1
|
Topalcengiz Z, Chandran S, Gibson KE. A comprehensive examination of microbial hazards and risks during indoor soilless leafy green production. Int J Food Microbiol 2024; 411:110546. [PMID: 38157635 DOI: 10.1016/j.ijfoodmicro.2023.110546] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/14/2023] [Revised: 10/26/2023] [Accepted: 12/16/2023] [Indexed: 01/03/2024]
Abstract
Produce grown under controlled environment agriculture (CEA) is often assumed to have a reduced risk of pathogen contamination due to the low chance of exposure to outdoor contaminant factors. However, the 2021 outbreak and numerous recalls of CEA-grown lettuce and microgreens demonstrate the possibility of pathogen introduction during indoor production when there is a failure in the implementation of food safety management systems. Indoor production of commercial leafy greens, such as lettuce and microgreens, is performed across a range of protective structures from primitive household setups to advanced and partially automatized growing systems. Indoor production systems include hydroponic, aquaponic, and aeroponic configurations. Hydroponic systems such as deep water culture and nutrient film technique comprised of various engineering designs represent the main system types used by growers. Depending on the type of leafy green, the soilless substrate, and system selection, risk of microbial contamination will vary during indoor production. In this literature review, science-based pathogen contamination risks and mitigation strategies for indoor production of microgreens and more mature leafy greens are discussed during both pre-harvest and post-harvest stages of production.
Collapse
Affiliation(s)
- Zeynal Topalcengiz
- Department of Food Science, Center for Food Safety, University of Arkansas System Division of Agriculture, Fayetteville, AR 72704, USA; Department of Food Engineering, Faculty of Engineering and Architecture, Muş Alparslan University, 49250 Muş, Türkiye
| | - Sahaana Chandran
- Department of Food Science, Center for Food Safety, University of Arkansas System Division of Agriculture, Fayetteville, AR 72704, USA
| | - Kristen E Gibson
- Department of Food Science, Center for Food Safety, University of Arkansas System Division of Agriculture, Fayetteville, AR 72704, USA.
| |
Collapse
|
2
|
Murphy CM, Weller DL, Strawn LK. Scale and detection method impacted Salmonella prevalence and diversity in ponds. Sci Total Environ 2024; 907:167812. [PMID: 37852489 DOI: 10.1016/j.scitotenv.2023.167812] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/27/2023] [Revised: 10/08/2023] [Accepted: 10/11/2023] [Indexed: 10/20/2023]
Abstract
Site-specific approaches for managing food safety hazards in agricultural water require an understanding of foodborne pathogen ecology. This study identified factors associated with Salmonella contamination in Virginia ponds. Grab samples (250 mL, N = 600) were collected from 30 sites across nine ponds. Culture- and culture-independent (CIDT)-based methods were used to detect Salmonella in each sample. Salmonella isolated by culture-based methods were serotyped by Kauffman-White classification. Environmental data were collected for each sample. McNemar's χ2 was used to determine if Salmonella detection differed by testing method. Separate mixed effect models were used to identify environmental factors associated with culture and CIDT-based Salmonella detection. Separate models were built for each pond, and for all ponds combined. Salmonella detection differed significantly (p < 0.001) between CIDT (31 %; 183/600)- and culture (13 %; 77/600)-based methods. Culture-based methods yielded 11 different serovars. All cultured Salmonella samples were confirmed by CIDT; 42.1 % of CIDT Salmonella-positive samples could be cultured. Associations between environmental factors and Salmonella detection also varied substantially by pond and detection method. In the all-pond model, associations were observed for five factors (total coliforms, Escherichia coli, air temperature, UV, rain) for both culture- and CIDT-based Salmonella detection. Rain prior to sampling (24 h) increased odds of Salmonella detection for culture (OR = 5.09) and CIDT (OR = 3.62) in the all-pond model. When all the pond data were used, models masked associations at the individual pond level, as there were noticeable differences between ponds and the odds of isolating Salmonella by environmental factors. Ponds were within a 187-ha area in this study, emphasizing water management needs to be individualized (i.e., assess hazards/risks by pond). Results also highlight detection methods and scale strongly affect observed water quality and should be considered when developing monitoring programs to develop guidance for growers.
Collapse
Affiliation(s)
- Claire M Murphy
- Department of Food Science and Technology, Virginia Tech, 1230 Washington Street SW, Blacksburg, VA 24061, USA
| | - Daniel L Weller
- Department of Food Science and Technology, Virginia Tech, 1230 Washington Street SW, Blacksburg, VA 24061, USA; Department of Biostatistics and Computational Biology, University of Rochester Medical Center, 265 Crittenden Boulevard, Rochester, NY 14642, USA
| | - Laura K Strawn
- Department of Food Science and Technology, Virginia Tech, 1230 Washington Street SW, Blacksburg, VA 24061, USA.
| |
Collapse
|
3
|
Dorick JM, Macarisin D, Dunn L, Dev Kumar G. Effect of aquaponic water and substratum material on biofilm formation by Aeromonas hydrophila. Int J Food Microbiol 2023; 404:110316. [PMID: 37499272 DOI: 10.1016/j.ijfoodmicro.2023.110316] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/14/2023] [Revised: 07/03/2023] [Accepted: 07/07/2023] [Indexed: 07/29/2023]
Abstract
Aeromonas hydrophila is a zoonotic pathogen causing illness in fish and susceptible humans. This emerging pathogen has been isolated within aquaponic systems and could cause disease in fish and a hazard to humans consuming aquaponic produce. This study determined whether A. hydrophila from an aquaponic farm could form biofilms in aquaponic water and on materials used in these systems. A. hydrophila biofilm biomass and cell density in aquaponic water were evaluated by crystal violet staining and culture-based enumeration. Biofilm biomass and biofilm cell density were affected by the water source and A. hydrophila isolate (P < 0.05). A. hydrophila formed the most biomass from the beginning of deep-water culture (BDWC) water (OD570 0.202 ± 0.066) and the least from the end of deep-water culture (EDWC) water (OD570 0.140 ± 0.036; P < 0.05). Enumerated A. hydrophila from the biofilm varied among water sources; the fish tank water supported the greatest cell density (7.04 ± 0.71 log CFU/mL) while the EDWC supported the lowest cell density (6.76 ± 0.83 log CFU/mL). Biofilm formation was also evaluated on aquaponic materials such as nylon, polyvinyl chloride, polyethylene liner, bead filter, and foam. Biofilm formation on the liner had the greatest population (2.39 ± 0.022 log CFU/cm2), and the bead had the least (0.64 ± 0.039 log CFU/cm2; P < 0.05). Pathogenic organisms, such as A. hydrophila, may pose a greater risk to produce harvested from the BDWC and MDWC due to greater biofilm formation.
Collapse
Affiliation(s)
- Jennifer M Dorick
- Department of Food Science & Technology, University of Georgia, Athens, GA 30605, USA
| | - Dumitru Macarisin
- Center for Food Safety and Applied Nutrition, Food and Drug Administration, College Park, MD 20740, USA
| | - Laurel Dunn
- Department of Food Science & Technology, University of Georgia, Athens, GA 30605, USA
| | | |
Collapse
|
4
|
Wu J, Gathman RJ, Quintanilla Portillo J, Gaulke C, Kim M, Stasiewicz MJ. Aggregative Soil Sampling Using Boot Covers Compared to Soil Grabs From Commercial Romaine Fields Shows Similar Indicator Organism and Microbial Community Recoveries. J Food Prot 2023; 86:100177. [PMID: 37805043 DOI: 10.1016/j.jfp.2023.100177] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/25/2023] [Revised: 09/26/2023] [Accepted: 10/03/2023] [Indexed: 10/09/2023]
Abstract
Aggregative boot cover sampling may be a more representative, practical, and powerful method for preharvest produce soil testing than grab sampling because boot covers aggregate soil from larger areas. Our study tests if boot cover sampling results reflect quality and safety indicator organisms and community diversity of grab sampling. We collected soil samples from commercial romaine lettuce fields spanning 5060 m2 using boot covers (n = 28, m = 1.1 ± 0.4 g; wearing boot covers and walking along the path), composite grabs (n = 28, m = 231 ± 24 g; consisting of 60 grabs of 3-5 g each), and high-resolution grabs (n = 72, m = 56 ± 4 g; taking one sample per stratum). Means and standard deviations of log-transformed aerobic plate counts (APCs) were 7.0 ± 0.3, 7.1 ± 0.2, and 7.3 ± 0.2 log(CFU/g) for boot covers, composite grabs, and high-resolution grabs, respectively. APCs did not show biologically meaningful differences between sample types. Boot covers recovered on average 0.6 log(CFU/g) more total coliforms than both grabs (p < 0.001) where means and standard deviations of log-transformed counts were 3.2 ± 1.0, 2.6 ± 0.6, and 2.6 ± 1.0 log(CFU/g) for boot covers, composite grabs, and high-resolution grabs, respectively. There were no generic E. coli detected in any sample by enumeration methods with LODs of 1.3-2.1 log(CFU/g) for boot covers and 0.5 log(CFU/g) for both grabs. By 16S rRNA sequencing, community species diversity (alpha diversity) was not significantly different within collection methods. While communities differed (p < 0.001) between soil sampling methods (beta diversity), variance in microbial communities was not significantly different. Of the 28 phyla and 297 genera detected, 25 phyla (89%) and 258 genera (87%) were found by all methods. Overall, aggregative boot cover sampling is similar to both grab methods for recovering quality and safety indicator organisms and representative microbiomes. This justifies future work testing aggregative soil sampling for foodborne pathogen detection.
