Fusarium species of the Gibberella fujikuroi complex and fumonisin contamination of pearl millet and corn in Georgia, USA

Relevant Fusarium Mycotoxins in Malt and Beer

Mycotoxins are secondary fungal metabolites of high concern in the food and feed industry. Their presence in many cereal-based products has been numerously reported. Beer is the most consumed alcoholic beverage worldwide, and Fusarium mycotoxins originating from the malted and unmalted cereals might reach the final product. This review aims to describe the possible Fusarium fungi that could infect the cereals used in beer production, the transfer of mycotoxins throughout malting and brewing as well as an insight into the incidence of mycotoxins in the craft beer segment of the industry. Studies show that germination is the malting step that can lead to a significant increase in the level of all Fusarium mycotoxins. The first step of mashing (45 °C) has been proved to possess the most significant impact in the transfer of hydrophilic toxins from the grist into the wort. However, during fermentation, a slight reduction of deoxynivalenol, and especially of zearalenone, is achieved. This review also highlights the limited research available on craft beer and the occurrence of mycotoxins in these products.

Spatiotemporal assessment of post-harvest mycotoxin contamination in rural North Indian food systems

The spatiotemporal trends in aflatoxin B1 (AFB1), fumonisin B1 (FB1), and deoxynivalenol (DON) accumulation were analyzed in a range of food commodities (maize, groundnut, pearl millet, rice, and wheat) in village settings in Unnao, Uttar Pradesh, India. Samples (n = 1549) were collected across six communities and six time points spanning a calendar year and were analyzed for mycotoxins using enzyme-linked immunosorbent assays. AFB1 and FB1 were common across surveyed villages, with moderate to high detection rates (45-75%) observed across commodities. AFB1 levels in maize and groundnuts and FB1 levels in maize and pearl millet frequently exceeded regulatory threshold levels of 15 μg/kg (AFB1) and 2 μg/g (FB1). DON was analyzed in wheat, with 3% of samples yielding detectable levels and none exceeding 1 μg/g. In rice, AFB1 levels were highest in the bran and husk and lower in the kernel. Commodity type significantly influenced AFB1 detection status, while commodity type, season, and visual quality influenced samples' legal status. Storage characteristics and household socioeconomic status indicators did not have significant effects on contamination. No significant effects of any variables on FB1 detection or legal status were observed. Data on mycotoxin contamination, combined with data on local dietary intake, were used to estimate spatiotemporal mycotoxin exposure profiles. Estimated seasonal per capita exposure levels for AFB1 (5.4-39.3 ng/kg body weight/day) and FB1 (~0-2.4 μg/kg body weight/day) exceeded provisional maximum tolerable daily intake levels (1 ng/kg body weight/day for AFB1 and 2 μg/kg body weight/day for FB1) in some seasons and locations. This study demonstrates substantial dietary mycotoxin exposure risk in Unnao food systems and serves as an evidentiary foundation for participatory food safety intervention in the region.

Mycotoxins produced by Fusarium proliferatum and F. pseudonygamai on maize, sorghum and pearl millet grains in vitro

Maize (Zea mays), sorghum (Sorghum bicolor) and pearl millet (Pennisetum glaucum) are basic staple foods for many rural or poorer communities. These crops are susceptible to plant diseases caused by multiple species of Fusarium, some of which also produce mycotoxins, including fumonisins and moniliformin that are detrimental to both humans and domesticated animals. Eighteen potentially toxigenic Fusarium strains were isolated from maize (n = 10), sorghum (n = 7) and pearl millet (n = 1) growing in the same field in Nigeria. The 17 strains from maize and sorghum were all F. proliferatum and the one strain from pearl millet was F. pseudonygamai. Under conducive conditions, the 17 F. proliferatum strains produced fumonisins, 11 in relatively large quantities (700-17,000 mg total fumonisins, i.e., FB₁ + FB₂ + FB₃/kg culture material), and six at <45 mg/kg. Ten F. proliferatum strains produced >100 mg of moniliformin per kg culture material with a maximum of 8900 mg/kg culture material. All strains could use all grains for growth and toxin production, regardless of the host from which they were isolated. Isolates varied in the amount of toxin produced on each substrate, with toxin production a property of the strain and not the host from which the strain was recovered. However, the extent to which a toxin-producing phenotype could be altered by the grain on which the fungus was grown is consistent with subtle genetic × environment interactions that require a larger data set than the one presented here to rigorously identify. In conclusion, there is significant variation in the ability of strains of F. proliferatum to produce fumonisins and moniliformin on maize, sorghum and millet. If the amount of toxin produced on the various grains in this study reflects real-world settings, e.g., poor storage, then the consumers of these contaminated grains could be exposed to mycotoxin levels that greatly exceed the tolerable daily intakes.

