Improving anaerobic fermentation of waste activated sludge using iron activated persulfate treatment

Mechanistic elucidation of ultraviolet light and peracetic acid coupling-driven enhancements in short-chain fatty acid production from sludge: Reactive species-induced organic solubilization and microbial function regulation

This study investigates the potential of enhancing short-chain fatty acid (SCFA) production during anaerobic fermentation of waste activated sludge through ultraviolet (UV) and peracetic acid (PAA) treatment. Under optimal conditions (UV irradiation time = 60 min and PAA dosage = 0.03 g/g VSS (volatile suspended solids), UV/PAA pretreatment enhanced sludge solubility, improved the biodegradability of organic matter, and facilitated pollutant degradation. During anaerobic fermentation, UV/PAA treatment resulted in an 836 % increase in SCFA production and a 50 % higher acetic acid ratio compared to the control group. Mechanistic studies revealed that UV/PAA treatment promoted sludge decomposition and enhanced the biodegradability of dissolved organic matter by generating more reactive species (•OH, CH3C(O)O•, •O2-, and 1O2), thereby facilitating sludge hydrolysis and acidification. Additionally, UV/PAA treatment increased the abundance of hydrolytic and SCFA-producing bacteria while reducing the abundance of SCFA-consuming bacteria. Moreover, UV/PAA treatment stimulated the expression of key enzyme genes involved in organic matter hydrolysis and SCFA production, thereby promoting SCFA accumulation. Therefore, UV/PAA treatment is promising in sludge treatment and provides a new approach for resource recovery from sludge.

Improved volatile fatty acid production in anaerobic digestion via simultaneous temperature regulation and persulfate activation by biochar: Chemical and biological response mechanisms

Increasing volatile fatty acid (VFA) production via persulfate activation (i.e., chemical effect) in anaerobic digestion (AD) is an emerging resource utilization method. However, the reaction mechanisms responsible for improving VFA production in AD via simultaneous temperature regulation and persulfate activation by biochar remain unclear. In this study, three PB15 treatment systems of low temperature (15 °C), medium temperature (35 °C) and high temperature (55 °C) were set to explore the relationship between VFAs production and treatment temperature and the influence of temperature on the reaction mechanism. The results show that the improvement of hydrolysis and acidification efficiency of the system in the medium temperature system is the highest. The VFA yield and acid production rate in the treatment group at 35 °C were 2.49 and 5.22 times higher than those in the control group, respectively. The chemical effect effectively initiated the anaerobic acid production process and maintained the dominant role of the biological effect. The activity of persulfate is too low at low temperature, and its decomposition is too fast at high temperature. Plenty of free radicals lead to enhanced oxidation of the system, which may kill the fermentation bacteria. The NCM model indicates that microbial stability is reduced in high temperature systems. The SEM model showed that temperature change mainly affected substrate degradation by hydrolytic bacteria and indirectly affected acid production by acid-producing bacteria. This study provides a new strategy for realizing pollutant recycling and increasing VFAs production in cold area.

Characteristics and aging of microplastics in waste activated sludge under persulfate and hydrothermal co-treatment: Impact of solid content and temperature

Activated persulfate and hydrothermal treatment (HTT) are often employed to treat waste activated sludge, which can improve the efficiency of subsequent sludge treatment and change the distribution of pollutants in the sludge. However, the impact of sludge solid content and temperature on the occurrence and aging of microplastics (MPs) during HTT remains poorly understood. This study investigated the effects of persulfate-HTT (SPS-HTT) co-treatment on the migration, occurrence, and aging of MPs in sludge with different solid contents (2% and 5% solid content). The results indicated that SPS-HTT co-treatment triggers both the disruption of sludge flocs and the melting deformation of MPs at high temperatures, leading to variations in the increasing trend of MP concentration in the solid-liquid phase at different solid contents. 5% solid content sludge showed a weak release of MPs from the solid phase. The proportion of fiber MPs first increased and then decreased with increasing temperature, while no significant changes were observed in the color and type of MPs. Higher temperature and solid content induced the melting deformation of MPs, exacerbated the aging of polypropylene MPs, and resulted in rough surfaces, higher carbonyl index, and variations in crystallinity. Moreover, the correlation between the carbonyl index and aging indicators increased with increasing solid content. The MP-derived dissolved organic matter under HTT primarily comprised soluble microbial by-products and humic acid-like substances. These findings underscore the significance of sludge solid content in affecting the migration and aging of MPs during HTT, and offer novel insights into the application of HTT to MP management in sludge treatment.

Enhanced methane production from waste activated sludge by potassium ferrate combined with thermal hydrolysis pretreatment

Anaerobic digestion of waste activated sludge (WAS) was one of the directions of sludge treatment, but how to effectively improve the production of methane as a resource product of anaerobic digestion of sludge still needs further research. The study examined how the combination of potassium ferrate (PF) and thermal hydrolysis (TH) pretreatment affected methane production from sludge. The results demonstrated a positive synergistic effect on methane production with PF-TH pretreatment. Specifically, by employing a 0.05 g/g TSS (total suspended solids) PF in conjunction with TH at 80 °C for 30 min, the methane yield increased from 170.66 ± 0.92 to 232.73 ± 2.21 mL/g VSS (volatile suspended solids). The co-pretreatment of PF and TH has been substantiated by mechanism studies to effectively enhance the disintegration and biodegradability of sludge. Additionally, the variation of microbial community revealed an enrichment of active microorganisms associated with anaerobic digestion after treated with PF + TH, resulting in a total abundance increase from 11.87 to 20.45% in the PF + TH group.

Peroxydisulfate activation and versatility of defective Fe3O4@MOF-808 for enhanced carbon and phosphorus recovery from sludge anaerobic fermentation

Although being viewed as a promising technology for reclamation of carbon and phosphorus from excess sludge, anaerobic fermentation (AF) grapples with issues such as a low yield of volatile fatty acids (VFAs) and high phosphorus recovery costs. In this study, we synthesized Fe3O4@MOF-808 (FeM) with abundant defects and employed it to simultaneously enhance VFAs and phosphorus recovery during sludge anaerobic fermentation. Through pre-oxidization of sludge catalyzed by FeM-induced peroxydisulfate, the soluble organic matter increased by 2.54 times, thus providing ample substrate for VFAs production. Subsequent AF revealed a remarkable 732.73 % increase in VFAs and a 1592.95 % increase in phosphate. Factors contributing to the high VFAs yield include the non-biological catalysis of unsaturated Zr active sites in defective FeM, enhancing protein hydrolysis, and the inhibition of methanogenesis due to electron competition arising from the transformation between Fe(III) and Fe(II) under Zr influence. Remarkably, FeM exhibited an adsorption capacity of up to 92.64 % for dissolved phosphate through ligand exchange and electrostatic attractions. Furthermore, FeM demonstrated magnetic separation capability from the fermentation broth, coupled with excellent stability and reusability in both catalysis and adsorption processes.

Simultaneous removal of antibiotic resistance genes and improved dewatering ability of waste activated sludge by Fe(II)-activated persulfate oxidation

Waste activated sludge properties vary widely with different regions due to the difference in living standards and geographical distribution, making a big challenge to developing a universally effective sludge dewatering technique. The Fe(II)-activated persulfate (S2O82-) oxidation process shows excellent ability to disrupt sludge cells and extracellular polymeric substances (EPS), and release bound water from sludge flocs. In this study, the discrepancies in the physicochemical characteristics of sludge samples from seven representative cities in China (e.g., dewaterability, EPS composition, surface charge, microbial community, relative abundance of antibiotic resistance genes (ARGs), etc.) were investigated, and the role of Fe(II)-S2O82- oxidation in enhancing removal of antibiotic resistance genes and dewatering ability were explored. The results showed significant differences between the EPS distribution and chemical composition of sludge samples due to different treatment processes, effluent sources, and regions. The Fe(II)-S2O82- oxidation pretreatment had a good enhancement of sludge dewatering capacity (up to 76 %). Microbial analysis showed that the microbial community in each sludge varied significantly depending on the types of wastewater, the wastewater treatment processes, and the regions, but Fe(II)-S2O82- oxidation was able to attack and rupture the sludge zoogloea indiscriminately. Genetic analysis further showed that a considerable number of ARGs were detected in all of these sludge samples and that Fe(II)-S2O82- oxidation was effective in removing ARGs by higher than 90 %. The highly active radicals (e.g., SO4-·, ·OH) produced in this process caused drastic damage to sludge microbial cells and DNA stability while liberating the EPS/cell-bound water. Co-occurrence network analysis highlighted a positive correlation between population distribution and ARGs abundance, while variations in microbial communities were linked to regional differences in living standards and level of economic development. Despite these variations, the Fe(II)-S2O82- oxidation consistently achieved excellent performance in both ARGs removal and sludge dewatering. The significant modularity of associations between different microbial communities also confirms its ability to reduce horizontal gene transfer (HGT) by scavenging microbes.

