Inhaled technosphere insulin: a novel delivery system and formulation for the treatment of types 1 and 2 diabetes mellitus

Are New Ultra-Rapid-Acting Insulins Associated with Improved Glycemic Control and Reduced Hypoglycemia in Comparison to Conventional Rapid-Acting Insulins for Individuals with Type 1 and Type 2 Diabetes? A Systematic Review and Meta-Analysis

Introduction: This study aimed to compare efficacy and safety of ultra-rapid-acting insulin analogs (URAIs; faster aspart [FAsp], ultra-rapid lispro [URLi], and technosphere insulin [TI]) with rapid-acting insulin analogs (RAI) in individuals with type 1 (T1D) or type 2 diabetes (T2D). Methods: Searching for randomized control trial comparing the effects of URAI versus RAI that lasted at least 12 weeks, we initially selected 15 studies for analysis. Three studies involving TI were excluded due to a high degree of heterogeneity. The final meta-analysis included only 12 studies with either FAsp or URLi. Results: Mealtime URAI significantly reduced overall early 1 h postprandial glycemia in individuals with T1D (-20.230 mg/dL [95% confidence interval, 95% CI -24.040 to -16.421]; P < 0.001; I2 = 33.42%) and those with T2D (-9.138 mg/dL [95% CI -12.612 to -5.663]; P < 0.001; I2 = 0%). However, the significant reduction in 2 h postprandial glucose remained only in individuals with T1D (-17.620 mg/dL [95% CI -26.047 to -9.193]; P < 0.001; I2 = 65.88%). These benefits were lost when URAI was administered postmeal. At 24-26 weeks, there was no significant difference in HbA1c between groups, but at 52 weeks, a slight reduction in HbA1c with mealtime URAI was observed (-0.080% [95% CI -0.147 to -0.013]; P = 0.019; I2 = 0%). No difference in weight or the rate of severe or confirmed hypoglycemia was observed. Only individuals with T1D showed a small, but significant increase in early 1-h hypoglycemia with URAI (1.468 [95% CI 1.235 to 1.747]; P < 0.001; I2 = 0%). Conclusion: Mealtime URAI improves 1 and 2 h postprandial glycemic control compared to RAI without increasing hypoglycemia or weight gain.

Pulmonary inhalation for disease treatment: Basic research and clinical translations

Pulmonary drug delivery has the advantages of being rapid, efficient, and well-targeted, with few systemic side effects. In addition, it is non-invasive and has good patient compliance, making it a highly promising drug delivery mode. However, there have been limited studies on drug delivery via pulmonary inhalation compared with oral and intravenous modes. This paper summarizes the basic research and clinical translation of pulmonary inhalation drug delivery for the treatment of diseases and provides insights into the latest advances in pulmonary drug delivery. The paper discusses the processing methods for pulmonary drug delivery, drug carriers (with a focus on various types of nanoparticles), delivery devices, and applications in pulmonary diseases and treatment of systemic diseases (e.g., COVID-19, inhaled vaccines, diagnosis of the diseases, and diabetes mellitus) with an updated summary of recent research advances. Furthermore, this paper describes the applications and recent progress in pulmonary drug delivery for lung diseases and expands the use of pulmonary drugs for other systemic diseases.

