Determination of type B trichothecenes and macrocyclic lactone mycotoxins in field contaminated maize

Magnetic Core-Shell Nanoparticles Using Molecularly Imprinted Polymers for Zearalenone Determination

This paper describes the synthesis of novel molecularly imprinted magnetic nano-beads for the selective extraction (MISPE) of zearalenone mycotoxin in river and tap waters and further analysis by high-performance liquid chromatography (HPLC) with fluorescence detection (FLD). A semi-covalent imprinting approach was achieved for the synthesis of the molecularly imprinted polymers (MIP). The nanoparticles were prepared by covering the starting Fe3O4 material with a first layer of tetraethyl orthosilicate (TEOS) and then with a second layer using cyclododecyl 2-hydroxy-4-(3-triethoxysilylpropylcarbamoyloxy) benzoate. The last was used with a dual role, template and functional monomer after the extraction of the template molecule. The material was characterized by transmission electron microscopy (TEM), X-ray diffraction (XRD) and Fourier transform infrared spectroscopies (FT-IR). The solid phase extraction was optimized in all the steps: loading, washing and elution. The optimal conditions allowed the determination of zearalenone in trace levels of 12.5, 25 and 50 µg L-1 without significant differences between the fortified and found level concentrations.

Critical Assessment of Mycotoxins in Beverages and Their Control Measures

Mycotoxins are secondary metabolites of filamentous fungi that contaminate food products such as fruits, vegetables, cereals, beverages, and other agricultural commodities. Their occurrence in the food chain, especially in beverages, can pose a serious risk to human health, due to their toxicity, even at low concentrations. Mycotoxins, such as aflatoxins (AFs), ochratoxin A (OTA), patulin (PAT), fumonisins (FBs), trichothecenes (TCs), zearalenone (ZEN), and the alternaria toxins including alternariol, altenuene, and alternariol methyl ether have largely been identified in fruits and their derived products, such as beverages and drinks. The presence of mycotoxins in beverages is of high concern in some cases due to their levels being higher than the limits set by regulations. This review aims to summarize the toxicity of the major mycotoxins that occur in beverages, the methods available for their detection and quantification, and the strategies for their control. In addition, some novel techniques for controlling mycotoxins in the postharvest stage are highlighted.

Mycotoxins Analysis in Cereals and Related Foodstuffs by Liquid Chromatography-Tandem Mass Spectrometry Techniques

In the entire world, cereals and related foodstuffs are used as an important source of energy, minerals, and vitamins. Nevertheless, their contamination with mycotoxins kept special attention due to harmful effects on human health. The present paper was conducted to evaluate published studies regarding the identification and characterization of mycotoxins in cereals and related foodstuffs by liquid chromatography coupled to (tandem) mass spectrometry (LC-MS/MS) techniques. For sample preparation, published studies based on the development of extraction and clean-up strategies including solid-phase extraction, solid-liquid extraction, and immunoaffinity columns, as well as on methods based on minimum clean-up (quick, easy, cheap, effective, rugged, and safe (QuEChERS)) technology, are examined. LC-MS/MS has become the golden method for the simultaneous multimycotoxin analysis, with different sample preparation approaches, due to the range of different physicochemical properties of these toxic products. Therefore, this new strategy can be an alternative for fast, simple, and accurate determination of multiclass mycotoxins in complex cereal samples.

A Novel Magnetic Molecular Imprinted Polymer for Selective Extraction of Zearalenone from Cereal Flours before Liquid Chromatography-Tandem Mass Spectrometry Determination

Zearalenone (ZEN) is a nonsteroidal estrogenic mycotoxin produced by various Fusarium species and commonly occurring in corn and other cereals. Even though its acute toxicity is low, still the estrogenic activity of ZEN and metabolites is a matter of concern. In this work, a new magnetic molecularly imprinted polymer (mMIP) for the selective extraction of ZEN from cereal flours is presented. The mMIP was synthesized previously using quercetin as dummy template, and here we wanted to test its applicability to complex food samples. Analyte determination was carried out by high-performance liquid chromatography coupled to tandem mass spectrometry. The selectivity of the mMIP and the main validation method parameters were assessed. In particular, even in samples as complex as cereals, matrix effect was negligible. Although the mMIP showed cross-selectivity towards both ZEN-related and quercetin-related compounds, nonetheless ZEN recovery was > 95% for the two lower spiking levels, and the quantification limit was 0.14 ng g⁻¹, i.e., ca. 500 times lower than the maximum limit fixed for most cereals by European law. Therefore, the material, also in comparison with a commercial sorbent, appears suitable for the application in food analysis, also to isolate ZEN at trace levels.

