Inactivation of Zika virus in platelet components using amotosalen and ultraviolet A illumination

Ultrafast-UV laser integrating cavity device for inactivation of SARS-CoV-2 and other viruses

Ultraviolet (UV) irradiation-based methods used for viral inactivation have provided an important avenue targeting severe acute respiratory-syndrome coronavirus-2 (SARS-CoV-2) virus. A major problem with state-of-the-art UV inactivation technology is that it is based on UV lamps, which have limited efficiency, require high power, large doses, and long irradiation times. These drawbacks limit the use of UV lamps in air filtering systems and other applications. To address these limitations, herein we report on the fabrication of a device comprising a pulsed nanosecond 266 nm UV laser coupled to an integrating cavity (LIC) composed of a UV reflective material, polytetrafluoroethylene. Previous UV lamp inactivation cavities were based on polished walls with specular reflections, but the diffuse reflective UV ICs were not thoroughly explored for virus inactivation. Our results show that LIC device can inactivate several respiratory viruses including SARS-CoV-2, at ~ 1 ms effective irradiation time, with > 2 orders of magnitude higher efficiency compared to UV lamps. The demonstrated 3 orders of magnitude cavity enhancement relative to direct exposure is crucial for the development of efficient real-time UV air and water purification systems. To the best of our knowledge this is the first demonstration of LIC application for broad viral inactivation with high efficiency.

Mitigating the risk of transfusion-transmitted infections with vector-borne agents solely by means of pathogen reduction

Background

This study evaluated whether pathogen reduction technology (PRT) in plasma and platelets using amotosalen/ultraviolet A light (A/UVA) or in red blood cells using amustaline/glutathione (S‐303/GSH) may be used as the sole mitigation strategy preventing transfusion‐transmitted West Nile (WNV), dengue (DENV), Zika (ZIKV), and chikungunya (CHIKV) viral, and Babesia microti, Trypanosoma cruzi, and Plasmodium parasitic infections.

Methods

Antibody (Ab) status and pathogen loads (copies/mL) were obtained for donations from US blood donors testing nucleic acid (NAT)‐positive for WNV, DENV, ZIKV, CHIKV, and B. microti. Infectivity titers derived from pathogen loads were compared to published PRT log₁₀ reduction factors (LRF); LRFs were also reviewed for Plasmodium and T. cruzi. The potential positive impact on donor retention following removal of deferrals from required questioning and testing for WNV, Babesia, Plasmodium, and T. cruzi was estimated for American Red Cross (ARC) donors.

Results

A/UVA and S‐303/GSH reduced infectivity to levels in accordance with those recognized by FDA as suitable to replace testing for all agents evaluated. If PRT replaced deferrals resulting from health history questions and/or NAT for WNV, Babesia, Plasmodium, and T. cruzi, 27,758 ARC donors could be retained allowing approximately 50,000 additional donations/year based on 1.79 donations/donor for calendar year 2019 (extrapolated to an estimated 125,000 additional donations nationally).

Conclusion

Pathogen loads in donations from US blood donors demonstrated that robust PRT may provide an opportunity to replace deferrals associated with donor questioning and NAT for vector‐borne agents allowing for significant donor retention and likely increased blood availability.

Molecular validation of pathogen-reduction technologies using rolling-circle amplification coupled with real-time PCR for torquetenovirus DNA quantification

BACKGROUND

Pathogen reduction technologies (PRT) based on nucleic-acid damaging chemicals and/or irradiation are increasingly being used to increase safety of blood components against emerging pathogens, such as convalescent plasma in the ongoing COVID-19 pandemic. Current methods for PRT validation are limited by the resources available to the blood component manufacturer, and quality control rely over pathogen spiking and hence invariably require sacrifice of the tested blood units: quantitative real-time PCR is the current pathogen detection method but, due to the high likelihood of detecting nonviable fragments, requires downstream pathogen culture. We propose here a new molecular validation of PRT based on the highly prevalent human symbiont torquetenovirus (TTV) and rolling circle amplification (RCA).

MATERIALS AND METHODS

Serial apheresis plasma donations were tested for TTV before and after inactivation with Intercept® PRT using real-time quantitative PCR (conventional validation), RCA followed by real-time PCR (our validation), and reverse PCR (for cross-validation).

RESULTS

While only 20% of inactivated units showed significant decrease in TTV viral load using real-time qPCR, all donations tested with RCA followed by real-time PCR showed TTV reductions. As further validation, 2 units were additionally tested with reverse PCR, which confirmed absence of entire circular genomes.