Surfactant and antibiotic co-occurrence reshaped the acidogenic process for volatile fatty acids production during sludge anaerobic fermentation

The overuse of surfactants and antibiotics has led to their high concentration in waste activated sludge (WAS), and these exogenous pollutants have been shown to pose various influences on the subsequent anaerobic treatment process. Previous works have primarily concerned the impacts of individual pollutants on WAS anaerobic fermentation process. This work revealed the synergetic effects of sodium dodecyl benzene sulfonate (SDBS) and sulfadiazine (SDZ) co-occurrence in WAS on the biosynthesis of volatile fatty acids (VFAs). The addition of SDBS in the SDZ reactor significantly increased VFAs generation, and this increase was correlated with the concentration of SDZ. The VFAs production exhibited a 200.0-211.9 % and 5.9-20.4 % increase in comparison with the sole SDZ and SDBS reactor, respectively. The SDBS and SDZ co-occurrence facilitated the solubilization, hydrolysis, and acidification stages of WAS fermentation synchronously. SDBS was effectively to disintegrate the cemented structure of extracellular polymeric substances and meanwhile improve the SDZ solubilization, which increase the SDZ bioavailability as well as biotoxicity to the anaerobic species. Herein, the anaerobic consortia structure was evidently reshaped, and the keystone microbes Acetoanaerobium and Fususibacter, as well-tolerated hydrolytic-acidogenic bacteria, were greatly enriched. Furthermore, the functional microbial metabolic traits responsible for the substrate extracellular hydrolysis (e.g., glsA and MAN2C1), intracellular metabolism (e.g., ALDO and asdA), and fatty acid generation (e.g., aarC) were all upregulated in the SDBS/SDZ co-occurrence reactor.

Promoting short-chain fatty acids production from sewage sludge via acidogenic fermentation: Optimized operation factors and iron-based persulfate activation system

Promoting short-chain fatty acids (SCFAs) production and ensuring the stability of SCFAs-producing process are becoming the two major issues for popularizing the acidogenic fermentation (AF). The key controlling operating and influencing factors during anaerobic fermentation process were thoroughly reviewed to facilitate better process performance prediction and to optimize the process control of SCFAs promotion. The wide utilization of iron salt flocculants during wastewater treatment could result in iron accumulating in sewage sludge which influenced AF performance. Additionally, appropriate ferric chloride (FC) could promote the SCFAs accumulation, while poly ferric sulfate (PFS) inhibited the bioprocess. Iron/persulfate (PS) system was proved to effectively enhance the SCFAs production while mechanism analysis revealed that the strong oxidizing radicals remarkably enhanced the solubilization and hydrolysis. Moreover, the changes of oxidation-reduction potential (ORP) and pH caused by iron/PS system exhibited more negative effects on the methanogens, comparing to the acidogenic bacteria. Furthermore, performance and mechanisms of different iron species-activating PS, organic chelating agents and iron-rich biochar derived from sewage sludge were also elucidated to extend and strengthen understanding of the iron/PS system for enhancing SCFAs production. Considering the large amount of generated Fe-sludge and the multiple benefits of iron activating PS system, carbon neutral wastewater treatment plants (WWTPs) were proposed with Fe-sludge as a promising recycling composite to improve AF performance. It is expected that this review can deepen the knowledge of optimizing AF process and improving the iron/PS system for enhancing SCFAs production and provide useful insights to researchers in this field.

Anaerobic fermentation of organic solid waste: Recent updates in substrates, products, and the process with multiple products co-production

The effective conversion and recycling of organic solid waste contribute to the resolution of widespread issues such as global environmental pollution, energy scarcity and resource depletion. The anaerobic fermentation technology provides for the effective treatment of organic solid waste and the generation of various products. The analysis, which is based on bibliometrics, concentrates on the valorisation of affordable and easily accessible raw materials with high organic matter content as well as the production of clean energy substances and high value-added platform products. The processing and application status of fermentation raw materials such as waste activated sludge, food waste, microalgae and crude glycerol are investigated. To analyse the status of the preparation and engineering applications of the products, the fermentation products biohydrogen, VFAs, biogas, ethanol, succinic acid, lactic acid, and butanol are employed as representatives. Simultaneously, the anaerobic biorefinery process with multiple product co-production is sorted out. Product co-production can reduce waste discharge, enhance resource recovery efficiency, and serve as a model for improving anaerobic fermentation economics.

Towards advanced simultaneous nitrogen removal and phosphorus recovery from digestion effluent based on anammox-hydroxyapatite (HAP) process: Focusing on a solution perspective

In this paper, the state-of-the-art information on the anammox-HAP process is summarized. The mechanism of this process is systematically expounded, the enhancement of anammox retention by HAP precipitation and the upgrade of phosphorus recovery by anammox process are clarified. However, this process still faces several challenges, especially how to deal with the ∼ 11% nitrogen residues and to purify the recovered HAP. For the first time, an anaerobic fermentation (AF) combined with partial denitrification (PD) and anammox-HAP (AF-PD-Anammox-HAP) process is proposed to overcome the challenges. By AF of the organic impurities of the anammox-HAP granular sludge, organic acid is produced to be used as carbon source for PD to remove the nitrogen residues. Simultaneously, pH of the solution drops, which promotes the dissolution of some inorganic purities such as CaCO₃. In this way, not only the inorganic impurities are removed, but the inorganic carbon is supplied for anammox bacteria.

Thiosulfate pretreatment enhancing short-chain fatty acids production from anaerobic fermentation of waste activated sludge: Performance, metabolic activity and microbial community

A novel strategy based on thiosulfate pretreatment for enhancing short-chain fatty acids (SCFAs) from anaerobic fermentation (AF) of waste activated sludge (WAS) was proposed in this study. The results showed that the maximal SCFA yield increased from 206.1 ± 4.7 to 1097.9 ± 17.2 mg COD/L with thiosulfate dosage increasing from 0 to 1000 mg S/L, and sulfur species contribution results revealed that thiosulfate was the leading contributor to improve SCFA yield. Mechanism exploration disclosed that thiosulfate addition largely improved WAS disintegration, due to thiosulfate serving as a cation binder for removing organic-binding cations, especially Ca²⁺ and Mg²⁺, dispersing the extracellular polymeric substance (EPS) structure and further entering into the intracellularly by stimulated carrier protein SoxYZ and subsequently caused cell lysis. Typical enzyme activities and related functional gene abundances indicated that both hydrolysis and acidogenesis were remarkably enhanced while methanogenesis was substantially suppressed, which were further strengthened by the enriched hydrolytic bacteria (e.g. C10-SB1A) and acidogenic bacteria (e.g. Aminicenantales) but severely reduced methanogens (e.g. Methanolates and Methanospirillum). Economic analysis confirmed that thiosulfate pretreatment was a cost-effective and efficient strategy. The findings obtained in this work provide a new thought for recovering resource through thiosulfate-assisted WAS AF for sustainable development.

Enhancement of methane production in anaerobic digestion of high salinity organic wastewater: The synergistic effect of nano-magnetite and potassium ions

During high salinity organic wastewater (HSOW) anaerobic digestion treatment, the process of methanogenesis can be severely inhibited in the high salinity environment, and the accumulation of volatile organic acids (VFAs) leads to failure of the anaerobic reaction. In this study, nano-magnetite and KCl were adopted to alleviate the inhibitory effect of high salinity and enhance the HSOW anaerobic digestion performance. The result showed that, under the optimal dosage of 200 mg/L, nano-magnetite addition promoted the anaerobic digestion performance, and the methane production increased by 11.06%. When KCl was added with a dosage of 0.174%, the methane production increased by 98.37%. The simultaneous addition of nano-magnetite (200 mg/L) and KCl showed a synergistic effect on enhancing HSOW anaerobic digestion performance, and the methane production increased by 124.85%. The addition of nano-magnetite and KCl promoted the conversion of VFAs, especially accelerated the degradation of propionic acid and butyric acid, also it promoted the activity of acetate kinase, dehydrogenase and F₄₂₀, and thereby enhanced the methanogenesis process. This study could provide a new method for enhancing the anaerobic digestion of HSOW.