Cytotoxic and inflammatory effects of individual and combined exposure of HepG2 cells to zearalenone and its metabolites

Zearalenone (ZEA), a mycotoxin produced by several Fusarium spp., is most commonly found as a contaminant in stored grain. ZEA derivatives (α-zearalenol (α-ZOL), β-zearalenol (β-ZOL)) can also be produced by Fusarium spp. in corn stems infected by fungi in the field. Also, following oral exposure, zearalenone is metabolized in various tissues, particularly in the liver, the major metabolites being α-ZOL and β-ZOL. The co-exposure of cells to mixture of a combination of mycotoxins may cause an increase of toxicity produced by these mycotoxins. In this in vitro study, we investigated the combined effects of ZEA, α-ZOL, β-ZOL in binary mixtures on the viability and inflammatory response of human liver cancer cell line (HepG2). Cell viability was assessed after 72 h using a neutral red assay. Effect of the toxins and their binary combinations on the expression of genes involved in inflammation (IL-1β, TNF-α, and IL-8) were assessed through qPCR. Our viability data showed that irrespective of the toxin combinations, the toxins have synergistic effect. ZEA + α-ZOL and ZEA + β-ZOL mixtures have induced a slight to high antagonistic response on inflammatory cytokines at low concentrations that have turned into strong synergism for high concentrations. α-ZOL + β-ZOL showed antagonistic effects on inflammation for IL-1β and TNF-α, but act synergic for IL-8 at high toxin concentrations. This study clearly shows that co-contamination of food and feed with ZEA metabolites should be taken into consideration, as the co-exposure to mycotoxins might result in stronger adverse effect than resulted from the exposure to individual toxin.

Toxicokinetic profile of fusarenon-X and its metabolite nivalenol in the goat (Capra hircus)

The main aim of this research was to evaluate the toxicokinetic characteristics of fusarenon-X (FX) and its metabolite, nivalenol (NIV), in goats. The amounts of FX and NIV in post-mitochondrial (S-9), microsomal and cytosolic fractions of diverse tissues of the goat were also investigated. FX was intravenously (iv) or orally (po) administered to goats at dosages of 0.25 and 1 mg/kg bw, respectively. The concentrations of FX and NIV in plasma, feces and urine were quantified by liquid chromatography tandem-mass spectrometry (LC-ESI-MS/MS). The concentrations of FX in plasma were quantified up to 8 h with both routes of administration. A large amount of NIV (metabolite) was quantifiable in plasma, urine and feces after both administrations. The C_max value of FX was 413.39 ± 206.84 ng/ml after po administration. The elimination half-life values were 1.64 ± 0.32 h and 4.69 ± 1.25 h after iv and po administration, respectively. In vitro experiments showed that the conversion FX-to-NIV mainly occurs in the liver microsomal fraction. This is the first study that evaluates the fate and metabolism of FX in ruminant species.

Intestinal toxicity of the type B trichothecene mycotoxin fusarenon-X: whole transcriptome profiling reveals new signaling pathways

The few data available on fusarenon-X (FX) do not support the derivation of health-based guidance values, although preliminary results suggest higher toxicity than other regulated trichothecenes. Using histo-morphological analysis and whole transcriptome profiling, this study was designed to obtain a global view of the intestinal alterations induced by FX. Deoxynivalenol (DON) served as a benchmark. FX induced more severe histological alterations than DON. Inflammation was the hallmark of the molecular toxicity of both mycotoxins. The benchmark doses for the up-regulation of key inflammatory genes by FX were 4- to 45-fold higher than the previously reported values for DON. The transcriptome analysis revealed that both mycotoxins down-regulated the peroxisome proliferator-activated receptor (PPAR) and liver X receptor - retinoid X receptor (LXR-RXR) signaling pathways that control lipid metabolism. Interestingly, several pathways, including VDR/RXR activation, ephrin receptor signaling, and GNRH signaling, were specific to FX and thus discriminated the transcriptomic fingerprints of the two mycotoxins. These results demonstrate that FX induces more potent intestinal inflammation than DON. Moreover, although the mechanisms of toxicity of both mycotoxins are similar in many ways, this study emphasize specific pathways targeted by each mycotoxin, highlighting the need for specific mechanism-based risk assessments of Fusarium mycotoxins.

A Rapid Magnetic Solid Phase Extraction Method Followed by Liquid Chromatography-Tandem Mass Spectrometry Analysis for the Determination of Mycotoxins in Cereals

Mycotoxins can contaminate various food commodities, including cereals. Moreover, mycotoxins of different classes can co-contaminate food, increasing human health risk. Several analytical methods have been published in the literature dealing with mycotoxins determination in cereals. Nevertheless, in the present work, the aim was to propose an easy and effective system for the extraction of six of the main mycotoxins from corn meal and durum wheat flour, i.e., the main four aflatoxins, ochratoxin A, and the mycoestrogen zearalenone. The developed method exploited magnetic solid phase extraction (SPE), a technique that is attracting an increasing interest as an alternative to classical SPE. Therefore, the use of magnetic graphitized carbon black as a suitable extracting material was tested. The same magnetic material proved to be effective in the extraction of mycoestrogens from milk, but has never been applied to complex matrices as cereals. Ultra high–performance liquid chromatography tandem mass spectrometry was used for detection. Recoveries were >60% in both cereals, even if the matrix effects were not negligible. The limits of quantification of the method results were comparable to those obtained by other two magnetic SPE-based methods applied to cereals, which were limited to one or two mycotoxins, whereas in this work the investigated mycotoxins belonged to three different chemical classes.

