Efficacy of an iodine backflush for preventing new intramammary infections

Effect of automatic cluster flushing on the concentration of Staphylococcus aureus in teat cup liners

Automatic flushing of milking clusters between milking events is a control measure aimed at reducing transmission of mastitis pathogens from infectious milk to a subsequently milked cow. We evaluated the effect of flushing with cold water and flushing with water containing peracetic acid (PAA) on the concentration of Staphylococcus aureus in teat cup liners. Thirty-two clusters in a swing-over milking parlor (Dairymaster, Causeway, Ireland) were subjected to a simulated milking with S. aureus-contaminated milk. Sixteen clusters were not flushed (controls), whereas 8 clusters were flushed with cold water (966 ± 32 mL) and 8 clusters were flushed with water containing PAA (200 mL/mL). A random teat cup in each cluster was sampled by rinsing with a phosphate buffer. Teat cup samples were cultured on the day following collection on Baird-Parker plates to determine the concentration of S. aureus. In teat cup samples from control clusters, the mean concentration of S. aureus was 2.8 × 10⁵ cfu/mL. The concentration of S. aureus was zero in teat cup samples from clusters flushed with cold water. In teat cup samples from clusters flushed with water containing PAA, the concentration of S. aureus was in general reduced compared with control clusters, but S. aureus was not removed completely. However, the automatic cluster flushing did not function properly when clusters were flushed with water containing PAA; thus, results reflected the effect of inadequate function rather than the effect of adding disinfectant to the flushing water. Before the main study, we conducted a pilot study to evaluate whether teat cup sampling with swabs and sample analysis with quantitative PCR were appropriate methods for the main study. Specifically, we evaluated the effect of swab sample mass on detection of S. aureus by quantitative PCR in the laboratory, Further, we compared PCR and bacterial culture on detection of S. aureus in a suspension following disinfection of the suspension with PAA. We sampled 20 identical S. aureus suspensions for culture and PCR by swabs before and after disinfection with PAA. Swab sample mass was determined by differential weighing and contributed to 46% of the variation observed in detection of S. aureus by PCR. Following disinfection with PAA, S. aureus remained detectable by PCR, although culturability ceased. Based on these results, we sampled teat cups in the main study with a buffer rinse and quantified S. aureus in the samples by bacterial culture. We concluded that automatic cluster flushing with cold water was effective in removing S. aureus from teat cup liners and that addition of PAA was therefore not necessary.

Short communication: Efficacy of glycolic acid-based and iodine-based postmilking barrier teat disinfectants for prevention of new intramammary infections in dairy cattle

A positive-control, natural exposure noninferiority field study was conducted to test the efficacy of a novel glycolic acid-based postmilking barrier teat disinfectant compared with a commercial iodine-based postmilking barrier teat disinfectant (positive control). Cows from 2 pens from a California Central Valley dairy farm were dipped after milking either with the positive-control product (PC) or the experimental product (EX) over 12 wk. New intramammary infections (NIMI) were determined by biweekly sampling of all quarters of study cows and classified as a NIMI based on somatic cell count and milk bacteriological culture results. The mean quarter-level incidence risks during a 2 wk study period were 3.50% (EX) and 4.28% (PC). The majority of NIMI were caused by coagulase-negative staphylococci, followed by non-agalactiae streptococci. The study results indicated that EX was noninferior to PC, with a 17% relative efficacy (improvement) in reducing NIMI compared with the PC group. Also, quarter somatic cell count was not affected by the postmilking teat disinfectant used. Finally, the EX product was safe in terms of teat conditioning: teat condition scores were not different between study groups. The study concluded that the glycolic acid-based experimental post-dip barrier was noninferior to the control, and could be considered a safe and effective postmilking teat disinfectant.

