Alcohol flush does not aid in endoscope channel drying but may serve as an adjunctive microbiocidal measure: A new take on an old assumption

BACKGROUND

Alcohol is perceived to aid flexible endoscope channel drying, however we previously showed alcohol increased the time required to dry some channels with forced air versus water alone. Yet, alcohol may prevent microorganism outgrowth during storage. Drying endoscope channels has been shown to prevent outgrowth, but it is unknown if incomplete drying (<10 µL remaining) provides similar protection.

METHODS

Endoscope channel test articles were used to determine the efficacy of 70%-30% alcohol flush for prevention of Pseudomonas aeruginosa outgrowth and drying efficiency. For non-alcohol flushed channels, the impact of forced air drying on outgrowth of P. aeruginosa was determined.

RESULTS

Alcohol flush (70%-30%) prevented outgrowth with little to no recovery of P. aeruginosa during ambient storage. 70% alcohol increased channel drying time by 1.5 or 3-fold compared to 50% alcohol or water, respectively. Forced air drying of non-alcohol flushed channels greatly reduced the initial contamination level and prevented outgrowth. Incomplete drying of contaminated channels was akin to no application of forced air. Applying forced air for more time than necessary to remove residual liquid did not completely eliminate the low level recovery of P. aeruginosa.

CONCLUSIONS

Flushing with reduced concentrations of alcohol may provide a strategy to prevent microbial outgrowth while reducing drying time.

How effective are the alcohol flush and drying cycles of automated endoscope reprocessors? Stripped endoscope model

BACKGROUND

Effective drying of the internal channels of endoscopes is essential to prevent the growth of water-borne pathogens and to assure adequate sterilization with vaporized hydrogen peroxide or ethylene oxide. The aim of this study was to evaluate the dryness of endoscopes after a routine disinfection process in an automated endoscope reprocessor.

METHODS

Stripped endoscopes (SE) that allow for visual inspection of the inside channels were reprocessed per protocol in a large urban medical center, with a 3-minute or 10-minute air flush following reprocessing. SE was hung and observed for any water within the channels after reprocessing and after a week of ambient storage. Ready-for-use endoscopes were also randomly spot-checked for moisture visually and with moisture detection paper.

RESULTS

All SE were grossly wet after HLD with a 3-minute air flush, despite alcohol flush and drying cycle. The 10-minute air flush was effective at drying the biopsy/suction channel, but not the air/water channels. Hanging had limited effect, being most effective in the biopsy/suction channels. Of the 77 ready-for-use respiratory and gastrointestinal endoscopes assessed, 37 (48.1%) showed evidence of retained moisture.

CONCLUSIONS

Air flush cycles commonly used in the final steps of automated endoscope reprocessing may not adequately dry endoscope channels, particularly the narrower diameter air/water channels. An extended 10-minute air flush appears effective at drying the larger biopsy/suction channel, but has limited effect on the air/water channels.

Efficacy of flexible endoscope drying using novel endoscope test articles that allow direct visualization of the internal channel systems

BACKGROUND

Thorough drying of flexible endoscope channels has been identified as an essential reprocessing step. Yet, instructions are not specific on how to dry endoscopes. There is lack of data supporting efficacy of current drying practices, due to limitations in determining channel dryness.

METHODS

Novel endoscope test articles were used to evaluate the effectiveness of alcohol flush and hanging in an ambient endoscope storage cabinet. Prepared test articles were hung in a storage cabinet for 5 days and visually inspected for residual liquid. The procedure for preoperative inspection of endoscopic systems was performed to determine the procedure's efficacy for removing residual liquid. Then, testing was performed to assess the impact of pressure, residual liquid type and route of air application on time to dry using compressed air.

RESULTS

Alcohol flush followed by hanging in an ambient storage cabinet was not effective for drying endoscope channels, and residual liquid was not completely removed after performing the steps of the preoperative inspection of endoscopic channels. The factors impacting effective compressed air drying were channel dependent. For some channels, alcohol increased the time to dry.

CONCLUSIONS

Endoscope drying is complex; borescope evaluation does not ensure a dry device.

Novel Algorithms for Reprocessing, Drying and Storing Endoscopes

After outbreaks of duodenoscope-transmitted infection with multidrug-resistant organisms, it has become clear that institutions must optimize their endoscope reprocessing programs. Standard endoscope reprocessing practices may not represent the ideal approach for preventing transmission of infection related to endoscopy. We discuss multiple approaches to enhance and optimize reprocessing, drying, and storage of standard duodenoscopes. The optimal enhanced duodenoscope reprocessing modality remains to be determined. Acknowledging the challenges and limitations in effectively reprocessing duodenoscopes, the FDA issued a safety communiqué recommending transitioning to either single use disposable duodenoscopes or duodenoscopes with innovative designs that allow more effective reprocessing.