Mutational analysis of the regulatory region of the srfA operon in Bacillus subtilis

Development of a Growth-Dependent System to Regulate Cell Growth and Keratinase Production in B. subtilis

Keratinases specifically degrade insoluble keratin waste, thus contributing to environmental protection and sustainable biomass development. However, their industrial application is hindered by inefficient enzyme production and poor biomass generation. In this study, the heterologous expression of keratinase was found to have cytotoxicity and might block host cell growth due to its proteolytic property. To address this problem, an autoregulatory expression system based on quorum sensing was developed to synergistically regulate cell growth and keratinase production in Bacillus subtilis. The growth-dependent promoter P_aprE was chosen and shown to be effective in delaying keratinase production while promoting host cell proliferation. Copy number screening and core region mutations further balanced the two states. Carbon supplement optimization indicated that addition of 2% glucose facilitated biomass accumulation during the early stage of fermentation. Cell density increased to 15.6 (OD_600 nm) from 8 with keratinase activity raised to 4200 U·mL^-1 from 1162 U·mL^-1. Keratinase was then utilized in the bioconversion of feather waste to prepare soluble keratins, polypeptides, and amino acids. This study provides a powerful system for efficient production of keratinase and paves the way for keratin waste recycling.

Engineering a ComA Quorum-Sensing circuit to dynamically control the production of Menaquinone-4 in Bacillus subtilis

Menaquinone-4 (MK-4) plays a significant role in bone health and cardiovascular therapy. Although many strategies have been adopted to increase the yield of MK-4 in Bacillus subtilis 168, the effectiveness of MK-4 is still low due to the inherent limitations of metabolic pathways. However, dynamic regulation based on quorum sensing (QS) has been extensively applied as a fundamental tool for fine-tuning gene expression in reaction to changes in cell density without adding expensive inducers. Nevertheless, in most reports, QS systems depend on down-regulated expression rather than up-regulated expression, which greatly limit their potential as molecular switches to control metabolic flux. To address this challenge, a modular PhrQ-RapQ-ComA QS system is developed based on promoter P_A11, which is up-regulated by phosphorylated ComA (ComA-P). In this paper, firstly we analyzed the ComA-based gene expression regulation system in Bacillus subtilis 168. We constructed a promoter library of diff ;erent abilities, selected best promoters from a library, and performed mutation screening on the selected promoters. Furthermore, we constructed a PhrQ-RapQ-ComA QS system to dynamically control the synthesis of MK-4 in B. subtilis 168. Cell growth and efficient synthesis of the target product can be dynamically balanced by the QS system. Our dynamic adjustment approach increased the yield of MK-4 in shake flask from 120.1 ± 0.6 to 178.9 ± 2.8 mg/L, and reached 217 ± 4.1 mg/L in a 3-L bioreactor, which verified the effectiveness of this strategy. In summary, PhrQ-RapQ-ComA QS system can realize dynamic pathway regulation in B. subtilis 168, which can be stretched to a great deal of microorganisms to fine-tune gene expression and enhance the production of metabolites.

Peptide signaling without feedback in signal production operates as a true quorum sensing communication system in Bacillus subtilis

Bacterial quorum sensing (QS) is based on signal molecules (SM), which increase in concentration with cell density. At critical SM concentration, a variety of adaptive genes sharply change their expression from basic level to maximum level. In general, this sharp transition, a hallmark of true QS, requires an SM dependent positive feedback loop, where SM enhances its own production. Some communication systems, like the peptide SM-based ComQXPA communication system of Bacillus subtilis, do not have this feedback loop and we do not understand how and if the sharp transition in gene expression is achieved. Based on experiments and mathematical modeling, we observed that the SM peptide ComX encodes the information about cell density, specific cell growth rate, and even oxygen concentration, which ensure power-law increase in SM production. This enables together with the cooperative response to SM (ComX) a sharp transition in gene expression level and this without the SM dependent feedback loop. Due to its ultra-sensitive nature, the ComQXPA can operate at SM concentrations that are 100-1000 times lower than typically found in other QS systems, thereby substantially reducing the total metabolic cost of otherwise expensive ComX peptide.

The quorum-sensing regulator ComA from Bacillus subtilis activates transcription using topologically distinct DNA motifs

ComA-like transcription factors regulate the quorum response in numerous Gram-positive bacteria. ComA proteins belong to the tetrahelical helix-turn-helix superfamily of transcriptional activators, which bind as homodimers to inverted sequence repeats in the DNA. Here, we report that ComA from Bacillus subtilis recognizes a topologically distinct motif, in which the binding elements form a direct repeat. We provide in vitro and in vivo evidence that the canonical and non-canonical site play an important role in facilitating type I and type II promoter activation, respectively, by interacting with different subunits of RNA polymerase. We furthermore show that there is a variety of contexts in which the non-canonical site can occur and identify new direct target genes that are located within the integrative and conjugative element ICEBs1. We therefore suggest that ComA acts as a multifunctional transcriptional activator and provides a striking example for complexity in protein–DNA interactions that evolved in the context of quorum sensing.

