Noteworthy Facts about a Methane-Producing Microbial Community Processing Acidic Effluent from Sugar Beet Molasses Fermentation

Greenhouse gas removal in agricultural peatland via raised water levels and soil amendment

Peatlands are an important natural store of carbon (C). Drainage of lowland peatlands for agriculture and the subsequent loss of anaerobic conditions had turned these C stores into major emitters of greenhouse gases (GHGs). Practical management strategies are needed to reduce these emissions, and ideally to reverse them to achieve net GHG removal (GGR). Here we show that a combination of enhanced C input as recalcitrant organic matter, CH4 suppression by addition of terminal electron acceptors, and suppression of decomposition by raising water levels has the potential to achieve GGR in agricultural peat. We measured GHG (CO2, N2O, and CH4) fluxes for 1 year with intensive sampling (6 times within the first 56 days) followed by monthly sampling in outdoor mesocosms with high (0 cm) and low (- 40 cm) water table treatments and five contrasting organic amendments (Miscanthus-derived biochar, Miscanthus chip, paper waste, biosolids, and barley straw) were applied to high water table cores, with and without iron sulphate (FeSO4). Biochar produced the strongest net soil C gain, suppressing both peat decomposition and CH4 emissions. No other organic amendment generated similar GGR, due to higher decomposition and CH4 production. FeSO4 application further suppressed CO2 and CH4 release following biochar addition. While we did not account for life-cycle emissions of biochar production, or its longer-term stability, our results suggest that biochar addition to re-wetted peatlands could be an effective climate mitigation strategy.

Supplementary Information

The online version contains supplementary material available at 10.1007/s42773-024-00422-2.

Influential factors in anaerobic digestion of rice-derived food waste and animal manure: A comprehensive review

Utilization of organic community wastes towards deriving sustainable renewable energy and adequate disposal of the residual has been an important topic of investigation. Anaerobic digestion and co-digestion of rice-derived food waste and animal manure for sustainable biogas generation is crucial from the view-point of community consumption. This paper presents an extensive review of the important and recent contributions in the related areas. The critical physico-chemical parameters involved in such digestion process are analyzed, including temperature, carbon-nitrogen ratio, microorganisms, pH, substrate characteristics, organic loading rate, hydraulic retention time, volatile fatty acids, ammonia, and light/heavy metal ions. Studies implied that the optimum yield of biogas production could be achieved only when the values of the parameters exist in the specific ranges. Few recent studies highlighted the use of emerging techniques including micro-aerobic system, additives, laser radiation, bio-electrochemical field, among others for efficiency enhancement of the digestion process and optimum yield. The entire study provided a set of important conclusions and future research directives are as well proposed.

Evaluation of microbial diversity in the formation water of the producer and marginal wells in bokaro coal field

The rise in global energy demand has prompted research on developing strategies for transforming conventional nonrenewable sources to cleaner fuels. Biogenic methane production is a promising source that caters to increasing energy demands. Therefore, research to enhance their production is of great importance. Implementation of successful enhancement strategies requires knowledge of the factors impacting coalbed methane production. The microbial diversity of the formation water in coal seams is the crucial parameter influencing biomethane production. This study explores microbial diversity in the Producing and Marginal wells of Bokaro, India, intending to understand the potential application of microbial-enhanced coalbed methane technology in the marginal wells of this reservoir. The high throughput sequencing analysis revealed the presence of both archaeal and bacterial groups in both well types. The result showed significant differences in the diversity of the samples from the two well groups, suggesting the immense role played by the microbes in producing methane gas. Random forest analysis shows genera Gelria, Methanothermobacter, Thaurea, Youngiibacter, and Proteiniclasticum in the Producing wells while Roseomonas, Rhodobacter, Mycobacterium, Methylobacter, and Bosea in the Marginal wells as the significant contributor in differentiating the overall diversity between the wells of Bokaro. The current study is the first to show microbial uniqueness in coalbed methane wells based on gas production efficiency. It also explores the role of physicochemical factors in framing microbial community structure in the wells. The results provide salient information that will help better understand the impact of microbial diversity on the production of coalbed methane wells of studied coal seams. This knowledge will further aid in exploring the prospects of microbial-enhanced methane in the Marginal wells.

Biogas production potential of aquatic weeds as the next-generation feedstock for bioenergy production: a review

Aquatic weeds have exceptionally high reproduction rates, are rich in cellulose and hemicellulose, and contain a negligible amount of lignin, making them an ideal crop for the next generation of biofuels. Previously reported studies proposed that water hyacinth, water lettuce, common duckweeds, and water spinach can be managed or utilized using different advanced techniques; from them, anaerobic digestion is one of the feasible and cost-effective techniques to manage these biowastes. The present study was carried out to investigate the potential of utilizing four common aquatic weed species (water hyacinth, water lettuce, common duckweeds, and water spinach) as substrates for anaerobic digestion in order to produce biogas for use in biofuels. The high reproduction rates and high cellulose and hemicellulose content, coupled with low lignin content, of these aquatic weeds make them ideal candidates for this purpose. The study evaluated the feasibility of using anaerobic digestion as a management technique for these aquatic weeds, which are often considered invasive and difficult to control. The results from various studies indicate that these aquatic weeds are productive feedstock options for anaerobic digestion, yielding a high biogas output. Among the aquatic weeds studied, water hyacinth, water lettuce, and common duckweeds exhibit higher methane production compared to water spinach. The study provides an overview of the characteristics and management strategies of these aquatic weeds in relation to biogas production, with possible future developments in the field.

