1
|
Kaur P, Annapure US. Rheological and gelling properties of atmospheric pressure cold plasma treated finger millet (Eleusine coracana) starch. Food Res Int 2024; 187:114418. [PMID: 38763668 DOI: 10.1016/j.foodres.2024.114418] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/16/2024] [Revised: 04/21/2024] [Accepted: 04/22/2024] [Indexed: 05/21/2024]
Abstract
Interest in exploring alternative starch sources like finger millet is rising due to wide starch applications. However, native starch often lacks desired qualities, including rheological properties. Modification is thus necessary for specific end uses. Plasma treatment as a greener and sustainable method for starch modification was therefore, studied for its ability to impact rheological properties of finger millet starch (FMS). Considerable changes in the rheological properties on FMS was noted, a significant decrease and increase (p < 0.05) in the peak viscosity (from 3.35 to 0.553 Pa.s) and paste clarity respectively was observed, indicating occurrence of depolymerization. However, intermediate plasma-treated samples (200 V) observed a decrease in paste clarity attributed to aggregate formation and cross-linking. Cross-linking was also confirmed by findings of frequency sweep where a continuous decrease in G' values of plasma treated FMS gel was interrupted by sudden increase. Despite depolymerization causing alteration of rheological behaviour such as decrease in shear thinning properties, gel strength observed a contradictory increase. This was attributed to incorporation of functional group and absence of shear responsible for network formation giving higher gel strength to FMS gels. This is elaborated in detail in the study. The study thus concluded that cold plasma significantly impacted all the rheological properties of the FMS and hence can prove to be beneficial for modification of starch rheological parameters.
Collapse
Affiliation(s)
- Parinder Kaur
- Department of Food Engineering Technology, Institute of Chemical Technology, Mumbai 400019, India
| | - Uday S Annapure
- Department of Food Engineering Technology, Institute of Chemical Technology, Mumbai 400019, India; Institute of Chemical Technology, Marathwada Campus, Jalna, India.
| |
Collapse
|
2
|
Jaddu S, Sonkar S, Seth D, Dwivedi M, Pradhan RC, Goksen G, Kumar Sarangi P, Režek Jambrak A. Cold plasma: Unveiling its impact on hydration, rheology, nutritional, and anti-nutritional properties in food materials - An overview. Food Chem X 2024; 22:101266. [PMID: 38486618 PMCID: PMC10937106 DOI: 10.1016/j.fochx.2024.101266] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/17/2024] [Revised: 02/28/2024] [Accepted: 02/29/2024] [Indexed: 03/17/2024] Open
Abstract
Non-thermal technologies, primarily employed for microbial inactivation and quality preservation in foods, have seen a surge in interest, with non-thermal plasma garnering particular attention. Cold plasma exhibits promising outcomes, including enhanced germination, improved functional and rheological properties, and microorganism destruction. This has sparked increased exploration across various domains, notably in hydration and rheological properties for creating new products. This review underscores the manifold benefits of applying cold plasma to diverse food materials, such as cereal and millet flours, and gums. Notable improvements encompass enhanced functionality, modified color parameters, altered rheological properties, and reduced anti-nutritional factors. The review delves into mechanisms like starch granule fragmentation, elucidating how these processes enhance the physical and structural properties of food materials. While promising for high-quality food development, overcoming challenges in scaling up production and addressing legal issues is essential for the technology's commercialization.
Collapse
Affiliation(s)
- Samuel Jaddu
- Department of Food Process Engineering, National Institute of Technology Rourkela, Odisha 769008, India
| | - Shivani Sonkar
- Department of Food Process Engineering, National Institute of Technology Rourkela, Odisha 769008, India
| | - Dibyakanta Seth
- Department of Food Process Engineering, National Institute of Technology Rourkela, Odisha 769008, India
| | - Madhuresh Dwivedi
- Department of Food Process Engineering, National Institute of Technology Rourkela, Odisha 769008, India
| | - Rama Chandra Pradhan
- Department of Food Process Engineering, National Institute of Technology Rourkela, Odisha 769008, India
| | - Gulden Goksen
- Department of Food Technology, Vocational School of Technical Sciences at Mersin 8 Tarsus Organized Industrial Zone, Tarsus University, 33100, Mersin, Turkey
| | | | - Anet Režek Jambrak
- Faculty of Food Technology and Biotechnology, University of Zagreb, Zagreb, Croatia
| |
Collapse
|
3
|
Ma S, Ma T, Tsuchikawa S, Inagaki T, Wang H, Jiang H. Effect of dielectric barrier discharge (DBD) plasma treatment on physicochemical and 3D printing properties of wheat starch. Int J Biol Macromol 2024; 269:132159. [PMID: 38719018 DOI: 10.1016/j.ijbiomac.2024.132159] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/24/2024] [Revised: 04/08/2024] [Accepted: 05/05/2024] [Indexed: 05/13/2024]
Abstract
In recent years, the focus has shifted towards carbohydrate-based hydrogels and their eco-friendly preparation methods. This study involved an investigation into the treatment of wheat starch using dielectric barrier discharge (DBD) plasma technology over varying time gradients (0, 2, 5, 10, 15, and 20 min). The objective was to systematically examine the impact of different treatment durations on the physicochemical properties of wheat starch and the suitability of its gels for 3D printing. Morphology of wheat starch remained intact after DBD treatment. However, it led to a reduction in the amylose content, molecular weight, and crystallinity. This subsequently resulted in a decrease in the pasting temperature and viscosity. Moreover, the gels of the DBD-treated starch exhibited superior 3D printing performance. After a 2-min DBD treatment, the 3D printed samples of the wheat starch gel showed no significant improvements, as broken bars were evident on the surface of the 3D printed graphic, whereas DBD-20 showed better printing accuracy and surface structure, compared to the original starch without slumping. These results suggested that DBD technology holds potential for developing new starch-based gels with impressive 3D printing properties.
Collapse
Affiliation(s)
- Shu Ma
- Shaanxi Union Research Center of University and Enterprise for Grain Processing Technologies, College of Food Science and Engineering, Northwest A & F University, Yangling 712100, China
| | - Te Ma
- Graduate School of Bioagricultural Sciences, Nagoya University, Furo-Cho, Chikusa, Nagoya 464-8601, Japan
| | - Satoru Tsuchikawa
- Graduate School of Bioagricultural Sciences, Nagoya University, Furo-Cho, Chikusa, Nagoya 464-8601, Japan
| | - Tetsuya Inagaki
- Graduate School of Bioagricultural Sciences, Nagoya University, Furo-Cho, Chikusa, Nagoya 464-8601, Japan
| | - Han Wang
- Graduate School of Bioagricultural Sciences, Nagoya University, Furo-Cho, Chikusa, Nagoya 464-8601, Japan
| | - Hao Jiang
- Shaanxi Union Research Center of University and Enterprise for Grain Processing Technologies, College of Food Science and Engineering, Northwest A & F University, Yangling 712100, China; Graduate School of Bioagricultural Sciences, Nagoya University, Furo-Cho, Chikusa, Nagoya 464-8601, Japan.
| |
Collapse
|
4
|
Kaur P, Annapure US. Understanding the atmospheric cold plasma-induced modification of finger millet (Eleusine coracana) starch and its related mechanisms. Int J Biol Macromol 2024; 268:131615. [PMID: 38631580 DOI: 10.1016/j.ijbiomac.2024.131615] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/23/2024] [Revised: 04/10/2024] [Accepted: 04/13/2024] [Indexed: 04/19/2024]
Abstract
This research was conducted to evaluate the effects of cold plasma (CP) on finger millet starch (FMS). FMS was exposed to partially ionized gas at varying voltages (170, 200, and 230 Volt) for varied time (10, 20, and 30 mins). The impact of treatment was studied using physico-chemical, and functional properties, and the mechanisms of starch modification occurring were stated. A significant reduction in the degree of polymerization was noticed based on parameters like reducing sugar, amylose content, solubility, and molecular weight. However, in certain voltage and time combinations, crosslinking was also confirmed by analysis such as XRD, FTIR, DSC, etc. The properties of starch were altered such as remarkable increase in water solubility by 6.7 times for highest voltage and longest time (230 V/30 min) was registered. NMR data suggested valuable findings- oxidation of OH group at C6 position of starch led to formation of carbonyl group followed by carboxyl group. NMR also showed a decrease in OH protons confirming crosslinking and hence all these analyses helped to conclude findings about the quality changes using CP. It was observed that the highest voltage and considerably longer exposure time of 20 and 30 min induced significant changes in the FMS.
Collapse
Affiliation(s)
- Parinder Kaur
- Department of Food Engineering Technology, Institute of Chemical Technology, Mumbai 400019, India
| | - Uday S Annapure
- Department of Food Engineering Technology, Institute of Chemical Technology, Mumbai 400019, India; Institute of Chemical Technology, Marathwada Campus, Jalna, India.
| |
Collapse
|
5
|
Liang Y, Zheng L, Yang Y, Zheng X, Xiao D, Ai B, Sheng Z. Dielectric barrier discharge cold plasma modifies the multiscale structure and functional properties of banana starch. Int J Biol Macromol 2024; 264:130462. [PMID: 38423435 DOI: 10.1016/j.ijbiomac.2024.130462] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/09/2023] [Revised: 02/13/2024] [Accepted: 02/24/2024] [Indexed: 03/02/2024]
Abstract
Banana starch has attracted significant attention due to its abundant content of resistant starch. This study aims to compare the multiscale structure and functional properties of banana starch obtained from five cultivated varieties and investigate the impact of dielectric barrier discharge cold plasma (DBD) treatment on these starch characteristics. All five types of natural banana starch exhibited an elliptical and irregular shape, conforming to the CB crystal structure, with a bimodal distribution of branch chain lengths. The resistant starch content ranged from 88.9 % to 94.1 %. Variations in the amylose content, amylopectin branch chain length distribution, and structural characteristics resulted in differences in properties such as gelatinization behavior and sensitivity to DBD treatment. The DBD treatment inflicted surface damage on starch granules, reduced the amylose content, shortened the amylopectin branch chain length, and changed the relative crystallinity to varying degrees. The DBD treatment significantly increased starch solubility and light transmittance. Simultaneously, it resulted in a noteworthy decrease in peak viscosity and gelatinization enthalpy of starch paste. The in vitro digestibility test showed that 76.2 %-86.5 % of resistant starch was retained after DBD treatment. The DBD treatment renders banana starch with reduced viscosity, increased paste transparency, enhanced solubility, and broadens its potential application.
