Percutaneous penetration and metabolism of 2-ethoxyethanol

Disposition and metabolism of ethylene glycol 2-ethylhexyl ether in Sprague Dawley rats, B6C3F1/N mice, and in vitro in rat hepatocytes

Ethylene glycol 2-ethylhexyl ether (EGEHE) is a solvent used in a variety of applications.We report disposition and metabolism of EGEHE following a single gavage or dermal administration of 50, 150 or 500 mg/kg [¹⁴C]EGEHE in rats and mice and in vitro in rat hepatocytes.EGEHE was cleared rapidly in rat hepatocytes (half-life ∼4 min) with no sex difference.EGEHE was well- and moderately absorbed following oral administration (rats: 80-96%, mice: 91-95%) and dermal application (rats: 25-37%, mice: 22-24%), respectively, and rapidly excreted in urine.[¹⁴C]EGEHE-derived radioactivity was distributed to tissues (oral: 2.3-7.2%, dermal: 0.7-2.2%) with liver and kidney containing the highest levels in both species.EGEHE was extensively metabolised with little to no parent detected in urine. The alkoxyacetic acid metabolite, which has previously been shown to mediate toxicities of other shorter-chain ethylene glycol ethers, was not detected.There were no apparent dose, species or sex differences in disposition and metabolism of EGEHE, except that the exhaled volatile compounds were greater in mice (19-20%) compared with rats (<2%).These studies address a critical gap in the scientific literature and provide data that will inform future studies designed to evaluate toxicity of EGEHE.

Hepatic oxidative stress, up-regulation of pro-inflammatory cytokines, apoptotic and oncogenic markers following 2-methoxyethanol administrations in rats

2-methoxyethanol (2-ME) is an organic solvent widely used in the manufacture of brake fluids, paints, resins, varnish, nail polish, acetate cellulose, wood coloring, and as a plasticizer in plastics manufacturing. We therefore, investigated its effect on the liver, in a time-course study in male Wistar rats. Animals were orally administered 50 mg/kg body weight of 2-ME for a period of 7, 14, and 21 days. Following 7 days of administration of 2-ME, there was a significant increase in the level of Bax, c-Myc, K-Ras, TNF-α, IL-1β, IL-6, MDA and GPx activity, while the levels of Bcl-2, NO and GSH were significantly reduced compared with control. At the end of 14 days exposure, Bcl-2, and GSH levels, as well as GST activity, were significantly decreased, while levels of Bax, c-Myc, K-Ras, caspase-3, TNF-α, IL-1β, IL-6, MDA and NO were significantly increased compared with control. After 21 days of 2-ME administration, Bcl-2, IL-10, and GSH levels, as well as SOD and GST activities, were significantly decreased, while levels of Bax, c-Myc, K-Ras, caspase-3, p53, TNF-α, IL-1β, IL-6, MDA and NO were significantly increased compared with control. Lastly, liver histopathology confirmed and corroborated the biochemical findings reported above. We therefore, advised that exposures to 2-ME should be strictly avoided as it could trigger hepatic damage through the disorganization of the antioxidant system, up-regulation of inflammatory, apoptotic, and oncogenic markers in rats.

Percutaneous absorption of thirty-eight organic solvents in vitro using pig skin

Percutaneous absorption is highly variable between chemicals but also within chemicals depending on exposure conditions and experimental set up. We tested a larger number of organic solvents with the same experimental set up, using skin from new-born piglets and static diffusion cells. Thirty-six common organic solvents were studied neat (and 31 of them also in water dilution): acetone, acetonitrile, n-butanol 2-butanone 2-butoxyethanol, 1-butoxy-2-propanol, n-butyl acetate, butyl acrylate, cyclohexane, cyclohexanone, 1,2-dichloroethane, dichloromethane, ethanol, 2-ethoxyethanol, ethyl acetate, ethyl acrylate, ethylbenzene, furfuryl alcohol, n-hexane, 2-hexanone, 2-isopropoxyethanol, methanol, 1-methoxy-2-propanol, methyl acrylate, 3-methyl-1-butanol, methyl tertiary butyl ether, 4-metyl-2-pentanol, methyl methacrylate, 2-propanol, 2-propen-1-ol, 2-propoxyethanol, 1-propoxy-2-propanol, styrene, trichloromethane, toluene and m-xylene. In addition, a mixture of 2-methylbutyl acetate and n-pentyl acetate was tested. For most of the solvents, little or no percutaneous absorption data have been published. Lag times, steady-state fluxes and apparent permeability coefficients were obtained from the time courses of solvent appearance in the receptor medium, as measured by gas chromatography. The use of the same methodology and kind of skin resulted in small variability within experiments, underlining the need for consistent methodology for useful results for developing predictive models. Furthermore, a comparison of the neat and diluted data shows that water dilution affects all these variables and that the direction and magnitude of the effects vary between chemicals. This comparison strongly supports that prediction of percutaneous absorption of neat and water diluted chemicals requires different models.

