1
|
Li Q, Xu Y, Chen S, Liang C, Guo W, Ngo HH, Peng L. Inorganic carbon limitation decreases ammonium removal and N 2O production in the algae-nitrifying bacteria symbiosis system. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 928:172440. [PMID: 38614328 DOI: 10.1016/j.scitotenv.2024.172440] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/05/2024] [Revised: 04/08/2024] [Accepted: 04/10/2024] [Indexed: 04/15/2024]
Abstract
Ammonium removal by a symbiosis system of algae (Chlorella vulgaris) and nitrifying bacteria was evaluated in a long-term photo-sequencing batch reactor under varying influent inorganic carbon (IC) concentrations (15, 10, 5 and 2.5 mmol L-1) and different nitrogen loading rate (NLR) conditions (270 and 540 mg-N L-1 d-1). The IC/N ratios provided were 2.33, 1.56, 0.78 and 0.39, respectively, for an influent NH4+-N concentration of 90 mg-N L-1 (6.43 mmol L-1). The results confirmed that both ammonium removal and N2O production were positively related with IC concentration. Satisfactory ammonium removal efficiencies (>98 %) and rates (29-34 mg-N gVSS-1 h-1) were achieved regardless of NLR levels under sufficient IC of 10 and 15 mmol L-1, while insufficient IC at 2.5 mmol L-1 led to the lowest ammonium removal rates of 0 mg-N gVSS-1 h-1. The ammonia oxidation process by ammonia oxidizing bacteria (AOB) played a predominant role over the algae assimilation process in ammonium removal. Long-time IC deficiency also resulted in the decrease in biomass and pigments of algae and nitrifying bacteria. IC limitation led to the decreasing N2O production, probably due to its negative effect on ammonia oxidation by AOB. The optimal IC concentration was determined to be 10 mmol L-1 (i.e., IC/N of 1.56, alkalinity of 500 mg CaCO3 L-1) in the algae-bacteria symbiosis reactor, corresponding to higher ammonia oxidation rate of ∼41 mg-N gVSS-1 h-1 and lower N2O emission factor of 0.13 %. This suggests regulating IC concentrations to achieve high ammonium removal and low carbon emission simultaneously in the algae-bacteria symbiosis wastewater treatment process.
Collapse
Affiliation(s)
- Qi Li
- Key Laboratory of Green Utilization of Critical Non-metallic Mineral Resources, Ministry of Education, Wuhan University of Technology, Wuhan 430070, China; Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China
| | - Yifeng Xu
- Key Laboratory of Green Utilization of Critical Non-metallic Mineral Resources, Ministry of Education, Wuhan University of Technology, Wuhan 430070, China; Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China.
| | - Shi Chen
- School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China
| | - Chuanzhou Liang
- Key Laboratory of Green Utilization of Critical Non-metallic Mineral Resources, Ministry of Education, Wuhan University of Technology, Wuhan 430070, China; Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China
| | - Wenshan Guo
- Centre for Technology in Water and Wastewater, School of Civil and Environmental Engineering, University of Technology Sydney, Sydney, New South Wales 2007, Australia
| | - Huu Hao Ngo
- Centre for Technology in Water and Wastewater, School of Civil and Environmental Engineering, University of Technology Sydney, Sydney, New South Wales 2007, Australia
| | - Lai Peng
- Key Laboratory of Green Utilization of Critical Non-metallic Mineral Resources, Ministry of Education, Wuhan University of Technology, Wuhan 430070, China; Hubei Key Laboratory of Mineral Resources Processing and Environment, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China; School of Resources and Environmental Engineering, Wuhan University of Technology, Luoshi Road 122, Wuhan 430070, China.
| |
Collapse
|
2
|
Sobolewska E, Borowski S, Nowicka-Krawczyk P, Jurczak T. Growth of microalgae and cyanobacteria consortium in a photobioreactor treating liquid anaerobic digestate from vegetable waste. Sci Rep 2023; 13:22651. [PMID: 38114556 PMCID: PMC10730507 DOI: 10.1038/s41598-023-50173-6] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/18/2023] [Accepted: 12/15/2023] [Indexed: 12/21/2023] Open
Abstract
This research examines the biological treatment of undiluted vegetable waste digestate conducted in a bubble column photobioreactor. Initially, the bioreactor containing 3N-BBM medium was inoculated with Microglena sp., Tetradesmus obliquus, and Desmodesmus subspicatus mixture with a density of 1.0 × 104 cells/mL and the consortium was cultivated for 30 days. Then, the bioreactor was semi-continuously fed with liquid digestate with hydraulic retention time (HRT) of 30 days, and the treatment process was continued for the next 15 weeks. The change in the microalgal and cyanobacterial species domination was measured in regular intervals using cell counting with droplet method on a microscope slide. At the end of the experiment, Desmonostoc sp. cyanobacteria (identified with 16S ribosomal RNA genetical analysis) as well as Tetradesmus obliquus green algae along with Rhodanobacteraceae and Planococcaceae bacteria (determined with V3-V4 16sRNA metagenomic studies) dominated the microbial community in the photobioreactor. The experiment demonstrated high treatment efficiency, since nitrogen and soluble COD were removed by 89.3 ± 0.5% and 91.2 ± 1.6%, respectively, whereas for phosphates, 72.8 ± 2.1% removal rate was achieved.
Collapse
Affiliation(s)
- Ewelina Sobolewska
- Interdisciplinary Doctoral School, Lodz University of Technology, 116 Żeromskiego street, 90-924, Lodz, Poland.
- Department of Environmental Biotechnology, Faculty of Biotechnology and Food Sciences, Lodz University of Technology, 171/173 Wólczańska street, 90-530, Lodz, Poland.
| | - Sebastian Borowski
- Department of Environmental Biotechnology, Faculty of Biotechnology and Food Sciences, Lodz University of Technology, 171/173 Wólczańska street, 90-530, Lodz, Poland
| | - Paulina Nowicka-Krawczyk
- Department of Algology and Mycology, Faculty of Biology and Environmental Protection, University of Lodz, 12/16 Banacha street, 90-237, Lodz, Poland
| | - Tomasz Jurczak
- UNESCO Chair On Ecohydrology and Applied Ecology, Faculty of Biology and Environmental Protection, University of Lodz, 12/16 Banacha street, 90-237, Lodz, Poland
| |
Collapse
|
3
|
Nagabalaji V, Maharaja P, Nishanthi R, Sathish G, Suthanthararajan R, Srinivasan SV. Effect of co-culturing bacteria and microalgae and influence of inoculum ratio during the biological treatment of tannery wastewater. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2023; 341:118008. [PMID: 37146488 DOI: 10.1016/j.jenvman.2023.118008] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/01/2023] [Revised: 04/12/2023] [Accepted: 04/22/2023] [Indexed: 05/07/2023]
Abstract
This present investigation is carried out to study the effect of algal and bacterial inoculum concentrations on the removal of organic pollutants and nutrients from the tannery effluent by the combined symbiotic treatment process. The bacterial and microalgal consortia was developed in laboratory setup and mixed together to perform this study. The Influence of algae and bacteria inoculum concentrations on the removal of pollutants such as Chemical Oxygen Demand (COD) and Total Kjeldahl Nitrogen (TKN) were studied using statistical optimization through Response surface methodology. For the design of experimental set up and optimization, full factorial Central composite design was used. The profiles of pH, Dissolved Oxygen (DO) and nitrate were also monitored and studied. The inoculum concentrations of microalgae and bacteria showed significant effect on Co-culturing on COD, TKN and nitrate removals as major response. The linear effect of bacterial inoculum has positive dominant influence on COD and TKN removal efficiencies. Nitrate utilization by microalgae increases with the increase in microalgal inoculum concentration. The maximum removal efficiencies of COD and TKN with 89.9% and 80.9% were obtained at optimum bacterial and algal inoculum concentrations of 6.7 g/L and 8.0 g/L respectively. These outcomes of this study are immensely favorable for maximizing the COD and nitrogen (nutrients) removal capabilities of microalgae-bacterial consortia in tannery effluent.