NMR solution structure and DNA-binding model of the DNA-binding domain of competence protein A

Competence protein A (ComA) is a response regulator protein involved in the development of genetic competence in the Gram-positive spore-forming bacterium Bacillus subtilis, as well as the regulation of the production of degradative enzymes and antibiotic synthesis. ComA belongs to the NarL family of proteins, which are characterized by a C-terminal transcriptional activator domain that consists of a bundle of four helices, where the second and third helices (alpha 8 and alpha 9) form a helix-turn-helix DNA-binding domain. Using NMR spectroscopy, the high-resolution 3D solution structure of the C-terminal DNA-binding domain of ComA (ComAC) has been determined. In addition, surface plasmon resonance and NMR protein-DNA titration experiments allowed for the analysis of the interaction of ComAC with its target DNA sequences. Combining the solution structure and biochemical data, a model of ComAC bound to the ComA recognition sequences on the srfA promoter has been developed. The model shows that for DNA binding, ComA uses the conserved helix-turn-helix motif present in other NarL family members. However, the model reveals also that ComA might use a slightly different part of the helix-turn-helix motif and there appears to be some associated domain re-orientation. These observations suggest a basis for DNA binding specificity within the NarL family.

Insights into the nature of DNA binding of AbrB-like transcription factors

Understanding the DNA recognition and binding by the AbrB-like family of transcriptional regulators is of significant interest since these proteins enable bacteria to elicit the appropriate response to diverse environmental stimuli. Although these "transition-state regulator" proteins have been well characterized at the genetic level, the general and specific mechanisms of DNA binding remain elusive. We present RDC-refined NMR solution structures and dynamic properties of the DNA-binding domains of three Bacillus subtilis transition-state regulators: AbrB, Abh, and SpoVT. We combined previously investigated DNase I footprinting, DNA methylation, gel-shift assays, and mutagenic and NMR studies to generate a structural model of the complex between AbrBN(55) and its cognate promoter, abrB8. These investigations have enabled us to generate a model for the specific nature of the transition-state regulator-DNA interaction, a structure that has remained elusive thus far.

A degenerate tripartite DNA-binding site required for activation of ComA-dependent quorum response gene expression in Bacillus subtilis

In Bacillus subtilis, the transcription factor ComA activates several biological processes in response to increasing population density. Extracellular peptide signaling is used to coordinate the activity of ComA with population density. At low culture densities, when the concentration of signaling peptides is lowest, ComA is largely inactive. At higher densities, when the concentration of signaling peptides is higher, ComA is active and activates the transcription of at least nine operons involved in the development of competence and in the production of degradative enzymes and antibiotics. We found that ComA binds a degenerate tripartite sequence consisting of three DNA-binding determinants or "recognition elements." Mutational analyses showed that all three recognition elements are required for transcription activation in vivo and for specific DNA binding by ComA in vitro. Degeneracy of the recognition elements in the ComA-binding site is an important regulatory feature for coordinating transcription with population density (i.e., promoters containing an optimized binding site have high activity at low culture density and are no longer regulated in the normal-density-dependent manner). We found that purified ComA forms a dimer in solution, and we propose a model for how two dimers of ComA bind to an odd number of DNA-binding determinants to activate transcription of target genes. This DNA-protein architecture for transcription activation appears to be conserved for ComA homologs in other Bacillus species.

Superoxide stress decreases expression of srfA through inhibition of transcription of the comQXP quorum-sensing locus in Bacillus subtilis

During the course of screening for competence-deficient mutants in the mutant collection constructed by the Japan Consortium of Bacillus Functional Genomics, a disruption mutant of sodA encoding superoxide dismutase was identified as a mutant with decreased transformation efficiency. In fact, in the sodA mutant we observed a severe decrease in the expression of srfA required for the development of genetic competence. Northern and primer extension analyses revealed inhibition of the transcription of the comQXP quorum-sensing locus in the sodA mutant, thereby preventing srfA expression. Furthermore, an excess amount of superoxide anion induced by the addition of paraquat also resulted in a decrease in comQXP transcription. Thus, it was concluded that high levels of superoxide are able to inhibit specifically the transcription of the comQXP operon. In support of this conclusion, the effect of added paraquat was significantly alleviated in a comX-independent srfA expression system.

