Cereal bran protects vitamin A from degradation during simmering and storage

Vitamin A stability during storage of fortified gari produced using different fortification strategies

Food fortification is an effective strategy to combat vitamin A deficiency. Gari, a cassava-based West African food product, is an interesting product to fortify with vitamin A, but the low stability of vitamin A poses a challenge. We showed that toasted wheat bran can stabilise vitamin A as retinyl palmitate (RP) during storage of RP-fortified gari to a limited extent. After four weeks of accelerated storage, the RP retention of gari with toasted wheat bran was 34 ± 9% whereas this was only 19.4 ± 0.3% for gari without bran. When comparing different fortification strategies, including RP addition, red palm oil addition and the use of yellow cassava, red palm oil addition was shown the most promising strategy. After eight weeks of accelerated storage, the vitamin A retention was more than four times higher for red palm oil-fortified gari (22.6 ± 0.1%) than for the two other fortification strategies.

Natural Pigments Recovery from Food By-Products: Health Benefits towards the Food Industry

Given the health risks associated with synthetic colorants, natural pigments have emerged as a promising alternative. These renewable choices not only provide health benefits but also offer valuable technical and sensory properties to food systems. The effective application of natural colorants, however, requires the optimization of processing conditions, exploration of new sources, and development of novel formulations to ensure stability and maintain their inherent qualities. Several natural pigment sources have been explored to achieve the broad color range desired by consumers. The purpose of this review is to explore the current advances in the obtention and utilization of natural pigments derived from by-products, which possess health-enhancing properties and are extracted through environmentally friendly methods. Moreover, this review provides new insights into the extraction processes, applications, and bioactivities of different types of pigments.

Mechanistic understanding of the stabilisation of vitamin A in oil by wheat bran: The interplay between vitamin A degradation, lipid oxidation, and lipase activity

Wheat bran stabilises vitamin A (retinyl palmitate, RP) in oil during storage, but the stabilisation mechanism remains unknown. We here studied the effect of the concentration of RP in oil (0.1-2%) and of RP-enriched oil in the system (5-50%) on the RP retention during accelerated storage of systems with native and toasted wheat bran. Generally, toasted bran showed better RP stabilisation than native bran. After four weeks of storage, up to 65% RP was retained in toasted bran systems, whereas the RP retention for native bran was below 10%. For native bran, a higher oil-to-bran ratio and, thus, a lower wheat lipase level resulted in better RP retention. For toasted bran, combined high oil and high RP concentrations resulted in the lowest RP retention. We, therefore, conclude that wheat bran protects RP and lipids from oxidation. This protection is reduced by the pro-oxidative effect of RP, lipid oxidation and lipase.

Conversion of Retinyl Palmitate to Retinol by Wheat Bran Endogenous Lipase Reduces Vitamin A Stability

Wheat bran can be used as a cost-effective food ingredient to stabilise vitamin A. However, wheat bran endogenous enzymes have been shown to reduce vitamin A stability. In this study, we elucidated the mechanism for this negative effect in an accelerated storage experiment with model systems consisting of native or toasted wheat bran, soy oil and retinyl palmitate (RP). Both native and toasted wheat bran substantially stabilised RP. While RP was entirely degraded after ten days of storage in the absence of wheat bran, the RP retention after ten days was 22 ± 2% and 75 ± 5% in the presence of native and toasted bran, respectively. The significantly stronger stabilising effect of toasted bran was attributed to the absence of bran endogenous enzymes. In contrast to toasted bran systems, noticeable free fatty acid production was observed for native bran systems. However, this did not result in a pronounced lipid oxidation. Next to lipid hydrolysis, wheat bran lipase was shown to hydrolyse retinyl esters to the less stable retinol and fatty acids. This reaction could explain the major part, about 66 ± 5%, of the difference in RP stabilisation between native and toasted wheat bran.