Collapse
Affiliation(s)
- Yonglun Liang
- Institute of Tropical Bioscience and Biotechnology, Chinese Academy of Tropical Agricultural Sciences, Haikou, Hainan 571101, China; Agricultural Product Processing Research Institute, Chinese Academy of Tropical Agricultural Sciences, Zhanjiang, Guangdong 524001, China
| | - Lili Zheng
- Institute of Tropical Bioscience and Biotechnology, Chinese Academy of Tropical Agricultural Sciences, Haikou, Hainan 571101, China; Haikou Key Laboratory of Banana Biology, Haikou, Hainan 571101, China
| | - Yang Yang
- Institute of Tropical Bioscience and Biotechnology, Chinese Academy of Tropical Agricultural Sciences, Haikou, Hainan 571101, China; Haikou Key Laboratory of Banana Biology, Haikou, Hainan 571101, China
| | - Xiaoyan Zheng
- Institute of Tropical Bioscience and Biotechnology, Chinese Academy of Tropical Agricultural Sciences, Haikou, Hainan 571101, China; Haikou Key Laboratory of Banana Biology, Haikou, Hainan 571101, China
| | - Dao Xiao
- Institute of Tropical Bioscience and Biotechnology, Chinese Academy of Tropical Agricultural Sciences, Haikou, Hainan 571101, China; Haikou Key Laboratory of Banana Biology, Haikou, Hainan 571101, China
| | - Binling Ai
- Institute of Tropical Bioscience and Biotechnology, Chinese Academy of Tropical Agricultural Sciences, Haikou, Hainan 571101, China; Haikou Key Laboratory of Banana Biology, Haikou, Hainan 571101, China.
| | - Zhanwu Sheng
- Agricultural Product Processing Research Institute, Chinese Academy of Tropical Agricultural Sciences, Zhanjiang, Guangdong 524001, China.
| |
Collapse
|
6
|
Otálora González CM, Felix M, Bengoechea C, Flores S, Gerschenson LN. Development and Characterization of Edible Films Based on Cassava Starch Modified by Corona Treatment. Foods 2024; 13:468. [PMID: 38338603 PMCID: PMC10855232 DOI: 10.3390/foods13030468] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/10/2024] [Revised: 01/26/2024] [Accepted: 01/29/2024] [Indexed: 02/12/2024] Open
Abstract
Corona treatment (CT), a surface treatment widely used in the plastic industry, can be used to alter the properties of cassava starch. In the present work, CT was performed on dry granular starch (DS), water-suspended humid granular starch (HS), and gelatinized starch (GS). Different properties and structural characteristics of treated starches were studied. A lowering in pH was generally observed after CT and the rheological properties depended on the starch presentation. A reinforcement of DS and HS samples after CT was deduced from higher viscosity values in flow assays and viscoelastic moduli, but weak gels were obtained when CT was applied to GS. Changes in the A-type polymorphic structure, as well as a drop in relative crystallinity, were produced by CT for DS and HS. Additionally, changes in O-H and C-O-C FTIR bands were observed. Therefore, CT can be applied for starch modification, producing predominantly cross-linking in the DS and de-polymerization in the HS. Casting films made from the modified DS showed higher tensile strength and lower hydrophilicity, solubility, water absorption capacity, and water vapor permeability. Thus, the DS cross-linking induced by CT improved mechanical characteristics and hydrophobicity in edible films, which can be better used as packaging materials.
Collapse
Affiliation(s)
- Carlos Mauricio Otálora González
- Departamento de Industrias, Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Intendente Guiraldes 2620, Buenos Aires 1428, Argentina; (C.M.O.G.); (S.F.); (L.N.G.)
- Instituto de Tecnología de Alimentos y Procesos Químicos (ITAPROQ), CONICET—Universidad de Buenos Aires, Buenos Aires 1428, Argentina
| | - Manuel Felix
- Departamento de Ingeniería Química, Escuela Politécnica Superior, Universidad de Sevilla, 41011 Sevilla, Spain;
| | - Carlos Bengoechea
- Departamento de Ingeniería Química, Escuela Politécnica Superior, Universidad de Sevilla, 41011 Sevilla, Spain;
| | - Silvia Flores
- Departamento de Industrias, Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Intendente Guiraldes 2620, Buenos Aires 1428, Argentina; (C.M.O.G.); (S.F.); (L.N.G.)
- Instituto de Tecnología de Alimentos y Procesos Químicos (ITAPROQ), CONICET—Universidad de Buenos Aires, Buenos Aires 1428, Argentina
| | - Lía Noemí Gerschenson
- Departamento de Industrias, Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Intendente Guiraldes 2620, Buenos Aires 1428, Argentina; (C.M.O.G.); (S.F.); (L.N.G.)
- Instituto de Tecnología de Alimentos y Procesos Químicos (ITAPROQ), CONICET—Universidad de Buenos Aires, Buenos Aires 1428, Argentina
| |
Collapse
|
7
|
Zhu Q, Yao S, Wu Z, Li D, Ding T, Liu D, Xu E. Hierarchical structural modification of starch via non-thermal plasma: A state-of-the-art review. Carbohydr Polym 2023; 311:120747. [PMID: 37028874 DOI: 10.1016/j.carbpol.2023.120747] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/12/2022] [Revised: 02/20/2023] [Accepted: 02/22/2023] [Indexed: 03/05/2023]
Abstract
The hierarchical architecture of natural and processed starches with different surface and internal structures determines their final physicochemical properties. However, the oriented control of starch structure presents a significant challenge, and non-thermal plasma (cold plasma, CP) has gradually been used to design and tailor starch macromolecules, though without clear illustration. In this review, the multi-scale structure (i.e., chain-length distribution, crystal structure, lamellar structure, and particle surface) of starch is summarized by CP treatment. The plasma type, mode, medium gas and mechanism are also illustrated, as well as their sustainable food applications, such as in food taste, safety, and packaging. The effects of CP on the chain-length distribution, lamellar structure, amorphous zone, and particle surface/core of starch includes irregularity due to the complex of CP types, action modes, and reactive conditions. CP-induced chain breaks lead to short-chain distributions in starch, but this rule is no longer useful when CP is combined with other physical treatments. The degree but not type of starch crystals is indirectly influenced by CP through attacking the amorphous region. Furthermore, the CP-induced surface corrosion and channel disintegration of starch cause changes in functional properties for starch-related applications.
Collapse
Affiliation(s)
- Qingqing Zhu
- College of Biosystems Engineering and Food Science, State Key Laboratory of Fluid Power and Mechatronic Systems, National-Local Joint Engineering Laboratory of Intelligent Food Technology and Equipment, Integrated Research Base of Southern Fruit and Vegetable Preservation Technology, Fuli Institute of Food Science, Zhejiang University, Hangzhou 310058, China; Innovation Center of Yangtze River Delta, Zhejiang University, Jiashan 314103, China
| | - Siyu Yao
- College of Biosystems Engineering and Food Science, State Key Laboratory of Fluid Power and Mechatronic Systems, National-Local Joint Engineering Laboratory of Intelligent Food Technology and Equipment, Integrated Research Base of Southern Fruit and Vegetable Preservation Technology, Fuli Institute of Food Science, Zhejiang University, Hangzhou 310058, China; Innovation Center of Yangtze River Delta, Zhejiang University, Jiashan 314103, China
| | - Zhengzong Wu
- State Key Laboratory of Biobased Material and Green Papermaking, Qilu University of Technology, Shandong Academy of Sciences, Jinan 250353, China
| | - Dandan Li
- College of Food Science and Technology, Nanjing Agricultural University, Nanjing 210095, China
| | - Tian Ding
- College of Biosystems Engineering and Food Science, State Key Laboratory of Fluid Power and Mechatronic Systems, National-Local Joint Engineering Laboratory of Intelligent Food Technology and Equipment, Integrated Research Base of Southern Fruit and Vegetable Preservation Technology, Fuli Institute of Food Science, Zhejiang University, Hangzhou 310058, China; Innovation Center of Yangtze River Delta, Zhejiang University, Jiashan 314103, China
| | - Donghong Liu
- College of Biosystems Engineering and Food Science, State Key Laboratory of Fluid Power and Mechatronic Systems, National-Local Joint Engineering Laboratory of Intelligent Food Technology and Equipment, Integrated Research Base of Southern Fruit and Vegetable Preservation Technology, Fuli Institute of Food Science, Zhejiang University, Hangzhou 310058, China; Innovation Center of Yangtze River Delta, Zhejiang University, Jiashan 314103, China
| | - Enbo Xu
- College of Biosystems Engineering and Food Science, State Key Laboratory of Fluid Power and Mechatronic Systems, National-Local Joint Engineering Laboratory of Intelligent Food Technology and Equipment, Integrated Research Base of Southern Fruit and Vegetable Preservation Technology, Fuli Institute of Food Science, Zhejiang University, Hangzhou 310058, China; Innovation Center of Yangtze River Delta, Zhejiang University, Jiashan 314103, China.
| |
Collapse
|
8
|
Kaur P, Annapure US. Effects of pin-to-plate atmospheric cold plasma for modification of pearl millet (Pennisetum glaucum) starch. Food Res Int 2023; 169:112930. [PMID: 37254356 DOI: 10.1016/j.foodres.2023.112930] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/31/2023] [Revised: 04/24/2023] [Accepted: 04/27/2023] [Indexed: 06/01/2023]
Abstract
The present study was done to analyze the effect of atmospheric pressure non-thermal pin-to-plate plasma at a range of different voltages (170, 200, and 230V) at different time intervals (10, 20, and 30 mins) on under-utilized pearl millet starch. The untreated and treated starches were analyzed for amylose content, pH, carbonyl, and carboxyl group, reducing sugar, turbidity, water, and oil binding property, pasting property, DSC, FTIR, XRD, and molecular weight. As cold plasma contains highly reactive species and free radicals, it is expected to cause noticeable modifications in the attributes of treated starch. There has been a significant reduction (p < 0.05) in turbidity value by 38.97% and pH value of starch from 6.49 to 4.05. Plasma-treated samples produced clearer pastes with higher stability over storage time. Cold plasma treatment also led to an increase in the ζ potential. However, there has been no significant change in the water activity and oil-binding capacity of the starch. Reducing sugar content, average molecular weight, degree of polymerization, pasting property, XRD, and FTIR data confirmed that cross-linking takes place in samples treated at lower voltages and lesser time followed by depolymerization occurring in harshly treated plasma samples. The study thus points out the possible use of cold plasma for starch modification to produce starches with altered properties.
