Significance of pre-incubation temperature and inoculum concentration on subsequent growth of Listeria monocytogenes at 14°C

Modeling the Effects of the Preculture Temperature on the Lag Phase of Listeria monocytogenes at 25°C

In predictive microbiology, the study of the microbial lag phase, i.e., the time needed for bacteria to adapt to a new environment before multiplying, has received a great deal of attention in the research literature. The microbial lag phase is more difficult to estimate than the specific growth rate because the lag phase is impacted by the previous and actual growth environments. In this study, the growth of Listeria monocytogenes preincubated at 0, 5, 10, and 15°C and subsequently grown at 25°C was investigated at the single-cell and population levels. The population lag phase of L. monocytogenes was obtained by fitting the Baranyi model, and the single-cell lag time was estimated by the time to detection method. The lag phase at the single-cell and population levels of L. monocytogenes presented a downward trend as the preculture temperature ranged from 0 to 15°C. The population lag phase of L. monocytogenes was lower than the single-cell lag time at the same preculture temperature. In addition, except for the zero-lag distribution at a preculture temperature of 15°C, all the single-cell lag time distributions of L. monocytogenes followed a Weibull distribution under all preculture temperatures. The preculture temperature had a significant impact on the rapid variation in the single-cell lag time distribution. Thus, the influence of preculture temperature on the lag phase needs to be quantitatively analyzed for better assessment of microbiological risk.

Adaptive growth responses of Listeria monocytogenes to acid and osmotic shifts above and across the growth boundaries

The effect of acid and osmotic shifts on the growth of Listeria monocytogenes was evaluated at 10°C. Two types of shifts were tested: (i) within the range of pH and water activity (a(w)) levels that allow growth of L. monocytogenes and (ii) after habituation at no-growth conditions back to growth-permitting conditions. A L. monocytogenes cheese isolate, with high survival capacity during cheesemaking, was inoculated (10(2) CFU/ml) in tryptic soy broth supplemented with 0.6% yeast extract at six pH levels (5.1 to 7.2; adjusted with lactic acid) and 0.5% NaCl (a(w) 0.995), or four a(w) levels (0.995 to 0.93, adjusted with 0.5 to 10.5% NaCl) at pH 7.2 and grown to early stationary phase. L. monocytogenes was then shifted (at 10(2) CFU/ml) to each of the aforementioned growth-permitting pH and a(w) levels and incubated at 10°C. Shifts from no-growth to growth-permitting conditions were carried out by transferring L. monocytogenes habituated at pH 4.9 or a(w) 0.90 (12.5% NaCl) for 1, 5, and 10 days to all pH and a(w) levels permitting growth. Reducing a(w) or pH at different levels in the range of 0.995 to 0.93 and 7.2 to 5.1, respectively, decreased the maximum specific growth rate of L. monocytogenes. The lag time of the organism increased with all osmotic downshifts, as well as by the reduction of pH to 5.1. Conversely, any type of shift within pH 5.5 to 7.2 did not markedly affect the lag times of L. monocytogenes. The longer the cells were incubated at no-growth a(w) (0.90), the faster they initiated growth subsequently, suggesting adaptation to osmotic stress. Conversely, extended habituation at pH 4.9 had the opposite effect on subsequent growth of L. monocytogenes, possibly due to cell injury. These results suggest that there is an adaptation or injury rate induced at conditions inhibiting the growth of the pathogen. Thus, quantifying adaptation phenomena under growth-limiting environments, such as in fermented dairy and meat products or products preserved in brine, is essential for reliable growth simulations of L monocytogenes during transportation and storage of foods.