Collapse
Affiliation(s)
- Jiaying Wu
- Department of Food Science and Human Nutrition, University of Illinois at Urbana-Champaign, Urbana, IL 61801, USA
| | - Rachel J Gathman
- Department of Food Science and Human Nutrition, University of Illinois at Urbana-Champaign, Urbana, IL 61801, USA
| | - Jorge Quintanilla Portillo
- Department of Food Science and Human Nutrition, University of Illinois at Urbana-Champaign, Urbana, IL 61801, USA
| | - Christopher Gaulke
- Department of Pathobiology, University of Illinois at Urbana-Champaign, Urbana, IL 61801, USA; Carl R. Woese Institute for Genomic Biology, University of Illinois at Urbana Champaign, Urbana, IL 61802, USA; Personalized Nutrition Initiative, University of Illinois at Urbana Champaign, Urbana, IL 61802, USA; Cancer Center at Illinois, University of Illinois at Urbana Champaign, Urbana, IL 61802, USA
| | - Minho Kim
- Department of Food Science and Human Nutrition, University of Illinois at Urbana-Champaign, Urbana, IL 61801, USA
| | - Matthew J Stasiewicz
- Department of Food Science and Human Nutrition, University of Illinois at Urbana-Champaign, Urbana, IL 61801, USA.
| |
Collapse
|
5
|
Gensler C, Harper K, Stoufer S, Moore MD, Kinchla AJ, McLandsborough L. Exploring Washing Procedures for Produce Brush Washer. J Food Prot 2023; 86:100126. [PMID: 37414285 DOI: 10.1016/j.jfp.2023.100126] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/21/2023] [Revised: 06/13/2023] [Accepted: 06/30/2023] [Indexed: 07/08/2023]
Abstract
Previous environmental monitoring projects in food production facilities have revealed inconsistencies in how produce brush washer machines are cleaned after use; thus, the study of effective sanitation procedures for these machines is needed. Four chlorine solution treatments (ranging from 25 to 200 ppm), as well as a water-only treatment, were tested for efficacy in reducing bacterial loads for a selected small brush washer machine. Results indicate that rinsing with the machine's power and water alone, a frequent practice among some produce processors, yielded a reduction of 0.91-1.96 log CFU per brush roller in bacterial counts, which was not statistically significant (p > 0.05). However, the chlorine treatments were found to be effective in reducing bacterial loads significantly, with higher concentrations being the most effective. The 200 ppm and 100 ppm chlorine treatments yielded bacterial reductions of 4.08 and 3.95 log CFU per brush roller, respectively, leaving bacterial levels statistically similar to the levels at postprocess decontamination, meaning these are the most effective at killing bacteria of all the chlorine concentrations tested. These data suggest the use of at least 100 ppm chlorine sanitizer solution is a good method to sanitize hard-to-clean produce washing machines, yielding an approximate 4 log CFU reduction of the inoculated bacteria.
Collapse
Affiliation(s)
- Catherine Gensler
- Department of Food Science, University of Massachusetts, Amherst, Massachusetts, USA
| | - Kelsi Harper
- Department of Food Science, University of Massachusetts, Amherst, Massachusetts, USA
| | - Sloane Stoufer
- Department of Food Science, University of Massachusetts, Amherst, Massachusetts, USA
| | - Matthew D Moore
- Department of Food Science, University of Massachusetts, Amherst, Massachusetts, USA
| | - Amanda J Kinchla
- Department of Food Science, University of Massachusetts, Amherst, Massachusetts, USA.
| | - Lynne McLandsborough
- Department of Food Science, University of Massachusetts, Amherst, Massachusetts, USA
| |
Collapse
|
6
|
Haley OC, Zhao Y, Hefley T, Britton LL, Nwadike L, Rivard C, Bhullar M. Developing a Decision-making Tool for Agricultural Surface Water Decontamination Using Ultraviolet-C Light. J Food Prot 2023; 86:100129. [PMID: 37442228 DOI: 10.1016/j.jfp.2023.100129] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/03/2023] [Revised: 07/06/2023] [Accepted: 07/07/2023] [Indexed: 07/15/2023]
Abstract
Ultraviolet-C (UV-C) light-assisted water treatment systems are an increasingly investigated alternative to chemical sanitizers for agricultural surface water decontamination. However, the relatively high concentration of particulate matter in surface water is a major challenge to expanding its application in the production of fresh produce. The objective of this project was to test the efficacy of two commercial UV-C devices to reduce the microbial risk of agricultural water in order to develop a web application to assist growers in decision-making related to the on-farm implementation of UV-C technologies for agricultural water treatment. An on-farm study using three agricultural water sources was performed to determine the microbial reduction efficacy of a low power, low flow (LP/LF; 1-9 gallons per minute (GPM), 1.34-gallon capacity) and a high powered, high flow (HP/HF; 1-110 GPM, 4.75-gallon capacity) device at flow rates of 6, 7, and 9 GPM. A threshold of 30% UVT for the HP/HF device was observed, wherein lower water transmissibility significantly impacted microbial inactivation. Although less effective at lower %UVT, the LP/LF device costs less to install, maintain, and operate. The observations were used to design an online tool for growers to calculate the predicted reduction of generic Escherichia coli using either device based on the %UVT of their water source. However, because this study utilized an exploratory and proof-of-concept approach, the experimental flow rates were limited to reflect the capacities of the smaller unit (9 GPM) for direct comparison to the larger unit. Thus, the preliminary model and tool are largely limited to the experimental conditions. Yet, these results of this study demonstrate the utility of UV-C light in reducing the microbial risk of agricultural water, and future studies using different UV-C devices and higher flow rates will expand the use of the decision-making tool.
Collapse
Affiliation(s)
- Olivia C Haley
- Department of Horticulture and Natural Resources, Kansas State University, Olathe, KS 66061, USA
| | - Yeqi Zhao
- Department of Horticulture and Natural Resources, Kansas State University, Olathe, KS 66061, USA
| | - Trevor Hefley
- Department of Statistics, Kansas State University, Manhattan, KS 66506, USA
| | - Logan L Britton
- Department of Agricultural Economics, Kansas State University, Manhattan, KS 66506, USA
| | - Londa Nwadike
- Kansas State Research and Extension, Kansas State University, 22201 W. Innovation Dr., Olathe, KS 66061, USA; University of Missouri Extension, 22201 W. Innovation Dr., Olathe, KS 66061, USA
| | - Cary Rivard
- Eastern Kansas Research and Extension Centers, 35230 W. 135th St., Olathe, KS 66061, USA
| | - Manreet Bhullar
- Department of Horticulture and Natural Resources, Kansas State University, Olathe, KS 66061, USA; Food Science Institute, Kansas State University, Manhattan, KS 66506, USA.
