Kinetics of osmotic water movement in chondrocytes isolated from articular cartilage and applications to cryopreservation

Model-Guided Design and Optimization of CPA Perfusion Protocols for Whole Organ Cryopreservation

Vitrification could enable long-term organ preservation, but only after loading high-concentration, potentially toxic cryoprotective agents (CPAs) by perfusion. In this paper, we combine a two-compartment Krogh cylinder model with a toxicity cost function to theoretically optimize the loading of CPA (VMP) in rat kidneys as a model system. First, based on kidney perfusion experiments, we systematically derived the parameters for a CPA transport loading model, including the following: Vb = 86.0% (ra = 3.86 μm), Lp = 1.5 × 10-14 m3/(N·s), ω = 7.0 × 10-13 mol/(N·s), σ = 0.10. Next, we measured the toxicity cost function model parameters as α = 3.12 and β = 9.39 × 10-6. Combining these models, we developed an improved kidney-loading protocol predicted to achieve vitrification while minimizing toxicity. The optimized protocol resulted in shorter exposure (25 min or 18.5% less) than the gold standard kidney-loading protocol for VMP, which had been developed based on decades of empirical practice. After testing both protocols on rat kidneys, we found comparable physical and biological outcomes. While we did not dramatically reduce toxicity, we did reduce the time. As our approach is now validated, it can be used on other organs lacking defined toxicity data to reduce CPA exposure time and provide a rapid path toward developing CPA perfusion protocols for other organs and CPAs.

Superficial zone chondrocytes can get compacted under physiological loading: A multiscale finite element analysis

Recent in vivo and in vitro studies have demonstrated that superficial zone (SZ) chondrocytes within articular layers of diarthrodial joints die under normal physiologic loading conditions. In order to further explore the implications of this observation in future investigations, we first needed to understand the mechanical environment of SZ chondrocytes that might cause them to die under physiological sliding contact conditions. In this study we performed a multiscale finite element analysis of articular contact to track the temporal evolution of a SZ chondrocyte's interstitial fluid pressure, hydraulic permeability, and volume under physiologic loading conditions. The effect of the pericellular matrix modulus and permeability was parametrically investigated. Results showed that SZ chondrocytes can lose ninety percent of their intracellular fluid after several hours of intermittent or continuous contact loading, resulting in a reduction of intracellular hydraulic permeability by more than three orders of magnitude. These findings are consistent with loss of cell viability due to the impediment of cellular metabolic pathways induced by the loss of fluid. They suggest that there is a simple mechanical explanation for the vulnerability of SZ chondrocytes to sustained physiological loading conditions. Future studies will focus on validating these specific findings experimentally. STATEMENT OF SIGNIFICANCE: As with any mechanical system, normal 'wear and tear' of cartilage tissue lining joints is expected. Yet incidences of osteoarthritis are uncommon in individuals younger than 45. This counter-intuitive observation suggests there must be an intrinsic repair mechanism compensating for this wear and tear over many decades of life. Recent experimental studies have shown superficial zone chondrocytes die under physiologic loading conditions, suggesting that this repair mechanism may involve cell replenishment. To better understand the mechanical environment of these cells, we performed a multiscale computational analysis of articular contact under loading. Results indicated that normal activities like walking or standing can induce significant loss of intracellular fluid volume, potentially hindering metabolic activity and fluid transport properties, and causing cell death.

The non-contact-based determination of the membrane permeability to water and dimethyl sulfoxide of cells virtually trapped in a self-induced micro-vortex

The cell-membrane permeabilities of a cell type toward water (L_p) and cryoprotective agents (P_s) provide crucial cellular information for achieving optimal cryopreservation in the biobanking industry. In this work, cell membrane permeability was successfully determined via directly visualizing the transient profile of the cell volume change in response to a sudden osmotic gradient instantaneously applied between the intracellular and extracellular environments. A new micro-vortex system was developed to virtually trap the cells of interest in flow-driven hydrodynamic circulation passively formed at the expansion region in a microfluidic channel, where trapped cells remain in suspension and flow with the streamline of the localized vortex, involving no physical contact between cells and the device structure; furthermore, this supports a pragmatic assumption of 100% sphericity and allows for the calculation of the active surface area of the cell membrane for estimating the actual cell volume from two-dimensional images. For an acute T-cell lymphoma cell line (Jurkat), moderately higher values (L_p = 0.34 μm min^-1 atm^-1 for a binary system, and L_p = 0.16 μm min^-1 atm^-1 and P_s = 0.55 × 10^-3 cm min^-1 for a ternary system) were measured than those obtained from prior methods utilizing contact-based cell-trapping techniques, manifesting the influence of physical contact on accuracy during the determination of cell membrane permeability.

General tissue mass transfer model for cryopreservation applications

Successful cryopreservation of complex specimens, such as tissues and organs, would greatly benefit both the medical and scientific research fields. Vitrification is one of the most promising techniques for complex specimen cryopreservation, but toxicity remains a major challenge because of the high concentration of cryoprotectants (CPAs) needed to vitrify. Our group has approached this problem using mathematical optimization to design less toxic CPA equilibration methods for cells. To extend this approach to tissues, an appropriate mass transfer model is required. Fick's law is commonly used, but this simple modeling framework does not account for the complexity of mass transfer in tissues, such as the effects of fixed charges, tissue size changes, and the interplay between cell membrane transport and transport through the extracellular fluid. Here, we propose a general model for mass transfer in tissues that accounts for all of these phenomena. To create this model, we augmented a previously published acellular model of mass transfer in articular cartilage to account for the effects of cells. We show that the model can accurately predict changes in CPA concentration and tissue size for both articular cartilage and pancreatic islets, tissue types with vastly different properties.

Cryopreservation of buffy coat derived platelets: Paired in vitro characterization using uncontrolled versus controlled freezing rate protocols

Background

Cryopreserved platelets show a reduced recovery and viability after freezing and thawing including several ultrastructural and phenotypic deteriorations compared with liquid‐stored platelets. It is suggested that using Controlled‐Rate Freezing (CRF) can reduce variability and optimize the functionality profile for cells. The objective of the study is to compare cellular, metabolic, phenotypic and functional effects on platelets after cryopreservation using different freezing rate protocols.

Study Design and Methods

To evaluate the possible effects of different freezing rate protocols a two‐experimental study comparing diverse combinations was tested with a pool and split design. Uncontrolled freezing of platelets in materials with different thermal conductivity (metal vs cardboard) was evaluated in experiment 1. Experiment 2 evaluated uncontrolled vs a controlled‐rate freezing protocol in metal boxes. All variables were assessed pre and post cryopreservation.

Results

Directly after thawing, no major differences in platelet recovery, LDH, ATP, Δψ, CD62P, CD42b, platelet endothelial cell adhesion molecule and sCD40L were seen between units frozen with different thermal conductivity for temperature. In contrast, we observed signs of increased activation after freezing using the CRF protocol, reflected by increased cell surface expression of CD62P, PAC‐1 binding and increased concentration of LDH. Agonist induced expression of a conformational epitope on the GPIIb/IIIa complex and contribution to blood coagulation in an experimental rotational thromboelastometry setup were not statistically different between the groups.

