Revealing the mechanisms of Triclosan affecting of methane production from waste activated sludge

Enhanced dewaterability and triclosan removal of waste activated sludge with iron-rich mineral-activated peroxymonosulfate

High water and pharmaceutical and care products (PPCPs) bounded in sludge flocs limit its utilization and disposal. The advanced oxidation process of perxymonosulfate (PMS) catalyzed by iron salts has been widely used in sludge conditioning. In this study, two iron-rich minerals pyrite and siderite were proposed to enhance sludge dewatering performance and remove the target contaminant of triclosan (TCS). The permanent release of Fe2+ in the activation of PMS made siderite more effective in enhancing sludge dewater with capillary suction time (CST) diminishing by 60.5 %, specific resistance to filtration (SRF) decreasing by 79.2 %, and bound water content (BWC) dropping from 37.1 % to 2.6 % at siderite/PMS dosages of 0.36/0.20 mmol/g-TSS after 20 min of pretreatment. Pyrite/PMS performed slightly inferior under the same conditions and the corresponding CST and SRF decreased by 51.5 % and 71.8 % while the BWC only declined to 17.8 %. Rheological characterization was employed to elucidate the changes in sludge dewatering performance, with siderite/PMS treated sludge showing a 48.3 % reduction in thixotropy, higher than 28.4 % of pyrite/PMS. Oscillation and creep tests further demonstrated the significantly weakened viscoelastic behavior of the sludge by siderite/PMS pretreatment. For TCS mineralization removal, siderite/PMS achieved a high removal efficiency of 43.9 %, in comparison with 39.9 % for pyrite/PMS. The reduction in the sludge solids phase contributed the most to the TCS removal. Free radical quenching assays and EPR spectroscopy showed that both siderite/PMS and pyrite/PMS produced SO4-·  and ·OH, with the latter acting as the major radicals. Besides, the dosage of free radicals generated from siderite/PMS exhibited a lower time-dependence, which also allowed it to outperform in destroying EPS matrix, neutralizing the negative Zeta potential of sludge flocs, and mineralizing macromolecular organic matter.

Pre-exposure of Triclosan compromise tetracycline-derived antibiotic resistance in methanogenic digestion microbiome

Triclosan (TCS) and tetracycline (TC) are commonly detected antibacterial agents in sewage and environment matrices. Nonetheless, the impact of sequential exposure to TCS and TC on the methanogenic digestion microbiome remains unknown. In this study, TCS was shown to reduce COD removal efficiency to 69.8%, but alleviated the inhibitive effect of consequent TC-amendment on the digestion microbiome. Interestingly, TCS pre-exposure resulted in abundance increase of acetotrophic Methanosaeta to 2.68%, being 2.91 folds higher than that without TCS amendment. Microbial network analyses showed that TCS pre-exposure caused microorganisms to establish a co-ecological relationship against TC disturbance. Further analyses of total antibiotic resistance genes (ARGs) showed the TCS-derived compromise of TC-induced ARGs enrichment in digestion microbiomes, e.g., 238.2% and 152.1% ARGs increase upon TC addition in digestion microbiomes without and with TCS pre-exposure, respectively. This study provides new insights into the impact of antibacterial agents on the methanogenic digestion microbiome.

Improved Short-Chain Fatty Acids Production and Protein Degradation During the Anaerobic Fermentation of Waste-Activated Sludge via Alumina Slag-Modified Biochar

As the by-product in the biological sewage treatment, waste-activated sludge (WAS) always suffers from the difficulty of disposal. Anaerobic fermentation to achieve valuable carbon sources is a feasible way for resource utilization of WAS, whereas the process is always restricted by its biochemical efficiency. Hence, the WAS was used as the feedstock in this study. Alumina slag-modified biochar (Al@BioC) respectively from pine wood (PW) or fresh vinegar residue (FVR) was employed to stimulate the process of short-chain fatty acids (SCFAs) production during the anaerobic treatment of WAS. The results indicate that the addition of Al@BioC could facilitate the distinct increase in SCFAs yield (42.66 g/L) by 14.09% and acetate yield (33.30 g/L) by 18.77%, respectively, when compared with that in regular fermentation without Al@BioC addition. Furthermore, protein degradation was also improved. With the Al@BioCPW added, the maximum concentration of soluble protein reached 867.68 mg/L and was 24.39% higher than the initial level, while the enhancement in the group with Al@BioCFVR and without biochar addition was 12.49% and 7.44%, respectively. According to the results of 16S rDNA sequencing, the relative abundance of acid-producing bacteria (Bacteroidota and Firmicutes) was enriched, enhancing the pathways of protein metabolisms and the ability to resist the harsh environment, respectively. Moreover, Proteiniphilum under Bacteroidota and Fastidiosipila under Firmicutes were the main microorganisms to metabolize protein. The above results might provide a novel material for harvesting the SCFAs production, which is conducive to harmless disposal and carbon resource recovery.