Mutational analysis of the Bacillus subtilis RNA polymerase alpha C-terminal domain supports the interference model of Spx-dependent repression

The Spx protein of Bacillus subtilis exerts both positive and negative transcriptional control in response to oxidative stress by interacting with the C-terminal domain of the RNA polymerase (RNAP) alpha subunit (alphaCTD). Thus, transcription of the srf operon at the onset of competence development, which requires the ComA response regulator of the ComPA signal transduction system, is repressed by Spx-alphaCTD interaction. Previous genetic and structural analyses have determined that an Spx-binding surface resides in and around the alpha1 region of alphaCTD. Alanine-scanning mutagenesis of B. subtilis alphaCTD uncovered residue positions required for Spx function and ComA-dependent srf transcriptional activation. Analysis of srf-lacZ fusion expression, DNase I footprinting, and solid-phase promoter retention experiments indicate that Spx interferes with ComA-alphaCTD interaction and that residues Y263, C265, and K267 of the alpha1 region lie within overlapping ComA- and Spx-binding sites for alphaCTD interaction. Evidence is also presented that oxidized Spx, while enhancing interference of activator-RNAP interaction, is not essential for negative control.

Bacillus subtilis RghR (YvaN) represses rapG and rapH, which encode inhibitors of expression of the srfA operon

Rap proteins regulate the activity of response regulators including Spo0F, DegU and ComA. We found that overexpression of either RapG or RapH severely downregulated the expression of srfA, which belongs to the ComA regulon. Disruption of those genes, however, showed small effects on srfA expression. These observations suggested that Bacillus subtilis cells possess a repressor for rapG and rapH. To identify candidate repressors we developed a novel transcription factor array (TF array) assay, in which disruptions of 287 genes encoding regulatory proteins were independently transformed into a strain carrying rapH-lacZ and the resultant transformants were grown on agar plates containing Xgal to detect beta-galactosidase activity. We identified a yvaN disruptant which showed a rapH-overproducing phenotype. DNA microarray analysis of the yvaN mutant suggested that both rapG and rapH were overproduced, leading to inhibition of srfA expression. In a gel retardation assay, purified His-tagged YvaN specifically bound to promoter sequences of rapG and rapH. Further footprint and gel retardation analyses using various deleted probes uncovered critical sequences for YvaN binding. In addition, a lacZ fusion analysis confirmed the significance of YvaN binding for transcription regulation of rapG and rapH. Thus, YvaN was renamed RghR (rapG and rapH repressor). As the rapH gene is activated by ComK and RapH inhibits comK indirectly, this constitutes an autoregulatory loop modulated by RghR.

Conservation of genes and processes controlled by the quorum response in bacteria: characterization of genes controlled by the quorum-sensing transcription factor ComA in Bacillus subtilis

Quorum or diffusion responses in bacteria are mediated by secreted signalling molecules that accumulate extracellularly as cultures grow to high density. The regulatory response to these signalling molecules can result in dramatic changes in gene expression. In Bacillus subtilis, a quorum response is mediated by a secreted 10-amino-acid modified peptide (ComX pheromone) that activates a receptor histidine kinase (ComP) that activates a response regulator transcription factor (ComA). We have used DNA microarrays to identify genes controlled by the ComX-ComP-ComA quorum-sensing pathway. We found that ComX, ComP and ComA affect the same set of genes, indicating that the kinase ComP is the only receptor for the signalling molecule ComX, and that ComA is the only transcription factor activated directly by ComP, under the conditions tested. Expression of over 20 genes appears to be controlled directly by this signalling pathway, and expression of over 150 additional genes, including those involved in competence development, appears to be controlled indirectly. The genes affected appear to have three general functions: (i) to co-ordinate physiological changes involved in developmental pathways, (ii) to produce extracellular products under conditions in which high concentrations of product are needed to be effective and (iii) to enhance survival, growth and colonization under conditions of crowding or limited diffusion. Many of the genes and processes controlled by the quorum response in B. subtilis are also regulated by quorum sensing in Gram-positive and Gram-negative bacteria. The quorum-sensing signalling molecules and regulatory proteins are quite different between Gram-positives and Gram-negatives and the convergent physiological regulation of similar genes and processes indicate the important and conserved nature of the quorum response.

Binding of response regulator DegU to the aprE promoter is inhibited by RapG, which is counteracted by extracellular PhrG in Bacillus subtilis

