The interplay of dietary nutrient level and varying calcium to phosphorus ratios on efficacy of a bacterial phytase: 2. Ileal and total tract nutrient utilization

Phytase and nutrient-energy matrix: a strategic approach to enhancing the performance of broiler chickens fed a corn-soybean meal-based diet

OBJECTIVE

This study examined the effects of a nutrient matrix with or without phytase on the performance of broiler chicken.

METHODS

A total of 2,000 day-old Ross 308 broiler chickens were assigned to 5 dietary treatments, with 10 broilers per replicate and 40 replicates per treatment. The experimental diets included 1. CON: A corn and soybean meal (SBM)-basal diet without phytase. 2, NC1: A corn-SBM-based diet with reduced nutrients, specifically 0.13% less phosphorus, 40 kcal/kg less metabolizable energy (ME), and 0.30% less crude protein (CP), without phytase. 3, NC1+PHYT: NC1+500 FTU/kg phytase. 4, NC2: Another corn-SBM-based diet with greater nutrient reductions, including 0.16% less phosphorus, 55 kcal/kg less ME, and 0.45% less CP, without phytase. 5, NC2+PHYT: NC2+1,000 FTU/kg phytase.

RESULTS

In the pre-starter and overall phase, feed conversion ratio (FCR) was higher in NC2 and NC2+PHYT. In the starter phase, body weight gain (BWG) was lower in NC2 and NC2+PHYT. In the grower phases, BWG was lower in NC2, while FCR was higher. At d28, the digestibility of ash was higher in NC1+PHYT, while the digestibility of Ca and phosphorus were higher in NC1+PHYT and NC2+PHYT. At day 42, the digestibility of ash, Ca, and phosphorus were higher in NC1+PHYT and NC2+PHYT. The level of tibia ash was lower in NC2. The level of myo-inositol was lower in NC2 at d28, while the level of myo-inositol at d42 was lower in NC1 and NC2.

CONCLUSION

We concluded NC1+PHYT showed a higher growth performance comparable to CON, as against the lower performance observed in NC2, NC2+PHYT, and NC1.

Interactive effect of 2 dietary calcium and phytase levels on broilers challenged with subclinical necrotic enteritis: part 1-broiler performance, gut lesions and pH, bacterial counts, and apparent ileal digestibility

This study investigated the hypothesis that high dietary calcium (Ca) would stimulate necrotic enteritis (NE) and reduce performance, gut health, and nutrient digestibility, and if increased, phytase would reduce NE. Ross 308 male broilers (n = 768) were randomly distributed to 8 treatments in a factorial arrangement. Factors were NE challenge (no or yes), phytase level (500 or 1,500 FTU/kg using 500 FTU/kg matrix values), and Ca level (0.6 or 1.0% starter, 0.5 or 0.9% grower, 0.4 or 0.8% finisher) with the same level of available P (0.40 S, 0.35 G, and 0.35 F). There were 48 pens, 16 birds per pen and 6 replications. Half of the birds were challenged with Eimeria spp on day 9 and 10⁸ CFU per mL of Clostridium perfringens strain EHE-NE18 on day 14 and 15. Gain was higher in birds fed high phytase on day 14 (P < 0.01), day 21 (P < 0.01), day 28 (P < 0.01), and day 35 (P < 0.01). Birds fed high phytase had greater livability on day 21 (P < 0.01). Ca was more digestible in high-Ca diets on day 16, and an NE × Ca interaction (P < 0.05) showed this effect to be more pronounced in unchallenged than in challenged birds. A challenge × Ca interaction for apparent ileal digestibility (AID) of crude protein (CP) (P < 0.05) indicated lower AID of CP in challenged birds fed high Ca. The challenge decreased AID of Ca (P < 0.01). Ca level had no impact on C. perfringens count, but it decreased Lactobacillus (P < 0.05) and Bifidobacteria (P < 0.05) populations in the ceca. High dietary Ca decreased feed conversion ratio. Overall (42 D), the highest WG was observed in unchallenged birds fed high Ca and high phytase with the lowest WG observed in NE-challenged birds fed low Ca and low phytase. The results suggest that full matrix values for high doses of phytase may be appropriate during NE challenge.

