1
|
Topalcengiz Z, Chandran S, Gibson KE. A comprehensive examination of microbial hazards and risks during indoor soilless leafy green production. Int J Food Microbiol 2024; 411:110546. [PMID: 38157635 DOI: 10.1016/j.ijfoodmicro.2023.110546] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/14/2023] [Revised: 10/26/2023] [Accepted: 12/16/2023] [Indexed: 01/03/2024]
Abstract
Produce grown under controlled environment agriculture (CEA) is often assumed to have a reduced risk of pathogen contamination due to the low chance of exposure to outdoor contaminant factors. However, the 2021 outbreak and numerous recalls of CEA-grown lettuce and microgreens demonstrate the possibility of pathogen introduction during indoor production when there is a failure in the implementation of food safety management systems. Indoor production of commercial leafy greens, such as lettuce and microgreens, is performed across a range of protective structures from primitive household setups to advanced and partially automatized growing systems. Indoor production systems include hydroponic, aquaponic, and aeroponic configurations. Hydroponic systems such as deep water culture and nutrient film technique comprised of various engineering designs represent the main system types used by growers. Depending on the type of leafy green, the soilless substrate, and system selection, risk of microbial contamination will vary during indoor production. In this literature review, science-based pathogen contamination risks and mitigation strategies for indoor production of microgreens and more mature leafy greens are discussed during both pre-harvest and post-harvest stages of production.
Collapse
Affiliation(s)
- Zeynal Topalcengiz
- Department of Food Science, Center for Food Safety, University of Arkansas System Division of Agriculture, Fayetteville, AR 72704, USA; Department of Food Engineering, Faculty of Engineering and Architecture, Muş Alparslan University, 49250 Muş, Türkiye
| | - Sahaana Chandran
- Department of Food Science, Center for Food Safety, University of Arkansas System Division of Agriculture, Fayetteville, AR 72704, USA
| | - Kristen E Gibson
- Department of Food Science, Center for Food Safety, University of Arkansas System Division of Agriculture, Fayetteville, AR 72704, USA.
| |
Collapse
|
2
|
Wang W, Liu JS, Zhou JW, Jia AQ. Synergistic effect of kanamycin and amikacin with setomimycin on biofilm formation inhibition of Listeria monocytogenes. Microb Pathog 2023; 185:106447. [PMID: 37972742 DOI: 10.1016/j.micpath.2023.106447] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/30/2023] [Revised: 10/12/2023] [Accepted: 11/08/2023] [Indexed: 11/19/2023]
Abstract
Listeria monocytogenes, a foodborne pathogen that causes listeriosis with high fatality rate, exhibits multidrug resistance (MDR) known to be progressively increasing. Alternative antibacterial strategies are in high demand for treating this well-known pathogen. Anti-biofilm and anti-virulence strategies are being explored as novel approaches to treat bacterial infections. In this study, one rare antibacterial named setomimycin was isolated from Streptomyces cyaneochromogenes, which showed potent antibacterial activity against L. monocytogenes. Next, the inhibition of biofilm formation and listeriolysin O (LLO) production against L. monocytogenes were investigated at sub-minimal inhibitory concentrations (sub-MICs) of setomimycin alone or combined with kanamycin and amikacin. Crystal violet staining confirmed that setomimycin combining with kanamycin or amikacin could dramatically reduce biofilm formation against L. monocytogenes at sub-MICs, which was further evaluated by scanning electron microscopy (SEM) and confocal laser scanning microscopy (CLSM). In the meantime, sub-MICs of setomimycin could significantly suppress the secretion of LLO. Furthermore, the transcription of genes associated with biofilms and main virulence factors, such as LLO, flagellum, and metalloprotease, were suppressed by setomimycin at sub-MICs. Hence, the study provided a deep insight into setomimycin as an alternative antibacterial agent against L. monocytogenes.
