Enhanced lipid and biomass production using alcohol wastewater as carbon source for Chlorella pyrenoidosa cultivation in anaerobically digested starch wastewater in outdoors

Combination of Exhaust Gas Fermentation Effluent and Dairy Wastewater for Microalgae Production: Effect on Growth and FAME Composition of Chlorella sorokiniana

Microalgae cultivation in wastewater is a promising strategy for reducing nutrient loads and generating biomass that can be further exploited. Although microalgae grown under such conditions are not suitable for high-value applications, the resulting biomass can still be valuable for uses such as biofuels, biofertilizers, or animal feed. In this study, Chlorella sorokiniana was cultivated in dairy wastewater and, to the best of our knowledge, for the first time in a spent effluent from gas fermentation, to assess its potential as a sustainable growth medium. Growth kinetics and biomass productivity were evaluated at different dilution ratios, and it was found that high concentrations of ammonium and hexanol in undiluted effluents were inhibitory, while an optimized 50:50 dilution led to the highest biomass accumulation (1.96 g L-1) and productivity (0.5 g L-1 d-1) of C. sorokiniana. This strategy significantly reduced the nitrogen (100%), phosphate (100%), sulfate (68%), and carbon (61%) contents, demonstrating effective bioremediation activity. Furthermore, the fatty acid profile revealed an increased polyunsaturated fatty acid fraction, enhancing the potential of C. sorokiniana biomass as a feed supplement. Overall, contributing to the circular bioeconomy, this approach is scalable and cost-effective, reducing freshwater and chemical dependency in microalgae biomass production.

Exogenous microbubbles contribute to valorization of microalgal compounds by ultrasound-assisted extraction

Ultrasound-assisted extraction (UAE) shows great potential in exploiting microalgal compounds. However, upgrading the extraction system lacks concerns. This study proposes a novel sono-reactor featuring a microbubble distributor for increasing bubble abundance and correspondingly improving microalgal compound extraction. Results indicate that protein concentrations increase with ultrasound powers and extraction time while an optimized gas flow rate exists. The optimal parameters by Box-Behnken design are power 646.0 W, nitrogen flow rate 25.0 mL/min, and time 40.0 min, with an optimal protein concentration of 249.1 mg/L - a substantial improvement over gas-free extraction. The strategic increase in bubble abundance enhances microalgal compound extraction efficiency and extraction kinetics. The system innovation will contribute to the advancement of bioresource utilization and sustainability.

Enhancing biomass and lipid accumulation by a novel microalga for unsterilized piggery biogas slurry remediation

The cost and efficiency of an algal-BS treatment system are determined by the specific microalgal species and BS pretreatment method. This study examines the growth of a novel algae Chlorella sp. YSD-2 and the removal of nutrients from the BS using different pretreatment methods, including dilution ratio and sterilization. The highest biomass production (1.84 g L-1) was achieved in the 1:2 unsterilized biogas slurry, which was 2.03 times higher than that in the sterilized group, as well as higher lipid productivity (17.29 mg L-1 d-1). Nevertheless, the sterilized biogas slurry at a 1:1 dilution ratio exhibited the most notable nutrient-removal efficiency, with COD at 71.97%, TP at 91.32%, and TN at 88.80%. Additionally, the analysis of 16S rRNA sequencing revealed a significant alteration in the indigenous bacterial composition of the biogas slurry by microalgal treatment, with Proteobacteria and Cyanobacteria emerging as the predominant phyla, and unidentified_Cyanobacteria as the primary genus. These findings suggest that Chlorella sp. YSD-2 exhibits favorable tolerance and nutrient-removal capabilities in unsterilized, high-strength biogas slurry, along with high productivity of biomass and lipids. Consequently, these results offer a theoretical foundation for the development of an efficient and economically viable treatment method for algal-BS.

Application of microbial resources in biorefineries: Current trend and future prospects

The recent growing interest in sustainable and alternative sources of energy and bio-based products has driven the paradigm shift to an integrated model termed "biorefinery." Biorefinery framework implements the concepts of novel eco-technologies and eco-efficient processes for the sustainable production of energy and value-added biomolecules. The utilization of microbial resources for the production of various value-added products has been documented in the literatures. However, the appointment of these microbial resources in integrated resource management requires a better understanding of their status. The main of aim of this review is to provide an overview on the defined positioning and overall contribution of the microbial resources, i.e., algae, fungi and bacteria, for various bioprocesses and generation of multiple products from a single biorefinery. By utilizing waste material as a feedstock, biofuels can be generated by microalgae while sequestering environmental carbon and producing value added compounds as by-products. In parallel, fungal biorefineries are prolific producers of lignocellulose degrading enzymes along with pharmaceutically important novel products. Conversely, bacterial biorefineries emerge as a preferred platform for the transformation of standard cells into proficient bio-factories, developing chassis and turbo cells for enhanced target compound production. This comprehensive review is poised to offer an intricate exploration of the current trends, obstacles, and prospective pathways of microbial biorefineries, for the development of future biorefineries.