Collapse
Affiliation(s)
- Velmurugan Nagabalaji
- Environmental Engineering Department, CSIR-Central Leather Research Institute, Chennai, 600 020, India; Academy of Scientific and Industrial Research (AcSIR), Ghaziabad, 201002, India.
| | - Pounsamy Maharaja
- Environmental Engineering Department, CSIR-Central Leather Research Institute, Chennai, 600 020, India
| | - Rajendiran Nishanthi
- Environmental Engineering Department, CSIR-Central Leather Research Institute, Chennai, 600 020, India
| | - Ganesan Sathish
- Environmental Engineering Department, CSIR-Central Leather Research Institute, Chennai, 600 020, India
| | | | - Shanmugham Venkatachalam Srinivasan
- Environmental Engineering Department, CSIR-Central Leather Research Institute, Chennai, 600 020, India; Academy of Scientific and Industrial Research (AcSIR), Ghaziabad, 201002, India.
| |
Collapse
|
4
|
Morán-Valencia M, Nishi K, Akizuki S, Ida J, Cuevas-Rodríguez G, Cervantes-Avilés P. Nitrogen removal from wastewater by an immobilized consortium of microalgae-bacteria in hybrid hydrogels. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2023; 87:527-538. [PMID: 36789701 DOI: 10.2166/wst.2023.001] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/18/2023]
Abstract
The high content of nitrogen in wastewater brings some operational, technical, and economical issues in conventional technologies. The aim of this study was to evaluate the nitrogen removal by hybrid hydrogels containing consortium microalgae-nitrifying bacteria in the presence of activated carbon (AC) used as an adsorbent of inhibitory substances. Hybrid hydrogels were synthesized from polyvinyl alcohol (PVA), sodium alginate (SA), biomass (microalgae-nitrifying bacteria), and AC. The hybrid hydrogels were evaluated based on the change in ammonium (NH4), nitrate (NO3), and chemical demand of oxygen (COD) concentrations, nitrification rate, and other parameters during 72 h. Results indicated that NH4 removal was more effective for hydrogels without AC than with AC, without significant differences regarding consortium biomass concentration (5 or 16%), presenting final concentrations of 3.13 and 3.75 mg NH4/L for hydrogels with 5 and 16% of the biomass, respectively. Regarding NO3 production, hydrogels without AC reached concentrations of 25.9 and 39.77 mg NO3/L for 5 and 16% of the biomass, respectively, while treatments with AC ended with 2.17 and 1.37 mg NO3/L. This confirms that hydrogels can carry out the nitrification process and do not need AC to remove potential inhibitors. The best performance was observed for the hydrogel with 5% of biomass without AC with a nitrification rate of 0.43 mg N/g TSS·h.
Collapse
Affiliation(s)
- Marien Morán-Valencia
- Escuela de Ingeniería y Ciencias, Tecnológico de Monterrey, Campus Puebla, Vía Atlixcáyotl 5718, Reserva Territorial Atlixcáyotl, Puebla, Puebla 72453, Mexico
| | - Kento Nishi
- Department of Science and Engineering for Sustainable Innovation, Faculty of Science and Engineering, Soka University, 1-236, Tangi-machi, Hachioji, Tokyo 192-8577, Japan
| | - Shinichi Akizuki
- Institute of Plankton Eco-Engineering, Soka University, 1-236, Tangi-machi, Hachioji, Tokyo 192-8577, Japan
| | - Junichi Ida
- Department of Science and Engineering for Sustainable Innovation, Faculty of Science and Engineering, Soka University, 1-236, Tangi-machi, Hachioji, Tokyo 192-8577, Japan
| | - Germán Cuevas-Rodríguez
- Department of Civil and Environmental Engineering, Engineering Division, University of Guanajuato, Av. Juárez 77, Zona Centro, Guanajuato Gto 36000, Mexico
| | - Pabel Cervantes-Avilés
- Escuela de Ingeniería y Ciencias, Tecnológico de Monterrey, Campus Puebla, Vía Atlixcáyotl 5718, Reserva Territorial Atlixcáyotl, Puebla, Puebla 72453, Mexico
| |
Collapse
|
5
|
Chen Z, Xie Y, Qiu S, Li M, Yuan W, Ge S. Granular indigenous microalgal-bacterial consortium for wastewater treatment: Establishment strategy, functional microorganism, nutrient removal, and influencing factor. BIORESOURCE TECHNOLOGY 2022; 353:127130. [PMID: 35398536 DOI: 10.1016/j.biortech.2022.127130] [Citation(s) in RCA: 18] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/28/2022] [Revised: 04/02/2022] [Accepted: 04/05/2022] [Indexed: 06/14/2023]
Abstract
Granular indigenous microalgal-bacterial consortium (G-IMBC) system integrates the advantages of the MBC and granular activated sludge technologies, also with superior microalgal wastewater adaptation capacity. In this review, the concept of IMBC was firstly described, followed by its establishment and acclimation strategies. Characteristics and advantages of G-IMBC system compared to other IMBC systems (i.e., attached and floc IMBC systems) were then introduced. Moreover, the involved functional microorganisms and their interactions, as well as nutrient removal mechanisms were systematically and critically reviewed. Finally, the influencing factors including wastewater characteristics and operation factors were discussed. This study aims to provide a comprehensive up-to-date summary of the G-IMBC system for sustainable wastewater treatment.
Collapse
Affiliation(s)
- Zhipeng Chen
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Yue Xie
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Shuang Qiu
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Mengting Li
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Wenqi Yuan
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China
| | - Shijian Ge
- Jiangsu Key Laboratory of Chemical Pollution Control and Resources Reuse, School of Environmental and Biological Engineering, Nanjing University of Science and Technology, Xiao Ling Wei 200, Nanjing 210094, Jiangsu, China.
| |
Collapse
|
6
|
Nishi K, Akizuki S, Toda T, Matsuyama T, Ida J. Advanced light-tolerant microalgae-nitrifying bacteria consortia for stable ammonia removal under strong light irradiation using light-shielding hydrogel. CHEMOSPHERE 2022; 297:134252. [PMID: 35271892 DOI: 10.1016/j.chemosphere.2022.134252] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/05/2021] [Revised: 02/19/2022] [Accepted: 03/05/2022] [Indexed: 06/14/2023]
Abstract
The consortium of microalgae and nitrifying bacteria has attracted attention owing to its advantages, such as energy- and cost-efficiency in terms of using only light irradiation without aeration. However, high light intensity can easily cause photoinhibition of nitrifying bacteria, resulting in process breakdown of the consortium. This challenge limits its practical application in outdoor environment. In a previous study, we developed a "light-shielding hydrogel" which entrapped nitrifying bacteria in carbon black-added alginate hydrogel beads and confirmed its effectiveness of protecting the nitrifying bacteria from intense light up to 1600 μmol photons m-2 s-1. However, the applicability of the light-shielding hydrogel to microalgae-nitrifying bacteria consortia under strong light irradiation has not yet been clarified. In this study, we aimed to establish consortia of Chlorella sorokiniana and nitrifying bacteria immobilised in light-shielding hydrogel and evaluate their nitrification performance under strong light. Three nitrifying bacteria conditions were used: light-shielding hydrogel, hydrogel containing only nitrifying bacteria without carbon black ('hydrogel'), and dispersed nitrifier without immobilisation ('dispersion') as a control. At 1600 μmol photons m-2 s-1, the dispersion afforded a significant decrease in nitrification activity and subsequent process breakdown. In contrast, light-shielding hydrogel achieved complete nitrification without nitrite accumulation and had nitrification rates of approximately nine and two times higher than those for the dispersion and hydrogel conditions, respectively. Based on the overall evaluation, a possible sequence of process breakdown under strong light was also proposed. This study demonstrated for the first time that the light-shielding hydrogel/consortia combination had potential for applications, which require mitigation of photoinhibition under strong light irradiation. Further, it is expected that the proposed method will contribute to realise the practical application of microalgae-nitrifying bacteria consortia in various countries that experience high sunlight intensity due to their location in the sunbelt areas.
Collapse
Affiliation(s)
- Kento Nishi
- Graduate School of Engineering, Soka University, 1-236 Tangi-machi, Hachioji, Tokyo, 192-8577, Japan; Research Fellow of Japan Society for the Promotion of Science (JSPS), Kojimachi Business Center Building, 5-3-1 Kojimachi, Chiyoda-ku, Tokyo, 102-0083, Japan
| | - Shinichi Akizuki
- Institute of Plankton Eco-engineering, Soka University, 1-236 Tangi-machi, Hachioji, Tokyo, 192-8577, Japan
| | - Tatsuki Toda
- Faculty of Science and Engineering, Soka University, 1-236 Tangi-machi, Hachioji, Tokyo, 192-8577, Japan
| | - Tatsushi Matsuyama
- Faculty of Science and Engineering, Soka University, 1-236 Tangi-machi, Hachioji, Tokyo, 192-8577, Japan
| | - Junichi Ida
- Faculty of Science and Engineering, Soka University, 1-236 Tangi-machi, Hachioji, Tokyo, 192-8577, Japan.