| |
Collapse
|
7
|
Zhao Y, Haley OC, Xu X, Jaberi-Douraki M, Rivard C, Pliakoni ED, Nwadike L, Bhullar M. The Potential for Cover Crops to Reduce the Load of Escherichia coli in Contaminated Agricultural Soil. J Food Prot 2023; 86:100103. [PMID: 37172906 DOI: 10.1016/j.jfp.2023.100103] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/25/2023] [Revised: 05/05/2023] [Accepted: 05/08/2023] [Indexed: 05/15/2023]
Abstract
Cover crops are plants seeded before or after cash crops to improve soil health, reduce weed pressure, and prevent erosion. Cover crops also produce various antimicrobial secondary metabolites (i.e., glucosinolates, quercetin), yet the role of cover crops in moderating the population of human pathogens in the soil has rarely been investigated. This study aims to determine the antimicrobial capacity of three cover crop species to reduce the population of generic Escherichia coli (E. coli) in contaminated agricultural soil. Four-week-old mustard greens (Brassicajuncea), sunn hemp (Crotalaria juncea), and buckwheat (Fagopyrum esculentum) were mixed into autoclaved soil and inoculated with rifampicin-resistant generic E. coli to achieve a starting concentration of 5 log CFU/g. The surviving microbial populations on days 0, 4, 10, 15, 20, 30, and 40 were enumerated. All three cover crops significantly reduced the population of generic E. coli compared to the control (p < 0.0001), particularly between days 10 and to 30. Buckwheat resulted in the highest reduction (3.92 log CFU/g). An inhibitory effect (p < 0.0001) on microbial growth was also observed in soils containing mustard greens and sunn hemp. This study provides evidence for the bacteriostatic and bactericidal effect of particular cover crops. More research regarding the secondary metabolites produced by certain cover crops and their potential as a bio mitigation strategy to improve on-farm produce safety is warranted.
Collapse
Affiliation(s)
- Yeqi Zhao
- Department of Horticulture and Natural Resources, Kansas State University, Olathe, KS 66061, USA
| | - Olivia C Haley
- Department of Horticulture and Natural Resources, Kansas State University, Olathe, KS 66061, USA
| | - Xuan Xu
- 1DATA Consortium, Kansas State University Olathe, Olathe, KS 66061, USA; Department of Mathematics, Kansas State University, Manhattan, KS 66506, USA
| | - Majid Jaberi-Douraki
- 1DATA Consortium, Kansas State University Olathe, Olathe, KS 66061, USA; Department of Mathematics, Kansas State University, Manhattan, KS 66506, USA
| | - Cary Rivard
- Department of Horticulture and Natural Resources, Kansas State University, Olathe, KS 66061, USA
| | - Eleni D Pliakoni
- Department of Horticulture and Natural Resources, Kansas State University, Olathe, KS 66061, USA
| | - Londa Nwadike
- Food Science Institute, Kansas State University, Manhattan, KS 66506, USA; Kansas State Research and Extension, Kansas State University, Olathe, KS 66061, USA; University of Missouri Extension, Kansas City, MO 64106, USA
| | - Manreet Bhullar
- Department of Horticulture and Natural Resources, Kansas State University, Olathe, KS 66061, USA; Food Science Institute, Kansas State University, Manhattan, KS 66506, USA.
| |
Collapse
|
8
|
Yin HB, Chen CH, Gu G, Nou X, Patel J. Pre-harvest biocontrol of Listeria and Escherichia coli O157 on lettuce and spinach by lactic acid bacteria. Int J Food Microbiol 2023; 387:110051. [PMID: 36516726 DOI: 10.1016/j.ijfoodmicro.2022.110051] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/20/2022] [Revised: 11/30/2022] [Accepted: 12/02/2022] [Indexed: 12/12/2022]
Abstract
Recent outbreaks linked to contaminated leafy greens underline the need for identifying effective natural approaches to improve produce safety at pre-harvest level. Lactic acid bacteria (LAB) have been evaluated as biocontrol agents in food products. In this study, the efficacy of a cocktail of LAB including Lactococcus lactis, Lactiplantibacillus plantarum, Lactobacillus johnsonii, and Lactobacillus acidophilus as pre-harvest biocontrol agents against Listeria and Escherichia coli O157 on lettuce and spinach was investigated. Bacterial pathogens L. monocytogenes and E. coli O157:H7 and the non-pathogenic surrogates L. innocua and E. coli O157:H12 were used to spray-inoculate cultivars of lettuce and spinach grown in growth chamber and in field, respectively. Inoculated plants were spray-treated with water or a cocktail of LAB. On day 0, 3, and 5 post-inoculation, four samples from each group were collected and bacterial populations were determined by serial dilution and spiral plating on selective agars. LAB treatment exhibited an immediate antimicrobial efficacy against L. monocytogenes and E. coli O157:H7 on "Green Star" lettuce by ~2 and ~ 1 log reductions under growth chamber conditions, respectively (P < 0.05). The effect of LAB against E. coli O157:H7 on "New Red Fire" lettuce remained effective during the 5-day period in growth chamber (P < 0.05). Treatment of LAB delivered an effective bactericidal effect against E. coli O157:H12 immediately after application on the field-grown lettuce plants (P < 0.05). Approximately 1 log L. innocua reduction was observed on "Matador" and "Palco" spinach on day 5 (P < 0.05). Results of this study support that LAB could potentially be applied as biocontrol agents for controlling Listeria and E. coli O157 contamination on leafy greens at the pre-harvest level.
Collapse
Affiliation(s)
- Hsin-Bai Yin
- U.S. Department of Agriculture, Agricultural Research Service, Beltsville, MD, USA
| | - Chi-Hung Chen
- U.S. Department of Agriculture, Agricultural Research Service, Beltsville, MD, USA
| | - Ganyu Gu
- U.S. Department of Agriculture, Agricultural Research Service, Beltsville, MD, USA
| | - Xiangwu Nou
- U.S. Department of Agriculture, Agricultural Research Service, Beltsville, MD, USA
| | - Jitendra Patel
- U.S. Department of Agriculture, Agricultural Research Service, Beltsville, MD, USA.
| |
Collapse
|
9
|
Alegbeleye O, Sant'Ana AS. Impact of temperature, soil type and compost amendment on the survival, growth and persistence of Listeria monocytogenes of non-environmental (food-source associated) origin in soil. Sci Total Environ 2022; 843:157033. [PMID: 35777564 DOI: 10.1016/j.scitotenv.2022.157033] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/11/2022] [Revised: 06/22/2022] [Accepted: 06/24/2022] [Indexed: 06/15/2023]
Abstract
Listeria monocytogenes of varied sources including food-related sources may reach the soil. Associated food safety and environmental health risks of such contamination depend significantly on the capacity of L. monocytogenes to survive in the soil. This study assessed the survival of 13 L. monocytogenes strains isolated from food and food processing environments and a cocktail of three of the strains in two types of soils (loam and sandy) under controlled temperature conditions: 5, 10, 20, 25, 30℃ and 'uncontrolled' ambient temperature conditions in a tropical region. The impact of compost amendment on the survival of L. monocytogenes in the two different types of soils was also assessed. Soil type, temperature and compost amendment significantly (P <0.001) impacted the survival of L. monocytogenes in soil. Temperature variations affected the survival of L. monocytogenes in soil, where some strains such as strain 732, a L. monocytogenes 1/2a strain survived better at lower temperature (5°C), for which counts of up to 10.47 ± 0.005 log CFU/g were recovered in compost-amended sandy soil, 60 days post-inoculation. Some other strains such as strain 441, a L. monocytogenes 1/2a survived best at intermediate temperature (25 and 30 °C), while others such as 2739 (L. monocytogenes 1/2b) thrived at higher temperature (between 30 °C - 37 °C). There were significant correlations between the influence of temperature and soil type, where lower temperature conditions (5°C - 20°C) were generally more suitable for survival in sandy soil compared to higher temperature conditions. For some of the strains that thrived better in sandy soil at lower temperature, Pearson correlation analysis found significant correlations between temperature and soil type. Steady, controlled temperature generally favored the survival of the strains compared to uncontrolled ambient temperature conditions, except for the cocktail. The cocktail persisted until the last day of post-inoculation storage (60th day) in all test soils and under all incubation temperature conditions. Loam soil was more favorable for the survival of L. monocytogenes and compost amendment improved the survival of the strains, especially in compost-amended sandy soil. Listeria monocytogenes may exhibit variable survival capacity in soil, depending on conditions such as soil type, compost amendment and temperature.