Collapse
Affiliation(s)
- Parinder Kaur
- Department of Food Engineering Technology, Institute of Chemical Technology, Mumbai 400019, India
| | - Uday S Annapure
- Department of Food Engineering Technology, Institute of Chemical Technology, Mumbai 400019, India; Institute of Chemical Technology, Marathwada Campus, Jalna, India.
| |
Collapse
|
9
|
Kheto A, Mallik A, Sehrawat R, Gul K, Routray W. Atmospheric cold plasma induced nutritional & anti-nutritional, molecular modifications and in-vitro protein digestibility of guar seed (Cyamopsis tetragonoloba L.) flour. Food Res Int 2023; 168:112790. [PMID: 37120236 DOI: 10.1016/j.foodres.2023.112790] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/09/2022] [Revised: 03/28/2023] [Accepted: 04/02/2023] [Indexed: 05/01/2023]
Abstract
The present study was carried out to investigate the effect of atmospheric cold plasma treatment on the nutritional, anti-nutritional, functional, morphological, and digestibility of guar seed (Cyamopsis tetragonoloba L.) flour. Here, guar seed flour was kept inside the plasma reactor for 5 to 20 min at different power levels (10 & 20 kV). The cold plasma treatment (CPT) significantly (p < 0.05) reduced the carbohydrate (46.87 - 36.81 %), protein (27.15 - 25.88 %), and increased the WAC (1.89 - 2.91 g/g), OAC (1.18 - 2.17 g/g), FC (113 - 186.17 %), and pasting properties of guar seed flour. High-intensity plasma-treated samples (20 kV-20 min) contained lesser tannin, phytic acid, and saponin with reduced the nutritional value. The FTIR spectrum suggested that functional group formation or destruction might have occurred in the plasma-treated samples. Additionally, the crystallinity is reduced with increasing applied voltage or duration. The SEM analysis reveals that CPT resulted in the formation of rough surfaces with highly porous structures. On the other hand, CPT significantly reduced the trypsin inhibitor activity and had a minor impact on in-vitro protein digestibility except for the 20 kV-20 min treated sample. In PCA analysis, 10 kV-15 min treated samples exhibited better nutritional value, functional, and pasting properties with maximum impact of anti-nutritional factors. From the results, it can be concluded that treatment duration rather than the applied voltage plays a significant role in preserving the nutritional content.
Collapse
Affiliation(s)
- Ankan Kheto
- Department of Food Process Engineering, National Institute of Technology, Rourkela, Odisha 769008, India
| | - Akarshan Mallik
- Department of Food Process Engineering, National Institute of Technology, Rourkela, Odisha 769008, India
| | - Rachna Sehrawat
- Department of Food Process Engineering, National Institute of Technology, Rourkela, Odisha 769008, India.
| | - Khalid Gul
- Department of Food Process Engineering, National Institute of Technology, Rourkela, Odisha 769008, India
| | - Winny Routray
- Department of Food Process Engineering, National Institute of Technology, Rourkela, Odisha 769008, India
| |
Collapse
|
10
|
Mutlu S, Kopuk B, Palabiyik I. Effect of Cold Atmospheric Pressure Argon Plasma Jet Treatment on the Freeze-Dried Mucilage of Chia Seeds ( Salvia hispanica L.). Foods 2023; 12:foods12081563. [PMID: 37107358 PMCID: PMC10137730 DOI: 10.3390/foods12081563] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/26/2023] [Revised: 03/25/2023] [Accepted: 04/03/2023] [Indexed: 04/29/2023] Open
Abstract
In the present study, the effects of the treatment of chia seeds with a cold atmospheric pressure plasma jet (CP) using argon as a working gas for different times (30, 60, and 120 s) on the rheological, structural, and microstructural properties of the freeze-dried mucilages at -54 °C were investigated. All mucilage gels showed pseudoplastic flow behavior, and CP treatment of chia seeds increased the viscosity of mucilages, probably due to the cross-linking between polymer molecules. The dynamic rheological analysis revealed that all mucilages were elastic gels and that CP treatment improved the elastic properties in a treatment time-dependent manner. Large amplitude oscillatory shear (LAOS) results showed that freeze-dried mucilages showed Type I strain-thinning behavior. Similar to small amplitude oscillatory shear (SAOS) results, CP treatment has affected and improved the large deformation behavior of mucilages depending on treatment time. Meanwhile, Fourier transform infrared spectroscopy (FTIR) revealed the incorporation of hydroxyl groups onto the surface and the formation of C-O-C glycosidic bonds during plasma treatment. Scanning electron microscope (SEM) micrographs showed the formation of denser structures with CP treatment time. Regarding color properties, CP treatment decreased the lightness values of mucilages. Overall, this study showed that CP is an effective way to modify both the SAOS and LAOS properties of freeze-dried chia mucilage and improve viscosity.
Collapse
Affiliation(s)
- Sebnem Mutlu
- Edirne Food Control Laboratory Directorate, 22100 Edirne, Türkiye
| | - Berkay Kopuk
- Department of Food Engineering, Faculty of Agriculture, Tekirdag Namik Kemal University, 59030 Tekirdag, Türkiye
| | - Ibrahim Palabiyik
- Department of Food Engineering, Faculty of Agriculture, Tekirdag Namik Kemal University, 59030 Tekirdag, Türkiye
| |
Collapse
|
11
|
Sarkar A, Niranjan T, Patel G, Kheto A, Tiwari BK, Dwivedi M. Impact of cold plasma treatment on nutritional, antinutritional, functional, thermal, rheological, and structural properties of pearl millet flour. J FOOD PROCESS ENG 2023. [DOI: 10.1111/jfpe.14317] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 03/17/2023]
Affiliation(s)
- Ayan Sarkar
- Department of Food Process Engineering National Institute of Technology Rourkela Rourkela Odisha India
| | - Thota Niranjan
- Department of Food Process Engineering National Institute of Technology Rourkela Rourkela Odisha India
| | - Gopesh Patel
- Department of Food Process Engineering National Institute of Technology Rourkela Rourkela Odisha India
| | - Ankan Kheto
- Department of Food Process Engineering National Institute of Technology Rourkela Rourkela Odisha India
| | | | - Madhuresh Dwivedi
- Department of Food Process Engineering National Institute of Technology Rourkela Rourkela Odisha India
| |
Collapse
|
12
|
Chaple S, Sarangapani C, Dickson S, Bourke P. Product development and X-Ray microtomography of a traditional white pan bread from plasma functionalized flour. Lebensm Wiss Technol 2023; 174:114326. [PMID: 36733634 PMCID: PMC9883616 DOI: 10.1016/j.lwt.2022.114326] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/03/2021] [Revised: 12/14/2022] [Accepted: 12/15/2022] [Indexed: 12/23/2022]
Abstract
Cold plasma (CP) technology has emerged as a novel non-thermal technology with the potential to improve food quality or impart functionality to ingredients. Our previous studies on wheat flour demonstrated how the structure and functionality of wheat flour might be modified using CP to provide an alternative to chemical additives (Chaple et al., 2020). However, understanding of the further effects of plasma functionalized ingredients in existing or new product formulation is limited. This study investigated the effects of CP treatment of wheat flour on traditional white pan bread development. The bread was formulated using plasma functionalized flour (PFF), and critical product characteristic responses were analyzed. Plasma treatment of flour positively affected the bread's expansion ratio, crust color, and water activity. Farinograph analysis suggests improvement in water absorption capacity, dough development time, and dough stability. X-Ray Microtomography (XRMT) analysis was conducted to understand how plasma functionalising the flour impacted the microstructure of bread. The 3D scans suggested no macro-change in the bread matrix compared to control; however, the porosity decreased in line with the increasing plasma treatment duration of the flour. The texture profile analysis showed an improvement in the gluten network developed in the dough developed from PFF. Sensory analysis results showed overall acceptance for bread formulated with PFF compared with a commercial sample. Overall, CP treatment of the flour improved the functionality in relation to dough and bread preparation and can thus provide an alternative to chemical additives in bread making. The CP processes may be modulated to deliver tailored effects for bread product development.
Collapse
Affiliation(s)
- Sonal Chaple
- School of Biosystems and Food Engineering, University College Dublin, Belfield, Dublin 4, Ireland
| | - Chaitanya Sarangapani
- School of Food Science and Environmental Health, Technological University Dublin, Dublin 7, Ireland
| | - Shannon Dickson
- School of Culinary Arts and Food Technology, Technological University Dublin, Dublin 7, Ireland
| | - Paula Bourke
- School of Biosystems and Food Engineering, University College Dublin, Belfield, Dublin 4, Ireland,Corresponding author.
| |
Collapse
|
13
|
De Baerdemaeker K, Van Reepingen A, Nikiforov A, De Meulenaer B, De Geyter N, Devlieghere F. Non-Thermal Plasma Decontamination Using a Multi-Hollow Surface Dielectric Barrier Discharge: Impact of Food Matrix Composition on Bactericidal Efficacy. Foods 2023; 12:foods12020386. [PMID: 36673477 PMCID: PMC9858114 DOI: 10.3390/foods12020386] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/02/2022] [Revised: 01/02/2023] [Accepted: 01/11/2023] [Indexed: 01/14/2023] Open
Abstract
The non-thermal plasma (NTP) treatment of food products as an alternative for thermal processing has been investigated over the last few years. This quasi-neutral gas contains a wide variety of reactive oxygen and nitrogen species (RONS), which could be lethal for bacterial cells present in the product. However, apart from only targeting bacteria, the RONS will also interact with components present in the food matrix. Therefore, these food components will protect the microorganisms, and the NTP treatment efficiency will decrease. This effect was investigated by supplementing a plain agar medium with various representative food matrix components. After inoculation with Escherichia coli O157:H7 (STEC) MB3885, the plates were treated for 30 s by a multi-hollow surface dielectric barrier discharge (MSDBD) generated in either dry air or air at 75% humidity, at constant power (25.7 ± 1.7 W). Subsequently, the survival of the cells was quantified. It has been found that the addition of casein hydrolysate (7.1 ± 0.2 m%), starch (2.0 m%), or soybean oil (4.6 m%) decreased the inactivation effect significantly. Food products containing these biomolecules might therefore need a more severe NTP treatment. Additionally, with increasing humidity of the plasma input gas, ozone levels decreased, and the bactericidal effect was generally less pronounced.