| |
Collapse
|
7
|
Aparicio S, Robles Á, Ferrer J, Seco A, Borrás Falomir L. Assessing and modeling nitrite inhibition in microalgae-bacteria consortia for wastewater treatment by means of photo-respirometric and chlorophyll fluorescence techniques. THE SCIENCE OF THE TOTAL ENVIRONMENT 2022; 808:152128. [PMID: 34863736 DOI: 10.1016/j.scitotenv.2021.152128] [Citation(s) in RCA: 17] [Impact Index Per Article: 5.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/29/2021] [Revised: 11/23/2021] [Accepted: 11/28/2021] [Indexed: 06/13/2023]
Abstract
Total nitrite (TNO2 = HNO2 + NO-2) accumulation due to the activity of ammonia-oxidizing bacteria (AOB) was monitored in microalgae-bacteria consortia, and the inhibitory effect of nitrite/free nitrous acid (NO2-N/FNA) on microalgae photosynthesis and inhibition mechanism was studied. A culture of Scenedesmus was used to run two sets of batch reactors at different pH and TNO2 concentrations to evaluate the toxic potential of NO2-N and FNA. Photo-respirometric tests showed that NO2-N accumulation has a negative impact on net oxygen production rate (OPRNET). Chlorophyll a fluorescence analysis was used to examine the biochemical effects of NO2-N stress and the mechanism of NO2-N inhibition. The electron transport rate (ETR), non-photochemical quenching (NPQ), and JIP-test revealed that the electron transport chain between Photosystems II and I (PS II and PS I) was hindered at NO2-N concentrations above 25 g N m-3. Electron acceptor QA was not able to reoxidize and could not transfer electrons to the next electron acceptor, QB, accumulating P680+ (excited PS II reaction center) and limiting oxygen production. A semi-continuous reactor containing a Scenedesmus culture was monitored by photo-respirometry tests and Chlorophyll a fluorescence to calibrate NO2-N inhibition (5-35 g N m-3). Non-competitive inhibition and Hill-type models were compared to select the best-fitting inhibition equations. Inhibition was correctly modeled by the Hill-type model and a half inhibition constant (KI) for OPRNET, NPQ, maximum photosynthetic rate (ETRMAX) and the performance index PIABS was 23.7 ± 1.2, 26.36 ± 1.10, 39 ± 2 and 26.5 ± 0.4, respectively.
Collapse
Affiliation(s)
- Stéphanie Aparicio
- CALAGUA - Unidad Mixta UV-UPV, Departament d'Enginyeria Química, Universitat de València, Avinguda de la Universitat s/n, 46100 Burjassot, València, Spain.
| | - Ángel Robles
- CALAGUA - Unidad Mixta UV-UPV, Departament d'Enginyeria Química, Universitat de València, Avinguda de la Universitat s/n, 46100 Burjassot, València, Spain
| | - José Ferrer
- CALAGUA - Unidad Mixta UV-UPV, Institut Universitari d'Investigació d'Enginyeria de l'Aigua i Medi Ambient - IIAMA, Universitat Politècnica de València, Camí de Vera s/n, 46022, València, Spain
| | - Aurora Seco
- CALAGUA - Unidad Mixta UV-UPV, Departament d'Enginyeria Química, Universitat de València, Avinguda de la Universitat s/n, 46100 Burjassot, València, Spain
| | - Luis Borrás Falomir
- CALAGUA - Unidad Mixta UV-UPV, Departament d'Enginyeria Química, Universitat de València, Avinguda de la Universitat s/n, 46100 Burjassot, València, Spain
| |
Collapse
|
8
|
Comprehensive assessment of the microalgae-nitrifying bacteria competition in microalgae-based wastewater treatment systems: Relevant factors, evaluation methods and control strategies. ALGAL RES 2022. [DOI: 10.1016/j.algal.2021.102563] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/20/2022]
|
9
|
Sunoj S, Hammed A, Igathinathane C, Eshkabilov S, Simsek H. Identification, quantification, and growth profiling of eight different microalgae species using image analysis. ALGAL RES 2021. [DOI: 10.1016/j.algal.2021.102487] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
|
10
|
López-Pacheco IY, Castillo-Vacas EI, Castañeda-Hernández L, Gradiz-Menjivar A, Rodas-Zuluaga LI, Castillo-Zacarías C, Sosa-Hernández JE, Barceló D, Iqbal HMN, Parra-Saldívar R. CO 2 biocapture by Scenedesmus sp. grown in industrial wastewater. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 790:148222. [PMID: 34380253 DOI: 10.1016/j.scitotenv.2021.148222] [Citation(s) in RCA: 10] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/18/2020] [Revised: 05/15/2021] [Accepted: 05/29/2021] [Indexed: 02/08/2023]
Abstract
Greenhouse gases (GHG) emissions are widely related to climate change, triggering several environmental problems of global concern and producing environmental, social, and economic negative impacts. Therefore, global research seeks to mitigate greenhouse gas emissions. On the other hand, the use of wastes under a circular economy scheme generates subproducts from the range of high to medium-value, representing a way to help sustainable development. Therefore, the use of wastewater as a culture medium to grow microalgae strains that biocapture environmental CO2, is a proposal with high potential to reduce the GHG presence in the environment. In this work, Scenedesmus sp. was cultivated using BG-11 medium and industrial wastewater (IWW) as a culture medium with three different CO2 concentrations, 0.03%, 10%, and 20% to determine their CO2 biocapture potential. Furthermore, the concomitant removal of COD, nitrates, and total phosphorus in wastewater was evaluated. Scenedesmus sp. achieves a biomass concentration of 1.9 g L-1 when is grown in BG-11 medium, 0.69 g L-1 when is grown in a combination of BG-11 medium and 25% of industrial wastewater; both cases with 20% CO2 supplied. The maximum CO2 removal efficiency (8.4%, 446 ± 150 mg CO2 L-1 day-1) was obtained with 10% CO2 supplied and using a combination of BG-11 medium and 50% IWW (T2). Also, the highest removal of COD was reached with a combination of BG-11 medium and T2 with a supply of 20% CO2 (82% of COD removal). Besides, the highest nitrates removal was achieved with a combination of BG-11 medium and 75% IWW (T3) with a supply of 10% CO2 (42% of nitrates removal) and the maximum TP removal was performed with the combination of BG-11 medium and 25% IWW (T1) with a supply of 10% CO2 (67% of TP removal). These results indicate that industrial wastewater can be used as a culture media for microalgae growth and CO2 biocapture can be performed as concomitant processes.
Collapse
Affiliation(s)
- Itzel Y López-Pacheco
- Tecnologico de Monterrey, School of Engineering and Sciences, Monterrey 64849, Mexico
| | - Eduardo Israel Castillo-Vacas
- Escuela Agrícola Panamericana, Zamorano. Km 30 carretera de Tegucigalpa a Danlí, Valle del Yeguare, Municipio de San Antonio de Oriente, Francisco Morazán, Honduras, Apartado postal 93, Tegucigalpa 11101, Honduras
| | - Lizbeth Castañeda-Hernández
- Escuela Agrícola Panamericana, Zamorano. Km 30 carretera de Tegucigalpa a Danlí, Valle del Yeguare, Municipio de San Antonio de Oriente, Francisco Morazán, Honduras, Apartado postal 93, Tegucigalpa 11101, Honduras
| | - Angie Gradiz-Menjivar
- Escuela Agrícola Panamericana, Zamorano. Km 30 carretera de Tegucigalpa a Danlí, Valle del Yeguare, Municipio de San Antonio de Oriente, Francisco Morazán, Honduras, Apartado postal 93, Tegucigalpa 11101, Honduras; University of Nebraska-Lincoln, Department of Biological Systems Engineering, Panhandle Research and Extension Center, Scottsbluff, NE, USA
| | | | | | | | - Damià Barceló
- Department of Environmental Chemistry, Institute of Environmental Assessment and Water Research, IDAEA-CSIC, Jordi Girona, 18-26, 08034 Barcelona, Spain; Catalan Institute for Water Research (ICRA-CERCA), Parc Científic i Tecnològic de la Universitat de Girona, c/Emili Grahit, 101, Edifici H2O, 17003 Girona, Spain; College of Environmental and Resources Sciences, Zhejiang A&F University, Hangzhou 311300, China
| | - Hafiz M N Iqbal
- Tecnologico de Monterrey, School of Engineering and Sciences, Monterrey 64849, Mexico.
| | | |
Collapse
|
11
|
Influence of Leachate and Nitrifying Bacteria on Photosynthetic Biogas Upgrading in a Two-Stage System. Processes (Basel) 2021. [DOI: 10.3390/pr9091503] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022] Open
Abstract
Photosynthetic biogas upgrading using two-stage systems allows the absorption of carbon dioxide (CO2) in an absorption unit and its subsequent assimilation by microalgae. The production of microalgae requires large amounts of nutrients, thus making scale-up difficult and reducing economic feasibility. The photosynthetic process produces oxygen (O2) (1 mol per mol of CO2 consumed), which can be desorbed into purified biogas. Two-stage systems reduce its impact but do not eliminate it. In this study, we test the use of landfill leachate as a nutrient source and propose a viable and economical strategy for reducing the O2 concentration. First, the liquid/gas (L/G) ratio and flow mode of the absorber were optimized for 20% and 40% CO2 with COMBO medium, then landfill leachate was used as a nutrient source. Finally, the system was inoculated with nitrifying bacteria. Leachate was found to be suitable as a nutrient source and to result in a significant improvement in CO2 absorption, with outlet concentrations of 0.01% and 0.6% for 20% and 40% CO2, respectively, being obtained. The use of nitrifying bacteria allowed a reduction in dissolved oxygen (DO) concentration, although it also resulted in a lower pH, thus making CO2 uptake slightly more difficult.
