Recovered granular sludge extracellular polymeric substances as carrier for bioaugmentation of granular sludge reactor

Unraveling the mechanism of fouling mitigation in AGS-MBR system: From AGS properties to foulant interactions

Aerobic granular sludge (AGS) has demonstrated a lower fouling propensity than floc sludge in membrane bioreactors (MBRs) due to various hypotheses, including differences in particle size and the efficacy of physical scouring. However, controversy exists regarding the dominant cause of this lower fouling. Therefore, in this work, we systematically investigated the contribution of four potential mechanisms of AGS on membrane fouling alleviation in MBRs: 1) loosening cake layer; 2) scouring of the membrane surface; 3) regulating soluble microbial product (SMP) secretion; and 4) changing the rheology of the bulk solution. Our results showed that, regardless of granular size range, AGS hardly caused cake fouling due to its low hydraulic resistances (<0.8 × 1012 m-1) and limited accumulation on the membrane surface. Scouring by AGS was ineffective in reducing the thickness and hydraulic resistance of the fouling layer compared with granular activated carbon, a commonly used scouring material for MBRs. Furthermore, liquid chromatography-organic carbon detection-organic nitrogen detection (LC-OCD-OND) results indicated that the lower fouling was related to reduced SMP secretion by AGS, with an optimal particle size (800-1000 μm) at which SMP secretion was minimized. AGS with this optimal particle size secreted over 54 % less high-molecular-weight SMP compared to floc sludge. As granule size further increased, SMP secretion increased due to biomass decay and cell lysis resulting from substrate transfer limitations in granules. Moreover, compared to floc sludge, granular sludge bulk solution exhibited lower viscosity, particularly in the 450-1000 μm size range. This enhanced rheological behavior could potentially improve shear stress induced by aeration, thereby mitigating membrane fouling. These findings emphasize that the indirect effects of AGS, including reduced SMP secretion and improved rheological properties, played a crucial role in the lower membrane fouling in AGS-MBRs, while direct effects such as loosening cake layer and the scouring effect played minor roles.

A novel strategy for waste activated sludge treatment: Recovery of structural extracellular polymeric substances and fermentative production of volatile fatty acids

Structural extracellular polymeric substances (SEPS) as valuable biopolymers, can be extracted from waste activated sludge (WAS). However, the extraction yield is typically low, and detailed information on SEPS characterizations, as well as proper treatment of the sludge after SEPS extraction, remains limited. This study aimed to optimize the conditions of heating-Na2CO3 extraction process to increase the yield of SEPS extracted from WAS. Subsequently, SEPS were characterized, and, for the first time, insights into their protein composition were uncovered by using proteomics. A maximum SEPS yield of 209 mg g-1 volatile solid (VS) was obtained under optimal conditions: temperature of 90 °C, heating time of 60 min, Na+ dosage of 8.0 mmol/g VS, and pH required to precipitation of 4.0, which was comparable to that from the aerobic granular sludge reported in literature. Proteomics analysis unveiled that the proteins in SEPS primarily originated from microorganisms involved in nitrogen fixation and organic matter degradation, including their intracellular and membrane-associated regions. These proteins exhibited various catalytic activities and played crucial roles in aggregation processes. Besides, the process of SEPS extraction significantly enhanced volatile fatty acid (VFA) production during the anaerobic fermentation of residual WAS after SEPS extraction. A maximum VFA yield of 420 ± 14 mg COD/g VSadded was observed in anaerobic fermentation of 10 d, which was 77.2 ± 0.1 % higher than that from raw sludge. Mechanism analysis revealed that SEPS extraction not only improved WAS disintegration and solubilization but also reduced the relative activity of methanogens during anaerobic fermentation. Moreover, SEPS extraction shifted the microbial population during anaerobic fermentation in the direction towards hydrolysis and acidification such as Fermentimonas sp. and Soehngenia sp. This study proposed a novel strategy based on SEPS extraction and VFA production for sludge treatment, offering potential benefits for resource recovery and improved process efficiency.