Ethylene glycol ethers induce oxidative stress in the rat brain

Ethylene glycol ethers (EGEs) are components of many industrial and household products. Their hemolytic and gonadotoxic effects are relatively well known while their potential adverse effects on the central nervous system have not yet been clearly demonstrated. The aim of the present study was to examine the effects of 4-week administration of 2-buthoxyethanol (BE), 2-phenoxyethanol (PHE) and 2-ethoxyethanol (EE) on the total antioxidant capacity, activity of some antioxidant enzymes, such as the superoxide dismutase (SOD), catalase, glutathione peroxidase (GPX) and glutathione reductase and lipid peroxidation in the frontal cortex and hippocampus in the rat. These studies showed that BE and PHE decreased the total antioxidant activity, SOD and GPX activity, while increased lipid peroxidation in the frontal cortex. Like in the frontal cortex, also in the hippocampus BE and PHE attenuated the total antioxidant activity, however, lipid peroxidation was increased only in animals which received BE while reduction in GPX activity was present in rats administered PHE. The obtained data indicated that 4-week administration of BE and PHE, but not EE, reduced the total antioxidant activity and enhanced lipid peroxidation in the brain. In the frontal cortex, adverse effects of PHE and BE on lipid peroxidation probably depended on reduction in SOD and GPX activity, however, in the hippocampus the changes in the total antioxidant activity and lipid peroxidation were not connected with reduction of the investigated antioxidant enzyme activity.

The application and limitations of mathematical modelling in the prediction of permeability across mammalian skin and polydimethylsiloxane membranes

OBJECTIVES

Predicting the rate of percutaneous absorption of a drug is an important issue with the increasing use of the skin as a means of moderating and controlling drug delivery. One key feature of this problem domain is that human skin permeability (as K(p)) has been shown to be inherently non-linear when mathematically related to the physicochemical parameters of penetrants. As such, the aims of this study were to apply and evaluate Gaussian process (GP) regression methods to datasets for membranes other than human skin, and to explore how the nature of the dataset may influence its analysis.

METHODS

Permeability data for absorption across rodent and pig skin, and artificial membranes (polydimethylsiloxane, PDMS, i.e. Silastic) membranes was collected from the literature. Two quantitative structure-permeability relationship (QSPR) models were used to compare with the GP models. Further performance metrics were computed in terms of all predictions, and a range of covariance functions were examined: the squared exponential (SE), neural network (NNone) and rational quadratic (QR) covariance functions, along with two simple cases of Matern covariance function (Matern3 and Matern5) where the polynomial order is set to 1 and 2, respectively. As measures of performance, the correlation coefficient (CORR), negative log estimated predictive density (NLL, or negative log loss) and mean squared error (MSE) were employed.

KEY FINDINGS

The results demonstrated that GP models with different covariance functions outperform QSPR models for human, pig and rodent datasets. For the artificial membranes, GPs perform better in one instance, and give similar results in other experiments (where different covariance parameters produce similar results). In some cases, the GP predictions for some of the artificial membrane dataset are poorly correlated, suggesting that the physicochemical parameters employed in this study might not be appropriate for developing models that represent this membrane.