Differences in Fusarium Species in brown midrib Sorghum and in Air Populations in Production Fields

Several Fusarium spp. cause sorghum (Sorghum bicolor) grain mold, resulting in deterioration and mycotoxin production in the field and during storage. Fungal isolates from the air (2005 to 2006) and from leaves and grain from wild-type and brown midrib (bmr)-6 and bmr12 plants (2002 to 2003) were collected from two locations. Compared with the wild type, bmr plants have reduced lignin content, altered cell wall composition, and different levels of phenolic intermediates. Multilocus maximum-likelihood analysis identified two Fusarium thapsinum operational taxonomic units (OTU). One was identified at greater frequency in grain and leaves of bmr and wild-type plants but was infrequently detected in air. Nine F. graminearum OTU were identified: one was detected at low levels in grain and leaves while the rest were only detected in air. Wright's F statistic (F_ST) indicated that Fusarium air populations differentiated between locations during crop anthesis but did not differ during vegetative growth, grain development, and maturity. F_ST also indicated that Fusarium populations from wild-type grain were differentiated from those in bmr6 or bmr12 grain at one location but, at the second location, populations from wild-type and bmr6 grain were more similar. Thus, impairing monolignol biosynthesis substantially effected Fusarium populations but environment had a strong influence.

Genetic diversity and pathogenicity of Fusarium species associated with fruit rot disease in banana across Peninsular Malaysia

AIMS

The aims of this study were to identify the Fusarium isolates based on translation elongation factor (tef) 1α sequence, to determine the genetic diversity among isolates and species using selected microsatellite markers and to examine the pathogenicity of Fusarium isolates causing fruit rot disease of banana.

METHODS AND RESULTS

One-hundred and thirteen microfungi isolates were obtained from fruit rot infected banana in Peninsular Malaysia. However, this study was focused on the dominant number of the discovered microfungi that belongs to the genus Fusarium; 48 isolates of the microfungi have been identified belonging to 11 species of Fusarium, namely Fusarium incarnatum, Fusarium equiseti, Fusarium camptoceras, Fusarium solani, Fusarium concolor, Fusarium oxysporum, Fusarium proliferatum, Fusarium verticillioides, Fusarium sacchari, Fusarium concentricum and Fusarium fujikuroi. All Fusarium isolates were grouped into their respective clades indicating their similarities and differences in genetic diversity among isolates. Out of 48 Fusarium isolates tested, 42 isolates caused the fruit rot symptom at different levels of severity based on Disease Severity Index (DSI). The most virulent isolate was F. proliferatum B2433B with DSI of 100%.

CONCLUSIONS

All the isolated Fusarium species were successfully identified and some of them were confirmed as the causal agents of pre- and postharvest fruit rot in banana across Peninsular Malaysia.

SIGNIFICANCE AND IMPACT OF THE STUDY

Our results will provide additional information regarding new report of Fusarium species in causing banana fruit rot and in the search of potential biocontrol agent of the disease.

Fusarium Toxins in Cereals: Occurrence, Legislation, Factors Promoting the Appearance and Their Management

Fusarium diseases of small grain cereals and maize cause significant yield losses worldwide. Fusarium infections result in reduced grain yield and contamination with mycotoxins, some of which have a notable impact on human and animal health. Regulations on maximum limits have been established in various countries to protect consumers from the harmful effects of these mycotoxins. Several factors are involved in Fusarium disease and mycotoxin occurrence and among them environmental factors and the agronomic practices have been shown to deeply affect mycotoxin contamination in the field. In the present review particular emphasis will be placed on how environmental conditions and stress factors for the crops can affect Fusarium infection and mycotoxin production, with the aim to provide useful knowledge to develop strategies to prevent mycotoxin accumulation in cereals.

Giberella fujikuroi species complex isolated from maize and wheat in Iran: distribution, molecular identification and fumonisin B1 in vitro biosynthesis

BACKGROUND

Contamination of food and agricultural crops by Fusarium species is a major concern of food spoilage and a potential public health hazard. In the present study, natural contamination of maize and wheat samples from main cultivation areas of Iran by Fusarium species belonging to the Giberella fujikuroi species complex was evaluated, with special attention to the ability of the isolates to produce fumonisin B1 (FB1 ).

