Cloning and nucleotide sequence of a cellulase gene, casA, from an alkalophilic Streptomyces strain

Biochemical Characterization of Novel GH6 Endoglucanase from Myxococcus sp. B6-1 and Its Effects on Agricultural Straws Saccharification

Cellulase has been widely used in many industrial fields, such as feed and food industry, because it can hydrolyze cellulose to oligosaccharides with a lower degree of polymerization. Endo-β-1,4-glucanase is a critical speed-limiting cellulase in the saccharification process. In this study, endo-β-1,4-glucanase gene (CelA257) from Myxococcus sp. B6-1 was cloned and expressed in Escherichia coli. CelA257 contained carbohydrate-binding module (CBM) 4-9 and glycosyl hydrolase (GH) family 6 domain that shares 54.7% identity with endoglucanase from Streptomyces halstedii. The recombinant enzyme exhibited optimal activity at pH 6.5 and 50 °C and was stable over a broad pH (6-9.5) range and temperature < 50 °C. CelA257 exhibited broad substrate specificity to barley β-glucan, lichenin, CMC, chitosan, laminarin, avicel, and phosphoric acid swollen cellulose (PASC). CelA257 degraded both cellotetrose (G₄) and cellppentaose (G₅) to cellobiose (G₂) and cellotriose (G₃). Adding CelA257 increased the release of reducing sugars in crop straw powers, including wheat straw (0.18 mg/mL), rape straw (0.42 mg/mL), rice straw (0.16 mg/mL), peanut straw (0.16 mg/mL), and corn straw (0.61 mg/mL). This study provides a potential additive in biomass saccharification applications.

LplR, a repressor belonging to the TetR family, regulates expression of the L-pantoyl lactone dehydrogenase gene in Rhodococcus erythropolis

The L-pantoyl lactone (L-PL) dehydrogenase (LPLDH) gene (lpldh) has been cloned from Rhodococcus erythropolis AKU2103, and addition of 1,2-propanediol (1,2-PD) was shown to be required for lpldh expression in this strain. In this study, based on an exploration of the nucleotide sequence around lpldh, a TetR-like regulator gene, which we designated lplR, was found upstream of lpldh, and three putative open reading frames existed between the two genes. Disruption of lplR led to 22.8 times higher lpldh expression, even without 1,2-PD induction, than that in wild-type R. erythropolis AKU2103 without 1,2-PD addition. Introduction of a multicopy vector carrying lplR (multi-lplR) into the wild-type and ΔlplR strains led to no detectable LPLDH activity even in the presence of 1,2-PD. The results of an electrophoretic mobility shift assay revealed that purified LplR bound to a 6-bp inverted-repeat sequence located in the promoter/operator region of the operon containing lpldh. These results indicated that LplR is a negative regulator in lpldh expression. Based on the clarification of the expression mechanism of lpldh, recombinant cells showing high LPLDH activity were constructed and used as a catalyst for the conversion of L-PL to ketopantoyl lactone. Finally, a promising production process of D-PL from DL-PL was constructed.

PssO, a unique extracellular protein important for exopolysaccharide synthesis in Rhizobium leguminosarum bv. trifolii

Synthesis and secretion of polysaccharides by Gram-negative bacteria are a result of a concerted action of enzymatic and channel-forming proteins localized in different compartments of the cell. The presented work comprises functional characterization of PssO protein encoded within the previously identified, chromosomal exopolysaccharide (EPS) biosynthesis region (Pss-I) of symbiotic bacterium Rhizobium leguminosarum bv. trifolii TA1 (RtTA1). pssO gene localization between pssN and pssP genes encoding proteins engaged in exopolysaccharide synthesis and transport, suggested its role in EPS synthesis and/or secretion. RtTA1 pssO deletion mutant and the PssO protein overproducing strains were constructed. The mutant strain was EPS-deficient, however, this mutation was not complemented. The PssO-overproducing strain was characterized by increase in EPS secretion. Subcellular fractionation, pssO-phoA/lacZ translational fusion analyses and immunolocalisation of PssO on RtTA1 cell surface by electron microscopy demonstrated that PssO is secreted to the extracellular medium and remains attached to the cell. Western blotting analysis revealed the presence of immunologically related proteins within the species R. leguminosarum bv. trifolii, bv. viciae and Rhizobium etli. The secondary structure of PssO-His(6), as determined by FTIR spectroscopy, consists of at least 32% alpha-helical and 12% beta-sheet structures. A putative function of PssO in EPS synthesis and/or transport is discussed in the context of its cellular localization and the phenotypes of the deletion mutant and pssO-overexpressing strain.

Isolation, characterization and manipulation of cellulase genes

The complete hydrolysis of cellulose requires a number of different enzymes including endoglucanase, exoglucanase and beta-glucosidase. These enzymes function in concert as part of a 'cellulase'complex called a cellulosome. In order (i) to develop a better understanding of the biochemical nature of the cellulase complex as well as the genetic regulation of its integral components and (ii) to utilize cellulases either as purified enzymes or as part of an engineered organism for a variety of purposes, researchers have, as a first step, used recombinant DNA technology to isolate the genes for these enzymes from a variety of organisms. This review provides some perspective on the current status of the isolation, characterization and manipulation of cellulase genes and specifically discusses (i) strategies for the isolation of endoglucanase, exoglucanase and beta-glucosidase genes; (ii) DNA sequence characterization of the cellulase genes and their accompanying regulatory elements; (iii) the expression of cellulase genes in heterologous host organisms and (iv) some of the proposed uses for isolated cellulase genes.