Sustainable management and valorization of biomass wastes using synthetic microbial consortia

In response to the persistent expansion of global resource demands, considerable attention has been directed toward the synthetic microbial consortia (SMC) within the domain of microbial engineering, aiming to address the sustainable management and valorization of biomass wastes. This comprehensive review systematically encapsulates the most recent advancements in research and technological applications concerning the utilization of SMC for biomass waste treatment. The construction strategies of SMC are briefly outlined, and the diverse applications of SMC in biomass wastes treatment are explored, with particular emphasis on its potential advantages in waste degradation, hazardous substances control, and high value-added products conversion. Finally, recommendations for the future development of SMC technology are proposed, and prospects for its sustainable application are discussed.

Microalgal co-cultivation -recent methods, trends in omic-studies, applications, and future challenges

The burgeoning human population has resulted in an augmented demand for raw materials and energy sources, which in turn has led to a deleterious environmental impact marked by elevated greenhouse gas (GHG) emissions, acidification of water bodies, and escalating global temperatures. Therefore, it is imperative that modern society develop sustainable technologies to avert future environmental degradation and generate alternative bioproduct-producing technologies. A promising approach to tackling this challenge involves utilizing natural microbial consortia or designing synthetic communities of microorganisms as a foundation to develop diverse and sustainable applications for bioproduct production, wastewater treatment, GHG emission reduction, energy crisis alleviation, and soil fertility enhancement. Microalgae, which are photosynthetic microorganisms that inhabit aquatic environments and exhibit a high capacity for CO2 fixation, are particularly appealing in this context. They can convert light energy and atmospheric CO2 or industrial flue gases into valuable biomass and organic chemicals, thereby contributing to GHG emission reduction. To date, most microalgae cultivation studies have focused on monoculture systems. However, maintaining a microalgae monoculture system can be challenging due to contamination by other microorganisms (e.g., yeasts, fungi, bacteria, and other microalgae species), which can lead to low productivity, culture collapse, and low-quality biomass. Co-culture systems, which produce robust microorganism consortia or communities, present a compelling strategy for addressing contamination problems. In recent years, research and development of innovative co-cultivation techniques have substantially increased. Nevertheless, many microalgae co-culturing technologies remain in the developmental phase and have yet to be scaled and commercialized. Accordingly, this review presents a thorough literature review of research conducted in the last few decades, exploring the advantages and disadvantages of microalgae co-cultivation systems that involve microalgae-bacteria, microalgae-fungi, and microalgae-microalgae/algae systems. The manuscript also addresses diverse uses of co-culture systems, and growing methods, and includes one of the most exciting research areas in co-culturing systems, which are omic studies that elucidate different interaction mechanisms among microbial communities. Finally, the manuscript discusses the economic viability, future challenges, and prospects of microalgal co-cultivation methods.

A review on the sustainable procurement of microalgal biomass from wastewaters for the production of biofuels

The feasibility of microalgal biomass as one of the most promising and renewable sources for the production of biofuels is being studied extensively. Microalgal biomass can be cultivated under photoautotrophic, heterotrophic, photoheterotrophic, and mixotrophic cultivation conditions. Photoautotrophic cultivation is the most common way of microalgal biomass production. Under mixotrophic cultivation, microalgae can utilize both organic carbon and CO2 simultaneously. Mixotrophic cultivation depicts higher biomass productivity as compared to photoautotrophic cultivation. It is evident from the literature that mixotrophic cultivation yields higher quantities of polyunsaturated fatty acids as compared to that photoautotrophic cultivation. In this context, for economical biomass production, the organic carbon of industrial wastewaters can be valorized for the mixotrophic cultivation of microalgae. Following the way, contaminants' load of wastewaters can be reduced while concomitantly producing highly productive microalgal biomass. This review focuses on different aspects covering the sustainable cultivation of different microalgal species in different types of wastewaters.