We screened the putative rap-phr (response regulator aspartyl-phosphate phosphatase-phosphatase regulator) systems identified in the Bacillus subtilis genome for a rap gene that affects aprE (alkaline protease gene) expression by using a multicopy plasmid. We found that rapG was involved in the regulation of aprE, which belongs to the regulon of DegU, the response regulator of the DegS-DegU two-component system. Disruption of rapG and phrG resulted in enhancement and reduction of aprE-lacZ expression, respectively, suggesting that PhrG inhibits RapG activity. Addition of 1-30 nM of a synthetic pentapeptide (PhrG; NH2-EKMIG-COOH) to the phrG disruptant completely rescued aprE-lacZ expression, indicating that the PhrG peptide is indeed involved in aprE-lacZ expression. Surprisingly, either introduction of multicopy phrG or addition of the PhrG peptide at high concentrations (100-300 nM) to the phrG cells decreased aprE-lacZ expression. These results are reminiscent of the previous observation that at higher concentrations the PhrC peptide inhibits srfA-lacZ expression directed by ComA, the regulator of the ComP-ComA two-component system. Because the Rap proteins belong to a family of aspartyl protein phosphatases, we tried to investigate the possible influence of RapG on dephosphorylation of DegU-P (phosphorylated DegU) in vitro. RapG, however, did not affect dephosphorylation of DegU-P under the adopted experimental conditions. Therefore, we hypothesized that RapG might inhibit the binding activity of DegU to the target promoters. We analysed the interaction of DegU and RapG using the aprE promoter and another target, a comK promoter. Gel shift analysis revealed that RapG served as the inhibitor of DegU binding to the promoter regions of aprE and comK and that this inhibition was counteracted by the PhrG peptide.

Control of the arabinose regulon in Bacillus subtilis by AraR in vivo: crucial roles of operators, cooperativity, and DNA looping

The proteins involved in the utilization of L-arabinose by Bacillus subtilis are encoded by the araABDLMNPQ-abfA metabolic operon and by the araE/araR divergent unit. Transcription from the ara operon, araE transport gene, and araR regulatory gene is induced by L-arabinose and negatively controlled by AraR. The purified AraR protein binds cooperatively to two in-phase operators within the araABDLMNPQ-abfA (OR(A1) and OR(A2)) and araE (OR(E1) and OR(E2)) promoters and noncooperatively to a single operator in the araR (OR(R3)) promoter region. Here, we have investigated how AraR controls transcription from the ara regulon in vivo. A deletion analysis of the ara promoters region showed that the five AraR binding sites are the key cis-acting regulatory elements of their corresponding genes. Furthermore, OR(E1)-OR(E2) and OR(R3) are auxiliary operators for the autoregulation of araR and the repression of araE, respectively. Analysis of mutations designed to prevent cooperative binding of AraR showed that in vivo repression of the ara operon requires communication between repressor molecules bound to two properly spaced operators. This communication implicates the formation of a small loop by the intervening DNA. In an in vitro transcription system, AraR alone sufficed to abolish transcription from the araABDLMNPQ-abfA operon and araE promoters, strongly suggesting that it is the major protein involved in the repression mechanism of L-arabinose-inducible expression in vivo. The ara regulon is an example of how the architecture of the promoters is adapted to respond to the particular characteristics of the system, resulting in a tight and flexible control.

The CitST two-component system regulates the expression of the Mg-citrate transporter in Bacillus subtilis

citS and citT genes encoding a new two-component system were identified in the 71 degrees region between the pel and citM loci on the Bacillus subtilis chromosome. citS- and citT-deficient strains were unable to grow on minimal plates including citrate as a sole carbon source. In addition, a strain deficient in citM, which encodes the secondary transporter of the Mg-citrate complex, exhibited the same phenotype on this medium. Northern blot analysis revealed that citM was polycistronically transcribed with the downstream yflN gene, and that CitS and CitT were necessary for transcription of the citM-yflN operon. Upon addition of 2 mM citrate to DSM, this operon was strongly induced after the middle of the exponential growth phase in the wild type, but not in the citST double null mutant. Moreover, the transcription of this operon was completely repressed in the presence of 1% glucose. We found a sequence exhibiting homology to a catabolite-responsive element (cre) in the citM promoter region. Glucose repression was lost in ccpA and citM-cre mutants. From the result of a citM-promoter deletion experiment, putative CitT target sequences were found to be located around two regions, from -62 to -74 and from -149 to -189, relative to the citM start point. Furthermore, DNase I footprinting assays revealed that these two CitT target regions extended maximally from -36 to -84 and from -168 to -194. From these findings, we concluded that the expression of citM is positively regulated by the CitST system and negatively regulated by CcpA.

Mutations conferring amino acid residue substitutions in the carboxy-terminal domain of RNA polymerase alpha can suppress clpX and clpP with respect to developmentally regulated transcription in Bacillus subtilis

The Bacillus subtilis clpX and clpP genes are the sites of pleiotropic mutations that adversely affect growth on a variety of media and impair developmental processes such as sporulation and competence development. ClpX is necessary for the post-exponential induction of genes that require the sigmaH form of RNA polymerase for transcription. Both ClpX and ClpP are required for the activation of sigmaA-dependent transcription of the srf operon that encodes surfactin synthetase and the regulatory peptide ComS, required for the development of genetic competence. Transcription of srf is activated by the two-component regulatory system ComPA in response to the peptide pheromone, ComX, which mediates cell density-dependent control. A clpX mutant, although able to produce ComX, is unable to respond to the pheromone. A mutant allele of comP, encoding a product whose activity is independent of ComX, is not able to suppress clpX with respect to srf expression, suggesting that ClpXP acts at the level of ComA-dependent activation of srf transcription initiation. Suppressor mutations of clpX (cxs-1 and cxs-2) were isolated in screens for pseudorevertants exhibiting high levels of srf expression and sigmaH-dependent transcription respectively. One mutation, cxs-1, suppressed a clpP null mutation with respect to srf transcription, but did not overcome the block conferred by clpP on competence development and sporulation. Both cxs-1 and cxs-2 mutations map to the region of the rpoA gene encoding the RNA polymerase alpha C-terminal domain (alphaCTD). The reconstruction of the cxs-1 and cxs-2 alleles of rpoA confirmed that these mutations confer the suppressor phenotype. These findings provide further support for the hypothesis that ClpX and ClpP might be intimately associated with transcription initiation in B. subtilis.

