Second-Generation Bioethanol from Coconut Husk

High-solids loading processing for an integrated lignocellulosic biorefinery: Effects of transport phenomena and rheology - A review

This review aims to present an analysis and discussion on the processing of lignocellulosic biomass in terms of biorefinery concept and circular bioeconomy operating at high solids lignocellulosic (above 15% [w/w]) at the pretreatment, enzymatic hydrolysis stage, and fermentation strategy for an integrated lignocellulosic bioprocessing. Studies suggest high solids concentration enzymatic hydrolysis for improved sugars yields and methods to overcome mass transport constraints. Rheological and computational fluid dynamics models of high solids operation through evaluation of mass and momentum transfer limitations are presented. Also, the review paper explores operational feeding strategies to obtain high ethanol concentration and conversion yield, from the hydrothermal pretreatment and investigates the impact of mass load over the operational techniques. Finally, this review contains a brief overview of some of the operations that have successfully scaled up and implemented high-solids enzymatic hydrolysis in terms of the biorefinery concept.

Effective pretreatment of lignin-rich coconut wastes using a low-cost ionic liquid

Coconut husks and shells are underutilised agricultural feedstocks in the bio-based industry. These biomass wastes have a higher lignin content than other woody biomass and have excellent potential as raw materials for the production of lignin-based materials. This work demonstrates the performance of a low-cost protic ionic liquid, N,N,N-dimethylbutylammonium hydrogen sulfate ([DMBA][HSO₄]), for ionoSolv pretreatment of coconut husk and shell at 150 °C for 45-90 min and 170 °C for 15-60 min. Optimum pretreatment conditions were observed at 170 °C and 45 min for both feedstocks. At these conditions, [DMBA][HSO₄] was able to remove almost 77 wt% of the lignin from the husk; leaving a cellulosic rich pulp behind, which released 82 % of the theoretical maximum glucose after enzymatic saccharification. The pretreated shell, by comparison, achieved 82 wt% lignin removal and 89 % glucose yield and these higher values could be attributed to the highly porous structure of coconut shell cell walls. The cleavage of the β-O-4 aryl ether linkages of lignin followed by extensive C-C condensation in the lignin at longer pretreatment times was shown by HSQC NMR analysis. This extensive condensation was evidenced by molecular weights > 10,000 g/mol exhibited by lignin precipitated after pretreatment at high temperature and long times. The high degree of lignin removal and high glucose release from both feedstocks demonstrate that [DMBA][HSO₄] is an excellent ionic liquid for fractionation of very lignin-rich biomass.

Algal Cells-Derived Extracellular Vesicles: A Review With Special Emphasis on Their Antimicrobial Effects

Extracellular vesicles (EVs) originated from different cells of approximately all kinds of organisms, recently got more attention because of their potential in the treatment of diseases and reconstructive medicine. To date, lots of studies have been performed on mammalian-derived vesicles, but little attention has been paid to algae and marine cells as valuable sources of EVs. Proving the promising role of EVs in medicine requires sufficient resources to produce qualified microvesicles. Algae, same as its other sister groups, such as plants, have stem cells and stem cell niches. Previous studies showed the EVs in plants and marine cells. So, this study was set out to talk about algal extracellular vesicles. EVs play a major role in cell-to-cell communication to convey molecules, such as RNA/DNA, metabolites, proteins, and lipids within. The components of EVs depends on the origin of the primitive cells or tissues and the isolation method. Sufficient resources are needed to produce high-quality, stable, and compatible EVs as a drug or drug delivery system. Plant stem cells have great potential as a new controllable resource for the production of EVs. The EVs secreted from stem cells can easily be extracted from the cell culture medium and evaluated for medicinal uses. In this review, the aim is to introduce algae stem cells as well as EVs derived from algal cells. In the following, the production of the EVs¸ the properties of EVs extracted from these sources and their antimicrobial effects will be discussed.

Artichoke leaf extract supplementation lowers hepatic oxidative stress and inflammation and increases multidrug resistance-associated protein 2 in mice fed a high-fat and high-cholesterol diet

Artichoke (Cynara scolymus) leaf extract (ALE) contains many phytonutrients that may have antioxidant and anti-inflammation activities against many diseases including liver damage. To investigate the protective effects of ALE on high-fat and high-cholesterol (HFHC) diet-induced steatohepatitis and liver damage in mice, twenty-four female mice were fed an HFHC diet without or with 0.5% and 1% ALE supplementation for 6 weeks. The antioxidant and anti-inflammation activities and histological changes in the liver after ALE treatment were evaluated. The results show that ALE treatment reduced the HFHC diet-induced elevation of liver damage, as indicated by an increased alanine aminotransferase activity in plasma and perivenular inflammatory infiltrates in the liver. In addition, ALE ameliorated HFHC diet-induced depletion of hepatic glutathione (GSH) and elevations of plasma total cholesterol, triglyceride and hepatic triglyceride. ALE suppressed HFHC diet-induced accumulation of cholesterol precursors, including squalene and desmosterol in the liver. Higher hepatic GSH contents and activities of GSH-related enzymes were observed after ALE treatment. Higher expressions of nuclear factor erythroid 2-related factor 2 and heme oxygenase-1 (HO-1) were induced by the HFHC diet; however, ALE treatment reduced HO-1 expression. The NOD-like receptor protein 3, caspase-1, and interleukin-1β protein and mRNA levels were reduced in the liver by ALE. A higher multidrug resistance-associated protein 2 expression in the liver was found after ALE treatment. These results suggest that ALE may ameliorate oxidative stress, inflammation and lipid metabolism disorder in HFHC diet-induced steatohepatitis and liver damage.

