The effect of perfluoroisobutene and phosgene on rat lavage fluid surfactant phospholipids

Phosgene-Induced acute lung injury: Approaches for mechanism-based treatment strategies

Phosgene (COCl2) gas is a chemical intermediate of high-volume production with numerous industrial applications worldwide. Due to its high toxicity, accidental exposure to phosgene leads to various chemical injuries, primarily resulting in chemical-induced lung injury due to inhalation. Initially, the illness is mild and presents as coughing, chest tightness, and wheezing; however, within a few hours, symptoms progress to chronic respiratory depression, refractory pulmonary edema, dyspnea, and hypoxemia, which may contribute to acute respiratory distress syndrome or even death in severe cases. Despite rapid advances in medicine, effective treatments for phosgene-inhaled poisoning are lacking. Elucidating the pathophysiology and pathogenesis of acute inhalation toxicity caused by phosgene is necessary for the development of appropriate therapeutics. In this review, we discuss extant literature on relevant mechanisms and therapeutic strategies to highlight novel ideas for the treatment of phosgene-induced acute lung injury.

Mechanism of Phosgene-Induced Acute Lung Injury and Treatment Strategy

Phosgene (COCl₂) was once used as a classic suffocation poison and currently plays an essential role in industrial production. Due to its high toxicity, the problem of poisoning caused by leakage during production, storage, and use cannot be ignored. Phosgene mainly acts on the lungs, causing long-lasting respiratory depression, refractory pulmonary edema, and other related lung injuries, which may cause acute respiratory distress syndrome or even death in severe cases. Due to the high mortality, poor prognosis, and frequent sequelae, targeted therapies for phosgene exposure are needed. However, there is currently no specific antidote for phosgene poisoning. This paper reviews the literature on the mechanism and treatment strategies to explore new ideas for the treatment of phosgene poisoning.

Mechanisms of Pulmonary Toxicity of Perfluoro-n-Alkane Pyrolysis Products with Consideration of the Structural Features of the Blood-Air Barriers

Perfluoroisobutylene a is pulmonotoxic chemical generated during pyrolysis of perfluoro-nalkanes (polytetrafluoroethylene). The mechanisms of acute pulmonary toxicity induced by perfluoroisobutylene have not been studied yet. The analysis of tissues of brown frogs showed that the products of polytetrafluoroethylene pyrolysis induce typical inflammatory response in the lungs (fluid accumulation, erythrocyte stasis, desquamation of the epithelium, and capillary plethora in lung septa) and oropharyngeal cavity (degeneration of ciliated epithelium, hyperemia of underlying vessels with plasmatic imbibition of the connective tissue, and margination of segmented leukocytes and monocytes). The absence of surfactant is a specific feature of the blood-air barrier of the oropharyngeal cavity in frogs compared to the lungs. It can be hypothesized that toxic effects of perfluoroisobutylene are determined by its influence on epithelial (pneumocytes and cells of nonkeratinized stratified ciliated epithelium) and endothelial cells. Even though the effects of the agent on surfactant cannot be excluded, they do not determine the probability of development of inflammatory response.

Management of phosgene-induced acute lung injury

CONTEXT

Phosgene is a substance of immense importance in the chemical industry. Because of its widespread industrial use, there is potential for small-scale exposures within the workplace, large-scale accidental release, or even deliberate release into a built-up area.

OBJECTIVE

This review aims to examine all published studies concerning potential treatments for phosgene-induced acute lung injury and incorporate them into up-to-date clinical guidance. In addition, it aims to contrast the approaches when dealing with small numbers of patients known to be exposed (possibly with dose information) with the presentation of a large and heterogeneous population of casualties following a significant industrial accident or deliberate release; no published guidelines have specifically addressed this second problem.

METHODS

PubMed and Embase were searched for all available years till April 2010 and 584 papers were identified and considered.