Fluorescence Polarization Immunoassay Based on a New Monoclonal Antibody for the Detection of the Zearalenone Class of Mycotoxins in Maize

To develop a sensitive fluorescence polarization immunoassay (FPIA) for screening the zearalenone class of mycotoxins in maize, two new monoclonal antibodies with uniform affinity to the zearalenone class and four fluorescein-labeled tracers were prepared. After careful selection of appropriate tracer-antibody pairs in terms of sensitivity and specificity, a FPIA that could simultaneously detect the zearalenone class with similar sensitivity was developed. Under optimum conditions, the half maximal inhibitory concentrations of the FPIA in buffer were 1.89, 1.97, 2.43, 1.99, 2.27, and 2.44 μg/L for zearalenone, α-zearalenol, β-zearalenol, α-zearalanol, β-zearalanol, and zearalanone, respectively. The limit of detection of FPIA for the zearalenone class was around 12 μg/kg in maize, and the recoveries ranged from 84.6 to 113.8%, with coefficients of variation below 15.3% in spiked samples. Finally, the FPIA was applied for screening naturally contaminated maize samples, and the results indicated a good correlation with that of high-performance liquid chromatography-tandem mass spectrometry.

An overview of the toxicology and toxicokinetics of fusarenon-X, a type B trichothecene mycotoxin

Fusarenon-X (FX) is a type B trichothecene mycotoxin that is frequently observed along with deoxynivalenol (DON) and nivalenol (NIV) in agricultural commodities. This review aims to give an overview of the literature concerning the toxicology and toxicokinetics of FX. FX is primarily found in cereals grown in temperate regions, but it can also be found worldwide because of the global transport of products. The major toxicity of FX occurs through inhibition of protein synthesis, followed by the disruption of DNA synthesis. Moreover, FX has also been shown to induce apoptosis in in vitro and in vivo studies. The targets of FX are organs containing actively proliferating cells, such as the thymus, spleen, skin, small intestine, testes and bone marrow. FX causes immunosuppression, intestinal malabsorption, developmental toxicity and genotoxicity. In addition, sufficient evidence of carcinogenicity in experimental animals is currently lacking, and the International Agency for Research on Cancer (IARC) classifies it as a group 3 carcinogen.

Formation Ratios of Zearalanone, Zearalenols, and Zearalanols versus Zearalenone during Incubation of Fusarium semitectum on Sorghum and Ratios in Naturally Contaminated Sorghum

We incubated Fusarium semitectum on sorghum and measured the production of zearalenone (ZEN) and ZEN-related compounds (zearalanone (ZAN), α-zearalenol (α-ZEL), β-zearalenol (β-ZEL), α-zearalanol (α-ZAL) and β-zearalanol (β-ZAL)) in the culture by LC-MS. Of the five ZEN-related compounds, ZAN and β-ZEL were mainly detected. The concentrations of ZEN and the five ZEN-related compounds increased until 9 days after incubation and then increased slightly or stayed constant between days 9 and 15. The ratios of α-ZEL, β-ZEL, α-ZAL and β-ZAL to ZEN decreased in a similar manner after 7 days, whereas the ratio of ZAN to ZEN remained constant after 5 days. Analysis of naturally contaminated sorghum by LC-MS/MS revealed that the production ratio of α-ZEL to ZEN was inconsistent with that of our in vitro incubation analysis. The results indicate that ZAN might not be suitable for use as an internal standard.

Natural Co-Occurrence of Mycotoxins in Foods and Feeds and Their in vitro Combined Toxicological Effects

Some foods and feeds are often contaminated by numerous mycotoxins, but most studies have focused on the occurrence and toxicology of a single mycotoxin. Regulations throughout the world do not consider the combined effects of mycotoxins. However, several surveys have reported the natural co-occurrence of mycotoxins from all over the world. Most of the published data has concerned the major mycotoxins aflatoxins (AFs), ochratoxin A (OTA), zearalenone (ZEA), fumonisins (FUM) and trichothecenes (TCTs), especially deoxynivalenol (DON). Concerning cereals and derived cereal product samples, among the 127 mycotoxin combinations described in the literature, AFs+FUM, DON+ZEA, AFs+OTA, and FUM+ZEA are the most observed. However, only a few studies specified the number of co-occurring mycotoxins with the percentage of the co-contaminated samples, as well as the main combinations found. Studies of mycotoxin combination toxicity showed antagonist, additive or synergic effects depending on the tested species, cell model or mixture, and were not necessarily time- or dose-dependent. This review summarizes the findings on mycotoxins and their co-occurrence in various foods and feeds from all over the world as well as in vitro experimental data on their combined toxicity.