Super-Antioxidant Vitamin A Derivatives with Improved Stability and Efficacy Using Skin-Permeable Chitosan Nanocapsules

Retinyl palmitate (RP) is a retinol ester with strong antioxidant and anti-inflammatory properties as an antiwrinkle agent. However, it has poor aqueous solubility and easily degrades into inactive forms for topical applications. Therefore, we developed chitosan-coated nanocapsules (ChiNCs) to encapsulate RP using a simple nanoprecipitation method for protection against physiological conditions and to enable deep skin penetration. The as-prepared RP-loaded nanocapsules (RP@ChiNCs) loaded with approximately 5 wt.% RP exhibited a hydrodynamic diameter of 86 nm and surface charge of 24 mV. They had adequate stability to maintain their physicochemical properties after lyophilization in a biological buffer. Notably, ChiNCs provided RP with remarkable protection against degradation for 4 weeks at 37 °C. Thus, RP@ChiNCs exhibited good antioxidant activity in situ for sufficiently long periods without considerable changes in their efficacy. Furthermore, ChiNCs enhanced the skin penetration of lipophilic RP based on the inherent nature of chitosan. RP@ChiNCs exhibited good in vitro antioxidant and anti-inflammatory effects without causing any cytotoxicity in dermal fibroblasts. Accordingly, they promoted cell proliferation in a wound-scratch test and enhanced collagen synthesis. These results suggest that RP@ChiNCs are promising candidates for cosmetic and biomedical applications.

Stabilization of Vitamin A by Cereal Bran: The Importance of the Balance between Antioxidants, Pro-oxidants, and Oxidation-Sensitive Components

This study investigated the contribution of bran antioxidants and lipids to the stabilizing effect of cereal bran on vitamin A during accelerated storage. Hereto, wheat and rice bran samples subjected to a sequential extraction process were used. Vitamin A stabilization was more pronounced for wheat compared to rice bran. This was attributed to the higher antioxidant capacity and lower degree of lipid oxidation of wheat compared to rice bran. Removal of the chloroform/methanol-extractable fraction resulted in a substantial decrease in vitamin A retention from 78 to 26% for wheat bran and from 30 to 0% for rice bran after 2 weeks of accelerated storage. However, the vitamin A-stabilizing effect could not be attributed to specific components. The ability of cereal bran to stabilize vitamin A is therefore believed to be determined by the balance of antioxidants, pro-oxidants, and oxidation-sensitive components in the system.

Influence of Pre-Treatment and Drying Methods on the Quality of Dried Carrot Properties as Snacks

The aim of the current research was to evaluate the effect of pre-treatment and drying methods on the properties of dried carrots. Carrots were blanched (B) (1 or 3 min) or osmotic dehydrated (OD) (15 or 30 min) and dried by either convection (CD), microwave-convection (MW-CD), microwave-vacuum (MVD), or freeze-drying (FD). FD carrots showed the highest dry matter content (93.6-95.8%) and the lowest water activity (0.24-0.38). MVD carrots had lower dry matter content (79.5-95.8%) and two times more water activity (0.447-0.637) than FD. The highest color difference (∆E) in relation to raw material was noted in MVD samples (22-35) and the smallest in CD and FD (7-18), mainly due to the increase in brightness of the dried carrot. In general dried MCD carrot samples were characterized by the highest max force (hardness) (21.6-42.5 N; on average 34.7 N) in the breaking test and the lowest hardness was observed in the CD (10.8 N) ones. Pre-treatment and drying caused a significant decrease in the content of carotenoids (2.0-2.7 times) and chlorophyll (2.7-4.5 times) compared to the fresh carrot but a retention or increase in the total content of phenolics and antioxidant activity, especially in microwave-vacuum-dried carrots with an increase of even 2.7-2.9 times compared to raw material. High phenolic content (195.6-277.4 mg GA/100 g d.m.) was found in pre-osmotic dehydrated samples, and lower phenolic content was found in blanched samples (110.7-189.6 mg GA/100 g d.m.). Significantly, the highest average antioxidant activity was found in microwave-vacuum-dried samples (228.9 µmol Trolox/100 g d.m.). The results of this study indicate that microwave-vacuum-drying as an alternative to freeze-drying, including in combination with thermal or osmotic treatment, is very promising for the production of dried carrot snacks.