Control by A-factor of a metalloendopeptidase gene involved in aerial mycelium formation in Streptomyces griseus

In Streptomyces griseus, A-factor (2-isocapryloyl-3R-hydroxymethyl-gamma-butyrolactone) switches on aerial mycelium formation and secondary metabolite biosynthesis. An A-factor-dependent transcriptional activator, AdpA, activates multiple genes required for morphological development and secondary metabolism in a programmed manner. A region upstream of a zinc-containing metalloendopeptidase gene (sgmA) was found among the DNA fragments that had been isolated as AdpA-binding sites. The primary product of sgmA consisted of N-terminal pre, N-terminal pro, mature, and C-terminal pro regions. sgmA was transcribed in an AdpA-dependent manner, and its transcription was markedly enhanced at the timing of aerial mycelium formation. AdpA bound two sites in the region upstream of the sgmA promoter; one was at about nucleotide position -60 (A site) with respect to the transcriptional start point of sgmA, and the other was at about position -260 (B site), as determined by DNase I footprinting. Transcriptional analysis with mutated promoters showed that the A site was essential for the switching on of sgmA transcription and that the B site was necessary for the marked enhancement of transcription at the timing of aerial mycelium formation. Disruption of the chromosomal sgmA gene resulted in a delay in aerial hypha formation by half a day. SgmA is therefore suggested to be associated with the programmed morphological development of Streptomyces, in which this peptidase, perhaps together with other hydrolytic enzymes, plays a role in the degradation of proteins in substrate hyphae for reuse in aerial hypha formation.

Characterization and cloning of celR, a transcriptional regulator of cellulase genes from Thermomonospora fusca

CelR, a protein that regulates transcription of cellulase genes in Thermomonospora fusca (Actinomycetaceae) was purified to homogeneity. A 6-kilobase NotI-SacI fragment of T. fusca DNA containing the celR gene was cloned into Esherichia coli and sequenced. The celR gene encodes a 340-residue polypeptide that is highly homologous to members of the GalR-LacI family of bacterial transcriptional regulators. CelR specifically binds to a 14-base pair inverted repeat, which has sequence similarity to the binding sites of other family members. This site is present in regions upstream of all six cellulase genes in T. fusca. The binding of CelR to the celE promoter is inhibited specifically by low concentrations of cellobiose (0.2-0.5 mM), the major end product of cellulases. The other sugars tested did not affect binding at equivalent or 50-fold higher concentrations. The results suggest that CelR may act as a repressor, and that the mechanism of induction involves a direct interaction of CelR with cellobiose.

Regulation of biosynthesis of individual cellulases in Thermomonospora fusca

Regulation of the biosynthesis of the six cellulases comprising the cellulolytic system of the thermophilic soil bacterium Thermomonospora fusca ER1 was studied. The levels of the individual enzymes produced on different noninducing and inducing carbon sources were determined. The lowest level of cellulase synthesis (3 nM) was observed with xylose as a carbon source, and the highest level (247 to 1,670 nM for different enzymes) was found in cultures grown on microcrystalline cellulose. Endocellulases and exocellulases showed distinctly different regulation patterns. Differences in the regulation of individual enzymes appear to be determined by the specific structural organization of the upstream regulatory sequences of their genes.

Microorganisms and enzymes involved in the degradation of plant fiber cell walls

One of natures most important biological processes is the degradation of lignocellulosic materials to carbon dioxide, water and humic substances. This implies possibilities to use biotechnology in the pulp and paper industry and consequently, the use of microorganisms and their enzymes to replace or supplement chemical methods is gaining interest. This chapter describes the structure of wood and the main wood components, cellulose, hemicelluloses and lignins. The enzyme and enzyme mechanisms used by fungi and bacteria to modify and degrade these components are described in detail. Techniques for how to assay for these enzyme activities are also described. The possibilities for biotechnology in the pulp and paper industry and other fiber utilizing industries based on these enzymes are discussed.

Transcriptional regulation of the Rhodococcus rhodochrous J1 nitA gene encoding a nitrilase

The 1.4-kb downstream region from a nitrilase gene (nitA) of an actinomycete Rhodococcus rhodochrous J1, which is industrially in use, was found to be required for the isovaleronitrile-dependent induction of nitrilase synthesis in experiments using a Rhodococcus-Escherichia coli shuttle vector pK4 in a Rhodococcus strain. Sequence analysis of the 1.4-kb region revealed the existence of an open reading frame (nitR) of 957 bp, which would encode a protein with a molecular mass of 35,100. Deletion of the central and 3'-terminal portion of nitR resulted in the complete loss of nitrilase activity, demonstrating that nitR codes for a transcriptional positive regulator in nitA expression. The deduced amino acid sequence of nitR showed similarity to a positive regulator family including XylS from Pseudomonas putida and AraC from E. coli. By Northern blot analysis, the 1.4-kb transcripts for nitA were detected in R. rhodochrous J1 cells cultured in the presence of isovaleronitrile, but not those cultured in the absence of isovaleronitrile. The transcriptional start site for nitA was mapped to a C residue located 26 bp upstream of its translational start site. Deletion analysis to define the nitA promoter region suggested the possible participation of an inverted repeat sequence, centered on base pair -52, in induction of nitA transcription.

Microbial hydrolysis of polysaccharides

Microorganisms are efficient degraders of starch, chitin, and the polysaccharides in plant cell walls. Attempts to purify hydrolases led to the realization that a microorganism may produce a multiplicity of enzymes, referred to as a system, for the efficient utilization of a polysaccharide. In order to fully characterize a particular enzyme, it must be obtained free of the other components of a system. Quite often, this proves to be very difficult because of the complexity of a system. This realization led to the cloning of the genes encoding them as an approach to eliminating other components. More than 400 such genes have been cloned and sequenced, and the enzymes they encode have been grouped into more than 50 families of related amino acid sequences. The enzyme systems revealed in this manner are complex on two quite different levels. First, many of the individual enzymes are complex, as they are modular proteins comprising one or more catalytic domains linked to ancillary domains that often include one or more substrate-binding domains. Second, the systems are complex, comprising from a few to 20 or more enzymes, all of which hydrolyze a particular substrate. Systems for the hydrolysis of plant cell walls usually contain more components than systems for the hydrolysis of starch and chitin because the cell walls contain several polysaccharides. In general, the systems produced by different microorganisms for the hydrolysis of a particular polysaccharide comprise similar enzymes from the same families.

