Denitrification performance evaluation and kinetics analysis with mariculture solid wastes (MSW) derived carbon source in marine recirculating aquaculture systems (RAS)

Aquaculture faecal waste generates different products during anaerobic digestion depending on nutrient composition

The inclusion of carbohydrate-rich ingredients in aquafeeds has resulted in an increased fraction of undigested material, culminating in faecal waste enriched in unutilized nutrients containing carbon, nitrogen and phosphorus. This study explored the impact of faecal composition, as influenced by diet, on the products of anaerobic digestion with a focus on organic acids (OAs). The aim was to in vitro assess the potential of faeces as internal carbon for denitrification, promoting circularity in recirculating aquaculture systems. In this regard, settleable faeces originating from six diets (DDGS, Dried distillers' grains with solubles; HFM, Hydrolyzed feather meal; IM, Insect meal; SCP, Single-cell protein; SSM, Shrimp shell meal; SWP, Seaweed protein) fed to European seabass, were incubated for a 14-day period in anoxic batch reactors. Nutrient solubilization (chemical oxygen demand, total Kjeldhal nitrogen, total phosphorus) was measured over time, and the final yield of OA was studied in relation to prokaryotic community composition. Results showed that digestion of faecal waste with a high crude-protein-to-carbohydrate ratio leads to an increased amount of OA which is greatly dominated by acetate. Among them, SSM faeces exhibited the highest final OA yield, resulting from a continuous increase over time. Despite variations in OA quantity and profile, prokaryotic composition did not substantially differ among treatments at the end of the trial, with only the relative abundance of three genera varying significantly (Anaerostignum, Bythopirellula, Mycobacterium). Yet, lactate concentration positively correlated with several taxa (Trichococcus, Oleispira, Defluviitaleaceae, Anaerocolumna, and Carboxyliverga) and butyrate with Anaerostignum. Alongside, ammonia release was minimal for all treatments, while phosphorus dissolution did not correlate to the faecal phosphorus content but was rather a result of acidification due to OA production. Overall, considering that an optimal carbon source for denitrification should produce a high amount of end OAs (i.e. acetate) along with low dissolved nitrogen and phosphorus, this research suggests that faecal waste originating from certain carbohydrate-rich aquafeed ingredients can be suitable as internal carbon source for denitrification.

Effect of external acetate added in aquaculture wastewater on mixotrophic cultivation of microalgae, nutrient removal, and membrane contamination in a membrane photobioreactor

The mixotrophic cultivation of microalgae in wastewater has attracted extensive attention due to its many advantages. In this study, acetate, which can be prepared by hydrolysis of aquaculture waste, was used as exogenous organic matter to promote the growth of Chlorella pyrenoidosa cultured in aquaculture wastewater. Microalgae cultivation was carried out in a membrane photobioreactor (MPBR) with continuous inflow and outflow mode. The results showed that exogenous acetate greatly promoted the mixotrophic growth of C. pyrenoidosa. When the dosage of acetate reached 1.0 g L-1, the relative growth rate of microalgae in the logarithmic stage reached 0.31 d-1, which was 4.4 times that of the control. As a result, exogenous acetate also promoted the removal of nutrients from aquaculture wastewater. During the stable operation stage of the MPBR with acetate added in the influent, an average of 87.41%-93.93% nitrogen and 76.34%-88.55% phosphorus was removed from the aquaculture wastewater containing 19.41 mg L-1 total inorganic nitrogen and 1.31 mg L-1 total inorganic phosphorus. However, it was worth noting that adding exogenous acetate also led to an increase in the membrane resistance of the membrane module in the MPBR. Membrane resistance was mainly composed of internal resistance (Ri) and cake resistance (Rc), and with the increase of acetate content in the influent, their proportion in the total resistance gradually increased. Ri contributed the major membrane resistance and was most affected by acetate dosage. Ri reached 32.04 × 1012 m-1 with 1 g L-1 acetate, which accounted for 69.49% of total resistance. Moreover, with the increase of influent acetate concentration of the MPBRs, both the number of insoluble contaminants and dissolved organic contaminants in the membrane modules increased. In addition, the composition of proteins, polysaccharides, and humus in dissolved organic contaminants was close to that in extracellular polymeric substances and soluble microbial products secreted by microalgae. These results suggested that the membrane fouling of membrane modules was closely related to the algal biomass content in the MPBRs. The above results provided a theoretical basis for reducing membrane fouling of MPBR.