DISCUSSION

We have described and validated a conservative and easy-to-setup protocol for molecular validation of PRT based on RCA and real-time PCR for TTV.

Quantum Leap from Gold and Silver to Aluminum Nanoplasmonics for Enhanced Biomedical Applications

Nanotechnology has been used in many biosensing and medical applications, in the form of noble metal (gold and silver) nanoparticles and nanostructured substrates. However, the translational clinical and industrial applications still need improvements of the efficiency, selectivity, cost, toxicity, reproducibility, and morphological control at the nanoscale level. In this review, we highlight the recent progress that has been made in the replacement of expensive gold and silver metals with the less expensive aluminum. In addition to low cost, other advantages of the aluminum plasmonic nanostructures include a broad spectral range from deep UV to near IR, providing additional signal enhancement and treatment mechanisms. New synergistic treatments of bacterial infections, cancer, and coronaviruses are envisioned. Coupling with gain media and quantum optical effects improve the performance of the aluminum nanostructures beyond gold and silver.

Inactivation of a broad spectrum of viruses and parasites by photochemical treatment of plasma and platelets using amotosalen and ultraviolet A light

BACKGROUND

The INTERCEPT Blood System pathogen reduction technology (PRT), which uses amotosalen and ultraviolet A light treatment (amotosalen/UV-PRT), inactivates pathogens in plasma and platelet components (PCs). This review summarizes data describing the inactivation efficacy of amotosalen/UVA-PRT for a broad spectrum of viruses and parasites.

METHODS

Twenty-five enveloped viruses, six nonenveloped viruses (NEVs), and four parasites species were evaluated for sensitivity to amotosalen/UVA-PRT. Pathogens were spiked into plasma and PC at high titers. Samples were collected before and after PRT and assessed for infectivity with cell cultures or animal models. Log reduction factors (LRFs) were defined as the difference in infectious titers before and after amotosalen/UV-PRT.

RESULTS

LRFs of ≥4.0 log were reported for 19 pathogens in plasma (range, ≥4.0 to ≥7.6), 28 pathogens in PC in platelet additive solution (PC-PAS; ≥4.1-≥7.8), and 14 pathogens in PC in 100% plasma (PC-100%; (≥4.3->8.4). Twenty-five enveloped viruses and two NEVs were sensitive to amotosalen/UV-PRT; LRF ranged from >2.9 to ≥7.6 in plasma, 2.4 or greater to greater than 6.9 in PC-PAS and >3.5 to >6.5 in PC-100%. Infectious titers for four parasites were reduced by >4.0 log in all PC and plasma (≥4.9 to >8.4).

CONCLUSION

Amotosalen/UVA-PRT demonstrated effective infectious titer reduction for a broad spectrum of viruses and parasites. This confirms the capacity of this system to reduce the risk of viral and parasitic transfusion-transmitted infections by plasma and PCs in various geographies.

Inactivation of yellow fever virus with amotosalen and ultraviolet A light pathogen-reduction technology

BACKGROUND

The reemergence of yellow fever virus (YFV) in Africa and Brazil, and massive vaccine campaigns triggered to contain the outbreaks, have raised concerns over blood transfusion safety and availability with increased risk of YFV transfusion-transmitted infections (TTIs) by native and vaccine-acquired YFV. Blood donor deferral for 2 to 4 weeks following live attenuated YFV vaccination, and deferral for travel to endemic/epidemic areas, may result in blood donor loss and impact platelet component (PC) stocks. This study investigated the efficacy of INTERCEPT Blood System pathogen reduction (PR) with use of amotosalen and ultraviolet A (UVA) light to inactivate high levels of YFV in PCs.

MATERIALS

Four units of apheresis platelets prepared in 35% plasma/65% platelet additive solution (PC-PAS) and 4 units of PC in 100% human plasma (PC-Plasma) were spiked with high infectious titers of YFV (YFV-17D vaccine strain). YFV-17D infectious titers were measured by plaque assay and expressed as plaque-forming units (PFU) before and after amotosalen/UVA treatment to determine log reduction.

RESULTS

The mean YFV-17D infectious titers in PC before inactivation were 5.5 ± 0.1 log PFU/mL in PC-PAS and 5.3 ± 0.1 log PFU/mL in PC-Plasma. No infectivity was detected immediately after amotosalen/UVA treatment.

CONCLUSION

The amotosalen/UVA PR system inactivated high titers of infectious YFV-17D in PC. This PR technology could reduce the risk of YFV TTI and help secure PC supplies in areas experiencing YFV outbreaks where massive vaccination campaigns are required.