The synthesis of the Streptomyces reticuli cellulase (avicelase) is regulated by both activation and repression mechanisms

The Streptomyces reticuli cellulase (Cell, Avicelase) hydrolyzes crystalline cellulose (Avicel) efficiently to cellobiose. The synthesis of the enzyme is induced by Avicel and repressed by glucose. DNA-binding proteins were purified from induced S. reticuli mycelia by affinity chromatography using the upstream region of the cell gene linked to Sepharose. The enriched protein(s) provoked a gel electrophoresis mobility shift of the upstream region, irrespective of the presence or absence of a 14-bp palindromic sequence, and enhanced the transcription of the cell gene by the S. reticuli RNA polymerase in vitro. The binding site (GTGACTGAGCGCCG) for the protein(s) was located in the vicinity of a DNA bend upstream of the transcriptional start site. Results of physiological studies, deletion and gel-shift analyses lead to the conclusion that a 14-bp palindrome (TGGGAGCGCTCCCA)--situated between the transcriptional start site and the structure gene--is the operator for a repressor protein. The data presented suggest that the two identified cis-acting elements, in cooperation with an activator and a repressor, mediate regulation of cell transcription.

The cellulolytic system of Streptomyces reticuli

The bacterium Streptomyces reticuli produces an unusual mycelia-associated cellulase (Avicelase, Cel1) which is solely sufficient to degrade crystalline cellulose to cellobiose. The enzyme consists of a binding domain, one adjoining region with unknown function, and a catalytic domain belonging to the cellulase family E. During cultivation, the strain produces a specific protease which processes the Avicelase to a truncated enzyme lacking the binding domain. The cellulase synthesis is regulated by induction (Avicel) and repression (metabolizable sugars and glycerol).

Studies of Streptomyces reticuli cel-1 (cellulase) gene expression in Streptomyces strains, Escherichia coli, and Bacillus subtilis

Various streptomyces strains [Streptomyces lividans 66, Streptomyces vinaceus, and Strepotmyces coelicolor A3 (2)] acquired the ability to utilize crystalline cellulose (Avicel) after transformation with a multicopy vector containing the cel-1 gene from Streptomyces reticuli. The expression level in these hosts was two to three times lower than in S. reticuli, indicating the absence of positive regulatory elements. Like S. reticuli, they processed the Avicelase to its catalytic domain and to an enzymatically inactive part. The cel-1 gene with its original upstream region was not expressed within Escherichia coli. When cel-1 had been fused in phase with the lacZ gene, large quantities of the fusion protein were produced in E. coli. However, this protein was enzymatically inactive and proteolytically degraded to a series of truncated forms. As the cellulase (Avicelase) synthesized by S. reticuli is not cleaved by the E. coli proteases, its posttranslational modification is proposed. With Bacillus subtilis as host, the cel-1 gene was expressed neither under its own promoter nor under the control of a strong Bacillus promoter.

Production and secretion of proteins by streptomycetes

Streptomycetes produce a large number of extracellular enzymes as part of their saprophytic mode of life. Their ability to synthesize enzymes as products of their primary metabolism could lead to the production of many proteins of industrial importance. The development of high-yielding expression systems for both homologous and heterologous gene products is of considerable interest. In this article, we review the current knowledge on the various factors that affect the production and secretion of proteins by streptomycetes and try to evaluate the suitability of these bacteria for the large-scale production of proteins of industrial importance.

Cloning and sequencing of an endo-beta-1,4-glucanase gene mcenA from Micromonospora cellulolyticum 86W-16

Endo-beta-1,4-glucanase gene mcenA of Micromonospora cellulolyticum 86W-16 was cloned, and the nucleotide sequence was determined. An open reading frame (ORF) of 1374 bases, coding for a peptide (McenA) of 457 amino acids and 46,742 Da, was found. It is preceded by a Gram-positive type of ribosome-binding site and followed by an imperfect inverted repeat. A putative signal peptide containing 23 amino acids is at the N-terminus and a linker region possessing 37 amino acids is in the midpart of McenA. The N-half of McenA functions as the catalytic domain and the C-half might serve as a cellulose-binding domain (CBD). Deletion of the latter did not decrease the CMCase activity of McenA. Significant similarity (70%) was found between the amino acid sequences of McenA and MbcelA, an endoglucanase from Microbispora bispora.

A beta-glucosidase gene (bgl3) from Streptomyces sp. strain QM-B814. Molecular cloning, nucleotide sequence, purification and characterization of the encoded enzyme, a new member of family 1 glycosyl hydrolases

A beta-glucosidase gene (bgl3) from Streptomyces sp. QM-B814 (American Type Culture Collection 11238) has been cloned by functional complementation of a beta-glucosidase-negative mutant of Streptomyces lividans. An open-reading frame of 1440 nucleotides encoding a polypeptide of 479 amino acids was found by sequencing. The encoded protein (Bgl3) shows extensive similarity (over 45% identity) with beta-glycosidases from family-1 glycosyl hydrolases. The cloned enzyme, purified following ammonium sulphate precipitation and two chromatographic steps, is monomeric with molecular mass 52.6 kDa, as determined by mass spectrometry, and an isoelectric point of pI 4.4. The enzyme appears to be a beta-glucosidase with broad substrate specificity, is active on cellooligomers, and performs transglycosylation reactions. The estimated apparent Km values for p-nitrophenyl-beta-D-glucopyranoside and cellobiose are 0.27 mM and 7.9 mM, respectively. The Ki values for glucose and delta-gluconolactone, using p-nitrophenyl-beta-D-glucopyranoside as a substrate, are 65 mM and 0.08 mM, respectively. The purified enzyme has a pH optimum of pH 6.5 and the temperature optimum for activity is 50 degrees C.