Influences of extracellular polymeric substances (EPS) recovered from waste sludge on the ability of Jiaozhou Bay to self-remediate of diesel-polluted seawater

The introduction of EPS recovered from waste sludge may have an impact on the process of microbial remediation of oil-contaminated seawater. This study investigated the effect of EPS on the self-remediation capacity of diesel-polluted seawater in Jiaozhou Bay. Hydrocarbon attenuation and microbial activity were monitored in seawater collected from five islands after diesel and N, P addition, with and without EPS, incubated under aerobic conditions. Compared to seawater without EPS, degradation of TPH (total petroleum hydrocarbon) doubled and improved degradation of non-volatile (C16-C24) hydrocarbons to some extent in EPS-added seawater. The introduction of EPS led to changes in microbiota richness and diversity, significantly stimulating the growth of Proteobacteria and Firmicutes phyla or Bacillus and Pseudomonas genera. RT-qPCR analysis indicated EPS caused higher increases in cytochrome P450 gene copies than alkB. Prediction of alkane decay genes from 16S rRNA sequencing data revealed that EPS addition obviously promoted genes related to ethanol dehydrogenation function in the microbial community. Additionally, EPS enhanced the enzymatic activities of alkane hydroxylase, ethanol dehydrogenase, phosphatase and lipase, but increased protease and catalase inconspicuously. The above outlook that environmental sustainability of EPS from waste sludge for diesel-contaminated seawater remediation may provide new perspectives for oil spill bioremediation.

Biochar facilitates ferrihydrite reduction by Shewanella oneidensis MR-1 through stimulating the secretion of extracellular polymeric substances

Biochar can mediate extracellular electron transfer (EET) of Shewanella oneidensis MR-1 and subsequently facilitate dissimilatory reduction of iron(III) minerals. Previous studies mainly focused on the interaction of biochar and membrane cytochrome complexes to reveal the mediating mechanisms between biochar and S. oneidensis MR-1. However, the influence of biochar on the production and activity of extracellular polymeric substances (EPS) has long been neglected, despite the fact that EPS are commonly exudated by S. oneidensis MR-1 and can participate in a variety of electron transfer processes due to their redox activity. Here, we performed a series of microbial ferrihydrite reduction experiments in combination with electrochemical voltametric and impedance analyses to investigate the role of biochar in the formation and transformation of cell EPS during EET. Results showed that the added biochar not only functioned as an electron shuttle facilitating electron transfer, but also induced the secretion of five times more EPS by S. oneidensis MR-1, leading to a 1.4-fold faster ferrihydrite reduction in comparison with biochar-free setups. We further extracted the secreted EPS and found that the proportion of redox-active exoproteins was significantly (p < 0.05) increased in the EPS and resulted in a higher electron exchange capacity in secreted EPS. Such increased exoprotein content also induced a higher ratio of exoprotein to exopolysaccharide, which largely dropped diffusion and electron transfer impedance of EPS to 1.1 and 18 Ω, respectively, and accelerated the EET and thus the ferrihydrite reduction. Overall, our findings revealed the interactions between biochar and EPS matrices, which could potentially play a critical role in EET processes in both environmental or biotechnological systems.

An overview of deploying membrane bioreactors in saline wastewater treatment from perspectives of microbial and treatment performance

The discharged saline wastewater has severely influenced the aquatic environment as the treatment performance of many wastewater treatment techniques is limited. In addition, the sources of saline wastewater are also plentiful from agricultural and various industrial fields such as food processing, tannery, pharmaceutical, etc. Although high salinity levels negatively impact the performance of both physicochemical and biological processes, membrane bioreactor (MBR) processes are considered as a potential technology to treat saline wastewater under different salinity levels depending on the adaption of the microbial community. Therefore, this study aims to systematically review the application of MBR widely used in the saline wastewater treatment from the perspectives of microbial structure and treatment efficiencies. At last, the concept of carbon dioxide capture and storage will be proposed for the MBR-treating saline wastewater technologies and considered toward the circular economy with the target of zero emission.