Cultivation of microalgae on food waste: Recent advances and way forward

Microalgae are photosynthetic microbes that can synthesize compounds of therapeutic potential with wide applications in the food, bioprocessing and pharmaceutical sector. Recent research advances have therefore, focused on finding suitable economic substrates for the sustainable cultivation of microalgae. Among such substrates, food derived waste specifically from the starch, meat, dairy, brewery, oil and fruit and vegetable processing industries has gained popularity but poses numerous challenges. Pretreatment, dilution of waste water supernatants, mixing of different food waste streams, utilizing two-stage cultivation and other biorefinery approaches have been intensively explored for multifold improvement in microalgal biomass recovery from food waste. This review discusses the advances and challenges associated with cultivation of microalgae on food waste. The review suggests that there is a need to standardize different waste substrates in terms of general composition, genetically engineered microalgal strains, tackling process scalability issues, controlling wastewater toxicity and establishing a waste transportation chain.

Recent Progress in Spectroscopic Methods for the Detection of Foodborne Pathogenic Bacteria

Detection of foodborne pathogens at an early stage is very important to control food quality and improve medical response. Rapid detection of foodborne pathogens with high sensitivity and specificity is becoming an urgent requirement in health safety, medical diagnostics, environmental safety, and controlling food quality. Despite the existing bacterial detection methods being reliable and widely used, these methods are time-consuming, expensive, and cumbersome. Therefore, researchers are trying to find new methods by integrating spectroscopy techniques with artificial intelligence and advanced materials. Within this progress report, advances in the detection of foodborne pathogens using spectroscopy techniques are discussed. This paper presents an overview of the progress and application of spectroscopy techniques for the detection of foodborne pathogens, particularly new trends in the past few years, including surface-enhanced Raman spectroscopy, surface plasmon resonance, fluorescence spectroscopy, multiangle laser light scattering, and imaging analysis. In addition, the applications of artificial intelligence, microfluidics, smartphone-based techniques, and advanced materials related to spectroscopy for the detection of bacterial pathogens are discussed. Finally, we conclude and discuss possible research prospects in aspects of spectroscopy techniques for the identification and classification of pathogens.

One-step co-cultivation and flocculation of microalgae with filamentous fungi to valorize starch wastewater into high-value biomass

A novel method of one-step co-cultivation and harvesting of microalgae and fungi, for efficient starch wastewater treatment and high-value biomass production was developed. By combination of Aspergillus oryzae and Chlorella pyrenoidosa, nutrients in wastewater could be converted to useful microbial biomass, while the wastewater was purified. Moreover, the microalgae C. pyrenoidosa could gradually be encapsulated in fungal pellets which promoted the biomass harvesting. The free algal cells could be completely harvested by fungal pellets within 72 h. The synergistic effects between them greatly improved the removal efficiencies of main pollutants as the removal efficiency of COD, TN, and TP reached 92.08, 83.56, and 96.58 %, respectively. In addition, the final biomass concentration was higher than that of individual cultures. The protein and lipid concentration was also significantly improved and reached 1.92 and 0.99 g/L, respectively. This study provides a simple and efficient strategy for simultaneous wastewater treatment and high-value biomass production.

Mechanisms of Sodium-Acetate-Induced DHA Accumulation in a DHA-Producing Microalga, Crypthecodinium sp. SUN

Docosahexaenoic acid (DHA) is an omega-3 polyunsaturated fatty acid (PUFA) that is critical for the intelligence and visual development of infants. Crypthecodinium is the first microalga approved by the Food and Drug Administration for DHA production, but its relatively high intracellular starch content restricts fatty acid accumulation. In this study, different carbon sources, including glucose (G), sodium acetate (S) and mixed carbon (M), were used to investigate the regulatory mechanisms of intracellular organic carbon distribution in Crypthecodinium sp. SUN. Results show that glucose favored cell growth and starch accumulation. Sodium acetate limited glucose utilization and starch accumulation but caused a significant increase in total fatty acid (TFA) accumulation and the DHA percentage. Thus, the DHA content in the S group was highest among three groups and reached a maximum (10.65% of DW) at 96 h that was 2.92-fold and 2.24-fold of that in the G and M groups, respectively. Comparative transcriptome analysis showed that rather than the expression of key genes in fatty acids biosynthesis, increased intracellular acetyl-CoA content appeared to be the key regulatory factor for TFA accumulation. Additionally, metabolome analysis showed that the accumulated DHA-rich metabolites of lipid biosynthesis might be the reason for the higher TFA content and DHA percentage of the S group. The present study provides valuable insights to guide further research in DHA production.

Waste mitigation and resource recovery from food industry wastewater employing microalgae-bacterial consortium

Wastewater generated by the food industry is rich in nitrogen and phosphorus with possible presence of heavy metals. Physical and chemical methods of treatment, although effective, are expensive and may cause secondary environmental pollution damaging aquatic and human life. Traditional biological methods are eco-friendly and cost-effective but involve standalone microorganisms that pose risk of contamination and are not as effective. This review discusses the application of novel microalgal-bacterial consortium as a solution for the resource recovery and treatment of dairy, starch and aquaculture wastewater. Use of biofilm reactors containing anaerobic and aerobic sludge has shown 80-90% and > 90% COD and nutrient removal efficiency in treatment of dairy and starch processing wastewater, respectively. The treatment of aquaculture processing wastewater can be challenging due to high sality and requires salt-tolerant bacteria-microalgae consortium. In this regard, the identification of dominant microalgae and bacteria using 16S rRNA and 18S rRNA genes is recommended.