Natural occurrence, analysis, and prevention of mycotoxins in fruits and their processed products

Mycotoxins are small toxic chemical products formed as the secondary metabolites by fungi that readily contaminate foods with toxins in the field or after harvest. The presence of mycotoxins, such as aflatoxins, ochratoxin A, and patulin, in fruits and their processed products is of high concern for human health due to their properties to induce severe acute and chronic toxicity at low-dose levels. Currently, a broad range of detection techniques used for practical analysis and detection of a wide spectrum of mycotoxins are available. Many analytical methods have been developed for the determination of each group of these mycotoxins in different food matrices, but new methods are still required to achieve higher sensitivity and address other challenges that are posed by these mycotoxins. Effective technologies are needed to reduce or even eliminate the presence of the mycotoxins in fruits and their processed products. Preventive measures aimed at the inhibition of mycotoxin formation in fruits and their processed products are the most effective approach. Detoxification of mycotoxins by different physical, chemical, and biological methods are less effective and sometimes restricted because of concerns of safety, possible losses in nutritional quality of the treated commodities and cost implications. This article reviewed the available information on the major mycotoxins found in foods and feeds, with an emphasis of fruits and their processed products, and the analytical methods used for their determination. Based on the current knowledge, the major strategies to prevent or even eliminate the presence of the mycotoxins in fruits and their processed products were proposed.

High performance liquid chromatography tandem mass spectrometry determination of perfluorinated acids in cow milk

A new and sensitive liquid chromatography/electrospray-tandem mass spectrometric (LC/ESI-MS/MS) method for the determination of 12 perfluorinated compounds (PFCs) in cow milk is described. Milk samples were extracted with acetone and cleaned-up by a graphitized carbon black solid-phase extraction cartridge, optimizing the entire procedure by using a screening experimental design. LC/ESI-MS/MS was performed in negative ion mode using multiple reaction monitoring mode. The performance of the method was evaluated under the optimized conditions in terms of matrix effects, range of linearity, accuracy, and repeatability. For all compounds, linearity in matrix was observed in the range LOQ-10μgL(-1), and coefficients of determination R(2) ranged from 0.9982 to 0.9999. The analytical recoveries, relative to the isotopic internal standard, measured at 10 and 50ngL(-1) were in the range of 91-105%, with relative standard deviations below 6% and method detection limit, based on the blank value +3 times the standard deviation of the blank, ranged from 0.5 to 3ngL(-1). The final method developed was used to determine the concentration of PFCs in 15 retail milk samples. None of these compounds were detected in cow milk analyzed samples.

Analytical strategies based on chromatography-mass spectrometry for the determination of estrogen-mimicking compounds in food

Food safety can be compromised by the presence of a wide variety of substances, deriving from both natural and anthropogenic sources. Among these substances, compounds exhibiting various degrees of estrogenic activity have been widely studied in environmental samples, whereas less attention has been devoted to food matrices. The aim of the present review is to give a general overview on the recent analytical methods based on gas or liquid chromatography coupled to mass spectrometry for the determination of estrogen-like compounds in foods, including new developments, improvements and upcoming trends in the field. Attention will be focused on four representative groups of compounds, i.e. natural and synthetic estrogens, mycoestrogens, phytoestrogens, and alkylphenols.

Simultaneous determination of deoxynivalenol, and 15- and 3-acetyldeoxynivalenol in cereals by HPLC-UV detection

Fusarium head blight is an important cereal crop disease, which not only causes yield losses but also mycotoxin contamination in wheat and other cereal grains. Developing an accurate, rapid and efficient assay is critical to minimise the risk of Fusarium mycotoxins for human and animal health. In this study, HPLC with UV detection was used to separate and quantify deoxynivalenol, 15-acetyldeoxynivalenol and 3-acetyldeoxynivalenol in cereals. Samples were extracted with water, and the extracting solution was precipitated by adding an equal volume of ethanol followed by solid-phase extraction. The analytes were separated on a reversed-phase C18 column by a mobile phase composed of acetonitrile and 1 mM H3PO4 with gradient elution. 15- and 3-acetyldeoxynivalenol showed effective baseline separation. All analytes were well-resolved from matrix co-extractives and detected at 224 nm. The results showed good linearity of calibration curves (R2 ranged from 0.997 to 0.999) and excellent precision for inter- and intra-day determinations. Average recovery rates for the tested matrices ranged from 71 to 92%. The limits of detection and quantification ranged from 16 to 25 ng/g and 48 to 60 ng/g, respectively. The results indicate that the feasibility and practicality of the presented LC-UV method are excellent and that the method is suitable for routine analysis of DON and its acetyl derivatives in cereal grains.