In-situ sulfite treatment enhanced the production of short-chain fatty acids from waste activated sludge in the side-stream anaerobic fermentation

Sulfite-based technology could enhance methane production from anaerobic sludge digestion. However, its potential for in-situ direct sludge treatment without anaerobic sludge addition in the side-stream remains unclear. This study investigated the feasibility of using in-situ sulfite treating sludge for short-chain fatty acids (SCFAs) production via anaerobic fermentation of waste activated sludge (WAS) as a side-stream treatment. In-situ sulfite direct sludge treatment enhanced SCFAs and acetic acid production by 2.03 and 4.89 times at 500 mg S/L compared to the control. With in-situ sulfite treatment, WAS hydrolysis and acidification were enhanced while methanogenesis was spontaneously hindered. The in-situ sulfite treatment inactivated pathogens and improved the sludge dewatering properties. The relative abundances of SCFAs-production microbial were stimulated, facilitating the sludge bioconversion. The produced SCFAs from in-situ sulfite side-stream treatment could be applied as an "internal carbon source" to enhance biological nutrient removal to improve economic and environmental value from sludge treatment.

Insights into integrated glycerol-driven partial denitrification-anaerobic ammonium oxidation system using bioinformatic analysis: The dominance of Bacillus spp. and the potential of nitrite producing via assimilatory nitrate reduction

Partial denitrification-anaerobic ammonium oxidation (PD/A) was considered a novel technology for biological nitrogen removal. In this study, a glycerol-driven PD/A granular sludge reactor was constructed, and its nitrogen removal efficiency and microbial mechanisms were investigated systematically. After optimization, the PD/A reactor achieved 92.3 % of the nitrogen removal (~90 % by anammox) with the influent COD/NO₃^--N ratio of 2.6, and approximate 1.36 mol NO₃^--N was required for removing 1 mol NH₄⁺-N. Granular sludge with layered structure (anaerobic ammonium oxidizing bacteria (AnAOB) was wrapped by the heterotrophic bacteria) was successfully developed, which resulted in the sludge floating. Bacillus was firstly found to be the dominant genus in PD/A system with an abundance of 46.1 %, whereas the AnAOB only accounted for 0.2-2.8 %. Metatranscriptomic analysis showed that the metabolic characteristics obviously changed during the operation, and the differential expressing genes mainly belonged to ABC transport and quorum sensing pathway. Further analysis about the expressing patterns of nitrogen metabolism related genes indicated that the anammox related genes (mainly from Candidatus Brocadia and Candidatus Jettenia) exhibited a much higher expressing level than other genes. Interestingly, the assimilatory nitrate reduction process in Bacillus showed great NO₂^--N producing potential, so it was considered to be an essential pathway participating in PD/A process. This study provided a comprehensive insight into the glycerol-driven PD/A system.

Comprehensive understanding of DOM reactivity in anaerobic fermentation of persulfate-pretreated sewage sludge via FT-ICR mass spectrometry and reactomics analysis

Understanding the composition and reactivity of dissolved organic matter (DOM) at molecular level is vital for deciphering potential regulators or indicators relating to anaerobic process performance, though it was hardly achieved by traditional analyses. Here, the DOM composition, molecular reactivity and transformation in the enhanced sludge fermentation process were comprehensively elucidated using high-resolution mass spectrometry measurement, and data mining with machine learning and paired mass distance (PMD)-based reactomics. In the fermentation process for dewatered sludge, persulfate (PDS) pretreatment presented its highest performance in improving volatile fatty acids (VFAs) production with the increase from 2,711 mg/L to 3,869 mg/L, whereas its activation in the presence of Fe (as well as the hybrid of Fe and activated carbon) led to the decreased VFAs production performance. In addition to the conventional view of improved decomposition and solubilization of N-containing structures from sludge under the sole PDS pretreatment, the improved VFAs production was associated with the alternation of DOM molecular compositions such as humification generating molecules with high O/C, N/C, S/C and aromatic index (AI_mod). Machine learning was capable of predicting the DOM reactivity classes with 74-76 % accuracy and found that these molecular parameters in addition to nominal oxidation state of carbon (NOSC) were among the most important variables determining the generation or disappearance of bio-resistant molecules in the PDS pretreatment. The constructed PMD-based network suggested that highly connected molecular network with long path length and high diameter was in favor of VFAs production. Especially, -NH related transformation was found to be active under the enhanced fermentation process. Moreover, network topology analysis revealed that CHONS compounds (e.g., C₁₃H₂₇O₈N₁S₁) can be the keystone molecules, suggesting that the presence of sulfur related molecules (e.g., cysteine-like compounds) should be paid more attention as potential regulators or indicators for controlling sludge fermentation performance. This study also proposed the non-targeted DOM molecular analysis and downstream data mining for extending our understanding of DOM transformation at molecular level.

The synergistic effect of chemical oxidation and microbial activity on improving volatile fatty acids (VFAs) production during the animal wastewater anaerobic digestion process treated with persulfate/biochar

Improving volatile fatty acid (VFA) production, rather than producing methane from the anaerobic digestion (AD) of waste, has become a new strategy of resource utilization. In regard to animal wastewater, the effectiveness of persulfate/biochar (potassium peroxodisulfate, PDS/BC) on the hydrolysis and acidogenesis stages and the reaction mechanisms are still unclear. In this study, the AD process on cow wastewater was controlled at the hydrolysis and acidification stages by setting the hydraulic retention time (HRT) at 25 days. The results showed that the contents of total solids (TS) and volatile solids (VS) were further reduced by PDS/BC treatment with 0.15 gPDS/gTS of PDS added. The VFAs production increased by 12.4 % from day 0 to 25 compared to the blank set. Based on our molecular analysis, the rate of increase for the dissolved organic matter with low molecular weight (0-10 kDa) was 699.5 mg/(L·d) in the first 10 days. The change rate increased nearly 2.1 times, leading to higher VFAs yield. Moreover, the activities of fermentative bacteria were enhanced and Anaerocella was determined to be the specific and critical genus. However, excessive PDS (0.3 gPDS/gTS) prolonged the acidification period and caused the inactivation of fermentative bacteria. Structural equation modeling demonstrated that PDS can directly affect VFAs yield and also had an indirect effect by influencing the decomposition of particulate matter and microbial activities. Therefore, the enhancement of VFAs production using the PDS/BC method could be due to synergistic chemical and microbial effects. Findings from this study can provide a practical strategy to enhance the VFAs production of AD technology for livestock wastewater and help reveal the reaction mechanism of PDS/BC treatment.

Distinct effects of typical sludge pretreatment approaches on the antibiotic resistance genes variations, associated bacterial community dynamics and metabolic activities during anaerobic fermentation process

Anaerobic fermentation is effective for waste activated sludge (WAS) disposal to realize resource generation and pollutants reduction, and various pretreatments were commonly applied to improve the performance. This work mainly investigated the effects of typical WAS pretreatment approaches on the antibiotic resistance genes (ARGs, as emerging contaminants) removal during anaerobic fermentation processes and unveiled the underlying mechanisms. The results indicated that all the pretreatment strategies exhibited evident effects on the overall ARGs removal with the order of Fe²⁺ activated persulfate (PS/Fe²⁺) > pH 10 > Ultrasonication > Heat, and showed selective removal tendency for the specific ARGs (namely easily removed (aadA1 and sul1) and persistent ARGs). Mechanistic analysis demonstrated that the pretreatments disrupted the extracellular polymeric substances (EPS) and rose the cell membrane permeability (particularly for PS/Fe²⁺ and Heat). Then the increased ARGs release benefitted the subsequent reduction of mobile genetic elements (MGEs) and extracellular ARGs (especially for PS/Fe²⁺ and pH10), resulting the ARGs attenuation. Pretreatments significantly shifted the microbial community structure and the abundances of potential ARGs hosts (i.e., Sulfuritalea, and Denitratisoma). Also, the different pretreatments exhibited distinct effects on the microbial metabolic traits related with ARGs proliferation (i.e., ABC transporters, two-component system and bacterial secretion systems), which also contributed to the ARGs attenuations during WAS fermentation. The partial least-squares path modeling (PLS-PM) analysis indicated that the bacterial community (total effects = 0.968) was key factor determining ARGs fates.