Collapse
Affiliation(s)
- Wei Wang
- Key Laboratory of Tropical Biological Resources of Ministry of Education, School of Pharmaceutical Sciences, Hainan University, Haikou, 570228, China; Hainan General Hospital, Hainan Affiliated Hospital of Hainan Medical University, Haikou, 570311, China
| | - Jun-Sheng Liu
- Key Laboratory of Tropical Biological Resources of Ministry of Education, School of Pharmaceutical Sciences, Hainan University, Haikou, 570228, China
| | - Jin-Wei Zhou
- School of Food and Biological Engineering, Xuzhou University of Technology, Xuzhou, 221018, China
| | - Ai-Qun Jia
- Hainan General Hospital, Hainan Affiliated Hospital of Hainan Medical University, Haikou, 570311, China.
| |
Collapse
|
3
|
Gędas A, Draszanowska A, den Bakker H, Diez-Gonzalez F, Simões M, Olszewska MA. Prevention of surface colonization and anti-biofilm effect of selected phytochemicals against Listeria innocua strain. Colloids Surf B Biointerfaces 2023; 228:113391. [PMID: 37290199 DOI: 10.1016/j.colsurfb.2023.113391] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/24/2023] [Revised: 05/28/2023] [Accepted: 05/31/2023] [Indexed: 06/10/2023]
Abstract
This work aimed to determine the ability of Listeria innocua (L.i.) to colonize eight materials found in food-processing and packaging settings and to evaluate the viability of the sessile cells. We also selected four commonly used phytochemicals (trans-cinnamaldehyde, eugenol, citronellol, and terpineol) to examine and compare their efficacies against L.i. on each surface. Biofilms were also deciphered in chamber slides using confocal laser scanning microscopy to learn more about how phytochemicals affect L.i. The materials tested were silicone rubber (Si), polyurethane (PU), polypropylene (PP), polytetrafluoroethylene (PTFE), stainless steel 316 L (SS), copper (Cu), polyethylene terephthalate (PET), and borosilicate glass (GL). L.i. colonized Si and SS abundantly, followed by PU, PP, Cu, PET, GL, and PTFE surfaces. The live/dead status ranged from 65/35% for Si to 20/80% for Cu, and the estimates of cells unable to grow on Cu were the highest, reaching even 43%. Cu was also characterized by the highest degree of hydrophobicity (ΔGTOT = -81.5 mJ/m2). Eventually, it was less prone to attachment, as we could not recover L.i. after treatments with control or phytochemical solutions. The PTFE surface demonstrated the least total cell densities and fewer live cells (31%) as compared to Si (65%) or SS (nearly 60%). It also scored high in hydrophobicity degree (ΔGTOT = -68.9 mJ/m2) and efficacy of phytochemical treatments (on average, biofilms were reduced by 2.1 log10 CFU/cm2). Thus, the hydrophobicity of surface materials plays a role in cell viability, biofilm formation, and then biofilm control and could be the prevailing parameter when designing preventive measures and interventions. As for phytochemical comparison, trans-cinnamaldehyde displayed greater efficacies, with the highest reductions seen on PET and Si (4.6 and 4.0 log10 CFU/cm2). The biofilms in chamber slides exposed to trans-cinnamaldehyde revealed the disrupted organization to a greater extent than other molecules. This may help establish better interventions via proper phytochemical selection for incorporation in environment-friendly disinfection approaches.
Collapse
Affiliation(s)
- Astrid Gędas
- Department of Industrial and Food Microbiology, The Faculty of Food Science, University of Warmia and Mazury in Olsztyn, Plac Cieszyński 1, 10-726 Olsztyn, Poland
| | - Anna Draszanowska
- Department of Human Nutrition, The Faculty of Food Science, University of Warmia and Mazury in Olsztyn, Słoneczna 45 f, 10-709 Olsztyn, Poland
| | - Henk den Bakker
- Center for Food Safety, College of Agriculture and Environmental Sciences, University of Georgia, 1109 Experiment Street, Griffin, GA 30223, USA
| | - Francisco Diez-Gonzalez
- Center for Food Safety, College of Agriculture and Environmental Sciences, University of Georgia, 1109 Experiment Street, Griffin, GA 30223, USA
| | - Manuel Simões
- ALiCE, Associate Laboratory in Chemical Engineering, Faculty of Engineering, University of Porto, Rua Dr. Roberto Frias, 4200-465 Porto, Portugal; LEPABE, Laboratory for Process Engineering, Environment, Biotechnology and Energy, Faculty of Engineering, University of Porto, Rua Dr. Roberto Frias, 4200-465 Porto, Portugal
| | - Magdalena A Olszewska
- Department of Industrial and Food Microbiology, The Faculty of Food Science, University of Warmia and Mazury in Olsztyn, Plac Cieszyński 1, 10-726 Olsztyn, Poland.