Development of a simultaneous liquid chromatography/tandem mass spectrometric method for the determination of type B trichothecenes, their derivatives, and precursors in wheat

A method coupling liquid chromatography with tandem mass spectrometry (LC/MS/MS) was developed for the simultaneous quantitative determination of trichothecenes, nivalenol, deoxynivalenol, deoxynivalenol-3-glucoside, fusarenon-X, 3-acetyldeoxynivalenol, 15-acetyldeoxynivalenol, isotrichodermin, calonectrin, 3-deacetylcalonectrin, 15-deacetylcalonectrin, 3,15-diacetylnivalenol, 4,15-diacetylnivalenol, 3,15-diacetyldeoxynivalenol, and 3,4,15-triacetylnivalenol. The analytical parameters of trichothecenes and their derivatives were optimized to enable their highly sensitive detection. Evaluation of clean-up procedures using Multisep #226 and #227 indicated that Multisep #227 was more suitable for their simultaneous detection in wheat. In performance validation studies using the LC/MS/MS method with Multisep #227 cleanup, good recoveries ranging from 84% to 115% with relative standard deviations from 0.4% to 7.2% were measured. The limits of detection and quantification ranged from 0.03 to 1.4 ng·g(-1) and from 0.1 to 4.7 ng·g(-1) , respectively. The effect of matrices using matrix-matched calibration was estimated to range from 80% to 117% after Multisep #227 cleanup. Multisep #227 clean-up procedure with matrix-free standard calibration achieved accurate quantification without having a considerable effect on matrix compounds. Using the developed method, several trichothecene derivatives and precursors were detected in fungally inoculated wheat samples. The developed LC/MS/MS method is a practical technique that can be used for the quantification of trichothecenes in wheat. This study is the first report of an analytical method used for the simultaneous quantification of major trichothecenes, their derivatives and precursors.

Natural occurrence of type-B trichothecene mycotoxins in Korean cereal-based products

Type-B trichothecenes (deoxynivalenol (DON), nivalenol (NIV), fusarenone-X (FUS-X), 15-acetyldeoxynivalenol (15ADON), and 3-acetyldeoxynivalenol (3ADON)) were determined in 338 cereal-based products. Detection limit, quantification limit and mean recovery for five toxins were in the ranges 0.7-2.6 µg kg(-1), 2.1-7.8 µg kg(-1) and 73-110%, respectively. The range of occurrence and average level in samples were, respectively, 21-88% and 5.2-121.8 µg kg(-1) for NIV, 10-96% and 1.7-109.5 µg kg(-1) for DON, 2-39% and 0.4-3.6 µg kg(-1) for FUS-X, 0-80% and 0-17.3 µg kg(-1) for 15ADON, and 0-29% and 0-1.5 µg kg(-1) for 3ADON. Regarding co-occurrence, 64% of samples had more than two type-B trichothecenes. The estimated daily intakes of NIV, DON, FUS-X, 15ADON, and 3ADON were 0.077, 0.048, 0.004, 0.006 and 0.002 µg kg(-1) bw day(-1), respectively. These results suggest that current exposure levels do not indicate the possibility of adverse effects, but consideration of the combined exposure of type-B trichothecenes may be required due to the high frequency of co-occurrence.

Elisa and HPLC analyses of deoxynivalenol in maize and wheat

Deoxynivalenol (DON) is a part of the family of mycotoxins called trichothecenes which are produced by a number of different Fusarium mold species. The presence of DON in 25 wheat and 25 maize samples was examined by Enzyme Linked Immunosorbent Assay (ELISA) and High Performance Liquid Chromatography (HPLC) methods. The presence of DON was detected and determined in 5 (20%) maize and 6 (25%) wheat samples by both of the methods. Correlation between ELISA and HPLC results was established, with the correlation coefficients (r) of 0.9691 and 0.9735 for wheat and maize samples, respectively. The results obtained by ELISA method were significantly higher than those obtained by HPLC method. This fact can be explained by the presence of conjugated or masked mycotoxins in the samples, especially DON-3-glucoside (DON-3-Glc), which could not be determined by HPLC method due to the lack of external standards. Contrary to this, being insufficiently selective towards masked DON, ELISA method measures total DON content of a sample. According to the obtained results, ELISA can be used as a reliable screening method, but the confirmation of positive results must be done by HPLC method.