Enhancing methane production from anaerobic digestion of secondary sludge through lignosulfonate addition: Feasibility, mechanisms, and implications

This study explores the feasibility of using lignosulfonate, a byproduct of the pulp and paper industry, to facilitate sludge anaerobic digestion. Biochemical methane potential assays revealed that the maximum methane production was achieved at 60 mg/g volatile solids (VS) lignosulfonate, 22.18 % higher than the control. One substrate model demonstrated that 60 mg/g VS lignosulfonate boosted the hydrolysis rate, biochemical methane potential, and degradation extent of secondary sludge by 19.12 %, 21.87 %, and 21.11 %, respectively, compared to the control. Mechanisms unveiled that lignosulfonate destroyed sludge stability, promoted organic matter release, and enhanced subsequent hydrolysis, acidification, and methanogenesis by up to 31.30 %, 74.42 % and 28.16 %, respectively. Phytotoxicity assays confirmed that lignosulfonate promoted seed germination and root development of lettuce and Chinese cabbage, with seed germination index reaching 170 ± 10 % and 220 ± 22 %, respectively. The findings suggest that lignosulfonate addition offers a sustainable approach to sludge treatment, guiding effective management practices.

Feasibility and mechanism of recycling carbon resources from waste cyanobacteria and reducing microcystin toxicity by dielectric barrier discharge plasma

Recycling carbon resources from discarded cyanobacteria is a worthwhile research topic. This study focuses on the use of dielectric barrier discharge (DBD) plasma technology as a pretreatment for anaerobic fermentation of cyanobacteria. The DBD group (58.5 W, 45 min) accumulated the most short chain fatty acids (SCFAs) along with acetate, which were 3.0 and 3.3 times higher than the control. The DBD oxidation system can effectively collapse cyanobacteria extracellular polymer substances and cellular structure, improve the biodegradability of dissolved organic matter, enrich microorganisms produced by hydrolysis and SCFAs, reduce the abundance of SCFAs consumers, thereby promoting the accumulation of SCFAs and accelerating the fermentation process. The microcystin-LR removal rate of 39.8% was obtained in DBD group (58.5 W, 45 min) on day 6 of anaerobic fermentation. The toxicity analysis using the ECOSAR program showed that compared to microcystin-LR, the toxicity of degradation intermediates was reduced. The contribution order of functional active substances to cyanobacteria cracking was obtained as eaq- > •OH > 1O2 > •O2- > ONOO-, while the contribution order to microcystin-LR degradation was eaq- > •OH > •O2- > 1O2 > ONOO-. DBD has the potential to be a revolutionary pretreatment method for cyanobacteria anaerobic fermentation.

Steel slag assists potassium ferrate to improve SCFAs production from anaerobic sludge fermentation

Potassium ferrate (PF) pretreatment in anaerobic sludge and its potential influence mechanisms have received widely attention. This study investigated the coupling effect of PF loading on steel slag (SS) on excess sludge anaerobic fermentation. Results showed that SS loading increase the treatment performance of PF on short chain volatile fatty acids (SCFAs) production from anaerobic fermented sludge. It was showed that the modified PF loaded SS (MPF-SS) promoted the dissolution and release of organic substrates from intracellular to extracellular. Further exploration showed the promotion of PF and MPF-SS exposure to acid production microorganisms was much more than that to acid consumption microorganisms. MPF-SS addition can also effectively reinforce the carbohydrate transport, amino acid metabolism and the key enhanced genes associated with fatty acid biosynthesis pathways. This study fills the knowledge gap about modified PF on sludge treatment and also expands a new perspective for its application for sludge resource recovery.

Enhanced mesophilic fermentation of waste activated sludge by integration with in-situ nitrate reduction

This study investigated the reduction of nitrate in a mesophilic waste activated sludge (WAS) fermentation system and determined the effect of nitrate reduction on the hydrolysis, acidogenesis and acetogenesis. Experimental results showed that the initial nitrate concentrations of 100, 200 and 400 mg/L were completely reduced in 1, 2 and 7 days, respectively. The destruction of volatile suspended solids was 1.2, 1.8 and 2.8 times, respectively, that without nitrate, demonstrating nitrate promoted the release of organic matter in sludge and enhanced the biodegradability of sludge organics. Moreover, batch tests using model substrates illustrated nitrate reduction promoted sludge hydrolysis and acetogenesis, but slightly inhibited acidogenesis. This study offers a feasible method to address two major problems currently faced by biological wastewater treatment plants, i.e. the overabundance of WAS and the lack of carbon sources for the denitrification process.

