Effect of phytase supplementation on phosphorus digestibility in low-phytate barley fed to finishing pigs

Hulled and hull-less barley grains with the genetic trait for low-phytic acid increased the apparent total-tract digestibility of phosphorus and calcium in diets for young swine

A 35-d experiment was conducted using 63 crossbred pigs (35 barrows and 28 gilts) with an initial average BW of 7.0 kg and age of 28 d to evaluate the efficacy of the low-phytic acid (LPA) genetic trait in hulled or hull-less barley in isocaloric diets. Hulled barleys were the normal barley (NB) cultivar Harrington and the near-isogenic LPA mutant 955 (M955) with P availabilities of 36 and 95%, respectively. Hull-less lines were produced by crossing NB and the LPA mutant 422 line with a hull-less line, producing hull-less NB (HNB) and hull-less mutant 422 (HM422) with P availabilities of 41 and 66%, respectively. Pigs were in individual metabolism cages or pens for Phase 1 (d 0 to 14) and Phase 2 (d 14 to 35). Diets defined as NB, HNB, HM422, or M955 with no added inorganic P (iP) had available P (aP) concentrations of 0.27, 0.28, 0.35, and 0.40% for Phase 1 and 0.15, 0.17, 0.23, and 0.31% for Phase 2, respectively. Only diet M955 was adequate in aP. Therefore, iP was added to the P-deficient diets to make diets NB + iP, HNB + iP, and HM422 + iP with aP equal to that in diet M955. Overall (d 0 to 35), ADG and G:F were greater ( < 0.01) for pigs fed diet M955 or the diets with added iP than for pigs fed the NB diet. Serum tartrate-resistant acid phosphatase activity on d 34 was greater ( < 0.01) for pigs fed the NB or HNB diets than for pigs fed the other diets. Bone breaking strength and P absorption (g/d) were greater ( < 0.01) for pigs fed diet M955 or the diets with iP than for pigs fed the NB or HNB diets. Pigs fed diet M955 absorbed greater ( < 0.01) percentages of P and Ca and had less ( < 0.01) fecal excretion of P (g/d and %) and Ca (%) than pigs fed the other diets. In conclusion, the LPA genetic trait was effective in hulled and hull-less barley in isocaloric diets fed to young pigs. Pigs fed the diet with LPA M955 consumed 31% less P and excreted 78% less fecal P and 30% less fecal Ca than pigs fed the diet with NB + iP that was equal to diet M955 in aP. Therefore, LPA barley, especially M955 with 95% aP, will reduce the use of iP in swine diets, reduce P pollution from swine manure, and support the goal of achieving global P sustainability.

Nutritional evaluation of low-phytate peas (Pisum sativum L.) for young broiler chicks

This experiment determined the effects of including normal and low-phytate peas in diets fed to young broiler chickens on performance, phosphorus availability and bone strength. A total of 180, day-old, male broilers (Ross-308 line) were assigned to six treatments. The control was based on corn and soybean meal while two additional corn-based diets were formulated containing 30% of either normal or low-phytate pea providing 0.45% available phosphorus. For each of these three diets, a similar diet was formulated by reducing the amount of dicalcium phosphate to produce a diet with 0.3% available phosphorus. The total tract apparent availability (TTAA) of phosphorus was higher (p = 0.02) for broilers fed the low-phytate pea than for birds fed the normal pea diets. Birds fed diets containing the lower level of phosphorus had a higher TTAA of phosphorus (50.64 vs. 46.68%) than broilers fed diets adequate in phosphorus. Protein source had no effect on weight gain, feed intake or feed conversion. Broilers fed the low phosphorus diets had lower weight gain (p = 0.04) and feed intake (p < 0.01) than broilers fed the higher phosphorus level. Bone strength was higher (p < 0.01) for broilers fed diets based on low-phytate pea than for those fed diets based on normal pea or soybean meal. Increasing the availability of the phosphorus in peas could mean that less inorganic phosphorus would be required in order to meet the nutritional requirements of broilers. Since inorganic phosphorus sources tend to be expensive, a reduction in their use would lower ration costs. In addition, increased availability of phosphorus would reduce the amount of phosphorus excreted thus reducing the amount of phosphorus that can potentially pollute the environment.