Collapse
|
12
|
Miao X, Bai X. Characterization of the synergistic relationships between nitrification and microbial regrowth in the chloraminated drinking water supply system. ENVIRONMENTAL RESEARCH 2021; 199:111252. [PMID: 34015300 DOI: 10.1016/j.envres.2021.111252] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/01/2021] [Revised: 04/23/2021] [Accepted: 04/26/2021] [Indexed: 06/12/2023]
Abstract
Deterioration of water quality is commonly found in secondary water supply systems (SWSSs), especially the growth of microbes. To explore the metabolic mechanism for rapid microbial regrowth in SWSSs, a regrowth potential assessment, flow cytometry, and quantitative PCR were conducted. Metagenomic and 16S rRNA gene sequencing were performed to better understand the microbial communities and metabolism. It was found that the increased biomass in the SWSS was significantly higher than that in the drinking water distribution system (DWDS). Statistical analysis revealed that ammonia oxidation was the dominant driver of increased biomass in the SWSS. The abundances of ammonia oxidation bacteria, concentration of nitrogen species, and related enzymes demonstrated that ammonia oxidation in the SWSS was more vigorous than that in the DWDS. In the SWSS, the metabolism of the ammonia oxidation cluster was more vigorous, and ammonia-oxidizing bacteria (AOB) were the dominant nitrifying bacteria. Incomplete nitrification products were involved in the metabolism of heterotrophic bacteria and promoted the growth of heterotrophic bacteria in the SWSS. More attention should be given to controlling incomplete nitrification to improve tap water quality.
Collapse
Affiliation(s)
- Xiaocao Miao
- State Key Laboratory of Microbial Metabolism, Joint International Research Laboratory of Metabolic & Developmental Sciences, School of Life Sciences and Biotechnology, Shanghai Jiao Tong University, Shanghai, 200240, PR China
| | - Xiaohui Bai
- State Key Laboratory of Microbial Metabolism, Joint International Research Laboratory of Metabolic & Developmental Sciences, School of Life Sciences and Biotechnology, Shanghai Jiao Tong University, Shanghai, 200240, PR China.
| |
Collapse
|
13
|
Torres-Franco AF, Zuluaga M, Hernández-Roldán D, Leroy-Freitas D, Sepúlveda-Muñoz CA, Blanco S, Mota CR, Muñoz R. Assessment of the performance of an anoxic-aerobic microalgal-bacterial system treating digestate. CHEMOSPHERE 2021; 270:129437. [PMID: 33429236 DOI: 10.1016/j.chemosphere.2020.129437] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/17/2020] [Revised: 12/15/2020] [Accepted: 12/21/2020] [Indexed: 06/12/2023]
Abstract
The performance of an anoxic-aerobic microalgal-bacterial system treating synthetic food waste digestate at 10 days of hydraulic retention time via nitrification-denitrification under increasing digestate concentrations of 25%, 50%, and 100% (v/v) was assessed during Stages I, II and III, respectively. The system supported adequate treatment without external CO2 supplementation since sufficient inorganic carbon in the digestate was available for autotrophic growth. High steady-state Total Organic Carbon (TOC) and Total Nitrogen (TN) removal efficiencies of 85-96% and 73-84% were achieved in Stages I and II. Similarly, PO43--P removals of 81 ± 15% and 58 ± 4% were recorded during these stages. During Stage III, the average influent concentrations of 815 ± 35 mg TOC·L-1, 610 ± 23 mg TN·L-1, and 46 ± 11 mg PO43--P·L-1 induced O2 limiting conditions, resulting in TOC, TN and PO43--P removals of 85 ± 3%, 73 ± 3%, and 28 ± 16%, respectively. Digestate concentrations of 25% and 50% favored nitrification-denitrification mechanisms, whereas the treatment of undiluted digestate resulted in higher ammonia volatilization and hampered nitrification-denitrification. In Stages I and II, the microalgal community was dominated by Chlorella vulgaris and Cryptomonas sp., whereas Pseudoanabaena sp. was more abundant during Stage III. Illumina sequencing revealed the presence of carbon and nitrogen transforming bacteria, with dominances of the genera Gemmata, Azospirillum, and Psychrobacter during Stage I, II, and III, respectively. Finally, the high settleability of the biomass (98% of suspended solids removal in the settler) and average C (42%), N (7%), P (0.2%), and S (0.4%) contents recovered in the biomass confirmed its potential for agricultural applications, contributing to a closed-cycle management of food waste.
Collapse
Affiliation(s)
- Andrés F Torres-Franco
- Department of Chemical Engineering and Environmental Technology, Valladolid University, Dr. Mergelina, s/n., 47011, Valladolid, Spain; Institute of Sustainable Processes, Dr. Mergelina, s/n, 47011, Valladolid, Spain; Department of Sanitary and Environmental Engineering, Federal University of Minas Gerais, Belo Horizonte, 31270-010, Brazil
| | - Maribel Zuluaga
- Department of Chemical Engineering and Environmental Technology, Valladolid University, Dr. Mergelina, s/n., 47011, Valladolid, Spain; Institute of Sustainable Processes, Dr. Mergelina, s/n, 47011, Valladolid, Spain; Faculty of Environmental Engineering UPAEP University, Puebla, 21 Sur 1103, Barrio de Santiago, 72410, Puebla, Mexico
| | - Diana Hernández-Roldán
- Department of Chemical Engineering and Environmental Technology, Valladolid University, Dr. Mergelina, s/n., 47011, Valladolid, Spain; Institute of Sustainable Processes, Dr. Mergelina, s/n, 47011, Valladolid, Spain; Faculty of Environmental Engineering UPAEP University, Puebla, 21 Sur 1103, Barrio de Santiago, 72410, Puebla, Mexico
| | - Deborah Leroy-Freitas
- Department of Chemical Engineering and Environmental Technology, Valladolid University, Dr. Mergelina, s/n., 47011, Valladolid, Spain; Institute of Sustainable Processes, Dr. Mergelina, s/n, 47011, Valladolid, Spain; Department of Sanitary and Environmental Engineering, Federal University of Minas Gerais, Belo Horizonte, 31270-010, Brazil
| | - Cristian A Sepúlveda-Muñoz
- Department of Chemical Engineering and Environmental Technology, Valladolid University, Dr. Mergelina, s/n., 47011, Valladolid, Spain; Institute of Sustainable Processes, Dr. Mergelina, s/n, 47011, Valladolid, Spain
| | - Saúl Blanco
- University of León, Campus de Vegazana, 24071, León, Spain; Laboratory of Diatomology, Institute of Environment, Natural Resources and Biodiversity, La Serna 58, 24007, León, Spain
| | - César R Mota
- Department of Sanitary and Environmental Engineering, Federal University of Minas Gerais, Belo Horizonte, 31270-010, Brazil
| | - Raúl Muñoz
- Department of Chemical Engineering and Environmental Technology, Valladolid University, Dr. Mergelina, s/n., 47011, Valladolid, Spain; Institute of Sustainable Processes, Dr. Mergelina, s/n, 47011, Valladolid, Spain.
| |
Collapse
|
14
|
Casagli F, Rossi S, Steyer JP, Bernard O, Ficara E. Balancing Microalgae and Nitrifiers for Wastewater Treatment: Can Inorganic Carbon Limitation Cause an Environmental Threat? ENVIRONMENTAL SCIENCE & TECHNOLOGY 2021; 55:3940-3955. [PMID: 33657315 PMCID: PMC8028045 DOI: 10.1021/acs.est.0c05264] [Citation(s) in RCA: 21] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 08/05/2020] [Revised: 02/17/2021] [Accepted: 02/17/2021] [Indexed: 06/12/2023]
Abstract
The first objective of this study is to assess the predictive capability of the ALBA (ALgae-BActeria) model for a pilot-scale (3.8 m2) high-rate algae-bacteria pond treating agricultural digestate. The model, previously calibrated and validated on a one-year data set from a demonstrative-scale raceway (56 m2), successfully predicted data from a six-month monitoring campaign with a different wastewater (urban wastewater) under different climatic conditions. Without changing any parameter value from the previous calibration, the model accurately predicted both online monitored variables (dissolved oxygen, pH, temperature) and off-line measurements (nitrogen compounds, algal biomass, total and volatile suspended solids, chemical oxygen demand). Supported by the universal character of the model, different scenarios under variable weather conditions were tested, to investigate the effect of key operating parameters (hydraulic retention time, pH regulation, kLa) on algae biomass productivity and nutrient removal efficiency. Surprisingly, despite pH regulation, a strong limitation for inorganic carbon was found to hinder the process efficiency and to generate conditions that are favorable for N2O emission. The standard operating parameters have a limited effect on this limitation, and alkalinity turns out to be the main driver of inorganic carbon availability. This investigation offers new insights in algae-bacteria processes and paves the way for the identification of optimal operational strategies.