Collapse
Affiliation(s)
- Klaas De Baerdemaeker
- Research Unit Food Microbiology and Food Preservation (FMFP), Department of Food Technology, Safety and Health, Ghent University, Coupure Links 653, 9000 Ghent, Belgium
| | - Amber Van Reepingen
- Research Unit Food Microbiology and Food Preservation (FMFP), Department of Food Technology, Safety and Health, Ghent University, Coupure Links 653, 9000 Ghent, Belgium
| | - Anton Nikiforov
- Research Unit Plasma Technology (RUPT), Department of Applied Physics, Ghent University, Sint-Pietersnieuwstraat 41, 9000 Ghent, Belgium
| | - Bruno De Meulenaer
- NutriFOODchem Research Group, Department of Food Technology, Safety and Health, Ghent University, Coupure Links 653, 9000 Ghent, Belgium
| | - Nathalie De Geyter
- Research Unit Plasma Technology (RUPT), Department of Applied Physics, Ghent University, Sint-Pietersnieuwstraat 41, 9000 Ghent, Belgium
| | - Frank Devlieghere
- Research Unit Food Microbiology and Food Preservation (FMFP), Department of Food Technology, Safety and Health, Ghent University, Coupure Links 653, 9000 Ghent, Belgium
- Correspondence: ; Tel.: +32-9-264-61-77
| |
Collapse
|
14
|
da Costa Pinto C, Sanches EA, Clerici MTPS, Rodrigues S, Fernandes FAN, de Souza SM, Teixeira-Costa BE, de Araújo Bezerra J, Lamarão CV, Campelo PH. Modulation of the Physicochemical Properties of Aria (Goeppertia allouia) Starch by Cold Plasma: Effect of Excitation Frequency. FOOD BIOPROCESS TECH 2022. [DOI: 10.1007/s11947-022-02970-6] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/23/2022]
|
15
|
Liang W, Zhao W, Liu X, Zheng J, Sun Z, Ge X, Shen H, Ospankulova G, Muratkhan M, Li W. Understanding how electron beam irradiation doses and frequencies modify the multiscale structure, physicochemical properties, and in vitro digestibility of potato starch. Food Res Int 2022; 162:111947. [DOI: 10.1016/j.foodres.2022.111947] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/19/2022] [Revised: 09/11/2022] [Accepted: 09/13/2022] [Indexed: 11/30/2022]
|
16
|
Jaddu S, Abdullah S, Dwivedi M, Pradhan RC. Multipin cold plasma electric discharge on hydration properties of kodo millet flour: Modelling and optimization using response surface methodology and artificial neural network – Genetic algorithm. Food Chemistry: Molecular Sciences 2022; 5:100132. [PMID: 36105752 PMCID: PMC9465321 DOI: 10.1016/j.fochms.2022.100132] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 06/17/2022] [Revised: 08/18/2022] [Accepted: 08/29/2022] [Indexed: 11/22/2022]
Abstract
Hydration properties of kodo millet flour was improved with plasma treatment. Independent variables such as voltage and time were optimized with RSM and ANN – GA. ANN – GA showed best optimized combination as compared to RSM. DSC, FTIR, XRD and SEM had positive effect on millet flour for optimized values.
The effect on functional properties of kodo millet flour was studied using multipin cold plasma electric reactor. The analysis was carried out at various levels of voltage (10–20 kV) and treatment time (10–30 min) for four different parameters such as water absorption capacity (WAC), oil absorption capacity (OAC), solubility index (SI) and swelling capacity (SC). Response surface methodology (RSM) and artificial neural network – genetic algorithm (ANN – GA) were adopted for modelling and optimization of process variables. The optimized values obtained from RSM were 20 kV and 17.9 min. On the contrary, 17.5 kV and 23.3 min were the optimized values obtained from ANN – GA. The RSM optimal values of WAC, OAC, SI and SC were 1.51 g/g, 1.40 g/g, 0.06 g/g and 3.68 g/g whereas optimized ANN – GA values were 1.51 g/g, 1.50 g/g, 0.06 g/g and 4.39 g/g, respectively. Infrared spectra, peak temperature, diffractograms and micrographs of both optimized values were analyzed and showed significant differences. ANN showed a higher value of R2 and lesser values of other statistical parameters compared to RSM. Therefore, ANN – GA was treated as the best model for optimization and modelling of cold plasma treated kodo millet flour. Hence, the ANN – GA optimized values of cold plasma treated flour could be utilized for practical applications in food processing industries.
Collapse
|
17
|
Srangsomjit N, Bovornratanaraks T, Chotineeranat S, Anuntagool J. Solid-state modification of tapioca starch using atmospheric nonthermal dielectric barrier discharge argon and helium plasma. Food Res Int 2022; 162:111961. [DOI: 10.1016/j.foodres.2022.111961] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/27/2022] [Revised: 09/16/2022] [Accepted: 09/18/2022] [Indexed: 11/04/2022]
|
18
|
Chumsri P, Panpipat W, Cheong LZ, Nisoa M, Chaijan M. Comparative Evaluation of Hydrothermally Produced Rice Starch-Phenolic Complexes: Contributions of Phenolic Type, Plasma-Activated Water, and Ultrasonication. Foods 2022; 11. [PMID: 36496635 DOI: 10.3390/foods11233826] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/04/2022] [Revised: 11/22/2022] [Accepted: 11/25/2022] [Indexed: 11/29/2022] Open
Abstract
A thorough investigation of the viability of rice starch conjugation with three different phenolic compounds-gallic acid, sinapic acid, and crude Mon-pu (Glochidion wallichianum Muell Arg) (MP) extract-was conducted using a variety of developed methods which modified the techno-functionality and digestibility of the end product. With and without the aid of ultrasonication (US), phenolic compounds were complexed with hydrothermally pre-gelatinized rice starch prepared using distilled water or plasma-activated water (PAW). The in vitro digestibility, structural features, rheological and thermal properties, and in vitro antioxidant activity of starch-phenolic complexes were evaluated. The US-assisted starch-MP complex in water had the highest complexing index (CI) value (77.11%) and resistant starch (RS) content (88.35%), resulting in a more compact and stable ordered structure. In all complexes, XRD revealed a new minor crystalline region of V-type, which was stabilized by hydrogen bonding as defined by FTIR and H1-NMR. Polyphenols caused a looser gel structure of starch, as imaged by a scanning electron microscope (SEM). Starch-phenolic complexes outperformed other complexes in terms of in vitro antioxidant activity. Gallic acid addition to starch molecules boosted DPPH scavenging activity, notably when synthesized in PAW regardless of US assistance, although having lower CI and RS values than the MP complex. Therefore, this research lays the groundwork for the efficient production of functional food ingredients based on rice starch and polyphenols.
Collapse
|
19
|
Jaddu S, Abdullah S, Dwivedi M, Pradhan RC. Optimization of functional properties of plasma treated kodo millet (open air multipin) using response surface methodology (
RSM
) and artificial neural network with genetic algorithm (
ANN‐GA
). J FOOD PROCESS ENG 2022. [DOI: 10.1111/jfpe.14207] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/11/2022]
Affiliation(s)
- Samuel Jaddu
- Department of Food Process Engineering National Institute of Technology Rourkela Odisha India
| | - S. Abdullah
- Department of Food Process Engineering National Institute of Technology Rourkela Odisha India
| | - Madhuresh Dwivedi
- Department of Food Process Engineering National Institute of Technology Rourkela Odisha India
| | - Rama Chandra Pradhan
- Department of Food Process Engineering National Institute of Technology Rourkela Odisha India
| |
Collapse
|
20
|
Xu Y, Bai Y, Dai C, Lv H, Zhou X, Xu Q. Effects of non-thermal atmospheric plasma on protein. J Clin Biochem Nutr 2022; 71:173-184. [PMID: 36447493 PMCID: PMC9701599 DOI: 10.3164/jcbn.22-17] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/06/2022] [Accepted: 03/15/2022] [Indexed: 01/02/2024] Open
Abstract
Currently, the advancement in non-thermal atmospheric plasma technology enables plasma treatments on some heat-sensitive targets, including biological substances, without unspecific damage caused by thermal effect. The significant effects of non-thermal atmospheric plasma modulating biological events have been demonstrated by considerable studies. Protein, one of the most important biomolecules, participates in the majority of the life-sustaining activities in all organisms, whose functions are derived from the diverse biochemical properties of amino acid compositions and four-tiered protein structure hierarchy. Therefore, the knowledge of how non-thermal atmospheric plasma affects protein greatly benefits the understanding and application of the non-thermal atmospheric plasma's effect in biological area. In this review, we summarize recent research progress on the effects of non-thermal atmospheric plasma, particularly its reactive species, on biochemical and biophysical characteristics of proteins at different structural levels that leads to their functional changes. Moreover, the physiological effects of non-thermal atmospheric plasma at cellular or organism level driven by the manipulations on protein and their relative application prospects are reviewed. Despite the exceptional application potential, the exploration of the non-thermal atmospheric plasma's effect on protein still confronts with difficulties due to the limited knowledge of the underlying mechanisms and the complexity of non-thermal atmospheric plasma operation systems, which requires further studies and standardization of non-thermal atmospheric plasma treatments.