Collapse
Affiliation(s)
- Oluwadara Alegbeleye
- Department of Food Science and Nutrition, Faculty of Food Engineering, University of Campinas, Campinas, SP, Brazil
| | - Anderson S Sant'Ana
- Department of Food Science and Nutrition, Faculty of Food Engineering, University of Campinas, Campinas, SP, Brazil.
| |
Collapse
|
10
|
Mohammad ZH, Prado ID, Sirsat SA. Comparative microbial analyses of hydroponic versus in-soil grown Romaine lettuce obtained at retail. Heliyon 2022; 8:e11050. [PMID: 36281368 PMCID: PMC9587268 DOI: 10.1016/j.heliyon.2022.e11050] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/16/2022] [Revised: 07/11/2022] [Accepted: 10/07/2022] [Indexed: 11/06/2022] Open
Abstract
The overarching goal of this study was to assess the microbiological profile of hydroponically grown Romaine lettuce and in-soil Romaine lettuce (organic and conventional). Thirty-six samples of hydroponic lettuce, seventy-two samples organic lettuce (thirty-six bagged lettuce and thirty-six non-bagged lettuce), and thirty-six conventionally grown lettuce was purchased from retail stores. A portion of each sample was analyzed for aerobic bacteria (APC), coliforms and E. coli, and yeasts and molds (YM). Another portion of each sample was enriched for Salmonella, E. coli O157:H7, Listeria monocytogenes, and Staphylococcus aureus, and confirmed with RT-PCR. No statistical differences were found in the microbial profile (P > 0.05) between the different farming practices. The APC, coliforms, E. coli, and YM counts were similar across bagged samples. The results demonstrated that APC and E. coli were significantly higher (P<0.05) in organic non-bagged samples compared to other practices. Salmonella and L. monocytogenes were detected in some organically and conventionally grown lettuce samples but were only detected in 3 hydroponically grown lettuce samples. This study indicated that hydroponically grown lettuce obtained at retail may have food safety risks similar to organic and conventional systems. These findings highlight the need for food safety training and educational programs.
Collapse
|
11
|
Moyne AL, Waite-Cusic J, Harris LJ. Water Application Method Influences Survival or Growth of Escherichia coli on Bulb Onions during Field Curing. J Food Prot 2022; 85:961-972. [PMID: 35333326 DOI: 10.4315/jfp-21-394] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/20/2021] [Accepted: 03/19/2022] [Indexed: 11/11/2022]
Abstract
ABSTRACT The impact of water application method on bacterial survival at or after the final irrigation was evaluated in bulb onions during commercially relevant field drying (curing). A three-strain rifampin-resistant cocktail of Escherichia coli was introduced to onions via a single overhead spray application in two separate trials (5.22 [trial 1] or 2.40 [trial 2] log CFU per onion) 2 to 3 days after the final irrigation. Onions were lifted from the soil 8 days after spray inoculation and, in some cases, foliage was removed (topping); onions remained in the field for an additional ca. 2 weeks (total ca. 3 weeks of curing). E. coli populations declined on the onions in the first 4 h after spray inoculation. E. coli was recovered from 38 (48%) or 28 (35%) of 80 whole-onion enrichments at the end of curing in trials 1 or 2, respectively. Topping did not significantly impact the percentage of E. coli-positive onions detected at the end of curing. From 8 h to 21 days, E. coli populations on positive onions ranged from 1 CFU per onion to 7 log CFU per onion in both trials, representing a potential risk of E. coli growth with overhead application of contaminated water at the end of onion production. In trial 2, additional rows of onions were inoculated via a 22-cm subsurface or surface drip irrigation line (1.94 log CFU/mL for 2.5 h). E. coli was detected in 0 (subsurface) and 4 (surface) of 50 whole-onion enrichments 3 h after the initiation of drip irrigation. Positive onions were detected at days 1 (4 of 50) and 7 (1 of 50) with subsurface drip inoculation, and at days 1 (7 of 50), 7 (2 of 50), and 14 (2 of 50) with surface drip inoculation. E. coli was not detected in whole-onion enrichments at the end of curing when inoculated by subsurface (0 of 50) or surface (0 of 50) drip irrigation. Application of contaminated water through drip irrigation, when coupled with field curing, results in low rates of contamination of bulb onions at the time of harvest. HIGHLIGHTS
Collapse
Affiliation(s)
- Anne-Laure Moyne
- Department of Food Science and Technology, University of California, Davis, One Shields Avenue, Davis, California 95616-5270.,Western Center for Food Safety, University of California, Davis, One Shields Avenue, Davis, California 95618
| | - Joy Waite-Cusic
- Department of Food Science and Technology, Oregon State University, Corvallis, Oregon, USA
| | - Linda J Harris
- Department of Food Science and Technology, University of California, Davis, One Shields Avenue, Davis, California 95616-5270.,Western Center for Food Safety, University of California, Davis, One Shields Avenue, Davis, California 95618
| |
Collapse
|
12
|
Doren J, Hadad R, McKEAG L, Tucker C, Newbold E. Food Safety Risks of Harvesting Dropped and Drooping Produce: A Review. J Food Prot 2022; 85:571-582. [PMID: 34914837 DOI: 10.4315/jfp-21-369] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/29/2021] [Accepted: 12/10/2021] [Indexed: 11/11/2022]
Abstract
ABSTRACT The Produce Safety Rule of the Food Safety Modernization Act (FSMA) sets forth minimum standards for fruit and vegetable production in the United States. One provision states that growers must not harvest dropped produce because damage or ground contact may contaminate produce. In an unpublished survey of 2020 food safety inspections conducted by the Northeast Center to Advance Food Safety, handling of dropped produce covered by the FSMA was a common misunderstood and noncompliance issue among growers in the Northeast. In consideration of this provision's on-farm practicality, this review was conducted to evaluate the risks associated with dropped and drooping produce, to guide growers in making informed risk management decisions, and to answer the following questions: (i) what are the risk factors that influence transferability of pathogens from touching the ground to produce and (ii) what are the risks associated with harvesting dropped or drooping produce covered under the Produce Safety Rule? A search of online databases revealed 12 relevant publications, which highlighted moisture, contact time, and crop features as affecting contamination rates from a ground surface to a crop surface. Soil and mulch posed a differential risk, with bare soil generally presenting a lower risk than plastic mulch. The effects of other mulch types are unclear. Mulches may promote pathogen persistence in soil, although they may also protect produce from contaminated soils. These studies were limited in their scope and applicability and most did not directly address dropped produce. Research is needed to clarify the various effects of dropped and drooping produce, the impact of ground surface type on pathogen survivability and transfer, soil and crop features that facilitate contamination, and postharvest risks of harvesting dropped or drooping produce. A comprehensive understanding of these issues will guide growers in implementing preventive measures and better managing risk in a way practicable to each farm's unique conditions. HIGHLIGHTS
Collapse
Affiliation(s)
- Johanna Doren
- Northeast Center to Advance Food Safety, University of Vermont Extension, Bennington, Vermont 05201
| | - Robert Hadad
- Cornell Vegetable Program, Cornell Cooperative Extension, Rochester, New York 14617
| | - Lisa McKEAG
- Center for Agriculture, Food, and the Environment, University of Massachusetts Extension, Amherst, Massachusetts 01003, USA
| | - Caitlin Tucker
- Cornell Vegetable Program, Cornell Cooperative Extension, Rochester, New York 14617
| | - Elizabeth Newbold
- Northeast Center to Advance Food Safety, University of Vermont Extension, Bennington, Vermont 05201
| |
Collapse
|
13
|
Quansah JK, Chen J. Antibiotic Resistance Profile of Salmonella enterica Isolated from Exotic and Indigenous Leafy Green Vegetables in Accra, Ghana. J Food Prot 2021; 84:1040-1046. [PMID: 33508091 DOI: 10.4315/jfp-20-442] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/03/2020] [Accepted: 01/19/2021] [Indexed: 12/24/2022]
Abstract