Nano-Albumin Particles Loaded with miR-20a Inhibitor Targeting Met Protein to Reverse Proliferation of Intestinal Cancer Cells

This study explored miR-20a’s role in intestinal cancer cells. SW480 cell line was divided into control group, agonist group, inhibitor group, and negative control group, followed by analysis of cell proliferation, apoptosis, Met, Bad, and Bcl-2 protein expressions. Results showed that miR-20a expression in the agonist group was the highest, followed by blank group and negative control group, and inhibitor group was lowest. S-phase and G2/M cell number from inhibitor group was lowest, and cell apoptosis rate was highest. However, the agonist group showed contrary changes. There was no difference in G0/G1 phase cell number among the four groups (P > 0.05). Moreover, the expressions of Bad, Bcl-2, Met, Wnt, β-catenin, and p-Wnt in inhibitor group were all lower, while the expressions in agonist group were all high (P < 0.05). S-phase and G2/M cell number in inhibitor group was lowest, while cell apoptosis was highest. The agonist group was opposite, with G0/G1 phase cells in each group showing no difference (P > 0.05). Wnt, β-catenin, and p-Wnt expressions were lowest in the inhibitor group, while the agonist group was opposite. These results together showed that the miR-20a directly targeted and regulated Met protein. Finally, the miR-20a inhibited intestinal cancer cell proliferation mainly through inhibiting Wnt/β-catenin signaling activity.

DNA Templated Silver Nanoclusters for Bioanalytical Applications: A Review

Due to their unique programmability, biocompatibility, photostability and high fluorescent quantum yield, DNA templated silver nanoclusters (DNA Ag NCs) have attracted increasing attention for bioanalytical application. This review summarizes the recent developments in fluorescence properties of DNA templated Ag NCs, as well as their applications in bioanalysis. Finally, we herein discuss some current challenges in bioanalytical applications, to promote developments of DNA Ag NCs in biochemical analysis.

An overview on microalgal-bacterial granular consortia for resource recovery and wastewater treatment

Excessive generation of wastewater is a matter of concern around the globe. Wastewater treatment utilizing a microalgae-mediated process is considered an eco-friendly and sustainable method of wastewater treatment. However, low biomass productivity, costly harvesting process, and energy extensive cultivation process are the major bottleneck. The use of the microalgal-bacteria granular consortia (MBGC) process is economic and requires less energy. For efficient utilization of MBGC, knowledge of its structure, composition and interaction are important. Various microscopic, molecular and metabolomics techniques play a significant role in understating consortia structure and interaction between partners. Microalgal-bacteria granular consortia structure is affected by various cultivation parameters like pH, temperature, light intensity, salinity, and the presence of other pollutants in wastewater. In this article, a critical evaluation of recent literature was carried out to develop an understanding related to interaction behavior that can help to engineer consortia having efficient nutrient removal capacity with reduced energy consumption.

Sustainable microalgal biomass production in food industry wastewater for low-cost biorefinery products: a review

Microalgae are recognized as cell factories enriched with biochemicals suitable as feedstock for bio-energy, food, feed, pharmaceuticals, and nutraceuticals applications. The industrial application of microalgae is challenging due to hurdles associated with mass cultivation and biomass recovery. The scale-up production of microalgal biomass in freshwater is not a sustainable solution due to the projected increase of freshwater demands in the coming years. Microalgae cultivation in wastewater is encouraged in recent years for sustainable bioeconomy from biorefinery processes. Wastewater from the food industry is a less-toxic growth medium for microalgal biomass production. Traditional wastewater treatment and management processes are expensive; hence it is highly relevant to use low-cost wastewater treatment processes with revenue generation through different products. Microalgae are accepted as potential biocatalysts for the bioremediation of wastewater. Microalgae based purification of wastewater technology could be a universal alternative solution for the recovery of resources from wastewater for low-cost biomass feedstock for industry. This review highlights the importance of microalgal biomass production in food processing wastewater, their characteristics, and different microalgal cultivation methods, followed by nutrient absorption mechanisms. Towards the end of the review, different microalgae biomass harvesting processes with biorefinery products, and void gaps that tend to hinder the biomass production with future perspectives will be intended. Thus, the review could claim to be valuable for sustainable microalgae biomass production for eco-friendly bioproduct conversions.