| |
Collapse
|
4
|
Youssef S, Custódio L, Rodrigues MJ, Pereira CG, Calhelha RC, Pinela J, Barros L, Jekő J, Cziáky Z, Ben Hamed K. Nutritional anti-nutritional chemical composition and antioxidant activities of the leaves of the sea cliff dwelling species Limonium spathulatum (Desf.) Kuntze. FRONTIERS IN PLANT SCIENCE 2022; 13:979343. [PMID: 36466224 PMCID: PMC9714570 DOI: 10.3389/fpls.2022.979343] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 06/27/2022] [Accepted: 10/10/2022] [Indexed: 06/17/2023]
Abstract
This work explored the nutritional and antioxidant properties of the leaves of the halophytic species Limonium spathulatum (Desf.) Kuntze from Tunisian sea cliffs. Furthermore, the analysis of the total phenolics and flavonoids contents and their individual compounds using high-performance liquid chromatography coupled with electrospray ionization mass spectrometry (HPLC-ESI-MS/MS) were also studied. L. spathulatum leaves had high levels of moisture, ash, neutral detergent fiber, and acid detergent fiber, but low concentrations of crude protein, crude fat and acid detergent lignin. It contained low carbohydrates levels, and low energetic values. The most abundant macroelements were Cl, Na and Ca while the microelements detected in the highest levels were Fe and Zn. No relevant α-amylase inhibition was observed, and no toxic metals (Pb and Cd) and phytic acid were detected. The ethanol and the hydroethanolic extracts had the highest capacity to scavenge free radicals, to chelate iron and copper and to inhibit lipid peroxidation. The same samples were also the most active towards oxidative haemolysis. These extracts contained high total phenolic and flavonoid contents. HPLC analysis, performed on ethanolic extracts identified 58 individual compounds known for their high antioxidant actvitiy including hydroxybenzoic acids (gallic, syringic acids), hydroxycinnamic acids (caffeic, coumaric, ferulic acids) and flavonoids (catechin, epigallocatechin gallate and naringin).In conclusion, the leaves of Tunisian accession of L. spathulatum were good source of minerals and fibers useful in the human diet for attaining nutritional sufficiency. The high in vitro and ex vitro antioxidant activities associated with high favonoids contents and compounds suggest the possibility to use the extracts of L. spathulatum in herbal products with the aim of improving general health and well-being, and/or as food additives for preventing lipid oxidation of lipid-rich foods.
Collapse
Affiliation(s)
- Seria Youssef
- Laboratory of Extremophile Plants, Center of Biotechnology of Borj Cedria, Hammam-Lif, Tunisia
| | - Luísa Custódio
- Centre of Marine Sciences, Universidade do Algarve, Faro, Portugal
| | | | | | - Ricardo C. Calhelha
- Centro de Investigação de Montanha (CIMO), Instituto Politécnico de Bragança, Bragança, Portugal
| | - José Pinela
- Centro de Investigação de Montanha (CIMO), Instituto Politécnico de Bragança, Bragança, Portugal
| | - Lillian Barros
- Centro de Investigação de Montanha (CIMO), Instituto Politécnico de Bragança, Bragança, Portugal
| | - József Jekő
- Agricultural and Molecular Research and Service Institute, University of Nyíregyháza, Nyíregyháza, Hungary
| | - Zoltán Cziáky
- Agricultural and Molecular Research and Service Institute, University of Nyíregyháza, Nyíregyháza, Hungary
| | - Karim Ben Hamed
- Laboratory of Extremophile Plants, Center of Biotechnology of Borj Cedria, Hammam-Lif, Tunisia
| |
Collapse
|
5
|
Chalke S, Vidovic S, Fletcher GC, Palmer J, Flint S. Differential effects of magnesium, calcium, and sodium on Listeria monocytogenes biofilm formation. BIOFOULING 2022; 38:786-795. [PMID: 36210503 DOI: 10.1080/08927014.2022.2131398] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/22/2022] [Revised: 08/16/2022] [Accepted: 09/26/2022] [Indexed: 06/16/2023]
Abstract
Listeria monocytogenes is a gram-positive foodborne pathogen that causes outbreaks of listeriosis associated with a diverse range of foods. L. monocytogenes forms biofilms as a strategy to enhance its survival in the environment. These biofilms then provide a source of contamination in processing plant environments. Cations like magnesium, calcium, and sodium are commonly found in the environment and are important to bacteria to maintain their homeostasis. It is, therefore, valuable to understand the relationship between these cations and biofilm formation. In this study, four isolates of L. monocytogenes from seafood processing environments were used to investigate the influence of magnesium, calcium, and sodium (1, 10, and 50 mM) on biofilms. The isolates selected were defined as being either a low biofilm former, a high biofilm former, an outbreak isolate, and a persistent isolate from the seafood industry. The study showed that the divalent cations magnesium and calcium increased biofilm formation compared with the monovalent cation, sodium. Fifty mM concentrations of the divalent cations significantly enhanced biofilm formation. The cations did not have a significant effect on the initial stages of biofilm formation but appeared to influence the later stages of biofilm development.