Role of Polysaccharides from Marine Seaweed as Feed Additives for Methane Mitigation in Ruminants: A Critical Review

Given the increasing concerns regarding greenhouse gas emissions associated with livestock production, the need to discover effective strategies to mitigate methane production in ruminants is clear. Marine algal polysaccharides have emerged as a promising research avenue because of their abundance and sustainability. Polysaccharides, such as alginate, laminaran, and fucoidan, which are extracted from marine seaweeds, have demonstrated the potential to reduce methane emissions by influencing the microbial populations in the rumen. This comprehensive review extensively examines the available literature and considers the effectiveness, challenges, and prospects of using marine seaweed polysaccharides as feed additives. The findings emphasise that marine algal polysaccharides can modulate rumen fermentation, promote the growth of beneficial microorganisms, and inhibit methanogenic archaea, ultimately leading to decreases in methane emissions. However, we must understand the long-term effects and address the obstacles to practical implementation. Further research is warranted to optimise dosage levels, evaluate potential effects on animal health, and assess economic feasibility. This critical review provides insights for researchers, policymakers, and industry stakeholders dedicated to advancing sustainable livestock production and methane mitigation.

Biogas production potential of aquatic weeds as the next-generation feedstock for Bioenergy production: A Review.. [DOI: 10.21203/rs.3.rs-2676987/v1] [Citation(s) in RCA: 0] [Impact Index Per Article: 0]

Aquatic weeds have exceptionally high reproduction rates, are rich in cellulose and hemicellulose, and contain a negligible amount of lignin, making them an ideal crop for the next generation of biofuels. Previously reported studies proposed that water hyacinth, water lettuce, common duckweeds, and water spinach can be managed or utilized using different advanced techniques, while anaerobic digestion is one of the feasible and cost-effective techniques to manage these biowastes. The present study was carried out to investigate the potential of utilizing four common aquatic weed species (water hyacinth, water lettuce, common duckweeds, and water spinach) as substrates for anaerobic digestion in order to produce biogas. The high reproduction rates, high cellulose and hemicellulose content, coupled with low lignin content, of these aquatic weeds make them ideal candidates for this purpose. The study evaluated the feasibility of anaerobic digestion as a management method for these aquatic weeds, which are often considered invasive and difficult to control. The study provides an overview of the characteristics and management strategies of these aquatic weeds in relation to biogas production, with possible future developments in the field.

Biomethane production and microbial strategies corresponding to high organic loading treatment for molasses wastewater in an upflow anaerobic filter reactor

Molasses wastewater contains high levels of organic compounds, cations, and anions, causing operational problems for anaerobic biological treatment. In this study, an upflow anaerobic filter (UAF) reactor was employed to establish a high organic loading treatment system for molasses wastewater and further investigated the microbial community dynamics in response to this stressful operation. The biogas production increased with an increase in total organic carbon (TOC) loading rate from 1.0 to 14 g/L/day, and then it decreased with further TOC loading rate addition until 16 g/L/day. The UAF reactor achieved a maximum biogas production of 6800 mL/L/day with a TOC removal efficiency of 66.5% at a TOC loading rate of 14 g/L/day. Further microbial analyses revealed that both the bacterial and archaeal communities developed multiple strategies to maintain stable operation of the reactor at high organic loading (e.g., Proteiniphilum and Defluviitoga maintained high abundances throughout the operation; Tissierella temporarily dominated the bacterial community at TOC loading rates of 8.0 to 14 g/L/day; and multi-trophic Methanosarcina shifted as the dominant methanogen at the TOC loading rates of 8.0 to 16 g/L/day). This study presents insights into a high organic loading molasses wastewater treatment system and the microbial flexibility in methane fermentation in response to process disturbances.

Metagenomic profiling of antibiotic resistance genes in Red Sea brine pools

Antibiotic resistance (AR) is an alarming global health concern, causing an annual death rate of more than 35,000 deaths in the US. AR is a natural phenomenon, reported in several pristine environments. In this study, we report AR in pristine Red Sea deep brine pools. Antimicrobial resistance genes (ARGs) were detected for several drug classes with tetracycline and macrolide resistance being the most abundant. As expected, ARGs abundance increased in accordance with the level of human impact with pristine Red Sea samples having the lowest mean ARG level followed by estuary samples, while activated sludge samples showed a significantly higher ARG level. ARG hierarchical clustering grouped drug classes for which resistance was detected in Atlantis II Deep brine pool independent of the rest of the samples. ARG abundance was significantly lower in the Discovery Deep brine pool. A correlation between integrons and ARGs abundance in brine pristine samples could be detected, while insertion sequences and plasmids showed a correlation with ARGs abundance in human-impacted samples not seen in brine pristine samples. This suggests different roles of distinct mobile genetic elements (MGEs) in ARG distribution in pristine versus human-impacted sites. Additionally, we showed the presence of mobile antibiotic resistance genes in the Atlantis II brine pool as evidenced by the co-existence of integrases and plasmid replication proteins on the same contigs harboring predicted multidrug-resistant efflux pumps. This study addresses the role of non-pathogenic environmental bacteria as a silent reservoir for ARGs, and the possible horizontal gene transfer mechanism mediating ARG acquisition.

Research on Biogas Yield from Macroalgae with Inoculants at Different Organic Loading Rates in a Three-Stage Bioreactor

Macroalgae can be a viable alternative to replace fossil fuels that have a negative impact on the environment. By mixing macroalgae with other substrates, higher quality biogas can be obtained. Such biogas is considered one of the most promising solutions for reducing climate change. In the work, new studies were conducted, during which biogas yield was investigated in a three-stage bioreactor (TSB) during the anaerobic digestion of Cladophora glomerata macroalgae with inoculants from cattle manure and sewage sludge at different organic loading rates (OLR). By choosing the optimal OLR in this way, the goal was to increase the energy potential of biomass. The research was performed at OLRs of 2.87, 4.06, and 8.13 Kg VS/m³ d. After conducting research, the highest biogas yield was determined when OLR was 2.87 Kg VS/m³ d. With this OLR, the average biogas yield was 439.0 ± 4.0 L/Kg VS_added, and the methane yield was 306.5 ± 9.2 L CH₄/Kg VS_added. After increasing the OLR to 4.06 and 8.13 Kg VS/m³ d, the yield of biogas and methane decreased by 1.55 times. The higher yield was due to better decomposition of elements C, N, H, and S during the fermentation process when OLR was 2.87 Kg VS/m³ d. At different OLRs, the methane concentration remained high and varied from 68% to 80%. The highest biomass energy potential with a value of 3.05 kWh/Kg VS_added was determined when the OLR was 2.87 Kg VS/m³ d. This biomass energy potential was determined by the high yield of biogas and methane in TSB.