Graphical abstract

Use of reverse osmosis reject from drinking water plant for microalgal biomass production

The present study evaluates the use of reverse osmosis (RO) reject, termed as ROR, for microalgal biomass production. The supplementation of ROR from two different sources, namely domestic RO unit (ROR1) and commercial-scale RO plant (ROR2), showed a synergistic effect on the growth and biochemical composition of Chlorella pyrenoidosa. Among the tested ROR1 doses, the highest biomass production (1.27±0.06 g L^-1) was observed with 25% ROR1 supplemented growth media. In contrast, the lipid content (28.85±3.13% of TS) in C. pyrenoidosa at 50% ROR1 dose was almost twice that in BG11 (positive control). Interestingly, the microalgae showed relatively higher biomass production (1.37±0.07 g L^-1) and higher lipid content (33.23±3.92% of TS) when 50% ROR2 was used in growth media. At the same time, the estimated carbohydrate and protein contents were 28.41±0.73 and 29.75±0.31% of TS, respectively. Furthermore, the lipid productivity (28.98±2.79 mg L^-1 d^-1) was relatively higher than the nutrient media (12.35±1.34 mg L^-1 d^-1). The present findings revealed that the RO reject from drinking water purifiers can efficiently be utilized for lipid-rich microalgal biomass production. Hence, the dependency on freshwater resources for mass scale microalgae cultivation through recycling of RO reject can be reduced.

Attempts to alleviate inhibitory factors of anaerobic digestate for enhanced microalgae cultivation and nutrients removal: A review

Anaerobic digestion is a well-established process that is applied to treat organic wastes and convert the carbon to valuable methane gas as a source of energy. The digestate that comes out as a by-product is of a great challenge due to its high nutrient content that can be toxic in case of improper disposal to the environment. Several attempts have been done to valorize this digestate. Digestate has been considered as an interesting medium to cultivate microalgae. The nutrients available in the digestate, mainly nitrogen and phosphorus, can be an interesting supplement for microalgae growth requirement. The main obstacles of using digestate as a medium to cultivate microalgae are the dark color and the high ammonium-nitrogen concentration. The focus of this review is to discuss in detail the major attempts in research to overcome inhibition and enhance microalgae cultivation in digestate. This review initially discussed the obstacles of digestate as a medium for microalgae cultivation. Different processes to overcome inhibition were discussed including dilution, supplying additional carbon source, favoring mixotrophic cultivation and pretreatment. More emphasis in this review was given to digestate pretreatment. Among the pretreatment methods, filtration, and centrifugation were of the most applied ones. These strategies were found to be effective for turbidity and chromaticity reduction. For ammonium nitrogen removal, ammonia stripping and biological pretreatment methods were found to play a vital role. Adsorption could work both ways depending on the material used. Combining different pretreatment methods as well as including selected microalgae stains were found interesting strategies to facilitate microalgae cultivation with no dilution. This study recommend that more study should investigate the optimization of microalgae cultivation in anaerobic digestate without the need for dilution.

Cultivation and Biorefinery of Microalgae (Chlorella sp.) for Producing Biofuels and Other Byproducts: A Review

Microalgae-based carbon dioxide (CO2) biofixation and biorefinery are the most efficient methods of biological CO2 reduction and reutilization. The diversification and high-value byproducts of microalgal biomass, known as microalgae-based biorefinery, are considered the most promising platforms for the sustainable development of energy and the environment, in addition to the improvement and integration of microalgal cultivation, scale-up, harvest, and extraction technologies. In this review, the factors influencing CO2 biofixation by microalgae, including microalgal strains, flue gas, wastewater, light, pH, temperature, and microalgae cultivation systems are summarized. Moreover, the biorefinery of Chlorella biomass for producing biofuels and its byproducts, such as fine chemicals, feed additives, and high-value products, are also discussed. The technical and economic assessments (TEAs) and life cycle assessments (LCAs) are introduced to evaluate the sustainability of microalgae CO2 fixation technology. This review provides detailed insights on the adjusted factors of microalgal cultivation to establish sustainable biological CO2 fixation technology, and the diversified applications of microalgal biomass in biorefinery. The economic and environmental sustainability, and the limitations and needs of microalgal CO2 fixation, are discussed. Finally, future research directions are provided for CO2 reduction by microalgae.