Conclusion

The use of a uncontrolled freezing rate protocol is feasible, creating a platelet product comparable to using a controlled rate freezing equipment during cryopreservation of platelets.

Combined effects of oscillating hydrostatic pressure, perfusion and encapsulation in a novel bioreactor for enhancing extracellular matrix synthesis by bovine chondrocytes

The influence of combined shear stress and oscillating hydrostatic pressure (OHP), two forms of physical forces experienced by articular cartilage (AC) in vivo, on chondrogenesis, is investigated in a unique bioreactor system. Our system introduces a single reaction chamber design that does not require transfer of constructs after seeding to a second chamber for applying the mechanical forces, and, as such, biochemical and mechanical stimuli can be applied in combination. The biochemical and mechanical properties of bovine articular chondrocytes encapsulated in agarose scaffolds cultured in our bioreactors for 21 days are compared to cells statically cultured in agarose scaffolds in addition to static micromass and pellet cultures. Our findings indicate that glycosaminoglycan and collagen secretions were enhanced by at least 1.6-fold with scaffold encapsulation, 5.9-fold when adding 0.02 Pa of shear stress and 7.6-fold with simultaneous addition of 4 MPa of OHP when compared to micromass samples. Furthermore, shear stress and OHP have chondroprotective effects as evidenced by lower mRNA expression of β1 integrin and collagen X to non-detectable levels and an absence of collagen I upregulation as observed in micromass controls. These collective results are further supported by better mechanical properties as indicated by 1.6-19.8-fold increases in elastic moduli measured by atomic force microscopy.

Investigation of the Effects of Extracellular Osmotic Pressure on Morphology and Mechanical Properties of Individual Chondrocyte

It has been demonstrated that most cells of the body respond to osmotic pressure in a systematic manner. The disruption of the collagen network in the early stages of osteoarthritis causes an increase in water content of cartilage which leads to a reduction of pericellular osmolality in chondrocytes distributed within the extracellular environment. It is therefore arguable that an insight into the mechanical properties of chondrocytes under varying osmotic pressure would provide a better understanding of chondrocyte mechanotransduction and potentially contribute to knowledge on cartilage degeneration. In this present study, the chondrocyte cells were exposed to solutions with different osmolality. Changes in their dimensions and mechanical properties were measured over time. Atomic force microscopy (AFM) was used to apply load at various strain-rates and the force-time curves were logged. The thin-layer elastic model was used to extract the elastic stiffness of chondrocytes at different strain-rates and at different solution osmolality. In addition, the porohyperelastic (PHE) model was used to investigate the strain-rate-dependent responses under the loading and osmotic pressure conditions. The results revealed that the hypo-osmotic external environment increased chondrocyte dimensions and reduced Young's modulus of the cells at all strain-rates tested. In contrast, the hyper-osmotic external environment reduced dimensions and increased Young's modulus. Moreover, using the PHE model coupled with inverse FEA simulation, we established that the hydraulic permeability of chondrocytes increased with decreasing extracellular osmolality which is consistent with previous work in the literature. This could be due to a higher intracellular fluid volume fraction with lower osmolality.

Non-ideal solution thermodynamics of cytoplasm

Quantitative description of the non-ideal solution thermodynamics of the cytoplasm of a living mammalian cell is critically necessary in mathematical modeling of cryobiology and desiccation and other fields where the passive osmotic response of a cell plays a role. In the solution thermodynamics osmotic virial equation, the quadratic correction to the linear ideal, dilute solution theory is described by the second osmotic virial coefficient. Herein we report, for the first time, intracellular solution second osmotic virial coefficients for four cell types [TF-1 hematopoietic stem cells, human umbilical vein endothelial cells (HUVEC), porcine hepatocytes, and porcine chondrocytes] and further report second osmotic virial coefficients indistinguishable from zero (for the concentration range studied) for human hepatocytes and mouse oocytes.

Extracellular matrix integrity affects the mechanical behaviour of in-situ chondrocytes under compression

Cartilage lesions change the microenvironment of cells and may accelerate cartilage degradation through catabolic responses from chondrocytes. In this study, we investigated the effects of structural integrity of the extracellular matrix (ECM) on chondrocytes by comparing the mechanics of cells surrounded by an intact ECM with cells close to a cartilage lesion using experimental and numerical methods. Experimentally, 15% nominal compression was applied to bovine cartilage tissues using a light-transmissible compression system. Target cells in the intact ECM and near lesions were imaged by dual-photon microscopy. Changes in cell morphology (N(cell)=32 for both ECM conditions) were quantified. A two-scale (tissue level and cell level) Finite Element (FE) model was also developed. A 15% nominal compression was applied to a non-linear, biphasic tissue model with the corresponding cell level models studied at different radial locations from the centre of the sample in the transient phase and at steady state. We studied the Green-Lagrange strains in the tissue and cells. Experimental and theoretical results indicated that cells near lesions deform less axially than chondrocytes in the intact ECM at steady state. However, cells near lesions experienced large tensile strains in the principal height direction, which are likely associated with non-uniform tissue radial bulging. Previous experiments showed that tensile strains of high magnitude cause an up-regulation of digestive enzyme gene expressions. Therefore, we propose that cartilage degradation near tissue lesions may be due to the large tensile strains in the principal height direction applied to cells, thus leading to an up-regulation of catabolic factors.

Cryopreservation of articular cartilage

Cryopreservation has numerous practical applications in medicine, biotechnology, agriculture, forestry, aquaculture and biodiversity conservation, with huge potentials for biological cell and tissue banking. A specific tissue of interest for cryopreservation is the articular cartilage of the human knee joint for two major reasons: (1) clinically, there exists an untapped potential for cryopreserved cartilage to be used in surgical repair/reconstruction/replacement of injured joints because of the limited availability of fresh donor tissue and, (2) scientifically, successful cryopreservation of cartilage, an avascular tissue with only one cell type, is considered a stepping stone for transition from biobanking cell suspensions and small tissue slices to larger and more complicated tissues. For more than 50years, a great deal of effort has been directed toward understanding and overcoming the challenges of cartilage preservation. In this article, we focus mainly on studies that led to the finding that vitrification is an appropriate approach toward successful preservation of cartilage. This is followed by a review of the studies on the main challenges of vitrification, i.e. toxicity and diffusion, and the novel approaches to overcome these challenges such as liquidus tracking, diffusion modeling, and cryoprotective agent cocktails, which have resulted in the recent advancements in the field.

Transport phenomena in articular cartilage cryopreservation as predicted by the modified triphasic model and the effect of natural inhomogeneities

Knowledge of the spatial and temporal distribution of cryoprotective agent (CPA) is necessary for the cryopreservation of articular cartilage. Cartilage dehydration and shrinkage, as well as the change in extracellular osmolality, may have a significant impact on chondrocyte survival during and after CPA loading, freezing, and thawing, and during CPA unloading. In the literature, Fick's law of diffusion is commonly used to predict the spatial distribution and overall concentration of the CPA in the cartilage matrix, and the shrinkage and stress-strain in the cartilage matrix during CPA loading are neglected. In this study, we used a previously described biomechanical model to predict the spatial and temporal distributions of CPA during loading. We measured the intrinsic inhomogeneities in initial water and fixed charge densities in the cartilage using magnetic resonance imaging and introduced them into the model as initial conditions. We then compared the prediction results with the results obtained using uniform initial conditions. The simulation results in this study demonstrate the presence of a significant mechanical strain in the matrix of the cartilage, within all layers, during CPA loading. The osmotic response of the chondrocytes to the cartilage dehydration during CPA loading was also simulated. The results reveal that a transient shrinking occurs to different levels, and the chondrocytes experience a significant decrease in volume, particularly in the middle and deep zones of articular cartilage, during CPA loading.