A collaborative effect of solid-phase denitrification and algae on secondary effluent purification

This study explored the collaborative effect on nutrients removal performance and microbial community in solid-phase denitrification based bacteria-algae symbiosis system. Three biodegradable carriers (apple wood, poplar wood and corncob) and two algae species (Chlorella vulgaris and Chlorella pyrenoidosa) were selected in these bacteria-algae symbiosis systems. Results demonstrated that corncob as the carrier exhibited the highest average removal efficiencies of total nitrogen (83.7%-85.1%) and phosphorus removal (38.1%-49.1%) in comparison with apple wood (65.8%-71.5%, 25.5%-32.7%) and poplar wood (42.5%-49.1%, 14.2%-20.7%), which was mainly attributed to the highest organics availability of corncob. The addition of Chlorella acquired approximately 3%-5% of promotion rates for nitrated removal among three biodegradable carriers, but only corncob reactor acquired significant promotions by 3%-11% for phosphorous removal. Metagenomics sequencing analysis further indicated that Proteobacteria was the largest phylum in all wood reactors (77.1%-93.3%) and corncob reactor without Chlorella (85.8%), while Chlorobi became the most dominant phylum instead of Proteobacteria (20.5%-41.3%) in the corncob with addition of Chlorella vulgaris (54.5%) and Chlorella pyrenoidosa (76.3%). Thus, the higher organics availability stimulated the growth of algae, and promoted the performance of bacteria-algae symbiosis system based biodegradable carriers.

The research progress, hotspots, challenges and outlooks of solid-phase denitrification process

Nitrogen pollution is one of the main reasons for water eutrophication. The difficulty of nitrogen removal in low-carbon wastewater poses a huge potential threat to the ecological environment and human health. As a clean biological nitrogen removal process, solid-phase denitrification (SPD) was proposed for long-term operation of low-carbon wastewater. In this paper, the progress, hotspots, and challenges of the SPD process based on different solid carbon sources (SCSs) are reviewed. Compared with synthetic SCS and natural SCS, blended SCSs have more application potential and have achieved pilot-scale application. Differences in SCSs will lead to changes in the enrichment of hydrolytic microorganisms and hydrolytic genes, which indirectly affect denitrification performance. Moreover, the denitrification performance of the SPD process is also affected by the physical and chemical properties of SCSs, pH of wastewater, hydraulic retention time, filling ratio, and temperature. In addition, the strengthening of the SPD process is an inevitable trend. The strengthening measures including SCSs modification and coupled electrochemical technology are regarded as the current research hotspots. It is worth noting that the outbreak of the COVID-19 epidemic has led to the increase of disinfection by-products and antibiotics in wastewater, which makes the SPD process face challenges. Finally, this review proposes prospects to provide a theoretical basis for promoting the efficient application of the SPD process and coping with the challenge of the COVID-19 epidemic.

Impact of sulfamethoxazole and organic supplementation on mixotrophic denitrification process: Nitrate removal efficiency and the response of functional microbiota

Recirculating aquaculture systems (RAS) effluent is characterized by low COD to total inorganic nitrogen ratio (C/N), excessive nitrate, and the presence of traces of antibiotics. Hence, it urgently needs to be treated before recycling or discharging. In this study, four denitrification bioreactors at increasing C/N ratios (0, 0.7, 2, and 5) were started up to treat mariculture wastewater under the sulfamethoxazole (SMX) stress, during which the bioreactors performance and the shift of mixotrophic microbial communities were explored. The result showed that during the SMX exposure, organic supplementation enhanced nitrate and thiosulfate removal, and eliminated nitrite accumulation. The denitrification rate was accelerated by increasing C/N from 0 to 2, while it declined at C/N of 5. The decline was ascribed to which SMX reduced the relative abundance of denitrifiers, but improved the capability of dissimilatory nitrogen reduction to ammonia (DNRA) and sulfide production. The direct evidence was the relative abundance of sulfidogenic populations, such as Desulfuromusa, Desulfurocapsa, and Desulfobacter increased under the SMX stress. Moreover, high SMX (1.5 mg L^-1) caused the obvious accumulation of ammonia at C/N of 5 due to the high concentration of sulfide (3.54 ± 1.08 mM) and the enhanced DNRA process. This study concluded that the mixotrophic denitrification process with the C/N of 0.7 presented the best performance in nitrate and sulfur removal and indicated the maximum resistance to SMX.