ABSTRACT Fresh produce-borne enteric bacterial pathogens that are resistant to antibiotics have posed serious challenges to food safety and public health worldwide. This study was conducted to evaluate the antibiotic resistance profiles of Salmonella enterica isolates (n = 33) recovered from exotic and indigenous leafy green vegetable samples (n = 328) collected from 50 vegetable farms in 12 farming areas and 37 vegetable sellers in four market centers in Accra, Ghana, from March 2016 to March 2017 and to determine the distribution of integrons among antibiotic-resistant isolates. The susceptibility of the Salmonella isolates to 12 antibiotics was assayed with the standard disk diffusion assay. The MICs of the five most resisted antibiotics were determined with a twofold macrodilution method. A PCR assay was used to detect the presence of integrons in Salmonella isolates, and PCR products with the amplified integron gene cassette were purified and sequenced with the Sanger sequencing technology. The Salmonella isolates used in the study were resistant to at least one tested antibiotic, and 30.3% (10 of 33) of the isolates were multidrug resistant. Most isolates (81.8%) were resistant to sulfisoxazole. The MICs of tetracycline, cefoxitin, streptomycin, ampicillin, and sulfisoxazole were 16, 32, 64, 64, and >1,024 μg/mL, respectively. Five patterns of multidrug resistance were observed among the Salmonella isolates, and the most common patterns were AAuFox (30.3%) and AAuFoxSSu (18.1%). One (3.0%) of the 33 Salmonella isolates tested positive for the class 1 integron, with a gene cassette of about 800 bp. Nucleotide sequencing revealed that this class 1 integron carried a single gene, dfrA7. Further studies are needed to determine whether the consumption of contaminated leafy green vegetables is a route for acquiring antibiotic-resistant Salmonella in Accra, Ghana. HIGHLIGHTS
Collapse
Affiliation(s)
- Joycelyn K Quansah
- Department of Food Science and Technology, The University of Georgia, Griffin, Georgia 30223-1797, USA
- Department of Nutrition and Food Science, University of Ghana, Legon, P.O. Box LG 134, Legon, Ghana
| | - Jinru Chen
- Department of Food Science and Technology, The University of Georgia, Griffin, Georgia 30223-1797, USA
| |
Collapse
|
14
|
Mao X, Xiao W, Wan Y, Li Z, Luo D, Yang H. Dispersive solid-phase extraction using microporous metal-organic framework UiO-66: Improving the matrix compounds removal for assaying pesticide residues in organic and conventional vegetables. Food Chem 2020; 345:128807. [PMID: 33310261 DOI: 10.1016/j.foodchem.2020.128807] [Citation(s) in RCA: 49] [Impact Index Per Article: 12.3] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/02/2020] [Revised: 11/19/2020] [Accepted: 11/30/2020] [Indexed: 02/07/2023]
Abstract
An efficient dispersive solid-phase extraction method was developed to trace pesticide residues in commonly consumed vegetables. In this method, UiO-66 with uniform micropores was used as sorbent, and gas chromatography-mass spectrometry was applied to detect the pesticides. Thanks to the size sieving action of uniform micropores, UiO-66 directly extracted the target pesticides from vegetable matrices and excluded the relatively large matrix compounds. This well eliminated the matrix effect. The important experimental conditions were evaluated by orthogonal array experimental design. In optimized conditions, good linearity (R2 ≥ 0.99), detection limits (0.4-2.0 ng/g), recoveries (60.9-117.5%) and precision (relativestandarddeviations < 14.6%) were achieved. Moreover, the sorbent UiO-66 can be reused more than 20 times. These demonstrate a simple, reliable and robust method to screen the pesticide residues in vegetables. Furthermore, the validated method was applied to detect the pesticides in various organic and conventional vegetables.
Collapse
Affiliation(s)
- Xuejin Mao
- State Key Laboratory of Food Science and Technology, Nanchang University, Nanchang 330047, China; Jiangxi Province Key Laboratory of Modern Analytical Science, Nanchang University, Nanchang 330031, China
| | - Weiming Xiao
- Key Laboratory of Jiangxi Province for Environment and Energy Catalysis, College of Chemistry, Nanchang University, Nanchang 330031, China
| | - Yiqun Wan
- State Key Laboratory of Food Science and Technology, Nanchang University, Nanchang 330047, China; Jiangxi Province Key Laboratory of Modern Analytical Science, Nanchang University, Nanchang 330031, China.
| | - Zhanming Li
- Department of Food Science and Technology, National University of Singapore, Singapore 117542, Singapore
| | - Dongmei Luo
- College of Chemistry and Chemical Engineering, Chifeng University, Chifeng 024000, China
| | - Hongshun Yang
- Department of Food Science and Technology, National University of Singapore, Singapore 117542, Singapore.
| |
Collapse
|
15
|
Abstract
Nearly one-half of foodborne illnesses in the United States can be attributed to fresh produce consumption. The preharvest stage of production presents a critical opportunity to prevent produce contamination in the field from contaminating postharvest operations and exposing consumers to foodborne pathogens. One produce-contamination route that is not often explored is the transfer of pathogens in the soil to edible portions of crops via splash water. We report here on the results from multiple field and microcosm experiments examining the potential for Salmonella contamination of produce crops via splash water, and the effect of soil moisture content on Salmonella survival in soil and concentration in splash water. In field and microcosm experiments, we detected Salmonella for up to 8 to 10 days after inoculation in soil and on produce. Salmonella and suspended solids were detected in splash water at heights of up to 80 cm from the soil surface. Soil-moisture conditions before the splash event influenced the detection of Salmonella on crops after the splash events-Salmonella concentrations on produce after rainfall were significantly higher in wet plots than in dry plots (geometric mean difference = 0.43 CFU/g; P = 0.03). Similarly, concentrations of Salmonella in splash water in wet plots trended higher than concentrations from dry plots (geometric mean difference = 0.67 CFU/100 mL; P = 0.04). These results indicate that splash transfer of Salmonella from soil onto crops can occur and that antecedent soil-moisture content may mediate the efficiency of microbial transfer. Splash transfer of Salmonella may, therefore, pose a hazard to produce safety. The potential for the risk of splash should be further explored in agricultural regions in which Salmonella and other pathogens are present in soil. These results will help inform the assessment of produce safety risk and the development of management practices for the mitigation of produce contamination.
Collapse
Affiliation(s)
- Debbie Lee
- Department of Environmental Health, Rollins School of Public Health, Emory University, 1518 Clifton Road, Atlanta, Georgia 30322
| | | | | | | | - Karen Levy
- Department of Environmental Health, Rollins School of Public Health, Emory University, 1518 Clifton Road, Atlanta, Georgia 30322
| | - Timothy Coolong
- Department of Horticulture, College of Agricultural & Environmental Sciences, University of Georgia, 2360 Rainwater Road, Tifton, Georgia 31793, USA
| |
Collapse
|
16
|
Zhang H, Dolan HL, Ding Q, Wang S, Tikekar RV. Antimicrobial action of octanoic acid against Escherichia coli O157:H7 during washing of baby spinach and grape tomatoes. Food Res Int 2019; 125:108523. [PMID: 31554067 DOI: 10.1016/j.foodres.2019.108523] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/05/2019] [Revised: 06/14/2019] [Accepted: 06/21/2019] [Indexed: 01/04/2023]
Abstract
We investigated the antimicrobial efficacy of octanoic acid (OA) against Escherichia coli O157:H7 inoculated on the surface of baby spinach and grape tomatoes during simulated washing processes. 3 mM OA at 45 °C achieved >6 log CFU/g reduction from the surface of tomatoes within 2 min. However, washing baby spinach with 6 mM OA at 5 °C resulted in <1 log CFU/g reduction, highlighting the role of surface properties in inactivation efficacy. OA significantly (p < 0.05) reduced the risk of cross-contamination during washing of spinach as well as tomatoes. Also, total mold and yeast population on surface of spinach was significantly reduced immediately after OA wash and inhibited during following 14 days. Baby spinach and grape tomatoes washed with OA did not cause significant (p > 0.05) difference in color compared to the control and no residual OA was detected in most cases following rinsing of produce in water. OA at the concentrations above 2 mM and temperature higher than 25 °C induced severe membrane damage along with release of ATP and other intracellular constituents resulting in bacterial death. OA can be an attractive natural decontamination agent for washing fresh produce.
