Validated method for quantitation of biomarkers for benzene and its alkylated analogues in urine

Ethyl chloroformate mediated gas chromatographic-mass spectrometric biomonitoring of acidic biomarkers of occupational exposure and endogenous metabolites in human urine

Numerous industrial organic pollutants such as aromates, alkoxyalcohols, other organic solvents and monomers are absorbed, metabolized, and finally excreted in urine mostly as carboxylic acids that are determined as biomarkers of exposure. For a number of these xenometabolites, biological limits (levels of biomarkers in biological material) have been established to prevent damage to human health. Till now, most of the analytical procedures used have been optimized for one or a few analytes. Here, we report a more comprehensive approach enabling rapid GC-MS screening of sixteen acidic biomarkers in urine that are metabolized in the human body from several important industrial chemicals; benzene, toluene, styrene, xylenes, alkoxyalcohols, carbon disulfide, furfural and N,N-dimethylformamide. The new method involves immediate in situ derivatization - liquid liquid microextraction of urine by an ethyl chloroformate-ethanol-chloroform-pyridine medium and GC-MS analysis of the derivatized analytes in the lower organic phase. The xenometabolite set represents diverse chemical structures and some of hippuric and mercapturic acids also provided unusual derivatives that were unambiguously elucidated by means of new ethyl chloroformates labeled with stable isotopes and by synthesis of the missing reference standards. In the next step, an automated routine was developed for GC-MS/MS analysis using a MetaboAuto® sample preparation workstation and the new method was validated for fourteen metabolites over the relevant concentration range of each analyte in the spiked pooled human urine. It shows good linearity (R² ≥ 0.982), accuracy (from 85% to 120%), precision (from 0.7% to 20%) and recovery (from 89% to 120%). The method performance was further successfully proved by GC-MS/MS analysis of the certified IP45 and RM6009 reference urines. Moreover, we show that the new method opens up the possibility for biomonitoring of combined and cumulative occupational exposures as well as for urinary metabolite profiling of persons exposed to harmful industrial chemicals.

Two conformational polymorphs of 4-methylhippuric acid

4-Methylhippuric acid {systematic name: 2-[(4-methylbenzoyl)amino]ethanoic acid}, a p-xylene excreted metabolite with a backbone containing three rotatable bonds (R-bonds), is likely to produce more than one stable molecular structure in the solid state. In this work, we prepared polymorph I by slow solvent evaporation (plates with Z' = 1) and polymorph II by mechanical grinding (plates with Z' = 2). Potential energy surface (PES) analysis, rotating the molecule about the C-C-N-C torsion angle, shows four conformational energy basins. The second basin, with torsion angles near -73°, agree with the conformations adopted by polymorph I and molecules A of polymorph II, and the third basin at 57° matched molecules B of polymorph II. The energy barrier between these basins is 27.5 kJ mol^-1. Superposition of the molecules of polymorphs I and II rendered a maximum r.m.s. deviation of 0.398 Å. Polymorphs I and II are therefore true conformational polymorphs. The crystal packing of polymorph I consists of C(5) chains linked by N-H...O interactions along the a axis and C(7) chains linked by O-H...O interactions along the b axis. In polymorph II, two molecules (A with A or B with B) are connected by two acid-amide O-H...O interactions rendering R₂²(14) centrosymmetric dimers. These dimers alternate to pile up along the b axis linked by N-H...O interactions. A Hirshfeld surface analysis localized weaker noncovalent interactions, C-H...O and C-H...π, with contact distances close to the sum of the van der Waals radii. Electron density at a local level using the Quantum Theory of Atoms in Molecules (QTAIM) and the Electron Localization Function (ELF), or a semi-local level using noncovalent interactions, was used to rank interactions. Strong closed shell interactions in classical O-H...O and N-H...O hydrogen bonds have electron density highly localized on bond critical points. Weaker delocalized electron density is seen around the p-methylphenyl rings associated with dispersive C-H...π and H...H interactions.