Interactive effects of phosphorus, calcium, and phytase supplements on products of phytate degradation in the digestive tract of broiler chickens

This study aimed to distinguish between the single and interactive effects of phosphorus (P), calcium (Ca), and phytase on products of phytate degradation, including the disappearance of myo-inositol (MI), P, Ca, and amino acids (AA) in different segments of the digestive tract in broiler chickens. Additionally, all dephosphorylation steps from myo-inositol 1,2,3,4,5,6-hexakis (dihydrogen phosphate) (InsP₆) to MI were investigated in the digesta of the terminal ileum. Unsexed Ross 308 broiler chickens were allocated to 56 pens with 19 birds per pen, and assigned to one of 8 dietary treatments. The dietary treatments included diets without (P−, 4.1 g/kg DM) or with (P+, 6.9 g/kg DM) monosodium phosphate supplementation, without (Ca−, 6.2 g/kg DM) or with (Ca+, 10.3 g/kg DM) additional fine limestone supplementation, and without or with 1,500 FTU phytase/kg feed in a factorial design. Adding Ca or P had no effect on InsP₆ disappearance in the crop when phytase was added. InsP₆ disappearance up to the terminal ileum (P−Ca− 56%) was decreased in P+Ca− (40%), and even more so in P+Ca+ (21%), when no phytase was added. Adding phytase removed all effects of P and Ca (77 to 87%); however, P+Ca+ increased the concentrations of lower InsP esters and reduced free MI in the ileum, even in the presence of phytase. These results indicate that mineral supplements, especially P and Ca combined, reduce the efficacy of endogenous microbial or epithelial phosphatases. Supplementation with phytase increased, while supplementation with Ca decreased the concentration of MI in all segments of the digestive tract and in blood plasma, demonstrating the ability of broilers to fully degrade phytate and absorb released MI. While AA disappearance was not affected by P or Ca, or an interaction among P, Ca, and phytase, it increased with the addition of phytase by 2 to 6%. This demonstrates the potential of the phytase used to increase AA digestibility, likely independent of P and Ca supply.

Influence of phytase or myo-inositol supplements on performance and phytate degradation products in the crop, ileum, and blood of broiler chickens

The objective of this study was to investigate the effects of supplementation with free myo-inositol (MI) or graded levels of phytase on inositol phosphate (InsP) degradation, concentrations of MI in the digestive tract and blood, bone mineralization, and prececal digestibility of amino acids (AA). Ross 308 broiler hatchlings were allocated to 40 pens with 11 birds each and assigned to one of 5 treatments. The birds were fed a starter diet until d 11 and a grower diet from d 11 to d 22. All diets were based on wheat, soybean meal, and corn. Birds were fed a control diet, calculated to contain adequate levels of all nutrients without (C) or with MI supplementation (C+MI), or one of 3 experimental diets that differed in phytase level (modified E. coli-derived 6-phytase; Phy500, Phy1500, or Phy3000 FTU/kg), with P and Ca levels adapted to the recommendations of the phytase supplier for a phytase level of 500 FTU/kg. The gain:feed ratio (G:F) was increased by MI or phytase in the starter+grower phase by 0.02 g/g. Prececal P and Ca digestibility, P and Ca concentration in blood serum, and tibia ash weight did not differ among treatments (P > 0.05). MI supplementation led to the highest MI concentration in the crop, ileum, and blood plasma across treatments. Phytase supplementation increased MI concentrations in the crop and ileum digesta in a dose-dependent manner and in plasma without any dose effect (P > 0.05). Prececal digestibility of some AA was increased by phytase. These outcomes indicate that MI might have been a relevant cause for the increase in G:F. Therefore, it is likely that the release of MI after complete dephosphorylation of phytate is one of the beneficial effects of phytase, along with the release of P and improvement in digestibility of other nutrients. Simultaneously, MI seems to have no diminishing effects on InsP degradation.

Hydrolysis of phytate to its lower esters can influence the growth performance and nutrient utilization of broilers with regular or super doses of phytase