The Control Strategy and Kinetics of VFAs Production in an ASBR Reactor Treating Low-Strength Mariculture Wastewater

As an environment-friendly wastewater treatment process, the anaerobic fermentation process has been widely used for the pretreatment of high-strength wastewater. However, it is rarely applied to treat low-strength wastewater due to low methane recovery. In this study, anaerobic fermentation treating low-strength mariculture wastewater was studied in an anaerobic sequencing batch reactor (ASBR) with a COD removal rate of 75%. Anaerobic fermentation was successfully controlled at the acidification stage by increasing COD loading. As the greenhouse gas emission decreased, the residual organics were enough for biological nutrients’ removal. Fluorescence in situ hybridization results showed that the dominant bacteria in the ASBR were acidogenic bacteria and methanogens, accounting for 39.7% and 46.5% of the total bacteria, respectively. Through the calculation processing of the experimental data, the order of the anaerobic fermentation reaction was a second-order reaction. The kinetic parameters of low-strength organic wastewater treatment were determined by using the Grau second-order substrate removal model, Stover–Kincannon model, Monod model and Haldane model. The maximum rate removal constant U_max, sludge yield coefficient Y and inhibition constant K_i were 1.157 g/(L·d), 0.153 mgVSS/mgCOD and 670 mg/L, respectively. It provided data support for the practical application of the anaerobic fermentation treating low-strength wastewater.

An Eco-Friendly Conversion of Aquaculture Suspended Solid Wastes Into High-Quality Fish Food by Improving Poly-β-Hydroxybutyrate Production

The aquaculture industry is vital in providing a valuable protein food source for humans, but generates a huge amount of solid and dissolved wastes that pose great risks to the environment and aquaculture sustainability. Suspended solids (in short SS), one of the aquaculture wastes, are very difficult to be treated due to their high organic contents. The bioconversion from wastewater, food effluents, and activated sludge into poly-β-hydroxybutyrate (PHB) is a sustainable alternative to generate an additional income and could be highly attractive to the agricultural and environmental management firms. However, little is known about its potential application in aquaculture wastes. In the present study, we first determined that 7.2% of SS was PHB. Then, the production of PHB was increased two-fold by the optimal fermentation conditions of wheat bran and microbial cocktails at a C/N ratio of 12. Also, the PHB-enriched SS showed a higher total ammonia nitrogen removal rate. Importantly, we further demonstrated that the PHB-enriched SS as a feed could promote fish growth and up-regulate the expression of the immune-related genes. Our study developed an eco-friendly and simple approach to transforming problematic SS wastes into PHB-enriched high-quality food for omnivorous fish, which will increase the usage efficiency of SS and provide a cheaper diet for aquatic animals.

Thermophilic bacteria combined with alkyl polyglucose pretreated mariculture solid wastes using as denitrification carbon source for marine recirculating aquaculture wastewater treatment

In marine recirculating aquaculture systems (RAS), efficient nitrogen removal is challenging due to the high NO₃^--N concentration, low organic matters content, and high salinity. In this study, mariculture solid wastes (MSW) acidogenic liquid pretreated by thermophilic bacteria (TB) combined with alkyl polyglucose (APG) was first used as carbon source for denitrification to remove NO₃^--N. TB + APG pretreatment could accelerate the hydrolysis of MSW, and the highest volatile fatty acids (VFAs) yield (40.3%) was obtained with TB + 0.2 g/g VSS APG pretreatment. MSW acidogenic liquid pretreated by TB + 0.2 g/g VSS APG was a reliable carbon source for denitrification, and the optimum COD/NO₃^--N ratio (C/N) was 8 with no residue of NO_x^--N. VFAs were more effectively utilized by denitrifiers than carbohydrate and protein. The high denitrification potential (P_DN) and denitrification rate (V_DN) indicated the higher denitrification ability at C/N of 8 using MSW acidogenic liquid as carbon source. The outcomes of this work could provide useful information for promoting technological innovation in marine RAS wastewater treatment.