RESULTS

A total of 55 Fusarium isolates were obtained from 27/32 maize samples (84.4%) and 11/15 wheat samples (73.3%). They were identified as F. verticillioides (47.3%), F. proliferatum (47.3%), F. fujikuroi (1.8%), F. nygamai (1.8%) and F. redolens (1.8%) by sequence analysis of translation elongation factor 1-α (TEF1-α). Twenty-two of 55 Fusarium isolates belonging to F. proliferatum (23.6%), F. verticillioides (14.5%) and F. fujikuroi (1.8%) produced FB1 in the concentration range 230.4-9565.0 µg mL(-1) . The dendrogram resulting from the TEF1-α profile showed that the genotypes were divided into clusters I, II and III, of which cluster III contained only F. redolens, its first report from Iran.

CONCLUSION

On the basis of in vitro FB1 biosynthesis of the analyzed strains, the high degree of contamination of maize and wheat with Fusarium strains reported here should be considered as a potential public health threat, because a meaningful number of the isolates were found to produce hazardous levels of carcinogenic FB1 .

Mesoionic compounds with antifungal activity against Fusarium verticillioides

Background

Fungi contaminate the food of humans and animals, are a risk to health, and can cause financial losses. In this work, the antifungal activities of 16 mesoionic compounds (MI 1–16) were evaluated against mycotoxigenic fungi, including Aspergillus spp., Fusarium verticillioides and Penicillium citrinum. Furthermore, the decreased ergosterol in the total lipid content of Fusarium verticillioides was investigated.

Results

F. verticillioides was the most sensitive fungus to the mesoionic compounds. Among the evaluated compounds, MI-11 and MI-16 presented higher antifungal effects against F. verticillioides, with MIC values of 7.8 μg/ml, and MI-2 and MI-3 followed, with MICs of 15.6 μg/ml. The most active compounds were those with heterocyclic ring phenyl groups substituted by electron donor moieties (MI-11 and MI-16). Among some compounds with higher activity (MI-2, MI-11 and MI-16), decreased ergosterol content in the total lipid fraction of F. verticillioides was demonstrated. MI-2 reduced the ergosterol content approximately 40% and 80% at concentrations of 7.8 μg/ml and 15.6 μg/ml, respectively, and MI-11 and MI-16 decreased the content by 30% and 50%, respectively, when at a concentration of 7.8 μg/ml.

Conclusion

These findings indicate that mesoionic compounds have significant antifungal activity against F. verticillioides.

Natural occurrence of mycotoxins in forage maize during crop growth in Japan: case study

We investigated concentrations of mycotoxins during the growth of four cultivars of forage maize (Zea mays L.) in Nasushiobara, Tochigi prefecture, and their distribution in ears of maize grown in Morioka, Iwate prefecture, Japan. In experiment 1, we measured concentrations of naturally occurring fumonisin, nivalenol, deoxynivalenol and zearalenone at progressive crop growth stages. Concentrations of fumonisin in stems+leaves remained very low or not detectable, but those in ears became detectable at 40 days after heading and increased rapidly after 50 days after heading (DAH) (fumonisin B1+B2<3260 μg/kg; mean value at 50-74 days after heading). Concentrations varied widely within cultivars on the same day. Concentrations of nivalenol, deoxynivalenol and zearalenone in stems+leaves and in ears were low or not detectable throughout the experiment. In experiment 2, we collected three ears of each cultivar at the late yellow-ripe stage that showed extreme symptoms of Fusarium ear rot. Concentrations of fumonisin were extremely high in the upper half of ears in all cultivars (fumonisin B1+B2 18,000-25,900 μg/kg) but low in the lower half and bracts. Concentrations of nivalenol, deoxynivalenol and zearalenone were extremely low or not detectable. These results show that fumonisin concentrations in ears increased rapidly after 50 DAH, they were extremely high in ears of all cultivars with symptoms of Fusarium ear rot, and fumonisin was the most common contaminant. These results will help reduce mycotoxin contamination.

Aflatoxin contamination of pearl millet during field and storage conditions with reference to stage of grain maturation and insect damage

