Nitrate removal by simultaneous sulfur utilizing autotrophic and heterotrophic denitrification under different organics and alkalinity conditions: batch experiments

The effect of various organic compounds were tested using lab-scale batch reactors. At sufficient alkalinity, the initial nitrate nitrogen concentration of 100 mg/L was completely reduced in all batch reactors. Sulfate production decreased by the addition of organics. The concentration range of organics used in this experiment did not inhibit autotrophic denitrification except for propionate. Propionate inhibited autotrophic denitrification a little, indicated by a lower sulfate production rate. Biomass in suspension increased with higher initial organic concentrations, showing higher DOC consumption. As the concentration of organics increased, alkalinity increased accordingly. Under the conditions of low alkalinity, in the case of a control reactor without organics, only about 30% of the initial nitrate was reduced. With half the theoretically required dosage of methanol, the denitrification rates increased slightly. When ethanol, acetate, and propionate were used, denitrification went to completion. When excess organics was added, however, sulfate production was significantly decreased. Interestingly, even when small amounts of organics were added, autotrophic denitrification was promoted as indicated by the sulfate production.

Monitoring the denitrification of wastewater containing high concentrations of nitrate with methanol in a sulfur-packed reactor

Biological denitrification of high nitrate-containing wastewater was examined in a sulfur-packed column using a smaller amount of methanol than required stoichiometrically for heterotrophic denitrification. In the absence of methanol, the observed nitrate removal efficiency was only about 40%, and remained at 400 mg NO(3)(-)-N/l, which was due to an alkalinity deficiency of the pH buffer and of CO(2) as a carbon source. Complete denitrification was achieved by adding approximately 1.4 g methanol/g nitrate-nitrogen (NO(3)(-)-N) to a sulfur-packed reactor. As the methanol concentration increased, the overall nitrate removal efficiency increased. As influent methanol concentrations increased from 285 to 570, 855, and 1,140 mg/l, the value of Delta mg alkalinity as CaCO(3) consumed/Delta mg NO(3)(-)-N removed increased from -1.94 to -0.84, 0.24, and 0.96, and Delta mg SO(4)(2-) produced/Delta mg NO(3)(-)-N removed decreased from 4.42 to 3.57, 2.58, and 1.26, respectively. These results imply the co-occurrence of simultaneous autotrophic and heterotrophic denitrification. Sulfur-utilizing autotrophic denitrification in the presence of a small amount of methanol is very effective at decreasing both sulfate production and alkalinity consumption. Most of methanol added was removed completely in the effluent. A small amount of nitrite accumulated in the mixotrophic column, which was less than 20 mg NO(2)(-) -N/l, while under heterotrophic denitrification conditions, nitrite accumulated steadily and increased to 60 mg NO(2)(-) -N/l with increasing column height.