Selective Separation of Polar Unsaturated Organics Using a Water Stationary Phase in Gas Chromatography

Deconvoluting the Combined Effects of Gas Composition and Temperature on Olefin Selectivity for Separations Using Silver(I) Ions in Ionic Liquids

Silver(I) ions have the propensity of undergoing reduction to form metallic silver within olefin/paraffin separation systems when they are subjected to hydrogen at elevated temperatures. Ionic liquids (ILs) are versatile solvents known for their low vapor pressure, high thermal stability, and structural tunability and have been shown to minimize hydrogen-induced reduction of silver(I) ions when employed as solvents. In the development of robust separation platforms that employ silver(I) ions, it is essential to deploy reliable approaches capable of measuring and assessing the factors that lower the overall separation performance. In this study, silver(I) ions dissolved in an imidazolium-based IL are subjected to mixed gas streams composed of hydrogen, nitrogen, and methane under varying temperatures. Using inverse gas chromatography, a total of 44 columns with stationary phases containing four different concentrations of silver(I) bis[(trifluoromethyl)sulfonyl]imide ([Ag+][NTf2 -]) dissolved in the 1-decyl-3-methylimidazolium ([C10MIM+]) [NTf2 -] IL were used to measure partition coefficients of olefins and paraffins, as well as aromatics, esters, and ketones. Upon exposing the stationary phases to mixed gases at elevated temperatures, olefin partitioning between the silver(I) ion pseudophase and the two other phases (i.e., carrier gas and IL stationary phase) was observed to decrease over time, while partitioning between the IL stationary phase and carrier gas remained unchanged. It was found that exposure gases composed of 5.0 to 85.0 mol % hydrogen and temperatures ranging from 95 to 130 °C resulted in a remarkable acceleration of silver(I) ion reduction and an approximate 36.4-61.3% decrease in olefin partitioning between the silver(I) ion pseudophase and both the carrier gas and IL stationary phase after 60 h. While binary mixtures of hydrogen and nitrogen resulted in a continuous decrease in silver(I) ion-olefin complexation capability, a ternary gas mixture produced varied silver(I) ion reduction kinetics.

Effect of silver(I) ion reduction on the selectivity of olefins, paraffins, and aromatic compounds by gas chromatographic stationary phases consisting of silver(I) salts in ionic liquids

The olefin/paraffin selectivity offered by ionic liquid (IL) stationary phases can be enhanced through the addition of silver(I) ion, which is well-known to undergo selective complexation with unsaturated compounds. However, such stationary phases often suffer from the loss of chromatographic selectivity as silver(I) ion can be reduced to elemental silver. To maintain the separation performance of silver(I) ion/IL stationary phases, an understanding of factors and conditions that promote the reduction of silver(I) ion is needed. In this study, capillary gas chromatography columns featuring a stationary phase consisting of the 1-decyl-3-methylimidazolium bis[(trifluoromethyl)sulfonyl]imide ([C₁₀MIM⁺][NTf₂^-]) IL impregnated with [Ag⁺][NTf₂^-] were examined to investigate the effects of temperature, hydrogen content in exposure gas stream, and time of heating/exposure events on olefin selectivity. Retention factors of representative analytes, such as C₆ olefins and paraffins as well as aromatic compounds, were measured after subjecting the columns to the aforementioned conditions, followed by an evaluation of selectivity factors over time. Selectivity factors of olefins and aromatic compounds were observed to decrease significantly when the stationary phases were heated to temperatures higher than 110°C as well as being subjected to mixed gas streams containing greater than 50 mol% of hydrogen. As constant column heating temperatures were applied under exposure gas mixtures containing hydrogen and nitrogen, a gradual decrease in analyte selectivity factors was observed under prolonged periods of time. However, application of a ternary gas mixture comprised of 25/50/25 mol% hydrogen/nitrogen/methane resulted in an increase in the 3-hexyne/cis-2-hexene selectivity when measured at 120°C for 60 h, due to a smaller decrease in the retention factor of 3-hexyne compared to cis-2-hexene.