Effect of low-phytate barley or phytase supplementation to a barley-soybean meal diet on phosphorus retention and excretion by grower pigs

Two studies were conducted to determine the effect of diets containing low-phytate barley or supplemented with phytase on P balance and excretion in grower pigs. In Exp. 1, eight 32-kg barrows were assigned to a repeated, 4 x 4 Latin square design and fed 4 diets that contained 96% barley: normal-phytate hulled barley (HB), low-phytate hulled barley (LPHB), normal-phytate hull-less barley (HLB), and low-phytate hull-less barley (LPHLB). The barley cultivars contained 0.16, 0.05, 0.24, and 0.03% phytate, respectively. Inorganic P (iP) was added to the HB and HLB diets to meet the 1998 National Research Council recommendation of available P (aP, 0.23%), whereas LPHB and LPHLB contained sufficient aP. The diets were fed at 2.5 times the maintenance requirement for ME. The apparent total tract digestibilities (ATTD) of P did not differ between the hulled and hull-less barley diets, but P retention (%) and excretion were greater in pigs fed the hull-less barley diets (P < 0.05). The ATTD of P was greater and P excretion was 35% lower in pigs fed the low-phytate compared with the normal-phytate diets (P < 0.001). The amount of P retained (g/d) was greater (P < 0.001) in pigs fed low-phytate barley, reflecting an ATTD of P of 65 and 49% for low-phytate and normal-phytate barley, respectively (P < 0.001). In Exp. 2, eight 21-kg barrows were assigned to a repeated, 4 x 4 Latin square design and fed 4 diets based on barley and soybean meal (SBM): HB-SBM, HB-SBM + iP, HB-SBM + phytase, and LPHB-SBM. The HB-SBM and HB-SBM + phytase diets were deficient in aP, whereas the HB-SBM + iP and LPHB-SBM diets had adequate aP. The feeding regimen was similar to that of Exp. 1. Adding iP to the HB-SBM diet did not affect the ATTD but increased the amount of P retained (g/d) and excreted (P < 0.001). The ATTD and amount of P retained (g/d) did not differ among pigs fed the HB-SBM + iP, HB-SBM + phytase, and LPHB-SBM diets. However, pigs fed the HB-SBM + phytase and LPHB-SBM diets excreted 32 and 29% less P, respectively, than pigs fed the HB-SBM + iP diet (P < 0.05), confirming that low-phytate barley is as effective as supplemental phytase in improving P digestibility and utilization and decreasing P excretion in grower pigs.

The effect of feeding low-phytate barley-soybean meal diets differing in protein content to growing pigs on the excretion of phosphorus and nitrogen

An experiment was conducted with growing pigs to determine the excretion of P and N in 4 barley-based diets formulated to contain 18 or 15% CP by using a normal barley (NB) or a low-phytate barley (LPB). The NB contained 0.31% total P and 0.19% phytate P; the LPB contained 0.32% total P and 0.01% phytate P. The diets were supplemented, when so required, with lysine, methionine, threonine, and tryptophan to meet their apparent ileal digestible supplies according to the NRC (1998). The diets containing NB were supplemented with inorganic P to meet the NRC (1998) recommendation for available P (0.23%). The diets containing LPB were not supplemented with inorganic P because these contained sufficient available P (0.27%). Eight barrows with an average BW of 20.9 kg were assigned to the 4 dietary treatments according to a repeated 4 x 4 Latin square design. The diets were fed at a rate of 2.5 times the ME requirement for maintenance. The barrows were fed twice daily, at 0800 and 1500, equal amounts each meal. Water was added to the feed at a ratio of 2.5:1. Each experimental period consisted of a 7-d adaptation period followed by a 5-d collection of feces and urine. The substitution of NB with LPB decreased (P < 0.001) the total P excretion by 38 and 43% for the 18 and 15% CP diets, respectively. Reducing the CP content from 18 to 15% decreased (P < 0.001) the N excretion by 29 and 32% for the NB and LPB diets, respectively. With the reduction in CP content, there was a decrease (P < 0.001) in the amount of N retained. The N:P ratio in manure of pigs fed the LPB diets was greater (P < 0.001) than from pigs fed the NB diets. These data indicate that P and N excretion can be greatly reduced by substitution of NB by LPB, and also by the reduction of the CP content, in diets for growing pigs.