Collapse
Affiliation(s)
- Yong Xu
- Institute of Microbiology, Anhui Academy of Medical Sciences, Gongwan Road 15, Hefei City, Anhui Province 230061, China
| | - Yu Bai
- Institute of Microbiology, Anhui Academy of Medical Sciences, Gongwan Road 15, Hefei City, Anhui Province 230061, China
| | - Chenwei Dai
- Institute of Microbiology, Anhui Academy of Medical Sciences, Gongwan Road 15, Hefei City, Anhui Province 230061, China
| | - Han Lv
- Institute of Microbiology, Anhui Academy of Medical Sciences, Gongwan Road 15, Hefei City, Anhui Province 230061, China
| | - Xiuhong Zhou
- Institute of Microbiology, Anhui Academy of Medical Sciences, Gongwan Road 15, Hefei City, Anhui Province 230061, China
| | - Qinghua Xu
- Institute of Microbiology, Anhui Academy of Medical Sciences, Gongwan Road 15, Hefei City, Anhui Province 230061, China
| |
Collapse
|
21
|
Rostamabadi H, Rohit T, Karaca AC, Nowacka M, Colussi R, Feksa Frasson S, Aaliya B, Valiyapeediyekkal Sunooj K, Falsafi SR. How non-thermal processing treatments affect physicochemical and structural attributes of tuber and root starches? Trends Food Sci Technol 2022. [DOI: 10.1016/j.tifs.2022.08.009] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/15/2022]
|
22
|
Wang J, Yu YD, Zhang ZG, Wu WC, Sun PL, Cai M, Yang K. Formation of sweet potato starch nanoparticles by ultrasonic—assisted nanoprecipitation: Effect of cold plasma treatment. Front Bioeng Biotechnol 2022; 10:986033. [PMID: 36185450 PMCID: PMC9523013 DOI: 10.3389/fbioe.2022.986033] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/04/2022] [Accepted: 08/01/2022] [Indexed: 11/23/2022] Open
Abstract
Starch nanoparticles (SNPs) were produced from sweet potato starches by ultrasonic treatment combined with rapid nanoprecipitation. The starch concentration, ultrasonic time, and the ratio of starch solution to ethanol were optimized through dynamic light scattering (DLS) technique to obtain SNPs with a Z-average size of 64.51 ± 0.15 nm, poly dispersity index (PDI) of 0.23 ± 0.01. However, after freeze drying, the SNPs showed varying degrees of aggregation depending on the particle size of SNPs before freeze-drying. The smaller the particle size, the more serious the aggregation. Therefore, we tried to treat SNPs with dielectric barrier discharge cold plasma before freeze drying. Properties including morphological features, crystalline structure and apparent viscosity of various starches were measured by field emission scanning electron microscopy (FE-SEM), X-ray diffraction (XRD), and rheometer, respectively. The results showed that, after cold plasma (CP) treatment, the aggregation of SNPs during freeze drying was significantly inhibited. Compared to the native sweet potato starch, SNPs showed a higher relative crystallinity and a lower apparent viscosity. After CP treatment, the relative crystallinity of CP SNPs was further higher, and the apparent viscosity was lower. This work provides new ideas for the preparation of SNPs and could promote the development of sweet potato SNPs in the field of active ingredient delivery.
Collapse
Affiliation(s)
- Jian Wang
- College of Food Science and Technology, Zhejiang University of Technology, Hangzhou, Zhejiang, China
| | - Yu-Die Yu
- College of Food Science and Technology, Zhejiang University of Technology, Hangzhou, Zhejiang, China
| | - Zhi-Guo Zhang
- Food Science Institute, Zhejiang Academy of Agricultural Sciences, Hangzhou, Zhejiang, China
| | - Wei-Cheng Wu
- Food Science Institute, Zhejiang Academy of Agricultural Sciences, Hangzhou, Zhejiang, China
| | - Pei-Long Sun
- College of Food Science and Technology, Zhejiang University of Technology, Hangzhou, Zhejiang, China
| | - Ming Cai
- College of Food Science and Technology, Zhejiang University of Technology, Hangzhou, Zhejiang, China
- *Correspondence: Ming Cai, ; Kai Yang,
| | - Kai Yang
- College of Food Science and Technology, Zhejiang University of Technology, Hangzhou, Zhejiang, China
- *Correspondence: Ming Cai, ; Kai Yang,
| |
Collapse
|
23
|
Park SK, Lee DJ, Baik OD. Factors Influencing Bactericidal Efficacy using Atmospheric Cold Plasma (ACP) against Escherichia coli in Wheat Flour. Food Res Int 2022; 162:111985. [DOI: 10.1016/j.foodres.2022.111985] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/09/2022] [Revised: 09/06/2022] [Accepted: 09/26/2022] [Indexed: 12/01/2022]
|
24
|
Aaliya B, Sunooj KV, Navaf M, Akhila PP, Sudheesh C, Sabu S, Sasidharan A, Sinha SK, George J. Influence of plasma-activated water on the morphological, functional, and digestibility characteristics of hydrothermally modified non-conventional talipot starch. Food Hydrocoll 2022. [DOI: 10.1016/j.foodhyd.2022.107709] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
25
|
Ge X, Shen H, Sun X, Liang W, Zhang X, Sun Z, Lu Y, Li W. Insight into the improving effect on multi-scale structure, physicochemical and rheology properties of granular cold water soluble rice starch by dielectric barrier discharge cold plasma processing. Food Hydrocoll 2022; 130:107732. [DOI: 10.1016/j.foodhyd.2022.107732] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/17/2022]
|
26
|
Yan Y, Xue X, Jin X, Niu B, Chen Z, Ji X, Shi M, He Y. Effect of annealing using plasma-activated water on the structure and properties of wheat flour. Front Nutr 2022; 9:951588. [PMID: 36034897 PMCID: PMC9403792 DOI: 10.3389/fnut.2022.951588] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/24/2022] [Accepted: 07/18/2022] [Indexed: 11/13/2022] Open
Abstract
In this study, wheat flour (WF) was modified by annealing (ANN) using plasma-activated water (PAW) for the first time. Compared with WF and DW-WF, the results of scanning electron microscopy (SEM) and particle-size analysis showed that the granule structure of wheat starch in PAW-WF was slightly damaged, and the particle size of PAW-WF was significantly reduced. The results of X-ray diffraction and Fourier transforming infrared spectroscopy indicated that PAW-ANN could reduce the long-range and short-range order degrees of wheat starch and change the secondary structure of the protein in WF, in which the content of random coils and α-helices was significantly increased. In addition, the analysis of solubility, viscosity, and dynamic rheological properties showed that PAW-ANN improved the solubility and gel properties of WF and decreased its viscosity properties and short-term regeneration. PAW-ANN, as a green modification technology, has the potential for further application in WF modification, as well as in the production of flour products.
Collapse
Affiliation(s)
- Yizhe Yan
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Xinhuan Xue
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Xueyuan Jin
- School of Clinical Medicine, Hainan Vocational University of Science and Technology, Haikou, China
| | - Bin Niu
- College of Food Science and Technology, Henan Agricultural University, Zhengzhou, China
| | - Zhenzhen Chen
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Xiaolong Ji
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Miaomiao Shi
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Yuan He
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| |
Collapse
|
27
|
Braşoveanu M, Nemţanu MR. Dual Modification of Starch by Physical Methods Based on Corona Electrical Discharge and Ionizing Radiation: Synergistic Impact on Rheological Behavior. Foods 2022; 11:foods11162479. [PMID: 36010483 PMCID: PMC9407343 DOI: 10.3390/foods11162479] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/19/2022] [Revised: 08/09/2022] [Accepted: 08/15/2022] [Indexed: 11/26/2022] Open
Abstract
The present paper focuses on evaluating the synergistic effects of dual modification with corona electric discharge (CED) and electron beam irradiation (EBI) on the rheological behavior of starch. Combined treatments were applied successively (CED/EBI and EBI/CED) and compared with single treatments. The outcomes showed that the rheological features of starch were altered by the dual modification in correlation with the irradiation dose mainly as a result of radiation-induced degradation. Decreases in apparent viscosity were described by exponential-like-models according to the order of application of the treatment sequences. The mathematical models allowed the estimation of the irradiation doses for which the viscosity decreased by e times for the dual modified starches (3.3 ± 1.3 kGy for CED/EBI and 5.6 ± 0.5 kGy for EBI/CED, respectively) and the fraction (f) of 0.47 ± 0.10 corresponding to starch granule considered to be affected by plasma. Both dual treatments yielded a synergistic effect, regardless of the order of application of the treatment sequences, being more effective in decreasing starch apparent viscosity than single EBI. However, synergism evaluation proved that the use of plasma as a pre-treatment to irradiation processing could provide benefits up to 20 kGy. These findings support the practical goals of technologists with valuable information that may facilitate or simplify the experimental design of starch dual modification with plasma and ionizing radiation.
Collapse
|
28
|
Ačkar Đ, Grec M, Grgić I, Gryszkin A, Styczyńska M, Jozinović A, Miličević B, Šubarić D, Babić J. Physical Properties of Starches Modified by Phosphorylation and High-Voltage Electrical Discharge (HVED). Polymers (Basel) 2022; 14:polym14163359. [PMID: 36015615 PMCID: PMC9414949 DOI: 10.3390/polym14163359] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/26/2022] [Revised: 08/11/2022] [Accepted: 08/15/2022] [Indexed: 11/16/2022] Open
Abstract
High-voltage electrical discharge (HVED) is considered as a novel, non-thermal process and is currently being researched regarding its effect on microorganisms (decontamination of food), waste water treatment, and modification of different compounds and food components. In this paper, four native starches (maize, wheat, potato, and tapioca) were treated with HVED, phosphorylated with Na2HPO4 and Na5P3O10, and modified by a combination of HVED with each phosphorylation reaction both prior and after chemical modification. Pasting properties, swelling power, solubility, gel texture, and particle size were analyzed. Although HVED induced lower contents of P in modified starches, it had an effect on analyzed properties. The results revealed that HVED treatment alone had a limited effect on pasting properties of starches, but it had an effect on properties of phosphorylated starches, both when it was conducted prior and after the chemical modification, reducing the influence of Na5P3O10 and Na2HPO4 on the decrease of pasting temperature. With minor exceptions, the gel strength of starches increased, and the rupture strength decreased by all modifications. HVED treatment resulted in a decrease of the particle size after the modification of maize and wheat starches, while potato and tapioca starches were not significantly influenced by the treatment.
