Risk Factors for Pseudarthrosis After Surgical Site Infection of the Spine

Synthesis and evaluation of a novel vancomycin-infused, biomimetic bone graft using a rat model of spinal implant-associated infection

Background

Postoperative infection is a complication of spinal fusion surgery resulting in increased patient morbidity. Strategies including intraoperative application of powdered vancomycin have been proposed to reduce the incidence of infection; however, such antimicrobial effects are short-lived.

Methods

Instrumentation of the L4-L5 vertebrae was performed mimicking pedicle screw and rod fixation in 30 rats. Titanium instrumentation inoculated with either PBS or 1×105 CFU bioluminescent MRSA, along with biomimetic bone grafts infused with varying concentrations of vancomycin and 125 µg of rhBMP-2 (BioMim-rhBMP-2-VCM) were implanted prior to closure. Infection was quantified during the six-week postoperative period using bioluminescent imaging. Arthrodesis was evaluated using micro-CT.

Results

Infected animals receiving a bone graft infused with low-dose (0.18 mg/g) or high-dose vancomycin (0.89 mg/g) both exhibited significantly lower bioluminescent signal over the six-week postoperative period than control animals inoculated with MRSA and implanted with bone grafts lacking vancomycin (p=.019 and p=.007, respectively). Both low and high-dose vancomycin-infused grafts also resulted in a statistically significant reduction in average bioluminescence when compared to control animals (p=.027 and p=.047, respectively), independent of time. MicroCT analysis of animals from each group revealed pseudoarthrosis only in the control group, suggesting a correlation between infection and pseudoarthrosis. MRSA-inoculated control animals also had significantly less bone volume formation on micro-CT than the PBS-inoculated control cohort (p<.001), the MRSA+low-dose vancomycin-infused bone graft cohort (p<.001), and the MRSA+high-dose vancomycin-infused bone graft cohort (p<.001).

Conclusion

BioMim-rhBMP-2-VCM presents a novel tissue engineering approach to simultaneously promoting arthrodesis and antimicrobial prophylaxis in spinal fusion. Despite mixed evidence of potential osteotoxicity of vancomycin reported in literature, BioMim-rhBMP-2-VCM preserved arthrodesis and osteogenesis with increasing vancomycin loading doses due to the graft's osteoinductive composition.

Predictive factors of symptomatic lumbar pseudoarthrosis following multilevel primary lumbar fusion

Background

Lumbar spinal fusion surgery is a well-established treatment for various spinal disorders. However, one of its complications, pseudoarthrosis, poses a significant concern. This study aims to explore the incidence, time and predictive factors contributing to pseudoarthrosis in patients who have undergone lumbar fusion surgery over a 10-year period.

Methods

Data for this research was sourced from the PearlDiver database where insurance claims of patients who underwent multilevel lumbar spinal fusion between 01/01/2010 and 10/31/2022 were examined for claims of pseudoarthrosis within the 10 years of their index procedure. A variety of demographic, comorbid, and surgical factors were assessed, including age, gender, Elixhauser Comorbidity Index (ECI), surgical approach, substance use disorders and history of spinal disorders. Statistical analyses, including chi-squared tests, multivariate analysis, and cox survival analysis were employed to determine significant associations.

Results

Among the 76,337 patients included in this retrospective study, 2.70% were diagnosed with symptomatic lumbar pseudoarthrosis at an average of 7.38 years in a 10-year follow-up. Multivariate and Cox hazard analyses revealed that significant predictors of symptomatic pseudoarthrosis development following multilevel primary lumbar fusion include vitamin D deficiency, osteoarthritis, opioid and NSAID use, tobacco use, and a prior history of congenital spine disorders.

Conclusions

In summary, this study revealed a 2.70% incidence of symptomatic lumbar pseudoarthrosis within 10 years of the index procedure. It highlighted several potential predictive factors, including comorbidities, surgical approaches, and substance use disorders, associated with the development of symptomatic pseudoarthrosis. Future research should focus on refining our understanding of these factors to improve patient outcomes and optimize healthcare resource allocation.

