Stimulation of heterotrophic and autotrophic growth of Sphaerotilus discophorus by manganous ions

A review of filamentous sludge bulking controls from conventional methods to emerging quorum quenching strategies

Filamentous bulking, which results from the overgrowth of filamentous microorganisms, is a common issue that frequently disrupts the stable operation of activated sludge processes. Recent literature has paid attention to the relationship between quorum sensing (QS) and filamentous bulking highlighting that the morphological transformations of filamentous microbes are regulated by functional signal molecules in the bulking sludge system. In response to this, a novel quorum quenching (QQ) technology has been developed to control sludge bulking effectively and precisely by disturbing QS-mediated filamentation behaviors. This paper presents a critical review on the limitations of classical bulking hypotheses and traditional control methods, and provides an overview of recent QS/QQ studies that aim to elucidate and control filamentous bulking, including the characterization of molecule structures, the elaboration of QS pathways, and the precise design of QQ molecules to mitigate filamentous bulking. Finally, suggestions for further research and development of QQ strategies for precise bulking control are put forward.

Biological oxidation of Mn(II) coupled with nitrification for removal and recovery of minor metals by downflow hanging sponge reactor

Biogenic manganese oxides (bio-MnO₂) have been shown to absorb minor metals. Bioreactor cultivation of heterotrophic manganese oxidizing bacteria (MnOB), which produce bio-MnO₂ via oxidation of Mn (II), can be expected to be involved in a promising system for removal and recovery of minor metals from wastewater. However, MnOB enrichment in wastewater treatment is difficult. This study investigated whether MnOB can be cultivated when coupled with nitrification in a system in which soluble microbial products (SMP) from nitrifiers are provided to MnOB as a substrate. A downflow hanging sponge (DHS) reactor was applied for MnOB cultivation with ammonium (NH₄⁺) and Mn (II) continuously supplied. During long-term operation, Mn (II) oxidation was successfully established at a rate of 48 g Mn m⁻³ d⁻¹ and bio-MnO₂ that formed on the sponges were recovered from the bottom of the reactor. The results also revealed that Ni and Co added to the influent were simultaneously removed. Microbial 16S rRNA gene clone analysis identified nitrifiers supporting MnOB growth and showed that only one clone of Bacillus subtilis, which was affiliated with a known MnOB cluster, was present, suggesting the existence of other novel bacteria with the ability to oxidize Mn (II).

Isolation of Sphaerotilus-Leptothrix strains from iron bacteria communities in Tierra del Fuego wetlands

Sheath-forming iron- and manganese-depositing bacteria belonging to the Sphaerotilus-Leptothrix group (SLG) are widespread in natural and artificial water systems. Known requirements for their growth include the presence of organic substrates and molecular oxygen. High concentrations of reduced iron or manganese, although not necessary for most species, make their growth a noticeable phenomenon. Such microbial communities have been studied mostly in the Northern Hemisphere. Here, we present descriptions of diverse ochre-depositing microbial communities in Tierra del Fuego, Argentina, using a combined approach of microscopical examination, clone library construction and cultivation focused on SLG bacteria. To date, only few SLG type strains are available. The present work increases the number and diversity of cultivated SLG bacteria by obtaining isolates from biofilms and sediment samples of wetlands in Tierra del Fuego. Thirty isolates were selected based on morphological features such as sheath formation and iron/manganese deposition. Five operational taxonomic units (OTUs) were deduced. Sequencing of 16S rRNA genes showed that one OTU is identical to the Leptothrix mobilis Feox-1(T) -sequence while the four remaining OTUs show similarity values related to previously described type strains. Similarity values ranged from 96.5% to 98.8%, indicating possible new species and subspecies.

Manganese oxidation by spores and spore coats of a marine bacillus species

Bacillus sp. strain SG-1 is a marine bacterial species isolated from a near-shore manganese sediment sample. Its mature dormant spores promote the oxidation of Mn to MnO(2). By quantifying the amounts of immobilized and oxidized manganese, it was established that bound manganese was almost instantaneously oxidized. When the final oxidation of manganese by the spores was partly inhibited by NaN(3) or anaerobiosis, an equivalent decrease in manganese immobilization was observed. After formation of a certain amount of MnO(2) by the spores, the oxidation rate decreased. A maximal encrustment was observed after which no further oxidation occurred. The oxidizing activity could be recovered by reduction of the MnO(2) with hydroxylamine. Once the spores were encrusted, they could bind significant amounts of manganese, even when no oxidation occurred. Purified spore coat preparations oxidized manganese at the same rate as intact spores. During the oxidation of manganese in spore coat preparations, molecular oxygen was consumed and protons were liberated. The data indicate that a spore coat component promoted the oxidation of Mn in a biologically catalyzed process, after adsorption of the ion to incipiently formed MnO(2). Eventually, when large amounts of MnO(2) were allowed to accumulate, the active sites were masked and further oxidation was prevented.

c-type cytochromes and manganese oxidation in Pseudomonas putida MnB1

Pseudomonas putida MnB1 is an isolate from an Mn oxide-encrusted pipeline that can oxidize Mn(II) to Mn oxides. We used transposon mutagenesis to construct mutants of strain MnB1 that are unable to oxidize manganese, and we characterized some of these mutants. The mutants were divided into three groups: mutants defective in the biogenesis of c-type cytochromes, mutants defective in genes that encode key enzymes of the tricarboxylic acid cycle, and mutants defective in the biosynthesis of tryptophan. The mutants in the first two groups were cytochrome c oxidase negative and did not contain c-type cytochromes. Mn(II) oxidation capability could be recovered in a c-type cytochrome biogenesis-defective mutant by complementation of the mutation.