Aflatoxin contamination in five varieties of pearl millet (ICMH-451, ICMP-50I, ICTP-8203, WCC-75 and ICMV-155) was studied from field and storage conditions in three districts of Andhra Pradesh State, India and the inter-relationships between various parameters such as stage of grain maturation in the field and insect pest infestation in storage in relation to aflatoxin production were evaluated. Aflatoxin contamination was more frequent in the seed samples collected from the fields during rainy season than winter season. All major aflatoxins were isolated from one or the other varieties of pearl millet, whereas aflatoxin G2 was not commonly observed in the seed samples collected during winter. Among all the varieties tested, ICMH-451 was vulnerable to aflatoxin contamination whereas ICMV-155 was the least susceptible variety. The higher amount of aflatoxins was observed in the matured seed samples followed by pre-matured and milky stage. Among all the toxins reported in the field, aflatoxin B1 was found in higher concentration (185 (μg/kg) followed by B2 (105 μg/kg). The four major types of aflatoxins with higher levels (35, 40, 140, 190 μg/kg of G1, G2, B2, B1 were reported in the rainy season seed samples after six months of storage, whereas aflatoxin G1 was not observed in any variety of stored seed sample from winter. Statistical analysis revealed that the aflatoxin incidence in relation to different parameters studied was significantly different for each factor. The relationship between aflatoxin contamination and insect damaged-grain clearly indicated that the seed samples with 16-40% of insect damage contained higher amounts of aflatoxins (758 μg/kg).

Fusarium verticillioides from finger millet in Uganda

Finger millet (Eleusine coracana) is a subsistence crop grown in Sub-Saharan Africa and the Indian Sub-continent. Fusarium species occurring on this crop have not been reported. Approximately 13% of the Fusarium isolates recovered from finger millet growing at three different locations in eastern Uganda belong to Fusarium verticillioides, and could produce up to 18,600 µg/g of total fumonisins when cultured under laboratory conditions. These strains are all genetically unique, based on AFLP analyses, and form fertile perithecia when crossed with the standard mating type tester strains for this species. All but one of the strains is female-fertile and mating-type segregates 13:20 Mat-1:Mat-2. Three new sequences of the gene encoding translation elongation factor 1-α were found within the population. These results indicate a potential health risk for infants who consume finger millet gruel as a weaning food, and are consistent with the hypothesis that F. verticillioides originated in Africa and not in the Americas, despite its widespread association with maize grown almost anywhere worldwide.

Identification and sensitivity of two rare fungal species isolated from two patients with Fusarium keratomycosis

We report two cases of Fusarium keratomycosis in which molecular analysis was used to identify two rare causative Fusarium species. A 65-year-old woman was diagnosed with Fusarium keratomycosis caused by F. equiseti, confirmed by sequencing the internal transcribed spacer (ITS) region and morphological characteristics. She was initially treated with topical corticosteroid but the keratitis did not improve. Even after aggressive antifungal treatment, there was a severe reduction of vision. In the end, the eye perforated. Our second case was a 75-year-old man who had diabetes mellitus. He developed keratitis after his cornea was injured by corn stalks. The ITS region identified the causative organism as F. verticillioides. Unlike the first case, he had good visual recovery after early antifungal therapy. Our findings demonstrate that both ITS and morphological characteristics can be used to identify the exact Fusarium species causing Fusarium keratomycosis. This allowed us to determine the sensitivity of these species to antifungal drugs that can be used to treat patients with these species of Fusarium.

Molecular identification of Fusarium species in Gibberella fujikuroi species complex from rice, sugarcane and maize from Peninsular Malaysia

The objective of this study was to identify Fusarium species in the Gibberella fujikuroi species complex from rice, sugarcane and maize as most of the Fusarium species in the species complex are found on the three crops. Isolates used were collected from the field and obtained from culture collection. The Fusarium isolates were initially sorted based on morphology and identifications confirmed based on the DNA sequence of the translation elongation factor 1-α (TEF-1α) gene. Based on the closest match of BLAST analysis, five species were recovered, namely, F. sacchari, F. fujikuroi, F. proliferatum, F. andiyazi and F. verticillioides. This is the first report regarding F. andiyazi from rice in Malaysia and Southeast Asia. The phylogenetic tree generated by using the neighbor joining method showed that isolates from the same species were grouped in the same clade. The present study indicated that Fusarium species in the G. fujikuroi species complex are widespread in rice, sugarcane and maize in Peninsular Malaysia. The findings also suggest that the use of morphological characters for identification of Fusarium species in the G. fujikuroi species complex from the three crops will lead to incorrect species designation.

