Application of a fluorescent dual stain to assess decontamination of tissue protein and prion amyloid from surgical stainless steel during simulated washer-disinfector cycles

Sensitive microscopic quantification of surface-bound prion infectivity for the assessment of surgical instrument decontamination procedures

BACKGROUND

Pathogenic prions (PrP^Sc) are amyloid-rich hydrophobic proteins which bind avidly to surgical surfaces and represent some of the most difficult targets during the reprocessing of reusable surgical instruments. In-vitro methods to amplify and detect the presence of otherwise undetectable prion contamination are available, but they do not measure associated infectivity. Most of these methods rely on the use of proteinase K, however this can lead to the loss of a substantial portion of PrP^Sc, potentially producing false negatives.

AIM

To develop a sensitive in-situ method without proteinase treatment for the dynamic quantification of amyloid accumulation in N2a #58 cells following 22L-prion infection from infected tissues and spiked stainless-steel surfaces.

METHODS

We spiked cultures of N2a #58 cells with the 22L prion strain in solution or dried on stainless-steel wires and directly measured the accumulation of prion amyloid aggregates over several passages using highly sensitive fluorescence microscopy.

FINDINGS

We demonstrated a 10-log dynamic range using our method to test residual prion infectivity, that was validated to show variable decontamination efficacy against prions from commercially available cleaning chemistries.

CONCLUSIONS

The new cell-based infectivity method presented here avoids partial or possibly total proteinase K digestion of PrP^Sc in samples for greater sensitivity, in addition to low cost, no ethical concerns, and adaptability to detect different prion strains. This method can be used to test cleaning chemistries' efficacy with greater sensitivity than measuring total residual proteins, which may not correlate with residual prion infectivity.

A cold water, ultrasonically activated stream efficiently removes proteins and prion-associated amyloid from surgical stainless steel

Background

Sterile service department decontamination procedures for surgical instruments struggle to demonstrate efficient removal of the hardiest infectious contaminants, such as prion proteins. A recently designed novel system, which uses a low pressure ultrasonically activated, cold water stream, has previously demonstrated efficient hard surface cleaning of several biological contaminants.

Aim

To test the efficacy of an ultrasonically activated stream for the removal of tissue proteins, including prion-associated amyloid, from surgical stainless steel surfaces.

Methods

Test surfaces were contaminated with 22L, ME7 or 263K prion-infected brain homogenates. The surfaces were treated with the ultrasonically activated water stream for contact times of 5 and 10 s. Residual proteinaceous and amyloid contamination were quantified using sensitive microscopic analysis, and immunoblotting was used to characterize the eluted prion residues before and after treatment with the ultrasonically activated stream.

Findings

Efficient removal of the different prion strains from the surgical stainless steel surfaces was observed, and reduced levels of protease-susceptible and -resistant prion protein was detected in recovered supernatant.

Conclusion

This study demonstrated that an ultrasonically activated stream has the potential to be a cost-effective solution to improve current decontamination practices and has the potential to reduce hospital-acquired infections.

Interventions to reduce the risk of surgically transmitted Creutzfeldt-Jakob disease: a cost-effective modelling review

BACKGROUND

Creutzfeldt-Jakob disease is a fatal neurological disease caused by abnormal infectious proteins called prions. Prions that are present on surgical instruments cannot be completely deactivated; therefore, patients who are subsequently operated on using these instruments may become infected. This can result in surgically transmitted Creutzfeldt-Jakob disease.

OBJECTIVE

To update literature reviews, consultation with experts and economic modelling published in 2006, and to provide the cost-effectiveness of strategies to reduce the risk of surgically transmitted Creutzfeldt-Jakob disease.

METHODS

Eight systematic reviews were undertaken for clinical parameters. One review of cost-effectiveness was undertaken. Electronic databases including MEDLINE and EMBASE were searched from 2005 to 2017. Expert elicitation sessions were undertaken. An advisory committee, convened by the National Institute for Health and Care Excellence to produce guidance, provided an additional source of information. A mathematical model was updated focusing on brain and posterior eye surgery and neuroendoscopy. The model simulated both patients and instrument sets. Assuming that there were potentially 15 cases of surgically transmitted Creutzfeldt-Jakob disease between 2005 and 2018, approximate Bayesian computation was used to obtain samples from the posterior distribution of the model parameters to generate results. Heuristics were used to improve computational efficiency. The modelling conformed to the National Institute for Health and Care Excellence reference case. The strategies evaluated included neither keeping instruments moist nor prohibiting set migration; ensuring that instruments were kept moist; prohibiting instrument migration between sets; and employing single-use instruments. Threshold analyses were undertaken to establish prices at which single-use sets or completely effective decontamination solutions would be cost-effective.

RESULTS

A total of 169 papers were identified for the clinical review. The evidence from published literature was not deemed sufficiently strong to take precedence over the distributions obtained from expert elicitation. Forty-eight papers were identified in the review of cost-effectiveness. The previous modelling structure was revised to add the possibility of misclassifying surgically transmitted Creutzfeldt-Jakob disease as another neurodegenerative disease, and assuming that all patients were susceptible to infection. Keeping instruments moist was estimated to reduce the risk of surgically transmitted Creutzfeldt-Jakob disease cases and associated costs. Based on probabilistic sensitivity analyses, keeping instruments moist was estimated to on average result in 2.36 (range 0-47) surgically transmitted Creutzfeldt-Jakob disease cases (across England) caused by infection occurring between 2019 and 2023. Prohibiting set migration or employing single-use instruments reduced the estimated risk of surgically transmitted Creutzfeldt-Jakob disease cases further, but at considerable cost. The estimated costs per quality-adjusted life-year gained of these strategies in addition to keeping instruments moist were in excess of £1M. It was estimated that single-use instrument sets (currently £350-500) or completely effective cleaning solutions would need to cost approximately £12 per patient to be cost-effective using a £30,000 per quality-adjusted life-year gained value.