Direct methyl esterification with 2,2-dimethoxypropane for the simultaneous determination of urinary metabolites of toluene, xylene, styrene, and ethylbenzene by gas chromatography-mass spectrometry

Objectives

The purpose of this study was to develop a simple and accurate gas chromatography‐mass spectrometry (GC‐MS) method for simultaneous determination of four urinary metabolites from four organic solvents, that is, hippuric acid (HA) from toluene, methylhippuric acid (MHA) from xylene, and mandelic acid (MA) and phenylglyoxylic acid (PGA) from styrene or ethylbenzene for biological monitoring.

Methods

The four metabolites were directly methyl‐esterified with 2,2‐dimethoxypropane and analyzed using GC‐MS. The proposed method was validated according to the US Food and Drug Administration guidance. The accuracy of the proposed method was confirmed by analyzing a ClinChek^®—Control for occupational medicine (RECIPE Chemicals +Instruments GmbH).

Results

Calibration curves showed linearity in the concentration range of 10‐1000 mg/L for each metabolite, with correlation coefficients >0.999. For each metabolite, the limits of detection and quantification were 3 mg/L and 10 mg/L, respectively. The recovery was 93%‐117%, intraday accuracy, expressed as the deviation from the nominal value, was 92.7%‐103.0%, and intraday precision, expressed as the relative standard deviation (RSD), was 1.3%‐4.7%. Interday accuracy and precision were 93.4%‐104.0% and 1.2%‐9.5%, respectively. The analytical values of ClinChek obtained using the proposed method were sufficiently accurate.

Conclusions

The proposed method is a simple and accurate which is suitable for routine analyses that could be used for biological monitoring of occupational exposure to four organic solvents.

Human urine certified reference material CZ 6010: creatinine and toluene metabolites (hippuric acid and o-cresol) and a benzene metabolite (phenol)

A reference material for the biological monitoring of occupational exposure to toluene, benzene and phenol was prepared. O-cresol and hippuric acid (metabolites of toluene) are used for the biological monitoring of occupational exposure to toluene. Phenol, a metabolite of benzene, is used for the biological monitoring of exposure to benzene, but phenol can of course also be used as an indicator of exposure to phenol as well. The reference material (RM) used for the determination of these metabolites was prepared by freeze-drying pooled urine samples obtained from healthy persons occupationally exposed to toluene and those taking part in an inhalation experiment. Tests for homogeneity and stability were performed by determining urine concentrations of o-cresol, hippuric acid, creatinine and phenol. To investigate the stability of the RM, the urinary concentrations of o-cresol and phenol were monitored for eighteen months using GC and HPLC, while those of hippuric acid and creatinine were followed for five and six years, respectively, using HPLC. Analysis of variance showed that the concentrations did not change. The certified concentration values (and their uncertainties) of the substances in this reference material (phenol concentration c=6.46+/-0.58 mg l(-1); o-cresol concentration c=1.17+/-0.15 mg l(-1); hippuric acid concentration c=1328+/-30 mg l(-1); creatinine concentration c=0.82+/-0.10 g l(-1)) were evaluated via the interactive statistical programme IPECA.

Analysis of urinary biomarkers for exposure to alkyl benzenes by isotope dilution gas chromatography-mass spectrometry

A validated GC-MS method for the analysis of urinary metabolites of alkyl benzenes is reported. Metabolites for exposure to toluene, xylene and ethylbenzene were analyzed simultaneously using stable isotope substituted internal standards. The method entailed acidic deconjugation of urine samples followed by extractive alkylation with pentafluorobenzyl bromide as alkylating agent. The resulting pentafluorobenzyl derivatives of ortho-, meta-, para-cresol, mandelic acid (MA), hippuric acid (HA) and ortho-, meta-, para-methylhippuric acid (MHA) were then quantified by SIM. Optimized reaction conditions for the extractive alkylation step are reported. The derivatives were found to be sufficiently stable for overnight batch analysis. The LODs were below 0.1 micromol/L for the cresols and below 1 micromol/L for MA and the HAs. Within-batch precision for o-MHA was 7%, for m-MHA 5%, for p-MHA 5.2% and below 5% for the rest of the analytes.