Phycoremediation of wastewater for pollutant removal: A green approach to environmental protection and long-term remediation

Surface and water bodies in many parts of the world are affected due to eutrophication, contamination and depletion. The approach of wastewater treatment using algae for eliminating nutrients and other pollutants from domestic wastewater is growing interest among the researchers. However, sustainable treatment of the wastewater is considered to be important in establishing more effective nutrient and pollutant reduction using algal systems. In comparison to the conventional method of remediation, there are opportunities to commercially viable businesses interest with phycoremediation, thus by achieving cost reductions and renewable bioenergy options. Phycoremediation is an intriguing stage for treating wastewater since it provides tertiary bio-treatment while producing potentially valuable biomass that may be used for a variety of applications. Furthermore, the phycoremediation provides the ability to remove heavy metals as well as harmful organic substances, without producing secondary contamination. In this review, the role of microalgae in treating different wastewaters and the process parameters affecting the treatment and future scope of research have been discussed. Though several algae are employed for wastewater treatment, species of the genera Chlamydomonas, Chlorella, and Scenedesmus are extensively utilized. Interestingly, there is a vast scope for employing algal species with high flocculation capacity and adsorption mechanisms for the elimination of microplastics. In addition, the algal biomass generated during phycoremediation has been found to possess high protein and lipid contents, promising their exploitation in biofuel, food and animal feed industries.

Converting nitrogen and phosphorus wastewater into bioenergy using microalgae-bacteria consortia: A critical review

Conventional wastewater treatment using activated sludge cannot efficiently eliminate nitrogen and phosphorus, thus engendering the risk of water eutrophication and ecosystem disruption. Fortunately, a new wastewater treatment process applying microalgae-bacteria consortia has attracted considerable interests due to its excellent performance of nutrients removal. Moreover, some bacteria facilitate the harvest of microalgal biomass through bio-flocculation. Additionally, while stimulating the functional bacteria, the improved biomass and enriched components also brighten bioenergy production from the perspective of practical applications. Thus, this review first summarizes the current development of nutrients removal and mutualistic interaction using microalgae-bacteria consortia. Then, advancements in bio-flocculation are completely described and the corresponding mechanisms are thoroughly revealed. Eventually, the recent advances of bioenergy production (i.e., biodiesel, biohydrogen, bioethanol, and bioelectricity) using microalgae-bacteria consortia are comprehensively discussed. Together, this review will provide the ongoing challenges and future developmental directions for better converting nitrogen and phosphorus wastewater into bioenergy using microalgae-bacteria consortia.

Valorization of lipidic food waste for enhanced biodiesel recovery through two-step conversion: A novel microalgae-integrated approach

The present study designed an innovative route for two-step biodiesel recovery from lipidic food waste followed by microalgae cultivation. Optimization of oil conversion showed the highest fatty acid methyl esters (FAMEs) recovery of 92.6% (lipid basis). Microalgal lipid accumulation enhanced by the increased lipid-free waste hydrolysate ratio in the medium, where the maximum lipid content of 26.2 dw% was recorded using 50% hydrolysate. Application of 30% hydrolysate ratio resulted in the maximum recorded lipid productivity, which was 99.4% higher than that of the control and insignificant with 40% hydrolysate. Waste oil-derived FAMEs showed 69.0% higher saturated fatty acids (SFAs) proportion than that of algal lipids. In contrast, the highest polyunsaturated fatty acids (PUFAs) proportion (48.8% of total fatty acids) was recorded in microalgal lipids. The study concluded that mixing microalgal lipids with waste oil (1:1, w/w) provides a desirable practical route for enhanced biodiesel production complying with the international standards.

Optimization of oil extraction process from blended sludge and algae for biodiesel production

Sewage sludge is one of the most polluting wastes that affect the environment, which contains organic and inorganic pollutants released into the surroundings. Using non-renewable energy for the engine also releases large amounts of pollutants results from combustion products was other issues to the environment. The decline of non-renewable energy sources, such as natural gas, fossil fuel, and petroleum made the world increase the production of alternative fuels like waste-derived fuels. Recently, biodiesel production developed from edible oil to cover the depilation of non-renewable energy supply. But it has also become a significant challenge for food security. Therefore, finding other potential opportunities for lipid extraction is crucial. Algae and sludge conversion presented by recent studies seem to be a promising method. The paper presents the extraction and optimization of lipids from blended sludge and algae for biodiesel production. The procedure of the study was a characterization of algal and sludge wastes, the extraction of the lipid component by Soxhlet extraction, and the parameters optimization for maximum oil yield obtain. Temperature, extraction time, and solvents were the basic factor affect oil extraction yield. In the optimization 80 temperature, 6hrs time and hexane solvent results in 61% oil extraction yield which maximum point. Algae and wastewater sludge high potential of lipid and can be substitute edible oil supplies for biodiesel production.