Microbial Biogas Production from Pork Gelatine

This research describes the results of the anaerobic digestion of gelatine as a potential hydrogen source with heat-shocked inoculum. The concentrations of applied gelatine were of VSS (volatile suspended solids) ranging from 10 g VSS/L to 30 g VSS/L. The initial process pH was 5.5, and, depending on the concentration, reached pH values from 7.5 to 7.8 after 55 days. Although the inoculum was heat-shocked in 30 g VSS/L of collagen, the process that occurred was hydrogenotrophic anaerobic digestion. In gelatine concentrations below 30 g VSS/L, hydrogen production was dominant only during the first 5 days of the experiments. Then, there was a change from dark fermentation to hydrogenotrophic methane production. The optimal hydrogen and methane yields resulted from the concentrations of 10 g VSS/L (7.65 mL ± 0.01 mL H2/g VSS and 3.49 ± 0.01 L CH4/g VSS). Additionally, 10 g VSS/L had the lowest accumulated emission of hydrogen sulphide (10.3 ± 0.01 mL of H2S), while 30 g VSS/L (0.440 ± 0.01mL H2S/g VSS) produced the lowest yield. After a lag time, the hydrogen production and hydrogen sulphide grew with a specific ratio, depending on the concentration. The hydrogen sulphide emission and sulphur added analysis proved that hydrogen sulphide originating from biogas created by bacteria remains longer than that from a substrate.

Prolonged acetogenic phase and biological succession during anaerobic digestion using swine manure

In recent years, global warming and the limitation of fossil fuels have been causing the governments of different countries to think about the search for more sustainable fuel sources. Biomethane (CH₄) has gained increasing attention in recent years as an alternative option for a sustainable source of energy. Biogas is generated during the anaerobic digestion of organic materials by the metabolism of complex microbial communities in the substrates that make up this digestion. The microbial community evaluation using 16S rDNA metabarcoding in a bench covered pond bioreactor using swine effluent revealed the dominant bacteria belonging to Firmicutes, Proteobacteria, and Bacteroidetes phyla. The methanogenic group was represented by the Euryarchaeota phylum. It was possible to observe that the relative frequency of the methanogenic archaea community decreased with the anaerobic digestion, indicating a biological succession stage. On the other hand, there was a predominant acetogenic diversity in this final stage. These data showed stabilization of biomethane production, although the microbial community of methanogens has drastically reduced in the late process.

Quantitative assessment of exposure to fecal contamination in urban environment across nine cities in low-income and lower-middle-income countries and a city in the United States

BACKGROUND

During 2014 to 2019, the SaniPath Exposure Assessment Tool, a standardized set of methods to evaluate risk of exposure to fecal contamination in the urban environment through multiple exposure pathways, was deployed in 45 neighborhoods in ten cities, including Accra and Kumasi, Ghana; Vellore, India; Maputo, Mozambique; Siem Reap, Cambodia; Atlanta, United States; Dhaka, Bangladesh; Lusaka, Zambia; Kampala, Uganda; Dakar, Senegal.

OBJECTIVE

Assess and compare risk of exposure to fecal contamination via multiple pathways in ten cities.

METHODS

In total, 4053 environmental samples, 4586 household surveys, 128 community surveys, and 124 school surveys were collected. E. coli concentrations were measured in environmental samples as an indicator of fecal contamination magnitude. Bayesian methods were used to estimate the distributions of fecal contamination concentration and contact frequency. Exposure to fecal contamination was estimated by the Monte Carlo method. The contamination levels of ten environmental compartments, frequency of contact with those compartments for adults and children, and estimated exposure to fecal contamination through any of the surveyed environmental pathways were compared across cities and neighborhoods.

RESULTS

Distribution of fecal contamination in the environment and human contact behavior varied by city. Universally, food pathways were the most common dominant route of exposure to fecal contamination across cities in low-income and lower-middle-income countries. Risks of fecal exposure via water pathways, such as open drains, flood water, and municipal drinking water, were site-specific and often limited to smaller geographic areas (i.e., neighborhoods) instead of larger areas (i.e., cities).

CONCLUSIONS

Knowledge of the relative contribution to fecal exposure from multiple pathways, and the environmental contamination level and frequency of contact for those "dominant pathways" could provide guidance for Water, Sanitation, and Hygiene (WASH) programming and investments and enable local governments and municipalities to improve intervention strategies to reduce the risk of exposure to fecal contamination.

Dynamics of dark fermentation microbial communities in the light of lactate and butyrate production

BACKGROUND

This study focuses on the processes occurring during the acidogenic step of anaerobic digestion, especially resulting from nutritional interactions between dark fermentation (DF) bacteria and lactic acid bacteria (LAB). Previously, we have confirmed that DF microbial communities (MCs) that fed on molasses are able to convert lactate and acetate to butyrate. The aims of the study were to recognize the biodiversity of DF-MCs able and unable to convert lactate and acetate to butyrate and to define the conditions for the transformation.