Value of 18 F-FDG PET/CT to Identify Occult Infection in Presumed Aseptic Pseudarthrosis after Spinal Fusion: Correlation with Intraoperative Cultures

Objective  Fluorine-18 fluorodeoxyglucose ( 18 F-FDG) positron emission tomography/computed tomography (PET/CT) has gained attention as an emerging tool in case of suspicion of infection on spine, whether native or instrumented. However, the diagnostic performance of 18 F-FDG PET/CT in clinically occult low-grade surgical site infection (SSI) after spinal fusion, an important risk factor for pseudarthrosis, remains unknown. Methods  We retrospectively identified all the presumed aseptic patients with pseudarthrosis confirmed by revision surgery who underwent preoperative 18 F-FDG PET/CT scans performed between April 2019 and November 2022. These patients were presumed aseptic because they did not have clinical signs or laboratory tests suggestive of SSI, preoperatively. The PET/CT images were analyzed in consensus by two nuclear medicine physicians blinded to the clinical, biological, and imaging information. Visual assessment of increased uptake around cage/intervertebral disk space (and/or hardware) higher than background recorded from the first normal adjacent vertebra was interpreted as positive. Image data were also quantitatively analyzed by the maximum standardized uptake value as an index of 18 F-FDG uptake, and the ratio between the uptake around cage/intervertebral disk space (and/or hardware) and background recorded from the first normal adjacent vertebra was calculated. The final diagnosis of infection was based on intraoperative cultures obtained during pseudarthrosis revision surgery. Results  Thirty-six presumed aseptic patients with surgically confirmed pseudarthrosis after spinal fusion underwent preoperative 18 F-FDG PET/CT scans. Cultures of samples from revisions found that 20 patients (56%) were infected. The most frequent isolated bacterium was Cutibacterium acnes ( C. acnes ) in 15 patients (75%), followed by coagulase-negative staphylococci (CNS) in 7 patients (33%). Two patients had co-infections involving both C. acnes and CNS. Of the 36 PET/CT studied in this study, 12 scans were true-negative, 10 true-positive, 10 false-negative, and 4 false-positive. This resulted in sensitivity, specificity, positive predictive value, negative predictive value, and diagnostic accuracy of 50%, 75%, 71%, 55%, and 61%, respectively. Conclusion  In presumed aseptic pseudarthrosis after spinal fusion, 18 F-FDG PET/CT offers good specificity (75%) but low sensitivity (50%) to identify occult SSI. The high prevalence (56%) of SSI, mostly caused by C. acnes (75%), found in our presumed aseptic cohort of patients supports the utility of systematic intraoperative cultures in revision cases for pseudarthrosis.

Effect of Body Mass Index on Fusion Outcome After Short-Segment Posterior Lumbar Fusion

OBJECTIVE

Obesity is a growing epidemic in the United States. While many adverse effects of obesity on surgical outcome are well studied, a direct correlation among obesity, pseudarthrosis, and adjacent segment pathology is not well defined. In this study we aimed to identify the effect of body mass index (BMI) on pseudarthrosis, adjacent segment pathology (ASP), and reoperation after short-segment (1-3 levels) open posterior lumbar fusion (PLF).

METHODS

This is a retrospective study of patients with degenerative spine pathologies who underwent 1-, 2-, or 3-level PLF surgery between 2010 and 2020. The relevant medical and imaging records were reviewed, and the following variables were recorded: age, gender, BMI, smoking status, surgical details, follow-up length, need for reoperation, indication for reoperation (pseudarthrosis or occurrence of ASP).