Purification and characterization of the CelB endoglucanase from Streptomyces lividans 66 and DNA sequence of the encoding gene

The endoglucanase CelB isolated from culture filtrates of Streptomyces lividans IAF9 has an M(r) of 36,000. With carboxymethyl cellulose as the substrate, the Vmax and Km values are 110 IU/mg of enzyme and 1.3 mg/ml, respectively. Comparison of primary amino acid sequences classifies CelB in the H family of cellulases.

The biological degradation of cellulose

Cellulolytic microorganisms play an important role in the biosphere by recycling cellulose, the most abundant carbohydrate produced by plants. Cellulose is a simple polymer, but it forms insoluble, crystalline microfibrils, which are highly resistant to enzymatic hydrolysis. All organisms known to degrade cellulose efficiently produce a battery of enzymes with different specificities, which act together in synergism. The study of cellulolytic enzymes at the molecular level has revealed some of the features that contribute to their activity. In spite of a considerable diversity, sequence comparisons show that the catalytic cores of cellulases belong to a restricted number of families. Within each family, available data suggest that the various enzymes share a common folding pattern, the same catalytic residues, and the same reaction mechanism, i.e. either single substitution with inversion of configuration or double substitution resulting in retention of the beta-configuration at the anomeric carbon. An increasing number of three-dimensional structures is becoming available for cellulases and xylanases belonging to different families, which will provide paradigms for molecular modeling of related enzymes. In addition to catalytic domains, many cellulolytic enzymes contain domains not involved in catalysis, but participating in substrate binding, multi-enzyme complex formation, or possibly attachment to the cell surface. Presumably, these domains assist in the degradation of crystalline cellulose by preventing the enzymes from being washed off from the surface of the substrate, by focusing hydrolysis on restricted areas in which the substrate is synergistically destabilized by multiple cutting events, and by facilitating recovery of the soluble degradation products by the cellulolytic organism. In most cellulolytic organisms, cellulase synthesis is repressed in the presence of easily metabolized, soluble carbon sources and induced in the presence of cellulose. Induction of cellulases appears to be effected by soluble products generated from cellulose by cellulolytic enzymes synthesized constitutively at a low level. These products are presumably converted into true inducers by transglycosylation reactions. Several applications of cellulases or hemicellulases are being developed for textile, food, and paper pulp processing. These applications are based on the modification of cellulose and hemicellulose by partial hydrolysis. Total hydrolysis of cellulose into glucose, which could be fermented into ethanol, isopropanol or butanol, is not yet economically feasible. However, the need to reduce emissions of greenhouse gases provides an added incentive for the development of processes generating fuels from cellulose, a major renewable carbon source.

DNA sequences and expression in Streptomyces lividans of an exoglucanase gene and an endoglucanase gene from Thermomonospora fusca

Two genes encoding cellulases E1 and E4 from Thermomonospora fusca have been cloned in Escherichia coli, and their DNA sequences have been determined. Both genes were introduced into Streptomyces lividans, and the enzymes were purified from the culture supernatants of transformants. E1 and E4 were expressed 18- and 4-fold higher, respectively, in S. lividans than in E. coli. Thin-layer chromatography of digestion products showed that E1 digests cellotriose, cellotetraose, and cellopentaose to cellobiose and a trace of glucose. E4 is poor at degrading cellotriose and cleaves cellopentaose to cellotetraose and glucose or cellotriose and cellobiose. It readily cleaves cellotetraose to cellobiose. E1 shows 59% identity to Cellulomonas fumi CenC in a 689-amino-acid overlap, and E4 shows 80% identity to the N terminus of C. fimi CenB in a 441-amino-acid overlap; all of these proteins are members of cellulase family E. Alignment of the amino acid sequences of Clostridium thermocellum celD, E1, E4, and four other members of family E demonstrates a clear relationship between their catalytic domains, although there is as little as 25% identity between some of them. Residues in celD that have been identified by site-directed mutagenesis and chemical modification to be important for catalytic activity are conserved in all seven proteins. The catalytic domains of E1 and E4 are not similar to those of T. fusca E2 or E5, but all four enzymes share similar cellulose-binding domains and have the same 14-bp inverted repeat upstream of their initiation codons. This sequence has been identified previously as the binding site for a protein that regulates induction.

Hidden domains and active site residues in beta-glycanase-encoding gene sequences?

Reading-frame corrective shifts in the nucleotide sequence upstream, within, or downstream from the putative coding region of several beta-glycanase-encoding genes reported in the literature reveal hidden active-site residues or even additional domains, including a cellulose-binding domain on a beta-mannanase-encoding gene. These findings also help in assigning, to cellulase family A, two enzymes previously found to lack sequence similarity with known cellulase families.

Endoglucanase CasA from alkalophilic Streptomyces strain KSM-9 is a typical member of family B of beta-1,4-glucanases

CasA is an endo-beta-1,4-glucanase from Streptomyces KSM-9 belonging to family B of beta-1,4-glucanases. A previous analysis of a portion of the corresponding gene (casA) revealed sequencing errors in a region encoding part of the catalytic site. Additional errors in the original sequence were suspected, based on sequence comparison of the C terminus of CasA with other members of its family. Re-sequencing of the remainder of the casA coding region showed that CasA is a typical member of family B.