Dependence of zonal chondrocyte water transport properties on osmotic environment

OBJECTIVE: The increasing concentration of proteoglycans from the surface to the deep zone of articular cartilage produces a depth-dependent gradient in fixed charge density, and therefore extracellular osmolarity, which may vary with loading conditions, growth and development, or disease. In this study we examine the relationship between in situ variations in osmolarity on chondrocyte water transport properties. Chondrocytes from the depth-dependent zones of cartilage, effectively preconditioned in varying osmolarities, were used to probe this relationship. DESIGN: First, depth variation in osmolarity of juvenile bovine cartilage under resting and loaded conditions was characterized using a combined experimental/theoretical approach. Zonal chondrocytes were isolated into two representative "baseline" osmolarities chosen from this analysis to reflect in situ conditions. Osmotic challenge was then used as a tool for determination of water transport properties at each of these baselines. Cell calcium signaling was monitored simultaneously as a preliminary examination of osmotic baseline effects on cell signaling pathways. RESULTS: Osmotic baseline exhibits a significant effect on the cell membrane hydraulic permeability of certain zonal subpopulations but not on cell water content or incidence of calcium signaling. CONCLUSIONS: Chondrocyte properties can be sensitive to changes in baseline osmolarity, such as those occurring during OA progression (decrease) and de novo tissue synthesis (increase). Care should be taken in comparing chondrocyte properties across zones when cells are tested in vitro in non-physiologic culture media.

Importance of collagen orientation and depth-dependent fixed charge densities of cartilage on mechanical behavior of chondrocytes

The collagen network and proteoglycan matrix of articular cartilage are thought to play an important role in controlling the stresses and strains in and around chondrocytes, in regulating the biosynthesis of the solid matrix, and consequently in maintaining the health of diarthrodial joints. Understanding the detailed effects of the mechanical environment of chondrocytes on cell behavior is therefore essential for the study of the development, adaptation, and degeneration of articular cartilage. Recent progress in macroscopic models has improved our understanding of depth-dependent properties of cartilage. However, none of the previous works considered the effect of realistic collagen orientation or depth-dependent negative charges in microscopic models of chondrocyte mechanics. The aim of this study was to investigate the effects of the collagen network and fixed charge densities of cartilage on the mechanical environment of the chondrocytes in a depth-dependent manner. We developed an anisotropic, inhomogeneous, microstructural fibril-reinforced finite element model of articular cartilage for application in unconfined compression. The model consisted of the extracellular matrix and chondrocytes located in the superficial, middle, and deep zones. Chondrocytes were surrounded by a pericellular matrix and were assumed spherical prior to tissue swelling and load application. Material properties of the chondrocytes, pericellular matrix, and extracellular matrix were obtained from the literature. The loading protocol included a free swelling step followed by a stress-relaxation step. Results from traditional isotropic and transversely isotropic biphasic models were used for comparison with predictions from the current model. In the superficial zone, cell shapes changed from rounded to elliptic after free swelling. The stresses and strains as well as fluid flow in cells were greatly affected by the modulus of the collagen network. The fixed charge density of the chondrocytes, pericellular matrix, and extracellular matrix primarily affected the aspect ratios (height/width) and the solid matrix stresses of cells. The mechanical responses of the cells were strongly location and time dependent. The current model highlights that the collagen orientation and the depth-dependent negative fixed charge densities of articular cartilage have a great effect in modulating the mechanical environment in the vicinity of chondrocytes, and it provides an important improvement over earlier models in describing the possible pathways from loading of articular cartilage to the mechanical and biological responses of chondrocytes.

Osmolarity influences chondrocyte death in wounded articular cartilage

BACKGROUND

Mechanical injury results in chondrocyte death in articular cartilage. The purpose of the present study was to determine whether medium osmolarity affects chondrocyte death in injured articular cartilage.

METHODS

Osteochondral explants (n = 48) that had been harvested from the metacarpophalangeal joints of three-year-old cows were exposed to media with varying osmolarity (0 to 480 mOsm) for ninety seconds to allow in situ chondrocytes to respond to the altered osmotic environment. Explants were then wounded with a scalpel through the full thickness of articular cartilage, incubated in the same media for 2.5 hours, and transferred to 340-mOsm Dulbecco's Modified Eagle Medium (control medium) with further incubation for seven days. The spatial distribution of in situ chondrocyte death, percentage cell death, and marginal cell death at the wounded cartilage edge were compared as a function of osmolarity and time (2.5 hours compared with seven days) with use of confocal laser scanning microscopy.

RESULTS

In situ chondrocyte death was mainly localized to the superficial tangential zone of injured articular cartilage for the range of medium osmolarities (0 to 480 mOsm) at 2.5 hours and seven days. Therefore, a sample of articular cartilage from the superficial region (which included the scalpel-wounded cartilage edge) was studied with use of confocal laser scanning microscopy to compare the effects of osmolarity on percentage and marginal cell death in the superficial tangential zone. Compared with the control explants exposed to 340-mOsm Dulbecco's Modified Eagle Medium, percentage cell death in the superficial tangential zone was greatest for explants exposed to 0-mOsm (distilled water) and least for explants exposed to 480-mOsm Dulbecco's Modified Eagle Medium at 2.5 hours (13.0% at 340 mOsm [control], 35.5% at 0 mOsm, and 4.3% at 480 mOsm; p <or= 0.02 for paired comparisons) and seven days (9.9% at 340 mOsm [control], 37.7% at 0 mOsm, and 3.5% at 480 mOsm; p <or= 0.01 for paired comparisons). Marginal cell death in the superficial tangential zone decreased with increasing medium osmolarity at 2.5 hours (p = 0.001) and seven days (p = 0.002). There was no significant change in percentage cell death from 2.5 hours to seven days for explants initially exposed to any of the medium osmolarities.

CONCLUSIONS

Medium osmolarity significantly affects chondrocyte death in wounded articular cartilage. The greatest chondrocyte death occurs at 0 mOsm. Conversely, increased medium osmolarity (480 mOsm) is chondroprotective. The majority of cell death occurs within 2.5 hours, with no significant increase over seven days.

An Application of Stream Imaging Technique in the Study of Osmotic Behaviors of Multiple Cells

Light microscopy method offers unique abilities for the determination of membrane transport properties of either single or multiple cells. A stream imaging system composed of a microfluidic device, a charge-coupled device camera, and a microscope has been developed to study the osmotic behavior of multiple cells in response toward their extracellular environment. Cells of interest were first mixed with the desired extracellular medium and streamed into a microchannel. The microchannel confines the movement of the cells in a monolayer and allows cells to move along the flow direction only. The cells then pass through a sensing zone where the images of cells were capable of being captured under a microscope. Using mouse dendritic cells (mDCs) as a model system, the membrane transport properties were investigated. The kinetics volume changes of mDCs under various extracellular conditions at room temperature (22°C) were analyzed using a biophysical model to determine water and cryoprotectant transport properties of the cell membrane. This prototype system directly allows us to observe, trace, capture, and store the sample information in terms of number, concentration, dynamic size, or shape for further analyses and documentations. We believe that the system has the potential of being used as a stand-alone equipment, or integrated into a lab-on-a-chip system, or embedded into commercialized instruments.