Cross-reactivity of antibodies in some commercial deoxynivalenol test kits against some fusariotoxins

Cross-reactivity of antibodies in AGRAQUANT, DON EIA, VERATOX, ROSA LF-DONQ, and MYCONTROLDON designed for deoxynivalenol (DON) determination in food and feedstuffs was evaluated against nivalenol, 3-acetylDON, 15-acetylDON, de-epoxy metabolite 1 of DON, DON-3β-glucoside, T2-toxin, HT2-toxin, fusarenone X, diacetoxyscirpenol, verrucarol, and zearalenone. Cross-reactivity measurements were run in water using the 50% reduction of absorbance of the blank for ELISA kits or through direct DON determination upon using the standards of mycotoxins via ROSA LF-DONQ or MYCONTROLDON. For the tested toxin concentrations, all DON kits have low cross-reactivity toward diacetoxyscirpenol, T2-toxin, HT2-toxin, verrucarol, and zearalenone and moderate cross-reactivity toward 15-AcetylDON and fusarenone X. AGRAQUANT, DON EIA, and VERATOX kits showed high cross-reactivity in various ranking orders against DON-3-Glc, DOM-1, and 3AcDON. DON EIA showed also high cross-reactivity against nivalenol and fusarenone X. These mycotoxins could coexist in food or feedstuffs, and analytical results can be wrongly interpreted. Cross-reactivity does not allow checking the compliance with the legal norms, but it does allow an overall risk assessment for the consumers. Updating regularly the cross-reactivity evaluation of the produced batches is recommended for 3-acetylDON, nivalenol, DON-3-Glc, de-epoxy metabolite 1, and fusarenone X.

Development and validation of a liquid chromatography/atmospheric pressure photoionization-tandem mass spectrometric method for the analysis of mycotoxins subjected to commission regulation (EC) No. 1881/2006 in cereals

A sensitive and reliable liquid chromatography/photoionization (APPI) tandem mass spectrometry method has been developed for determining nine selected mycotoxins in wheat and maize samples. The analytes were chosen on the basis of the mycotoxins under EU Commission Regulation (EC) No. 1881/2006, i.e., deoxynivalenol (DON), zearalenone (ZON), aflatoxins (AFs), and ochratoxin A (OTA), and considering the possibility of a near future regulation for T-2 and HT-2 toxins. Mycotoxins were extracted from samples by means of an one-step solvent extraction without any cleanup. The developed multi-mycotoxin method permits simultaneous, simple, and rapid determination of several co-existing toxins separated in a single chromatographic run, in which AFs, T-2 and HT-2 toxin are acquired in positive, while OTA, DON and ZON in negative mode. Although a moderate signal suppression was noticeable, matrix effect did not give significant differences at p=0.05. Then, calibration in standard solution were used for quantitation. Based on the EU Commission Decision 2002/657/EC, the method was in-house validated in terms of ruggedness, specificity, linearity, trueness, within-laboratory reproducibility, decision limit (CCalpha) and detection capability (CCbeta). For all the analytes, the regression coefficient r ranged between 0.8752 (DON in wheat) and 0.9465 (ZON in maize), biases related to mean concentrations were from -13% to +12% of the nominal spiking level, and the overall within-laboratory reproducibility ranged 3-16%; finally, CCalpha values did not differ more than 20% and CCbeta not more than 42% from their respective maximum limit. Method quantification limits ranged from 1/20 (AFG1) to 1/4 (AFG2 and OTA) the maximum limit established by European Union in the Commission Regulation (EC) No. 1881/2006 and its subsequent amendments.

Development and comparison of two multiresidue methods for the analysis of 17 mycotoxins in cereals by liquid chromatography electrospray ionization tandem mass spectrometry

Two multiresidue methods based on different extraction procedures have been developed and compared for the liquid chromatography electrospray ionization tandem mass spectrometry analysis of 17 mycotoxins including ochratoxin A, aflatoxins (B(1), B(2), G(1), and G(2)), zearalenone, fumonisins (B(1) and B(2)), T-2 toxin, HT-2 toxin, nivalenol, deoxynivalenol, 3- and 15-acetyldeoxynivalenol, fusarenon-X, diacetoxyscirpenol, and neosolaniol in cereal-based commodities. The extraction procedures considered were a QuEChERS-like method and one using accelerated solvent extraction (ASE). Both extraction procedures gave similar performances in terms of linearity (r(2) > 0.98) and precision (both RSD(r) and RSD(iR) < 20%). Trueness was evaluated through participation in four proficiency tests and by the analysis of two certified reference materials and one quality control material. Satisfactory Z scores (|Z| < 2) and trueness values (73-130%) were obtained by the proposed procedures. Limits of quantification were similar by both methods and were within the 1.0-2.0 microg/kg range for aflatoxins, 0.5 microg/kg for ochratoxin A, and the 5-100 microg/kg range for all other mycotoxins tested. The QuEChERS-like method was found to be easier to handle and allowed a higher sample throughput as compared to the ASE method.