LIMITATIONS

As no direct published evidence to implicate surgery as a cause of Creutzfeldt-Jakob disease has been found since 2005, the estimations of potential cases from elicitation are still speculative. A particular source of uncertainty was in the number of potential surgically transmitted Creutzfeldt-Jakob disease cases that may have occurred between 2005 and 2018.

CONCLUSIONS

Keeping instruments moist is estimated to reduce the risk of surgically transmitted Creutzfeldt-Jakob disease cases and associated costs. Further surgical management strategies can reduce the risks of surgically transmitted Creutzfeldt-Jakob disease but have considerable associated costs.

STUDY REGISTRATION

This study is registered as PROSPERO CRD42017071807.

FUNDING

This project was funded by the National Institute for Health Research (NIHR) Health Technology Assessment programme and will be published in full in Health Technology Assessment; Vol. 24, No. 11. See the NIHR Journals Library website for further project information.

Prion disease and recommended procedures for flexible endoscope reprocessing - a review of policies worldwide and proposal for a simplified approach

Several guidelines recommend specific treatments for endoscopes, procedures of quarantine for endoscopes, or additional treatments for the endoscope washer disinfector (EWD) in suspected or confirmed cases of Creutzfeldt-Jakob disease (CJD) or variant CJD (vCJD) but vary in many details. This study therefore reviewed guidelines on reprocessing flexible endoscopes after use in patients with suspected or confirmed prion disease. In addition, a literature search was performed in Medline on prion, CJD, vCJD, chemical inactivation, transmission healthcare, epidemiology healthcare, concentration tissue human and endoscope. Thus far, no case of CJD or vCJD transmitted by flexible endoscope has been reported. In animals it has been shown that oral uptake of 0.1-5 g of bovine spongiform encephalopathy (BSE)-infected brain homogenate is necessary for transmission. The maximum prion concentration in other tissues (e.g., terminal ileum) is at least 100-fold lower. Automated cleaning of endoscopes alone results in very low total residual protein ≤5.6 mg per duodenoscopes. Recommendations vary between countries, sometimes with additional cleaning, use of alkaline cleaners, no use of cleaners with fixative properties, use of disinfectants without fixative properties or single-use disinfectants. Sodium hydroxide (1 M) and sodium hypochlorite (10,000 and 25,000 mg/L) are very effective in preventing transmission via contaminated wires implanted into animal brains, but their relevance for endoscopes is questionable. Based on circumstantial evidence, it is proposed to consider validated reprocessing as appropriate in the case of delayed suspected prion disease when immediate bedside cleaning, routine use of alkaline cleaners, no fixative agents anywhere prior to disinfection and single use brushes and cleaning solutions can be assured.

Efficacy of humidity retention bags for the reduced adsorption and improved cleaning of tissue proteins including prion-associated amyloid to surgical stainless steel surfaces

Increasing drying time adversely affects attachment of tissue proteins and prion-associated amyloid to surgical stainless steel, and reduces the efficacy of commercial cleaning chemistries. This study tested the efficacy of commercial humidity retention bags to reduce biofouling on surgical stainless steel and to improve subsequent cleaning. Surgical stainless steel surfaces were contaminated with ME7-infected brain homogenates and left to dry for 15 to 1,440 min either in air, in dry polythene bags or within humidity retention bags. Residual contamination pre/post cleaning was analysed using Thioflavin T/SYPRO Ruby dual staining and microscope analysis. An increase in biofouling was observed with increased drying time in air or in sealed dry bags. Humidity retention bags kept both protein and prion-associated amyloid minimal across the drying times both pre- and post-cleaning. Therefore, humidity bags demonstrate a cheap, easy to implement solution to improve surgical instrument reprocessing and to potentially reduce associated hospital acquired infections.

Application of rapid read-out cleaning indicators for improved process control in hospital sterile services departments

BACKGROUND

Heightened awareness of the importance of cleaning has led to an emphasis on automated systems for the decontamination of re-usable medical devices. The authors have previously described an enzymatic indicator system, based on thermostable adenylate kinases (tAK), for quantitative monitoring of automated cleaning processes within hospital sterile services departments (SSDs).

AIM

To evaluate tAK indicators for routine process monitoring across a range of SSDs with different cleaning chemistries and different automated washer disinfectors (AWDs).

METHODS

tAK indicator devices and alternative industry test indicators were included in five independent cleaning cycles in each of eight different AWDs. Residual tAK post wash was determined by a coupled luciferase assay using a modified hygiene monitoring system.

FINDINGS

In all cases, with the exception of a single test, the alternative indicators showed that cleaning had been adequate. They were not able to discriminate between the performance of different processes. In contrast, the tAK indicators were able to resolve differences in the performance of processes across the different SSDs. Where the tAK indicators identified cleaning to the limits of detection of the assay, this demonstrated a log10 enzyme removal factor of >5.69.

CONCLUSION

The results suggest that tAK indicators are suitable for providing improved process control for automated cleaning processes, being able to distinguish between wash performance in different hospital settings and between individual process runs. This technology is believed to be a useful addition to routine AWD performance qualification when used as a daily or weekly test.