The osmotic sensitivity of rat growth plate chondrocytes in situ; clarifying the mechanisms of hypertrophy

Bone elongation is predominantly driven by the volume expansion of growth plate chondrocytes. This mechanism was initially believed to be "hypertrophy", describing a proportional increase of cell water and organelles. However, morphometrical analysis subsequently assumed the increase to be "swelling", resulting in a disproportionate increase of cell water (osmotically active fraction). Histological approaches were performed on fixed tissue, and for the "swelling" assumption to be valid, the osmotic sensitivity of living cells before and during volume increase should differ. To test this, analysis of images acquired by 2-photon laser scanning microscopy (2PLSM) were used to determine the osmotic sensitivity, and osmotically active/inactive proportions of in situ chondrocytes from 15 living rat growth plates exposed to varying media osmolarities ( approximately 0-580 mOsm). The dimensions of cell volume swelling in hypotonic media were different to the preferential lengthening seen in vivo, confirming the complexity of directional cell volume increase. Boyle-van't Hoff analysis of cell volume over the range of media osmolarity indicated no significant difference (Student's t-test) in the osmotically inactive fraction, 39.5 +/- 2.9% and 47.0 +/- 4.3% (n = 13) for proliferative and hypertrophic zones, respectively, or the sensitivity of volume to changes in media osmolarity (proliferative 15.5 +/- 0.8 and hypertrophic zone 15.5 +/- 1.2%volume . Osm). The osmotic fractions did not change as chondrocytes progress from proliferative to hypertrophic regions of the growth plate. Our data suggest cell volume increase by hypertrophy may play a greater role in cell enlargement than swelling, and should be re-evaluated as a mechanism responsible for growth plate chondrocyte volume increase and hence bone elongation.

Development of a microfluidic device for determination of cell osmotic behavior and membrane transport properties

An understanding of cell osmotic behavior and membrane transport properties is indispensable for cryobiology research and development of cell-type-specific, optimal cryopreservation conditions. A microfluidic perfusion system is developed here to measure the kinetic changes of cell volume under various extracellular conditions, in order to determine cell osmotic behavior and membrane transport properties. The system is fabricated using soft lithography and is comprised of microfluidic channels and a perfusion chamber for trapping cells. During experiments, rat basophilic leukemia (RBL-1 line) cells were injected into the inlet of the device, allowed to flow downstream, and were trapped within a perfusion chamber. The fluid continues to flow to the outlet due to suction produced by a Hamilton Syringe. Two sets of experiments have been performed: the cells were perfused by (1) hypertonic solutions with different concentrations of non-permeating solutes and (2) solutions containing a permeating cryoprotective agent (CPA), dimethylsulfoxide (Me(2)SO), plus non-permeating solute (sodium chloride (NaCl)), respectively. From experiment (1), cell osmotically inactive volume (V(b)) and the permeability coefficient of water (L(p)) for RBL cells are determined to be 41% [n=18, correlation coefficient (r(2)) of 0.903] of original/isotonic volume, and 0.32+/-0.05 microm/min/atm (n=8, r(2)>0.963), respectively, for room temperature (22 degrees C). From experiment (2), the permeability coefficient of water (L(p)) and of Me(2)SO (P(s)) for RBL cells are 0.38+/-0.09 microm/min/atm and (0.49+/-0.13) x 10(-3)cm/min (n=5, r(2)>0.86), respectively. We conclude that this device enables us to: (1) readily monitor the changes of extracellular conditions by perfusing single or a group of cells with prepared media; (2) confine cells (or a cell) within a monolayer chamber, which prevents imaging ambiguity, such as cells overlapping or moving out of the focus plane; (3) study individual cell osmotic response and determine cell membrane transport properties; and (4) reduce labor requirements for its disposability and ensure low manufacturing costs.

Cryopreservation of articular cartilage. Part 1: Conventional cryopreservation methods

There is increasing interest in the possibility of treating diseased or damaged areas of synovial joint surfaces by grafts of healthy allogeneic cartilage. Such grafts could be obtained from cadaver tissue donors or in the future they might be manufactured by 'tissue engineering' methods. Cartilage is an avascular tissue and hence is immunologically privileged but to take advantage of this is the graft must contain living cells. Preservation methods that achieve this are required to build up operational stocks of grafts, to provide a buffer between procurement and use, and to enable living grafts of a practical size to be provided at the right time for patient and surgeon. Review of the literature shows that it has been relatively straightforward to cryopreserve living isolated chondrocytes, but at the present time there is no satisfactory method to preserve cartilage between the time of procurement or manufacture and surgical use. In this paper, we review the relevant literature and we confirm that isolated ovine chondrocytes in suspension can be effectively cryopreserved by standard methods yet the survival of chondrocytes in situ in cartilage tissue is inadequate and extremely variable.

A theoretical analysis of water transport through chondrocytes

Because of the avascular nature of adult cartilage, nutrients and waste products are transported to and from the chondrocytes by diffusion and convection through the extracellular matrix. The convective interstitial fluid flow within and around chondrocytes is poorly understood. This theoretical study demonstrates that the incorporation of a semi-permeable membrane when modeling the chondrocyte leads to the following findings: under mechanical loading of an isolated chondrocyte the intracellular fluid pressure is on the order of tens of Pascals and the transmembrane fluid outflow, on the order of picometers per second, takes several days to subside; consequently, the chondrocyte behaves practically as an incompressible solid whenever the loading duration is on the order of minutes or hours. When embedded in its extracellular matrix (ECM), the chondrocyte response is substantially different. Mechanical loading of the tissue leads to a fluid pressure difference between intracellular and extracellular compartments on the order of tens of kilopascals and the transmembrane outflow, on the order of a nanometer per second, subsides in about 1 h. The volume of the chondrocyte decreases concomitantly with that of the ECM. The interstitial fluid flow in the extracellular matrix is directed around the cell, with peak values on the order of tens of nanometers per second. The viscous fluid shear stress acting on the cell surface is several orders of magnitude smaller than the solid matrix shear stresses resulting from the ECM deformation. These results provide new insight toward our understanding of water transport in chondrocytes.

A mechano-chemical model for the passive swelling response of an isolated chondron under osmotic loading

The chondron is a distinct structure in articular cartilage that consists of the chondrocyte and its pericellular matrix (PCM), a narrow tissue region surrounding the cell that is distinguished by type VI collagen and a high glycosaminoglycan concentration relative to the extracellular matrix. We present a theoretical mechano-chemical model for the passive volumetric response of an isolated chondron under osmotic loading in a simple salt solution at equilibrium. The chondrocyte is modeled as an ideal osmometer and the PCM model is formulated using triphasic mixture theory. A mechano-chemical chondron model is obtained assuming that the chondron boundary is permeable to both water and ions, while the chondrocyte membrane is selectively permeable to only water. For the case of a neo-Hookean PCM constitutive law, the model is used to conduct a parametric analysis of cell and chondron deformation under hyper- and hypo-osmotic loading. In combination with osmotic loading experiments on isolated chondrons, model predictions will aid in determination of pericellular fixed charge density and its relative contribution to PCM mechanical properties.