Microencapsulation for Pharmaceutical Applications: A Review

In order to improve bioavailability, stability, control release, and target delivery of active pharmaceutical ingredients (APIs), as well as to mask their bitter taste, to increase their efficacy, and to minimize their side effects, a variety of microencapsulation (including nanoencapsulation, particle size <100 nm) technologies have been widely used in the pharmaceutical industry. Commonly used microencapsulation technologies are emulsion, coacervation, extrusion, spray drying, freeze-drying, molecular inclusion, microbubbles and microsponge, fluidized bed coating, supercritical fluid encapsulation, electro spinning/spray, and polymerization. In this review, APIs are categorized by their molecular complexity: small APIs (compounds with low molecular weight, like Aspirin, Ibuprofen, and Cannabidiol), medium APIs (compounds with medium molecular weight like insulin, peptides, and nucleic acids), and living microorganisms (such as probiotics, bacteria, and bacteriophages). This article provides an overview of these microencapsulation technologies including their processes, matrix, and their recent applications in microencapsulation of APIs. Furthermore, the advantages and disadvantages of these common microencapsulation technologies in terms of improving the efficacy of APIs for pharmaceutical treatments are comprehensively analyzed. The objective is to summarize the most recent progresses on microencapsulation of APIs for enhancing their bioavailability, control release, target delivery, masking their bitter taste and stability, and thus increasing their efficacy and minimizing their side effects. At the end, future perspectives on microencapsulation for pharmaceutical applications are highlighted.

Evaluation of Bacillus subtilis SPB1 biosurfactant effects on hyperglycemia, angiotensin I-converting enzyme (ACE) activity and kidney function in rats fed on high-fat-high-fructose diet

This study investigated the protective and the curative effects of Bacillus subtilis SPB1 crude lipopeptide biosurfactant in alleviating induced obesity complications in rats fed on high-fat-high-fructose diet (HFFD). Male Wistar rats were divided into five groups with the following treatment schedule: normal diet-fed rats (CD), HFFD-fed rats, HFFD-fed rats supplemented with SPB1 biosurfactant from the first day of the experiment (HFFD + Bios1), rats fed on HFFD receiving standard drug (HFFD + Torva), or SPB1 biosurfactant (HFFD + Bios2) during the last 4 weeks of the study. HFFD induced hyperglycemia, manifested by a significant (p < 0.001) increase (20%) in the levels of glucose and α-amylase activity in the plasma, when compared with CD. The administration of SPB1 biosurfactant to rats fed on HFFD reverted back normal blood glucose and α-amylase activity levels. Also, the findings clearly showed that acute oral administration of SPB1 biosurfactant reduced significantly (34%) the peak of blood glucose concentration 60 min after glucose administration, as compared with untreated rats fed on HFFD. Furthermore, renal dysfunction indices such as creatinine and urea as well as the level of angiotensin I-converting enzyme (ACE) exhibited remarkable increases in serum of rats fed on HFFD by 28.35%, 46%, and 92%,. Interestingly, SPB1 lipopeptides treatments decreased the creatinine and urea levels significantly (p < 0.001) near normal values, as compared with that of the HFFD group, and also showed an improvement of the kidney cortex architecture. Moreover, SPB1 biosurfactant displayed a potent inhibition of ACE activity in vitro (CI₅₀ value=1.37 mg/mL) as well as in vivo in obese rats by 42% and 27.25% with HFFD + Bios1 and HFFD + Bios2 treatments, respectively, and comparatively with the HFFD group. Besides, SPB1 lipopeptides treatments improved some of serum electrolytes such as Na⁺, K⁺, Ca²⁺, and Mg²⁺. The results showed that SPB1 lipopeptide biosurfactant presented useful hypoglycemic and antihypertensive properties, and was able to alleviate renal lipid deposition in rats fed on a hypercaloric diet.

Place of technosphere inhaled insulin in treatment of diabetes

Technosphere insulin (TI), Afrezza, is a powder form of short-acting regular insulin taken by oral inhalation with meals. Action of TI peaks after approximately 40-60 min and lasts for 2-3 h. TI is slightly less effective than subcutaneous insulin aspart, with mean hemoglobin A1c (HbA1c) reduction of 0.21% and 0.4%, respectively. When compared with technosphere inhaled placebo, the decrease in HbA1c levels was 0.8% and 0.4% with TI and placebo, respectively. Compared with insulin aspart, TI is associated with lower risk of late post-prandial hypoglycemia and weight gain. Apart from hypoglycemia, cough is the most common adverse effect of TI reported by 24%-33% of patients vs 2% with insulin aspart. TI is contraindicated in patients with asthma and chronic obstructive pulmonary disease. While TI is an attractive option of prandial insulin, its use is limited by frequent occurrence of cough, need for periodic monitoring of pulmonary function, and lack of long-term safety data. Candidates for use of TI are patients having frequent hypoglycemia while using short-acting subcutaneous insulin, particularly late post-prandial hypoglycemia, patients with needle phobia, and those who cannot tolerate subcutaneous insulin due to skin reactions.