Collapse
Affiliation(s)
- Đurđica Ačkar
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, F. Kuhača 18, 31000 Osijek, Croatia
- Correspondence:
| | - Marijana Grec
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, F. Kuhača 18, 31000 Osijek, Croatia
| | - Ivanka Grgić
- Institute of Public Health Brod-Posavina County, V. Nazora 2A, 35000 Slavonski Brod, Croatia
| | - Artur Gryszkin
- Department of Food Storage and Technology, Faculty of Biotechnology and Food Science, Wrocław University of Environmental and Life Sciences, Chełmońskiego 37, 51-630 Wroclaw, Poland
| | - Marzena Styczyńska
- Department of Human Nutrition, Faculty of Biotechnology and Food Science, Wrocław University of Environmental and Life Sciences, Chełmońskiego 37, 51-630 Wroclaw, Poland
| | - Antun Jozinović
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, F. Kuhača 18, 31000 Osijek, Croatia
| | - Borislav Miličević
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, F. Kuhača 18, 31000 Osijek, Croatia
- Polytechnic in Požega, Vukovarska ulica 17, 34000 Požega, Croatia
| | - Drago Šubarić
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, F. Kuhača 18, 31000 Osijek, Croatia
| | - Jurislav Babić
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, F. Kuhača 18, 31000 Osijek, Croatia
| |
Collapse
|
29
|
Singh H, Blennow A, Gupta AD, Kaur P, Dhillon B, Sodhi NS, Dubey PK. Pulsed light, Pulsed Electric Field and Cold plasma modification of Starches: Technological Advancements & Effects on Functional Properties. Food Measure. [DOI: 10.1007/s11694-022-01487-y] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 10/17/2022]
|
30
|
Kopuk B, Gunes R, Palabiyik I. Cold plasma modification of food macromolecules and effects on related products. Food Chem 2022; 382:132356. [DOI: 10.1016/j.foodchem.2022.132356] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/22/2021] [Revised: 01/20/2022] [Accepted: 02/03/2022] [Indexed: 12/27/2022]
|
31
|
Gao S, Zhang H, Pei J, Liu H, Lu M, Chen J, Wang M. High-voltage and short-time dielectric barrier discharge plasma treatment affects structural and digestive properties of Tartary buckwheat starch. Int J Biol Macromol 2022. [DOI: 10.1016/j.ijbiomac.2022.05.171] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/06/2022] [Revised: 05/05/2022] [Accepted: 05/25/2022] [Indexed: 11/22/2022]
|
32
|
Jaddu S, Pradhan RC, Dwivedi M. Effect of multipin atmospheric cold plasma discharge on functional properties of little millet (Panicum miliare) flour. INNOV FOOD SCI EMERG 2022. [DOI: 10.1016/j.ifset.2022.102957] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/24/2022]
|
33
|
Zhang K, Zhang Z, Zhao M, Milosavljević V, Cullen P, Scally L, Sun DW, Tiwari BK. Low-pressure plasma modification of the rheological properties of tapioca starch. Food Hydrocoll 2022. [DOI: 10.1016/j.foodhyd.2021.107380] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/06/2023]
|
34
|
Guo Z, Gou Q, Yang L, Yu QL, Han L. Dielectric barrier discharge plasma: A green method to change structure of potato starch and improve physicochemical properties of potato starch films. Food Chem 2022; 370:130992. [PMID: 34509946 DOI: 10.1016/j.foodchem.2021.130992] [Citation(s) in RCA: 20] [Impact Index Per Article: 10.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/22/2021] [Revised: 08/15/2021] [Accepted: 08/29/2021] [Indexed: 11/24/2022]
Abstract
The effects of dielectric barrier discharge (DBD) plasma treatment on the physicochemical properties of potato starch and its films were studied. The results showed that the plasma species caused etching lead to small cracks and pores in potato starch particles and that oxidation, de-polymerization, and crosslinking were the main mechanisms underlying the effects of DBD plasma treatment. As the treatment time extended, starch hydrolysis, turbidity, syneresis, and gelatinization temperatures increased first and then decreased, whereas the solubility, swelling power, and water absorption significantly increased (P < 0.05). There was a decrease in the retrogradation tendency of the starch gels. The surfaces of the DBD plasma-modified potato starch-based films were relatively flat. After a 9-min treatment, the films exhibited the lowest water vapor permeability and highest tensile strength. In conclusion, the use of DBD plasma is a simple and green method to enhance the properties of potato starch and its film.
Collapse
|
35
|
Zare L, Mollakhalili-Meybodi N, Fallahzadeh H, Arab M. Effect of atmospheric pressure cold plasma (ACP) treatment on the technological characteristics of quinoa flour. Lebensm Wiss Technol 2022. [DOI: 10.1016/j.lwt.2021.112898] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/19/2022]
|
36
|
Okyere AY, Rajendran S, Annor GA. Cold plasma technologies: Their effect on starch properties and industrial scale-up for starchmodification. Curr Res Food Sci 2022; 5:451-463. [PMID: 35243357 PMCID: PMC8866071 DOI: 10.1016/j.crfs.2022.02.007] [Citation(s) in RCA: 24] [Impact Index Per Article: 12.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/01/2021] [Revised: 01/29/2022] [Accepted: 02/15/2022] [Indexed: 11/28/2022] Open
Abstract
Native starches have limited applications in the food industry due to their unreactive and insoluble nature. Cold plasma technology, including plasma-activated water (PAW), has been explored to modify starches to enhance their functional, thermal, molecular, morphological, and physicochemical properties. Atmospheric cold plasma and low-pressure plasma systems have been used to alter starches and have proven successful. This review provides an in-depth analysis of the different cold plasma setups employed for starch modifications. The effect of cold plasma technology application on starch characteristics is summarized. We also discussed the potential of plasma-activated water as a novel alternative for starch modification. This review provides information needed for the industrial scale-up of cold plasma technologies as an eco-friendly method of starch modification. Cold plasma technology could be an effective, sustainable alternative for starch modification. The extent of modification of starches from different botanical sources depends on the type of cold plasma technology used. For mainstream adoption of cold plasma modified starches, research on safety and consumer perception must be conducted.
Collapse
|
37
|
Kalaivendan RGT, Mishra A, Eazhumalai G, Annapure US. Effect of atmospheric pressure non-thermal pin to plate plasma on the functional, rheological, thermal, and morphological properties of mango seed kernel starch. Int J Biol Macromol 2022; 196:63-71. [PMID: 34896473 DOI: 10.1016/j.ijbiomac.2021.12.013] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/06/2021] [Revised: 11/23/2021] [Accepted: 12/02/2021] [Indexed: 11/23/2022]
Abstract
This study aimed to investigate the effect of atmospheric pressure non-thermal pin-to-plate plasma on the functional, rheological, thermal, and morphological properties of mango seed kernel starch. As cold plasma contains highly reactive species and free radicals, it is expected to cause noticeable modifications in the attributes of starch treated. The isolated mango seed kernel starch was subjected to the plasma treatment of input voltages 170 and 230 V for 15 and 30 min of exposure. Water adsorption, swelling, and solubility at lower temperatures. There has been a significant reduction (p < 0.05) in pH values of starch from 7.09 to 6.16 and also the desirable reduction in turbidity values by 42.60%. However, there has been no significant change in the oil and water binding behavior of the starch. The FTIR spectra of MSKS demonstrate the formation of amines which contributes to the better hydrophilic nature of the starch. The structural modification has been adequately confirmed by SEM images. The maximum voltage and time combination, lead to depolymerization of starch which is supported by NMR spectra thus affecting thermal and rheological properties. The application of cold plasma-modified MSKS in food would facilitate stable and smooth textural development.
Collapse
|
38
|
Kariuki PN, Arjunan Y, Nagarajan U, Kanth SV. The combined effect of thermal-acid hydrolysis, periodate oxidation, and iodine species removal on the properties of native tapioca (Manihot esculenta Crantz) starch. Int J Biol Macromol 2022; 196:107-19. [PMID: 34910925 DOI: 10.1016/j.ijbiomac.2021.11.211] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/02/2021] [Revised: 11/08/2021] [Accepted: 11/30/2021] [Indexed: 11/21/2022]
Abstract
Through a four-step top-down approach, native tapioca starch (NTS) was thermally acid-hydrolyzed, periodate-oxidized with subsequent removal of iodine species (i.e., IO4(-), IO3(-), I(-), and I2), and dialdehyde tapioca starch (DTS) alcohol-precipitation. The percent yield was ∼91%. Analyses confirmed the presence of aldehydic functionalities (∼71%), effectual iodine species removal (∼98%), and enhanced water-solubility (∼96.57%). Besides, the combined treatment significantly reduced the Mw (∼57.81 kDa) and ameliorated homogeneity as well as thermal stability (Tmax ∼ 667.15 °C). Structural-spectral characterization also confirmed the presence of aldehydic functionality, polymorphic transition (C- to A-type), and a higher degree of crystallinity (∼91.77%), the latter further corroborated by thermal analysis. The morphological study revealed that the combined treatment reduced size (∼393.55-nm-diameter and ∼5.22-μm-length) and changed shape into rod-like crystals. DTS showed considerably and significantly low cytotoxicity to HaCaT cells in vitro at the concentrations assayed over the test period (24 h). DTS's conformation was most stable at -289 kcal/mol and -151.7 au heat formation and minimum potential energies, respectively. Overall, these results demonstrated that the combined treatment had no deleterious effects on NTS's properties, thus yielded DTS with ideal properties for multifarious uses.
Collapse
|
39
|
Wu Z, Qiao D, Zhao S, Lin Q, Zhang B, Xie F. Nonthermal physical modification of starch: An overview of recent research into structure and property alterations. Int J Biol Macromol 2022; 203:153-175. [PMID: 35092737 DOI: 10.1016/j.ijbiomac.2022.01.103] [Citation(s) in RCA: 16] [Impact Index Per Article: 8.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/14/2021] [Revised: 01/03/2022] [Accepted: 01/16/2022] [Indexed: 11/28/2022]
Abstract
To tailor the properties and enhance the applicability of starch, various ways of starch modification have been practiced. Among them, physical modification methods (micronization, nonthermal plasma, high-pressure, ultrasonication, pulsed electric field, and γ-irradiation) are highly potential for starch modification considering its safety, environmentally friendliness, and cost-effectiveness, without generating chemical wastes. Thus, this article provides an overview of the recent advances in nonthermal physical modification of starch and summarizes the resulting changes in the multi-level structures and physicochemical properties. While the effect of these techniques highly depends on starch type and treatment condition, they generally lead to the destruction of starch granules, the degradation of molecules, decreases in crystallinity, gelatinization temperatures, and viscosity, increases in solubility and swelling power, and an increase or decrease in digestibility, to different extents. The advantages and shortcomings of these techniques in starch processing are compared, and the knowledge gap in this area is commented on.