Collapse
Affiliation(s)
- Saili Chalke
- Food Safety and Preservation Team, The New Zealand Institute for Plant and Food Research Limited, Auckland, New Zealand
- Institute of Food Science and Technology, School of Food and Advanced Technology, Massey University, Palmerston North, New Zealand
| | - Sinisa Vidovic
- Food Safety and Preservation Team, The New Zealand Institute for Plant and Food Research Limited, Auckland, New Zealand
| | - Graham C Fletcher
- Food Safety and Preservation Team, The New Zealand Institute for Plant and Food Research Limited, Auckland, New Zealand
| | - Jon Palmer
- Institute of Food Science and Technology, School of Food and Advanced Technology, Massey University, Palmerston North, New Zealand
| | - Steve Flint
- Institute of Food Science and Technology, School of Food and Advanced Technology, Massey University, Palmerston North, New Zealand
| |
Collapse
|
6
|
Han X, Chen Q, Zhang X, Peng J, Zhang M, Zhong Q. The elimination effects of lavender essential oil on Listeria monocytogenes biofilms developed at different temperatures and the induction of VBNC state. Lett Appl Microbiol 2022; 74:1016-1026. [PMID: 35211995 DOI: 10.1111/lam.13681] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/13/2021] [Revised: 02/20/2022] [Accepted: 02/21/2022] [Indexed: 11/28/2022]
Abstract
Listeria monocytogenes is a typical foodborne pathogen that causes hard-to-treat bacterial infections, mainly due to its ability to form biofilm and enter into a viable but non-culturable state (VBNC). In this study, we investigated the removal effects of four antimicrobial agents on L. monocytogenes biofilms formed at 32 ℃ and 10 ℃, analyzed the resistances of the mature biofilms to antimicrobial agents, and explored the VBNC state of cells in mature biofilms induced by lavender essential oil (LEO). The results showed that the growth of L. monocytogenes was completely inhibited when 1.6% (v/v) of the LEO was added. Meanwhile, the results of the crystal violet staining and XTT reduction method indicated that different concentrations of LEO significantly reduced L. monocytogenes biofilms biomass and metabolic activities, followed by sodium hypochlorite, lactic acid, and hydrogen peroxide. Moreover, the confocal laser scanning microscopy (CLSM) images confirmed that the treated biofilms became thinner, the structure was sparse, and the appearance was blurry. More interestingly, L. monocytogenes biofilms developed at 10 ℃ were less susceptible to the sanitizers than that formed at 32 ℃. In addition, LEO presented a more significant dispersing effect on the biofilm cells, and 1/2 MIC to 4 MIC of LEO could induce fewer VBNC state cells in biofilm and plankton compared with sodium hypochlorite. This study indicated that the LEO could be considered as an ideal antibiofilm agent for controlling L. monocytogenes. But we should pay attention to the resistance of the biofilms developed at low temperatures.