Collapse
Affiliation(s)
- Francesca Casagli
- Dipartimento
di Ingegneria Civile e Ambientale (DICA), Politecnico di Milano, 32, Piazza L. da Vinci, 20133 Milan, Italy
- Institut
National de Recherche en Informatique et en Automatique (INRIA), Biocore,
Université Cote d’Azur, 2004, Route des Lucioles − BP 93, 06902 Sophia-Antipolis, France
| | - Simone Rossi
- Dipartimento
di Ingegneria Civile e Ambientale (DICA), Politecnico di Milano, 32, Piazza L. da Vinci, 20133 Milan, Italy
| | | | - Olivier Bernard
- Institut
National de Recherche en Informatique et en Automatique (INRIA), Biocore,
Université Cote d’Azur, 2004, Route des Lucioles − BP 93, 06902 Sophia-Antipolis, France
| | - Elena Ficara
- Dipartimento
di Ingegneria Civile e Ambientale (DICA), Politecnico di Milano, 32, Piazza L. da Vinci, 20133 Milan, Italy
| |
Collapse
|
15
|
Mohamed AYA, Welles L, Siggins A, Healy MG, Brdjanovic D, Rada-Ariza AM, Lopez-Vazquez CM. Effects of substrate stress and light intensity on enhanced biological phosphorus removal in a photo-activated sludge system. WATER RESEARCH 2021; 189:116606. [PMID: 33189975 DOI: 10.1016/j.watres.2020.116606] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/23/2020] [Revised: 11/03/2020] [Accepted: 11/04/2020] [Indexed: 06/11/2023]
Abstract
Photo-activated sludge (PAS) systems are an emerging wastewater treatment technology where microalgae provide oxygen to bacteria without the need for external aeration. There is limited knowledge on the optimal conditions for enhanced biological phosphorus removal (EBPR) in systems containing a mixture of polyphosphate accumulating organisms (PAOs) and microalgae. This research aimed to study the effects of substrate composition and light intensity on the performance of a laboratory-scale EBPR-PAS system. Initially, a model-based design was developed to study the effect of organic carbon (COD), inorganic carbon (HCO3) and ammonium-nitrogen (NH4-N) in nitrification deprived conditions on phosphorus (P) removal. Based on the mathematical model, two different synthetic wastewater compositions (COD:HCO3:NH4-N: 10:20:1 and 10:10:4) were examined at a light intensity of 350 µmol m-2 sec-1. Add to this, the performance of the system was also investigated at light intensities: 87.5, 175, and 262.5 µmol m-2 sec-1 for short terms. Results showed that wastewater having a high level of HCO3 and low level of NH4-N (ratio of 10:20:1) favored only microalgal growth, and had poor P removal due to a shortage of NH4-N for PAOs growth. However, lowering the HCO3 level and increasing the NH4-N level (ratio of 10:10:4) balanced PAOs and microalgae symbiosis, and had a positive influence on P removal. Under this mode of operation, the system was able to operate without external aeration and achieved a net P removal of 10.33 ±1.45 mg L-1 at an influent COD of 100 mg L-1. No significant variation was observed in the reactor performance for different light intensities, indicating the EBPR-PAS system can be operated at low light intensities with a positive influence on P removal.
Collapse
Affiliation(s)
- A Y A Mohamed
- Environmental Engineering and Water Technology Department. IHE Delft Institute for Water Education, Westvest 7, 2611 AX Delft, The Netherlands; Civil Engineering and Ryan Institute, College of Science and Engineering, NUI Galway, Republic of Ireland; Animal and Grassland Research and Innovation Centre, Teagasc, Moorepark, Fermoy, Co. Cork, Ireland.
| | - L Welles
- Environmental Engineering and Water Technology Department. IHE Delft Institute for Water Education, Westvest 7, 2611 AX Delft, The Netherlands
| | - A Siggins
- Civil Engineering and Ryan Institute, College of Science and Engineering, NUI Galway, Republic of Ireland
| | - M G Healy
- Civil Engineering and Ryan Institute, College of Science and Engineering, NUI Galway, Republic of Ireland
| | - D Brdjanovic
- Environmental Engineering and Water Technology Department. IHE Delft Institute for Water Education, Westvest 7, 2611 AX Delft, The Netherlands; Department of Biotechnology, Delft University of Technology, Van der Maasweg 9, 2629 HZ, Delft, the Netherlands
| | - A M Rada-Ariza
- Environmental Engineering and Water Technology Department. IHE Delft Institute for Water Education, Westvest 7, 2611 AX Delft, The Netherlands
| | - C M Lopez-Vazquez
- Environmental Engineering and Water Technology Department. IHE Delft Institute for Water Education, Westvest 7, 2611 AX Delft, The Netherlands
| |
Collapse
|
16
|
Zhang H, Gong W, Jia B, Zeng W, Li G, Liang H. Nighttime aeration mode enhanced the microalgae-bacteria symbiosis (ABS) system stability and pollutants removal efficiencies. THE SCIENCE OF THE TOTAL ENVIRONMENT 2020; 743:140607. [PMID: 32659554 DOI: 10.1016/j.scitotenv.2020.140607] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/10/2019] [Revised: 04/03/2020] [Accepted: 06/27/2020] [Indexed: 06/11/2023]
Abstract
Utilizing external aeration to enhance the performance of microalgae-bacteria symbiosis (ABS) system has been extensively studied. However, inappropriate aeration damaged ABS system stability. A nighttime aeration mode (NA-ABS) in different aeration intensities (20, 50, 100 mL/min) was adopted to compare to continuous aeration microalgae-bacteria symbiosis (CA-ABS) mode and no-aerated mode on pollutants removal efficiencies and system stability. Results showed that NA-ABS system performed better on total organic carbon (TOC), NH4+-N, total nitrogen (TN) and PO43- removal than CA-ABS system, especially under the aeration intensity of 20 mL/min (NAI20), with the removal efficiencies of 96.59%, 99.18%, 90.30% and 89.16%, respectively. These results were because NA-ABS system prevented CO2 stripping and provided more dissolved inorganic carbon (DIC) for the microalgae growth. Furthermore, less CO2 stripping released the competition between microalgae and autotrophic bacteria for the DIC, leading to a more stable ABS system during long-term operation. This paper suggested that NA-ABS system would provide some new insights into ABS system and be helpful for further study.
Collapse
Affiliation(s)
- Han Zhang
- State Key Laboratory of Urban Water Resource and Environment (SKLUWRE), Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, PR China
| | - Weijia Gong
- School of Engineering, Northeast Agricultural University, 600 Changjiang Street, Xiangfang District, Harbin 150030, PR China
| | - Baohui Jia
- Department of Civil Engineering, The University of British Columbia, 6250 Applied Science Lane, Vancouver, BC V6T 1Z4, Canada
| | - Weichen Zeng
- State Key Laboratory of Urban Water Resource and Environment (SKLUWRE), Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, PR China
| | - Guibai Li
- State Key Laboratory of Urban Water Resource and Environment (SKLUWRE), Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, PR China
| | - Heng Liang
- State Key Laboratory of Urban Water Resource and Environment (SKLUWRE), Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, PR China.
| |
Collapse
|
17
|
Feng S, Liu F, Zhu S, Feng P, Wang Z, Yuan Z, Shang C, Chen H. Performance of a microalgal-bacterial consortium system for the treatment of dairy-derived liquid digestate and biomass production. BIORESOURCE TECHNOLOGY 2020; 306:123101. [PMID: 32197188 DOI: 10.1016/j.biortech.2020.123101] [Citation(s) in RCA: 19] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/13/2020] [Revised: 02/27/2020] [Accepted: 02/28/2020] [Indexed: 06/10/2023]
Abstract
To enhance the treatment performance of dairy-derived liquid digestate (DLD) using microalgal-bacterial consortium system composed of Chlorella vulgaris and indigenous bacteria (CV), activated sludge was introduced to form a new microalgal-bacterial consortium system (Co-culture). The activated sludge shortened the lag phase and increased the specific growth rate of C. vulgaris (0.56 d-1). The biomass yield in the Co-culture was 2.72 g L-1, which was lower than that in the CV (3.24 g L-1), but the Co-culture had an improved COD (chemical oxygen demand) removal (25.26%) compared to the CV (13.59%). Quantitative PCR and metagenomic analyses demonstrated that microalgae also promoted bacterial growth, but influenced differently on the bacterial communities of indigenous bacteria and activated sludge. Compared with indigenous bacteria, activated sludge was more prone to forming a favorable symbiosis with C. vulgaris. These findings contribute to the construction of efficient microalgal-bacterial consortium system in wastewater treatment.