Collapse
Affiliation(s)
- Hongchao Zhang
- Department of Nutrition and Food Science, University of Maryland, College Park, MD 20770, United States
| | - Heather Leigh Dolan
- Department of Nutrition and Food Science, University of Maryland, College Park, MD 20770, United States
| | - Qiao Ding
- Department of Nutrition and Food Science, University of Maryland, College Park, MD 20770, United States
| | - Siyuan Wang
- Department of Nutrition and Food Science, University of Maryland, College Park, MD 20770, United States
| | - Rohan V Tikekar
- Department of Nutrition and Food Science, University of Maryland, College Park, MD 20770, United States.
| |
Collapse
|
17
|
Callahan MT, Van Kessel JA, Micallef SA. Salmonella enterica recovery from river waters of the Maryland Eastern Shore reveals high serotype diversity and some multidrug resistance. Environ Res 2019; 168:7-13. [PMID: 30253315 DOI: 10.1016/j.envres.2018.09.012] [Citation(s) in RCA: 16] [Impact Index Per Article: 3.2] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/15/2018] [Revised: 09/06/2018] [Accepted: 09/11/2018] [Indexed: 06/08/2023]
Abstract
The Delmarva Peninsula, a major agricultural and recreational region for the U.S. states of Delaware, Maryland and Virginia, experiences recurrent salmonellosis disease. Previous studies point to water environments as a potential persistent environmental reservoir of Salmonella enterica. To evaluate this hypothesis, water from the four main rivers of the Maryland Eastern Shore on the Delmarva Peninsula was tested for the presence of S. enterica, and recovered isolates were characterized for antimicrobial resistance. Sampling was performed in autumn and spring to evaluate temporal persistence at twenty four sites along the Choptank, Nanticoke, Pocomoke and Wicomico Rivers. Water (10 L) was filtered through sterile modified Moore swabs in situ. Swabs were selectively enriched for S. enterica and presumptive salmonellae were confirmed by PCR amplification of the Salmonella-specific invA and hilA genes. The serogroup of 402 isolates was determined, followed by serotype characterization for 157 isolates selected to represent all the identified serogroups across all samples. S. enterica was isolated from all the rivers in both seasons and was detected in 35/46 (65%) of surface water samples, with equivalent recovery in spring (70%) and fall (61%). The likelihood of isolating S. enterica was higher for the Nanticoke and Pocomoke Rivers, χ2 (3, N = 46) = 12.75, p < 0.01. In total, 18 serotypes of S. enterica were identified, and serotype diversity differed between the fall and spring samplings. Newport was the most frequently isolated serotype, both overall and in the fall, identified in 8/46 samples (17%). Typhimurium was the predominant serotype in spring. Some temporal and biogeographic patterns were observed in S. enterica recovery, but 6/18 serotypes were identified in both seasons. The majority (84%) of isolates were pan-susceptible, including all those tested from the Wicomico River (N = 19). Twenty five isolates (16%) from 9 samples were resistant to at least one antimicrobial, including serotypes Typhimurium, Newport, Litchfield, III 17:z10: e,n,x,z15, III 60:I and IV_40:z4: z32: -. Of the isolates that were resistant to a single antimicrobial (N = 12), resistance was to streptomycin or sulfisoxazole. Thirteen isolates were multidrug resistant, nine exhibiting resistance to ampicillin, sulfisoxazole, tetracycline, amoxicillin/clavulanic acid, cefoxitin and ceftriaxone, and four to sulfisoxazole and tetracycline. The widespread presence and diversity of S. enterica in Delmarva rivers are concerning given the frequent use of rivers and tributaries as a source of irrigation and for recreation. Future research should seek to determine specific point sources of S. enterica for surface river waters, and risks associated with acquisition of antimicrobial resistance traits.
Collapse
Affiliation(s)
- Mary Theresa Callahan
- Department of Plant Science and Landscape Architecture, University of Maryland, College Park, MD, USA
| | - Jo Ann Van Kessel
- Environmental Microbial and Food Safety Laboratory, Beltsville Agricultural Research Center, ARS-USDA, Beltsville, MD, USA
| | - Shirley A Micallef
- Department of Plant Science and Landscape Architecture, University of Maryland, College Park, MD, USA; Centre for Food Safety and Security Systems, University of Maryland, College Park, MD, USA.
| |
Collapse
|
18
|
Gutiérrez-Rodríguez E, Gundersen A, Sbodio A, Koike S, Suslow TV. Evaluation of post-contamination survival and persistence of applied attenuated E. coli O157:H7 and naturally-contaminating E. coli O157:H7 on spinach under field conditions and following postharvest handling. Food Microbiol 2019; 77:173-84. [PMID: 30297048 DOI: 10.1016/j.fm.2018.08.013] [Citation(s) in RCA: 13] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/15/2018] [Revised: 08/23/2018] [Accepted: 08/23/2018] [Indexed: 11/23/2022]
Abstract
This study determined the variability in population uniformity of an applied mixture of attenuated E. coli O157:H7 (attEcO157) on spinach leaves as impacted by sampling mass and detection technique over spatial and temporal conditions. Opportunistically, the survival and distribution of naturally contaminating pathogenic E. coli O157:H7 (EcO157), in a single packaged lot following commercial postharvest handling and washing, was also evaluated. From the main study outcomes, differences in the applied inoculum dose of 100-fold, resulted in indistinguishable population densities of approximately Log 1.1 CFU g-1 by 14 days post-inoculation (DPI). Composite leaf samples of 150 g and the inclusion of the spinach petiole resulted in the greatest numerical sensitivity of detection of attEcO157 when compared to 25 and 150 g samples without petioles (P < 0.05). Differences in population density and protected-site survival and potential leaf internalization were observed between growing seasons and locations in California (P < 0.05). A Double Weibull model best described and identified two distinct populations with different inactivation rates of the inoculated attEcO157. Linear die-off rates varied between 0.14 and 0.29 Log/Day irrespective of location. Detection of EcO157- stx1-negative and stx2-positive, resulting from a natural contamination event, was observed in 11 of 26 quarantined commercial units of washed spinach by applying the 150 g sample mass protocol. The capacity to detect EcO157 varied between commercial test kits and non-commercial qPCR. Our findings suggest the need for modifications to routine pathogen sampling protocols employed for lot acceptance of spinach and other leafy greens.
Collapse
|
19
|
Cai S, Worobo RW, Snyder AB. Outgraded produce variably retains surface inoculated Escherichia coli through washing. Int J Food Microbiol 2018; 269:27-35. [PMID: 29421355 DOI: 10.1016/j.ijfoodmicro.2018.01.012] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/17/2017] [Revised: 12/20/2017] [Accepted: 01/10/2018] [Indexed: 11/22/2022]
Abstract
The use of secondary quality produce has gained attention as a solution to food waste in both the U.S. and Europe. The purpose of this study was to evaluate the impact of using secondary quality or outgraded produce on the retention of surface inoculated E. coli following a rinse treatment on four model fresh produce systems (apple, tomato, carrot, lettuce). A three-strain cocktail of rifampicin-resistant generic E. coli, with a concentration of 9.0 log CFU/mL, was spot-inoculated on the intact surfaces of U.S. No.1 grade produce items and damaged or decayed areas of outgraded produce items. Generally, outgraded produce of all four kinds retained higher levels of inoculated E. coli following two postharvest treatments, chlorinated (150 ppm) or water only. However, physical damage, those defects which compromised the integrity of the produce surface, lead to significantly greater E. coli levels following rinsing than did physiological defects. Compared to U.S. No.1 quality apples, outgraded apples retained 4.3 ± 1.4 log CFU/g more E. coli following water only treatment, and 3.6 ± 1.7 log CFU/g more following chlorine treatment. Outgraded tomatoes retained significantly more (3.5 ± 1.1 log CFU/g) inoculated E. coli following water only rinse and 3.0 ± 1.4 log CFU/g more inoculated E. coli following chlorine treatment than U.S. No.1 quality tomatoes did under the same treatment conditions. Outgraded carrots retained 1 ± 1.1 log more CFU/g inoculated E. coli following water only treatment and 0.5 ± 0.8 log more CFU/g inoculated E. coli following chlorine treatment, compared to U.S. No.1 carrots. Outgraded lettuce leaves retained 1.6 ± 0.5 log CFU/g more inoculated E. coli following water only treatment and 4.1 ± 0.4 log CFU/g more inoculated E. coli following chlorine treatment than did U.S. No.1 quality lettuce leaves under the same treatment conditions. Treating with 150 ppm chlorine was not sufficient to eliminate the increased microbial retention associated with secondary quality or outgraded produce, and the efficacy of disinfection was greatly affected by type of defect. Apples with physical damage retained significantly higher E. coli loads than did those with physiological defects, an additional 2.6 log CFU/g under chlorine treatment and 0.8 log CFU/g more under was water only treatment. Tomatoes with physical damage had a 1.3-log CFU/g and 0.6-log CFU/g average increase of retained E. coli counts compared to those with physiological defects following a chlorine and water only treatment, respectively. Although a chlorine dip provided only a modest reduction in pathogens, generally, outgraded produce with physiological defects may present less food safety risks if introduced into the fresh market than does produce with physical damage due to their enhanced retention of bacterial cells. Therefore, as industry considers how to minimize its food waste problem, preferentially directing physically damaged produce away from the fresh market will help to minimize risk while maximizing food resources.