Low-phytate barley cultivars improve the utilization of phosphorus, calcium, nitrogen, energy, and dry matter in diets fed to young swine

A 28-d experiment was conducted using 45 crossbred barrows with an average initial BW of 9.5 kg and age of 35 d to evaluate low-phytate barley (LPB) mutants (M) M422, M635, and M955, which were hulled, near-isogenic progeny of the normal barley (NB) Harrington and had 47, 66, and 80% less phytic acid, respectively, than NB. A hull-less LPB, M422-H, which was not near-isogenic to the other cultivars, was also evaluated. Apparent nutrient balance, bone measurements, and growth performance were the response criteria evaluated. The barrows were fed the diets to appetite in meal form in individual metabolism crates. Barley and soybean meal were the only sources of phytic acid. Dietary protein supplementation and ME/kg were equalized in all diets. The treatments were diets containing NB, M422, M635, or M422-H without or with added inorganic P (iP), or M955 without added iP. Diets with added iP contained 0.30% available P (aP), the same concentration of aP provided by the diet containing M955 without added iP. There were linear increases (P < or = 0.02) in ADG, G:F, metacarpal and radius bone strength, and fat-free dry weight, and in the absorption and retention (g/d and % of intake) of P and Ca with increasing dietary concentration of aP from the near-isogenic cultivars NB, M422, M635, or M955 without added iP. There were linear decreases in the grams (P < or = 0.02) and percentages (P < 0.001) of P and Ca excreted per day with increasing dietary concentration of aP without added iP. There were no responses for N or energy balance. Growth performance and bone response criteria did not differ for barrows fed the diet containing M955 or the near-isogenic diets containing NB, M422, or M635 with added iP. However, barrows fed the diet containing M955 had greater (P < or = 0.02) percentages of P, N, and energy absorption and retention, Ca absorption, and DM digestibility and had less (P < or = 0.02, g/d and %) excretion of P, N, energy, and Ca (g) per day than barrows fed the diets containing the near-isogenic NB or LPB cultivars with added iP. When dietary aP was equalized with iP, the excretion of P in feces plus urine (g/d) was reduced by 20.2, 27.9, and 44.6%, respectively, in barrows fed the diets containing M422 + iP, M635 + iP, or M955 compared with barrows fed the diet containing NB + iP. Energy utilization did not differ for barrows fed the diets containing hulled or hull-less LPB when ME/kg was equalized with lard. In conclusion, the apparent utilization of P and Ca, the bone strength and fat-free dry weight, and growth performance increased with increasing dietary concentration of aP provided by LPB, in association with linear decreases in P and Ca excretion. Barrows fed the diet containing M955 also had greater utilization and less excretion of P, Ca, N, energy, and DM than barrows fed the diets containing the near-isogenic NB or LPB cultivars with added iP to equalize aP at 0.30%.

Phosphorus composition of manure from swine fed low-phytate grains: evidence for hydrolysis in the animal

Including low-phytic-acid grains in swine diets can reduce P concentrations in manure, but the influence on manure P composition is relatively unknown. To address this we analyzed manure from swine fed one of four barley (Hordeum vulgare L.) varieties. The barley types consisted of wild-type barley (CDC bold, normal barley diet) and three low-phytic-acid mutant barleys that contained similar amounts of total P but less phytic acid. The phytic acid concentrations in the mutant barleys were reduced by 32% (M422), 59% (M635), and 97% (M955) compared with that in the wild-type barley, respectively. Phosphorus concentrations were approximately one-third less in manures from animals fed low-phytic-acid barleys compared with those fed the wild-type variety. Phytic acid constituted up to 55% of the P in feed, but only trace concentrations were detected in NaOH-EDTA extracts of all manures by solution (31)P nuclear magnetic resonance (NMR) spectroscopy. Phosphate was the major P fraction in the manures (86-94% extracted P), with small concentrations of pyrophosphate and simple phosphate monoesters also present. The latter originated mainly from the hydrolysis of phospholipids during extraction and analysis. These results suggest that phytic acid is hydrolyzed in swine, possibly in the hind gut by intestinal microflora before being excreted in feces, even though the animals have little phytase activity in the gut and derive little nutritional benefit from phytate P. We conclude that feeding low-phytic-acid grains reduces total manure P concentrations and the manure P is no more soluble than P generated from normal barley diets.