Limited surveillance of fumonisins in brown rice and wheat harvested in Japan

Fumonisins are mycotoxins mainly produced by Fusarium verticillioides, which is a major contaminant of corn. However, there are sporadic reports of fumonisin contamination in wheat worldwide. The rice adherent fungus Gibberella fujikuroi is taxonomically closely related to F. verticillioides. Therefore, the potential risk of fumonisin contamination in rice and wheat is significant. Previously, a sensitive detection method utilizing liquid chromatography with tandem electrospray mass spectrometry (LC-ESI-MS-MS) was developed for the determination of fumonisins in brown rice. In the present study, the incidence of fumonisins in brown rice and wheat harvested in Japan was investigated using LC-ESI-MS-MS. Forty-eight rice samples and 47 wheat samples were screened and analyzed for the major B-type fumonisins: fumonisin B1 (FB1) and fumonisin B2 (FB2). About 1 kg of rice or wheat seed was divided into three subsamples, and 10 g from each subsample was used for the analysis. The limits of detection were 0.012 and 0.011 mg/kg for FBt and FB2, respectively, in rice samples and 0.010 and 0.008 mg/kg for FB1 and FB2, respectively, in wheat samples. The mean (standard deviation) recoveries of FB1 spiked at 0.50 mg/kg into toxin-free rice and wheat samples were 77.6 (4.2)% and 84.5 (3.1)%, respectively. One of the wheat samples was positive for FBt with a value greater than the limit of detection,but no fumonisin was found in any of the rice samples. This is the first report of fumonisins detected in Japanese wheat.

Changes in fungi and mycotoxins in pearl millet under controlled storage conditions

Pearl millet is increasingly being grown as a premium-value grain for the recreational wildlife and poultry industries in the southern US. We conducted three experiments to assess grain mold development in storage conditions typically encountered in the region of production. Variables included production year, temperature, relative humidity, atmosphere, and grain moisture content. In the first experiment, grain was stored for 9 weeks at 20 or 25 degrees C and maintained at 86% or 91% relative humidity (r.h.). In the second experiment, grain was stored for 9 weeks at 20 or 25 degrees C in either air (aerobic) or N2 (anaerobic), and maintained at 100% r.h. In the third experiment, high-moisture grain was stored for 3 weeks at 20 or 25 degrees C and maintained at 100% r.h. Grain was sampled at weekly intervals and plated to determine changes in fungal frequency. Fungi isolated included Fusarium chlamydosporum (19% of grain), Curvularia spp. (14%), F. semitectum (16%), Alternaria spp. (9%), Aspergillus flavus (8%), "Helminthosporium"-type spp. (6%), and F. moniliforme sensu lato (3%). Year of grain production significantly affected isolation frequency of fungi. Isolation frequencies from low-moisture grain were rarely affected by temperature, relative humidity, or atmosphere treatments, but was affected by storage duration for some fungi. Changes in isolation of toxigenic fungi occurred in high-moisture grain. Isolation frequency of F. chlamydosporum increased in grain stored at 86% and 91% r.h. Incidence of A. flavus increased in high-moisture grain treatments, particularly at 25 degrees C. Incidence of deoxynivalenol was not affected by storage treatment. Low concentrations of nivalenol were detected in most grain incubated at 100% r.h. Zearalenone was detected only when grain moisture content was 20-22%. Aflatoxin contamination averaged 174 ng g(-1) over all treatments, and increased up to 798 ng g(-1) in high-moisture grain at stored at 25 degrees C.

Host-specific Variation in Infection by Toxigenic Fungi and Contamination by Mycotoxins in Pearl Millet and Corn

Pearl millet is widely consumed in regions of Africa and Asia, and is increasingly being grown as an alternative grain in drought-prone regions of the United States. Pearl millet and corn were grown in dryland conditions at Tifton, Georgia, USA and grains were compared for pre-harvest infection by potentially toxigenic fungi and contamination by mycotoxins. Corn hybrids Agripro 9909 and Pioneer 3146, and pearl millet Tifgrain 102 were grown in 2000 and 2001; pearl millet HGM 100 was included in the test in 2001. Hybrids were sown on multiple planting dates in each year to induce variation in flowering time. Host species differed in the frequency of isolation of potentially toxigenic fungal species in both years. Across years, corn hybrids were more prone to infection by Aspergillus flavus Link (maximum isolation frequency = 8.8%) and Fusarium moniliforme Sheldon sensu lato (maximum isolation frequency = 72.8%), with corresponding greater concentrations of aflatoxins (maximum concentration = 204.9 microg kg(-1)) and fumonisins (maximum concentration = 34,039 microg kg(-1)). Pearl millet was more prone to infection by F. semitectum Berk. & Ravenel (maximum isolation = 74.2%) and F. chlamydosporum Wollenweb & Reinking (maximum isolation = 33.0%), and contamination by moniliformin (maximum contamination = 92.1 microg kg(-1)). Beauvericin (maximum concentration = 414.6 microg kg(-1)) was present in both hosts. Planting date of corn affected aflatoxin and beauvericin contamination in 2000, and fumonisin concentration in 2001. The observed differences in mycotoxin contamination of the grains, which are likely due to host-specific differences in susceptibility to pre-harvest mycoflora, may affect food safety when the crops are grown under stress conditions.