Mechanism of dielectric barrier plasma technology to improve the quantity and quality of short chain fatty acids in anaerobic fermentation of cyanobacteria

The recycling of high value carbon resources from cyanobacteria has become a research hotspot. This work investigated the possibility of dielectric barrier discharge (DBD) plasma pretreatment to improve the anaerobic fermentation performance of cyanobacteria. The maximum accumulations of short-chain fatty acids (SCFAs) and acetic acid in DBD group were 3.30 and 1.49 times of that in control group. The physical effects of DBD plasma and the oxidative stress response of cyanobacteria cells could improve the solubilization of cyanobacteria polymer. The destruction of humus by DBD plasma can reduce the negative impact of humus on the early stage of anaerobic fermentation, thus facilitating the rapid start of anaerobic fermentation. The contents of Bacteroidetes, Firmicutes and Chloroflexi in DBD group were higher than those in control group, while the content of Proteobacteria was on the contrary, which was conducive to the hydrolysis and acidification process. The decrease of Methanosaeta sp. and Methanosarcina sp. abundance in DBD group might be another reason for the increase of acetic acid ratio. Under the joint action of plasma chemical oxidation and microbial degradation, the degradation effect of microcystin-LR in the anaerobic fermentation supernatant of DBD group was better than that of the control group, which was conducive to the recycling of cyanobacteria anaerobic fermentation supernatant. Therefore, DBD pretreatment was conductive to recycling valuable carbon source from cyanobacteria and can be further developed as a potential new pretreatment technology.

Enhanced biohydrogen generation through calcium peroxide engendered efficient ultrasonic disintegration of waste activated sludge in low temperature environment

Waste activated sludge is a renewable source for biohydrogen production, whereas the presence of complex biopolymers limits the hydrolysis step during this process, and thus pretreatment is required to disintegrate the sludge biomass. In this study, the feasibility of utilizing waste activated sludge to produce biohydrogen by improving the solubilization by means of thermo CaO₂ engendered sonication disintegration (TCP-US) was studied. The optimized condition for extracellular polymeric substance (EPS) dissociation was obtained at the CaO₂ dosage of 0.05 g/g SS at 70 °C. The maximum disintegration after EPS removal was achieved at the sonic specific energy input of 1612.8 kJ/kg TS with the maximum solubilization and SS reduction of 23.7% and 18.14%, respectively, which was higher than the US alone pretreatment. Thus, this solubilization yields higher biohydrogen production of 114.3 mLH₂/gCOD in TCP-US sample.

Effect of Different Acid and Base Potassium Ferrate Pretreatment on Organic Acid Recovery by Anaerobic Digestion of Sludge

Potassium ferrate has strong oxidation in both acid and alkali environments, which has attracted extensive attention. However, the impact of the pH environment on this coupling process with the goal of resource recovery has not received attention. Under the goal of the efficient recovery of organic acid, the changes of solid-liquid characteristics of sludge after acid and alkaline ferrate pretreatment and during anaerobic digestion were discussed. The results showed that compared with blank control groups, after alkaline ferrate pretreatment, the volatile suspended solids (VSSs) decreased the most, reaching 28.19%. After being pretreated with alkaline ferrate, the sludge showed the maximum VFA accumulation (408.21 COD/g VSS) on the third day of digestion, which was 1.34 times higher than that of the acid ferrate pretreatment. Especially in an alkaline environment, there is no need to add additional alkaline substances to adjust the pH value, and the effect of sludge reduction and acid production is the best.

Coupled process of in-situ sludge fermentation and riboflavin-mediated nitrogen removal for low carbon wastewater treatment

Volatile fatty acid recovery from waste activated sludge (WAS) was highly suggested to supplement carbon source for nitrogen removal. However, it was not easy to separate them from the metabolites under the ex-situ fermentation. In this study, in-situ WAS fermentation combined in the denitrification system was established to treat low carbon wastewater (COD/TN = 4), and riboflavin was employed as a redox mediator. This coupled process could simultaneously enhance the WAS fermentation and nitrogen removal, and riboflavin could significantly enrich the fermentative bacteria (Firmicutes phylum), denitrifying bacteria (Denitratisoma genus) and related functional genes (narGHJI, napABC, nirKS, nosZ, norBC), generating more available carbon sources for efficient nitrogen removal. This resulted in the effluent TN (<15 mg/L) satisfying the required discharge standard in China. This study provided new insights into the efficient nitrogen removal from low carbon wastewater, realizing the carbon-neutral operation of new concept wastewater treatment plant in China.

Application of persulfate-based oxidation processes to address diverse sustainability challenges: A critical review

Over the past years, persulfate (PS) is widely applied due to their high versatility and efficacy in decontamination and sterilization. While treatment of organic chemicals, remediation of soil and groundwater, sludge treatment, disinfection on pathogen microorganisms have been covered by most published reviews, there are no comprehensive and specific reviews on its application to address diverse sustainability challenges, including solid waste treatment, resources recovery and regeneration of ecomaterials. PS applications mainly rely on direct oxidation by PS itself or the reactive sulfate radical (SO₄^•-) or hydroxyl radical (^•OH) from the activation of peroxodisulfate (PDS, S₂O₈^2-) or peroxymonosulfate (PMS, HSO₅^-) in SO₄^•--based advanced oxidation processes (SO₄^•--AOPs). From a broader perspective of environmental cleanup and sustainability, this review summarizes the various applications of PS except pollutant decontamination and elaborates the possible reaction mechanisms. Additionally, the differences between PS treatment and conventional technologies are highlighted. Challenges, research needs and future prospect are thus discussed to promote the development of the applications of PS-based oxidation processes in niche environmental fields. In all, this review is a call to pay more attention to the possibilities of PS application in practical resource reutilization and environmental protection except widely reported pollutant degradation.

Synergistic improvement of short-chain fatty acid production from waste activated sludge via anaerobic fermentation by combined plasma-calcium peroxide process

In this study, the combination of dielectric barrier discharge plasma (DBD) with calcium peroxide (CaO₂) achieved significant synergistic effects in promoting hydrolysis of waste activated sludge (WAS) and short-chain fatty acid (SCFA) production during anaerobic fermentation. Compared with the control, DBD/CaO₂ pretreatment increased SCFA production by 116 %, acetic acid ratio by 39 %, and sludge reduction by 30 % under the optimal conditions (discharge power = 76.5 W, CaO₂ dosage = 0.05 g/g VSS). Mechanism investigations elucidated that DBD/CaO₂ enhanced the generation of •OH, ¹O₂, and •O₂^-, synergistically promoted decomposing extracellular polymeric substances (EPS), lysing cells, releasing biodegradable substances, and enhancing acetic acid-enriched SCFA accumulation from fermentation. Meanwhile, Illumina MiSeq sequencing analysis revealed that the enrichment of hydrolytic and SCFAs-forming bacteria and the decrease in SCFAs-consuming bacteria by DBD/CaO₂ treatment also contributed. This work provides an effective method to boost the SCFA production from WAS fermentation.

Thiosulfate-assisted Fe2+/persulfate pretreatment effectively alleviating iron dose and enhancing biotransformation of waste activated sludge into high-value liquid products

Ferrous-based acidogenic fermentation (AF) as a means to treat waste activated sludge (WAS) and produce short-chain fatty acids (SCFAs) has drawn increasing attention, but the massive amount of "iron sludge" that it produces not only significantly increases costs and difficulty of disposal but also poses risks to the environment and human health. This study explored a novel approach to not only reduce the iron dosage required by AF but also to improve its performance by introducing a thiosulfate (TS)-assisted Fe²⁺/persulfate (TAFP) pretreatment. Effects of the TAFP pretreatment on WAS disintegration and biodegradability, SCFA production, and microbial community structure with different persulfate-Fe²⁺-thiosulfate molar ratios at 4:4:0 (R1), 4:3:1 (R2), 4:2:2 (R3) and 4:1:3 (R4) were investigated. The results showed that the TAFP pretreatment by a remarkable margin promoted the disintegration of WAS as well as the biodegradability of the organics released, owing to the production of robust free radicals (SO₄•^- and •OH) triggered by the thiosulfate and Fe²⁺ cycles. 48-day AF tests further showed maximum SCFA production, ranging roughly between 1283 and 1395 mg COD/L in the TAFP pretreated samples, much higher than Control (<120 mg/L) and R1 (around 593 mg COD/L). At the meantime, the Fe²⁺ dosage was reduced by 50% in R3 than that of R1. However, a prolonged lag phase of SCFA generation was observed between days 7 and 25, which was ascribable to the acidic conditions (pH < 4.5) closely related to impaired metabolic activities as well as electron transfer efficiencies and limited activities of acidogenic enzymes (i.e., pyruvate-ferredoxin oxidoreductase). Despite such lag phase, the economic and environmental assessment of AF of TAFP-pretreated WAS had a higher net SCFA yield and less "iron sludge" than either without any pretreatment or with Fe²⁺/persulfate-only pretreatment.

