Alkaline aided thermophiles pretreatment of waste activated sludge to increase short chain fatty acids production: Microbial community evolution by alkaline on hydrolysis and fermentation

Performance and mechanism of a novel hydrolytic bacteria pretreatment to boost waste activated sludge disintegration and volatile fatty acids production during acidogenic fermentation

In this study, an innovative mixed hydrolytic bacteria culture (HB) (the main dominant bacterial species: Lactobacillus acetotolerans), as an environmentally friendly pretreatment technique, was developed to enhance the volatile fatty acids (VFAs) production from waste-activated sludge (WAS). The highest VFAs production of 517 and 518 mg/g VSS were achieved with HB 8% and HB 8%-35 °C pretreatments, which were almost 3.6 folds compared to the control (143 mg/g VSS), respectively. The mechanism analysis revealed that HB boosted the bioavailability of organics released from WAS and significantly accelerated sludge solubilization. Protease and α-glucosidase enzymatic activity were improved and associated with hydrolysis and acidogenesis. Furthermore, the microbial community analysis showed that HB pretreatment significantly increased the hydrolytic and acidifying bacteria proportions (e.g., Veillonella, Macellibacteroides sp., Clostridium_sensu_stricto_1 and Bacteroides sp., etc.). This study provides a promising, low-cost, and eco-friendly approach for recovering resources from WAS and transforming them into high-value products.

Effect of rhamnolipid on the performance of compound thermophilic bacteria agent pretreatment system for waste sludge hydrolysis

This study innovatively introduced rhamnolipid (RL) to compound thermophilic bacteria (TB) agent pretreatment system for further accelerating the waste sludge hydrolysis and substrates transformation. The results showed that combined pretreatment was beneficial for the sludge extracellular polymers (EPS) rupture and dissolved organic matters (DOM) release. In the optimal dosage of 40 mg/g SS RL, the activities of protease and α-glucosidase increased by 20.7 % and 33.3 % than that without RL addition, respectively. The addition of RL enhanced efficient contacts between hydrolases and organic substrates, and excitation emission matrix (EEM) spectrum revealed that combined pretreatment with 40 mg/g SS RL could achieve higher soluble microbial by-products occupancy (54 %) and lower fulvic acid-like substances (6 %) occupancy in DOM, promoting the waste sludge biodegradability. High organics availability conducted to more shifts in microbial community structure, compared with TB agent pretreatment, the relative abundance of genus Geobacillus and norank_f__Synergistaceae were enhanced by 29.08 and 0.33 times in combined pretreatment system, respectively, which was conducive to sludge hydrolysis and subsequent anaerobic fermentation process.

Enhancement of alkaline pretreatment-anaerobically digested sludge dewaterability by chitosan and rice husk powder for land use of biogas slurry

Alkaline pretreatment can improve the methane yields and dewatering performance of anaerobically digested sludge, but it still needs to be coupled with other conditioning methods in the practical dewatering process. This study utilized four different flocculants and a skeleton builder for conditioning of alkaline pretreatment-anaerobically digested sludge. Chitosan was found to be the most effective in dewatering the sludge. Chitosan coupled with rice husk powder further improved the dewatering performance, which reduced normalized capillary suction time, specific resistance to filtration, and moisture content by 98.7%, 82.0%, and 12.1%. For land use of biogas slurry as a fertilizer, chitosan conditioning promoted the growth of corn seedlings, while the other three flocculants diminished the growth of corn seedlings. Chitosan coupled with rice husk powder further promoted the growth of corn seedlings by 103.5%, 65.0%, and 53.7% in fresh weight, dry weight, and root length, respectively. Overall, chitosan coupled with rice husk powder not only enhanced the dewaterability of alkaline pretreatment-anaerobically digested sludge but also realized the resource utilization of agricultural waste.