EXPERIMENTAL STUDIES

Because of the nature of the injury, there have been no human trials of patients exposed to phosgene. Multiple small and large animal studies have been performed to examine potential treatments of phosgene-induced acute lung injury, but many of these used isolated organ models, pretreatment regimens, or clinically improbable doses. Recent studies in large animals using both realistic time frames and dosing regimens have improved our knowledge, but clinical guidance remains based on incomplete data. Management of a small-scale, confirmed exposure. In the circumstance of a small-scale, confirmed industrial release where a few individuals are exposed and present rapidly, an intravenous bolus of high-dose corticosteroid (e.g., methylprednisolone 1 g) should be considered, although there are no experimental data to support this recommendation. The evidence is that there is no benefit from nebulized steroid even when administered 1 h after exposure, or methylprednisolone if administered intravenously ≥6 h after exposure. Consideration should also be given to administration of nebulized acetylcysteine 1-2 g, though there is no substantive evidence of benefit outside a small animal, isolated lung model and there is a possibility of adverse effects. If the oxygen saturation falls below 94%, patients should receive the lowest concentration of supplemental oxygen to maintain their SaO(2) in the normal range. Once patients require oxygen, nebulized β-agonists [e.g., salbutamol (albuterol) 5 mg by nebulizer every 4 h] may reduce lung inflammation if administered within 1 h of exposure. Elective intubation should be considered early using an ARDSnet protective ventilation strategy. Management of a large-scale, non-confirmed exposure. In the circumstances of a large-scale industrial or urban release, not all patients presenting will have been exposed and health services are likely to be highly stretched. In this situation, patients should not be treated immediately as there is no evidence that delaying therapy causes harm, rather they should be rested and observed with regular physical examination and measurement of peripheral oxygen saturations. Once a patient's oxygen saturation falls below 94%, treatment with the lowest concentration of oxygen required to maintain their oxygen saturations in the normal range should be started. Once oxygen has been started, nebulized β-agonists [e.g., salbutamol (albuterol) 5 mg by nebulizer every 4 h] may reduce lung inflammation if administered within 1 h of exposure, though delayed administration which is likely following a large-scale release has not been tested formally. There is no benefit from nebulized steroid even when administered 1 h after exposure, or high-dose corticosteroid if administered intravenously ≥6 h after exposure. Although there are no experimental data to support this recommendation, an intravenous bolus of high-dose corticosteroid (e.g., methylprednisolone 1 g) may be considered if presentation is <6 h and resources allow. Depending on the numbers of casualties presenting, invasive ventilation should be initiated either electively once symptoms present (especially where there is a short latent period, indicating likelihood of more significant injury), or delayed until required. Ventilation should be with high positive end expiratory pressure, ARDSnet recommended ventilation.

CONCLUSIONS

The mechanisms underlying the phosgene-induced acute lung injury are not well understood. Future experimental work should ensure that potential treatments are tested in a large animal model using realistic dosing regimens and clinically relevant timings, such as those that might be found in a mass casualty situation.

Correlation between sPLA2-IIA and phosgene-induced rat acute lung injury

Secreted phospholipase A(2) of group IIA (sPLA(2)-IIA) has been involved in a variety of inflammatory diseases, including acute lung injury. However, the specific role of sPLA(2)-IIA in phosgene-induced acute lung injury remains unidentified. The aim of the present study was to investigate the correlation between sPLA(2)-IIA activity and the severity of phosgene-induced acute lung injury. Adult male rats were randomly exposed to either normal room air (control group) or a concentration of 400 ppm phosgene (phosgene-exposed group) for there are 5 phosgene-exposed groups altogether. For the time points of 1, 3, 6, 12 and 24 h post-exposure, one phosgene-exposed group was sacrificed at each time point. The severity of acute lung injury was assessed by Pa(O2)/F(IO2) ratio, wet-to-dry lung-weight ratio, and bronchoalveolar lavage (BAL) fluid protein concentration. sPLA(2)-IIA activity in BAL fluid markedly increased between 1 h and 12 h after phosgene exposure, and reached its highest level at 6 h. Moreover, the trend of this elevation correlated well with the severity of lung injury. These results indicate that sPLA(2)-IIA probably participates in phosgene-induced acute lung injury.