Cryopreservation and biophysical properties of articular cartilage chondrocytes

In order to successfully cryopreserve articular cartilage chondrocytes, it is important to characterize their osmotic response during the cryopreservation process, as the ice forms and the solutes concentrate. In this study, experimental work was undertaken to determine the osmotic parameters of articular cartilage chondrocytes. The osmotically inactive volume of articular cartilage chondrocytes was determined to be 44% of the isotonic volume. The membrane hydraulic conductivity parameters for water were determined by fitting a theoretical water transport model to the experimentally obtained volumetric shrinkage data; the membrane hydraulic conductivity parameter L(Pg) was found to be 0.0633 microm/min/atm, and the activation energy E, 8.23 kcal/mol. The simulated cooling process, using the osmotic parameters obtained in this study, suggests a cooling rate of 80 degrees C/min for the cryopreservation of the articular cartilage chondrocytes of hogs. The data obtained in this study could serve as a starting point for those interested in cryopreservation of chondrocytes from articular cartilage in other species in which there is clinical interest and there are no parameters for prediction of responses.

Biopreservation of cells and engineered tissues

The development of effective preservation and long-term storage techniques is a critical requirement for the successful clinical and commercial application of emerging cell-based technologies. Biopreservation is the process of preserving the integrity and functionality of cells, tissues and organs held outside the native environment for extended storage times. Biopreservation can be categorized into four different areas on the basis of the techniques used to achieve biological stability and to ensure a viable state following long-term storage. These include in vitro culture, hypothermic storage, cryopreservation and desiccation. In this chapter, an overview of these four techniques is presented with an emphasis on the recent developments that have been made using these technologies for the biopreservation of cells and engineered tissues.

Chondrocyte mechanotransduction: effects of compression on deformation of intracellular organelles and relevance to cellular biosynthesis

OBJECTIVE

The effects of mechanical deformation of intact cartilage tissue on chondrocyte biosynthesis in situ have been well documented, but the mechanotransduction pathways that regulate such phenomena have not been elucidated completely. The goal of this study was to examine the effects of tissue deformation on the morphology of a range of intracellular organelles which play a major role in cell biosynthesis and metabolism.

DESIGN

Using chemical fixation, high pressure freezing, and electron microscopy, we imaged chondrocytes within mechanically compressed cartilage explants at high magnification and quantitatively and qualitatively assessed changes in organelle volume and shape caused by graded levels of loading.

RESULTS

Compression of the tissue caused a concomitant reduction in the volume of the extracellular matrix (ECM), chondrocyte, nucleus, rough endoplasmic reticulum, and mitochondria. Interestingly, however, the Golgi apparatus was able to resist loss of intraorganelle water and retain a portion of its volume relative to the remainder of the cell. These combined results suggest that a balance between intracellular mechanical and osmotic gradients govern the changes in shape and volume of the organelles as the tissue is compressed.

CONCLUSIONS

Our results lead to the interpretive hypothesis that organelle volume changes appear to be driven mainly by osmotic interactions while shape changes are mediated by structural factors, such as cytoskeletal interactions that may be linked to extracellular matrix deformations. The observed volume and shape changes of the chondrocyte organelles and the differential behavior between organelles during tissue compression provide evidence for an important mechanotransduction pathway linking translational and post-translational events (e.g., elongation and sulfation of glycosaminoglycans (GAGs) in the Golgi) to cell deformation.

Dynamic osmotic loading of chondrocytes using a novel microfluidic device

Many cells exhibit disparate responses to a mechanical stimulus depending on whether it is applied dynamically or statically. In this context, few studies have examined how cells respond to dynamic changes of the extracellular osmolality. In this study, we hypothesized that the cell size change response of cultured articular chondrocytes would be dependent on the frequency of applied osmotic loading. To test this hypothesis, we developed a novel microfluidic device, to apply hydrostatic pressure-driven dynamic osmotic loading by applying composition modulated flow, adapted from Tang and co-workers. This microfluidic device was used to study osmotic loads of +/-180 mOsm at a frequency up to 0.1 Hz with a constant minimal fluid-shear stress, and permit real-time monitoring of cell responses. Bovine articular chondrocytes were observed to exhibit increasing changes in cell volume with decreasing osmotic loading frequency. When the cell volume response was modeled by an exponential function, chondrocytes exhibited significantly different volume change responses to dynamic osmotic loading at 0.0125 Hz and static osmotic loading applied for a period of four minutes (Delta = +/-180 mOsm relative to the isotonic 360 mOsm). The intracellular calcium response at 0.0125 Hz was also monitored and compared with the response to static loading. Coupled with phenomenological or constitutive models, this novel approach could yield new information regarding cell material properties in response to dynamic loading that may contribute new insights into mechanisms of cellular homeostasis and mechanotransduction.

Measurement of the chondrocyte membrane permeability to Me2SO, glycerol and 1,2-propanediol

The addition of cryopreservative agents (CPAs) to chondrocytes and natural and engineered cartilage is critical to protect the cells and tissues from freezing damage during cryopreservation, but this may cause cell damage, e.g. by osmotic shock. The damage could be minimized by the control of the cell volume excursion with the knowledge of cell membrane permeability. In this study, the cell volume responses of chondrocytes to three commonly used CPAs were evaluated using a perfusion microscope stage. The osmotic response of chondrocytes was measured to the perfusion with 1.4 M dimethyl sulfoxide (Me2SO), 1,2-propanediol and glycerol at 21 degrees C. Cell volumes and their transients were determined with image analysis. The cell membrane permeability parameters, including the hydraulic conductivity (Lp), the CPA permeability (omega) and the reflection coefficients (sigma) in the Kedem-Katchalsky (K-K) model, and the Lp and omega in the two-parameter model were determined. The correlated K-K parameters at 21 degrees C were Lp=0.166 +/- 0.035, 0.149 +/- 0.061, 0.212 +/- 0.041 microm/min atm, omega=(7.630 +/- 0.174) x 10(-2), (1.428 +/- 0.627) x 10(-2), (2.744 +/- 0.775) x 10(-2) microm/s and sigma=0.91 +/- 0.09, 0.82 +/- 0.11, 0.88 +/- 0.10 for Me(2)SO, glycerol and 1,2-propanediol, respectively. For the two-parameter model, the parameter values were Lp=0.163 +/- 0.040, 0.128 +/- 0.031, 0.169 +/- 0.025 microm/min atm, omega=(7.881 +/- 0.178) x 10(-2), (1.529 +/- 0.525) x 10(-2), (3.716 +/- 0.493) x 10(-2) microm/s for Me2SO, glycerol and 1,2-propanediol, respectively. No significant difference in the predictions of cell volume excursion during CPA addition was observed when using either the K-K model or the two-parameter model and it was hence advised to adopt the simple two-parameter model in the evaluation. The measured parameters can be used to optimise the CPA addition and removal protocols to maximize the cell survival during cryopreservation.

