The characteristics of stepwise ultrasonic hydrolysates of sludge for enhancing denitrification

Review on ultrasonic technology enhanced biological treatment of wastewater

As a clean, sustainable and efficient technology of wastewater treatment, ultrasonic irradiation has gained special attention in wastewater treatment. It has been widely studied for degrading pollutants and enhancing biological treatment processes for wastewater treatment. This review focuses on the mechanism and updated information of ultrasonic technology to enhance biological treatment of wastewater. The mechanism involved in improving biological treatment by ultrasonic includes: 1) degradation of refractory substances and release carbon from sludges, 2) promotion of mass transfer and change of cell permeability, 3) facilitation of enzyme-catalyzed reactions and 4) influence of cell growth. Based on the above discussion, the effects of ultrasound on the enhancement of wastewater biological treatment processes can be categorized into indirect and direct ways. The indirect effect of ultrasonic waves in enhancing biological treatment is mainly achieved through the use of high-intensity ultrasonic waves. These waves can be used as a pretreatment to improve biodegradability of the wastewater. Moreover, the ultrasonic-treated sludge or its supernatant can serve as a carbon source for the treatment system. Low-intensity ultrasound is often employed to directly enhance the biological treatment of wastewater. The propose of this process is to improve activated sludge, domesticate polyphosphate-accumulating organisms, ammonia-oxidizing bacteria, and anammox bacteria, and achieve speedy start-up of partial nitrification and anammox. It has shown remarkable effects on maintaining stable operation, tolerating adverse conditions (i.e., low temperature, low C/N, etc.), resisting shock load (i.e., organic load, toxic load, etc.), and collapse recovery. These results indicate a promising future for biological wastewater treatment. Furthermore, virous ultrasonic reactor designs were presented, and their potential for engineering application was discussed.

Simultaneous denitrification enhancement and sludge reduction based on novel suspended carrier modified using activated carbon and magnetite at low carbon/nitrogen ratio

A novel suspended carrier was prepared by sticking activated carbon (AC) and magnetite (Fe3O4) onto polypropylene slices. Although this carrier could not reverse the decreased denitrification capacity trends under anoxic conditions at an influent carbon/nitrogen (C/N) ratio of 2, it enhanced denitrification by stimulating sludge reduction and accelerating electron transfer to certain extent. The carrier stuck by mixed AC/Fe3O4 exhibited better performance in terms of sludge reduction, extracellular polymeric substances (EPS) secretion, and denitrification than that merely stuck by AC and Fe3O4 at an influent C/N ratio of 2. The carrier stuck by mixed AC/Fe3O4 increased the total nitrogen removal efficiency by 24.6 % ± 12.5 % in a 72-h denitrification batch experiment compared to the common polypropylene carrier. Moreover, the carrier improved EPS secretion and nitrogen metabolism and promoted the growth of Trichococcus and some denitrifying genera. This study provides a reference for the treatment of low C/N ratio sewage.

Effects of lysed sludge reflux point on ultrasound lysis-cryptic growth in anaerobic/aerobic (A/O) wastewater treatment: Sludge reduction, microbial community, and metabolism

Ultrasonication allows sludge reduction to be performed in situ during wastewater treatment, and the reflux point of the lysed sludge affects this performance. This study investigated the effects of reflux point (anaerobic stage, carbon/nitrogen (C/N) lowest stage, and aerobic stage) on sludge lysis-cryptic growth in an anaerobic/aerobic reactor and variations in the sludge and microbial community. The best reflux point occurred at the lowest C/N ratio stage, and a 50.96% reduction in excess sludge was achieved. The reflux of the lysed sludge to the aerobic stage reduced nitrogen and phosphorus removal. The reflux of the lysed sludge decreased the average sludge size, reaching 29.2 μm when reflux to the aerobic stage. Scanning electron microscopy showed that the sludge surface was unaffected by the reflux point. The Fourier-transform infrared spectrometry and X-ray photoelectron spectroscopy results showed that the most prominent variation in the intensity of the sludge functional groups occurred when the reflux was at the lowest C/N stage. The amount of extracellular polymeric substances decreased the most during reflux to the anaerobic stage. The sludge microbial communities varied with the reflux point, and the dominant phyla during reflux to the anaerobic, lowest C/N, and aerobic stages were Bacteroidetes, Firmicutes, and Bacteroidetes, respectively. Furthermore, the reflux point did not alter the metabolic pathway of sludge microorganisms but increased the number of enzymes in metabolic pathways.