LC-MS/MS multi-analyte method for mycotoxin determination in food supplements

A multi-analyte method for the liquid chromatography-tandem mass spectrometric determination of mycotoxins in food supplements is presented. The analytes included A and B trichothecenes (nivalenol, deoxynivalenol, 3-acetyldeoxynivalenol, 15-acetyldeoxynivalenol, neosolaniol, fusarenon-X, diacetoxyscirpenol, HT-2 toxin and T-2 toxin), aflatoxins (aflatoxin-B(1), aflatoxin-B(2), aflatoxin-G(1) and aflatoxin-G(2)), Alternaria toxins (alternariol, alternariol methyl ether and altenuene), fumonisins (fumonisin-B(1), fumonisin-B(2) and fumonisin-B(3)), ochratoxin A, zearalenone, beauvericin and sterigmatocystin. Optimization of the simultaneous extraction of these toxins and the sample pretreatment procedure, as well as method validation were performed on maca (Lepidium meyenii) food supplements. The results indicated that the solvent mixture ethyl acetate/formic acid (95:5, v/v) was the best compromise for the extraction of the analytes from food supplements. Liquid-liquid partition with n-hexane was applied as partial clean-up step to remove excess of co-extracted non-polar components. Further clean-up was performed on Oasis HLB cartridges. Samples were analysed using an Acquity UPLC system coupled to a Micromass Quattro Micro triple quadrupole mass spectrometer equipped with an electrospray interface operated in the positive-ion mode. Limits of detection and quantification were in the range of 0.3-30 ng g(-1) and 1-100 ng g(-1), respectively. Recovery yields were above 60% for most of the analytes, except for nivalenol, sterigmatocystine and the fumonisins. The method showed good precision and trueness. Analysis of different food supplements such as soy (Glycine max) isoflavones, St John's wort (Hypericum perforatum), garlic (Allium sativum), Ginkgo biloba, and black radish (Raphanus niger) demonstrated the general applicability of the method. Due to different matrix effects observed in different food supplement samples, the standard addition approach was applied to perform correct quantitative analysis. In 56 out of 62 samples analysed, none of the 23 mycotoxins investigated was detected. Positive samples contained at least one of the toxins fumonisin-B(1), fumonisin-B(2), fumonisin-B(3) and ochratoxin A.

An ultra-high-performance liquid chromatography-tandem mass spectrometry method for simultaneous determination of aflatoxins B1, B2, G1, G2, M1 and M2 in traditional Chinese medicines

An ultra-high-performance liquid chromatography-tandem mass spectrometry (UHPLC-MS/MS) method for simultaneous determination of aflatoxins B1, B2, G1, G2, M1 and M2 in traditional Chinese medicines (TCMs) was developed. The approach was characterized in details and a special focus was placed on the recovery rates of isolation procedure in different TCM matrices, i.e. rhizomes and roots, seeds, flowers, grasses and leaves. For this purpose, [(13)C(17)]-aflatoxinB1 was employed as the internal standard and a reliable solid phase extraction-based clean-up method was developed. The observed recovery rates of the six aflatoxins ranged from 85.6% to 117.6% in different matrices. Then, the established method was successfully applied to the determination of the six aflatoxins in various TCMs. For 30 commercial samples analyzed, 16 were contaminated with aflatoxins. The mean levels (incidence) of aflatoxins B1, B2, G1 and G2 in positive samples were 1.40 (68.8%), 1.27 (50.0%), 0.50 (43.8%) and 0.94 (43.8%) microg kg(-1), respectively. Interestingly, aflatoxin M1 was detected in two samples with the maximal content of 0.70 microg kg(-1). No sample was contaminated with aflatoxin M2. Meanwhile, a possible association between the contamination levels and the selected herbs was clarified in the present study.

Analytical methods for determination of mycotoxins: a review

Mycotoxins are small (MW approximately 700), toxic chemical products formed as secondary metabolites by a few fungal species that readily colonise crops and contaminate them with toxins in the field or after harvest. Ochratoxins and Aflatoxins are mycotoxins of major significance and hence there has been significant research on broad range of analytical and detection techniques that could be useful and practical. Due to the variety of structures of these toxins, it is impossible to use one standard technique for analysis and/or detection. Practical requirements for high-sensitivity analysis and the need for a specialist laboratory setting create challenges for routine analysis. Several existing analytical techniques, which offer flexible and broad-based methods of analysis and in some cases detection, have been discussed in this manuscript. There are a number of methods used, of which many are lab-based, but to our knowledge there seems to be no single technique that stands out above the rest, although analytical liquid chromatography, commonly linked with mass spectroscopy is likely to be popular. This review manuscript discusses (a) sample pre-treatment methods such as liquid-liquid extraction (LLE), supercritical fluid extraction (SFE), solid phase extraction (SPE), (b) separation methods such as (TLC), high performance liquid chromatography (HPLC), gas chromatography (GC), and capillary electrophoresis (CE) and (c) others such as ELISA. Further currents trends, advantages and disadvantages and future prospects of these methods have been discussed.