Competence for transformation: a matter of taste

Genetic competence in both Bacillus subtilis and Streptococcus pneumoniae, as well as virulence in Staphylococcus aureus, are regulated by quorum-sensing mechanisms that use two-component signal transduction systems to respond to extracellular peptide pheromones. Recent data indicate that in all three systems closely related strains express markedly different pheromones and polytopic membrane receptor proteins. This polymorphism may function as a sexual isolation mechanism. In B. subtilis the downstream segment of the competence regulatory pathway acts by controlling the stability of a key transcription factor. In S. pneumoniae the downstream segment involves the transcriptional activation of a minor sigma factor that is in turn responsible for the expression of late competence genes.

The genes degQ, pps, and lpa-8 (sfp) are responsible for conversion of Bacillus subtilis 168 to plipastatin production

Bacillus subtilis YB8 produces the lipopeptide antibiotic plipastatin. B. subtilis MI113, which is a derivative of strain 168, was converted into a new plipastatin producer, strain 406, by competence transformation with the chromosomal DNA of YB8. Transposon mini-Tn10 insertional mutagenesis was applied to strain 406, which revealed that lpa-8 (sfp) (encoding 4'-phosphopantetheinyl transferase) and the pps operon (located between 167 and 171 degrees ) are essential for plipastatin production. The pps operon was previously suggested to encode putative peptide synthetases (A. Tognoni, E. Franchi, C. Magistrelli, E. Colombo, P. Cosmina, and G. Grandi, Microbiology 141:645-648, 1995) and was thought to be the fengycin operon (V. Tosato, A. M. Albertini, M. Zotti, S. Sonda, and C. V. Bruschi, Microbiology 143:3443-3450, 1997). We claim that the pps operon is the pli operon, encoding plipastatin synthetase. By using a new high-performance liquid chromatography system, we revealed that strain 168 expressing only lpa-8 can also produce plipastatin, although the yield is very low. However, the introduction of the pleiotropic regulator degQ of strain YB8 into strain 168 expressing lpa-8 resulted in a 10-fold increase in the production of plipastatin.

Mutational analysis and membrane topology of ComP, a quorum-sensing histidine kinase of Bacillus subtilis controlling competence development

ComP is a sensor histidine kinase of Bacillus subtilis required for the signal transduction pathway that initiates the development of competence for genetic transformation. It is believed that ComP senses the presence of ComX, a modified extracellular peptide pheromone, and donates a phosphate to ComA, thereby activating this transcription factor for binding to the srfA promoter. In the present study, fusions to the Escherichia coli proteins PhoA and LacZ and analysis of its susceptibility to the protease kallikrein were used to probe the membrane topology of ComP. These data suggest that ComP contains six or eight membrane-spanning segments and two large extracytoplasmic loops in its N-terminal membrane-associated domain. Deletions were introduced involving the large extracellular loops to explore the role of the N-terminal domain of ComP in signal transduction. The absence of the second loop conferred a phenotype in which ComP was active in the absence of ComX. The implications of these data are discussed.

Mutational analysis of ComS: evidence for the interaction of ComS and MecA in the regulation of competence development in Bacillus subtilis

The development of Bacillus subtilis genetic competence is a highly regulated adaptive response to stationary-phase stress. A key step in competence development is the activation of the transcriptional regulator ComK, which is required for the expression of genes encoding the products that function in DNA uptake. In log-phase cultures, ComK is trapped in a complex composed of MecA and ClpC, in which it is rendered inactive. The comS gene, contained within the srf operon, is induced in response to high culture cell density and nutritional stress. Its product functions to release active ComK from the complex, allowing ComK to stimulate the transcription initiation of its own gene as well as that of the late competence operons. Western analysis showed that ComS accumulates to maximal levels between T3 and T4, mirroring the pattern of competence cell development and late competence gene expression. Experiments to examine the target of ComS activity in vitro showed that ComS binds to MecA. This is further supported by coimmunoprecipitation using anti-MecA antiserum. To clarify the role of ComS in competence regulation, a system for evaluating the effect of comS and mutant derivatives on the expression of comG, one of the late competence operons, was constructed. comS mutations, created by alanine-scanning mutagenesis, that significantly reduced comG-lacZ expression were clustered within two regions, one at the N-terminus and the other at the C-terminus of ComS. ComSI13 --> A and ComSW43 --> A were selected for further analysis as representative mutants for both regions required for ComS activity. We observed that ComSI13 --> A showed significantly reduced affinity for MecA, whereas ComSW43 --> A showed near normal binding affinity for MecA. The results show that binding to MecA is critical for ComS function, but do not rule out the possibility that ComS possesses other activities.

