Synergistic effect and supernatant nitrogen reduction from anaerobic co-digestion of sewage sludge and pig manure

Analysis of biogas production from sewage sludge combining BMP experimental assays and the ADM1 model

The Anaerobic Digestion Model No. 1 (ADM1) was employed to simulate methane (CH4) production in an anaerobic reactor (AR), and the associated bench-scale biochemical methane potential (BMP) assay, having sewage sludge (SWS) from a municipal wastewater treatment plant (WWTP) as feedstock. The SWS presented the following physical-chemical characteristics: pH (7.4-7.6), alkalinity (2,382 ± 100 mg CaCO3 L-1), tCOD (21,903 ± 1,000 mg L-1), TOC (895 ± 100 mg L-1), TS, TVS, and VSS (2.0%, 1.1%, and 0.8%, respectively). The BMP assay was conducted in six replicates under anaerobic mesophilic conditions (37 ± 0.1°C) for 11 days with a CH4 yield registered of 137.6 ± 6.39 NmL CH4 or 124 ± 6.72 CH4 g-1 VS-1. When the results obtained with the BMP bench-scale reactors were compared to the output generated with computational data by the ADM1 model having as input data the same initial sewage tCOD, similar cumulative CH4 production curves were obtained, indicating the accuracy of the ADM1 model. This approach allowed the characterization of the sludge and estimation of its biogas production potential. The combination of BMP assays, experimental data, and ADM1 model simulations provided a framework for studying anaerobic digestion (AD) processes.

Evaluation of potential feedstock for biogas production via anaerobic digestion in Malaysia: kinetic studies and economics analysis

As the population increases, energy demands continue to rise rapidly. In order to satisfy this increasing energy demand, biogas offers a potential alternative. Biogas is economically viable to be produced through anaerobic digestion (AD) from various biomass feedstocks that are readily available in Malaysia, such as food waste (FW), palm oil mill effluent (POME), garden waste (GW), landfill, sewage sludge (SS) and animal manure. This paper aims to determine the potential feedstocks for biogas production via AD based on their characteristics, methane yield, kinetic studies and economic analysis. POME and FW show the highest methane yield with biogas yields up to 0.50 L/g VS while the lowest is 0.12 L/g VS by landfill leachate. Kinetic study shows that modified Gompertz model fits most of the feedstock with R 2 up to 1 indicating that this model can be used for estimating treatment efficiencies of full-scale reactors and performing scale-up analysis. The economic analysis shows that POME has the shortest payback period (PBP), highest internal rate of return (IRR) and net present value (NPV). However, it has already been well explored, with 93% of biogas plants in Malaysia using POME as feedstock. The FW generation rate in Malaysia is approximately 15,000 tonnes per day, at the same time FW as the second place shows potential to have a PBP of 5.4 years and 13.3% IRR, which is close to the results achieved with POME. This makes FW suitable to be used as the feedstock for biogas production.

Impact of biochar supported nano zero-valent iron on anaerobic co-digestion of sewage sludge and food waste: Methane production, performance stability and microbial community structure

This work evaluates the effects of biochar supported nano zero-valent iron (nZVI-BC) on anaerobic co-digestion (co-AD) of sewage sludge and food waste. Kinetic model analysis suggested that nZVI-BC addition significantly increased the methane production potential (R₀) and daily methane production rate (G_m) by 42.87% and 49.87%, while the raw biochar only increased R₀ and G_m by 5.11% and 6.73%, respectively. Supplementation of higher concentrations of nZVI-BC was not preferable as inhibition of methane productivity was appeared. nZVI-BC addition remarkably improved organics degradation efficiency, as the reduction rate of TCOD, VSS and TSS were increased by 34.93%, 11.44% and 13.96%, respectively. The microbial analysis demonstrated that nZVI-BC facilitated the growth of hydrogentrophic methanogens, while acetotrophic methanogens which can only use acetate as electron donor were restrained. The study demonstrated nZVI-BC can effectively strengthen methanogenesis mainly through the enhancement of DIET between bacteria and methanogens, and the enrichment of hydrogenotrophic methanogens.

The Influence of Co-Fermentation of Agri-Food Waste with Primary Sludge on Biogas Production and Composition of the Liquid Fraction of Digestate

Energy self-sufficiency is a current trend in wastewater treatment plants. This effect can be achieved by increasing the production of electricity from biogas and by reducing energy consumption for technological processes. One idea, in line with the circular economy concept, is the use of waste rich in organic matter as co-substrates for the fermentation process. The aim of this study was to determine the effect of waste co-fermentation on biogas production and nitrogen concentration in the reject water. A co-fermentation process with flotate or flotate and vegetables increased biogas production compared to primary sludge by 162 and 180%, respectively. During the tests, there was no inhibition of the fermentation process. Hydrolysis of organic compounds contained in flotate and vegetables resulted in a significant increase in ammonium nitrogen (by 80–100%) and dissolved organic nitrogen concentration (by 170–180%). The biogas and methane production rate as well as the ammonium and total nitrogen release rate were calculated. An energy balance was made, which took into account the variable amount of electric energy production depending on the efficiency of the cogeneration systems and energy consumption for supplying oxygen necessary to remove nitrogen contained in the reject water. A positive energy balance was obtained for all analyses.