RESULTS

MCs sampled from a DF bioreactor were grown anaerobically in mesophilic conditions on different media containing molasses or sucrose and/or lactate and acetate in five independent static batch experiments. The taxonomic composition (based on 16S_rRNA profiling) of each experimental MC was analysed in reference to its metabolites and pH of the digestive liquids. In the samples where the fermented media contained carbohydrates, the two main tendencies were observed: (i) a low pH (pH ≤ 4), lactate and ethanol as the main fermentation products, MCs dominated with Lactobacillus, Bifidobacterium, Leuconostoc and Fructobacillus was characterized by low biodiversity; (ii) pH in the range 5.0-6.0, butyrate dominated among the fermentation products, the MCs composed mainly of Clostridium (especially Clostridium_sensu_stricto_12), Lactobacillus, Bifidobacterium and Prevotella. The biodiversity increased with the ability to convert acetate and lactate to butyrate. The MC processing exclusively lactate and acetate showed the highest biodiversity and was dominated by Clostridium (especially Clostridium_sensu_stricto_12). LAB were reduced; other genera such as Terrisporobacter, Lachnoclostridium, Paraclostridium or Sutterella were found. Butyrate was the main metabolite and pH was 7. Shotgun metagenomic analysis of the selected butyrate-producing MCs independently on the substrate revealed C.tyrobutyricum as the dominant Clostridium species. Functional analysis confirmed the presence of genes encoding key enzymes of the fermentation routes.

CONCLUSIONS

Batch tests revealed the dynamics of metabolic activity and composition of DF-MCs dependent on fermentation conditions. The balance between LAB and the butyrate producers and the pH values were shown to be the most relevant for the process of lactate and acetate conversion to butyrate. To close the knowledge gaps is to find signalling factors responsible for the metabolic shift of the DF-MCs towards lactate fermentation. Video Abstract.

Sustained effect of zero-valent iron nanoparticles under semi-continuous anaerobic digestion of sewage sludge: Evolution of nanoparticles and microbial community dynamics

The effects of adding zero-valent iron nanoparticles (nZVI) on the physicochemical, biological and biochemical responses of a semi-continuous anaerobic digestion of sewage sludge have been assessed. Two sets of consecutive experiments of 103 and 116 days, respectively, were carried out in triplicate. nZVI were magnetically retained in the reactors, and the effect of punctual doses (from 0.27 to 4.33 g L^-1) over time was studied. Among the different parameters monitored, only methane content in the biogas was significantly higher when nZVI was added. However, this effect was progressively lost after the addition, and in 5-7 days, the methane content returned to initial values. The increase in the oxidation state of nanoparticles seems to be related to the loss of effect over time. Higher dose (4.33 g L^-1) sustained positive effects for a longer time along with higher methane content, but this fact seems to be related to microbiome acclimation. Changes in microbial community structure could also play a role in the mechanisms involved in methane enhancement. In this sense, the microbial consortium analysis reported a shift in the balance among acetogenic eubacterial communities, and a marked increase in the relative abundance of members assigned to Methanothrix genus, recognized as acetoclastic species showing high affinity for acetate, which explain the rise in methane content in the biogas. This research demonstrates that biogas methane enrichment in semicontinuous anaerobic digesters can be achieved by using nZVI nanoparticles, thus increasing energy production or reducing costs of a later biogas upgrading process.

New Insights into the Ecology and Physiology of Methanomassiliicoccales from Terrestrial and Aquatic Environments

Members of the archaeal order Methanomassiliicoccales are methanogens mainly associated with animal digestive tracts. However, environmental members remain poorly characterized as no representatives not associated with a host have been cultivated so far. In this study, metabarcoding screening combined with quantitative PCR analyses on a collection of diverse non-host-associated environmental samples revealed that Methanomassiliicoccales were very scarce in most terrestrial and aquatic ecosystems. Relative abundance of Methanomassiliicoccales and substrates/products of methanogenesis were monitored during incubation of environmental slurries. A sediment slurry enriched in Methanomassiliicoccales was obtained from a freshwater sample. It allowed the reconstruction of a high-quality metagenome-assembled genome (MAG) corresponding to a new candidate species, for which we propose the name of Candidatus 'Methanomassiliicoccus armoricus MXMAG1'. Comparison of the annotated genome of MXMAG1 with the published genomes and MAGs from Methanomassiliicoccales belonging to the 2 known clades ('free-living'/non-host-associated environmental clade and 'host-associated'/digestive clade) allowed us to explore the putative physiological traits of Candidatus 'M. armoricus MXMAG1'. As expected, Ca. 'Methanomassiliicoccus armoricus MXMAG1' had the genetic potential to produce methane by reduction of methyl compounds and dihydrogen oxidation. This MAG encodes for several putative physiological and stress response adaptations, including biosynthesis of trehalose (osmotic and temperature regulations), agmatine production (pH regulation), and arsenic detoxication, by reduction and excretion of arsenite, a mechanism that was only present in the 'free-living' clade. An analysis of co-occurrence networks carried out on environmental samples and slurries also showed that Methanomassiliicoccales detected in terrestrial and aquatic ecosystems were strongly associated with acetate and dihydrogen producing bacteria commonly found in digestive habitats and which have been reported to form syntrophic relationships with methanogens.

Annual microbial community dynamics in a full-scale anaerobic sludge digester from a wastewater treatment plant in Colombia

Anaerobic digestion is a microbe-driven process widely applied to treat activated sludge from municipal wastewater treatment plants. It is one of the most efficient solutions for sludge reduction along with biogas production. However, the knowledge of the microbial consortium involved in this process is still unknown in full-scale anaerobic digesters from Latin America. This study aimed to elucidate the dynamics of the microbial community of a full-scale anaerobic digester for a year using 16S rDNA amplicon sequencing with the Illumina Miseq platform. The results showed fluctuations in the frequencies of dominant phyla with a decrease of Proteobacteria and Bacteroidetes after a temporary suspension of anaerobic digester. The core community was affiliated with bacterial phyla Firmicutes, Actinobacteria, Proteobacteria, and Chloroflexi. The core community was represented by 154 OTUs that accounted for 74% of all the processed reads. The Anaerolineaceae family, within Chloroflexi phylum, was the most frequently observed taxonomic group in all samples analyzed. Despite the microbial fluctuations, the biogas production was stable over the studied year (average 66% methane production), which might indicate a functional redundancy in the microbial consortium.