Therapeutic Treatments of Phosgene-Induced Lung Injury

A series of studies was performed to address treatment against the former chemical warfare edemagenic gas phosgene. Both in situ and in vivo models were used to assess the efficacy of postexposure treatment of phosgene-induced lung injury using clinically existing drugs. The degree of efficacy was judged by examining treatment effects on pulmonary edema formation (PEF) as measured by wet/dry weight (WW/DW) ratios, real-time (in situ) lung weight gain (LWG), survival rates (SR), odds ratios, and glutathione (GSH) redox states. Drugs included N-acetylcysteine (NAC), ibuprofen (IBU), aminophylline (AMIN), and isoproterenol (ISO). Using the in situ isolated perfused rabbit lung model (IPRLM), intratracheal (IT) NAC (40 mg/kg bolus) delivered 45-60 min after phosgene exposure (650 mg/m(3)) for10 min lowered pulmonary artery pressure, LWG, leukotrienes (LT) C(4)/D(4)/E(4), lipid peroxidation, and oxidized GSH. We concluded that NAC protected against phosgene-induced lung injury by acting as an antioxidant by maintaining protective levels of GSH, reducing both lipid peroxidation and production of arachidonic acid metabolites. Also in IPRLM, administration of AMIN (30 mg/kg) 80-90 min after phosgene exposure significantly reduced lipid peroxidation and perfusate LTC(4)/D(4)/E(4), reduced LWG, and prevented phosgene-induced decreases in lung tissue cAMP. These data suggest that protective mechanisms observed with AMIN involve decreased LTC(4)/D(4)/E(4) mediated pulmonary capillary permeability and attenuated lipid peroxidation. Direct antipermeability effects of AMIN-induced upregulation of cAMP on cellular contraction may also be important in protection against phosgene-induced lung injury. Posttreatment with ISO in the IPRLM by either combined intravascular (iv; infused into pulmonary artery at 24 microg/min infused) + IT (24 microg bolus) or IT route alone 50-60 min after phosgene exposure significantly lowered pulmonary artery pressure, tracheal pressure, and LWG. ISO treatment significantly enhanced GSH products or maintained protective levels when compared with results from phosgene-exposed only rabbits. These data suggest that protective mechanisms for ISO involve reduction in vascular pressure, decreased LTC(4)/D(4)/E(4)-mediated pulmonary capillary permeability, and favorably maintained lung tissue GSH redox states. For in vivo male mouse (CD-1, 25-30 g) studies IBU was administered ip within 20 min after a lethal dose of phosgene (32 mg/m(3) for 20 min) at 0 (saline), 3, 9, or 15 mg/mouse. Five hours later, a second IBU injection was given but at half the original doses (0, 1.5, 4.5, and 7.5 mg/mouse); therefore, these treatment groups are now referred to as the 0/0, 3/1.5, 9/4.5, and 15/7.5 mg IBU/mouse groups. SRs and odds ratios were calculated for each dose at 12 and 24 h. The 12-h survival was 63% for 9/4.5 mg IBU and 82% for the 15/7.5 mg IBU groups, compared with 25% for saline-treated phosgene-exposed mice. At 24 h, those survival rates were reduced to 19%, 19%, and 6%, respectively. In the 15/7.5 mg IBU group, lung WW/DW ratios were significantly lower than in saline-treated mice at 12 h. Lipid peroxidation was lower only for the 9/4.5 mg IBU dose; however, nonprotein sulfhydryls (a measure of GSH) were greater across all IBU doses. The odds ratio was 5 for the 9/4.5 IBU group at 12 h and 13 for the 15/7.5 mg IBU group, compared with 3.5 for both groups at 24 h. IBU posttreatment increased the survival of mice at 12 h by reducing PEF, lipid peroxidation, and GSH depletion. In conclusion, effective treatment of phosgene-induced lung injury involves early postexposure intervention that could reduce free radical species responsible for lipid peroxidation, correct the imbalance in the GSH redox state, and prevent the release of biological mediators such as leukotrienes, which are accountable for increased permeability.

Protection of Rats Against Perfluoroisobutene (PFIB)-Induced Pulmonary Edema by Curosurf andN-Acetylcysteine