RESULTS

We included363 patients in our study. Twenty-five patients (6.9%) developed pseudarthrosis, 109 (30%) developed ASP, and 104 patients (28.7%) underwent reoperation for either of these reasons. BMI was significantly less in those who developed pseudarthrosis compared with those who did not (28.6 ± 5.5 vs. 31.2 ± 6.2, respectively; P = 0.04). BMI was not significantly different in those who developed ASP or underwent reoperation compared with those who did not (P = 0.06 and 0.08, respectively). Multivariate regression analysis showed none of the variables in the model (age, gender, tobacco use, BMI, and its classes) significantly predicted pseudarthrosis, ASP, or reoperation (P > 0.1 for all variables).

CONCLUSIONS

Obese patients undergoing short-segment open PLF have comparable results in terms of pseudarthrosis, ASP, and reoperation.

Predicting metalwork following posterior fixation of thoracolumbar fractures

OBJECTIVES

Surgical fusion through posterior instrumentation and pedicle screw placement is a long established method for stabilising traumatic spinal fractures. Post-surgical complications include infection and metal work failure, the most common aetiology of which is pedicle screw fracture. Metal work failure rates vary from 15% to 60%. Research relating to factors which predict metal work failure in post-traumatic thoracolumbar spinal fixation is lacking. This study aimed to identify potential risk factors for metalwork failure in patients who had posterior fixation for traumatic thoracolumbar spine fractures.

METHODS

This retrospective cohort analysis was conducted by interrogating the hospital database for neurosurgical post-traumatic thoracolumbar fixation cases between 2015 and 2018 with at least 2 years follow up. Data was collected through electronic medical notes and PACS. Nineteen different patient factors (gender, age, mechanism of injury, presence of concomitant injury spinal or extra-spinal injury, pedicle cross-sectional area, pedicle cancellous bone density, pedicle total bone density, vertebral body bone density, erector spinae muscle density and lumbar spine subcutaneous fat thickness, Charlson comorbidity index, fracture location, surgical approach, long/short segment fixation, whether decompression was done, whether the index level was fixed, and presence of wound infection) were compared.

RESULTS

We identified 92 patients with 97 operations, and 9 cases of metal work failure. Two factors were statistically significantly associated with metal work failure: Post-operative wound infection (p = 0.029) and lumbar spine fat thickness (p = 0.024). The relative risk calculated in patients with a wound infection was 3.76. Lumbar spine fat thickness was on average 11.9 mm greater than patients not experiencing metal work failure.

CONCLUSIONS

This study has identified two factors associated with increased rates of metal work failure: Post-operative wound infection and lumbar spine fat thickness. When assessing surgical candidates these factors may be incorporated into surgical planning.

Experience With Recombinant Human Bone Morphogenetic Protein-2 in Posterior Lumbar Interbody Fusion: A Retrospective Review of 1019 Procedures

BACKGROUND

Recombinant human bone morphogenetic protein-2 (rhBMP-2) combined with an activated collagen scaffold (Infuse; Medtronic, MN) has been used to facilitate lumbar intervertebral fusion; however, data regarding its efficacy are inconsistent. We aimed to assess the efficacy of rhBMP-2 when used in posterior lumbar interbody fusion (PLIF) by analyzing the rate of reoperation for nonunion and patient-reported outcome measures in a large retrospective case series. We also aimed to assess the impact of patient and surgical factors on rates of reoperation and determine frequency of complications.

METHODS

Prospectively collected data from a single-surgeon database of consecutive PLIFs (minimum 18-month follow-up) were retrospectively analyzed. PLIF was performed with pedicle screw instrumentation, intervertebral spacers, and locally harvested bone graft to which rhBMP-2 and bone marrow aspirate (BMA) were added. Multivariate logistic regression was used to determine the influence of patient and surgical factors on the primary outcome: reoperation for confirmed nonunion.