A putative lichenysin A synthetase operon in Bacillus licheniformis: initial characterization

Certain Bacillus licheniformis strains isolated from oil wells have been shown to produce a very effective biosurfactant, lichenysin A, which is structurally similar to another less active lipopeptide, surfactin. Surfactin, like many small peptides in prokaryotes and lower eukaryotes, is synthesized non-ribosomally by multi-enzyme peptide synthetase complex. Analysis of several peptide synthetases of bacterial and fungal origin has revealed a high degree of sequence conservation. Two 35-mer oligonucleotides derived from highly conserved motifs ('core I' and 'core II') of surfactin synthetase were used to identify the cloned putative operon of lichenysin A synthetase lchA from B. licheniformis BNP29, a strain not amenable to genetic manipulation in a BAC system (F-plasmid-based bacterial artificial chromosome) based on Escherichia coli and its single-copy plasmid F-factor. A 32.4 kb fragment containing lichenysin A biosynthesis locus was sequenced and analysed. The structural architecture of putative lichenysin A synthetase protein containing seven amino acid (aa) activation-thiolation, two epimerization and one thioesterase domains is discussed in terms of its similarity to surfactin and other peptide synthetases. The 100 aa peptide chain situated between the highly conserved signature sequences FDXX and NXYGPTE(IV)X within amino acid binding domains of peptide synthetases is proposed to be a minimal block dictating the substrate specificity of the enzymes. A new operon-type structure has been localized directly upstream from the lichenysin A synthetase genes which, on the basis of sequence determination, potentially encode a four-member ABC-type transport system involved in product secretion.

Coordinate transcription and physical linkage of domains in surfactin synthetase are not essential for proper assembly and activity of the multienzyme complex

Bacterial peptide synthetases have two common features that appear to be strictly conserved. 1) The enzyme subunits are co-regulated at both transcriptional and translational level. 2) The organization of the different enzymatic domains constituting the enzyme fulfills the "colinearity rule" according to which the order of the domains along the chromosome parallels their functional hierarchy. Considering the high degree of conservation of these features, one would expect that mutations such as transcription uncoupling and domain dissociations, deletions, duplications, and reshuffling would result in profound effects on the quality and quantity of synthesized peptides. To start testing this hypothesis, we designed two mutants. In one mutant, the operon structure of surfactin synthetase was destroyed, thus altering the concerted expression of the enzyme subunits. In the other mutant, the thioesterase domain naturally fused to the last amino acid binding domain of surfactin was physically dissociated and independently expressed. When the lipopeptides secreted by the mutant Bacillus subtilis strains were purified and characterized, they appeared to be expressed approximately at the same level of the wild type surfactin and to be identical to it, indicating that specific domain-domain interactions rather than coordinated transcription and translation play the major role in determining the correct assembly and activity of peptide synthetases.

Molecular genetics of biosurfactant production

Biosurfactants are surface-active microbial products that have numerous industrial applications. The molecular genetics of two structurally diverse biosurfactants, a glycolipid and a lipopeptide, were the first to be characterized. Recent advances include the identification of the structural genes for a second lipopeptide, and the isolation of a gene responsible for enhanced emulsification activity of a high molecular weight biopolymer. New insight has also developed in the regulatory mechanisms of the originally described biosurfactants, both of which are controlled by quorum sensing, a mechanism bacteria use to monitor cell density.

Altered srf expression in Bacillus subtilis resulting from changes in culture pH is dependent on the Spo0K oligopeptide permease and the ComQX system of extracellular control

The expression of the srf operon of Bacillus subtilis, encoding surfactin synthetase and the competence regulatory protein ComS, was observed to be reduced when cells were grown in a rich glucose- and glutamine-containing medium in which late-growth culture pH was 5.0 or lower. The production of the surfactin synthetase subunits and of surfactin itself was also reduced. Raising the pH to near neutrality resulted in dramatic increases in srf expression and surfactin production. This apparent pH-dependent induction of srf expression required spo0K, which encodes the oligopeptide permease that functions in cell-density-dependent control of sporulation and competence, but not CSF, the competence-inducing pheromone that regulates srf expression in a Spo0K-dependent manner. Both ComP and ComA, the two-component regulatory pair that stimulates cell-density-dependent srf transcription, were required for optimal expression of srf at low and high pHs, but ComP was not required for pH-dependent srf induction. The known negative regulators of srf, RapC and CodY, were found not to function significantly in pH-dependent srf expression. Late-growth culture supernatants at low pH were not active in inducing srf expression in cells of low-density cultures but were rendered active when their pH was raised to near neutrality. ComQ (and very likely the srf-inducing pheromone ComX) and Spo0K were found to be required for the extracellular induction of srf-lacZ at neutral pH. The results suggest that srf expression, in response to changes in culture pH, requires Spo0K and another, as yet unidentified, extracellular factor. The study also provides evidence consistent with the hypothesis that ComP acts both positively and negatively in the regulation of ComA and that both activities are controlled by the ComX pheromone.