Amotosalen and ultraviolet A light efficiently inactivate MERS-coronavirus in human platelet concentrates

Objective

This study aimed to assess the efficacy of the INTERCEPT™ Blood System [amotosalen/ultraviolet A (UVA) light] to reduce the risk of Middle East respiratory syndrome‐Coronavirus (MERS‐CoV) transmission by human platelet concentrates.

Background

Since 2012, more than 2425 MERS‐CoV human cases have been reported in 27 countries. The infection causes acute respiratory disease, which was responsible for 838 deaths in these countries, mainly in Saudi Arabia. Viral genomic RNA was detected in whole blood, serum and plasma of infected patients, raising concerns of the safety of blood supplies, especially in endemic areas.

Methods

Four apheresis platelet units in 100% plasma were inoculated with a clinical MERS‐CoV isolate. Spiked units were then treated with amotosalen/UVA to inactivate MERS‐CoV. Infectious and genomic viral titres were quantified by plaque assay and quantitative real‐time reverse transcription polymerase chain reaction (RT‐qPCR). Inactivated samples were successively passaged thrice on Vero E6 cells to exclude the presence of residual replication‐competent viral particles in inactivated platelets.

Results

Complete inactivation of MERS‐CoV in spiked platelet units was achieved by treatment with Amotosalen/UVA light with a mean log reduction of 4·48 ± 0·3. Passaging of the inactivated samples in Vero E6 showed no viral replication even after nine days of incubation and three passages. Viral genomic RNA titration in inactivated samples showed titres comparable to those in pre‐treatment samples.

Conclusion

Amotosalen and UVA light treatment of MERS‐CoV‐spiked platelet concentrates efficiently and completely inactivated MERS‐CoV infectivity (>4 logs), suggesting that such treatment could minimise the risk of transfusion‐related MERS‐CoV transmission.

Pathogen reduction of blood components during outbreaks of infectious diseases in the European Union: an expert opinion from the European Centre for Disease Prevention and Control consultation meeting

Pathogen reduction (PR) of selected blood components is a technology that has been adopted in practice in various ways. Although they offer great advantages in improving the safety of the blood supply, these technologies have limitations which hinder their broader use, e.g. increased costs. In this context, the European Centre for Disease Prevention and Control (ECDC), in co-operation with the Italian National Blood Centre, organised an expert consultation meeting to discuss the potential role of pathogen reduction technologies (PRT) as a blood safety intervention during outbreaks of infectious diseases for which (in most cases) laboratory screening of blood donations is not available. The meeting brought together 26 experts and representatives of national competent authorities for blood from thirteen European Union and European Economic Area (EU/EEA) Member States (MS), Switzerland, the World Health Organization, the European Directorate for the Quality of Medicines and Health Care of the Council of Europe, the US Food and Drug Administration, and the ECDC. During the meeting, the current use of PRTs in the EU/EEA MS and Switzerland was verified, with particular reference to emerging infectious diseases (see Appendix). In this article, we also present expert discussions and a common view on the potential use of PRT as a part of both preparedness and response to threats posed to blood safety by outbreaks of infectious disease.

Acute Zika virus infection in an asymptomatic blood donor at the onset of the Puerto Rico epidemic

BACKGROUND

Zika virus (ZIKV) spread to Puerto Rico likely originated from southeastern Brazil approximately 8.5 months earlier than blood donation screening for ZIKV was initiated, but the time of ZIKV introduction in the blood donor population remains unknown.

METHODS

To better understand when arboviral infections first appeared in the blood donor pool in Puerto Rico, we retrospectively screened for ZIKV RNA (as well as chikungunya [CHIKV] and dengue [DENV] viral RNA) a repository of 1186 linked blood donor and recipient samples collected from February 2015 to May 2016 as an endpoint efficacy measure following the introduction of platelet pathogen reduction (PR). Phylogenetic analysis identified relatedness of donor strain to other circulating strains, and molecular clock analysis identified the estimated time of introduction.

RESULTS

An asymptomatic donor collected in December 2015 was ZIKV RNA confirmed positive, 4 months BEFORE investigational nucleic acid testing (NAT) implementation in April 2016, coincident and related to the first reported autochthonous cases. No CHIKV RNA or DENV RNA reactives were identified in donors or recipients, and no adverse events were reported from PR use in recipients. Phylogenetic analysis confirmed the molecular relatedness of the donor ZIKV strain to the Puerto Rico lineage likely introduced approximately 4.5 months earlier.