Collapse
Affiliation(s)
- Zhuoting Wu
- Group for Cereals and Oils Processing, College of Food Science and Technology, Key Laboratory of Environment Correlative Dietology (Ministry of Education), Huazhong Agricultural University, Wuhan 430070, China
| | - Dongling Qiao
- Glyn O. Phillips Hydrocolloid Research Centre at HBUT, School of Food and Biological Engineering, Hubei University of Technology, Wuhan 430068, China
| | - Siming Zhao
- Group for Cereals and Oils Processing, College of Food Science and Technology, Key Laboratory of Environment Correlative Dietology (Ministry of Education), Huazhong Agricultural University, Wuhan 430070, China
| | - Qinlu Lin
- National Engineering Laboratory for Rice and By-product Deep Processing, College of Food Science and Engineering, Central South University of Forestry and Technology, Changsha 410004, China
| | - Binjia Zhang
- Group for Cereals and Oils Processing, College of Food Science and Technology, Key Laboratory of Environment Correlative Dietology (Ministry of Education), Huazhong Agricultural University, Wuhan 430070, China.
| | - Fengwei Xie
- School of Engineering, Newcastle University, Newcastle upon Tyne NE1 7RU, United Kingdom.
| |
Collapse
|
40
|
Seidi F, Yazdi MK, Jouyandeh M, Habibzadeh S, Munir MT, Vahabi H, Bagheri B, Rabiee N, Zarrintaj P, Saeb MR. Crystalline polysaccharides: A review. Carbohydr Polym 2022; 275:118624. [PMID: 34742405 DOI: 10.1016/j.carbpol.2021.118624] [Citation(s) in RCA: 24] [Impact Index Per Article: 12.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/24/2021] [Revised: 08/26/2021] [Accepted: 08/26/2021] [Indexed: 12/12/2022]
Abstract
The biodegradability and mechanical properties of polysaccharides are dependent on their architecture (linear or branched) as well as their crystallinity (size of crystals and crystallinity percent). The amount of crystalline zones in the polysaccharide significantly governs their ultimate properties and applications (from packaging to biomedicine). Although synthesis, characterization, and properties of polysaccharides have been the subject of several review papers, the effects of crystallization kinetics and crystalline domains on the properties and application have not been comprehensively addressed. This review places focus on different aspects of crystallization of polysaccharides as well as applications of crystalline polysaccharides. Crystallization of cellulose, chitin, chitosan, and starch, as the main members of this family, were discussed. Then, application of the aforementioned crystalline polysaccharides and nano-polysaccharides as well as their physical and chemical interactions were overviewed. This review attempts to provide a complete picture of crystallization-property relationship in polysaccharides.
Collapse
Affiliation(s)
- Farzad Seidi
- Jiangsu Co-Innovation Center of Efficient Processing and Utilization of Forest Resources and International Innovation Center for Forest Chemicals and Materials, Nanjing Forestry University, Nanjing 210037, China
| | - Mohsen Khodadadi Yazdi
- Center of Excellence in Electrochemistry, School of Chemistry, College of Science, University of Tehran, Tehran, Iran
| | - Maryam Jouyandeh
- Center of Excellence in Electrochemistry, School of Chemistry, College of Science, University of Tehran, Tehran, Iran
| | - Sajjad Habibzadeh
- Department of Chemical Engineering, Amirkabir University of Technology (Tehran Polytechnic), Tehran, Iran
| | | | - Henri Vahabi
- Université de Lorraine, CentraleSupélec, LMOPS, F-57000 Metz, France
| | - Babak Bagheri
- Department of Chemical and Biomolecular Engineering, Korea Advanced Institute of Science and Technology (KAIST), Daejeon, Republic of Korea
| | - Navid Rabiee
- Department of Physics, Sharif University of Technology, P.O. Box 11155-9161, Tehran, Iran
| | - Payam Zarrintaj
- School of Chemical Engineering, Oklahoma State University, 420 Engineering North, Stillwater, OK 74078, United States
| | - Mohammad Reza Saeb
- Department of Polymer Technology, Faculty of Chemistry, Gdańsk University of Technology, G. Narutowicza 11/12, 80-233 Gdańsk, Poland.
| |
Collapse
|
41
|
Ge X, Shen H, Su C, Zhang B, Zhang Q, Jiang H, Yuan L, Yu X, Li W. Pullulanase modification of granular sweet potato starch: Assistant effect of dielectric barrier discharge plasma on multi-scale structure, physicochemical properties. Carbohydr Polym 2021; 272:118481. [PMID: 34420740 DOI: 10.1016/j.carbpol.2021.118481] [Citation(s) in RCA: 25] [Impact Index Per Article: 8.3] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/19/2021] [Revised: 07/18/2021] [Accepted: 07/20/2021] [Indexed: 11/21/2022]
Abstract
This study explored the potential application of physical combined enzyme treatment to modify starch granules. Starch was modified by exposure to cold plasma (CP) for 1, 3, and 9 min and to pullulanase (PUL) for 12, 24, and 36 h. Individual treatments with CP and PUL somewhat modified starch structure and physicochemical properties. Nevertheless, compared with native starch and individual treatments, CP-PUL combined treatment significantly (p < 0.05) promoted the subsequent structural modification, increased the short-chain ratio and the amylose content, reduce the molecular weight and the relative crystallinity, and disturb the short-range order. CP also improved the properties of PUL-modified starch, including enhanced solubility, thermal properties and resistance to enzymatic hydrolysis but worsened swelling power and peak viscosity properties. This research provides a new perspective for the rational application of CP-PUL co-treated starch in the food industry.
Collapse
|
42
|
Sadeghi F, Koocheki A, Shahidi F. Physical modification of Lepidium perfoliatum seed gum using cold atmospheric-pressure plasma treatment. Food Hydrocoll 2021; 120:106902. [DOI: 10.1016/j.foodhyd.2021.106902] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/22/2022]
|
43
|
Barbhuiya RI, Singha P, Singh SK. A comprehensive review on impact of non-thermal processing on the structural changes of food components. Food Res Int 2021; 149:110647. [PMID: 34600649 DOI: 10.1016/j.foodres.2021.110647] [Citation(s) in RCA: 40] [Impact Index Per Article: 13.3] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/25/2021] [Revised: 08/17/2021] [Accepted: 08/18/2021] [Indexed: 10/20/2022]
Abstract
Non-thermal food processing is a viable alternative to traditional thermal processing to meet customer needs for high-quality, convenient and minimally processed foods. They are designed to eliminate elevated temperatures during processing and avoid the adverse effects of heat on food products. Numerous thermal and novel non-thermal technologies influence food structure at the micro and macroscopic levels. They affect several properties such as rheology, flavour, process stability, texture, and appearance at microscopic and macroscopic levels. This review presents existing knowledge and advances on the impact of non-thermal technologies, for instance, cold plasma treatment, irradiation, high-pressure processing, ultrasonication, pulsed light technology, high voltage electric field and pulsed electric field treatment on the structural changes of food components. An extensive review of the literature indicates that different non-thermal processing technologies can affect the food components, which significantly affects the structure of food. Applications of novel non-thermal technologies have shown considerable impact on food structure by altering protein structures via free radicals or larger or smaller molecules. Lipid oxidation is another process responsible for undesirable effects in food when treated with non-thermal techniques. Non-thermal technologies may also affect starch properties, reduce molecular weight, and change the starch granule's surface. Such modification of food structure could create novel food textures, enhance sensory properties, improve digestibility, improve water-binding ability and improve mediation of gelation processes. However, it is challenging to determine these technologies' influence on food components due to differences in their primary operation and equipment design mechanisms and different operating conditions. Hence, to get the most value from non-thermal technologies, more in-depth research about their effect on various food components is required.
Collapse
Affiliation(s)
- Rahul Islam Barbhuiya
- Department of Food Process Engineering, National Institute of Technology (NIT) Rourkela, Rourkela 769008, Odisha, India
| | - Poonam Singha
- Department of Food Process Engineering, National Institute of Technology (NIT) Rourkela, Rourkela 769008, Odisha, India.
| | - Sushil Kumar Singh
- Department of Food Process Engineering, National Institute of Technology (NIT) Rourkela, Rourkela 769008, Odisha, India.
| |
Collapse
|
44
|
Gryszkin A, Grec M, Ačkar Đ, Zięba T, Jozinović A, Šubarić D, Miličević B, Blažić M, Babić J. Phosphorylation of Maize Starch Enhanced with High-Voltage Electrical Discharge (HVED) Instead of Thermal Treatment. Polymers (Basel) 2021; 13:3231. [PMID: 34641049 PMCID: PMC8512410 DOI: 10.3390/polym13193231] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/28/2021] [Revised: 09/13/2021] [Accepted: 09/15/2021] [Indexed: 11/16/2022] Open
Abstract
The aim of this research was to explore the use of a high-voltage electrical treatment (HVED) as a substitute for heating during the phosphorylation of maize starch. Starch was treated with HVED, phosphorylated with Na2HPO4 or Na5P3O10 with and without thermal treatment and phosphorylated in combination with HVED prior to and after the chemical modification. When starch was phosphorylated with Na2HPO4, HVED was more efficient in catalyzing reaction (3.89 mg P/kg for 30 min HVED in relation to 0.43 mg P/kg for thermal treatment), whereas with Na5P3O10 similar P content was achieved as with thermal treatment (0.76 P/kg for 30 min HVED in relation to 0.86 mg P/kg). The order of HVED and chemical reactions did not have a marked effect on phosphorous content. In combination with Na2HPO4, HVED pre-treatment had a more pronounced effect on the solubility and water absorption, whereas post-treatment was favoured with Na5P3O10. Mean diameter was increased by all treatments, where HVED had a marked effect. Enthalpy of gelatinization ranged from 11.76 J/g for starch treated with Na5P3O10 and 10 min-HVED to 13.58 J/g for Na5P3O10 treated sample. G' and G″ increased after both thermally and HVED enhanced phosphorylations, with a slightly more pronounced effect of the HVED.
Collapse
Affiliation(s)
- Artur Gryszkin
- Department of Food Storage and Technology, Wrocław University of Environmental and Life Sciences, ul. Chełmońskiego, 37/41, 51-630 Wrocław, Poland; (A.G.); (T.Z.)
| | - Marijana Grec
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, Franje Kuhača 18, 31000 Osijek, Croatia; (M.G.); (A.J.); (D.Š.); (B.M.); (J.B.)
| | - Đurđica Ačkar
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, Franje Kuhača 18, 31000 Osijek, Croatia; (M.G.); (A.J.); (D.Š.); (B.M.); (J.B.)
| | - Tomasz Zięba
- Department of Food Storage and Technology, Wrocław University of Environmental and Life Sciences, ul. Chełmońskiego, 37/41, 51-630 Wrocław, Poland; (A.G.); (T.Z.)
| | - Antun Jozinović
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, Franje Kuhača 18, 31000 Osijek, Croatia; (M.G.); (A.J.); (D.Š.); (B.M.); (J.B.)
| | - Drago Šubarić
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, Franje Kuhača 18, 31000 Osijek, Croatia; (M.G.); (A.J.); (D.Š.); (B.M.); (J.B.)
| | - Borislav Miličević
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, Franje Kuhača 18, 31000 Osijek, Croatia; (M.G.); (A.J.); (D.Š.); (B.M.); (J.B.)