Mechanism of dielectric barrier plasma technology to improve the quantity and quality of short chain fatty acids in anaerobic fermentation of cyanobacteria

The recycling of high value carbon resources from cyanobacteria has become a research hotspot. This work investigated the possibility of dielectric barrier discharge (DBD) plasma pretreatment to improve the anaerobic fermentation performance of cyanobacteria. The maximum accumulations of short-chain fatty acids (SCFAs) and acetic acid in DBD group were 3.30 and 1.49 times of that in control group. The physical effects of DBD plasma and the oxidative stress response of cyanobacteria cells could improve the solubilization of cyanobacteria polymer. The destruction of humus by DBD plasma can reduce the negative impact of humus on the early stage of anaerobic fermentation, thus facilitating the rapid start of anaerobic fermentation. The contents of Bacteroidetes, Firmicutes and Chloroflexi in DBD group were higher than those in control group, while the content of Proteobacteria was on the contrary, which was conducive to the hydrolysis and acidification process. The decrease of Methanosaeta sp. and Methanosarcina sp. abundance in DBD group might be another reason for the increase of acetic acid ratio. Under the joint action of plasma chemical oxidation and microbial degradation, the degradation effect of microcystin-LR in the anaerobic fermentation supernatant of DBD group was better than that of the control group, which was conducive to the recycling of cyanobacteria anaerobic fermentation supernatant. Therefore, DBD pretreatment was conductive to recycling valuable carbon source from cyanobacteria and can be further developed as a potential new pretreatment technology.

Advances in pretreatment strategies to enhance the biodegradability of waste activated sludge for the conversion of refractory substances

Anaerobic digestion (AD) is a low-cost technology widely used to divert waste activated sludge (WAS) to renewable energy production, but is generally restricted by its poor biodegradability which mainly caused by the endogenous and exogenous refractory substances present in WAS. Several conventional methods such as thermal-, chemical-, and mechanical-based pretreatment have been demonstrated to be effective on organics release, but their functions on refractory substances conversion are overlooked. This paper firstly reviewed the presence and role of endogenous and exogenous refractory substances in anaerobic biodegradability of WAS, especially on their inhibition mechanisms. Then, the pretreatment strategies developed for enhancing WAS biodegradability by facilitating refractory substances conversion were comprehensively reviewed, with the conversion pathways and underlying mechanisms being emphasized. Finally, the future research needs were directed, which are supposed to improve the circular bioeconomy of WAS management from the point of removing the hindering barrier of refractory substances on WAS biodegradability.

Effect of Carbamazepine, Ibuprofen, Triclosan and Sulfamethoxazole on Anaerobic Bioreactor Performance: Combining Cell Damage, Ecotoxicity and Chemical Information

Pharmaceuticals and personal care products (PPCPs) are partially degraded in wastewater treatment plants (WWTPs), thereby leading to the formation of more toxic metabolites. Bacterial populations in bioreactors operated in WWTPs are sensitive to different toxics such as heavy metals and aromatic compounds, but there is still little information on the effect that pharmaceuticals exert on their metabolism, especially under anaerobic conditions. This work evaluated the effect of selected pharmaceuticals that remain in solution and attached to biosolids on the metabolism of anaerobic biomass. Batch reactors operated in parallel under the pressure of four individual and mixed PPCPs (carbamazepine, ibuprofen, triclosan and sulfametoxazole) allowed us to obtain relevant information on anaerobic digestion performance, toxicological effects and alterations to key enzymes involved in the biodegradation process. Cell viability was quantitatively evaluated using an automatic analysis of confocal microscopy images, and showed that triclosan and mixed pollutants caused higher toxicity and cell death than the other individual compounds. Both individual pollutants and their mixture had a considerable impact on the anaerobic digestion process, favoring carbon dioxide production, lowering organic matter removal and methane production, which also produced microbial stress and irreversible cell damage.

Triclosan facilitates the recovery of volatile fatty acids from waste activated sludge

The emergence of triclosan (TCS) in the environment has caused extensive concern, but its role in waste activated sludge (WAS) anaerobic fermentation (AF) is still uncertain. This work investigated the impact of TCS on volatile fatty acids (VFAs) recycling from WAS. The results showed that TCS of 200 mg/kg TSS increased the maximum VFA accumulation from 7284 to 15,083 mg COD/L. The increase in total VFA production is attributed to the massive increase in acetic acid. Mechanism exploration showed that TCS promotes WAS solubilization by facilitating cell breakage and extracellular polymeric substances disruption, and stimulates AF by enhancing the activity of key enzymes among all stages. TCS promotes acidification stronger than methanogenesis, which makes VFA production faster than consumption, leading to increased VFA accumulation. These findings provide novel insights for revealing the role of TCS in WAS resource recovery, and offer thoughts for the selective production of final recycling products of TCS-containing WAS.