CONCLUSION

This study identified an asymptomatic ZIKV infection in a blood donor occurring before those previously recognized by blood donation screening. NAT and PR continue to be used as acceptable strategies to prevent transfusion-transmitted arboviral infections worldwide; however, repeated arboviral outbreaks warrant consideration of PR as a more proactive approach.

Trends and targets in antiviral phototherapy

Photodynamic therapy (PDT) is a well-established treatment option in the treatment of certain cancerous and pre-cancerous lesions. Though best-known for its application in tumor therapy, historically the photodynamic effect was first demonstrated against bacteria at the beginning of the 20^th century. Today, in light of spreading antibiotic resistance and the rise of new infections, this photodynamic inactivation (PDI) of microbes, such as bacteria, fungi, and viruses, is gaining considerable attention. This review focuses on the PDI of viruses as an alternative treatment in antiviral therapy, but also as a means of viral decontamination, covering mainly the literature of the last decade. The PDI of viruses shares the general action mechanism of photodynamic applications: the irradiation of a dye with light and the subsequent generation of reactive oxygen species (ROS) which are the effective phototoxic agents damaging virus targets by reacting with viral nucleic acids, lipids and proteins. Interestingly, a light-independent antiviral activity has also been found for some of these dyes. This review covers the compound classes employed in the PDI of viruses and their various areas of use. In the medical area, currently two fields stand out in which the PDI of viruses has found broader application: the purification of blood products and the treatment of human papilloma virus manifestations. However, the PDI of viruses has also found interest in such diverse areas as water and surface decontamination, and biosafety.

Ultraviolet-Based Pathogen Inactivation Systems: Untangling the Molecular Targets Activated in Platelets

Transfusions of platelets are an important cornerstone of medicine; however, recipients may be subject to risk of adverse events associated with the potential transmission of pathogens, especially bacteria. Pathogen inactivation (PI) technologies based on ultraviolet illumination have been developed in the last decades to mitigate this risk. This review discusses studies of platelet concentrates treated with the current generation of PI technologies to assess their impact on quality, PI capacity, safety, and clinical efficacy. Improved safety seems to come with the cost of reduced platelet functionality, and hence transfusion efficacy. In order to understand these negative impacts in more detail, several molecular analyses have identified signaling pathways linked to platelet function that are altered by PI. Because some of these biochemical alterations are similar to those seen arising in the context of routine platelet storage lesion development occurring during blood bank storage, we lack a complete picture of the contribution of PI treatment to impaired platelet functionality. A model generated using data from currently available publications places the signaling protein kinase p38 as a central player regulating a variety of mechanisms triggered in platelets by PI systems.

Method for simple and rapid concentration of Zika virus particles from infected cell-culture supernatants

Experimental studies on Zika virus (ZIKV) may require improvement of infectious titers in viral stocks obtained by cell culture amplification. The use of centrifugal filter devices to increase infectious titers of ZIKV from cell-culture supernatants is highlighted here. A mean gain of 2.33 ± 0.12 log₁₀ DICT₅₀/mL was easily and rapidly obtained with this process. This efficient method of ultrafiltration may be applied to other viruses and be useful in various experimental studies requiring high viral titers.

Prevention and Control Strategies to Counter Zika Virus, a Special Focus on Intervention Approaches against Vector Mosquitoes-Current Updates

Zika virus (ZIKV) is the most recent intruder that acquired the status of global threat creating panic and frightening situation to public owing to its rapid spread, attaining higher virulence and causing complex clinical manifestations including microcephaly in newborns and Guillain Barré Syndrome. Alike other flaviviruses, the principal mode of ZIKV transmission is by mosquitoes. Advances in research have provided reliable diagnostics for detecting ZIKV infection, while several drug/therapeutic targets and vaccine candidates have been identified recently. Despite these progresses, currently there is neither any effective drug nor any vaccine available against ZIKV. Under such circumstances and to tackle the problem at large, control measures of which mosquito population control need to be strengthened following appropriate mechanical, chemical, biological and genetic control measures. Apart from this, several other known modes of ZIKV transmission which have gained importance in recent past such as intrauterine, sexual intercourse, and blood-borne spread need to be checked and kept under control by adopting appropriate precautions and utmost care during sexual intercourse, blood transfusion and organ transplantation. The virus inactivation by pasteurization, detergents, chemicals, and filtration can effectively reduce viral load in plasma-derived medicinal products. Added to this, strengthening of the surveillance and monitoring of ZIKV as well as avoiding travel to Zika infected areas would aid in keeping viral infection under check. Here, we discuss the salient advances in the prevention and control strategies to combat ZIKV with a focus on highlighting various intervention approaches against the vector mosquitoes of this viral pathogen along with presenting an overview regarding human intervention measures to counter other modes of ZIKV transmission and spread. Additionally, owing to the success of vaccines for a number of infections globally, a separate section dealing with advances in ZIKV vaccines and transmission blocking vaccines has also been included.