Assessment of the antidiabetic and antilipidemic properties of Bacillus subtilis SPB1 biosurfactant in alloxan-induced diabetic rats

The present study aimed to scrutinize the potential of Bacillus subtilis SPB1biosurfactant, orally administered, for preventing diabetic complications in rats. The findings revealed that, Bacillus subtilis biosurfactant was an effective reducer of α-amylase activity in the plasma. Moreover, this supplement helped protect the β-cells from death and damage. Both the inhibitory action of SPB1 biosurfactant on α-amylase and the protection of the pancreas' β-cells lead to a decrease of the blood glucose levels, consequently antihyperglycemic effect. Interestingly, this lipopeptide biosurfactant modulated key enzyme related to hyperlipidemia as lipase; which leads to the regulation of the lipid profile in serum by the delay in the absorption of LDL-cholesterol and triglycerides, and a significant increase in HDL-cholesterol. Histological analyses also showed that it exerted a protective action on the pancreases and efficiently preserved the liver-kidney functions of diabetic rats, evidenced by significant decreases in aspartate transaminase, alanine transaminase, gamma-glytamyl transpeptidase and lactate deshydrogenase activities in the plasma, as well as in the creatinine and urea contents. Overall, the present study demonstrated that the hypoglycemic and antilipidemic activities exhibited by Bacillus subtilis biosurfactant were effective enough to alleviate induced diabetes in experimental rats. Therefore, SPB1biosurfactant could be considered as a potential strong candidate for the treatment and prevention of diabetes.

Future prospect of insulin inhalation for diabetic patients: The case of Afrezza versus Exubera

The current review was designed to compare between the insulin inhalation systems Exubera and Afrezza and to investigate the reasons why Exubera was unsuccessful, when Afrezza maker is expecting their product to be felicitous. In January 2006, Pfizer secured FDA and EC approval for the first of its kind, regular insulin through Exubera inhaler device for the management of types 1 and 2 diabetes mellitus (DM) in adults. The product was no longer available to the market after less than two years from its approval triggering a setback for competitive new inhalable insulins that were already in various clinical development phases. In contrary, MannKind Corporation started developing its ultra-rapid-acting insulin Afrezza in a bold bid, probably by managing the issues in which Exubera was not successful. Afrezza has been marketed since February, 2015 by Sanofi after getting FDA approval in June 2014. The results from this systematic review indicate the effectiveness of insulin inhalation products, particularly for patients initiating insulin therapy. Pharmaceutical companies should capitalize on the information available from insulin inhalation to produce competitive products that are able to match the bioavailability of subcutaneous (SC) insulin injection and to deal with the single insulin unit increments and basal insulin requirements in some diabetic patients or extending the horizon to inhalable drug products with completely different drug entities for other indications.

Insulin administration: present strategies and future directions for a noninvasive (possibly more physiological) delivery

Insulin is a life-saving medication for people with type 1 diabetes, but traditional insulin replacement therapy is based on multiple daily subcutaneous injections or continuous subcutaneous pump-regulated infusion. Nonphysiologic delivery of subcutaneous insulin implies a rapid and sustained increase in systemic insulin levels due to the loss of concentration gradient between portal and systemic circulations. In fact, the liver degrades about half of the endogenous insulin secreted by the pancreas into the venous portal system. The reverse insulin distribution has short- and long-term effects on glucose metabolism. Thus, researchers have explored less-invasive administration routes based on innovative pharmaceutical formulations, which preserve hormone stability and ensure the therapeutic effectiveness. This review examines some of the recent proposals from clinical and material chemistry point of view, giving particular attention to patients' (and diabetologists') ideal requirements that organic chemistry could meet.