Collapse
Affiliation(s)
- Siran Feng
- Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, China; Key Laboratory of Renewable Energy, Chinese Academy of Sciences, Guangzhou 510640, China; Guangdong Provincial Key Laboratory of New and Renewable Energy Research and Development, Guangzhou 510640, China
| | - Fen Liu
- Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, China; Key Laboratory of Renewable Energy, Chinese Academy of Sciences, Guangzhou 510640, China; Guangdong Provincial Key Laboratory of New and Renewable Energy Research and Development, Guangzhou 510640, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Shunni Zhu
- Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, China; Key Laboratory of Renewable Energy, Chinese Academy of Sciences, Guangzhou 510640, China; Guangdong Provincial Key Laboratory of New and Renewable Energy Research and Development, Guangzhou 510640, China.
| | - Pingzhong Feng
- Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, China; Key Laboratory of Renewable Energy, Chinese Academy of Sciences, Guangzhou 510640, China; Guangdong Provincial Key Laboratory of New and Renewable Energy Research and Development, Guangzhou 510640, China
| | - Zhongming Wang
- Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, China; Key Laboratory of Renewable Energy, Chinese Academy of Sciences, Guangzhou 510640, China; Guangdong Provincial Key Laboratory of New and Renewable Energy Research and Development, Guangzhou 510640, China
| | - Zhenhong Yuan
- Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, China; Key Laboratory of Renewable Energy, Chinese Academy of Sciences, Guangzhou 510640, China; Guangdong Provincial Key Laboratory of New and Renewable Energy Research and Development, Guangzhou 510640, China
| | - Changhua Shang
- College of Life Science, Guangxi Normal University, Guilin, Guangxi 541006, China
| | - Huanjun Chen
- Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, China; Key Laboratory of Renewable Energy, Chinese Academy of Sciences, Guangzhou 510640, China; Guangdong Provincial Key Laboratory of New and Renewable Energy Research and Development, Guangzhou 510640, China; University of Chinese Academy of Sciences, Beijing 100049, China
| |
Collapse
|
18
|
Wang Y, Wang S, Sun L, Sun Z, Li D. Screening of a Chlorella-bacteria consortium and research on piggery wastewater purification. ALGAL RES 2020. [DOI: 10.1016/j.algal.2020.101840] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/24/2022]
|
19
|
Trebuch LM, Oyserman BO, Janssen M, Wijffels RH, Vet LEM, Fernandes TV. Impact of hydraulic retention time on community assembly and function of photogranules for wastewater treatment. WATER RESEARCH 2020; 173:115506. [PMID: 32006806 DOI: 10.1016/j.watres.2020.115506] [Citation(s) in RCA: 64] [Impact Index Per Article: 12.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/02/2019] [Revised: 01/10/2020] [Accepted: 01/12/2020] [Indexed: 06/10/2023]
Abstract
Photogranules are dense, spherical agglomerates of cyanobacteria, microalgae and non-phototrophic microorganisms that have considerable advantages in terms of harvesting and nutrient removal rates for light driven wastewater treatment processes. This ecosystem is poorly understood in terms of the microbial community structure and the response of the community to changing abiotic conditions. To get a better understanding, we investigated the effect of hydraulic retention time (HRT) on photogranule formation and community assembly over a period of 148 days. Three laboratory bioreactors were inoculated with field samples from various locations in the Netherlands and operated in sequencing batch mode. The bioreactors were operated at four different HRTs (2.00, 1.00, 0.67, 0.33 days), while retaining the same solid retention time of 7 days. A microbial community with excellent settling characteristics (95-99% separation efficiency) was established within 2-5 weeks. The observed nutrient uptake rates ranged from 24 to 90 mgN L-1 day-1 and from 3.1 to 5.4 mgP L-1 day-1 depending on the applied HRT. The transition from single-cell suspension culture to floccular agglomeration to granular sludge was monitored by microscopy and 16S/18S sequencing. In particular, two important variables for driving aggregation and granulation, and for the structural integrity of photogranules were identified: 1. Extracellular polymeric substances (EPS) with high protein to polysaccharide ratio and 2. specific microorganisms. The key players were found to be the cyanobacteria Limnothrix and Cephalothrix, the colony forming photosynthetic eukaryotes within Chlamydomonadaceae, and the biofilm producing bacteria Zoogloea and Thauera. Knowing the makeup of the microbial community and the operational conditions influencing granulation and bioreactor function is crucial for successful operation of photogranular systems.
Collapse
Affiliation(s)
- L M Trebuch
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, the Netherlands; Bioprocess Engineering, AlgaePARC Wageningen University, P.O. Box 16, 6700 AA, Wageningen, the Netherlands.
| | - B O Oyserman
- Department of Microbial Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, the Netherlands; Bioinformatics Group, Wageningen University, Wageningen, the Netherlands
| | - M Janssen
- Bioprocess Engineering, AlgaePARC Wageningen University, P.O. Box 16, 6700 AA, Wageningen, the Netherlands
| | - R H Wijffels
- Bioprocess Engineering, AlgaePARC Wageningen University, P.O. Box 16, 6700 AA, Wageningen, the Netherlands; Faculty of Biosciences and Aquaculture, Nord University, N-8049, Bodø, Norway
| | - L E M Vet
- Department of Terrestrial Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, the Netherlands
| | - T V Fernandes
- Department of Aquatic Ecology, Netherlands Institute of Ecology (NIOO-KNAW), Droevendaalsesteeg 10, 6708 PB, Wageningen, the Netherlands
| |
Collapse
|
20
|
Wang M, Zhang SC, Tang Q, Shi LD, Tao XM, Tian GM. Organic degrading bacteria and nitrifying bacteria stimulate the nutrient removal and biomass accumulation in microalgae-based system from piggery digestate. THE SCIENCE OF THE TOTAL ENVIRONMENT 2020; 707:134442. [PMID: 31865075 DOI: 10.1016/j.scitotenv.2019.134442] [Citation(s) in RCA: 27] [Impact Index Per Article: 5.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/25/2019] [Revised: 09/08/2019] [Accepted: 09/12/2019] [Indexed: 06/10/2023]
Abstract
The microalgae-based system has been applied in anaerobic digestate treatment for nutrient removal and biomass production. To optimize its performance in treating piggery digestate, here, commercial bacterial agents, including organic degrading bacteria (Cb) and nitrifying bacteria (Nb), were inoculated into the microalgae-based system dominated by Desmodesmus sp. CHX1 (D). Reactor DN (inoculated with D and Nb) and DCN (inoculated with D, and Cb to Nb at a ratio of 1:2) have better performance on NH4+-N removal, with a final efficiency at 40.26% and 39.87%, respectively, and no NO3--N or NO2--N accumulations. The final total chlorophyll concentration, an indicator of microalgal growth, reached 4.74 and 5.47 mg/L in DN and DCN, respectively, three times more than that in D. These results suggested that high NH4+-N removal was achieved by the assimilation into high microalgal biomass after the inoculation with functional bacteria. High-throughput sequencing showed that the richness of microbial community decreased but the evenness increased by inoculating functional microorganisms. Microalgae aggregating bacteria were Cellvibrio, Sphingobacterium, Flavobacterium, Comamonas, Microbacterium, Dyadobacter, and Paenibacillus. This study revealed that the inoculation with functional bacteria reconstructed the microbial community which benefited for the microalgal growth and nutrient removal, providing a promising strategy for treating highly-concentrated digestate.
Collapse
Affiliation(s)
- Min Wang
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China
| | - Shu-Chi Zhang
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China
| | - Qin Tang
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China
| | - Ling-Dong Shi
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China
| | - Xing-Ming Tao
- Hangzhou Wanxiang Polytechnic, Hangzhou 310023, China
| | - Guang-Ming Tian
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China.
| |
Collapse
|
21
|
Foladori P, Petrini S, Andreottola G. How suspended solids concentration affects nitrification rate in microalgal-bacterial photobioreactors without external aeration. Heliyon 2020; 6:e03088. [PMID: 31909261 PMCID: PMC6939075 DOI: 10.1016/j.heliyon.2019.e03088] [Citation(s) in RCA: 10] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/24/2019] [Revised: 12/02/2019] [Accepted: 12/17/2019] [Indexed: 11/27/2022] Open
Abstract
The use of microalgae for the treatment of municipal wastewater makes possible to supply oxygen and save energy, but must be coupled with bacterial nitrification to obtain nitrogen removal efficiency above 90%. This paper explores how the concentration of Total Suspended Solids (TSS, from 0.2 to 3.9 g TSS/L) affects the nitrification kinetic in three microalgal-bacterial consortia treating real municipal wastewater. Two different behaviors were observed: (1) solid-limited kinetic at low TSS concentrations, (2) light-limited kinetic at higher concentrations. For each consortium, an optimal TSS concentration that produced the maximum volumetric ammonium removal rate (around 1.8–2.0 mg N L−1 h−1), was found. The relationship between ammonium removal rate and TSS concentration was then modelled considering bacteria growth, microalgae growth and limitation by dissolved oxygen and light intensity. Assessment of the optimal TSS concentrations makes possible to concentrate the microbial biomass in a photobioreactor while ensuring high kinetics and a low footprint.
