Pectinase hydrolysis of guava pulp: effect on the physicochemical characteristics of its juice

Effect of Novel Processing Techniques on the Carotenoid Release during the Production of Red Guava Juice

Red guava, distinguished by its elevated lycopene content, emerges as a promising natural source of carotenoids. This study systematically evaluates the impact of diverse processing techniques on the efficient release of carotenoids. The primary objective is to facilitate the transfer of carotenoids into the juice fraction, yielding carotenoid-enriched juice seamlessly integrable into aqueous-based food matrices. The untreated guava puree exhibited a modest release of carotenoids, with only 66.26% of β-carotene and 57.08% of lycopene reaching the juice. Contrastly, both high-pressure homogenization (HPH) at 25 MPa and enzyme (EM) treatment significantly enhanced carotenoid release efficiency (p < 0.05), while high hydrostatic pressure (HHP) at 400 MPa and pulsed electric field (PEF) of 4 kV/cm did not (p > 0.05). Notably, HPH demonstrated the most substantial release effect, with β-carotene and lycopene reaching 90.78% and 73.85%, respectively. However, the stability of EM-treated samples was relatively poor, evident in a zeta-potential value of -6.51 mV observed in the juice. Correlation analysis highlighted the interactions between pectin and carotenoids likely a key factor influencing the stable dissolution or dispersion of carotenoids in the aqueous phase. The findings underscore HPH as a potent tool for obtaining carotenoid-enriched guava juice, positioning it as a desirable ingredient for clean-label foods.

Tunning pectinase activity under the effects of electric fields in the enhanced clarification of wine must

Introduction

Pectinolytic enzymes are of great importance for the clarification process of “Vinho Verde” wine must, contributing to the reduction of haze development. During the last decade, a growing body of knowledge has been established about the effects of electric fields on the activation of important food enzymes. However, the influence of electrical parameters on catalytic activity is enzyme-dependent and should be evaluated on a case-by-case basis. This work describes, for the first time, the effects of electric fields and electrical frequency on the activity of pectinase (PEC) in the accelerated clarification of “Vinho Verde” must.

Method

Moderate electric fields (MEF) with intensities below 20 V/cm and at electrical frequencies ranging from 50 to 20 kHz were applied at temperatures between 15 and 35°C. Enzymatic activity was measured for 25 min, and the initial rate of reaction was determined by the coefficient of the linear plot of galacturonic acid (GAL) production as a function of time.

Results

The results show that electrical frequency can increase enzymatic activity depending on temperature conditions; at 20°C and with electrical frequencies of 2 and 20 kHz, enzymatic activity increased by up to 40 and 20%, respectively, when compared with the control sample (without the application of MEF). Temperature dependence was evaluated through the Arrhenius equation, showing that energy of activation (Ea) can be reduced from 9.2 to 6.6 kJ/mol at sub-optimal temperatures for PEC activity when MEF is applied.

Discussion

Electrical parameters, when combined with temperatures below 20°C, reduced pectin concentration in “Vinho Verde” wine must by up to 42% of its initial content. This emergent treatment can be integrated in relevant environmental conditions, presenting an opportunity to increase enzyme efficiency even in low-temperature conditions, which favors the winemaking process.

Effects of Pectinase Pre-Treatment on the Physicochemical Properties, Bioactive Compounds, and Volatile Components of Juices from Different Cultivars of Guava

In this study, the physicochemical properties, antioxidant capacity, and volatile compounds of the juices of different guava cultivars before and after pectinase treatment were evaluated. The results showed that the guava juice of the small fragrant (SF) cultivar exhibited the highest ascorbic acid concentration (1761.09 mg/L), and the highest contents of total phenolics (329.52 mg GAE/L) and total flavonoids (411.13 mg RE/L) were both found in the juice of the watermelon red (WR) cultivar. After pectinase treatment, the juice yield and the titratable acid, sugar components, total phenolics and total flavonoids, and antioxidant capacity levels of the guava juices were all higher than those of the non-pectinase group. However, lower sensory evaluation scores were obtained in the pectinase-treated guava juices. Aldehydes and terpenoids were the main flavor components in the guava juices, which were responsible for the aroma of the juice, while their relative contents were different in the four cultivar guava juices. Furthermore, pectinase treatment could change the amounts and relative contents of volatile compounds in the guava juice. During the pectinase treatment process, the relative contents of the main aroma constituents in the guava juices were significantly decreased. The findings of this research provide valuable information for the processing of guava juice.

Enzymes-Assisted Extraction of Plants for Sustainable and Functional Applications

The scientific community and industrial companies have discovered significant enzyme applications to plant material. This rise imparts to changing consumers’ demands while searching for ‘clean label’ food products, boosting the immune system, uprising resistance to bacterial and fungal diseases, and climate change challenges. First, enzymes were used for enhancing production yield with mild and not hazardous applications. However, enzyme specificity, activity, plant origin and characteristics, ratio, and extraction conditions differ depending on the goal. As a result, researchers have gained interest in enzymes’ ability to cleave specific bonds of macroelements and release bioactive compounds by enhancing value and creating novel derivatives in plant extracts. The extract is enriched with reducing sugars, phenolic content, and peptides by disrupting lignocellulose and releasing compounds from the cell wall and cytosolic. Nonetheless, depolymerizing carbohydrates and using specific enzymes form and release various saccharides lengths. The latest studies show that oligosaccharides released and formed by enzymes have a high potential to be slowly digestible starches (SDS) and possibly be labeled as prebiotics. Additionally, they excel in new technological, organoleptic, and physicochemical properties. Released novel derivatives and phenolic compounds have a significant role in human and animal health and gut-microbiota interactions, affecting many metabolic pathways. The latest studies have contributed to enzyme-modified extracts and products used for functional, fermented products development and sustainable processes: in particular, nanocellulose, nanocrystals, nanoparticles green synthesis with drug delivery, wound healing, and antimicrobial properties. Even so, enzymes’ incorporation into processes has limitations and is regulated by national and international levels.

Effects of High-Pressure, Hydrothermal, and Enzyme-Assisted Treatment on the Taste and Flavor Profile of Water-Soluble Ginger (Zingiber officinale) Extract

Ginger, a plant widely consumed worldwide, is used as a spice or to enhance the flavor of foods. In this study, the taste characteristics (gingerol, shogaol, and amino acid) of extracts treated with various solubilizing methods were objectively compared. In addition, an E-nose confirmed the flavor pattern combined with principal component analysis (PCA) between each extract gas chromatogram-tandem mass spectrometry was performed to compare and analyze volatile compounds between extraction methods. As a result, high-pressure enzyme-assisted extraction (HPE) and hydrothermal enzyme-assisted extraction (HWE) treatment effectively improved the extraction yield of ginger and the contents of gingerol and shogaol and removed the bitter taste. In addition, radar charts of both E-nose and PCA provided the distribution of flavor substances in HPE and HWE products of ginger. After enzyme-assisted treatment, a strong fruity and piquant flavor was noted. In conclusion, it is suggested that ginger extract of enzyme-assisted treatment has increased flavor compounds and can be an excellent food material.