Intracellular pH changes in isolated bovine articular chondrocytes during the loading and removal of cryoprotective agents

The addition and removal of a cryoprotective agent (CPA) are necessary steps in the cryopreservation of natural or engineered tissue products. However, the introduction and removal of CPAs induces dramatic chemical changes inside tissues and cells and these could cause irreversible damage. This study examined the effect of CPA loading and removal on the intracellular pH of isolated bovine articular chondrocytes using a fluorimetric technique. Chondrocytes that had been isolated from bovine articular cartilage were loaded with the pH-sensitive fluorophore 2('),7(')-bis(carboxyethyl)-5(6)-carboxyfluorescein. After removal of the extracellular fluorophore, the intensity of fluorescence was used to measure the intracellular pH according to a pre-determined calibration curve. Changes of intracellular pH in chondrocytes were measured following their exposure to dimethyl sulfoxide (Me(2)SO) and glycerol at concentrations of 0.6, 0.9, and 1.2M and later to the isotonic or hypertonic solutions that were used to remove the CPA. The effect of the presence of NaCl on the intracellular pH during CPA removal was also examined. The temperature was maintained at 37 degrees C. Trypan blue exclusion was used to quantify cell membrane integrity after the addition and removal of CPA. It was found that when the cells were exposed to CPA, the intracellular pH decreased quickly and recovered gradually later. During CPA removal, the intracellular pH rose following exposure to isotonic Hepes-buffered medium, but the opposite was observed if the Hepes buffer solution contained no NaCl; this was ascribed to the role of NaCl in cell membrane transport. It was noted that the change in intracellular pH correlated with the cell volume excursion, which could be estimated by the Kedem-Katchalsky model, and was linked to cell survival. The resulting alteration of pH inside the cells might contribute to cell damage and loss of function after cryopreservation.

Effects of citicholine and dimethylsulfoxide on transepithelial transport of passively diffused drugs in the Caco-2 cell culture model

The objective of this study was to determine, using a Caco-2 cell monolayer model, the extent to which the paracellular and transcellular routes are altered by citicholine (CDP-Ch) and DMSO in the presence of human serum albumin (HSA). The apparent permeability (Papp) of mannitol in the presence of 4% (w/v) HSA was investigated using 0, 0.5, 1.0, 2.5, 5.0, and 10.0% (v/v)) of DMSO. The Papp for mannitol ranged from 0.56 x 10(-6) to 0.89 x 10(-6) cm/s (mean 0.77 x 10(-6)). Increasing the concentration of DMSO does not appear to have an effect on the paracellular transport of mannitol and on the transepithelial resistance (TEER) of the monolayer, (P>0.05). The effect of citicholine (CDP-Ch) was investigated in confluent Caco-2 cell monolayers incubated in the presence of 2, 4, 10, 40, 60, 100 and 200 mM CDP-Ch at 37 degrees C in an atmosphere of 7% CO(2) and 95% relative humidity. Papp of mannitol and diltiazem in the presence of CDP-Ch ranged from 0.53 x 10(-6) to 8.52 x 10(-6) cm/s and from 1.30 x 10(-5) to 2.71 x 10(-5) cm/s, respectively. CDP-Ch may have an effect on the stability of the tight junction complex resulting in an increase in the apparent permeability of mannitol.

Damage and protection of UC blood cells during cryopreservation

BACKGROUND

Current procedures for the cryopreservation of umbilical cord blood (UCB) progenitor cells, which are based on techniques used for BM, have had varying degrees of success (survival 9-118%). Improving the effectiveness of UCB cell therapies demands a more comprehensive understanding of freezing injury during cryopreservation.

METHODS

Leukocyte concentrates from UCB, with or without 10% DMSO were cooled at 1 degrees C/min to different subzero temperatures (-5 to -50 degrees C), then either thawed directly (thaw) or plunged into liquid nitrogen before thawing (plunge). Single-platform flow cytometry with 7-amino-actinomycin D was used to directly quantify survival of CD34(+) cells. Fluorescent microscopy was used to examine plasma membrane integrity of nucleated cells.

RESULTS

Without DMSO, recovery of nucleated cells was approximately 80% for both thaw and plunge. Survival was 9%, indicating damage to the plasma membrane. With 10% DMSO, nucleated cell recovery was also approximately 80%, indicating that DMSO does not improve recovery of nucleated cells. Survival, however, was much higher with DMSO, > 60% for nucleated cells thawed directly, and 30-55% for cells thawed from plunge, demonstrating cryoprotection conferred by DMSO. With DMSO, survival of CD34(+) cells was higher than that of nucleated cells, indicating that CD34(+) cells with 10% DMSO are more tolerant to cryopreservation than the total nucleated cell population.

DISCUSSION

This study provides the necessary data on the low temperature response of UCB progenitor cells that are critical for the development of standards for the cryopreservation of UCB.

Osmotic parameters of cells from a bioengineered human corneal equivalent and consequences for cryopreservation

A human corneal equivalent is under development with potential applications in pharmaceutical testing, biomedical research, and transplantation, but the ability to distribute this engineered tissue, depends on successful cryopreservation. Tissue recovery after exposure to conditions during cryopreservation depends on the response of its constituent cells to the changing environment as ice forms and solutes concentrate. This study defines the osmotic properties that define the rate of water movement across the plasma membrane of isolated human corneal endothelial, stroma, and epithelial cells. Cells were transferred from an isotonic (300 mosm/kg) to an anisotonic (150-1500 mosm/kg) solution at constant temperature, and cell volumes monitored using an electronic particle counter. Histograms describing cell volume changes over time after anisosmotic exposure allowed calculation of hydraulic conductivity (L(p)) and osmotically inactive volume fraction (V(b)). Experimental values for L(p) at 4, 13, 22, and 37 degrees C were used to determine the Arrhenius activation energy (E(a)). The L(p) for endothelial, stroma, and epithelial cells at 37 degrees C was 1.98+/-0.32,1.50+/-0.30, and 1.19+/-0.14 microm/min/atm, and the V(b) was 0.28, 0.27, and 0.41, respectively. The E(a) for endothelial, stroma, and epithelial cells was 14.8, 12.0, and 14.1 kcal/mol, respectively, suggesting the absence of aqueous pores. These osmotic parameters and temperature dependencies allow simulation of osmotic responses of human corneal cells to cryopreservation conditions, allowing amount of supercooling to be calculated to indicate the likelihood of intracellular freezing. Simulations show that differences in the osmotic parameters for the constituent cells in the bioengineered cornea result in significant implications for cryopreservation of the engineered corneal equivalent.

The effect of temperature on membrane hydraulic conductivity

The objective of this study was to use the temperature dependence of water permeability to suggest the physical mechanisms of water transport across membranes of osmotically slowly responding cells and to demonstrate that insight into water transport mechanisms in these cells may be gained from easily performed experiments using an electronic particle counter. Osmotic responses of V-79W Chinese hamster fibroblast cells were measured in hypertonic solutions at various temperatures and the membrane hydraulic conductivity was determined. The results were fit with the general Arrhenius equation with two free parameters, and also fit with two specific membrane models each having only one free parameter. Data from the literature including that for human bone marrow stem cells, hamster pancreatic islets, and bovine articular cartilage chondrocytes were also examined. The results indicated that the membrane models could be used in conjunction with measured permeability data at different temperatures to investigate the method of water movement across various cell membranes. This approach for slower responding cells challenges the current concept that the presence of aqueous pores is always accompanied by an osmotic water permeability value, P(f)>0.01 cm/s. The possibility of water transport through aqueous pores in lower-permeability cells is proposed.