CONCLUSIONS

While the results of this study indicate that permeation across rodent (mouse and rat) and pig skin is, in a statistical sense, similar, and that the artificial membranes are poor replacements of human or animal skin, the overriding issue raised in this study is the nature of the dataset and how it can influence the results, and subsequent interpretation, of any model produced for particular membranes. The size of the datasets, in both absolute and comparative senses, appears to influence model quality. Ideally, to generate viable cross-comparisons the datasets for different mammalian membranes should, wherever possible, exhibit as much commonality as possible.

Evaluation of in-vivo animal and in-vitro models for prediction of dermal absorption in man

Risk assessment of dermal exposure to chemicals requires percutaneous absorption data to link the external exposure to the systemic uptake. The most reliable data on percutaneous absorption are obtained from in-vivo human volunteer studies. In addition to ethical constrains, the conduct of these studies is not feasible for the large number of industrial chemicals in use today. Therefore, there is an increasing need for alternative methods to determine percutaneous absorption such as in-vitro assays and methods performed in vivo in experimental animals. In this article, recent comparative in-vitro and in-vivo studies on percutaneous absorption have been addressed with emphasis on the factors that may affect the predictive value of the in-vitro models. Furthermore, the use of animal models, in particular the rat skin, in prediction of percutaneous absorption in the human skin has been reviewed. In-vitro assays showed to be largely influenced by the experimental circumstances, such as type and thickness of the skin, receptor fluid, and the way in which percutaneous absorption is calculated. Rat skin showed consistently to be more permeable than human skin. However, the difference between human and rat skin does not show a consistent pattern between chemicals hampering prediction of human percutaneous absorption. To increase predictive value of in-vitro and animal models, the influence of experimental factors on the percutaneous absorption should be systematically investigated by comparison with human in-vivo data, resulting in more prescriptive guidelines.

Hematological effects of four ethylene glycol monoalkyl ethers in short-term repeated exposure in rats

This study was carried out to compare the hematological effects of 2-methoxyethanol (ME), 2-ethoxyethanol (EE), 2-isopropoxyethanol (IPE), and 2-butoxyethanol (BE) in short-term studies in rats. Male rats were subcutaneously treated with ME or EE at a dosage of 0, 1.25, 2.5 and 5.0 mM/kg in saline, 5 days per week, for 4 weeks. Other rats were exposed to IPE or BE at doses of 0, 0.25, 0.5, 0.75 and 1.25 mM/kg in the same manner. Administration of each chemical, except of ME, resulted in a time- and dose-dependent swelling of erythrocytes as evidenced by an increase in mean corpuscular volume (MCV). Subsequently, red blood cells (RBC), packed cell volumes (PCV), hemoglobin concentration (HGB), and mean cell hemoglobin concentration (MCHC) decreased. Furthermore, an increase in mean cell hemoglobin (MCH) and reticulocyte counts was observed. The onset of hemolysis induced by EE, IPE or BE was faster than after ME administration. While in rats exposed to ME hematological changes were strongly pronounced and progressively increased with exposure time beginning from the day 11, those in animals treated with EE were rather persisted at low constant level for all exposure period. In contrast, the rats exposed to IPE and BE demonstrated the dramatic hematological changes more pronounced in case of BE than IPE at the beginning of exposure (on day 4). Despite of exposure duration, these changes were regressed, although the decrease in RBC and MCHC and the increase in MCV and MCH in rats treated with highest doses of both compound (0.5, 0.75, and 1.25 mM/kg) were more persistent, probably due to selective hemolysis of the aged erythrocytes. In addition, significant leukopenia due to reduction of lymphocytes in rats exposed to ME was observed. In summary, this study demonstrated no tolerance to ME- and EE-induced intravascular hemolysis developed under these experimental conditions. On the contrary, tolerance to IPE- and BE-induced hemolysis in rats exposed to these compounds was prompted.