Update on control of Staphylococcus aureus and Streptococcus agalactiae for management of mastitis

The primary method of spread for S agalactiae and S aureus is from cow to cow, so prevention focuses on within and between herd biosecurity to reduce or eliminate the reservoir of infection. S agalactiae is an obligate pathogen of the mammary gland, whereas S aureus is more widespread on other cow body sites and in the environment. Both organisms cause persistent infections, with S agalactiae typically causing higher SCC and bacteria counts in milk. Conventional methods of detection through culture perform well at the cow level. In bulk tanks, augmented procedures should be considered. PCR methods show promise of high sensitivity and specificity, at both the cow and bulk tank level. In developed dairy industries, prevalence of infection has decreased dramatically over the past 30 years for S agalactiae. For S aureus, the herd level of infection remains very high, although with rigorous, consistent application of control measures, within-herd prevalence has decreased. Because the milking time is the primary period for new IMI, it is the focal point of most prevention activities. Premilking and postmilking teat disinfection and proper stimulation and milk-out with adequately functioning equipment are key factors. There is growing evidence that the use of milking gloves is an integral part of contagious mastitis control and the production of high-quality milk. Treatment success is dramatically different between the 2 pathogens. For S agalactiae, eradication can be completed rapidly through a culture and treatment program with minimal culling. For S aureus, treatment success, particularly during lactation, is often disappointing and depends on cow, pathogen, and treatment factors. These factors should be reviewed prior to initiating any treatment to determine the potential for cure. Blanket dry cow therapy and strategic culling are important control procedures for contagious mastitis pathogens. Maintaining a closed herd or, at minimum, adhering to clearly defined biosecurity protocols is critical to reduce risk of reintroduction of S agalactiae or the addition of new, potentially more virulent strains of S aureus to endemic herds.

Use of an enzyme-linked immunosorbent assay to monitor the control of Staphylococcus aureus mastitis

Conventional culture methods were used to evaluate the ability of an ELISA to identify Staphylococcus aureus IMI. The test was 96% accurate; sensitivity was 90%, and specificity was 97%. The test was used to screen preserved milk samples rapidly in 10 cooperator herds. Prevalence of IMI was greater than 10% in 6 herds at the first test. Average prevalence of cows scoring +2 (suspect) and +3 (positive) was 12.6%. Prevalence declined during the 12-mo study. Incidence of new IMI decreased from 7.9% at 6 mo to 3.6% at 12 mo. Rinsing teat cup liners with a 25-ppm iodophor or 100-ppm chlorine solution reduced the presence of S. aureus on the milking machine liners by 97%. Elevated scores were correlated with increases in lactation number. Milk antibody concentrations changed quadratically with increasing SCC. The SCC increased as milk antibody concentration increased. In 38 dairy herds, bulk tank antibody tests reflected herd prevalence of S. aureus infection. The average prevalence was 15.0% in 87 herds in which all lactating cows were tested.

Prevalence of minor udder pathogens after intramammary dry treatment

A total of 156 dairy cows was randomly assigned to one of four groups at drying off over an 18-mo period: untreated control or intramammary treatment of each mammary quarter with either 400 mg novobiocin, 300 mg cephapirin, or 1 g dihydrostreptomycin with 1 million units penicillin. Quarter foremilk samples were aseptically collected from each cow within 1 mo of drying off and within 1 mo after parturition for bacteriological analysis. Prior to drying off, 28.7% of quarters were positive of which 46.7% were Corynebacterium bovis and 45.5% were coagulase-negative staphylococci. Reductions in infection prevalence from drying off to postpartum samplings for control, novobiocin, cephapirin, and streptomycin-penicillin groups were 13.6, 60.5, 74.4, and 35.3% of quarters. Recovery rates for C. bovis infections were 47.6, 100, 100, and 94.1%; for coagulase-negative staphylococci infections they were 72.7, 86.4, 80.0, and 100%. The cephapirin group showed the lowest new infection rate (1.3%) with coagulase-negative staphylococci compared with control (6.9%). There were no significant differences in lactation milk production among groups following dry period therapy. Results suggest that dry treatment reduces the prevalence of infections by the minor mastitis pathogens.