Mechanism of dielectric barrier discharge plasma technology to improve the quantity of short-chain fatty acids in anaerobic fermentation of waste active sludge

The mechanism of improving the anaerobic fermentation performance of waste active sludge by using dielectric barrier discharge (DBD) plasma pretreatment technology was investigated. The maximum accumulation of short-chain fatty acids (SCFAs) was observed on the 7th day of anaerobic fermentation when the DBD power was 76.50 W, which was 1726.70 mg COD/L, 1.50 times of the control group. The ratio of acetic acid in DBD group was 9.30% higher than that in the control. Further mechanism research indicated that DBD pretreatment can destroy the structure of extracellular polymer substances and release organic substances such as protein and polysaccharide. The dissolved organic matter analysis indicated that the DBD technique could increase the release of biodegradable organics (eg., tyrosine proteins, soluble microbial by-products), thus accelerate the biotransformation of organic substance. Bacterial community structure analysis showed that the increase in the abundance of Firmicutes and Bacteroidetes and the decrease in the abundance of Proteobacteria in DBD group were beneficial to the accumulation of SCFAs. Besides, further archaeal analysis indicated that the decrease of Methanosaeta sp. and Methanosarcina sp. abundance in the DBD group facilitate acetic acid accumulation. This study demonstrated that the DBD technique can be used as an effective and potential pretreatment method to improve sludge anaerobic fermentation performance.

Iron-based advanced oxidation processes for enhancing sludge dewaterability: State of the art, challenges, and sludge reuse

The increasing amount of sewage sludge produced in wastewater treatment plants (WWTPs) poses a great challenge to both environment and economy globally. As a requisite process during sludge treatment, sludge dewatering can significantly minimize the sludge volume and lower the operational cost for downstream transportation and disposal. Iron-based advanced oxidation process (AOP), a robust and cost-effective technique with relatively low technical barriers for high-level sludge dewatering, has been widely explored in the past 20 years. The development was mainly driven by the demands of efficient and sustainable sludge conditioning technology and the flexible sludge management approaches. The application of iron-based AOPs in sludge dewatering process attracts more and more attention. In this work, we discussed the current application of iron-based AOPs technology in the sludge dewatering processes in a holistic manner, summarized the factors affecting the sludge dewaterability in the treatment processes, and analyzed the mechanisms of iron-based AOPs to improve dewatering processes. Furthermore, we elaborated potential advantages, limitations, and challenges associated with implementing iron-based AOPs in the full-scale plants and shared the opportunities for sludge reutilization. This review aims to contribute to the development of highly efficient iron-based AOPs for sludge dewatering and offer perspectives and directions towards the new-generation of WWTPs with the sustainable and eco-friendly benefits.

Insights into Fe(Ⅱ)-sulfite-based pretreatment strategy for enhancing short-chain fatty acids (SCFAs) production from waste activated sludge: Performance and mechanism

This paper proposed a concept of "co-treating" waste activated sludge (WAS) with waste-derived sulfite and environmentally-friendly ferrous iron. The maximal short-chain fatty acids (SCFAs) production from WAS anaerobic fermentation ascended by 27.1 times after pretreated by Fe(Ⅱ) activated sulfite with a sulfite dosage of 500 mg S/L and a Fe(Ⅱ)/sulfite ratio of 1.25. Mechanism explorations elucidated that the production of SO₄·- and ·OH induced by Fe(Ⅱ)-activated sulfite-auto-oxidation remarkably promoted the disintegration of WAS and the biodegradability of dissolved organic matter, leading to enrichment of substances available for SCFAs-producing microbes. Besides, activities of hydrolytic and acidogenic enzymes were stimulated, while enzymes related to SCFAs consumption were inhibited severely. Further microbial community investigation confirmed that the abundances of hydrolytic microorganisms and acidogens were enriched. In addition, sludge dewaterability and vivianite production was enhanced after Fe(Ⅱ)-sulfite pretreated WAS fermentation, thereby benefiting the subsequent sludge disposal and resource recovery.

Simultaneous recovery of vivianite and produce short-chain fatty acids from waste activated sludge using potassium ferrate as pre-oxidation treatment

Recovery resources from waste active sludge (WAS) is an effective way to alleviate the predicament of WAS disposal, and it is also conducive to the carbon neutralization of wastewater treatment systems. This study discussed the strategy of WAS anaerobic fermentation after pre-oxidation with potassium ferrate (K₂FeO₄, PF), which can simultaneously recover vivianite and enhance SCFAs production. The results showed that PF pre-oxidation considerably shortened the fermentation time of SCFAs to 2 days, and the main Fe-P mineral was vivianite. The optimal PF dosage of 0.06 g Fe (VI)/g TSS for pre-oxidation WAS resulted in the maximum SCFAs production and vivianite recovery rate of 3698.2 ± 118.98 mg COD/g VSS and 32.39%, respectively. The mechanism analysis showed that the oxidizing properties of PF significantly accelerated the disintegration of tight EPS, release of protein and sludge acidification efficiency. Moreover, the PF strengthened the transfer of P to the solid phase, forming the Fe-P mineral and unsaturated coordination state of phosphate group. Then the key microorganism Geobacter reduced the Fe³⁺ in Fe-P state to Fe²⁺ and combined unsaturated phosphate to form vivianite. This study provides an alternative method for resource recovery and environmentally friendly disposal of WAS and contributes to the carbon neutrality of urban water systems.

Mechanisms of allicin exposure for the sludge fermentation enhancement: Focusing on the fermentation processes and microbial metabolic traits

As a frequently used product with antimicrobial activity, consumed allicin might be discharged and concentrated in waste-activated sludge (WAS). However, the influence of allicin (as an exogenous pollutant) on WAS fermentation has not been clearly revealed. This study aimed to disclose the impacts of allicin on volatile fatty acid (VFA) generation during WAS fermentation. The results showed that the appropriate presence of allicin (10 mg/g TSS) significantly enhanced the VFA yield (1894 versus 575 mg COD/L in the control) with increased acetate proportion (24.3%). Further exploration found that allicin promoted WAS solubilization, hydrolysis and acidification simultaneously. Metagenomic analysis revealed that the key genes involved in extracellular hydrolysis metabolism (i.e., CAZymes), membrane transport (i.e., gtsA and ytfT), substrate metabolism (i.e., yhdR and pfkC) and fatty acid synthesis (i.e., accA and accD) were all highly expressed. Allicin also induced the bacteria to produce more signalling molecules and regulate cellular functions, thereby enhancing the microbial adaptive and regulatory capacity to the unfavourable environment. Moreover, the variations in fermentative microbes and their contributions to the upregulation of functional genes (i.e., ytfR, gltL, INV, iolD and pflD) for VFA generation were disclosed. Overall, the simultaneous stimulation of functional microbial abundances and metabolic activities contributed to VFA production in allicin-conditioned reactors.

Insights into vacuum preloading consolidation of landfill sludge based on Fe2+-activated sodium persulfate

To further reduce the in-situ sludge from landfill, Fe²⁺-activated sodium persulfate combined with vacuum preloading was first proposed. Firstly, the effects of optimal Na₂S₂O₈ dosage on the landfill sludge (LS) were investigated by the vacuum filtration experiments. Then, vacuum preloading experiments were conducted on the sludge with different Na₂S₂O₈ dosages to study the water content, water discharge, and settlement. Besides, sludge particle size diversification was carried out by particle size distribution and scanning electron microscopy (SEM) tests. The results were summarized as follows: the specific resistance of filtration (SRF) of LS could be reduced by 98.5% mostly when the Na₂S₂O₈ dosage was 30%; the particle size became significantly smaller, and large particles were converted to small particles; the water content dropped from 86.9 to 58.3%; and the SEM test manifested the oxidation of sodium persulfate caused the destruction of the glial structure of the sludge and the recombination of partial particles.