Hematological Follow‐up of an Intervention Program Adding Rubber Glove‐Wearing to Local Ventilation for 2‐Ethoxyethanol Acetate‐Exposed Workers

The objective of this study was to evaluate an intervention program, implemented in year 1999, of wearing rubber gloves in addition to engineering control, and to follow-up the hematological effects of 2-ethoxyethanol acetate (2-EEA) exposure among workers in a silk-screening factory. All workers from the printing department with direct exposure to 2-EEA were recruited as the exposed group. Workers from the other departments were recruited as the comparison group. Hematological parameters were measured during health surveys conducted 3 times every two years. Information on personal characteristics and working habits was obtained through a structured questionnaire. More female workers were involved in manual printing resulting in higher exposure to 2-EEA. Hemoglobin and haematocrit levels in female exposed workers were significantly lower than those of female comparison workers in the 1st (1998) health survey, but not in the 2nd (2000) and 3rd (2002) health surveys. No difference was found between male exposed and comparison workers for all three surveys. Longitudinal analysis after adjusting for confounders using the general estimating equation model showed the hemoglobin, haematocrit, and RBC count were significantly higher for 2-EEA exposed workers than comparison workers across the 3 surveys (n=42). The results show that wearing rubber gloves in addition to local ventilation was effective at preventing direct dermal exposure to 2-EEA and ameliorated the hematological effects of 2-EEA exposure.

In-vitro human skin penetration of the fragrance material geranyl nitrile

In-vitro human skin permeation and distribution of geranyl nitrile (GN) was determined using epidermal membranes following application (5 microl/cm(2)) in 70% ethanol, under non-occlusive conditions, at maximum in-use concentration (1%). Permeation was measured (12 time-points over 24 h) using 6% (w/v) Oleth-20 in pH 7.4 phosphate buffered saline as receptor. Permeation of reference benzoic acid was assessed using the same skin donors. Overall recovery of GN at 24 h was low (14.1+/-0.4%) due to evaporation. Evaporative loss of GN from polytetrafluoroethylene (PTFE) sheet, under the same conditions was rapid (93% over 24h) although this overestimated loss during permeation where evaporation competed with uptake. At 24 h, 1.89+/-0.15 microg/cm(2) GN, (3.74+/-0.30% of applied dose) (mean+/-standard error, SE, n=12), had permeated. Following rapid initial permeation, the absorption plateaued due to depletion. Levels of GN in the epidermis (plus any remaining stratum corneum after tape stripping), filter paper membrane support and receptor fluid were combined (as per SCCNFP guidelines) to produce a total absorbed dose value of 4.72+/-0.32%. Systemic exposure resulting from the use of GN as a fragrance ingredient, under unoccluded conditions, would be low based on the currently reported use levels.

The influence of water mixtures on the dermal absorption of glycol ethers

Glycol ethers are solvents widely used alone and as mixtures in industrial and household products. Some glycol ethers have been shown to have a range of toxic effects in humans following absorption and metabolism to their aldehyde and acid metabolites. This study assessed the influence of water mixtures on the dermal absorption of butoxyethanol and ethoxyethanol in vitro through human skin. Butoxyethanol penetrated human skin up to sixfold more rapidly from aqueous solution (50%, 450 mg/ml) than from the neat solvent. Similarly penetration of ethoxyethanol was increased threefold in the presence of water (50%, 697 mg/ml). There was a corresponding increase in apparent permeability coefficient as the glycol ether concentration in water decreased. The maximum penetration rate of water also increased in the presence of both glycol ethers. Absorption through a synthetic membrane obeyed Fick's Law and absorption through rat skin showed a similar profile to human skin but with a lesser effect. The mechanisms for this phenomenon involves disruption of the stratum corneum lipid bilayer by desiccation by neat glycol ether micelles, hydration with water mixtures and the physicochemical properties of the glycol ether-water mixtures. Full elucidation of the profile of absorption of glycol ethers from mixtures is required for risk assessment of dermal exposure. This work supports the view that risk assessments for dermal contact scenarios should ideally be based on absorption data obtained for the relevant formulation or mixture and exposure scenario and that absorption derived from permeability coefficients may be inappropriate for water-miscible solvents.

