polymerase chain reaction, were admitted. OTI for mechanical ventilation was required in 421 patients (31%). Of the intubated patients, 172 (40.9%) were discharged and 249 (59.1%) died. Outpatient evaluation by videoendoscopy was performed in 95 patients (55.2%) approximately 100 days after extubation. Laryngotracheal lesions were observed in 38 patients (40%), with 17.9% diagnosed with laryngotracheal stenosis or unilateral immobility while 6.3% had severe stenosis (grades 3 and 4). The factors presenting statistical significance for the development of laryngotracheal lesions were the endotracheal tube (ETT) size; prone position over the OTI period; and the increased leukocyte count, d-dimer, prothrombin time (PT), and international normalized ratio (INR) on the day OTI was performed.

CONCLUSIONS

The incidence of laryngotracheal lesion in COVID-19 patients is 40%, with 6.3% of them presenting with severe stenosis. There was a greater risk for the development of laryngotracheal lesions in patients using a larger ETT, kept in a prone position, presenting a greater inflammatory reaction (increased leukocyte count), or developing coagulation disorders (increased d-dimer, PT, and INR).

LEVEL OF EVIDENCE

3 Laryngoscope, 2021.

Effectiveness of continuous endotracheal cuff pressure control for the prevention of ventilator associated respiratory infections: an open-label randomised, controlled trial

Background

An endotracheal tube cuff pressure between 20 and 30 cmH₂O is recommended to prevent ventilator-associated respiratory infection (VARI). We aimed to evaluate whether continuous cuff pressure control (CPC) was associated with reduced VARI incidence compared with intermittent CPC.

Methods

We conducted a multicenter open-label randomized controlled trial in intensive care unit (ICU) patients within 24 hours of intubation in Vietnam. Patients were randomly assigned 1:1 to receive either continuous CPC using an automated electronic device or intermittent CPC using a manually hand-held manometer. The primary endpoint was the occurrence of VARI, evaluated by an independent reviewer blinded to the CPC allocation.

Results

We randomized 600 patients; 597 received the intervention or control and were included in the intention to treat analysis. Compared with intermittent CPC, continuous CPC did not reduce the proportion of patients with at least one episode of VARI (74/296 [25%] vs 69/301 [23%]; odds ratio [OR] 1.13; 95% confidence interval [CI] .77–1.67]. There were no significant differences between continuous and intermittent CPC concerning the proportion of microbiologically confirmed VARI (OR 1.40; 95% CI .94–2.10), the proportion of intubated days without antimicrobials (relative proportion [RP] 0.99; 95% CI .87–1.12), rate of ICU discharge (cause-specific hazard ratio [HR] 0.95; 95% CI .78–1.16), cost of ICU stay (difference in transformed mean [DTM] 0.02; 95% CI −.05 to .08], cost of ICU antimicrobials (DTM 0.02; 95% CI −.25 to .28), cost of hospital stay (DTM 0.02; 95% CI −.04 to .08), and ICU mortality risk (OR 0.96; 95% CI .67–1.38).

Conclusions

Maintaining CPC through an automated electronic device did not reduce VARI incidence.

Clinical Trial Registration

NCT02966392.

Examination of the frequency of upward and downward fluctuations in the pressure obtained from the cuff pressure-time curve by continuous measurement of endotracheal tube cuff pressure during thyroid surgery: a case series

Background

Few studies examined time-to-time changes of cuff pressure of an endotracheal tube during surgery. We retrospectively analyzed the changes of cuff pressure during thyroid surgery and examined its relationships with postoperative airway complications.

Case presentation

Cuff pressure was initially adjusted at 26 cmH₂O and continuously measured in 61 patients. The cuff pressure-time curve dynamically fluctuated, and exceeded 30 cmH₂O in all patients, whereas decreased to ≤ 20 cmH₂0 in 42 (69%) patients. Ratio of the period with such an increase and decrease of cuff pressure to the total duration of surgery were 40% (28–66%) and 9% (0–21%), respectively (median, interquartile range). No patients showed symptoms of airway stenosis requiring treatment except one who developed recurrent laryngeal nerve palsy. No patients had lower respiratory tract infection.

Conclusions

Cuff pressure dynamically fluctuated during thyroid surgery. Preventing an increase as well as decrease of cuff pressure is required.