Different response of bacteria, archaea and fungi to process parameters in nine full-scale anaerobic digesters

Biogas production is a biotechnological process realized by complex bacterial, archaeal and likely fungal communities. Their composition was assessed in nine full-scale biogas plants with distinctly differing feedstock input and process parameters. This study investigated the actually active microbial community members by using a comprehensive sequencing approach based on ribosomal 16S and 28S rRNA fragments. The prevailing taxonomical units of each respective community were subsequently linked to process parameters. Ribosomal rRNA of bacteria, archaea and fungi, respectively, showed different compositions with respect to process parameters and supplied feedstocks: (i) bacterial communities were affected by the key factors temperature and ammonium concentration; (ii) composition of archaea was mainly related to process temperature; and (iii) relative abundance of fungi was linked to feedstocks supplied to the digesters. Anaerobic digesters with a high methane yield showed remarkably similar bacterial communities regarding identified taxonomic families. Although archaeal communities differed strongly on genus level from each other, the respective digesters still showed high methane yields. Functional redundancy of the archaeal communities may explain this effect. 28S rRNA sequences of fungi in all nine full-scale anaerobic digesters were primarily classified as facultative anaerobic Ascomycota and Basidiomycota. Since the presence of ribosomal 28S rRNA indicates that fungi may be active in the biogas digesters, further research should be carried out to examine to which extent they are important players in anaerobic digestion processes.

Changes in the Substrate Source Reveal Novel Interactions in the Sediment-Derived Methanogenic Microbial Community

Methanogenesis occurs in many natural environments and is used in biotechnology for biogas production. The efficiency of methane production depends on the microbiome structure that determines interspecies electron transfer. In this research, the microbial community retrieved from mining subsidence reservoir sediment was used to establish enrichment cultures on media containing different carbon sources (tryptone, yeast extract, acetate, CO₂/H₂). The microbiome composition and methane production rate of the cultures were screened as a function of the substrate and transition stage. The relationships between the microorganisms involved in methane formation were the major focus of this study. Methanogenic consortia were identified by next generation sequencing (NGS) and functional genes connected with organic matter transformation were predicted using the PICRUSt approach and annotated in the KEGG. The methane production rate (exceeding 12.8 mg CH₄ L⁻¹ d⁻¹) was highest in the culture grown with tryptone, yeast extract, and CO₂/H_2. The analysis of communities that developed on various carbon sources casts new light on the ecophysiology of the recently described bacterial phylum Caldiserica and methanogenic Archaea representing the genera Methanomassiliicoccus and Methanothrix. Furthermore, it is hypothesized that representatives of Caldiserica may support hydrogenotrophic methanogenesis.

Interaction Between Conservation Tillage and Nitrogen Fertilization Shapes Prokaryotic and Fungal Diversity at Different Soil Depths: Evidence From a 23-Year Field Experiment in the Mediterranean Area

Soil biodiversity accomplishes key roles in agro-ecosystem services consisting in preserving and enhancing soil fertility and nutrient cycling, crop productivity and environmental protection. Thus, the improvement of knowledge on the effect of conservation practices, related to tillage and N fertilization, on soil microbial communities is critical to better understand the role and function of microorganisms in regulating agro-ecosystems. In the Mediterranean area, vulnerable to climate change and suffering for management-induced losses of soil fertility, the impact of conservation practices on soil microbial communities is of special interest for building mitigation and adaptation strategies to climate change. A long-term experiment, originally designed to investigate the effect of tillage and N fertilization on crop yield and soil organic carbon, was utilized to understand the effect of these management practices on soil prokaryotic and fungal community diversity. The majority of prokaryotic and fungal taxa were common to all treatments at both soil depths, whereas few bacterial taxa (Cloacimonates, Spirochaetia and Berkelbacteria) and a larger number of fungal taxa (i.e., Coniphoraceae, Debaryomycetaceae, Geastraceae, Cordicypitaceae and Steccherinaceae) were unique to specific management practices. Soil prokaryotic and fungal structure was heavily influenced by the interaction of tillage and N fertilization: the prokaryotic community structure of the fertilized conventional tillage system was remarkably different respect to the unfertilized conservation and conventional systems in the surface layer. In addition, the effect of N fertilization in shaping the fungal community structure of the surface layer was higher under conservation tillage systems than under conventional tillage systems. Soil microbial community was shaped by soil depth irrespective of the effect of plowing and N addition. Finally, chemical and enzymatic parameters of soil and crop yields were significantly related to fungal community structure along the soil profile. The findings of this study gave new insights on the identification of management practices supporting and suppressing beneficial and detrimental taxa, respectively. This highlights the importance of managing soil microbial diversity through agro-ecological intensified systems in the Mediterranean area.

Functional bacterial and archaeal dynamics dictated by pH stress during sugar refinery wastewater in a UASB

The operation performance and microbial mechanisms by pH stress were investigated during anaerobic digestion of sugar refinery wastewater in a upflow anaerobic sludge blanket (UASB) reactor to clarify correlations between pH stress, microbial community and process efficiency. Results showed that the COD removal and methane yield were respectively reduced by 24.8% and 25.3% as pH decreased to 5.0. pH decrease resulted in the composition of dominant fermentative acidogenic bacteria was changed to Butyricicoccus, Lactococcus, Brooklawnia, Armatimonadetes_gp2 and Megasphaera from Prevotella, Streptococcus, Acidaminococcus and Megasphaera, causing an increase in propionate production. In addition, the growth of propionate-oxidizing bacteria was also inhibited at pH 5.0, leading the propionate was accumulated, and then reduced the process efficiency. Methane was mainly produced through acetate cleavage by Methanosaeta during the whole operational period of UASB. pH decrease blocked the metabolic balance and community structure between different trophic groups, resulting in the decrease in reactor performance.