Absorption of [14C]-tetrabromodiphenyl ether (TeBDE) through human and rat skin in vitro

The skin is the largest organ in the human body and has the potential to come into contact with a variety of xenobiotics both intentionally (e.g., drugs and cosmetics) or accidentally (e.g., agrochemicals and industrial chemicals). These chemicals may then cross the skin barrier (the stratum corneum) and enter into the systemic circulation where they may produce a desired or an undesired effect, or even no systemic effect at all. Tetrabromodiphenyl ether (TeBDE) is one congener in a mixture of polybrominated diphenyl ethers that makes up a flame-retardant commercial product called pentabromodiphenyl ether (PeBDE). TeBDE was used as a surrogate to assess the potential dermal absorption of this product. The physicochemical properties, including lipophilicity, of TeBDE and PeBDE are similar. Operator exposure of PeBDE product to human skin is possible during production and use. However, during these activities, operators wear protective clothing to protect from or minimize exposure. This study was designed to assess the rate and extent of absorption of [14C]-tetrabromodiphenyl ether ([14C]-TeBDE) through human and rat skin in vitro. [14C]-TeBDE was applied to human and rat split thickness skin membranes in vitro in a single test preparation: [14C]-TeBDE in acetone (ca. 20%, w/v). Dermal delivery and absorbed dose of TeBDE applied to human skin was 3.13% (313 microg equiv/cm(2)) and 1.94% (194 microg equiv/cm(2)) of the applied dose, respectively. Dermal delivery and absorbed dose of TeBDE applied to rat skin was 17.94% (1804 microg equiv/cm(2)) and 14.81% (1489 microg equiv/cm(2)) of the applied dose, respectively. These results confirm that the risk of systemic exposure due to external dermal exposure of the PeBDE product is low in the human. Consequently, based on the toxicological profile of these materials, the potential for undesirable effects is also quite low. The results also confirm that the rat is a conservative model overpredicting human absorption about eight fold.

In vitro studies-how good are they at replacing in vivo studies for measurement of skin absorption?

Measures of percutaneous penetration are required for risk assessment of exposure of man to chemicals. In vitro approaches and QSAR predictions can be used and reduce the use of in vivo animal experiments. The OECD Guidelines on in vitro dermal absorption studies were recently accepted but progress was hampered by a lack of direct in vitro/in vivo comparisons in humans or in rodents. Either flow through diffusion or static cell systems with full thickness, dermatomed skin or membranes can be used. In a study of the robustness of in vitro techniques, inter-skin variability was greater than inter-laboratory or between cell variability. Recent studies with a number of chemicals have shown a reasonably good prediction but the difference between in vitro and in vivo results was greater for lipophilic molecules as lipophilic molecules which were retained in the stratum corneum. The experimental flux obtained in vitro using conditions that reflect the potential occupational exposure may be the most appropriate figure for risk assessment purposes. A database of in vitro and in vivo dermal penetration has been established. Dermal absorption data using infinite doses has been combined in a number of databases used for predictive QSAR modelling approaches to dermal absorption. However, absorption values derived from QSAR may over estimate the actual absorption from a finite dose.