LC-MS/MS multi-method for mycotoxins after single extraction, with validation data for peanut, pistachio, wheat, maize, cornflakes, raisins and figs

Mycotoxin analysis is usually carried out by high performance liquid chromatography after immunoaffinity column cleanup or in enzyme-linked immunosorbent assay tests. These methods normally involve determination of single compounds only. EU legislation already exists for the aflatoxins, ochratoxin A and patulin in food, and legislation will come into force for deoxynivalenol, zearalenone and the fumonisins in 2007. To enforce the various legal limits, it would be preferable to determine all mycotoxins by routine analysis in different types of matrices in one single extract. This would also be advantageous for HACCP control purposes. For this reason, a multi-method was developed with which 33 mycotoxins in various products could be analysed simultaneously. The mycotoxins were extracted with an acetonitrile/water mixture, diluted with water and then directly injected into a LC-MS/MS system. The mycotoxins were separated by reversed-phase HPLC and detected using an electrospray ionisation interface (ESI) and tandem MS, using MRM in the positive ion mode, to increase specificity for quality control. The following mycotoxins could be analysed in a single 30-min run: Aflatoxins B1, B2, G1 and G2, ochratoxin A, deoxynivalenol, zearalenone, T-2 toxin, HT-2 toxin, alpha-zearalenol, alpha-zearalanol, beta-zearalanol, sterigmatocystin, cyclopiazonic acid, penicillic acid, fumonisins B1, B2 and B3, diacetoxyscirpenol, 3- and 15-acetyl-deoxynivalenol, zearalanone, ergotamin, ergocornin, ergocristin, alpha-ergocryptin, citrinin, roquefortin C, fusarenone X, nivalenol, mycophenolic acid, alternariol and alternariol monomethyl ether. The limit of quantification for the aflatoxins and ochratoxin A was 1.0 microg kg(-1) and for deoxynivalenol 50 microg kg(-1). The quantification limits for the other mycotoxins were in the range 10-200 microg kg(-1). The matrix effect and validation data are presented for between 13 and 24 mycotoxins in peanuts, pistachios, wheat, maize, cornflakes, raisins and figs. The method has been compared with the official EU method for the determination of aflatoxins in food and relevant FAPAS rounds. The multi-mycotoxin method has been proven by the detection of more than one mycotoxin in maize, buckwheat, figs and nuts. The LC-MS/MS technique has also been applied to baby food, which is subject to lower limits for aflatoxin B1 and ochratoxin A, ergot alkaloids in naturally contaminated rye and freeze-dried silage samples.

Fumonisins, trichothecenes and zearalenone in cereals

Fumonisins are phytotoxic mycotoxins which are synthesized by various species of the fungal genus Fusarium such as Fusarium verticillioides (Sacc.) Nirenberg (ex F.moniliforme Sheldon) and Fusarium proliferatum. The trichothecene (TC) mycotoxins are secondary metabolites produce by species that belong to several fungal genera, especially Fusarium, Stachybotrys, Trichothecium, Trichoderma, Memnoniella and Myrothecium. Fusarium mycotoxins are widely dispersed in cereals and their products. Zearalenone (ZEA) is an estrogenic compound produced by Fusarium spp. such as F. graminearum and F. culmorum. Fumonisins, the TCs and ZEA are hazardous for human and animal health. Contamination with TCs causes a number of illnesses in human and animal such as decrease in food consumption (anorexia), depression or inhibition on immune system function and haematoxicity. The purpose of this paper is to give a review of the papers published on the field of fumonisin, TC and ZEA mycotoxins in cereals consumed in the world.

Occurrence of deoxynivalenol in maize and wheat in Serbia

A total of 226 samples of maize and 59 of wheat from the 2004-2007 harvests were investigated for the presence and concentration of deoxynivalenol (DON). Samples of the 2004 harvest were analyzed after their storing for one year in barns, while those of the 2005-2007 harvest were taken directly off fields immediately after the harvest. The samples were analyzed by liquid chromatography on an ODS Hypersil column with DAD detector and ELISA methods. The average incidence rate of DON in maize from the 2004 harvest was 50% (concentration range 0.042-2.460 mg/kg, average value 0.536 mg/kg), while for those of the 2005-2007 harvest it was 32.4% (concentration range 0.027-2.210 mg/kg, average value 0.223 mg/kg). In the case of wheat incidence rate of DON for 2004 harvest was 50.0% (concentration range 0.630-1.840 mg/kg, average value 1.235 mg/kg), while for those of the 2005-2007 harvest it was 34.5% (concentration range 0.057-0.423 mg/kg, average value 0.190 mg/kg). Concentrations in two samples of maize and one of wheat (one sample of each cereal being of the 2004 harvest) were above the maximum level adopted by the European Commission. The results obtained were analyzed as a function of climatic conditions and compared with those of the neighboring countries where the relevant data existed.