Stabilisation of vitamin A by wheat bran is affected by wheat bran antioxidants, bound lipids and endogenous lipase activity

Food fortification is an efficient strategy to combat vitamin A deficiency. However, the stability of vitamin A during storage is low. Cereal bran can be used as a natural and affordable stabilising agent, but the mechanism behind this stabilisation remains unclear. To unravel this mechanism, vitamin A stabilisation was studied during an accelerated storage experiment (60 °C, 70% relative humidity) using a set of 30 in-house modified wheat bran samples. The characteristics of these samples were linked to vitamin A stabilisation during storage using forward regression modelling. While all wheat bran samples could stabilise vitamin A to a significant extent, the stabilising effect was more pronounced for samples with a high antioxidant capacity, high bound lipid content and low lipase activity. The main effect of lipase activity was more than thrice as large as the main effects of antioxidant capacity and bound lipid content. These results suggest that wheat bran antioxidants and bound lipids protect vitamin A from degradation during storage, while endogenous lipase activity counteracts the stabilising effect. Based on these findings, modified wheat bran mixed with vitamin A can be a cost-effective and healthy aid in food fortification by providing high vitamin A stability.

Effect of rice bran protein concentrate as wall material adjunct on selected physicochemical and release properties of microencapsulated β-carotene

Rice bran protein is an emerging protein source from rice milling that possesses health benefits and emulsifying capacity suitable for hypoallergenic encapsulation applications, especially for lipophilic compounds such as β-carotene. The purpose of this study is to develop and characterize β-carotene encapsulates with maltodextrin and rice bran protein. Rice bran protein was prepared using conventional alkali extraction. β-carotene was added to the composite wall materials (50:50 of 4%, 8%, 12%, and 16% solids content) and spray-dried. Encapsulation efficiency (85-98%) and radical scavenging activity (11-43%) varied proportionally with rice bran protein. Across increasing maltodextrin and rice bran protein content of the feed, carbohydrate content of the microcapsules varied proportionally (50-66%) but protein content was uniform (10-13%). Scanning electron microscopy, differential scanning calorimetry, and Fourier transform infrared spectroscopy data suggested successful encapsulation. Release profiles showed decreasing trend with increasing rice bran protein content; co-digestion with rice mitigated negative impacts of rice bran protein. Microcapsules with nutritive potential and health-promoting properties were developed as potential carotenoid delivery systems.

Normal-Phase HPLC-ELSD to Compare Lipid Profiles of Different Wheat Flours

Normal-phase high-performance liquid chromatography (HPLC) is widely used in combination with evaporative light scattering detection (ELSD) for separating and detecting lipids in various food samples. ELSD responses of different lipids were evaluated to elucidate the possibilities and challenges associated with quantification by means of HPLC-ELSD. Not only the number and type of polar functional groups but also the chain length and degree of unsaturation of (free or esterified) fatty acids (FAs) had a significant effect on ELSD responses. Tripalmitin and trilinolein yielded notably different ELSD responses, even if their constituting free FAs produced identical responses. How FA structure impacts ELSD responses of free FAs is thus not predictive for those of triacylglycerols and presumably other lipids containing esterified FAs. Because ELSD responses of lipids depend on the identity of the (esterified) FA(s) which they contain, fully accurate lipid quantification with HPLC-ELSD is challenging and time-consuming. Nonetheless, HPLC-ELSD is a good and fast technique to semi-quantitatively compare the levels of different lipid classes between samples of comparable FA composition. In this way, lipid profiles of different flours from near-isogenic wheat lines could be compared.