A new Bacillus subtilis gene, med, encodes a positive regulator of comK

Bacillus subtilis degR, a positive regulator of the production of degradative enzymes, is negatively regulated by the competence transcription factor ComK which is overproduced in mecA null mutants. We used transposon Tn10 to search for a mutation that reduced the repression level of degR caused by a mecA mutation. A new gene exerting positive regulation on comK was obtained and designated med (suppressor of mecA effect on degR). Sequence determination, Northern analysis, and primer extension analyses revealed that the med gene contained an open reading frame (ORF) composed of 317 codons and was transcribed into an approximately 1,250-nucleotide mRNA together with its short downstream gene. The expression of comK is positively regulated by factors such as ComK itself, ComS (SrfA)-MecA, DegU, SinR, and AbrB. Quantitative analyses using comK'-'lacZ, srfA-lacZ, degU'-'lacZ, and sinR'-'lacZ fusions showed that disruption of med caused a significant decrease in comK expression in both mecA+ and mecA strains, while expression of srfA, sinR, and degU was not affected by the mutation. An epistatic analysis revealed that overproduction of ComK resulted in alteration of med expression, suggesting a regulatory loop between comK and med. Several possible mechanisms for positive regulation of comK by Med are discussed.

Microbial production of surfactants and their commercial potential

Many microorganisms, especially bacteria, produce biosurfactants when grown on water-immiscible substrates. Biosurfactants are more effective, selective, environmentally friendly, and stable than many synthetic surfactants. Most common biosurfactants are glycolipids in which carbohydrates are attached to a long-chain aliphatic acid, while others, like lipopeptides, lipoproteins, and heteropolysaccharides, are more complex. Rapid and reliable methods for screening and selection of biosurfactant-producing microorganisms and evaluation of their activity have been developed. Genes involved in rhamnolipid synthesis (rhlAB) and regulation (rhlI and rhlR) in Pseudomonas aeruginosa are characterized, and expression of rhlAB in heterologous hosts is discussed. Genes for surfactin production (sfp, srfA, and comA) in Bacillus spp. are also characterized. Fermentative production of biosurfactants depends primarily on the microbial strain, source of carbon and nitrogen, pH, temperature, and concentration of oxygen and metal ions. Addition of water-immiscible substrates to media and nitrogen and iron limitations in the media result in an overproduction of some biosurfactants. Other important advances are the use of water-soluble substrates and agroindustrial wastes for production, development of continuous recovery processes, and production through biotransformation. Commercialization of biosurfactants in the cosmetic, food, health care, pulp- and paper-processing, coal, ceramic, and metal industries has been proposed. However, the most promising applications are cleaning of oil-contaminated tankers, oil spill management, transportation of heavy crude oil, enhanced oil recovery, recovery of crude oil from sludge, and bioremediation of sites contaminated with hydrocarbons, heavy metals, and other pollutants. Perspectives for future research and applications are also discussed.

Biochemical characterization of a molecular switch involving the heat shock protein ClpC, which controls the activity of ComK, the competence transcription factor of Bacillus subtilis

Development of genetic competence in Bacillus subtilis is controlled by the competence-specific transcription factor ComK. ComK activates transcription of itself and several other genes required for competence. The activity of ComK is controlled by other genes including mecA, clpC, and comS. We have used purified ComK, MecA, ClpC, and synthetic ComS to study their interactions and have demonstrated the following mechanism for ComK regulation. ClpC, in the presence of ATP, forms a ternary complex with MecA and ComK, which prevents ComK from binding to its specific DNA target. This complex dissociates when ComS is added, liberating active ComK. ClpC and MecA function as a molecular switch, in which MecA confers molecular recognition, connecting ClpC to ComK and to ComS.