Ennoblement of Stainless Steel by the Manganese-Depositing Bacterium Leptothrix discophora

The noble shift in open-circuit potential exhibited by microbially colonized stainless steel (ennoblement) was investigated by examining the relationship among surface colonization, manganese deposition, and open-circuit potential for stainless steel coupons exposed to batch cultures of the manganese-depositing bacterium Leptothrix discophora. Open-circuit potential shifted from -100 to +330 mV(infSCE) as a biofilm containing 75 nmol of MnO(infx) cm(sup-2) formed on the coupon surface but changed little further with continued MnO(infx) deposition up to 270 nmol cm(sup-2). Increased open-circuit potential corresponded to decreasing Mn(II) concentration in solution and to increased MnO(infx) accumulation and attached cell density on the coupon surfaces. MnO(infx) deposition was attributable to biological activity, and Mn(II) was observed to enhance cell attachment. The experimental results support a mechanism of ennoblement in which open-circuit potential is fixed near +350 mV(infSCE) by the cathodic activity of biomineralized MnO(infx).

Characterization of extracellular Mn2+-oxidizing activity and isolation of an Mn2+-oxidizing protein from Leptothrix discophora SS-1

Supernatant fluid from Leptothrix discophora SS-1 cultures possessed high Mn2+-ozidizing activity. Studies of temperature and pH optima, chemical inhibition, and protease sensitivity suggested that the activity may be enzymatic. Kinetic studies of unconcentrated supernatant fluid indicated an apparent Km of 7 microM Mn2+ in the 1 to 200 microM Mn2+ range. The greatest Vmax value observed was 1.4 nmol of Mn2+ oxidized min-1 micrograms of protein-1 in unconcentrated samples. When the supernatant fluid was concentrated on DEAE-cellulose and the activity was eluted with MgSO4, an Mn2+-oxidizing protein was detected in the concentrate by sodium dodecyl sulfate-polyacrylamide gel electrophoresis. The Mn2+-oxidizing protein appeared to have a molecular weight of 110,000 in 10% polyacrylamide gels and of 100,000 in 8% gels. Periodic acid-Schiff base staining of overloaded polyacrylamide gels showed that the DEAE-cellulose concentrate contained abundant high-molecular-weight polysaccharides; concurrent staining of the Mn2+-oxidizing band suggested that it too contained carbohydrate components. Isolation of the protein was achieved by subjecting the DEAE-cellulose concentrate to Sephacryl gel filtration in the presence of 1% sodium dodecyl sulfate, followed by preparative electrophoresis and reverse-polarity elution. However, these procedures resulted in loss of a large proportion of the activity, which precluded recovery of the protein in significant quality.

Manganese oxidation by Leptothrix discophora

Cells of Leptothrix discophora SS1 released Mn2+-oxidizing factors into the medium during growth in batch culture. Manganese was optimally oxidized when the medium was buffered with HEPES (N-2-hydroxyethylpiperazine-N'-2-ethanesulfonic acid) at pH 7.5. Manganese-oxidizing activity in the culture medium in which this strain had been grown previously was sensitive to heat, phosphate, Tris, NaN3, HgCl2 NaCl, sodium dodecyl sulfate, and pronase; 0.5 mol of O2 was consumed per mol of MnO2 formed. During Mn2+ oxidation, protons were liberated. With sodium dodecyl sulfate-polyacrylamide gel electrophoresis, two protein-containing bands were detected in the spent culture medium. One band had an apparent molecular weight of 110,000 and was predominant in Mn2+-oxidizing activity. The second product (Mr 85,000) was only detected in some cases and probably represents a proteolytic breakdown moiety of the 110,000-Mr protein. The Mn2+-oxidizing factors were associated with the MnO2 aggregates that had been formed in spent culture medium. After solubilization of this MnO2 with ascorbate, Mn2+-oxidizing activity could be recovered.

Manganese: its acquisition by and function in the lactic acid bacteria

The transition metal manganese is considered to be a minor micronutrient in both pro- and eukaryotes, usually being required from the environment at subnanomolar levels. Until recently, Mn was only known to function in cells as a cofactor for a few enzymatic reactions. A notable exception has been reported in many lactic acid bacterial species which require micromolar medium Mn levels for growth and contain up to 35 mM Mn. These high Mn concentrations are accompanied by the near or complete absence of intracellular iron and superoxide dismutase (SOD). Lacking hemes, Lactobacillus plantarum and related species contain a unique Mn-cofactored catalase as well as millimolar Mn(II) in a nonenzymic complex performing the function of the micromolar superoxide dismutase found in most other aerotolerant cells. The high Mn(II) levels are accumulated via an efficient active transport system and are stored intracellularly in a high molecular weight complex. Study of Lactobacillus plantarum has provided an interesting example of the substitution of Mn for Fe in several of the biological roles of Fe, an alternative mechanism of aerotolerance, and a better understanding of the unique biochemistry of the lactic acid bacteria.

Determination of growth of Sphaerotilus discophorus in the presence of manganese

Manganese interferes strongly with most chemical methods of biomass determination. However, the biomass of manganese-encrusted Sphaerotilus discophorus can be determined after removal of the MnO2 with trichloroacetic acid and oxalic acid. Evidence which indicates that manganese inhibits the heterotrophic growth of S. discophorus and that the cells only oxidize manganese late in the growth curve is presented.