Effect of potassium persulphate addition on sludge disintegration of a mesophilic anaerobic fermentation system

Persulphates, an advanced oxidation process, has been recently used as an alternative pretreatment method to enhance short-chain fatty acids (SCFAs) yield from waste-activated sludge (WAS) anaerobic fermentation (AF). But so far, the effects of peroxydisulphate (PDS) dosages on mesophilic anaerobic fermentation are still not studied fully. Herein, we explored the influences of potassium PDS addition on mesophilic AF of WAS. Notably, the addition of PDS could drastically accelerate WAS solubilization and hydrolysis, which was proportional to the amount of PDS. The maximal total SCFAs yield of 249.14 mg chemical oxygen demand/L was obtained with 120 mg PDS/g suspended solids addition at 6 days of AF, which was 2.2-fold that of the control one. Tightly bound extracellular polymeric substances (EPSs) were transformed into loosely bound EPS and dissolved organic matters, and aromatic proteins and humic-like substances of EPSs were disintegrated, which were caused by the devastating effects of PDS treatments on EPSs disruption. The intracellular constituents of microbial cells in the sludge were released accordingly. As a result, there was release of soluble substrates derived from the disintegration of both EPSs and cells, the amounts of which were proportional to the dose of PDS. Moreover, microbial diversity and richness were both decreased in the presence of PDS, and the relative abundance of phyla Actinobacteria increased with the increase of the PDS dosage. In addition, the stability of sludge flocs was destroyed in the presence of PDS, the distribution of particle size tended to be small and dispersive, and dewaterability of the sludge was deteriorated.

Can radicals-orientated chemical oxidation improve the reduction of antibiotic resistance genes (ARGs) by mesophilic anaerobic digestion of sludge?

The dissemination of antibiotic resistance genes (ARGs) increases risks towards human health and environmental safety. This work investigates the control of ARGs abundance and bacterial community evolution involved in waste activated sludge (WAS) treatment by chemical conditioning and subsequent mesophilic anaerobic digestion (MAD). The different chemical oxidation processes of ferrous iron-activated oxone and hydrogen peroxide (PMS-Fe²⁺ and H₂O₂-Fe²⁺) and thermal-activated oxone (PMS@80 ℃) were investigated, and the ferric chloride (FeCl₃) and inactivated oxone (PMS) were compared. PMS@80 ℃ decreased the absolute abundance of most ARGs by 10.6-99.3% and that of total ARGs by 66.3%. Interestingly, oxidation pretreatment increased rather than decreased the relative abundance of most ARGs. MAD with PMS@80 ℃ pretreatment increased the absolute abundance of total ARGs by 51.6%, and other MAD processes decreased it by 8.6-47.4%. PMS-Fe²⁺ and PMS@80 ℃ negatively inhibited methane production from 98.3 to 81.7 and 94.4 mL/g VSS in MAD. MAD effluent showed high abundance of Arcobacter genus in the range of 8.1-17.4% upon PMS-based pretreatment, possibly related to sulfur oxidation, nitrate reduction, and blaVEB enrichment. The radicals-orientated chemical oxidation can hardly improve the ARGs elimination by MAD due to the extremely high competitive organics in sludge.

Biological recovery of phosphorus from waste activated sludge via alkaline fermentation and struvite biomineralization by Brevibacterium antiquum

Struvite biomineralization is a promising method for phosphorus recovery from wastewater treatment plant streams, and the growth of responsible microorganisms in mixed cultures is one of the most critical points for applying this process in pilot and full-scale. This study aimed to investigate the growth and bio-struvite production of Brevibacterium antiquum in mixed sludge culture. Alkaline fermentation was applied at different pH conditions to enhance the phosphorus content of sludge for an efficient recovery, and pH 8 was determined as the most feasible considering the phosphorus release and sludge characteristics. Growth optimization studies showed that NaCl's presence decreases the growth rate of Brevibacterium antiquum and bio-struvite production. At the same time, pH in the range of 6.8-8.2 did not alter the growth significantly. In addition, studies showed the ability of Brevibacterium antiquum in unsterilized fermented sludge centrate to grow and recover the phosphorus as struvite. Thus, our results indicated the potential of struvite biomineralization in full-scale wastewater treatment plants.

Adaptability of organic matter and solid content to Fe2+/persulfate and skeleton builder conditioner for waste activated sludge dewatering

Sludge conditioning is important for improved dewatering, with the sludge characteristics impacting the effect of conditioning. A composite conditioner, Fe2+-activated sodium persulfate (Fe2+/SPS) combined with phosphogypsum (PG), was used to examine its impact on sludges with different organic contents (34.6-43.8%) or different solid contents (2.8-5.9%). Response surface optimization analysis shows that when the best conditioning is achieved, the reduction of the specific resistance to filtration (SRF) is not sensitive to organic matter content, but the dewatering performance of the sludge is greatly affected by the solid content. The oxidation role of Fe2+/SPS and the skeleton builder role of PG together affect the conditioning, oxidation playing a major role in conditioning, especially for greater organic matter content. The organic content (maximum ηSOL value was 0.32) also affects the effectiveness of the skeleton builder more than the solid content (Maximum ηSOL value was 0.25). Changes in PG significantly impacts the optimal molar ratio and dosage of Fe2+/SPS. Sludge with greater solid content requires greater Fe2+/SPS dosage to provide stronger oxidation to destroy flocs, and the maximum Fe2+:SPS molar ratio was 1.14 with solid content of 5.9 wt%. The composite conditioning decreases the content of extracellular polymeric substances and proteins/polysaccharides. This study provides new insight into the relationship between the oxidation role of Fe2+/SPS and the skeleton builder role of PG for sludge conditioning strategies according to the optimal conditions.

Effects of persulfate treatment on the fates of antibiotic resistance genes in waste activated sludge fermentation process and the underlying mechanism

The occurrence of antibiotic resistance genes (ARGs) in waste activated sludge (WAS) fermentation was investigated with persulfate (PS)-based treatment. ARGs affiliated with multidrug (mexP), macrolide (bla_OXA-129), tetracycline (tetB), sulfonamide (sul1), and vancomycin (vanRG) types were significantly decreased by PS/Fe treatment. Mechanistic investigations revealed that PS/Fe possessed oxidating potential and exhibited devastating effects on WAS fermentation. First, PS/Fe promoted cell structure damage, which facilitated ARGs release from potential hosts. A co-occurrence network analysis indicated that Fe/PS suppressed the proliferation of potential host bacteria. In addition, the PS/Fe treatment induced the decreased abundance of certain functional genes involved in pathways associated with ARGs dissemination. Finally, variation partitioning analysis demonstrated that the microbial community structure exhibited more vital effects on ARGs fates than physicochemical factors (i.e., pH and ORP) and gene expression (i.e., two-component system). This work provided a deeper understanding of the critical factors used to determine ARGs fates during WAS fermentation.

Urea removal in reclaimed water used for ultrapure water production by spent coffee biochar/granular activated carbon activating peroxymonosulfate and peroxydisulfate

This study evaluated the performance of spent coffee biochar (SCBC)/granular activated carbon (GAC) activating peroxymonosulfate (PMS) and peroxydisulfate (PDS) for urea degradation in reclaimed water used for ultrapure water production. Results showed that catalyst and oxidant wielded a great influence on urea removal. Of them, the GAC-PMS system could completely remove urea at the least oxidant (1 g/L) and catalyst dosage (0.2 g/L). GAC activating PMS mainly depended on graphite C structure and minor oxygen functional groups. However, the amounts of urea removed by 600BC-PMS and 900BC-PMS were 57% and 70%, respectively. In the PDS system, the urea removal through GAC-PDS could reach 90%, which mainly depends on the graphite C structure of GAC. Using the same conditions, the urea removal of 900BC-PDS was similar to GAC-PDS, so it has some potential as an alternative to commercial GAC.