Optimization of microwave-assisted carbohydrate extraction from indigenous Scenedesmus sp. grown in brewery effluent using response surface methodology

The use of wastewater as a nutrient source for microalgae cultivation is considered as a cost-effective approach for algal biomass and biofuel production. The microalgal biomass contains carbohydrates that can be processed into bioethanol through different extraction methods. The objective of this study is to optimize the microwave-assisted extraction (MAE) of carbohydrates from the indigenous Scenedesmus sp. grown on brewery effluent. Optimization of independent variables, such as acid concentration (0.1–5 N), microwave power (800–1200 W), temperature (80–180 °C) and extraction time (5–30 min) performed by response surface methodology. It was found that all independent variables had a significant and positive effect on microwave-assisted carbohydrate extraction. The quadratic model developed on the basis of carbohydrate yield had F value of 112.05 with P < 0.05, indicating that the model was significant to predict the carbohydrate yield. The model had a high value of R² (0.9899) and adjusted R² (0.9811), indicating that the fitted model displayed a good agreement between the predicted and actual carbohydrate yield. An optimum carbohydrate yield obtained was 260.54 mg g⁻¹ under the optimum conditions of acid concentration (2.8 N), microwave power (1075 W), temperature (151 °C) and extraction time (22 min). The validation test showed that the model has adequately described the microwave-assisted extraction (MAE) of carbohydrates from microalgal biomass. This study demonstrated that the indigenous Scenedesmus sp. grown on brewery effluent provides a promising result in carbohydrate production for bioethanol feedstock.

High fatty acid productivity from Scenedesmus obliquus in heterotrophic cultivation with glucose and soybean processing wastewater via nitrogen and phosphorus regulation

In this study, the effects of nitrogen and phosphorus supply on biodiesel production from Scenedesmus obliquus with glucose as the carbon source were investigated. It was found that sufficient phosphorus could further improve biodiesel production under nitrogen starvation. S. obliquus was cultivated in soybean processing wastewater. The removal efficiencies of carbon oxygen demand (COD), total nitrogen (TN), and total phosphorus (TP) after 8-day cultivation were 72%, 95%, and 54%, respectively. Moreover, the fatty acid productivity after eight-day cultivation reached as high as 99.3 mg·L-1·d-1, which was 1.15 times higher than the highest efficiency using a glucose culture. This result was due to two naturally-formed stages occurring with sufficient phosphorus: nitrogen sufficiency stage for biomass and nitrogen starvation stage for lipid accumulation. It verified the conclusion of the roles of nitrogen and phosphorus obtained in the glucose culture and provided an economic and environmentally friendly choice for biodiesel production with efficient soybean wastewater treatment.

Effect of organic carbon and nutrient supplementation on the digestate-grown microalga, Parachlorella kessleri

Digested effluents are usually deprived of the appropriate levels of organic carbon or macro- and micro-nutrients to effectively sustain microalgal growth. In this regard, Parachlorella kessleri was cultivated in an agro-waste digestate supplemented with different glucose concentrations, magnesium and trace metals and alternatively with cheese whey (CW), with view to enriching digestate with organic and inorganic constituents and decreasing freshwater demand. Between the conditions tested, CW addition resulted in the highest biomass concentration, 2.68 g L^-1 within 18 days of cultivation. Chlorophyll content significantly decreased under 5 g L^-1 glucose addition, in contrast to MgSO₄ co-addition and CW supplementation. The latter also induced high photosynthetic activity and better-preserved vitality of the photosynthetic apparatus, compared to sole glucose addition. Concerning lipid accumulation, in the presence of high glucose concentration, % of total fatty acids decreased, and the saturated fraction increased over polyunsaturated fatty acids (PUFAs).

Comprehensive approach to improving life-cycle CO2 reduction efficiency of microalgal biorefineries: A review

Along with the increase in global awareness of rising CO₂ levels, microalgae have attracted considerable interest as a promising CO₂ reduction platforms since they exhibit outstanding biomass productivity and are capable of producing numerous valuable products. At this moment, however, two major barriers, relatively low photosynthetic CO₂ fixation efficiency and necessity of carbon-intensive microalgal process, obstruct them to be practically utilized. This review suggests effective approaches to improve life-cycle CO₂ reduction of microalgal biorefinery. In order to enhance photosynthetic CO₂ fixation, strategies to augment carbon content and to increase biomass productivity should be considered. For reducing CO₂ emissions associated with the process operations, introduction of efficient process elements, designing of energy-saving process routes, reuse of waste resources and utilization of process integration can be noteworthy options. These comprehensive strategies will provide guidance for microalgal biorefineries to become a practical CO₂ reduction technology in near future.