Collapse
Affiliation(s)
- Paola Foladori
- Department of Civil, Environmental and Mechanical Engineering, University of Trento, via Mesiano 77, 38123, Trento, Italy
| | - Serena Petrini
- Department of Civil, Environmental and Mechanical Engineering, University of Trento, via Mesiano 77, 38123, Trento, Italy
| | - Gianni Andreottola
- Department of Civil, Environmental and Mechanical Engineering, University of Trento, via Mesiano 77, 38123, Trento, Italy
| |
Collapse
|
22
|
Ülgüdür N, Ergüder TH, Demirer GN. Simultaneous dissolution and uptake of nutrients in microalgal treatment of the secondarily treated digestate. ALGAL RES 2019. [DOI: 10.1016/j.algal.2019.101633] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/19/2023]
|
23
|
Benítez MB, Champagne P, Ramos A, Torres AF, Ochoa-Herrera V. Wastewater treatment for nutrient removal with Ecuadorian native microalgae. ENVIRONMENTAL TECHNOLOGY 2019; 40:2977-2985. [PMID: 29600735 DOI: 10.1080/09593330.2018.1459874] [Citation(s) in RCA: 15] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/01/2017] [Accepted: 03/26/2018] [Indexed: 06/08/2023]
Abstract
The aim of this project was to study the feasibility of utilizing native microalgae for the removal of nitrogen and phosphorus, as a potential secondary wastewater treatment process in Ecuador. Agitation and aeration batch experiments were conducted using synthetic secondary wastewater effluent, to determine nitrogen and phosphorus removal efficiencies by a native Ecuadorian microalgal strain. Experimental results indicated that microalgal cultures could successfully remove nitrogen and phosphorus. NH4+-N and PO43--P removal efficiencies of 52.6 and 55.6%, and 67.0 and 20.4%, as well as NO3--N production efficiencies of 87.0 and 93.1% were reported in agitation and aeration photobioreactors, respectively. Aeration was not found to increase the nutrient removal efficiency of NH4+-N . Moreover, in the case of PO43--P , a negative impact was observed, where removal efficiencies decreased by a factor of 3.3 at higher aeration rates. To the best of our knowledge, this is the first report of the removal of nutrients by native Ecuadorian Chlorella sp., hence the results of this study would indicate that this native microalgal strain could be successfully incorporated in a potential treatment process for nutrient removal in Ecuador.
Collapse
Affiliation(s)
- María Belén Benítez
- a Colegio de Ciencias e Ingenierías, Universidad San Francisco de Quito , Quito , Ecuador
| | - Pascale Champagne
- b Department of Civil Engineering, Queen's University , Kingston , Canada
| | - Ana Ramos
- c Department of Biology, Queen's University , Kingston , Canada
| | - Andres F Torres
- d Colegio de Ciencias Biológicas y Ambientales, Universidad San Francisco de Quito , Quito , Ecuador
| | - Valeria Ochoa-Herrera
- a Colegio de Ciencias e Ingenierías, Universidad San Francisco de Quito , Quito , Ecuador
- e Instituto Biósfera, Universidad San Francisco de Quito , Quito , Ecuador
| |
Collapse
|
24
|
Gong W, Xie B, Deng S, Fan Y, Tang X, Liang H. Enhancement of anaerobic digestion effluent treatment by microalgae immobilization: Characterized by fluorescence excitation-emission matrix coupled with parallel factor analysis in the photobioreactor. THE SCIENCE OF THE TOTAL ENVIRONMENT 2019; 678:105-113. [PMID: 31075577 DOI: 10.1016/j.scitotenv.2019.04.440] [Citation(s) in RCA: 19] [Impact Index Per Article: 3.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/13/2019] [Revised: 04/29/2019] [Accepted: 04/30/2019] [Indexed: 06/09/2023]
Abstract
The bacterial-microalgal consortium has been investigated to anaerobic digestion effluent (ADE) treatment in the photobioreactor (PBR). However, the high concentrations of nutrients reduced the ADE treatment efficiency and the transformation of organic pollutants in PBR was still unclear. In this study, two-sequencing batch PBRs were operated with suspended Microcystis aeruginosa (M. aeruginosa, SMA) and immobilized M. aeruginosa (IMA) to compare the ADE treatment performance. Fluorescence excitation-emission matrix coupled with parallel factor analysis (EEM-PARAFAC) was conducted to identify organics degradations. The results showed that the proportion of living M. aeruginosa cell (86.4%) in PBR (IMA) was highly significant (p < 0.05) higher than that in PBR (SMA) (75.2%). This indicated immobilized microalgae beads enhanced the resistance to the high concentration of nutrients in PBR (IMA). EEM-PARAFAC analysis displayed the biodegradation order in the bacterial-microalgal consortium system was humic-like substances > tyrosine-like substances > tryptophan-like substances. The removals of humic-like matters (94.05 ± 0.92%) and tyrosine-like matters (91.13 ± 2.49%) in PBR (IMA) were significantly (p < 0.01) higher than those in PBR (SMA). Notably, the average removals of nutrients in PBR (IMA) were significantly (p < 0.05) higher than those in PBR (SMA). This result verified that microalgae immobilization benefitted nutrients removals with 93.05 ± 1.45% of NH4+-N and complete PO43--P removal in PBR (IMA). Moreover, the enrichment of functional genera Flavobacterium and Opitutus contributed to decreasing the organics loadings and strengthening the ADE treatment performance. Therefore, this study verified microalgae immobilization enhanced the actual ADE treatment. Additionally, fluorescent organic pollutants degradations were further evaluated by EEM-PARAFAC analysis in the bacterial-microalgal consortium.
Collapse
Affiliation(s)
- Weijia Gong
- School of Engineering, Northeast Agricultural University, 600 Changjiang Street, Xiangfang District, Harbin 150030, PR China.
| | - Binghan Xie
- State Key Laboratory of Urban Water Resource and Environment (SKLUWRE), School of Environment, Harbin Institute of Technology, Harbin 150090, PR China; National University of Singapore Environmental Research Institute, National University of Singapore, 5A Engineering Dr. 1, Singapore 117411, Singapore
| | - Shihai Deng
- National University of Singapore Environmental Research Institute, National University of Singapore, 5A Engineering Dr. 1, Singapore 117411, Singapore; School of Civil Engineering, Beijing Jiaotong University, Beijing 100044, PR China
| | - Yuhui Fan
- School of Engineering, Northeast Agricultural University, 600 Changjiang Street, Xiangfang District, Harbin 150030, PR China
| | - Xiaobin Tang
- State Key Laboratory of Urban Water Resource and Environment (SKLUWRE), School of Environment, Harbin Institute of Technology, Harbin 150090, PR China
| | - Heng Liang
- State Key Laboratory of Urban Water Resource and Environment (SKLUWRE), School of Environment, Harbin Institute of Technology, Harbin 150090, PR China
| |
Collapse
|
25
|
Rada-Ariza A, Fredy D, Lopez-Vazquez C, Van der Steen N, Lens P. Ammonium removal mechanisms in a microalgal-bacterial sequencing-batch photobioreactor at different solids retention times. ALGAL RES 2019. [DOI: 10.1016/j.algal.2019.101468] [Citation(s) in RCA: 24] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/26/2022]
|
26
|
Xie B, Gong W, Yu H, Tang X, Yan Z, Luo X, Gan Z, Wang T, Li G, Liang H. Immobilized microalgae for anaerobic digestion effluent treatment in a photobioreactor-ultrafiltration system: Algal harvest and membrane fouling control. BIORESOURCE TECHNOLOGY 2018; 268:139-148. [PMID: 30077170 DOI: 10.1016/j.biortech.2018.07.110] [Citation(s) in RCA: 29] [Impact Index Per Article: 4.1] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/14/2018] [Revised: 07/22/2018] [Accepted: 07/23/2018] [Indexed: 05/26/2023]
Abstract
A photobioreactor (PBR) coupled with ultrafiltration (UF) system was developed with goals of microalgae cultivation, harvest, and membrane fouling control in the anaerobic digestion effluent purification. Firstly, three-sequencing batch PBRs were started-up with suspended Chlorella vulgaris (C. vulgaris, SCV), immobilized C. vulgaris (ICV) and immobilized C. vulgaris with powdered activated carbon (ICV + PAC). The results exhibited high DOC degradation (66.61%-84.35%) and completely nutrients (nitrogen and phosphorus) removals were attained in PBRs. This indicated bacterial-microalgal consortiums enhanced biodegradation and PAC adsorption accelerated photodegradation. During the microalgae harvest by UF, immobilized microalgae beads protected cells integrity with less debris and intracellular/extracellular organic matters lysis. Moreover, the cake layer in ICV + PAC could even serve as a dynamic layer to entrap the residual pollutants and control membrane fouling. Hence, membrane fouling mitigation and ADE purification were realized during the microalgae harvest process in the ICV + PAC.