Effect of polystyrene microplastics on the volatile fatty acids production from waste activated sludge fermentation

Anaerobic fermentation is crucial to resource utilization of waste activated sludge (WAS). However, accumulated microplastics (MPs) in sludge could not be ignored. Here, a typical MP, polystyrene (PS), was selected to study the effects of different concentrations of PS on anaerobic fermentation under the optimal volatile fatty acids (VFAs) production. Compared to the control, low PS concentrations (30 particles/g _{total solid}) significantly (p = 0.002) increased the production of VFAs to 112.8 ± 2.4% due to solubilization enhancement and enzymatic activity. High concentrations of PS (90 particles/g _{total solid}) significantly (p = 0.000) decreased VFAs production to 83.01 ± 0.76% because of the inactive related microbial activities, although organic matter release was enhanced in the initial stage. Mechanism studies showed that the toxicity of high PS concentration could be attributed to reactive oxygen species (ROS) production, excess sodium dodecyl sulfate (SDS), and synergistic toxicity of aged MPs with external pollutants.

Enhancements of short-chain fatty acids production via anaerobic fermentation of waste activated sludge by the combined use of persulfate and micron-sized magnetite

The combination of persulfate (PDS) with micron-sized magnetite (Fe₃O₄) was introduced into the process of anaerobic fermentation (AF) to scrutinize the short chain fatty acid (SCFA) production from waste activated sludge for the first time. The synergetic effect of PDS and Fe₃O₄ results in the promotion of intracellular and extracellular substance liberation, augment in key hydrolases activities, and enrichment of hydrolytic and acidifying microbial population. Meanwhile, carbohydrate, amino acid, and energy metabolism as well as enzymes, are considerably accelerated. Consequently, the maximum SCFAs yield is significantly enhanced to 391.25 mg COD/L on day 8 of AF with the addition of 0.3 g Fe₃O₄/g SS and 0.5 g PDS/g SS, which was 2.39-folds than that of the control. The relative abundance of Actinobacteria were highly enriched and reached to 35.76% at the class level. This work affords an effective avenue to evidently boost the production of SCFAs from WAS via AF.

Distribution patterns of functional microbial community in anaerobic digesters under different operational circumstances: A review

Anaerobic digestion (AD) processes are promising to effectively recover resources from organic wastes or wastewater. As a microbial-driven process, the functional anaerobic species played critical roles in AD. However, the lack of effective understanding of the correlations of varying microbial communities with different operational factors hinders the microbial regulation to improve the AD performance. In this paper, the main anaerobic functional microorganisms involved in different stages of AD processes were first demonstrated. Then, the response of anaerobic microbial community to different operating parameters, exogenous interfering substances and digestion substrates, as well as the digestion efficiency, were discussed. Finally, the research gaps and future directions on the understanding of functional microorganisms in AD were proposed. This review provides insightful knowledge of distribution patterns of functional microbial community in anaerobic digesters, and gives critical guidance to regulate and enrich specific functional microorganisms to accumulate certain AD products.

Disordered mesoporous carbon activated peroxydisulfate pretreatment facilitates disintegration of extracellular polymeric substances and anaerobic bioconversion of waste activated sludge

The potential of disordered mesoporous carbon (DMC) as catalyst of peroxydisulfate (PDS) to improve sludge solubilization and methane production was investigated. Results showed that DMC activated PDS (DMC/PDS) to produce sulfate radicals (SO₄^-), facilitating cells rupture and sludge matrix dissociation by degrading the carbonyl and amide groups in organic biopolymers (especially proteins, polysaccharides and humus). At the optimal DMC/PDS dosage of 0.04/1.2 g-mmol/g-VS, SCOD was increased from initial 294.0 to 681.5 mg/L, with the methane production rate of 12.6 mL/g-VS/day. Moreover, DMC could serve as electron mediator to accelerate electron transfer of microorganisms, building a more robust anaerobic metabolic environment. Modelling analysis further demonstrated the crucial role of DMC/PDS pretreatment in biological degradation and methane productivity. This study indicated that DMC/PDS pretreatment can prominently enhance the release of soluble substances and methane production, aiding the utilization of PDS oxidation technology for improving anaerobic bioconversion of sludge.

An innovative cation regulation-based anaerobic fermentation strategy for enhancing short-chain fatty acids production from waste activated sludge: Metal ion removal coupled with Na+-regulation

This study proposed a cation-regulation strategy based on metal ion removal coupled Na⁺-regulation for enhancing anaerobic fermentation of waste activated sludge. The optimal treatment condition was: cation-exchange resin dosage of 1.75 g/g SS for 1-day treatment, followed by Na⁺-enhanced anaerobic fermentation at NaCl concentration of 20 g/L. The CER induced sludge solubilization and the Na⁺-regulation treatment triggered secondary hydrolysis of CER-solubilized sludge, causing remarkable sludge disintegration and extracellular polymeric substance (EPS) disruption. Numerous SCOD of 6588 mg/L (SCOD/TCOD = 40.6%) was released within 2 days, and the short-chain fatty acids (SCFAs) of 439.9 mg COD/g VSS was produced through 4-day anaerobic fermentation. More than 59% of the SCFAs was composed of acetate and propionate. Nitrogen-free organic matters (i.e. SCFAs and carbohydrates) accounted for 77.9% of SCOD, while considerable sludge solid reduction (51.6% of total VSS) was achievable, which was beneficial for fermentative liquid utilization and sludge disposal.

Effect of sodium dichloroisocyanurate treatment on enhancing the biodegradability of waste-activated sludge anaerobic fermentation

In the present study, a novel oxidant (sodium dichloroisocyanurate, NaCl₂(NCO)₃; SDIC) combined with microorganisms was employed to achieve a higher performance of waste-activated sludge (WAS) anaerobic fermentation. Four concentrations of SDIC (0, 0.3, 0.6, and 1.0 mg SDIC/mg SS) were studied in WAS fermentation systems. The results showed that the release of proteins and polysaccharides was enhanced by the addition of SDIC with values of 1002.25 mg COD/L and 680.25 mg COD/L, respectively, and these values increased 14.46-18.07 times (proteins) and 3.74-7.40 times (polysaccharides) compared with that of the blank test. Additionally, the short-chain fatty acids also increased 2.24 times. The rate of extraction of organic substances from the sludge increased from 3.03% to 33.33%. Furthermore, the fermented sludge with the SDIC treatment had higher hydrolytic acidification efficiencies for bovine serum albumin and glucose, increasing from 4.558% to 9.91% and 2.976%-6.764%, respectively. However, SDIC treatment of the conventional fermented sludge resulted in lower hydrolytic acidification efficiencies with values of 4.978%-1.781% and 3.334%-0.582%, respectively. Biological enzyme analysis also showed that SDIC enhanced α-glucosidase and protease activity but inhibited dehydrogenase, alkaline phosphatase, and acid phosphatase activity. Proteobacteria and Comamonas were the main microbial communities observed in the WAS anaerobic fermentation.

Surfactant-assisted thermal hydrolysis off waste activated sludge for improved dewaterability, organic release, and volatile fatty acid production

The surfactant-assisted thermal hydrolysis pretreatment (THP) of waste activated sludge (WAS) was investigated, focusing on the effect of the surfactant addition on the results of sludge disintegration, dewaterability, organic release, and production of volatile fatty acids (VFAs) via fermentation. Typical anionic surfactant sodium dodecyl sulfate (SDS) and cationic surfactant cetyl trimethyl ammonium bromide (CTAB) were used for the THP experiments. The supernatant of the THP-treated sludge was anaerobically fermented to determine its potential VFAs yield. The results showed that the surfactant addition, particularly CTAB, enhanced the hydrolysis and organic solubilization of the sludge during THP. CTAB addition led to a 36% increase of dissolved organic and a 27% increase of VFAs production. For the THP-treated sludge with the surfactant addition, its dewaterability was also greatly improved. When the CTAB dosage increased from 0 to 0.10 g/g VSS, the minimum capillary suction time (CST) of the sludge decreased from 205 to 50 s/g TSS, and the sludge particles became smaller and less negative with the zeta potential changing from -12.4 to -8.2 mV. Analysis of extracellular polymeric substances (EPS) of the sludge revealed that the surfactant addition increased the sludge disintegration and organic dissolution during the THP process. The surfactant-assisted THP is shown to be a promising technology to enhance the WAS treatment for improved sludge dewaterability, waste reduction, and resource recovery.

