High-shear, jet-cooking, and alkali treatment of corn distillers' dried grains to obtain products with enhanced protein, oil and phenolic antioxidants

Anti-inflammatory effects of proanthocyanidin-rich red rice extract via suppression of MAPK, AP-1 and NF-κB pathways in Raw 264.7 macrophages

BACKGROUND/OBJECTIVES

Several pharmacological properties of red rice extract have been reported including anti-oxidant, anti-tumor, and reduced cancer cell invasion. This study was conducted to evaluate the anti-inflammatory effects of red rice extract on the production of inflammatory mediators in lipopolysaccharide (LPS)-induced Raw 264.7 macrophages.

MATERIALS/METHODS

Pro-inflammatory cytokines including tumor necrosis factor-α and interleukin-6 were determined by ELISA and cyclooxygenase-2 and inducible nitric oxide synthase expression was evaluated using western blot analysis. In addition, the signaling pathway controlling the inflammatory cascade such as nuclear factor kappa B (NF-κB), activator proteins-1 (AP-1), and mitogen-activated protein kinase (MAPK) was determined.

RESULTS

Our results showed that red rice polar extract fraction (RR-P), but not non-polar extract fraction, inhibited interleukin-6, tumor necrosis factor-α, and nitric oxide production in LPS-induced Raw 264.7 cells. RR-P also reduced the expression of inflammatory enzymes, inducible nitric oxide synthase, and cyclooxygenase-2. In addition, activation of AP-1 and NF-κB transcription factor in the nucleus was abrogated by RR-P. RR-P inhibited the phosphorylation of extracellular signaling-regulated kinase 1/2, c-Jun NH2-terminal kinase, and p38 MAPK signaling responsible for the expression of inflammatory mediators in LPS-stimulated Raw 264.7 cells. Based on chemical analysis, high amounts of proanthocyanidin and catechins were detected in the RR-P fraction. However, only proanthocyanidin reduced NF-κB and AP-1 activation in LPS-activated Raw 264.7 cells.

CONCLUSION

These observations suggest that the anti-inflammatory properties of RR-P may stem from the inhibition of pro-inflammatory mediators via suppression of the AP-1, NF-κB, and MAPKs pathways.

Changes in phenolic acid content during dry-grind processing of corn into ethanol and DDGS

BACKGROUND

Nine fractions (1, ground corn; 2, cooked slurry; 3, liquefied slurry; 4, fermented mash; 5, whole stillage; 6, thin stillage; 7, condensed distillers soluble (CDS); 8, distillers wet grains (DWG); and 9, distillers dried grains with solubles (DDGS)) were collected at different steps from three commercial dry-grind bioethanol processing plants. Samples were analyzed for individual and total phenolic acid content by HPLC and the antioxidant capacity by ferric reducing antioxidant power (FRAP) assay.

RESULTS

There were significant differences in phenolic acid (individual and total) content and the antioxidant capacity in the nine fractions collected from the three processing plants, but the changing trends in all three plants were very similar. The four phenolic acids identified in all fractions were caffeic, p-coumaric, ferulic and sinapic acids. Vanillic acid was present in all fractions except fractions 2 and 3. All fractions collected following fermentation, except fractions 6 and 7, had higher concentrations of phenolic acids than fractions before fermentation, with DWG having the highest phenolic acids content.

CONCLUSION

The increased concentration of phenolic acid content after fermentation in four fractions (4, 5, 8 and 9) was primarily due to depletion of starch during dry-grind processing. Further research is needed to investigate the influence of enriched phenolic acid concentration in DDGS on diet palatability (sensory property) and animal health.