Collapse
Affiliation(s)
- Xiangpeng Han
- Guangdong Provincial Key Laboratory of Food Quality and Safety, College of Food Science, South China Agricultural University, Guangzhou, 510642, China.,Guangdong Laboratory of Lingnan Modern Agriculture, South China Agricultural University, Guangzhou, 510642, China
| | - Qingying Chen
- Guangdong Provincial Key Laboratory of Food Quality and Safety, College of Food Science, South China Agricultural University, Guangzhou, 510642, China.,Guangdong Laboratory of Lingnan Modern Agriculture, South China Agricultural University, Guangzhou, 510642, China
| | - Xingguo Zhang
- Guangdong Provincial Key Laboratory of Food Quality and Safety, College of Food Science, South China Agricultural University, Guangzhou, 510642, China.,Guangdong Laboratory of Lingnan Modern Agriculture, South China Agricultural University, Guangzhou, 510642, China
| | - Jiayi Peng
- Guangdong Provincial Key Laboratory of Food Quality and Safety, College of Food Science, South China Agricultural University, Guangzhou, 510642, China.,Guangdong Laboratory of Lingnan Modern Agriculture, South China Agricultural University, Guangzhou, 510642, China
| | - Mengyu Zhang
- Guangdong Provincial Key Laboratory of Food Quality and Safety, College of Food Science, South China Agricultural University, Guangzhou, 510642, China.,Guangdong Laboratory of Lingnan Modern Agriculture, South China Agricultural University, Guangzhou, 510642, China
| | - Qingping Zhong
- Guangdong Provincial Key Laboratory of Food Quality and Safety, College of Food Science, South China Agricultural University, Guangzhou, 510642, China.,Guangdong Laboratory of Lingnan Modern Agriculture, South China Agricultural University, Guangzhou, 510642, China
| |
Collapse
|
7
|
Rezaei Z, Khanzadi S, Salari A. Biofilm formation and antagonistic activity of Lacticaseibacillus rhamnosus (PTCC1712) and Lactiplantibacillus plantarum (PTCC1745). AMB Express 2021; 11:156. [PMID: 34825290 PMCID: PMC8617238 DOI: 10.1186/s13568-021-01320-7] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/21/2021] [Accepted: 11/16/2021] [Indexed: 11/16/2022] Open
Abstract
Currently, the health benefits of probiotic bacteria are well known, and this has taken up a great deal of space in food science and health, both research and operational. On the other hand, anti-biofilm properties on food pathogens in the food and pharmaceutical industries have created an attractive challenge. This study aimed to describe the inhibitory activity of cell-free supernatants (CFS), planktonic cells, and biofilm form of lactobacilus strains (L. rhamnosus and L. plantarum) against food pathogens such as Pseudomonas aeruginosa and Listeria monocytogenes. Anti-bacterial activities of the CFS of lactobacillus strains were assessed by the microplate method and via violet staining. Evaluation of the antagonistic activity of planktonic cells and biofilm of LAB were performed by the spread plate method. The results showed the incubation time of 48 h was the best time to produce biofilm. Although the planktonic states reduce the pathogens bacterial about 1 –1.5 log, but in biofilm forms, decreased L. monocytogenes about 4.5 log compared to the control, and in the case of P. aeruginosa, a growth reduction of about 2.13 log was observed. Furthermore, biofilm formation of L. monocytogenes in the presence of L. rhamnosus cell-free supernatant was more weakly than L. plantarum CFS, but their CFS effect on reducing the bacterial population of P. aeruginosa was the same. According to the study, biofilm produced by probiotic strains can be considered a new approach for biological control. Also, cell-free supernatant can be used as postbiotic in the food and pharmaceutical industries.
Collapse
|
8
|
A Review on Sarcocornia Species: Ethnopharmacology, Nutritional Properties, Phytochemistry, Biological Activities and Propagation. Foods 2021; 10:foods10112778. [PMID: 34829059 PMCID: PMC8625059 DOI: 10.3390/foods10112778] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/13/2021] [Revised: 11/03/2021] [Accepted: 11/07/2021] [Indexed: 01/11/2023] Open
Abstract
Sarcocornia A. J. Scott is a halophytic edible succulent plant belonging to the Amaranthaceae family. To date, the genus includes 28 species distributed worldwide in saline environments, usually salt marshes. Sarcocornia (Scott) is similar to Salicornia (L.), which has a recognized commercial value in morphological and taxonomical traits. Species of both genera are commonly named samphire or glassworts in Europe, and their fleshy shoots are commercialized under their traditional names. Due to their nutritional, organoleptic and medicinal properties, Sarcocornia species have a high economic potential in various biotechnology sectors. Being highly tolerant to salt, they can be cultivated in saline conditions, and dissimilar to Salicornia, they are perennial, i.e., they can be harvested year-round. Therefore, Sarcocornia species are considered promising gourmet vegetables to be explored in the context of climate change, soil and water salinization and eco-sustainability. We hereby put together and reviewed the most relevant information on Sarcocornia taxonomy, morphology, nutritional and pharmacological properties, uses in ethnomedicine, potential applications in biotechnology, and propagation strategies.
Collapse
|
9
|
Comparison of growth characteristics, functional qualities, and texture of hydroponically grown and soil-grown lettuce. Lebensm Wiss Technol 2021. [DOI: 10.1016/j.lwt.2021.111931] [Citation(s) in RCA: 11] [Impact Index Per Article: 3.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/23/2022]
|