RESULTS

A total of 1019 operations at 1485 levels across 908 patients were analyzed. Mean duration of follow-up was 51.7 ± 30.0 months (range 18-172). Twelve patients required reoperation for nonunion (1.2%). Increasing body mass index was found to be significant in predicting reoperation (OR 1.114, P = 0.046). Postoperative radiculitis was common (42%) but transient in most cases. There were significant and sustained improvements in patient-reported outcome measures postoperatively. Four cases of osteolysis and 5 of epidural cyst were recorded, and a reduction of rhBMP-2 dose seemed to ameliorate these sequelae.

CONCLUSION

In this large retrospective observational study, PLIF performed with rhBMP-2 and BMA resulted in a low rate of clinically significant nonunion and significant improvement in patient-reported outcomes. Transient radiculitis was common. Osteolysis and epidural cyst formation were rare and possibly related to dosage.

CLINICAL RELEVANCE

rhBMP-2 is effective when used in PLIF, resulting in a high rate of fusion and improved patient outcomes, and it has an acceptable safety profile.

LEVEL OF EVIDENCE: 3

High Failure Rates in Prisoners Undergoing Spine Fusion Surgery

OBJECTIVE

The medical literature on prisoner health care is limited, despite data showing that prisoners experience high rates of physical and mental health challenges. We compared clinical outcomes for prisoners undergoing spine fusion with comparable nonincarcerated patients and determined what factors were implicated in differences in outcomes.

METHODS

Prisoners who underwent spinal fusion in 2011-2021 were retrospectively compared with an age-, sex-, and procedure-matched 3:1 control group of nonincarcerated spinal fusion patients. Fusion failure was confirmed by lack of bridging bone between vertebrae on CT or radiographic images >1 year postoperatively or evidence of instrumentation failure with resultant >2 mm of translation on flexion/extension radiographs.

RESULTS

Twenty-seven identified prisoners were compared with 81 nonincarcerated controls. Ten prisoners and 6 controls experienced nonunion (37% vs. 7%, P < 0.01). Rates of risk factors for nonunion, such as smoking history, elevated body mass index, chronic steroid use, diabetes mellitus, previous spine surgery, and levels fused, were not significantly different between prisoners and controls. Among prisoners, those with nonunion were younger (45 vs. 53 years, P = 0.03), had greater body mass index (34 vs. 29, P = 0.02), and were more likely to undergo reoperation (30% vs. 0%, P = 0.02). Multivariate analysis revealed that prisoners carry a 9.62 increased odds of nonunion compared with controls.

CONCLUSIONS

This is one of few studies investigating health care outcomes in prisoners. We found they had a significantly higher rate of nonunion than matched control patients from the general population treated at the same hospital, suggesting additional measures may be necessary postoperatively to support fusion in prisoners.

Clinical relevance of occult infections in spinal pseudarthrosis revision

Background

Occult infections in spinal pseudarthrosis revisions have been reported in the literature, but the relevance of such an infection on patient outcomes is unknown. We aimed to elucidate clinical outcomes and re-revision risks between patients with and without occult infections in spinal revision surgery for pseudarthrosis.

Methods

In this matched case-control study, we identified 128 patients who underwent thoracolumbar revision surgery from 2014–2019 for pseudarthrosis of the spine. Among them, 13 (10.2%) revealed an occult infection (defined by at least two positive intraoperative tissue samples with the same pathogen), and nine of these 13 were available for follow-up. We selected 18 of the 115 controls using a 2:1 fuzzy matching based on fusion length and length of follow-up. The patients were followed up to assess subsequent re-revision surgeries and the following postoperative patient-reported outcome measures (PROMs): overall satisfaction, Oswestry Disability Index, 5-level EQ-5D, and Short Form 36.