Volume increase in growth plate chondrocytes during hypertrophy: the contribution of organic osmolytes

During the differentiation cascade of growth plate chondrocytes, cells undergo as much as a 10-15-fold increase in volume. This volume increase, which occurs to different extents in growth plates growing at different rates, has been demonstrated to be the single most significant variable in understanding the quantitative aspects of the cellular kinetics of long bone growth. Our hypothesis is that this volume increase, which occurs through cell swelling by water imbibition, requires intracellular accumulation of osmolytes through activation or upregulation of membrane transport mechanisms. Significant intracellular accumulation of inorganic osmolytes, such as Na+, K+, and Cl-, is potentially disruptive to normal cellular metabolism, whereas intracellular accumulation of organic osmolytes is considered to be more compatible with metabolic function. Thus, we concentrated on determining the contributions of organic osmolytes--betaine, amino acids, inositol, and sorbitol--to volume increase. Pooled cryostat sections of young bovine growth plates were extracted followed by automated analysis for their content of amino acids. Analysis for betaine and the sugar alcohols was done by extraction and derivatization, followed by high-performance liquid chromatography (HPLC). Parallel stereological analyses correlated osmolyte changes to stages of chondrocytic differentiation, specifically comparing intracellular concentration and amount in proliferative vs. hypertrophic chondrocytes. Calculations demonstrated that, maximally, these organic osmolytes, in total, account for 6%-7% of the intracellular osmolytes required to sustain the volume increase, and that the most significant contribution is from betaine. This suggests that intracellular accumulation of organic osmolytes is not a primary strategy used by growth plate chondrocytes during volume increase of their terminal differentiation. The data also suggest that there is a differential regulation of transporters of these osmolytes such that intracellular concentrations are constantly modified as cells proceed through the differentiation cascade.

The effects of osmotic stress on the viscoelastic and physical properties of articular chondrocytes

The metabolic activity of chondrocytes in articular cartilage is influenced by alterations in the osmotic environment of the tissue, which occur secondary to mechanical compression. The mechanism by which osmotic stress modulates cell physiology is not fully understood and may involve changes in the physical properties of the membrane or the cytoskeleton. The goal of this study was to determine the effect of the osmotic environment on the mechanical and physical properties of chondrocytes. In isoosmotic medium, chondrocytes exhibited a spherical shape with numerous membrane ruffles. Normalized cell volume was found to be linearly related to the reciprocal of the extracellular osmolality (Boyle van't Hoff relationship) with an osmotically active intracellular water fraction of 61%. In deionized water, chondrocytes swelled monotonically until lysis at a mean apparent membrane area 234 +/- 49% of the initial area. Biomechanically, chondrocytes exhibited viscoelastic solid behavior. The instantaneous and equilibrium elastic moduli and the apparent viscosity of the cell were significantly decreased by hypoosmotic stress, but were unchanged by hyperosmotic stress. Changes in the viscoelastic properties were paralleled by the rapid dissociation and remodeling of cortical actin in response to hypoosmotic stress. These findings indicate that the physicochemical environment has a strong influence on the viscoelastic and physical properties of the chondrocyte, potentially through alterations in the actin cytoskeleton.

Transplantation of articular cartilage following a step-cooling cryopreservation protocol

Using a step-cooling cryopreservation protocol that held the tissue 60 min at -4 degrees C, 30 min at -8 degrees C, and 10 min at -40 degrees C before plunging into liquid nitrogen, we were able to get a substantial improvement in the magnitude and pattern of chondrocyte recovery following cryopreservation, achieving postthaw recoveries of 62 +/- 13%. These results are consistent with the hypothesis that ice growth within articular cartilage is planar, but they provide no direct support for that hypothesis. Transplanting (step-cooled) cryopreserved osteochondral allografts into adult Suffolk/Romanoff crossbred sheep for periods of 3 months and 1 year further tested the efficacy of the cryopreservation protocol. Unfortunately, the cryoinjury sustained by the chondrocytes during cryopreservation, although apparently nonlethal immediately after thawing in many cases, was not innocuous in the long term. The presence of large clusters of chondrocytes at 1 year after transplantation illustrates that cryoinjury not detectable with a membrane integrity assay can still have far-reaching effects on transplanted tissue.

The osmotic sensitivity of isolated and in situ bovine articular chondrocytes

Articular chondrocytes experience changes to matrix hydration during both physiological (static load) and pathophysiological (osteoarthrosis, OA) conditions. Such changes should alter chondrocytes' volume, which has been shown to modify matrix metabolism. However, the osmometric behaviour of chondrocytes is not well understood. Here, using confocal laser scanning microscopy (CLSM), we have investigated the 'passive' osmotic responses of fluorescent-labelled chondrocytes within, and isolated from, the matrix. The volume-regulatory pathways normally activated by cell shrinkage/swelling, were blocked by bumetanide/REV5901, respectively. Chondrocytes in situ were broadly grouped into superficial (SZ), mid (MZ) and deep (DZ) zones, and there was a significant increase in resting cell volume with depth into the cartilage. Variation in medium osmolarity (range 0-530 mOsm; corresponding to an extracellular osmolarity of approximately 150 to approximately 600 mOsm) caused a rapid and sustained change to in situ MZ chondrocytes' volume. Over the range 180-380 mOsm, the change to in situ or isolated chondrocytes' volume was similar. For MZ chondrocytes. ideal osmometric (Boyle-van't Hoff) behaviour was apparent over the extracellular osmolarity range of approximately 250 to approximately 600 mOsm. Chondrocytes within the SZ appeared to be more sensitive to reduced osmolarity, swelling more for a given reduction in osmolarity, than MZ or DZ chondrocytes. These data show that over wide variations in osmolarity, articular chondrocytes in situ were osmotically sensitive, and for MZ chondrocytes behaved as perfect osmometers with the extracellular matrix (ECM) not restraining cell volume changes. Changes to matrix hydration may therefore alter passive chondrocytes' volume and unless compensated by volume-regulatory pathways, could lead to changes in cell volume, and hence matrix metabolism.

Cryobiology of articular cartilage: ice morphology and recovery of chondrocytes

The cryopreservation of articular cartilage chondrocytes has been achieved with cells isolated from the cartilage matrix but has found only limited success when the tissue is left intact. Previous work with ovine cartilage has shown that cryopreservation of the chondrocytes of the superficial and deep zones is possible, but the cells of the intermediate zone have not been successfully cryopreserved. This finding led to the suggestion that there might be biological differences between chondrocytes of the different morphological zones that were responsible for this differential recovery. This study investigates the hypothesis that the cells of the intermediate zone are more sensitive to cryoinjury by introducing cuts in the cartilage so that cells of the intermediate zone have the same proximity to the outer surface of the tissue as the cells of the superficial zone. When this was done, it was found that cells of the intermediate zone could survive cryopreservation as well as the cells of the superficial zone when they were near a surface, but not when they were embedded deep within the tissue. Thus the hypothesis of a biological difference between the cells of the two zones being responsible for the differential recovery is disproved. It is further hypothesized that physical proximity to a surface leads to higher recovery as a result of planar ice growth into the cartilage.