Streptomyces lividans glycosylates an exoglucanase (Cex) from Cellulomonas fimi

Exoglucanase Cex from Cellulomonas fimi is a glycoprotein [Langsford et al., J. Gen. Microbiol. 130 (1984) 1367-1376]. Cex produced by Streptomyces lividans from the cloned cex gene is also glycosylated. The extent and nature of glycosylation are similar for Cex from both organisms. The glycosylation affords protection against proteolysis for the enzymes from both organisms when they are bound to cellulose, but not in solution. The ability to glycosylate cloned gene products enhances the utility of Streptomyces as a host for the production of heterologous polypeptides.

Cloning, expression, and characterization of the Micromonospora viridifaciens neuraminidase gene in Streptomyces lividans

We have cloned the Micromonospora viridifaciens neuraminidase (EC 3.2.1.18) gene (nedA) in Streptomyces lividans. This was accomplished by using the vector pIJ702 and BglII-BclI libraries of M. viridifaciens chromosomal inserts created in S. lividans. The libraries were screened for the expression of neuraminidase by monitoring the cleavage of the fluorogenic neuraminidase substrate 2'-(4-methylumbelliferyl)-alpha-D-N-acetyl-neuraminic acid. Positive clones (BG6, BG7, BC4, and BC8) contained the identical 2-kb BclI-BglII fragment and expressed neuraminidase efficiently and constitutively using its own promoter in the heterologous host. From the nucleotide sequence analysis, an open reading frame of 1,941 bp which encodes a polypeptide with an M(r) of 68,840 was detected. The deduced amino acid sequence has five Asp boxes, -Ser-X-Asp-X-Gly-X-Thr-Trp, showing great similarity to other bacterial and viral neuraminidases. We have also identified the catalytic domain by using truncated proteins produced in S. lividans.

Biochemical and Electron Microscopic Studies of the Streptomyces reticuli Cellulase (Avicelase) in Its Mycelium-Associated and Extracellular Forms

Streptomyces reticuli is able to grow efficiently with crystalline cellulose (Avicel) as the sole carbon source. Cultivation in the presence of the nonionic detergent Tween 80 at a concentration of 0.1% led to a 10-fold increase in extracellular cellulolytic activity. Under these conditions, one single 82-kDa cellulase (Avicelase) capable of degrading crystalline and soluble cellulose as well as cellodextrins and p -nitrophenylcellobioside was purified to apparent homogeneity by a procedure which consisted of two consecutive anion-exchange chromatographies followed by chromatofocusing. Aggregation, which was a major problem during protein purification, could be avoided by including Triton X-100 at a concentration of 0.1% in every chromatographic step. The Avicelase was identified in extracellular and mycelium-associated forms, the latter of which could be released efficiently by nonionic detergents. In addition, a 42-kDa truncated form retaining cellulolytic activity was identified which had been generated from the 82-kDa enzyme by a protease. Antibodies raised against the mycelium-associated Avicelase reacted with the 42-kDa derivative and the extracellular form. The mycelial association of the enzyme was confirmed by immunofluorescence and immunoelectron microscopies.

Cloning and nucleotide sequence of celA1, and endo-beta-1,4-glucanase-encoding gene from Streptomyces halstedii JM8

The celA1 gene encoding an endo-beta-1,4-glucanase from a mesophilic actinomycete, strain JM8, identified as Streptomyces halstedii, was cloned and expressed in S. lividans JI66. From the nucleotide sequence of a 1.7-kb DNA fragment we identified an open reading frame of 963 nucleotides encoding a protein of 321 amino acids, starting at TTG (instead of ATG). The Cel1 mature enzyme is a protein of 294 amino acids (after signal peptide cleavage) and can be included in the beta-glycanase family B (N. R. Gilkes, B. Henrissat, D. G. Kilburn, R. C. Miller, Jr., and R. A. J. Warren, Microbiol. Rev. 55:303-315, 1991). The Cel1 enzyme lacks a cellulose-binding domain as predicted by computer analysis of the sequence and confirmed by Avicel binding experiments. The promoter region of celA1 was identified by S1 mapping; the -35 region closely resembles those of housekeeping Streptomyces promoters. Three imperfectly repeated sequences of 15, 15, and 14 nucleotides were found upstream from celA1 [ATTGGGACCGCTTCC-(N85)-ATTGGGACCGCTTCC-(N2)-TGGGAGC GCTCCCA]; The 14-nucleotide sequence has a perfect palindrome identical to that found in several cellulase-encoding genes from Thermomonospora fusca, an alkalophilic Streptomyces strain, and Streptomyces lividans. This sequence has been implicated in the mechanism of induction exerted by cellobiose. Using an internal celA1 probe, we detected similar genes in several other Streptomyces species, most of them cellulase producers.

A metalloprotease gene from Streptomyces coelicolor 'Müller' and its transcriptional activator, a member of the LysR family

A metalloprotease gene (mprA) and its regulatory gene (mprR) from Streptomyces coelicolor 'Müller' DSM3030 were isolated and their DNA sequences determined. The protease secreted by the heterologous host Streptomyces lividans was characterized biochemically as a metalloprotease with a M(r) of 20,000, which is in good agreement with data derived from DNA sequence analysis. The mprA gene is transcribed divergently from mprR, the deduced protein of which displays homology to prokaryotic transcriptional regulators of the LysR family. The regulatory protein (MprR) was shown to bind to the intergenic region between mprR and mprA. It was found to activate transcription of mprA in S. lividans and also in Escherichia coli.