Metagenomic analysis reveals the fate of antibiotic resistance genes in two-stage and one-stage anaerobic digestion of waste activated sludge

Waste activated sludge (WAS) from wastewater treatment plants is an important reservoir of antibiotic resistance genes (ARGs). The fate of ARGs in this process was not revealed previously. The present study applied metagenomic approach to examine the occurrence and fate of ARGs in thermophilic alkaline fermentation followed by mesophilic anaerobic digestion (TM), by comparison with mesophilic alkaline fermentation followed by mesophilic anaerobic digestion (MM) and one-stage mesophilic anaerobic digestion (M) process. The removal efficiency of two-stage anaerobic digestion (AD) to total ARGs is higher than that of one-stage AD. The hydrogen and methane production stages of two-stage AD processes have dissimilar impact on the fate of ARGs. Macrolide, lincosamide, and streptogramin (MLS) resistance genes were enriched, especially in the hydrogen production reactors of TM and MM processes. Statistical analysis of metagenomic profiles analysis suggested that bacA may be the differential ARG subtype of two-stage AD process. ARG-like sequences encoding antibiotic efflux pump, antibiotic inactivation and antibiotic target alteration mechanisms were identified as the dominant ARGs resistance mechanisms in all samples. Procrustes analysis showed that microbial community composition structured the resistome. Co-occurrence patterns between ARGs and microbial phylogeny revealed that 26 bacterial species might be potential hosts of 94 ARG subtypes.

Use of biochar/persulfate for accelerating the stabilization process and improving nitrogen stability of animal waste digestate

In China, the growing amount of digestate from anaerobic digestion produced by animal husbandry is an emerging challenge. A common treatment used to eliminate this digestate is long-term stabilization ponds. However, this process can lead to a shortage of digestate storage space and loss of nitrogen nutrients within the digestate. To alleviate those shortcomings, this study developed an efficient stabilization pond using biochar and persulfate (BC/PS treatment). Using this treatment, the germination index (GI) of the digestate increased from 56% to 85% and the stabilization efficiency increased nearly 2.7 times. In addition, the dehydrogenase activity (DHA) in the BC/PS treatment remained between 0.47 and 0.91 μg/(g·h) across the 40 days, which indicated that BC/PS had a positive effect on microbial inactivation. In the traditional stabilization process (CK treatment), dissolved organic nitrogen (DON) decreased from 47.77 mg/L to 0.81 mg/L and ammonium nitrogen almost disappeared. The BC/PS treatment led to the promotion of nitrogen nutrient composition. Particulate total nitrogen (21.49% of total nitrogen) decomposed into dissolved total nitrogen and the DON increased from 47.77 to 58.89 mg/L. The BC/PS treatment showed a faster stabilization time, good microbial inactivation, lower toxicity, and stable nitrogen nutrient composition of the digestate compared to traditional methods.

Distinct effects of hypochlorite types on the reduction of antibiotic resistance genes during waste activated sludge fermentation: Insights of bacterial community, cellular activity, and genetic expression

The effectiveness of hypochlorites (NaClO and Ca(ClO)₂) on the reduction of antibiotic resistance genes (ARGs) during waste activated sludge (WAS) fermentation was determined by the quantitative PCR. NaClO and Ca(ClO)₂ exhibited distinct effects on ARGs fates. Ca(ClO)₂ was effective in removing all investigated ARGs, and the efficiency was highly dose-dependent. Unexpectedly, the NaClO treatment attenuated ARGs with lower efficiency and even caused the propagation of certain ARGs (i.e., aadA1 and tetQ) at higher doses. The extracellular polymeric substances dissolution and membrane integrity suggested that unstable NaClO had acute effects on bacteria initially, while it was ineffective to further attenuate ARGs released from hosts due to the rapid consumption of oxidative ClO^-. Without lasting and strong oxidative stress, the microbial activities of tolerant ARGs hosts will partially recover and then contribute to the ARGs dissemination across genera. In contrast, solid-state Ca(ClO)₂ was slowly released and exhibited prolonged effects on bacteria by disrupting cell membranes and removing the susceptible ARGs released from hosts. Furthermore, bacterial taxa-ARG network analysis indicated that Ca(ClO)₂ reduced the abundance of potential hosts, and the metabolic pathway and gene expression related to ARGs propagation were significantly downregulated by Ca(ClO)₂, which contributed to efficient ARGs attenuation.

Activation of peroxymonosulfate using metal-free in situ N-doped carbonized polypyrrole: A non-radical process

Metal-free catalysts are widely considered as promising alternatives to traditional metal-based catalysts, which can effectively activate peroxymonosulfate (PMS). In this study, a novel metal-free catalyst, carbonized polypyrrole (CPPy) was synthesized through high-temperature carbonization of PPy, easily achieving the in situ N doping without the addition of nitrogen sources. Tetracycline (TC) was selected as the target contaminant to assess the catalytic activity of the CPPy/PMS system. Enhanced catalytic activity was observed in CPPy/PMS over a wide pH range (3.0-9.0), and the removal rate of TC by CPPy-3/PMS reached 91.3% after 10 min. After regenerating the used catalyst, the catalytic activity was refreshed, implying its stability and recyclability. The catalytic degradation of TC by CPPy/PMS was mainly attributed to a non-radical process. CPPy, as an intermediary, grabbed electrons from the electron-donating groups of TC and transferred them to the PMS molecule. Thereafter, TC that lost electrons was oxidized and degraded, and the O-O bonds of PMS were destroyed by the transferred electrons to form SO₄^2- and OH^-. Moreover, O⋅₂^- and ¹O₂ were involved in TC degradation. TC degradation pathway was investigated through HPLC-MS analysis. These findings provide a promising strategy for the construction of catalysts for PMS and environmental remediation.

Performance and microbial community dynamics in anaerobic continuously stirred tank reactor and sequencing batch reactor (CSTR-SBR) coupled with magnesium-ammonium-phosphate (MAP)-precipitation for treating swine wastewater

The impacts of magnesium-ammonium-phosphate (MAP) precipitation on the performance and microbial dynamics in an anaerobic continuously stirred tank reactor (CSTR) coupled with sequencing batch reactor (SBR) for swine wastewater treatment were investigated. In CSTR-SBR systems, an overall higher removal efficiency for COD, NH₄⁺ and PO₄^3-as 98.6%, 98.7% and 97.9% was achieved with MAP precipitation, compared to CSTR-SBR without MAP pretreatment (i.e., 97.5, 74.3% and 19.9% for COD, NH₄⁺ and PO₄^3-, respectively). With MAP precipitation, the high C/N ratio of 6.6 after anaerobic CSTR was observed. The increase in the richness and diversity of microbial communities in CSTR with MAP was conducive to nitrogen and phosphorus removal, as well as biogas production. The core community was affiliated with bacterial phyla Firmicutes, Bacteroidetes, Proteobacteria, Cloacimonetes, and Spirochaetae. The study provide a new insight into the potential application of MAP precipitation as pretreatment for dealing with nutrient recovery from high-strength swine wastewater.

Improving the treatment of waste activated sludge using calcium peroxide

The treatment and disposal of waste activated sludge (WAS) has become one of the major challenges for the wastewater treatment plants (WWTPs) due to large output, high treatment costs and enriched substantial emerging contaminants (ECs). Therefore, reducing sludge volume, recovering energy and resource from WAS, and removing ECs and decreasing environmental risk have gained increasing attentions. Calcium peroxide (CaO₂), a versatile and safe peroxide, has been widely applied in terms of WAS treatment including sludge dewatering, anaerobic sludge digestion and anaerobic sludge fermentation due to its specific properties such as generating free radicals and alkali, etc., providing supports for sludge reduction, recycling, and risk mitigation. This review outlines comprehensively the recent progresses and breakthroughs of CaO₂ in the fields of sludge treatment. In particular, the relevant mechanisms of CaO₂ enhancing WAS dewaterability, methane production from anaerobic digestion, short-chain fatty acids (SCFA) and hydrogen production from anaerobic fermentation, and the removal of ECs in WAS and role of experiment parameters are systematically elucidated and discussed, respectively. Finally, the knowledge gaps and opportunities in CaO₂-based sludge treatment technologies that need to be focused in the future are prospected. The review presented can supply a theoretical basis and technical reference for the application of CaO₂ for improving the treatment of WAS.