Collapse
Affiliation(s)
- Binghan Xie
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, China
| | - Weijia Gong
- School of Engineering, Northeast Agriculture University, 59 Mucai Street, Xiangfang District, Harbin 150030, China
| | - Huarong Yu
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, China
| | - Xiaobin Tang
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, China
| | - Zhongsen Yan
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, China
| | - Xinsheng Luo
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, China
| | - Zhendong Gan
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, China
| | - Tianyu Wang
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, China
| | - Guibai Li
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, China
| | - Heng Liang
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Nangang District, Harbin 150090, China.
| |
Collapse
|
27
|
Foladori P, Petrini S, Nessenzia M, Andreottola G. Enhanced nitrogen removal and energy saving in a microalgal-bacterial consortium treating real municipal wastewater. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2018; 78:174-182. [PMID: 30101800 DOI: 10.2166/wst.2018.094] [Citation(s) in RCA: 11] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/08/2023]
Abstract
The optimization of total nitrogen removal from municipal wastewater was investigated in a laboratory-scale photo-sequencing batch reactor (PSBR) operated with a mixed microalgal-bacterial consortium spontaneously acclimatized to real wastewater. No external aeration was provided in the PSBR to reduce energy consumption: oxygen was only supplied by the microalgal photosynthesis. The enhancement of total nitrogen removal was achieved through: (1) feeding of wastewater in the dark phase to provide readily biodegradable COD when oxygen was not produced, promoting denitrification; (2) intermittent use of the mixer to favor simultaneous nitrification-denitrification inside the dense flocs and to achieve 41% energy saving with respect to continuous mixing. Efficient COD removal (86 ± 2%) was observed, obtaining average effluent concentrations of 37 mg/L and 22 mg/L of total COD and soluble COD, respectively. TKN removal was 97 ± 3%, with an average effluent concentration of 0.5 ± 0.7 mg NH4 +-N/L. Assimilation of nitrogen by heterotrophic bacteria accounted only for 20% of TKN removal, whilst the major part of TKN was nitrified. In particular, the nitrification rate was 1.9 mgN L-1 h-1 (specific rate 2.4 mgN gTSS-1 h-1), measured with dissolved oxygen near zero, when the oxygen demand was higher than the oxygen produced by photosynthesis. Total nitrogen of 6.3 ± 4.4 mgN/L was measured in the effluent after PSBR optimization.
Collapse
Affiliation(s)
- P Foladori
- Department of Civil, Environmental and Mechanical Engineering, University of Trento, via Mesiano 77, Trento 38123, Italy E-mail:
| | - S Petrini
- Department of Civil, Environmental and Mechanical Engineering, University of Trento, via Mesiano 77, Trento 38123, Italy E-mail:
| | - M Nessenzia
- Department of Civil, Environmental and Mechanical Engineering, University of Trento, via Mesiano 77, Trento 38123, Italy E-mail:
| | - G Andreottola
- Department of Civil, Environmental and Mechanical Engineering, University of Trento, via Mesiano 77, Trento 38123, Italy E-mail:
| |
Collapse
|
28
|
Li Y, Wang Y, Gao Y, Zhao H, Zhou W. Seawater toilet flushing sewage treatment and nutrients recovery by marine bacterial-algal mutualistic system. CHEMOSPHERE 2018; 195:70-79. [PMID: 29253791 DOI: 10.1016/j.chemosphere.2017.12.076] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/28/2017] [Revised: 12/02/2017] [Accepted: 12/11/2017] [Indexed: 06/07/2023]
Abstract
Seawater toilet flushing sewage with excess eutrophic and high salinity brought a great barrier on the municipal wastewater treatment plants. Nutrients recovery and biomass production as potential biofuel feedstock with less energy consumption will be a key challenge in wastewater treatment. In the optimal inoculation of algae and bacteria, a marine bacterial-algal mutualistic system was established to treat synthetic seawater toilet flushing sewage without extra carbon and O2 addition. It was showed that 85.5% of total nitrogen (TN) (from 200 mg/L), 91.0% of total phosphorus (TP) (from 40 mg/L) and 98.7% of chemical oxygen demand (COD) (from 1600 mg/L) were removed with 4.28 g/L of biomass yield (biomass productivity 159.3 mg/L/d) containing 16.3% lipid and 62.6% protein, which performance mainly achieved by bacteria during first six days and algae functioned subsequently. Both nitrogen and phosphorus removal of the system were mainly assimilation/accumulation. Algal facultative heterotrophia ensured dissolved organic carbon for bacterial utilization and avoiding excessive organic matter produced. The established algal-bacterial system provided a potential energy-efficient and eco-friendly approach for seawater blackwater treatment and nutrients recovery simultaneously.
Collapse
Affiliation(s)
- Yating Li
- School of Environmental Science and Engineering, Shandong University, Jinan, Shandong, 250100, China
| | - Yafei Wang
- School of Environmental Science and Engineering, Shandong University, Jinan, Shandong, 250100, China
| | - Yizhan Gao
- School of Environmental Science and Engineering, Shandong University, Jinan, Shandong, 250100, China
| | - Haixia Zhao
- School of Environmental Science and Engineering, Shandong University, Jinan, Shandong, 250100, China
| | - Weizhi Zhou
- School of Environmental Science and Engineering, Shandong University, Jinan, Shandong, 250100, China.
| |
Collapse
|
29
|
Arashiro LT, Rada-Ariza AM, Wang M, van der Steen P, Ergas SJ. Modelling shortcut nitrogen removal from wastewater using an algal-bacterial consortium. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2017; 75:782-792. [PMID: 28234279 DOI: 10.2166/wst.2016.561] [Citation(s) in RCA: 23] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/06/2023]
Abstract
A shortcut nitrogen removal process was investigated for treatment of high ammonium strength wastewater using an algal-bacterial consortium in photo-sequencing batch reactors (PSBRs). In this process, algae provide oxygen for nitritation during the light period, while denitritation takes place during the dark (anoxic) period, reducing overall energy and chemical requirements. Two PSBRs were operated at different solids retention times (SRTs) and fed with a high ammonium concentration wastewater (264 mg NH4+-N L-1), with a '12 hour on, 12 hour off' light cycle, and an average surface light intensity of 84 μmol m-2 s-1. High total inorganic nitrogen removal efficiencies (∼95%) and good biomass settleability (sludge volume index 53-58 mL g-1) were observed in both PSBRs. Higher biomass density was observed at higher SRT, resulting in greater light attenuation and less oxygen production. A mathematical model was developed to describe the algal-bacterial interactions, which was based on Activated Sludge Model No. 3, modified to include algal processes. Model predictions fit the experimental data well. This research also proposes an innovative holistic approach to water and energy recovery. Wastewater can be effectively treated in an anaerobic digester, generating energy from biogas, and later post-treated using an algal-bacterial PSBR, which produces biomass for additional biogas production by co-digestion.
Collapse
Affiliation(s)
- Larissa T Arashiro
- Department of Environmental Engineering and Water Technology, UNESCO-IHE Institute for Water Education, P.O. Box 3015, Delft 2601 DA, The Netherlands E-mail: ; Department of Civil & Environmental Engineering, University of South Florida, 4202 E. Fowler Ave, ENB 118, Tampa, FL 33620, USA
| | - Angelica M Rada-Ariza
- Department of Environmental Engineering and Water Technology, UNESCO-IHE Institute for Water Education, P.O. Box 3015, Delft 2601 DA, The Netherlands E-mail:
| | - Meng Wang
- Department of Civil & Environmental Engineering, University of South Florida, 4202 E. Fowler Ave, ENB 118, Tampa, FL 33620, USA
| | - Peter van der Steen
- Department of Environmental Engineering and Water Technology, UNESCO-IHE Institute for Water Education, P.O. Box 3015, Delft 2601 DA, The Netherlands E-mail:
| | - Sarina J Ergas
- Department of Civil & Environmental Engineering, University of South Florida, 4202 E. Fowler Ave, ENB 118, Tampa, FL 33620, USA
| |
Collapse
|