Airborne exposure to lung-toxic agents may damage the lung surfactant system and epithelial and endothelial cells, resulting in a life-threatening pulmonary edema that is known to be refractory to treatment. The aim of this study was to investigate in rats (1) the respiratory injury caused by nose-only exposure to perfluoroisobutene (PFIB), and (2) the therapeutic efficacy of a treatment at 4 and/or 8 h after exposure consisting of the natural surfactant Curosurf and/or the anti-inflammatory drug N-acetylcysteine (NAC). For that purpose, the following parameters were examined: respiratory frequency (RF), lung compliance (Cdyn), airway resistance (Raw), lung wet weight (LWW), airway histopathology; and in brochoalveolar lavage (BAL) fluid, total protein, total phospholipid, cell count and differentiation, and changes in the surface tension of the BAL fluid. The mean (+/- SEM) surface tension of BAL fluid derived from PFIB-exposed (C . t = 1100-1200 mg min(-1) m(-3), approximately 1LCt50; t = 20 min) animals at 24 h following exposure (11 +/- 3 mN/m) was higher than that of unexposed rats (0.8 +/- 0.4 mN/m), reflecting damage to the surfactant system and justifying treatment with exogenous surfactant. Curosurf treatment (62.5 mg/kg i.t.) decreased pulmonary edema caused by PFIB, reflected by a decreased LWW, and decreased the amount of protein in BAL fluid. NAC treatment (1000 mmol/kg ip) inhibited the interstitial pneumonia reflected by a decreased percentage of neutrophils in the alveolar space. It was concluded that a combined treatment of Curosurf + NAC improved respiration, that is, RF and Cdyn, whereby Curosurf predominantly decreased pulmonary edema and NAC predominantly reduced the inflammatory process. A combined treatment may therefore be considered a promising therapeutic approach in early-stage acute respiratory distress caused by PFIB, although the treatment regimes need further investigation.

Acute Nose-Only Exposure of Rats to Phosgene. Part II. Concentration × Time Dependence of Changes in Bronchoalveolar Lavage During a Follow-Up Period of 3 Months

Groups of young adult male Wistar rats were acutely exposed to phosgene gas for either 30 or 240 min using a directed-flow nose-only mode of exposure. In 30-min exposed rats the concentrations were 0.94, 2.02, 3.89, 7.35, and 15.36 mg/m3, which relate to C x t products of 28.2, 60.6, 116.7, 220.5, and 460.8 mg/m3 x min. In 240-min exposed rats the concentrations were 0.96, 0.387, 0.786, 1.567, and 4.2 mg/m3, which relate C x t products of 47.0, 92.9, 188.6, 376, and 1008 mg/m3 x min. Six rats/group were sacrificed on postexposure days 1, 3, 7, 14, and 84, while the rats of the 1008 mg/m3 x min group where sacrificed on postexposure days 1, 7, 14, and 28. The focus of measurements was directed toward indicators of inflammatory response and increased transmucosal permeability in bronchoalveolar lavage (BAL), including lung weights. Lungs from rats sacrificed at the end of the postexposure period were additionally examined by histopathology. Mortality did not occur at any C x t product. The most pronounced changes were related to C x t-dependent increases in the following markers in BAL: protein, soluble collagen, polymorphonuclear leukocytes (PMN) counts, and alveolar macrophages with foamy appearance. These indicators were maximal on the first postexposure day, while total cell counts and alveolar macrophages containing increased phospholipids reached their climax around post-exposure day 3. At 1008 mg/m3 x min the most sensitive indicators in BAL, that is, protein, PMN, and collagen, resolved within 2 wk, whereas at lower C x t products they reached the level of the control by postexposure day 7. At 1008 mg/m3 x min (day 28), histopathology revealed a minimal to slight hypercellularity in terminal bronchioles with focal peribronchiolar inflammatory infiltrates and focal septal thickening. At lower C x t products (day 84) the rats from all groups were indistinguishable and Sirius red-stained lungs did not provide evidence of late-onset sequelae, such as fibrotic changes or collagen deposition. At similar C x t products the changes in BAL were slightly less pronounced using 30-min exposure periods when compared to 240-min exposure periods. In summary, the phosgene-induced transmucosal permeability caused a C x t-dependent increase of several BAL indicators, of which those of protein, PMN, and soluble collagen were most pronounced. Exposure intensities up to 116.7 mg/m3 x min did not cause changes different from those observed in controls, while at 188.6 mg/m3 x min distinct differences to the control existed. Despite the extensively increased airway permeability, histopathology did not provide evidence of lung tissue remodeling or irreversible sequelae.