Impacts of mixing on foaming, methane production, stratification and microbial community in full-scale anaerobic co-digestion process

This study investigated the impact of mixing on key factors including foaming, substrate stratification, methane production and microbial community in three full scale anaerobic digesters. Digester foaming was observed at one plant that co-digested sewage sludge and food waste, and was operated without mixing. The lack of mixing led to uneven distribution of total chemical oxygen demand (tCOD) and volatile solid (VS) as well as methane production within the digester. 16S rRNA gene-based community analysis clearly differentiated the microbial community from the top and bottom. By contrast, foaming and substrate stratification were not observed at the other two plants with internal circulation mixing. The abundance of methanogens (Methanomicrobia) at the top was about four times higher than at the bottom, correlating to much higher methane production from the top verified by ex-situ biomethane assay, causing foaming. This result is consistent with foaming potential assessment of digestate samples from the digester.

Microbial profiling during anaerobic digestion of cheese whey in reactors operated at different conditions

This study investigates the efficiency in methane production of lab-scale mesophilic (37 °C) and thermophilic (54 °C) continuous stirred tank reactors fed with cheese whey at different operational conditions. Results showed that whey mono-digestion was feasible at mesophilic conditions, while at thermophilic conditions frequent acidification incidents were recorded. The limited buffer capacity of the influent feedstock was responsible for the unstable anaerobic digestion process. The co-digestion of cheese whey with cattle manure maintained the pH levels higher than 7.0, and therefore, stable methane production rates were achieved without any significant accumulation of volatile fatty acids. An additional enhancement of the methane productivity was achieved by in-situ H₂ dispersion. Microbial community composition was investigated using high-throughput 16S rRNA gene amplicon sequencing and results were correlated with process parameters. Hydrogenotrophic methanogens were the dominant archaea during the whole experiment at mesophilic and thermophilic conditions.

PhyMet2 : a database and toolkit for phylogenetic and metabolic analyses of methanogens

The vast biodiversity of the microbial world and how little is known about it, has already been revealed by extensive metagenomics analyses. Our rudimentary knowledge of microbes stems from difficulties concerning their isolation and culture in laboratory conditions, which is necessary for describing their phenotype, among other things, for biotechnological purposes. An important component of the understudied ecosystems is methanogens, archaea producing a potent greenhouse-effect gas methane. Therefore, we created PhyMet² , the first database that combines descriptions of methanogens and their culturing conditions with genetic information. The database contains a set of utilities that facilitate interactive data browsing, data comparison, phylogeny exploration and searching for sequence homologues. The most unique feature of the database is the web server MethanoGram, which can be used to significantly reduce the time and cost of searching for the optimal culturing conditions of methanogens by predicting them based on 16S RNA sequences. The database will aid many researchers in exploring the world of methanogens and their applications in biotechnological processes. PhyMet² with the MethanoGram predictor is available at http://metanogen.biotech.uni.wroc.pl.

Impact of temperature and substrate concentration on degradation rates of acetate, propionate and hydrogen and their links to microbial community structure

The present study investigates the conversion of acetate, propionate and hydrogen consumption linked to the microbial community structure and related to temperature and substrate concentration. Biogas reactors were continuously fed with coffee powder (20 g-COD/L) or acetate (20, 40, and 60 g-COD/L) and operated for 193 days at 37 °C or 55 °C conditions. Starting HRT was 23 days which was then reduced to 7 days. The kinetics of acetate and propionate degradation and hydrogen consumption rates were measured in batch assays. At HRT 7 days, the degradation rate of propionate was higher in thermophilic batches, while acetate degradation rate was higher at mesophilic conditions. The gaseous hydrogen consumption in acetate reactors increased proportionally with temperature and substrate concentration, while the dissolved hydrogen was not affected. The relative high abundance of hydrogentrophic methanogens indicated that the methanogenesis was directed towards the syntrophic acetate oxidation pathway at high acetate concentration and high temperature.

Methane-yielding microbial communities processing lactate-rich substrates: a piece of the anaerobic digestion puzzle

BACKGROUND

Anaerobic digestion, whose final products are methane and carbon dioxide, ensures energy flow and circulation of matter in ecosystems. This naturally occurring process is used for the production of renewable energy from biomass. Lactate, a common product of acidic fermentation, is a key intermediate in anaerobic digestion of biomass in the environment and biogas plants. Effective utilization of lactate has been observed in many experimental approaches used to study anaerobic digestion. Interestingly, anaerobic lactate oxidation and lactate oxidizers as a physiological group in methane-yielding microbial communities have not received enough attention in the context of the acetogenic step of anaerobic digestion. This study focuses on metabolic transformation of lactate during the acetogenic and methanogenic steps of anaerobic digestion in methane-yielding bioreactors.

RESULTS

Methane-yielding microbial communities instead of pure cultures of acetate producers were used to process artificial lactate-rich media to methane and carbon dioxide in up-flow anaerobic sludge blanket reactors. The media imitated the mixture of acidic products found in anaerobic environments/digesters where lactate fermentation dominates in acidogenesis. Effective utilization of lactate and biogas production was observed. 16S rRNA profiling was used to examine the selected methane-yielding communities. Among Archaea present in the bioreactors, the order Methanosarcinales predominated. The acetoclastic pathway of methane formation was further confirmed by analysis of the stable carbon isotope composition of methane and carbon dioxide. The domain Bacteria was represented by Bacteroidetes, Firmicutes, Proteobacteria, Synergistetes, Actinobacteria, Spirochaetes, Tenericutes, Caldithrix, Verrucomicrobia, Thermotogae, Chloroflexi, Nitrospirae, and Cyanobacteria. Available genome sequences of species and/or genera identified in the microbial communities were searched for genes encoding the lactate-oxidizing metabolic machinery homologous to those of Acetobacterium woodii and Desulfovibrio vulgaris. Furthermore, genes for enzymes of the reductive acetyl-CoA pathway were present in the microbial communities.