Cutaneous metabolism of glycol ethers

The toxicity of glycol ethers is associated with their oxidation to the corresponding aldehyde and alkoxyacetic acid by cytosolic alcohol dehydrogenase (ADH; EC 1.1.1.1.) and aldehyde dehydrogenase (ALDH; 1.2.1.3). Dermal exposure to these compounds can result in localised or systemic toxicity including skin sensitisation and irritancy, reproductive, developmental and haemotological effects. It has previously been shown that skin has the capacity for local metabolism of applied chemicals. Therefore, there is a requirement to consider metabolism during dermal absorption of these compounds in risk assessment for humans. Cytosolic fractions were prepared from rat liver, and whole and dermatomed skin by differential centrifugation. Rat skin cytosolic fractions were also prepared following multiple dermal exposure to dexamethasone, ethanol or 2-butoxyethanol (2-BE). The rate of ethanol, 2-ethoxyethanol (2-EE), ethylene glycol, 2-phenoxyethanol (2-PE) and 2-BE conversion to alkoxyacetic acid by ADH/ALDH in these fractions was continuously monitored by UV spectrophotometry via the conversion of NAD+ to NADH at 340 nm. Rates of ADH oxidation by rat liver cytosol were greatest for ethanol followed by 2-EE >ethylene glycol >2-PE >2-BE. However, the order of metabolism changed to 2-BE >2-PE >ethylene glycol >2-EE >ethanol using whole and dermatomed rat skin cytosolic fractions, with approximately twice the specific activity in dermatomed skin cytosol relative to whole rat skin. This suggests that ADH and ALDH are localised in the epidermis that constitutes more of the protein in dermatomed skin than whole skin cytosol. Inhibition of ADH oxidation in rat liver cytosol by pyrazole was greatest for ethanol followed by 2-EE >ethylene glycol >2-PE >2-BE, but it only inhibited ethanol metabolism by 40% in skin cytosol. Disulfiram completely inhibited alcohol and glycol ether metabolism in the liver and skin cytosolic fractions. Although ADH1, ADH2 and ADH3 are expressed at the protein level in rat liver, only ADH1 and ADH2 are selectively inhibited by pyrazole and they constitute the predominant isoforms that metabolise short-chain alcohols in preference to intermediate chain-length alcohols. However, ADH1, ADH3 and ADH4 predominate in rat skin, demonstrate different sensitivities to pyrazole, and are responsible for metabolising glycol ethers. ALDH1 is the predominant isoform in rat liver and skin cytosolic fractions that is selectively inhibited by disulfiram and responds to the amount of aldehyde formed by the ADH isoforms expressed in these tissues. Thus, the different affinity of ADH and ALDH for alcohols and glycol ethers of different carbon-chain length may reflect the relative isoform expression in rat liver and skin. Following multiple topical exposure, ethanol metabolism increased the most following ethanol treatment, and 2-BE metabolism increased the most following 2-BE treatment. Ethanol and 2-BE may induce specific ADH and ALDH isoforms that preferentially metabolise short-chain alcohols (i.e. ADH1, ALDH1) and longer chain alcohols (i.e. ADH3, ADH4, ALDH1), respectively. Treatment with a general inducing agent such as dexamethasone enhanced ethanol and 2-BE metabolism suggesting induction of multiple ADH isoforms.

Percutaneous penetration and metabolism of 2-butoxyethanol

2-Butoxyethanol (2-BE) is widely used as an industrial solvent, which may result in human dermal exposure within the workplace. This study compares in vivo and in vitro skin absorption of 2-BE using similar application regimes and determines the potential of skin to metabolise this chemical prior to entering the systemic blood circulation. Following topical application of undiluted [1-14C] 2-BE to occluded rat skin in vivo, 28% of the dose was absorbed after 24 h. The major routes of excretion included the urine (19%), expiration as carbon dioxide (6%) and faeces (0.4%) whilst little of the dose remained in the carcass (1.3%). Free 2-BE (0.5%), butoxyacetic acid (8%), glucuronide conjugate (3%), sulphate conjugates (0.7%) and ethylene glycol (0.6%) were detected in urine. Permeation rates of 2-BE through unoccluded rat dermatomed skin (16%) were greater than rat whole skin (8%) whilst absorption through human dermatomed skin (4%) was lower than the rat. Absorption of undiluted 2-BE through occluded rat dermatomed skin in vitro (18%) most accurately predicted absorption through rat skin in vivo. However, 2-BE absorption (23%) was enhanced by application in methanol. Distribution analysis and microautoradiography demonstrated the lack of 2-BE accumulation within the skin in vitro or in vivo. This was reflected in the absence of first pass metabolism of 2-BE during percutaneous penetration through viable human or rat skin in vitro or rat skin in vivo, despite rat skin cytosol having the potential to metabolise 2-BE. In conclusion, the in vitro system provided a reasonable estimate of dermal absorption in vivo for the rat. Therefore, by extrapolation of the comparative in vitro data for human and rat skin in vitro, dermal absorption of 2-BE in man was about one-fifth of that in the rat. However, the rapid penetration through skin in vitro prevented local metabolism and systemic exposure after skin contact with 2-BE in vivo was likely to be to the parent compound. Thus, in vitro skin systems can be used to model dermal absorption of volatile glycol ethers, to predict how much compound enters the circulation and allows the toxicologist to evaluate the body burden of a chemical and potential systemic toxicity.