Compilation and analysis of DNA sequences associated with apparent streptomycete promoters

The DNA sequences associated with 139 apparent streptomycete transcriptional start sites are compiled and compared. Of these, 29 promoters appeared to belong to a group which are similar to those recognized by eubacterial RNA polymerases containing sigma 70-like subunits. The other 110 putative promoter regions contain a wide diversity of sequences; several of these promoters have obvious sequence similarities in the -10 and/or -35 regions. The apparent Shine-Dalgarno regions of 44 streptomycete genes are also examined and compared. These were found to have a wide range of degree of complementarity to the 3' end of streptomycete 16S rRNA. Eleven streptomycete genes are described and compared in which transcription and translation are proposed to be initiated from the same or nearby nucleotide. An updated consensus sequence for the E sigma 70-like promoters is proposed and a potential group of promoter sequences containing guanine-rich -35 regions also is identified.

Purification and characterization of an endoglucanase from Streptomyces lividans 66 and DNA sequence of the gene

The endoglucanase isolated from culture filtrates of Streptomyces lividans IAF74 was shown to have an Mr of 46,000 and a pI of 3.3. The specific enzyme activity of 539 IU/mg, determined by the reducing assay method on carboxymethyl cellulose, is among the highest reported in the literature. The cellulase showed typical endo-type activity when reacting on oligocellodextrins. Optimal enzyme activity was obtained at 50 degrees C and pH 5.5. The kinetic constants for this endoglucanase, determined with carboxymethyl cellulose as the substrate, were a Vmax of 24.9 IU/mg of enzyme and a Km of 4.2 mg/ml. Activity was found against neither methylumbelliferyl- nor p-nitrophenyl-cellobiopyranoside nor with xylan. The DNA sequence contains one possible reading frame validated by the N terminus of the mature purified protein. However, neither ATG nor GTG starting codons were identified near the ribosome-binding site. A putative TTG codon was found as a good candidate for the start codon. Comparison of the primary amino acid sequence of the endoglucanase of S. lividans revealed that the N terminus contains a bacterial cellulose-binding domain. The catalytic domain at the C terminus showed similarity to endoglucanases from a Bacillus sp. Thus, the endoglucanase CelA belongs to family A of cellulases as described before (N. R. Gilkes, B. Henrissat, D. G. Kilburn, R. C. Miller, Jr., and R. A. J. Warren, Microbiol. Rev. 55:303-315, 1991.

Cloning and characterization of a gene encoding extracellular metalloprotease from Streptomyces lividans

The prt gene, encoding a protease (Prt) from Streptomyces lividans TK24, was cloned and sequenced. An S. lividans host with plasmid-borne prt secreted 200 micrograms/ml of a 22-kDa Prt into the culture medium. Prt is classified as a metalloprotease since its activity is significantly inhibited by 1,10-phenanthroline or EDTA. The region upstream from prt codes for an incomplete open reading frame (ORF) oriented opposite to prt. This ORF has a strong similarity to a gene family (lysR) whose members regulate the transcription of structural genes required for either biosynthesis or degradation.

Streptomyces: a host for heterologous gene expression

Streptomyces species offer many potential advantages as hosts for the expression and secretion of eukaryotic gene products. In this review we discuss the expression and localization signals that have been used to direct heterologous gene expression and the applications of these signals. Finally, we discuss future strategies aimed at increasing the capacity of this host for the high level production of biologically active eukaryotic gene products.

Biochemistry and genetics of actinomycete cellulases

The order Actinomycetales includes a number of genera that contain species that actively degrade cellulose and these include both mesophilic and facultative thermophilic species. Cellulases produced by strains from two of the genera containing thermophilic organisms have been studied extensively: Microbispora bispora and Thermomonospora fusca. Fractionation of M. bispora cellulases has identified six different enzymes, all of which were purified to near homogeneity and partially characterized. Two of these enzymes appear to be exocellulases and gave synergism with each other and with the endocellulases. The structural genes of five M. bispora cellulases have been cloned and one was sequenced. Fractionation of T. fusca cellulases has identified five different enzymes, all of which were purified to near homogeneity and partially characterized. One of the T. fusca enzymes gives synergism in the hydrolysis of crystalline cellulose with several T. fusca endocellulases and with Trichoderma reesei CBHI but not with T. reesei CBHII. Each T. fusca cellulase contains distinct catalytic and cellulose binding domains. The structural genes of four of the T. fusca endoglucanases have been cloned and sequenced, while three cellulase genes have been cloned from "T. curvata". The T. fusca cellulase genes are expressed at a low level in Escherichia soli, but at a high level in Streptomyces lividans. Sequence comparisons have shown that there are no significant amino acid homologies between any of the catalytic domains of the four T. fusca cellulases, but each of them shows extensive homology to several other cellulases and fits in one of the five existing cellulase gene families. There have been extensive studies of the regulation of the synthesis of these cellulases and a number of regulatory mutants have been isolated. This work has shown that the different T. fusca cellulases are coordinately regulated over a 100-fold range by two independent controls; induction by cellobiose and repression by any good carbon source.

Structural and functional relationships in two families of beta-1,4-glycanases

CenA and Cex are beta-1,4-glycanases produced by the cellulolytic bacterium Cellulomonas fimi. Both enzymes are composed of two domains and contain six Cys residues. Two disulfide bonds were assigned in both enzymes by peptide analysis of the isolated catalytic domains. A further disulfide bond was deduced in both cellulose-binding domains from the absence of free thiols under denaturing conditions. Corresponding Cys residues are conserved in eight of nine other known C. fimi-type cellulose-binding domains. CenA and Cex belong to families B and F, respectively, in the classification of beta-1,4-glucanases and beta-1,4-xylanases based on similarities in catalytic domain primary structure. Disulfide bonds in the CenA catalytic domain correspond to the two disulfide bonds in the catalytic domain of Trichoderma reesei cellobiohydrolase II (family B) which stabilize loops forming the active-site tunnel. Sequence alignment indicates the probable occurrence of disulfides at equivalent positions in the two other family B enzymes. Partial resequencing of the gene encoding Streptomyces KSM-9 beta-1,4-glucanase CasA (family B) revealed five errors in the original nucleotide sequence analysis. The corrected amino acid sequence contains an Asp residue corresponding to the proposed proton donor in hydrolysis catalysed by cellobiohydrolase II. Cys residues which form disulfide bonds in the Cex catalytic domain are conserved in XynZ of Clostridium thermocellum and Xyn of Cryptococcus albidus but not in the other eight known family F enzymes. Like other members of its family, Cex catalyses xylan hydrolysis. The catalytic efficiency (kcat/Km) for hydrolysis of the heterosidic bond of p-nitrophenyl-beta-D-xylobioside is 14,385 min-1.mM-1 at 25 degrees C; the corresponding kcat/Km for p-nitrophenyl-beta-D-cellobioside hydrolysis is 296 min-1.mM-1.