CONCLUSIONS

The results indicate that lactate is oxidized mainly to acetate during the acetogenic step of AD and this comprises the acetotrophic pathway of methanogenesis. The genes for lactate utilization under anaerobic conditions are widespread in the domain Bacteria. Lactate oxidation to the substrates for methanogens is the most energetically attractive process in comparison to butyrate, propionate, or ethanol oxidation.

Methane production in an anaerobic osmotic membrane bioreactor using forward osmosis: Effect of reverse salt flux

This study investigated the impact of reverse salt flux (RSF) on microbe community and bio-methane production in a simulated fertilizer driven FO-AnMBR system using KCl, KNO₃ and KH₂PO₄ as draw solutes. Results showed that KH₂PO₄ exhibited the lowest RSF in terms of molar concentration 19.1mM/(m².h), while for KCl and KNO₃ it was 32.2 and 120.8mM/(m².h), respectively. Interestingly, bio-methane production displayed an opposite order with KH₂PO₄, followed by KCl and KNO₃. Pyrosequencing results revealed the presence of different bacterial communities among the tested fertilizers. Bacterial community of sludge exposed to KH₂PO₄ was very similar to that of DI-water and KCl. However, results with KNO₃ were different since the denitrifying bacteria were found to have a higher percentage than the sludge with other fertilizers. This study demonstrated that RSF has a negative effect on bio-methane production, probably by influencing the sludge bacterial community via environment modification.

Grape pomace compost harbors organohalide-respiring Dehalogenimonas species with novel reductive dehalogenase genes

Organohalide-respiring bacteria have key roles in the natural chlorine cycle; however, most of the current knowledge is based on cultures from contaminated environments. We demonstrate that grape pomace compost without prior exposure to chlorinated solvents harbors a Dehalogenimonas (Dhgm) species capable of using chlorinated ethenes, including the human carcinogen and common groundwater pollutant vinyl chloride (VC) as electron acceptors. Grape pomace microcosms and derived solid-free enrichment cultures were able to dechlorinate trichloroethene (TCE) to less chlorinated daughter products including ethene. 16S rRNA gene amplicon and qPCR analyses revealed a predominance of Dhgm sequences, but Dehalococcoides mccartyi (Dhc) biomarker genes were not detected. The enumeration of Dhgm 16S rRNA genes demonstrated VC-dependent growth, and 6.55±0.64 × 10⁸ cells were measured per μmole of chloride released. Metagenome sequencing enabled the assembly of a Dhgm draft genome, and 52 putative reductive dehalogenase (RDase) genes were identified. Proteomic workflows identified a putative VC RDase with 49 and 56.1% amino acid similarity to the known VC RDases VcrA and BvcA, respectively. A survey of 1,173 groundwater samples collected from 111 chlorinated solvent-contaminated sites in the United States and Australia revealed that Dhgm 16S rRNA genes were frequently detected and outnumbered Dhc in 65% of the samples. Dhgm are likely greater contributors to reductive dechlorination of chlorinated solvents in contaminated aquifers than is currently recognized, and non-polluted environments represent sources of organohalide-respiring bacteria with novel RDase genes.

Effects of organic loading rate on biogas production from macroalgae: Performance and microbial community structure

Macroalgae biomass has been considered as a promising feedstock for biogas production. In order to improve the efficiency of anaerobic digestion (AD) of macroalgae, semi-continuous fermentation was conducted to examine the effects of organic loading rate (OLR) on biogas production from Macrocystis pyrifer. Results showed that, under OLRs of 1.37, 2.74, 4.12 and 6.85kgVS_substrate/(m³·d), the average unit biogas yields were 438.9, 477.3, 480.1 and 188.7mL/(gVS_substrated), respectively. It indicated that biogas production was promoted by the increased OLR in an appropriate range while inhibited by the OLR beyond the appropriate range. The investigation on physical-chemical parameters revealed that unfavorable VFAs concentration, pH and salinity might be the main causes for system failure due to the overrange OLR, while the total phenols failed to reach the inhibitory concentration. Microbial community analysis demonstrated that several bacterial and archaeal phyla altered with increase in OLR apparently.

Technological Microbiology: Development and Applications

Over thousands of years, modernization could be predicted for the use of microorganisms in the production of foods and beverages. However, the current accelerated pace of new food production is due to the rapid incorporation of biotechnological techniques that allow the rapid identification of new molecules and microorganisms or even the genetic improvement of known species. At no other time in history have microorganisms been so present in areas such as agriculture and medicine, except as recognized villains. Currently, however, beneficial microorganisms such as plant growth promoters and phytopathogen controllers are required by various agricultural crops, and many species are being used as biofactories of important pharmacological molecules. The use of biofactories does not end there: microorganisms have been explored for the synthesis of diverse chemicals, fuel molecules, and industrial polymers, and strains environmentally important due to their biodecomposing or biosorption capacity have gained interest in research laboratories and in industrial activities. We call this new microbiology Technological Microbiology, and we believe that complex techniques, such as heterologous expression and metabolic engineering, can be increasingly incorporated into this applied science, allowing the generation of new and improved products and services.