Collapse
Affiliation(s)
- Shiyu Cai
- Department of Food Science, Cornell University, Ithaca, NY 14853, United States
| | - Randy W Worobo
- Department of Food Science, Cornell University, Ithaca, NY 14853, United States
| | - Abigail B Snyder
- Department of Extension, The Ohio State University, Wooster, OH 44691, United States.
| |
Collapse
|
20
|
Ding Q, Alborzi S, Bastarrachea LJ, Tikekar RV. Novel sanitization approach based on synergistic action of UV-A light and benzoic acid: Inactivation mechanism and a potential application in washing fresh produce. Food Microbiol 2017; 72:39-54. [PMID: 29407404 DOI: 10.1016/j.fm.2017.11.004] [Citation(s) in RCA: 25] [Impact Index Per Article: 3.6] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/22/2017] [Revised: 11/03/2017] [Accepted: 11/06/2017] [Indexed: 12/17/2022]
Abstract
Antimicrobial activity of the simultaneous UV-A light and benzoic acid (BA) treatment against stationary phase Escherichia coli O157:H7 was investigated. While 15 mM BA or UV-A light exposure for 30 min alone caused < 1 logarithmic reduction in the bacterial population, > 5 logarithmic reductions were induced by the simultaneous application of UV-A and 15 mM BA in 30 min, demonstrating a synergistic antimicrobial effect. Due to its ability to increase cell membrane permeability, addition of EDTA (1 mM) was able to decrease the required concentration of BA in the simultaneous treatment from 15 to 8 mM. Microbial inactivation was a result of simultaneous membrane damage, intracellular acidification, and intracellular oxidative stress. The simultaneous treatment was effective in the presence of organic load of up to 500 mg/L of chemical oxygen demand (COD) and was able to lower cross-contamination risk during simulated washing of spinach (Spinacia oleracea) without adversely affecting its color.
Collapse
Affiliation(s)
- Qiao Ding
- Department of Nutrition and Food Science, University of Maryland, 112 Skinner Building, College Park, MD 20742, United States
| | - Solmaz Alborzi
- Department of Nutrition and Food Science, University of Maryland, 112 Skinner Building, College Park, MD 20742, United States
| | - Luis J Bastarrachea
- Department of Nutrition, Dietetics and Food Sciences, Utah State University, 8700 Old Main Hill, Logan, UT 84322, United States
| | - Rohan V Tikekar
- Department of Nutrition and Food Science, University of Maryland, 112 Skinner Building, College Park, MD 20742, United States.
| |
Collapse
|
21
|
Hsu CK, Micallef SA. Plant-mediated restriction of Salmonella enterica on tomato and spinach leaves colonized with Pseudomonas plant growth-promoting rhizobacteria. Int J Food Microbiol 2017; 259:1-6. [PMID: 28778009 DOI: 10.1016/j.ijfoodmicro.2017.07.012] [Citation(s) in RCA: 16] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/03/2017] [Revised: 06/30/2017] [Accepted: 07/19/2017] [Indexed: 12/27/2022]
Abstract
Reducing Salmonella enterica association with plants during crop production could reduce risks of fresh produce-borne salmonellosis. Plant growth-promoting rhizobacteria (PGPR) colonizing plant roots are capable of promoting plant growth and boosting resistance to disease, but the effects of PGPR on human pathogen-plant associations are not known. Two root-colonizing Pseudomonas strains S2 and S4 were investigated in spinach, lettuce and tomato for their plant growth-promoting properties and their influence on leaf populations of S. enterica serovar Newport. Plant roots were inoculated with Pseudomonas in the seedling stage. At four (tomato) and six (spinach and lettuce) weeks post-germination, plant growth promotion was assessed by shoot dry weight (SDW) and leaf chlorophyll content measurements. Leaf populations of S. Newport were measured after 24h of leaf inoculation with this pathogen by direct plate counts on Tryptic Soy Agar. Root inoculation of spinach cv. 'Tyee', with Pseudomonas strain S2 or S4 resulted in a 69% and 63% increase in SDW compared to non-inoculated controls (p<0.005 and p<0.01, respectively). Similarly, Romaine lettuce cv. 'Parris Island Cos' responded positively to S2 and S4 inoculation (53% and 48% SDW increase, respectively; p<0.05), and an increase in leaf chlorophyll content (p<0.001), compared to controls. Tomato cv. 'Nyagous' yielded significantly greater SDW (74%, p<0.01 and 54%, p<0.05 for S2 and S4, respectively), and also higher leaf chlorophyll content (19% and 29%, p<0.001, respectively) relative to controls. Leaf chlorophyll content only increased in S4-inoculated tomato cv. 'Moneymaker' plants (27%, p<0.001), although both S2 and S4 promoted plant growth by over 40% compared to controls (p<0.01 and p<0.05, respectively). No significant growth promotion was detected in tomato cv. 'BHN602', but S2-inoculated plants had elevated leaf chlorophyll content (13%, p<0.01). Root inoculation with Pseudomonas S4 restricted S. Newport populations inoculated on leaves of spinach (p<0.001) and all three tomato cultivars (p<0.05), compared to controls, 24h post Salmonella inoculation. Impairment of S. Newport leaf populations was also observed on spinach when plant roots were inoculated with S2 (p<0.01). With an initial leaf inoculum of approximately 6.0logCFU of S. Newport/plant, the significantly greater reduction of S. Newport populations on Pseudomonas-treated plants than those on non-inoculated control plants after 24h was modest with differences of one log or less. By contrast, the survival of S. Newport on the leaves of Romaine lettuce was not influenced by Pseudomonas root colonization. These findings provide evidence that root inoculation of certain specialty crops with beneficial Pseudomonas strains exhibiting PGPR properties may not only promote plant growth, but also reduce the fitness of epiphytic S. enterica in the phyllosphere. Plant-mediated effects induced by PGPR may be an effective strategy to minimize contamination of crops with S. enterica during cultivation.
Collapse
Affiliation(s)
- Chiun-Kang Hsu
- Department of Plant Science and Landscape Architecture, University of Maryland, College Park, MD 20742, USA
| | - Shirley A Micallef
- Department of Plant Science and Landscape Architecture, University of Maryland, College Park, MD 20742, USA; Center for Food Safety and Security Systems, University of Maryland, College Park, MD 20742, USA.
| |
Collapse
|
22
|
Abstract
The objective of this study was to evaluate the potential of cinnamon oil emulsions as alternative washing solutions to improve the microbial safety of carrots. Whey protein concentrate (WPC), gum arabic (GA), lecithin, and their combinations were used to prepare cinnamon oil emulsions. The emulsions were characterized for their hydrodynamic diameter (Dh) during 7 days of storage and their antimicrobial activity against cocktails of Salmonella enterica , Escherichia coli O157:H7, and Listeria monocytogenes . The Dh of the emulsion prepared with the GA+WPC blend did not change significantly (195.0 to 184.1 nm), whereas all other emulsions showed varying degrees of increases in Dh. Compared with free cinnamon oil dissolved in 5% ethanol, all emulsions showed similar or lower MICs and MBCs. Emulsions prepared with GA and equal masses of GA and WPC were chosen and diluted to 0.2 and 0.5% cinnamon oil to wash carrots that were surface inoculated with bacterial cocktails because of their lower MICs and MBCs than free oil. Emulsions resulted in significantly higher reductions of pathogens on carrots than free cinnamon oil, 3.0 to 3.7 versus 2.1 to 2.3 log CFU/g at 0.5% cinnamon oil and 2.0 to 3.0 versus 1.0 to 1.7 log CFU/g at 0.2% cinnamon oil. No transfer of bacteria from inoculated carrots to wash solutions and no effects of organic load on log reductions were only observed for wash treatments with 0.5% emulsified cinnamon oil. Thus, the cinnamon oil emulsions are potential alternative postharvest washing solutions for fresh produce production.