Current practices and challenges in using microalgae for treatment of nutrient rich wastewater from agro-based industries

Considerable research activities are underway involving microalgae species in order to treat industrial wastewater to address the waste-to-bioenergy economy. Several studies of wastewater treatment using microalgae have been primarily focused on removal of key nutrients such as nitrogen and phosphorus. Although the use of wastewater would provide nutrients and water for microalgae growth, the whole process is even more complex than the conventional microalgae cultivation on freshwater media. The former one adds several gridlocks to the system. These gridlocks are surplus organic and inorganic nutrients concentration, pH of wastewater, wastewater color, total dissolved solids (TDS), microbial contaminants, the scale of photobioreactor, batch versus continuous system, harvesting of microalgae biomass etc. The present review discusses, analyses, and summarizes key aspects involved in the treatment of wastewaters from distillery, food/snacks product processing, and dairy processing industry using microalgae along with sustainable production of its biomass. This review further evaluates the bottlenecks for individual steps involved in the process such as pretreatment of wastewater for contaminants removal, concentration tolerance/dilutions, harvesting of microalgae biomass, and outdoor scale-up. The review also describes various strategies to optimize algal biomass and lipid productivities for various wastewater and photobioreactor type. Moreover, the review emphasizes the potential of co-cultivation of microorganism such as yeast and bacteria along with microalgae in the treatment of industrial wastewater.

Nutrient removal and microalgal biomass production from different anaerobic digestion effluents with Chlorella species

Potential of microalgal cultivation as an alternative approach to the treatment of anaerobic digestion (AD) effluents was examined using two representative Chlorella species, Chlorella vulgaris (CV) and Chlorella protothecoides (CP). Both species effectively removed NH₄⁺-N from the AD effluents from four digesters treating different wastes under different operating conditions. In all experimental cultures on the AD effluents, NH₄⁺-N (initial concentration, 40 mg/L) was completely removed within 10 days without residual NO₃^--N or NO₂^--N in batch mode. Compared to CP, CV showed greater biomass and lipid yields (advantageous for biodiesel production), regardless of the media used. Prolonged nitrogen starvation significantly increased the lipid accumulation in all cultures on the AD effluents, and the effect was more pronounced in the CV than in the CP cultures. On the other hand, compared to CV, CP showed significantly faster settling (advantageous for biomass harvesting) in all media. Our results suggest that the Chlorella cultivation on AD effluents under non-sterile, mixed-culture conditions may provide a viable way to manage and valorize the problematic effluents. Diverse bacteria derived from the AD effluents co-existed and presumably interacted with the Chlorella species in the cultures.

CO2 fixation and production of biodiesel by Chlorella vulgaris NIOCCV under mixotrophic cultivation

In this study, Chlorella vulgaris NIOCCV was cultivated in seafood processing industry wastewater with continuous supply of 5%, 10%, and 20% CO₂. The optimum CO₂ fixation efficiency ( [Formula: see text] ), biomass productivity, specific growth rate (SGR), and lipid content recorded were 0.43 mg L^-1 d^-1, 264.58 ± 8.8 mg L^-1 d^-1, 0.46 d^-1, and 38 ± 2.6% on dry weight basis, respectively at CO₂ supply of 10%. The fatty acid methyl ester-derived biodiesel properties determined at same condition were in compliance with national and international fuel standards. The higher calorific value (HHV) of the resultant biomass was 11.14, 16.41 and 12.83 MJ Kg^-1 for CO₂ enrichment of 5%, 10%, and 20%, respectively. The synergistic environmental benefit of nutrients removal from wastewater is shown as an additional advantage of microalgal cultivation. Thus, integration of algae-based CO₂ fixation with wastewater treatment and biodiesel production may realize microalgal CO₂ capture technology as environmentally sustainable and economically more attractive.

An integrated approach for microalgae cultivation using raw and anaerobic digested wastewaters from food processing industry

An integrated approach has been proposed to produce microalgal biodiesel using both raw wastewater (RW) and anaerobically digested wastewater (ADW) of food processing industry without addition of extra nutrients or carbon source for cultivation besides obtaining effluent discharge permissible limits of TN, TP, and COD. Three microalgae species cultivated with following different combinations: RW, ADW, RW + ADW, and glucose + ADW. Results indicated that the addition of RW as a carbon source in ADW significantly enhanced BP, LP, and TN removal as compared to the ADW alone. The runs with RW + ADW removed COD, TN, and TP by 89%, 84%, and 70%, respectively. Sc. obliquus showed highest biomass and lipid productivities (211 and 27.5 mg L^-1 d^-1) for RW + ADW. The addition of RW or glucose in ADW significantly lowered PUFA contents to 5-15% CDW (as against 35-50% with ADW) for Chl. sorokiniana and Sc. obliquus.