Genetics of streptomycin production in Streptomyces griseus: nucleotide sequence of five genes, strFGHIK, including a phosphatase gene

The cluster of streptomycin (SM) production genes in Streptomyces griseus was further analysed by determining the nucleotide sequence of genes strFGHIK. The products of the strF and/or strG genes may be involved in the formation of N-methyl-L-glucosamine, and that of the strH gene in the first glycosylation step condensing streptidine-6-phosphate and dihydrostreptose. The putative StrI protein showed strong similarity to the amino-terminal NAD(P)-binding sites of many dehydrogenases, especially of the glyceraldehyde-3-phosphate dehydrogenases. The product of the strK gene strongly resembles the alkaline phosphatase of Escherichia coli. It was shown that S. griseus excretes an enzyme that specifically cleaves both SM-6-phosphate and--more slowly--SM-3''-phosphate ate during the production phase for SM. The identity of this enzyme with the StrK protein was demonstrated by expression of the strK gene in Streptomyces lividans 66. Further evidence for an involvement of these genes in SM biosynthesis came from the fact that genes homologous to them were found in the equivalent gene cluster of the hydroxy-SM producer Streptomyces glaucescens; these, however, were in part differently organized. The ca. 5 kb DNA segment downstream of strI in S. griseus which contains the strK gene was found to be located in inverse orientation between the homologues of the aphD and strR genes in S. glaucescens.

Increased yield of a lysozyme after self-cloning of the gene in Streptomyces coelicolor "Müller"

Streptomyces coelicolor "Müller" DSM3030 excretes a lysozyme comprising both beta-1,4-N-acetyl- and beta-1,4-N,6-O-diacetyl muramidase activities. The lysozyme is named Cellosyl. Gene libraries have been established using genomic DNA from the wild-type strain, S. coelicolor DSM3030, and from an overproducing mutant, S. coelicolor HP1, which exhibits about a twofold increase in lysozyme production. The lysozyme-encoding genes (cel) from both strains were detected by oligodeoxynucleotide hybridization. The nucleotide sequence of the cel genes isolated from both strains was shown to be identical. The different levels of lysozyme production could not be correlated with any mutations at the cel gene locus. The cel gene isolated from the wild-type strain could not be expressed in some other species of Streptomyces. However, self-cloning of the cel gene into S. coelicolor DSM3030 and HP1 resulted in a 2.5-fold increase in lysozyme production.

Domains in microbial beta-1, 4-glycanases: sequence conservation, function, and enzyme families

Several types of domain occur in beta-1, 4-glycanases. The best characterized of these are the catalytic domains and the cellulose-binding domains. The domains may be joined by linker sequences rich in proline or hydroxyamino acids or both. Some of the enzymes contain repeated sequences up to 150 amino acids in length. The enzymes can be grouped into families on the basis of sequence similarities between the catalytic domains. There are sequence similarities between the cellulose-binding domains, of which two types have been identified, and also between some domains of unknown function. The beta-1, 4-glycanases appear to have arisen by the shuffling of a relatively small number of progenitor sequences.

DNA sequences of three beta-1,4-endoglucanase genes from Thermomonospora fusca

The DNA sequences of the Thermomonospora fusca genes encoding cellulases E2 and E5 and the N-terminal end of E4 were determined. Each sequence contains an identical 14-bp inverted repeat upstream of the initiation codon. There were no significant homologies between the coding regions of the three genes. The E2 gene is 73% identical to the celA gene from Microbispora bispora, but this was the only homology found with other cellulase genes. E2 belongs to a family of cellulases that includes celA from M. bispora, cenA from Cellulomonas fimi, casA from an alkalophilic Streptomyces strain, and cellobiohydrolase II from Trichoderma reesei. E4 shows 44% identity to an avocado cellulase, while E5 belongs to the Bacillus cellulase family. There were strong similarities between the amino acid sequences of the E2 and E5 cellulose binding domains, and these regions also showed homology with C. fimi and Pseudomonas fluorescens cellulose binding domains.

Recent advances in rumen microbial ecology and metabolism: potential impact on nutrient output

Feedstuffs consumed by ruminants are all initially exposed to fermentative activity in the rumen prior to gastric and intestinal digestion. The extent and type of transformation of feedstuffs thus determines the productive performance of the host. Research on rumen microbial ecology and metabolism is essentially a study of the interactions between the host, microorganisms present, substrates available, and end products of digestion. Furthermore, the interactions of the normal microbial flora with the host can be manipulated to improve the efficiency of nutrient utilization in ruminant animals. Three important areas of ruminal fermentation will be reviewed, N metabolism, fiber degradation, and biotransformation of toxic compounds. The extent of protein degradation and the rate of uptake of resultant peptides and ammonia are extremely important factors in determining the efficiency of N utilization by rumen bacteria and, therefore, the relative amounts of microbial or bypass protein available to the host. Strategies aimed at identifying and characterizing rate-limiting enzymes of cellulolytic bacteria are essential in elucidating mechanisms involved in ruminal fiber degradation. Results obtained with ruminococci will be described. The detoxification of phytotoxins by passage through the gastrointestinal tract of ruminants is a process deserving special attention and several examples will be presented. Opportunities for manipulation of rumen fermentation are good. However, successful manipulation and full exploitation depend on a through understanding of the mechanisms involved.