Long-term storage of tissues by cryopreservation: critical issues

The technique of cryopreservation (maintenance of biological samples in a state of 'suspended animation' at cryogenic temperatures), its potential use in tissue engineering applications and current obstacles to the development of effective cryopreservation methods for tissues are reviewed. A didactic overview of the principles of cryobiology and the methodology of cryopreservation is given, with emphasis on the processes of injury to cells during freezing and thawing, and how these are related to the physicochemical and biophysical changes occurring during cryopreservation. Critical issues relevant to the application of cryopreservation methods to tissues are then addressed, including heat and mass transfer limitations in these bulk systems, intrinsic differences between isolated and cultured cells, and mechanisms of freezing injury unique to tissue systems.

The osmotic rupture hypothesis of intracellular freezing injury

A hypothesis of the nature of intracellular ice formation is proposed in which the osmotically driven water efflux that occurs in cells during freezing (caused by the increased osmotic pressure of the extracellular solution in the presence of ice) is viewed as the agent responsible for producing a rupture of the plasma membrane, thus allowing extracellular ice to propagate into the cytoplasm. This hypothesis is developed into a mathematical framework and the forces that are present during freezing are compared to the forces which are required to rupture membranes in circumstances unrelated to low temperatures. The theory is then applied to systems which have been previously studied to test implications of the theory on the nature of intracellular ice formation. The pressure that develops during freezing due to water flux is found to be sufficient to cause a rupture of the plasma membrane and the theory gives an accurate description of the phenomenology of intracellular ice formation.

Optimization of cryopreservative procedures for human articular cartilage chondrocytes

Procedures are being developed which use isolated articular cartilage (AC) chondrocytes to restore damaged articular surfaces. The availability of isolated human chondrocytes for transplantation may be increased by low-temperature storage (banking). At present, no single method of freezing chondrocytes has been proven to be optimal. In this project, two different freezing protocols, I and II, were compared. Protocol I used freezing rates of -1 degrees C/min down to a temperature of -40 degrees C. Protocol II used a freezing rate of -1 degree C/min down to -10 degrees C and faster rates thereafter. Cells were stored for 2 weeks at -196 degrees C. Survival and function of the cells after thawing were evaluated by histological examination and determination of 35S- and 3H-thymidine incorporation after 1 and 2 weeks of high-density monolayer culture. Cells frozen with protocol I showed better function and survival (99.75%) than cells frozen with protocol II (85%). Both groups showed slowing of metabolism and replication after freezing when compared with controls. We conclude that controlled freezing of adult human chondrocytes at rates of -1 degrees C/min improves survival. Banking of human AC chondrocytes may be feasible using protocol I, although some questions regarding the long-term behaviour of human AC chondrocytes after cryopreservation remain to be answered.

Regulation of matrix synthesis rates by the ionic and osmotic environment of articular chondrocytes

Chondrocytes in cartilage are embedded in a matrix containing a high concentration of proteoglycans and hence of fixed negative charges. Their extracellular ionic environment is thus different from that of most cells, with extracellular Na+ being 250-350 mM and extracellular osmolality 350-450 mOsm. When chondrocytes are isolated from the matrix and incubated in standard culture medium (DMEM; osmolality 250-280 mOsm), their extracellular environment changes sharply. We incubated isolated bovine articular chondrocytes and cartilage slices in DMEM whose osmolality was altered over the range 250-450 mOsm by Na+ or sucrose addition. 35S-sulphate and 3H-proline incorporation rates were at a maximum when the extracellular osmolality was 350-400 mOsm for both freshly isolated chondrocytes and for chondrocytes in cartilage. The incorporation rate per cell of isolated chondrocytes was only 10% that of chondrocytes in situ both 4 and 24 hours after isolation. For freshly isolated chondrocytes, the rate increased 30-50% in DMEM to which NaCl or sucrose had been added to increase osmolality. In chondrocytes incubated overnight in DMEM, the rate was greatest in DMEM of normal osmolality and fell from the maximum in proportion to the change in osmolality. The effects of sucrose addition on incorporation rates were similar but not identical to those of Na+ addition. Changes in cell volume might be linked to changes in synthesis rates since the cell volume of chondrocytes (measured by Coulter-counter) increased 30-40% when the cells were removed from their in situ environment into DMEM. Synthesis rates can thus be partly regulated by changes in extracellular osmolality, which in cartilage is controlled by proteoglycan concentration. This provides a mechanism by which the chondrocytes can rapidly respond to changes in extracellular matrix composition.

Cryoinjury in human granulocytes and cytoplasts

Although most isolated cells can be successfully cryopreserved, human granulocytes have little functional recovery after cryopreservation, even under optimized conditions. Cytoplasts, which are vesicles created from human granulocytes by depletion of organelles including granules and the nucleus, can carry out some of the complex functions of the parent granulocyte such as phagocytosis of bacteria, even after cryopreservation. Human granulocytes and cytoplasts were used in this comparative study of low-temperature responses to assess the relative importance of the plasma membrane and the granules in cryoinjury to human granulocytes. Boyle-van't Hoff plots of cell volume as a function of the reciprocal of osmolality showed that granulocytes and cytoplasts have similar osmometric behavior and equivalent osmotically inactive fractions. The hydraulic conductivities were also similar, indicating that the osmotic properties of the plasma membrane and cytoplasm were retained during preparation of the cytoplasts. Assessment of membrane integrity using fluorescein diacetate after graded freezing stresses showed that the low-temperature responses of cytoplasts were similar to those of human lymphocytes and hamster fibroblasts, with recoveries much higher than those of human granulocytes, particularly after post-thaw incubation at 37 degrees C. The results indicate that the plasma membrane is not the primary site of injury to granulocytes during freezing and thawing, and suggest that activation of cytoplasmic elements, such as granules, may constitute the early events in cryoinjury to human granulocytes. These studies have significance in approaches to the cryopreservation of granulocytes and other types of cells, such as platelets, with increased sensitivity to the conditions encountered during freezing and thawing.

Plasma membrane water permeabilities of human oocytes: the temperature dependence of water movement in individual cells

Membrane water permeability values were measured in individual fresh human pre-ovulatory oocytes using real time microscopy in a microscope diffusion chamber. The cells were exposed to anisosmotic conditions, their volume responses measured, and from these data the Lp values were computed employing the Kedem-Katchalsky analyses of irreversible thermodynamics. Lp values were measured at four temperatures for each oocyte between 37 degrees C and 10 degrees C, and the temperature-related Arrhenius activation energy (Ea) calculated. It was apparent that individual oocytes exhibited a wide range of Lp values; at 37 degrees C Lp values ranged between 0.33 and 1.80 microns/atm/min. However, each oocyte exhibited the expected inverse linear correlation between Lp and temperature, with high linear correlations (R2 values between 0.73 and 0.96). A mean value for Ea of 8.61 +/- 5.11 Kcal/mol was computed. It is apparent that pre-ovulatory human oocytes express a range of biological diversity in terms of membrane water transport, and this fact needs to be considered when attempting to formulate cryopreservation protocols for storage of these oocytes.