Results

Patient characteristics, surgical data, and length of follow-up were equal between both study groups. The rate of re-revision free survival after the initial pseudarthrosis revision surgery was higher in the occult infection group (77.8%) than the non-infectious controls (44.4%), although not significantly (0.22). The total number of re-revision surgeries, including re-re-revisions, was thirteen (in ten patients) in the control and two (in two patients) in the occult infection group (p = 0.08) after a median follow-up of 24 months (range 13-75). Four cases in the control group underwent re-revision for pseudarthrosis compared to none in the infected group. Satisfactory scores were recorded in all PROMs, with similar scores between the two groups.

Conclusions

The presence of an occult infection accompanying spinal pseudarthrosis revision was not inferior to non-infected pseudarthrosis revisions in a matched, small sample size cohort study. This may be explained due to the possibility of targeted treatment of the identified cause of pseudarthrosis.

Surgical site infection is a major risk factor of pseudarthrosis in adult spinal deformity surgery

BACKGROUND CONTEXT

Despite the evidence in appendicular skeletal surgery, the effect of infection on spinal fusion remains unclear, particularly after Adult Spinal Deformity (ASD) surgery.

PURPOSE

The purpose of this study was to determine the impact of surgical site infection (SSI) in ASD surgery fusion rates and its association with other risks factors of pseudarthrosis.

STUDY DESIGN

We conducted an international multicenter retrospective study on a prospective cohort of patients operated for spinal deformity.

PATIENT SAMPLE

A total of 956 patients were included (762 females and 194 males).

OUTCOME MEASURES

Patient's preoperative characteristics, pre and postoperative spinopelvic parameters, surgical variables, postoperative complications and were recorded. Surgical site infections were asserted in case of clinical signs associated with positive surgical samples. Each case was treated with surgical reintervention for debridement and irrigation. Presence of pseudarthrosis was defined by the association of clinical symptoms and radiological signs of nonfusion (either direct evidence on CT-scan or indirect radiographic clues such as screw loosening, rod breakage, screw pull out or loss of correction). Each iterative surgical intervention was collected.

METHODS

Univariate and multivariate analysis with logistic regression models were performed to evaluate the role of risk factors of pseudarthrosis.

RESULTS

Nine hundred fifty-six surgical ASD patients with more than two years of follow-up were included in the study. 65 of these patients were treated for SSI (6.8%), 138 for pseudarthrosis (14.4%), and 28 patients for both SSI and pseudarthrosis. On multivariate analysis, SSI was found to be a major risk factor of pseudarthrosis (OR=4.4; 95% CI=2.4,7.9) as well as other known risks factors: BMI (OR=1.1; 95% CI=1.0,1.1), smoking (OR=1.6; 95% CI=1.1,2.9), performance of Smith-Petersen osteotomy (OR = 1.6; 95% CI 1.0,2.6), number of vertebrae instrumented (OR=1.1; 95% CI=1.1,1.2) and the caudal level of fusion, with a distal exponential increment of the risk (OR max for S1=6, 95% CI=1.9,18.6).

CONCLUSION

SSI significantly increases the risk of pseudarthrosis with an OR of 4.4.

Pseudarthrosis Following Lumbar and Lumbosacral Fusion Using the Antepsoas Technique

STUDY DESIGN

Retrospective case-control study.

OBJECTIVE

The aim of this study was to evaluate the prevalence of pseudarthrosis following antepsoas (ATP) lumbar and lumbosacral fusions.

SUMMARY OF BACKGROUND DATA

Pseudarthrosis is a feared complication following spinal fusions and may affect their clinical outcomes. To date there are no sufficient data on the fusion rate following ATP lumbar and lumbosacral arthrodesis.

METHODS

This is a retrospective review of 220 patients who underwent lumbar minimally invasive antepsoas (MIS-ATP) fusions between January 2008 and February 2019 who have at least 1-year postoperative computed tomography (CT) follow-up scans. Fusion was graded using CT scans imaging and adopting a 1-4 grading scale (1, definitely fused; 2, likely fused; 3, likely not fused; 4, definitely not fused/nonunion). Grades 3 or 4 indicate pseudarthrosis.