Three-dimensional structure of cellobiohydrolase II from Trichoderma reesei

The enzymatic degradation of cellulose is an important process, both ecologically and commercially. The three-dimensional structure of a cellulase, the enzymatic core of CBHII from the fungus Trichoderma reesei reveals an alpha-beta protein with a fold similar to but different from the widely occurring barrel topology first observed in triose phosphate isomerase. The active site of CBHII is located at the carboxyl-terminal end of a parallel beta barrel, in an enclosed tunnel through which the cellulose threads. Two aspartic acid residues, located in the center of the tunnel are the probable catalytic residues.

Cloning and sequencing of a Bacteroides ruminicola B(1)4 endoglucanase gene

Bacteroides ruminicola B(1)4, a noncellulolytic rumen bacterium, produces an endoglucanase (carboxymethylcellulase [CMCase]) that is excreted into the culture supernatant. Cultures grown on glucose, fructose, maltose, mannose, and cellobiose had high specific activities of CMCase (greater than 3 mmol of reducing sugar per mg of protein per min), but its synthesis was repressed by sucrose. B. rumincola did not grow on either ball-milled or acid-swollen cellulose even though the CMCase could hydrolyze swollen cellulose. The CMCase gene was cloned into Escherichia coli, and its nucleotide sequence contained a single open reading frame coding for a protein of 40,481 daltons. The enzyme was overproduced in E. coli under the control of the tac promoter and purified to homogeneity. The N-terminal sequence, amino acid composition, and molecular weight of the purified enzyme were similar to the values predicted from the open reading frame of the DNA sequence. However, the CMCase present in B. ruminicola was found to have a monomer molecular weight of 88,000 by Western immunoblotting. This discrepancy appeared to have resulted from our having cloned only part of the CMCase gene into E. coli. The amino acid sequence of the CMCase showed homology to sequences of beta-glucanases from Ruminococcus albus and Clostridium thermocellum.

Cloning and nucleotide sequence of the N-acetylmuramidase M1-encoding gene from Streptomyces globisporus

The gene (acm) encoding N-acetylmuramidase M1 (ACM) was cloned of Streptomyces globisporus ATCC No. 21553. The nucleotide sequence of the acm gene was determined and found to code for an ORF of 294 amino acids (aa). Comparison of aa sequence deduced from the acm gene with the N-terminal sequence of the extracellular enzyme suggests that ACM is synthesized with a 77-aa leader peptide. A comparison of the ACM aa sequence with the aa sequences of other proteins in the NBRF data base reveals that ACM has strong similarity to the N-O-diacetylmuramidase secreted by the fungus Chalaropsis.

Purification and characterization of endoglucanase C of Cellulomonas fimi, cloning of the gene, and analysis of in vivo transcripts of the gene

Two nonglycosylated endoglucanases which bind to Sephadex were purified from culture supernatants of Cellulomonas fimi grown on microcrystalline cellulose. Their Mrs were 120,000 and 130,000. The N-terminal amino acid sequences of the enzymes were identical, suggesting that the enzymes were related. A DNA fragment encoding this N-terminal sequence was cloned in Escherichia coli. The nucleotide sequence corresponding to the N-terminal amino acid sequence was preceded by a sequence encoding a typical leader peptide. Transcripts hybridizing to the cloned fragment were detected in total RNA isolated from C. fimi cells grown on carboxymethyl cellulose but not from cells grown on glycerol or glucose. Transcription started at a cluster of sites 53 to 59 nucleotides upstream of a GUG translation initiation codon and terminated at either of two closely spaced C residues immediately downstream of a region of potential secondary structure. The size of the transcript was approximately 3.5 kilobases, sufficient to encode a polypeptide of 130 kilodaltons. The 130-kilodalton polypeptide is designated endoglucanase C (CenC), and the gene encoding it is designated cenC.

Cellulase families revealed by hydrophobic cluster analysis

The amino acid sequences of 21 beta-glycanases have been compared by hydrophobic cluster analysis. Six families of cellulases have been identified on the basis of primary structure homology: (A) endoglucanases B, C and E of Clostridium thermocellum; endoglucanases of Erwinia chrysanthemi and Bacillus sp.; endoglucanase III of Trichoderma reesei; endoglucanase I of Schizophyllum commune; (B) cellobiohydrolase II of T. reesei; endoglucanases of Cellulomonas fimi and Streptomyces sp; (C) cellobiohydrolases I of T. reesei and of Phanerochaete chrysosporium; endoglucanase I of T. reesei; (D) endoglucanase A of C. thermocellum and an endoglucanase from Ce. uda; (E) endoglucanase D of C. thermocellum and an endoglucanase from Pseudomonas fluorescens; (F) xylanases of C. thermocellum and of Cryptococcus albidus and the cellobio-hydrolase of Ce. fimi. For each family, conserved potentially catalytic residues have have been listed and previous allocations of the active-site residues are evaluated in the light of the alignment of the amino acid sequences. A strong homology is also reported for the putative cellulose-binding domains of cellulases of Ce. fimi and of P. fluorescens.

Species-specific variation in signal peptide design. Implications for protein secretion in foreign hosts

Secretory signal peptides from individual prokaryotic and eukaryotic species have been analyzed, and the lengths and amino acid compositions of the positively charged amino-terminal region, the central hydrophobic region, and the carboxy-terminal cleavage-region have been compared. We find distinct differences between species in all three regions. Implications for protein secretion in foreign hosts are discussed.