Collapse
Affiliation(s)
- Yue Zhang
- Department of Food Science and Technology, 2510 River Drive, University of Tennessee, Knoxville, Tennessee 37996, USA
| | - Huaiqiong Chen
- Department of Food Science and Technology, 2510 River Drive, University of Tennessee, Knoxville, Tennessee 37996, USA
| | - Faith Critzer
- Department of Food Science and Technology, 2510 River Drive, University of Tennessee, Knoxville, Tennessee 37996, USA
| | - P Michael Davidson
- Department of Food Science and Technology, 2510 River Drive, University of Tennessee, Knoxville, Tennessee 37996, USA
| | - Qixin Zhong
- Department of Food Science and Technology, 2510 River Drive, University of Tennessee, Knoxville, Tennessee 37996, USA
| |
Collapse
|
23
|
Xu A, Buchanan RL, Micallef SA. Impact of mulches and growing season on indicator bacteria survival during lettuce cultivation. Int J Food Microbiol 2016; 224:28-39. [PMID: 26938806 DOI: 10.1016/j.ijfoodmicro.2016.02.013] [Citation(s) in RCA: 18] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/06/2015] [Revised: 11/11/2015] [Accepted: 02/19/2016] [Indexed: 11/22/2022]
Abstract
In fresh produce production, the use of mulches as ground cover to retain moisture and control weeds is a common agricultural practice, but the influence that various mulches have on enteric pathogen survival and dispersal is unknown. The goal of this study was to assess the impact of different mulching methods on the survival of soil and epiphytic fecal indicator bacteria on organically grown lettuce during different growing seasons. Organically managed lettuce, cultivated with various ground covers--polyethylene plastic, corn-based biodegradable plastic, paper and straw mulch--and bare ground as a no-mulch control, was overhead inoculated with manure-contaminated water containing known levels of generic Escherichia coli and Enterococcus spp. Leaves and soil samples were collected at intervals over a two week period on days 0, 1, 3, 5, 7, 10 and 14, and quantitatively assessed for E. coli, fecal coliforms and Enterococcus spp. Data were analyzed using mixed models with repeated measures and an exponential decline with asymptote survival model. Indicator bacterial concentrations in the lettuce phyllosphere decreased over time under all treatments, with more rapid E. coli declines in the fall than in the spring (p<0.01). Persistence of E. coli in spring was correlated with higher maximum and minimum temperatures in this season, and more regular rainfall. The survival model gave very good fits for the progression of E. coli concentrations in the phyllosphere over time (R(2)=0.88 ± 0.12). In the spring season, decline rates of E. coli counts were faster (2013 p=0.18; 2014 p<0.005) for the bare ground-cultivated lettuce compared to mulches. In fall 2014, the E. coli decline rate on paper mulch-grown lettuce was higher (p<0.005). Bacteria fluctuated more, and persisted longer, in soil compared to lettuce phyllosphere, and mulch type was a factor for fecal coliform levels (p<0.05), with higher counts retrieved under plastic mulches in all trials, and higher enterococci levels under straw in fall 2014 (p<0.05). This study demonstrates that mulches used in lettuce production may impact the fate of enteric bacteria in soil or on lettuce, most likely in relation to soil moisture retention, and other weather-related factors, such as temperature and rainfall. The data suggest that the time between exposure to a source of enteric bacteria and harvesting of the crop is season dependent, which has implications for determining best harvest times.
Collapse
Affiliation(s)
- Aixia Xu
- Department of Nutrition and Food Science, University of Maryland, College Park, MD 20742, USA
| | - Robert L Buchanan
- Department of Nutrition and Food Science, University of Maryland, College Park, MD 20742, USA; Center for Food Safety and Security Systems, University of Maryland, College Park, MD 20742, USA
| | - Shirley A Micallef
- Department of Plant Science and Landscape Architecture, University of Maryland, College Park, MD 20742, USA; Center for Food Safety and Security Systems, University of Maryland, College Park, MD 20742, USA.
| |
Collapse
|
24
|
Marvasi M, George AS, Giurcanu MC, Hochmuth GJ, Noel JT, Teplitski M. Effect of the irrigation regime on the susceptibility of pepper and tomato to post-harvest proliferation of Salmonella enterica. Food Microbiol 2014; 46:139-144. [PMID: 25475277 DOI: 10.1016/j.fm.2014.07.014] [Citation(s) in RCA: 9] [Impact Index Per Article: 0.9] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/25/2013] [Revised: 07/15/2014] [Accepted: 07/17/2014] [Indexed: 11/18/2022]
Abstract
Raw produce is increasingly recognized as a vehicle of human gastroenteritis. Non-typhoidal Salmonella, pathogenic Escherichia coli, and other human pathogens have been isolated from fruits and vegetables in the field and in the marketplace, which led to the hypothesis that these microbes can use plants as alternate hosts. However, environmental and physiological factors that facilitate persistence of these bacteria in the crop production environment and make produce more vulnerable to post-harvest contamination have not been fully delineated. This study tested the effect of irrigation regimes on the susceptibility of peppers and tomatoes to post-harvest proliferation of Salmonella. The experiments were carried out over three experimental seasons in two locations using seven strains of Salmonella. The irrigation regime per se did not affect susceptibility of tomatoes and peppers to post-harvest proliferation of Salmonella; however, in some of the seasons, irrigation regime-dependent differences were observed. Red peppers and tomatoes were more conducive to proliferation of Salmonella than green fruit in all seasons. Inter-seasonal differences were the strongest factors affecting proliferation of Salmonella in peppers.
Collapse
Affiliation(s)
- Massimiliano Marvasi
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA
| | - Andrée S George
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA
| | - Mihai C Giurcanu
- Department of Statistics, University of Florida, Gainesville, FL, USA
| | - George J Hochmuth
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA
| | - Jason T Noel
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA
| | - Max Teplitski
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA.
| |
Collapse
|
25
|
Marvasi M, George AS, Giurcanu M, Hochmuth GJ, Noel JT, Gause E, Teplitski M. Effects of nitrogen and potassium fertilization on the susceptibility of tomatoes to post-harvest proliferation of Salmonella enterica. Food Microbiol 2014; 43:20-7. [PMID: 24929878 DOI: 10.1016/j.fm.2014.03.017] [Citation(s) in RCA: 8] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/11/2013] [Revised: 03/21/2014] [Accepted: 03/22/2014] [Indexed: 10/25/2022]
Abstract
Fresh fruits and vegetables are increasingly recognized as vehicles of salmonellosis. Pre- and post-harvest environmental conditions, and physiological, and genetic factors are thought to contribute to the ability of human pathogens to persist in the production environment, attach to, colonize and proliferate in and on raw produce. How field production conditions affect the post-harvest food safety outcomes is not entirely understood. This study tested how varying nitrogen and potassium fertilization levels affected the "susceptibility" of tomatoes to Salmonella infections following the harvest of fruits. Two tomato varieties grown over three seasons under high, medium, and low levels of nitrogen and potassium fertilization in two locations were inoculated with seven strains of Salmonella. Even though the main effects of nitrogen and potassium fertilization on the susceptibility of tomatoes to infections with Salmonella enterica were not statistically significant overall, differences in nitrogen concentrations in plant tissues correlated with the susceptibility of partially ripe tomatoes (cv. Solar Fire) to Salmonella. Tomato maturity and the season in which tomatoes were produced had the strongest effect on the ability of Salmonella to multiply in tomatoes. Tomato phenolics, accumulation of which is known to correlate with rates of the N fertilization, did not inhibit growth of Salmonella in vitro.
Collapse
Affiliation(s)
- Massimiliano Marvasi
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA
| | - Andrée S George
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA
| | - Mihai Giurcanu
- Statistics Department, University of Florida, Gainesville, FL, USA
| | - George J Hochmuth
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA
| | - Jason T Noel
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA
| | - Elizabeth Gause
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA
| | - Max Teplitski
- Department of Soil and Water Science, University of Florida, Gainesville, FL, USA.
| |
Collapse
|