Amustaline (S-303) treatment inactivates high levels of Chikungunya virus in red-blood-cell components

BACKGROUND AND OBJECTIVES

Chikungunya virus (CHIKV) infections have been reported in all continents, and the potential risk for CHIKV transfusion-transmitted infections (TTIs) was demonstrated by the detection of CHIKV RNA-positive donations in several countries. TTIs can be reduced by pathogen inactivation (PI) of blood products. In this study, we evaluated the efficacy of amustaline and glutathione (S-303/GSH) to inactivate CHIKV in red-blood-cell concentrates (RBCs).

MATERIAL AND METHODS

Red-blood-cells were spiked with high level of CHIKV. Infectious titres and RNA loads were measured before and after PI treatment. Residual CHIKV infectivity was also assessed after five successive cell culture passages.

RESULTS

The mean CHIKV titres in RBCs before inactivation was 5·81 ± 0·18 log₁₀ 50% tissue culture infectious dose (TCID₅₀ )/mL, and the mean viral RNA load was 10·49 ± 0·15 log₁₀ genome equivalent (GEq)/mL. No CHIKV TCID was detected after S-303 treatment nor was replicative CHIKV particles and viral RNA present after five cell culture passages of samples obtained immediately after S-303 treatment.

CONCLUSION

Chikungunya virus was previously shown to be inactivated by the PI technology using amotosalen and ultraviolet A light for the treatment of plasma and platelets. This new study demonstrates that S-303/GSH can inactivate high titres of CHIKV in RBCs.

Evaluation of bacterial inactivation in random donor platelets and single-donor apheresis platelets by the INTERCEPT blood system

BACKGROUND:

Blood transfusion of contaminated components is a potential source of sepsis by a wide range of known and unknown pathogens. Collection mechanism and storage conditions of platelets make them vulnerable for bacterial contamination. Several interventions aim to reduce the transfusion of contaminated platelet units; however, data suggest that contaminated platelet transfusion remains very common.

AIM:

A pathogen inactivation system, “INTERCEPT”, to inactivate bacteria in deliberately contaminated platelet units was implemented and evaluated.

MATERIALS AND METHODS:

Five single-donor platelets (SDP) and five random donor platelets (RDP) were prepared after prior consent of donors. Both SDP and RDP units were deliberately contaminated by stable stock ATCC Staphylococcus aureus and Escherichia coli, respectively, with a known concentration of stock culture. Control samples were taken from the infected units and bacterial concentrations were quantified. The units were treated for pathogen inactivation with the INTERCEPT (Cerus Corporation, Concord, CA) Blood system for platelets (Amotosalen/UVA), as per the manufacturer's instructions for use. Post illumination, test samples were analyzed for any bacterial growth.

RESULTS:

Post-illumination test samples did not result in any bacterial growth. A complete reduction of >6 log₁₀S. aureus in SDP units and >6 log₁₀Escherichia coli in RDP units was achieved.

CONCLUSION:

The INTERCEPT system has been shown to be very effective in our study for bacterial inactivation. Implementation of INTERCEPT may be used as a mitigation against any potential bacterial contamination in platelet components.

An update on Zika virus infection

The epidemic history of Zika virus began in 2007, with its emergence in Yap Island in the western Pacific, followed in 2013-14 by a larger epidemic in French Polynesia, south Pacific, where the first severe complications and non-vector-borne transmission of the virus were reported. Zika virus emerged in Brazil in 2015 and was declared a national public health emergency after local researchers and physicians reported an increase in microcephaly cases. In 2016, WHO declared the recent cluster of microcephaly cases and other neurological disorders reported in Brazil a global public health emergency. Similar clusters of microcephaly cases were also observed retrospectively in French Polynesia in 2014. In 2015-16, Zika virus continued its spread to cause outbreaks in the Americas and the Pacific, and the first outbreaks were reported in continental USA, Africa, and southeast Asia. Non-vector-borne transmission was confirmed and Zika virus was established as a cause of severe neurological complications in fetuses, neonates, and adults. This Review focuses on important updates and gaps in the knowledge of Zika virus as of early 2017.