RESULTS

A total of 220 patients (average age: 66 years, 82 males (37.2%), and 127 (57.7%) smokers) were included. Eight patients (3.6%) developed pseudarthrosis. A total of 693 discs were addressed using the ATP approach. Of those, 681 (98.3%) were considered fused (641 levels [92.5%] were "definitely fused" and 40 levels [5.8%] were "Likely fused") and 12 discs (1.7%) developed pseudarthrosis (seven levels [1.0%] were "likely not fused" and five levels (0.7%) were "definitely not fused"). The highest rate of pseudarthrosis was found at L5-S1 (4.8%) compared to the L1-L5 discs (0-2%). Of 127 smokers, six developed pseudarthrosis (odds ratio = 2.3, P = 0.3). The fusion rates were 95.3% and 97.8% for smokers and nonsmokers, respectively. Of the eight patients who developed pseudarthrosis, only four (50%) were symptomatic, of whom two (25%) required revision surgery. Both of these patients were smokers. The overall revision rate due to pseudarthrosis was 0.9% (two of 220 patients).

CONCLUSION

The MIS-ATP technique results in a high fusion rate (96.4% of patients; 98.3% of levels). Pseudarthrosis was noted mostly at the L5-S1 discs and in smokers.Level of Evidence: 4.

Occult infection in pseudarthrosis revision after spinal fusion

BACKGROUND CONTEXT

Pseudarthrosis after attempted spinal fusion is yet not sufficiently understood and presents a surgical challenge. Occult infections are sometimes observed in patients with pseudarthrosis and no inflammatory signs of infection. The prevalence of such occult infection and its association with patient demographics and inflammatory markers are largely unknown.

PURPOSE

To determine the prevalence of unexpected low-grade infection in spinal pseudarthrosis revision surgery, and to evaluate whether such infection is associated with patient demographics and inflammatory markers.

STUDY DESIGN

Retrospective observational study.

PATIENT SAMPLE

One-hundred-and-twenty-eight patients who underwent thoracolumbar revision surgery due to presumed aseptic pseudarthrosis after spinal instrumentation.

OUTCOME MEASURES

Culture-positive infections or noninfectious pseudarthrosis.

METHODS

Samples were routinely taken for microbiological examination from all adults (n=152) who underwent revision surgery for presumed aseptic thoracolumbar pseudarthrosis between 2014 and 2019. A full intraoperative microbiological workup (at least three intraoperative tissue samples) was done for 128 (84%) patients, and these patients were included in further analyses. Patient characteristics, medical history, inflammatory markers, and perioperative data were compared between those with and without microbiologically-confirmed infection based on samples obtained during pseudarthrosis revision.

RESULTS

The microbiological workup confirmed infection in 13 of 128 cases (10.2%). The predominant pathogen was Cutibacterium acnes (46.2%), followed by coagulase-negative staphylococci (38.5%). The presence of infection was associated with the body mass index (30.9±4.7 kg/m² [infected] vs. 28.2±5.6 kg/m² [controls], p=.049), surgery in the thoracolumbar region (46% vs. 18%, p=.019), and a slightly higher serum C-reactive protein level on admission (9.4±8.0 mg/L vs. 5.7±7.1 mg/L, p=.031). Occult infection was not associated with age, sex, prior lumbar surgeries, number of fused lumbar levels, American Society of Anesthesiologist score, Charlson Comorbidity Index, presence of diabetes mellitus, and smoking status.

CONCLUSIONS

Occult infections were found in 10% of patients undergoing pseudarthrosis revision after spinal fusion, even without preoperative clinical suspicion. Occult infection was associated with higher body mass index, fusions including the thoracolumbar junction, and slightly higher C-reactive protein levels. Intraoperative microbiological samples should be routinely obtained to exclude or identify occult infection in all revision surgeries for symptomatic pseudarthrosis of the spine, as this information can be used to guide postoperative antibiotic treatment.