Effects of organic loading rate on hydrogen and volatile fatty acid production and microbial community during acidogenic hydrogenesis in a continuous stirred tank reactor using molasses wastewater

AIMS

Microbial community associated with hydrogen production and volatile fatty acids (VFAs) accumulation was characterized in acidogenic hydrogenesis using molasses wastewater as a feedstock.

METHODS AND RESULTS

Hydrogen and VFAs production were measured under an organic loading rate (OLR) from 19 to 35 g-COD l^-1  day^-1 . The active microbial community was analysed using RNA-based massively parallel sequencing technique, and their correlation patterns were analysed using networking analysis. The continuous stirred tank reactor achieved stable hydrogen production at different OLR conditions, and the maximum hydrogen production rate (HPR) was 1·02 L-H₂  l^-1  day^-1 at 31·0 g-COD l^-1  day^-1 . Butyrate (50%) and acetate (38%) positively increased with increase in OLR. Total VFA production stayed around 7135 mg l^-1 during the operation period. Although Clostridiales and Lactobacillales were relatively abundant, the HPR was positively associated with Pseudomonadaceae and Micrococcineae. Total VFA and acetate, butyrate and propionate concentrations were positively correlated with lactic acid bacteria (LAB) such as Bacillales, Sporolactobacillus and Lactobacillus.

CONCLUSIONS

The close relationship between Pseudomonadaceae and Micrococcineae, and LAB play important roles for stable hydrogen and VFA production from molasses wastewater.

SIGNIFICANCE AND IMPACT OF THE STUDY

Microbial information on hydrogen and VFA production can be useful to design and operate for acidogenic hydrogenesis using high strength molasses wastewater.

Insertion sequences enrichment in extreme Red sea brine pool vent

Mobile genetic elements are major agents of genome diversification and evolution. Limited studies addressed their characteristics, including abundance, and role in extreme habitats. One of the rare natural habitats exposed to multiple-extreme conditions, including high temperature, salinity and concentration of heavy metals, are the Red Sea brine pools. We assessed the abundance and distribution of different mobile genetic elements in four Red Sea brine pools including the world's largest known multiple-extreme deep-sea environment, the Red Sea Atlantis II Deep. We report a gradient in the abundance of mobile genetic elements, dramatically increasing in the harshest environment of the pool. Additionally, we identified a strong association between the abundance of insertion sequences and extreme conditions, being highest in the harshest and deepest layer of the Red Sea Atlantis II Deep. Our comparative analyses of mobile genetic elements in secluded, extreme and relatively non-extreme environments, suggest that insertion sequences predominantly contribute to polyextremophiles genome plasticity.

Microbial community dynamics linked to enhanced substrate availability and biogas production of electrokinetically pre-treated waste activated sludge

The restricted hydrolytic degradation rate of complex organic matter presents a considerable challenge in anaerobic digestion of waste activated sludge (WAS). Within this context, application of pre-treatment of digester substrate has potential for improved waste management and enhanced biogas production. Anaerobic degradation of untreated or electrokinetically pre-treated WAS was performed in two pilot-scale digesters for 132days. WAS electrokinetically pre-treated with energy input 0.066kJ/kg sludge was used in a first phase of operation and WAS pre-treated with energy input 0.091kJ/kg sludge was used in a second phase (each phase lasted at least three hydraulic retention times). Substrate characteristics before and after pre-treatment and effects on biogas digester performance were comprehensively analysed. To gain insights into influences of altered substrate characteristics on microbial communities, the dynamics within the bacterial and archaeal communities in the two digesters were investigated using 16S rRNA gene sequencing (pyrosequencing) and quantitative PCR (qPCR). Specific primers targeting dominant operation taxonomic units (OTUs) and members of the candidate phylum Cloacimonetes were designed to further evaluate their abundance and dynamics in the digesters. Electrokinetic pre-treatment significantly improved chemical oxygen demand (COD) and carbohydrate solubility and increased biogas production by 10-11% compared with untreated sludge. Compositional similarity of the bacterial community during initial operation and diversification during later operation indicated gradual adaptation of the community to the higher solubility of organic material in the pre-treated substrate. Further analyses revealed positive correlations between gene abundance of dominant OTUs related to Clostridia and Cloacimonetes and increased substrate availability and biogas production. Among the methanogens, the genus Methanosaeta dominated in both digesters. Overall, the results showed that electrokinetic pre-treatment of WAS increases substrate solubility and biogas production. Changes in bacterial community composition and abundances of dominant bacterial OTUs were observed during anaerobic degradation of pre-treated WAS, whereas the relative abundance of methanogenic community members remained stable.

An overview of physico-chemical mechanisms of biogas production by microbial communities: a step towards sustainable waste management

Biogas is a combination of methane, CO₂, nitrogen, H₂S and traces of few other gases. Almost any organic waste can be biologically transformed into biogas and other energy-rich organic compounds through the process of anaerobic digestion (AD) and thus helping in sustainable waste management. Although microbes are involved in each step of AD, knowledge about those microbial consortia is limited due to the lack of phylogenetic and metabolic data of predominantly unculturable microorganisms. However, culture-independent methods like PCR-based ribotyping has been successfully employed to get information about the microbial consortia involved in AD. Microbes identified have been found to belong mainly to the bacterial phyla of Proteobacteria, Chloroflexi, Firmicutes and Bacteroidetes. Among the archaeal population, the majority have been found to be methanogens (mainly unculturable), the remaining being thermophilic microbes. Thus, the AD process as a whole could be controlled by regulating the microbial consortia involved in it. Optimization in the feedstock, pH, temperature and other physical parameters would be beneficial for the microbial growth and viability and thus helpful for biogas production in AD. Besides, the biogas production is also dependent upon the activity of several key genes, ion-specific transporters and enzymes, like genes coding for methyl-CoM reductase, formylmethanofuran transferase, formate dehydrogenase present in the microbes. Fishing for these high-efficiency genes will ultimately increase the biogas production and sustain the production plant.