Plasmid-amplified comS enhances genetic competence and suppresses sinR in Bacillus subtilis

The establishment of genetic competence in Bacillus subtilis is controlled by a vast signal transduction network involving the products of genes that function in several postexponential-phase processes. Two of these proteins, SinR and DegU, serve as molecular switches that influence a cell's decision to undergo either sporulation or genetic competence development. In order to determine the roles of SinR and DegU in competence control, multicopy suppression experiments with plasmid-amplified comS, SinR, and degU genes were undertaken. Multicopy comS was found to elevate competence gene transcription and transformation efficiency in both wild-type and sinR mutant cells but not in degU mutant cells. Multicopy degU failed to suppress comS or sinR mutations. No suppression of comS or degU by multicopy sinR was observed. The expression of a comS'::'lacZ translational fusion and srf-lacZ operon fusion was examined in sinR cells and cells bearing plasmid-amplified sinR. The expression of comS'::'lacZ gene fusion was reduced by the sinR mutation, but both comS'::'lacZ and srf-lacZ were repressed by multicopy sinR. Cells bearing plasmid-amplified sinR were poorly competent. These results suggest that sinR is required for optimal comS expression but not transcription from the srf promoter and that SinR at high concentrations represses srf transcription initiation.

Production of rhamnolipid biosurfactants

Biosurfactants are of increasing interest due to their broad range of potential applications. A large variety of microbial surfactants is known at present, some of which may be used for specific applications. Towards the large scale industrial production of biosurfactants, the physiology, biochemistry and genetics of biosurfactant synthesis has to be well understood. A fully integrated process has to be developed, allowing high productivities under optimized conditions. In the past few years, we have investigated the molecular biology of rhamnolipid biosynthesis have been partially purified and characterized. The structural and regulatory genes encoding the rhamnolipid synthesis pathway have been isolated and characterized. The knowledge of the complex mechanisms involved in rhamnolipid synthesis facilitates the overproduction of these extracellular compounds. Furthermore, the transfer of the relevant genes into other species allows the production of rhamnolipids in heterologous hosts under controlled conditions. An integrated process for the production of rhamnolipids on an industrial scale has been developed. This process involves continuous cultivation under optimized media and growth conditions and makes use of refined methods of cell recycling, gas exchange and downstream processing, thus allowing high yields and productivities.

comK acts as an autoregulatory control switch in the signal transduction route to competence in Bacillus subtilis

The comK gene is a regulatory transcription unit which is essential for the development of genetic competence in Bacillus subtilis. The transcription of comK is under strict nutritional and growth phase-dependent control and has been shown to depend on the gene products of comA and srfA. In this report, we show that expression of comK is dependent on its own gene product as well as on the gene products of all other tested regulatory genes known to be involved in competence development (abrB, comA, comP, degU, sin, spo0A, spo0H, spo0K, and srfA). A mecA mutation is able to suppress the competence deficiency of mutations in any of these regulatory loci except for mutations in spo0A and, as we show here, in comK. Furthermore, we show that the presence of comK on a multiple copy plasmid leads to derepression of comK expression, causing an almost constitutive expression of competence in minimal medium as well as permitting competence development in complex medium. We infer from these results that the signals which trigger competence development, after having been received and processed by the various components of the competence signal transduction pathway, all converge at the level of comK expression. As soon as derepression of comK expression occurs, the positive autoregulation rapidly results in accumulation of the comK gene product, which subsequently induces competence.

Amino-acylation site mutations in amino acid-activating domains of surfactin synthetase: effects on surfactin production and competence development in Bacillus subtilis

The part of the srfA operon of Bacillus subtilis that contains the region required for competence development is composed of the first four amino acid-activating domains which are responsible for the incorporation of Glu, Leu, D-Leu, and Val into the peptide moiety of the lipopeptide surfactin. Ser-to-Ala substitutions were made in the amino-acylation site of each domain, and their effects on surfactin production and competence development were examined. All of the mutations conferred a surfactin-negative phenotype, supporting the finding that the conserved Ser in the amino-acylation site is required for peptide synthesis. However, none of the mutations affected significantly competence development or the expression of a lacZ fusion to the late competence operon comG. This, coupled with recent findings that only the fourth, Val-activating, domain is required for competence, suggests that some activity, other than amino-acylation and perhaps unrelated to peptide synthesis, possessed by the fourth domain is involved in the role of srfA in regulating competence development.

ComA, a phosphorylated response regulator protein of Bacillus subtilis, binds to the promoter region of srfA

ComA is a response regulator protein of Bacillus subtilis which is required for the transcription of several genes which are involved in late-growth expression and in responses to environmental stress. Among these genes are degQ, gsiA, and srfA. The last is an operon needed for the development of genetic competence, surfactin production, and normal sporulation. We show here that partially purified ComA protein, isolated from an overproducing Escherichia coli strain, is phosphorylated in vitro by incubation with acetyl phosphate and that ComA could bind specifically to a DNA fragment containing the promoter of srfA and associated sequences. The binding affinity is enhanced when ComA is phosphorylated. DNase I protection analysis identified two protected sites located upstream from the srfA promoter. The presence of DNase I-hypersensitive bonds induced by ComA binding which are located between the protected sequences is consistent with a model for ComA action involving the bending of DNA.