Workshop Summary: Phosgene-Induced Pulmonary Toxicity Revisited: Appraisal of Early and Late Markers of Pulmonary Injury From Animal Models With Emphasis on Human Significance

A workshop was held February 14, 2007, in Arlington, VA, under the auspices of the Phosgene Panel of the American Chemistry Council. The objective of this workshop was to convene inhalation toxicologists and medical experts from academia, industry and regulatory authorities to critically discuss past and recent inhalation studies of phosgene in controlled animal models. This included presentations addressing the benefits and limitations of rodent (mice, rats) and nonrodent (dogs) species to study concentration x time (C x t) relationships of acute and chronic types of pulmonary changes. Toxicological endpoints focused on the primary pulmonary effects associated with the acute inhalation exposure to phosgene gas and responses secondary to injury. A consensus was reached that the phosgene-induced increased pulmonary extravasation of fluid and protein can suitably be probed by bronchoalveolar lavage (BAL) techniques. BAL fluid analyses rank among the most sensitive methods to detect phosgene-induced noncardiogenic, pulmonary high-permeability edema following acute inhalation exposure. Maximum protein concentrations in BAL fluid occurred within 1 day after exposure, typically followed by a latency period up to about 15 h, which is reciprocal to the C x t exposure relationship. The C x t relationship was constant over a wide range of concentrations and single exposure durations. Following intermittent, repeated exposures of fixed duration, increased tolerance to recurrent exposures occurred. For such exposure regimens, chronic effects appear to be clearly dependent on the concentration rather than the cumulative concentration x time relationship. The threshold C x t product based on an increased BAL fluid protein following single exposure was essentially identical to the respective C x t product following subchronic exposure of rats based on increased pulmonary collagen and influx of inflammatory cells. Thus, the chronic outcome appears to be contingent upon the acute pulmonary threshold dose. Exposure concentrations high enough to elicit an increased acute extravasation of plasma constituents into the alveolus may also be associated with surfactant dysfunction, intra-alveolar accumulation of fibrin and collagen, and increased recruitment and activation of inflammatory cells. Although the exact mechanisms of toxicity have not yet been completely elucidated, consensus was reached that the acute pulmonary toxicity of phosgene gas is consistent with a simple, irritant mode of action at the site of its initial deposition/retention. The acute concentration x time mortality relationship of phosgene gas in rats is extremely steep, which is typical for a local, directly acting pulmonary irritant gas. Due to the high lipophilicity of phosgene gas, it efficiently penetrates the lower respiratory tract. Indeed, more recent published evidence from animals or humans has not revealed appreciable irritant responses in central and upper airways, unless exposure was to almost lethal concentrations. The comparison of acute inhalation studies in rats and dogs with focus on changes in BAL fluid constituents demonstrates that dogs are approximately three to four times less susceptible to phosgene than rats under methodologically similar conditions. There are data to suggest that the dog may be useful particularly for the study of mechanisms associated with the acute extravasation of plasma constituents because of its size and general morphology and physiology of the lung as well as its oronasal breathing patterns. However, the study of the long-term sequelae of acute effects is experimentally markedly more demanding in dogs as compared to rats, precluding the dog model to be applied on a routine base. The striking similarity of threshold concentrations from single exposure (increased protein in BAL fluid) and repeated-exposure 3-mo inhalation studies (increased pulmonary collagen deposition) in rats supports the notion that chronic changes depend on acute threshold mechanisms.

The effect of hexafluorocyclobutene on rat bronchoalveolar lavage fluid surfactant phospholipids and alveolar type II cells

Hexafluorocyclobutene (HFCB), a reactive organohalogen gas, causes overwhelming pulmonary oedema. We investigated its effect on the rat lung surfactant system, comparing its action on type II pneumocytes with air-exposed rats. The inflammatory cell population and protein content of bronchoalveolar lavage fluid was analysed following exposure to air or HFCB (LCt30). Six rat lung phospholipids were measured by high-performance liquid chromatography, following solid phase extraction (SPE) from lavage fluid. Transmission electron microscopy (TEM) was used to visualise effects on alveolar type II cell ultrastructure. HFCB caused changes in cell populations and increased lavage fluid protein compared to controls, suggesting a permeability oedema. Changes in the total amount and percentage composition (sustained decrease in phosphatidylglycerol and phosphatidylcholine) of surfactant phospholipids also occurred. TEM observations indicated no direct ultrastructural damage to the type II cells, but showed initial, rapid release of surfactant into the alveolar space. HFCB altered the surfactant system in a manner similar to that shown following another reactive organohalogen gas, perfluoroisobutene (PFIB), but differently to that after phosgene. These differences suggest different mechanisms of action even though pulmonary oedema is the final injury for all gases. Better knowledge of the mechanisms involved will improve prospects for prophylactic/therapeutic intervention.