TEMPO-oxidized nanocellulose films derived from coconut residues: Physicochemical, mechanical and electrical properties

The present work focuses on the development of cellulose nanofibrils (CNF) film that derived from sustainable biomass resources, which potentially to work as bio-based conductive membranes that assembled into supercapacitors. The chemically purified cellulose was isolated from different parts of coconut (coconut shell and its husk) and further subjected to 2,2,6,6-tetramethylpiperidine-1-oxyl radical (TEMPO)-mediated oxidation for CNF preparation. Physicochemical properties of prepared CNFs were studied in terms of chemical characteristics & crystallinity, surface functionalities, surface morphology, and thermal properties. Both coconut shell-derived CNF and coconut husk-derived CNF fulfilled with nanocellulose's characteristics with fibres width ranged of 70-120 nm and 150-330 nm, respectively. CNF films were further prepared by solvent casting method to measure the modulus elasticity, piezoelectric and dielectric properties of the films. Mechanical study indicated that coconut shell-derived CNF film showed a higher value of elastic modulus than the coconut husk-derived CNF film, which was 8.39 GPa and 5.36 GPa, respectively. The effectiveness of electrical aspects for CNF films are well correlated with the crystallinity and thermal properties, associated with it's composition of different coconut's part.

In silico identification of epitope-based vaccine candidates against HTLV-1

Human T cell leukemia virus type-1 (HTLV-1) is the cause of adult T cell leukemia/lymphoma (ATL), uveitis, and certain pulmonary diseases. In recent decades, many scientists have proposed the development of different treatment and prevention strategies to combat HTLV-1 infection. In this study, we used bioinformatics tools to predict peptide and protein vaccine candidates against HTLV-1 that can potentially induce antibody production and both CD4+ and CD8+ T cell immune responses. Five critical proteins, viz., Hbz, Tax, Pol, Gag, and Env, were analyzed for predicting immunogenic T and B cell epitopes and subsequently evaluated using bioinformatics tools. Based on the predictions, the most antigenic epitopes were selected, and their interaction with immune receptors was investigated. We also designed a protein vaccine candidate with an eight-epitopes-rich domain, including overlapping epitopes detected on both B and T cells. Then, the interaction of the epitope and the designed protein with immune receptors was validated in an in silico docking study. The docking analysis showed that the O2 epitope and D8 protein interact strongly with immune receptors, especially the HLA-A*02:01 receptor. The stability of the interactions was investigated by molecular dynamics (MD) for 100 ns. The root mean square deviation, radius of gyration, hydrogen bonds, and solvent-accessible surface area were calculated for the 100 ns trajectory period. MD studies demonstrated that the O2-HLA-A*02:01 and D8-HLA-A*02:01 complexes were stable during the simulation. Analysis of in silico results showed that the peptide and the designed protein could elicit humoral and cell-mediated immune responses.Communicated by Ramaswamy H. Sarma.

Evolutionary engineering of Lactobacillus pentosus improves lactic acid productivity from xylose-rich media at low pH

Since xylose is the second most abundant sugar in lignocellulose, using microorganisms able to metabolize it into bio-based chemicals like lactic acid is an attractive approach. In this study, Lactobacillus pentosus CECT4023T was evolved to improve its xylose fermentation capacity even at acid pH by adaptive laboratory evolution in repeated anaerobic batch cultures at increasing xylose concentration. The resulting strain (named MAX2) presented between 1.5 and 2-fold more xylose consumption and lactic acid production than the parental strain in 20 g L^-1 xylose defined media independently of the initial pH value. When the pH was controlled in bioreactor, lactic acid productivity at 16 h increased 1.4-fold when MAX2 was grown both in xylose defined media and in wheat straw hydrolysate. These results demonstrated the potential of this new strain to produce lactic acid from hemicellulosic substrates at low pH, reducing the need of using neutralizing agents in the process.

Biomass and waste materials as potential sources of nanocrystalline cellulose: Comparative review of preparation methods (2016 - Till date)

Nanocrystalline cellulose (NCC) has gained much popularity over the last decade as a preferred nanomaterial in varied applications, despite its laborious industrial production and higher cost. Its production methods have undergone a great deal of metamorphosis lately. The main emphasis has been on the environment-friendly and green processes, in addition to the sustainable and renewable feedstock. Globally, the researchers have explored biomass and waste cellulosic materials as renewable sources for NCC extraction. Newer and/or improved process alternatives, e.g., ultrasonication, enzymatic hydrolysis and mechanical treatments have been applied successfully for producing high-quality material. Detailed investigations on optimizing the overall yield from cheaper feedstock have yielded obvious benefits. This is still work in progress. The present review majorly focuses on the advances made in the NCC preparation field from biomass and waste cellulosic materials in last three years (2016 - till date). Collaborative efforts between chemical engineers and research scientists are crucial for the success of this really amazing nanomaterial.