Mariculture wastewater treatment with Bacterial-Algal Coupling System (BACS): Effect of light intensity on microalgal biomass production and nutrient removal

Mariculture wastewater generated from the mariculture industry has increased public concern due to its impact on the sustainability of aquatic environments and aquaculture practices. Herein, the Bacterial-Algal Coupling System was applied for mariculture wastewater treatment. Microalgae growth in heterotrophy and mixotrophy (2000-8000 lux) was first compared. The best microalgal growth and nutrient removal were obtained at 5000 lux, where biomass productivity of microalgae was 0.465 g L^-1 d^-1, and 98.1% of chemical oxygen demand, 70.7% of ammonia-nitrogen, and 90.0% of total phosphorus were removed. To further understand the nutrient removal through microalgae cultivation, the enzyme activities involved in the Calvin cycle and the Tricarboxylic Acid cycle at different light intensities were determined. Under mixotrophic cultivation, there was a coordination between photosynthesis and heterotrophic metabolism in the agal cell, which resulted in a high algal biomass production and removal efficiency of nutrients. This study provided a novel insight into the bioremediation of mariculture wastewater and microalgae cultivation.

Aquaculture industry: Supply and demand, best practices, effluent and its current issues and treatment technology

The aquaculture industry has become increasingly important and is rapidly growing in terms of providing a protein food source for human consumption. With the increase in the global population, demand for aquaculture is high and is estimated to reach 62% of the total global production by 2030. In 2018, it was reported that the demand for aquaculture was 46% of the total production, and with the current positive trends, it may be possible to increase tremendously in the coming years. China is still one of the main players in global aquaculture production. Due to high demand, aquaculture production generates large volumes of effluent, posing a great danger to the environment. Aquaculture effluent comprises solid waste and dissolved constituents, including nutrients and contaminants of emerging concern, thereby bringing detrimental impacts such as eutrophication, chemical toxicity, and food insecurity. Waste can be removed through culture systems, constructed wetlands, biofloc, and other treatment technologies. Some methods have the potential to be applied as zero-waste discharge treatment. Thus, this article analyses the supply and demand for aquaculture products, the best practices adopted in the aquaculture industry, effluent characteristics, current issues, and effluent treatment technology.

Heterotrophic nitrification-aerobic denitrification characteristics and antibiotic resistance of two bacterial consortia from Marinomonas and Halomonas with effective nitrogen removal in mariculture wastewater

Heterotrophic nitrification-aerobic denitrification (HNAD) characteristics and antibiotic resistance of two bacterial consortia, Marinomonas communis & Halomonas titanicae (MCH) and Marinomonas aquimarina & Halomonas titanicae (MAH), and their single isolates (MC, MA, and H) were determinated in this study. When cultured in sole and mixed N-source media (NH₄⁺-N and/or NO₂^--N of 10 mg/L), MCH and MAH exhibited greater efficiency and stability of inorganic-N removal than single isolates, and these strains preferred to remove NH₄⁺-N by simultaneous HNAD in mixed N-source media. Meanwhile, 45%-70% of NH₄⁺-N and/or NO₂^--N was mainly converted to organic nitrogen (15%-25%) and gaseous nitrogen (30%-40%) by these strains, and more inorganic-N was transformed to intracellular-N by MCH and MAH via assimilation instead of gaseous-N production by denitrification. Both isolates and their consortia had the maximal NH₄⁺-N or NO₂^--N removal efficiency above 95% under the optimum conditions including temperature of 20-30 °C, C/N ratios of 15-20, and sucrose as carbon source. Interestingly, bacterial consortia performed greater nitrogen removal than single isolates under the low temperature of 10 °C or C/N ratios of 2-5. In real mariculture wastewater, MCH and MAH also showed higher NH₄⁺-N removal efficiency (65%-68%) and more stable cell quantity (4.2-5.2 × 10⁸ CFU/mL) than single strains, due to the interspecific coexistence detected by bacterial quantitation with indirect immunoassay. Additionally, these isolates and consortia had stronger resistances to polypeptides, tetracyclines, sulfonamides, furanes, and macrolides than other antibiotics. These findings will be conducive to the applications of HNAD bacteria of Marinomonas and Halomonas on reducing nitrogen pollution in mariculture or other saline environments.