The effect of different inflating volume on the measurement accuracy of the modified cuff pressure measurement method

To evaluate the effect of different inflation volume on the measurement accuracy of the modified cuff pressure measurement method in different shapes of cuffs, so as to provide reference for the correct monitoring of cuff pressure in clinic. In vitro study: The traditional cuff pressure measurement method (the cuff pressure gauge before measurement shows 0 cm H₂O) and the modified cuff pressure measurement method (the cuff pressure before measurement shows 25 cm H₂O, 28 cm H₂O, 30 cm H₂O or 32 cm H₂O) were used to measure cylindrical and tapered cuffs, and the effect of different inflation volume on cuff pressure was analyzed statistically. Clinical study: patients with the artificial airway established by orotracheal intubation or tracheotomy in Neuro-ICU were prospectively selected as subjects, and the measurement procedure was the same as in vitro study. In vitro study showed that the pressure loss values of cylindrical cuff and tapered cuff using the traditional cuff pressure measurement method were (3.75 ± 0.31) cm H₂O and (4.92 ± 0.44) cm H₂O, respectively, and clinical study showed that the pressure loss values were (5.07 ± 0.83) cm H₂O and (5.17 ± 0.93) cm H₂O, respectively. The actual measured values measured by the traditional cuff pressure measurement method of the two cuff shapes were compared with the corrected target value of 28 cm H₂O, and the differences were statistically significant (P < 0.000). Both in vitro and clinical study had shown that all differences between the actual measured value and the corrected target value using the modified cuff pressure measurement method (measured with 25 cm H₂O, 30 cm H₂O, 32 cm H₂O) were statistically significant (P < 0.000), and the range of overall differences was (0-1.23 ± 0.25) cm H₂O. In vitro study had shown that the pressure variation coefficient (CV) of the tapered cuff was greater than that of the cylindrical cuff, and the difference was statistically significant (3.08 ± 0.25 VS 2.41 ± 0.21, P < 0.000). The traditional cuff pressure measurement method can directly lead to the cuff pressure drop, which is easy to cause the leakage of secretions on the cuffs and the misjudgment of the cuff pressure by medical personnel. However, the modified cuff pressure measurement method can effectively reduce cuff pressure loss, and taking the actual cuff pressure value as the inflation volume is the highest measurement accuracy.The tapered cuff is more susceptible to air volume, so it is necessary to pay attention to its measurement and correction in clinical practice.

Surgical Tracheostomies in COVID-19 Patients: Indications, Technique, and Results in a Second-Level Spanish Hospital

OBJECTIVE

The main purpose of this work is to describe the sociodemographic and clinical characteristics of intensive care unit (ICU) patients in a second-level hospital in Madrid, Spain, focusing in those who underwent surgical tracheostomy during the coronavirus disease 2019 (COVID-19) pandemic. The surgical technique and associated complications are also detailed.

STUDY DESIGN

Observational and historical cohort.

SETTING

Single center.

METHODS

Eighty-three intubated COVID-19 patients were analyzed. Thirty bedside surgical tracheostomies had been performed following our safety protocol.

RESULTS

Data from 83 patients admitted to the ICU in Infanta Leonor University Hospital were collected; 74.7% were male. The average age was 59.7 years. The main comorbidities found were hypertension in 51.8%, diabetes mellitus in 25.3%, asthma in 7.2%, and chronic obstructive pulmonary disease in 3.6%. A surgical tracheostomy was carried out in 36.1% of patients who needed a prolonged intubation. The most frequent complication of the surgical procedure, bleeding, occurred in 30%, but the majority were mild and ceased with compression only. The most relevant complication was local infection, which occurred in 26.7% of patients. There were statistically significant differences in the time from the beginning of mechanical ventilation until weaning between tracheostomized and nontracheostomized patients. The mortality rate of patients who underwent tracheostomy was 56.7%. Despite severe acute respiratory syndrome coronavirus 2 being highly contagious and tracheostomy being considered a high-risk procedure, our rate of infected ear, nose, and throat specialists was only 11.8%.

CONCLUSION

In our experience, bedside surgical tracheostomy is a safe procedure in COVID-19 patients when safety protocols are followed.

Tracheostomy during SARS-CoV-2 pandemic: Recommendations from the New York Head and Neck Society

The rapid spread of SARS‐CoV‐2 in 2019 and 2020 has resulted in a worldwide pandemic characterized by severe pulmonary inflammation, effusions, and rapid respiratory compromise. The result of this pandemic is a large and increasing number of patients requiring endotracheal intubation and prolonged ventilator support. The rapid rise in endotracheal intubations coupled with prolonged ventilation requirements will certainly lead to an increase in tracheostomy procedures in the coming weeks and months. Performing tracheostomy in the setting of active SARS‐CoV‐2, when necessary, poses a unique situation, with unique risks and benefits for both the patient and the health care providers. The New York Head and Neck Society has collaborated on this document to provide guidance on the performance of tracheostomies during the SARS‐CoV‐2 pandemic.