- Polytechnic in Požega, Vukovarska 17, 34000 Požega, Croatia
| | - Marijana Blažić
- Department of Food Technology, Karlovac University of Applied Sciences, Trg Josipa Jurja Strossmayera 9, 47000 Karlovac, Croatia;
| | - Jurislav Babić
- Faculty of Food Technology Osijek, Josip Juraj Strossmayer University of Osijek, Franje Kuhača 18, 31000 Osijek, Croatia; (M.G.); (A.J.); (D.Š.); (B.M.); (J.B.)
| |
Collapse
|
45
|
Settapramote N, Utama-Ang N, Petiwathayakorn T, Settakorn K, Svasti S, Srichairatanakool S, Koonyosying P. Antioxidant Effects of Anthocyanin-Rich Riceberry™ Rice Flour Prepared Using Dielectric Barrier Discharge Plasma Technology on Iron-Induced Oxidative Stress in Mice. Molecules 2021; 26:4978. [PMID: 34443567 DOI: 10.3390/molecules26164978] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/14/2021] [Revised: 08/10/2021] [Accepted: 08/13/2021] [Indexed: 11/17/2022] Open
Abstract
Redox-active iron generates reactive oxygen species that can cause oxidative organ dysfunction. Thus, the anti-oxidative systems in the body and certain dietary antioxidants, such as anthocyanins, are needed to control oxidative stress. We aimed to investigate the effects of dielectric barrier discharge (DBD) plasma technology in the preparation of Riceberry™ rice flour (PRBF) on iron-induced oxidative stress in mice. PRBF using plasma technology was rich in anthocyanins, mainly cyanidine-3-glucoside and peonidine-3-glucoside. PRBF (5 mg AE/mg) lowered WBC numbers in iron dextran (FeDex)-loaded mice and served as evidence of the reversal of erythrocyte superoxide dismutase activity, plasma total antioxidant capacity, and plasma and liver thiobarbituric acid-reactive substances in the loading mice. Consequently, the PRBF treatment was observed to be more effective than NAC treatment. PRBF would be a powerful supplementary and therapeutic antioxidant product that is understood to be more potent than NAC in ameliorating the effects of iron-induced oxidative stress.
Collapse
|
46
|
Braşoveanu M, Nemţanu MR, Ticoș D. Influence of the sample loading on the contribution of competitive effects for granular starch exposed to radio-frequency plasma. INNOV FOOD SCI EMERG 2021. [DOI: 10.1016/j.ifset.2021.102740] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/21/2022]
|
47
|
Amirabadi S, Mohammadzadeh Milani J, Sohbatzadeh F. Effects of cold atmospheric-pressure plasma on the rheological properties of gum Arabic. Food Hydrocoll 2021. [DOI: 10.1016/j.foodhyd.2021.106724] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022]
|
48
|
Warne GR, Williams PM, Pho HQ, Tran NN, Hessel V, Fisk ID. Impact of cold plasma on the biomolecules and organoleptic properties of foods: A review. J Food Sci 2021; 86:3762-3777. [PMID: 34337748 DOI: 10.1111/1750-3841.15856] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/02/2020] [Revised: 06/15/2021] [Accepted: 06/21/2021] [Indexed: 11/27/2022]
Abstract
Cold plasma is formed by the nonthermal ionization of gas into free electrons, ions, reactive atomic and molecular species, and ultraviolet (UV) radiation. This cold plasma can be used to alter the surface of solid and liquid foods, and it offers multiple advantages over traditional thermal treatments, such as no thermal damage and increased output variation (due to the various input parameters gas, power, plasma type, etc.). Cold plasma appears to have limited impact on the sensory and color properties, at lower power and treatment times, but there has been a statistically significant reduction in pH for most of the cold plasma treatments reviewed (p < 0.05). Carbohydrates (cross linking and glycosylation), lipids (oxidation), and proteins (secondary structure) are more significantly impacted due to cold plasma at higher intensities and longer treatment times. Although cold plasma treatments and food matrices can vary considerably, this review has identified the literary evidence of some of the influences and impacts of the vast array of cold plasma treatment parameters on the biomolecular and organoleptic properties of these foods. Due to the rapidly evolving nature of the field, we have also identified that authors prioritize the presentation of different information when publishing from different research areas. Therefore, we have proposed a number of key physical and chemical cold plasma parameters that should be considered for inclusion in all future publications in the field.
Collapse
Affiliation(s)
- George R Warne
- Division of Food Sciences, School of Biosciences, University of Nottingham, Loughborough, UK.,The University of Adelaide, Adelaide, South Australia, Australia
| | - Philip M Williams
- Molecular Therapeutics and Formulation, School of Pharmacy, University of Nottingham, Nottingham, UK
| | - Hue Quoc Pho
- School of Chemical Engineering and Advanced Materials, The University of Adelaide, Adelaide, South Australia, Australia.,School of Chemical Engineering, University of Warwick, Coventry, UK
| | - Nam Nghiep Tran
- School of Chemical Engineering and Advanced Materials, The University of Adelaide, Adelaide, South Australia, Australia.,School of Chemical Engineering, University of Warwick, Coventry, UK
| | - Volker Hessel
- School of Chemical Engineering and Advanced Materials, The University of Adelaide, Adelaide, South Australia, Australia.,School of Chemical Engineering, University of Warwick, Coventry, UK
| | - Ian D Fisk
- Division of Food Sciences, School of Biosciences, University of Nottingham, Loughborough, UK.,The University of Adelaide, Adelaide, South Australia, Australia
| |
Collapse
|
49
|
Gojković Cvjetković V, Marjanović‐Balaban Ž, Vujadinović D, Vukić M, Rajić D. Investigation of the effect of cold atmospheric plasma on gliadins and glutenins extracted from wheat flour samples. J FOOD PROCESS PRES 2021. [DOI: 10.1111/jfpp.15789] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
Affiliation(s)
- Vesna Gojković Cvjetković
- Faculty of Technology Zvornik University of East Sarajevo Zvornik Republic of Srpska, Bosnia and Herzegovina
| | | | - Dragan Vujadinović
- Faculty of Technology Zvornik University of East Sarajevo Zvornik Republic of Srpska, Bosnia and Herzegovina
| | - Milan Vukić
- Faculty of Technology Zvornik University of East Sarajevo Zvornik Republic of Srpska, Bosnia and Herzegovina
| | - Danijela Rajić
- Faculty of Technology Zvornik University of East Sarajevo Zvornik Republic of Srpska, Bosnia and Herzegovina
| |
Collapse
|
50
|
Carvalho APMG, Barros DR, da Silva LS, Sanches EA, Pinto CDC, de Souza SM, Clerici MTPS, Rodrigues S, Fernandes FAN, Campelo PH. Dielectric barrier atmospheric cold plasma applied to the modification of Ariá (Goeppertia allouia) starch: Effect of plasma generation voltage. Int J Biol Macromol 2021; 182:1618-1627. [PMID: 34052266 DOI: 10.1016/j.ijbiomac.2021.05.165] [Citation(s) in RCA: 28] [Impact Index Per Article: 9.3] [Reference Citation Analysis] [What about the content of this article? (0)] [Affiliation(s)] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/22/2021] [Revised: 05/23/2021] [Accepted: 05/24/2021] [Indexed: 11/30/2022]
Abstract
The goal of this paper was to evaluate the influence of a range of plasma generation voltages on the physicochemical, structural, and technological properties of Aria (Goeppertia allouia) starch. Untreated (0 kV) and high voltages of cold plasma generation (7, 10, 14, and 20 kV) treated samples were evaluated according to their amylose content, pH, groups carbonyl/carboxyl, molecular size distribution, structure and technological properties (empirical viscosity, hydration properties, thermal analysis and gel strength). The applied voltage of 14 kV resulted in the greatest depolymerization of the starch chains, while 20 kV allowed the formation of oxidized complexes, promoting crosslinking of the starches chain. The cold plasma technique did not affect the levels of resistant starches, but increased the starch digestibility. The increased carbonyl and carboxyl groups also influenced the paste viscosity, improved hydration properties. This study suggests that the cold plasma technique can be useful in the controlled modification of starches, producing starches with different technological properties.
Collapse
Affiliation(s)
- Ana Paula Miléo Guerra Carvalho
- Grupo de Inovação em Biotecnologia e Alimentos da Amazônia (gIBA), Universidade Federal do Amazonas, Manaus, Amazonas 69077-000, Brazil; Federal Institute of Education, Science and Technology of Amazonas, Manaus, Amazonas, Brazil
| | - Domingos Rodrigues Barros
- Grupo de Inovação em Biotecnologia e Alimentos da Amazônia (gIBA), Universidade Federal do Amazonas, Manaus, Amazonas 69077-000, Brazil; Federal Institute of Education, Science and Technology of Amazonas, Manaus, Amazonas, Brazil
| | - Laiane Souza da Silva
- Laboratory of Nanostructured Polymers (NANOPOL; @nanopol_ufam), Federal University of Amazonas, Manaus, Amazonas 69077-000, Brazil
| | - Edgar Aparecido Sanches
- Laboratory of Nanostructured Polymers (NANOPOL; @nanopol_ufam), Federal University of Amazonas, Manaus, Amazonas 69077-000, Brazil
| | - Camila da Costa Pinto
- Graduation Program in Material Science & Engineering (PPGCEM), Federal University of Amazonas, Manaus, Amazonas 69077-000, Brazil
| | - Sérgio Michielon de Souza
- Graduation Program in Material Science & Engineering (PPGCEM), Federal University of Amazonas, Manaus, Amazonas 69077-000, Brazil; Department of Physics, Federal University of Amazonas, Manaus, Amazonas 69077-000, Brazil
| | | | - Sueli Rodrigues
- Universidade Federal do Ceará, Departamento de Engenharia de Alimentos, Campus do Pici Bloco 858, 60440-900 Fortaleza, Ceará, Brazil
| | - Fabiano André Narciso Fernandes
- Universidade Federal do Ceará, Departamento de Engenharia Química, Campus do Pici Bloco 709, 60440-900 Fortaleza, Ceará, Brazil
| | - Pedro Henrique Campelo
- Grupo de Inovação em Biotecnologia e Alimentos da Amazônia (gIBA), Universidade Federal do Amazonas, Manaus, Amazonas 69077-000, Brazil; Faculty of Agrarian Science, Federal University of Amazonas, Manaus, Amazonas 69077-000, Brazil.
| |
Collapse
|