The aim of the study was to observe the effects of dietary available phosphorus (aP) and calcium (Ca), with regular or super doses of phytase, on phytate hydrolysis and subsequent influences on broiler growth performance and nutrient utilization. In a 2 × 3 factorial design, 384 Ross-308 broilers were allocated to one of 6 dietary treatments with 8 replicates in a randomized complete block design for 21 days. Diets were nutritionally adequate (positive control, PC) or marginally deficient in aP and Ca (negative control, NC), with 0, 500 or 1,500 FTU/kg phytase. Bird and feed weights were recorded on d 0 and 21, excreta were collected on d 19 and 20, and gizzard and ileal contents were collected on d 21. Body weight gain (P < 0.01) increased linearly with phytase in the PC and quadratically in the NC. There was an interactive effect on ileal DM, N, and P utilization, increasing quadratically with phytase supplementation in the NC, but there was no phytase influence in the PC (P < 0.05). Phytase linearly increased copper (P < 0.001) and linearly decreased Ca (P < 0.05) utilization in the ileum. Phytase decreased ileal (IPx, inositol x-phosphate) IP6 and IP5 and increased inositol (quadratic, P < 0.001) but had no effect on IP4 or IP3. The influence of the dietary aP was more apparent on the hydrolysis of phytate and phytate esters after the ileum, with increasing (linear and quadratic, P < 0.05) IP4 and IP3 content in the excreta of birds fed the NC or PC when phytase was added. Phytate hydrolysis improves the growth potential of birds fed NC diets, allowing them to match the growth performance of birds fed PC diets and improve nutrient utilization. These results indicate that dietary Ca and aP concentrations can be reduced when phytase is supplemented. It also may be beneficial to apply the enzyme nutrient matrix to other nutrients in the diet to maintain an optimal balance of nutrients in the digesta.

The efficacy of dietary xylanase and phytase in broiler chickens fed expeller-extracted camelina meal

A study was conducted to investigate the effects of dietary phytase (PHY) and xylanase (XYL) on growth performance, nutrient utilization, and intestinal characteristics in broilers fed corn-soybean meal-based diets with added expeller-extracted camelina meal (CM). The corn-soybean meal-based diets without or with CM was formulated to contain 2.9 or 2.7 g/kg non phytate phosphorus, respectively. A total of 384 male Ross 708 broilers were allocated to 8 dietary treatments in a randomized complete block design with 6 replicates per treatment, from 7 to 21 d post hatching. The experiment consisted of a 2 × 2 × 2 factorial arrangement of treatments with 2 dietary CM levels (zero or 100 g/kg), 2 dietary levels of XYL (zero or 800 unit/kg), and 2 dietary levels of PHY (zero or 4,000 unit/kg). Chromic oxide was included in the diets as an indigestible marker. Growth was measured throughout the experiment and excreta were collected on d 18 to 21 post hatching for measurement of nutrient and energy retention. On d 21 post hatching, broilers were euthanized by CO2 asphyxiation, ileal digesta was collected for nutrient and energy digestibility measurements, and the left tibia was removed for bone ash measurement. Furthermore, duodenal digesta was collected and a segment of the mid jejunum was excised for viscosity and morphology measurement, respectively. Broilers fed 100 g/kg CM diets showed lower (P < 0.001) BW gain and G:F than those fed zero g/kg CM diets for 7 to 14 d and 7 to 21 d post hatching periods, respectively. Phytase supplementation improved (P < 0.05) all the growth parameters measured regardless of CM addition. Phytase supplementation resulted in an increase (P < 0.05) in jejunum villus height but there was no impact of CM or XYL. Additionally, duodenal digesta viscosity increased (P < 0.001) with added CM. Tibia ash and weight increased (P < 0.001) with PHY supplementation. There was a CM × PHY interaction (P < 0.05) on percentage tibia ash, with greater PHY effect in zero g/kg CM diets compared with 100 g/kg CM diets. Phytase supplementation increased (P < 0.05) ileal DM, N, energy, P, and neutral detergent fiber (NDF) digestibility. In diets with 100 g/kg CM, addition of PHY had a greater effect (CM × PHY; P < 0.05) on ileal P digestibility compared with diet without CM. There was a CM × PHY interaction (P < 0.05) for ileal digestible energy (IDE) in which PHY increased the IDE in birds fed CM supplemented diets. Both ileal digestibility and retentions of DM, N, energy, and IDE, AME, and AMEn were decreased (P < 0.05) by CM supplementation. Retention of ether extract and NDF decreased (P < 0.05) with CM supplementation. Nitrogen retention, AME, and AMEn decreased (CM × XYL; P < 0.05) with XYL supplementation in zero g/kg CM diets. There were CM × XYL interactions (P < 0.01) for P and Ca retentions in which XYL increased retentions in 100 g/kg CM diets. In conclusion, PHY was efficacious at improving P digestibility and retention of birds fed low P corn-soy based diets without or with CM. However, regardless of CM addition, XYL did not improve nutrient utilization and growth performance of broiler chickens. The present data also show that the mechanism underlying the detrimental effects of CM inclusion on nutrient utilization is not mediated through gut morphology and goblet cell density. The data also show that the villus height increase occurring with PHY addition might be a contributor to the improvements in ileal DM, N, and energy digestibility obtained with PHY supplementation.