Hydrocyclone combines with alkali-thermal pretreatment to enhance short-chain fatty acids production from anaerobic fermentation of waste activated sludge

The production of short-chain fatty acids (SCFAs) through anaerobic fermentation of waste activated sludge (WAS) is commonly constrained by limited substrate availability, particularly for WAS with low organic content. Combining the hydrocyclone (HC) selection with alkali-thermal (AT) pretreatment is a promising solution to address this limitation. The results indicated that HC selection modified the sludge properties by enhancing the ratio of mixed liquid volatile suspended solids (MLVSS)/mixed liquid suspended solids (MLSS) by 19.0% and decreasing the mean particle size by 17.4%, which were beneficial for the subsequent anaerobic fermentation process. Under the optimal HC + AT condition, the peak value of SCFAs production reached 4951.9 mg COD/L, representing a 23.2% increase compared to the raw sludge with only AT pretreatment. Mechanism investigations revealed such enhancement beyond mechanical separation. It involved an increase in bound extracellular polymeric substances (EPS) through HC selection and the disruption of sludge spatial structure by AT pretreatment. Consequently, this combination pretreatment accelerated the transfer of particulate organics (i.e., bound EPS and intracellular components) to the supernatant, thus increasing the accessibility of WAS substrate to hydrolytic and acidifying bacteria. Furthermore, the microbial structure was altered with the enrichment of key functional microorganisms, probably due to the facilitation of substrate biotransformation and product output. Meanwhile, the activity of hydrolases and SCFAs-forming enzymes increased, while that of methanogenic enzymes decreased. Overall, this strategy successfully enhanced SCFAs production from WAS while reducing the environmental risks of WAS disposal.

Enhanced hydrolysis of waste activated sludge and recovery of volatile fatty acids: Performance and mechanistic analysis of synergistic treatment with sodium citrate and calcium oxide

Anaerobic fermentation has emerged as a promising method of transforming waste activated sludge into high-value products (e.g., volatile fatty acids (VFAs)). This work developed sodium citrate (SC)-calcium oxide (CaO) pretreatment to accelerate the production of VFAs by enhancing sludge solubilization and disintegration of extracellular polymeric substances. The results showed that co-pretreatment with 0.25 g/g TSS of SC and 0.05 g/g TSS of CaO effectively boosted VFAs accumulation (5823.3 mg COD/L), which was 12.2 times higher than the Control group. SC-CaO pretreatment enhanced hydrolysis and acidogenesis by providing ample organic substrates, thereby promoting the growth of hydrolytic and acidogenic bacteria. Additionally, the fermentation broth resulting from co-pretreatment exhibited lower phosphorus concentration and higher biodegradability. Economic analysis confirmed that the combined pretreatment is cost-effective. This work provides a viable strategy for enhancing high-value product recovery from sludge.

Insights into the effect of nitrate photolysis on short-chain fatty acids production from waste activated sludge in anaerobic fermentation system: Performance and mechanisms

Nitrate photolysis has become an efficient, low-cost and promising technology for emerging contaminants removal, while its performance and mechanism for waste activated sludge (WAS) treatment is still unknown. This study innovatively introduced nitrate photolysis for WAS disintegration, and investigated the effect of nitrate addition (150-375 mg N/L) for short-chain fatty acids (SCFAs) production during anaerobic fermentation (AF). The results showed that nitrate photolysis significantly promoted the SCFAs production from WAS, and peaked at 280.7 mg/g VSS with 7-d fermentation with 150 mg N/L addition (150N-UV), which increased by 8.8-35.0 % and 10.7-23.3 % compared with other photolysis groups and sole nitrate groups. Effective release of the soluble organics was observed in the nitrate photolysis groups during AF, especially soluble proteins, reaching 1505.4 mg COD/L at 9 d in 150N-UV group, promoted by 7.0∼15.7 % than nitrate/nitrate photolysis groups. The model compounds simulation experiment further demonstrated the positive effect of nitrate photolysis on organics hydrolysis and SCFAs accumulation. The result of the radical capture and quenching verified the reactive oxygen species contributed more compared with reactive nitrogen species. Functional group analysis confirmed the effective bioconversion of the macromolecular organics during the fermentation. Moreover, the nitrate photolysis enhanced the enrichment of the functional consortia, including anaerobic fermentation bacteria (AFB), e.g., Fnoticella, Romboutsia, Gracilibacter and Sedimentibacter, and nitrate reducing bacteria (NRB), e.g., Acinerobacter and Ahniella. The macrogenetic analysis further revealed that glycolysis, amino acid metabolism, acetate metabolism and nitrogen metabolism were the dominating metabolic pathways during fermentation, and the abundance of the relevant genes were enhanced in 150N-UV group.

Promoting short-chain fatty acids production from sewage sludge via acidogenic fermentation: Optimized operation factors and iron-based persulfate activation system

Promoting short-chain fatty acids (SCFAs) production and ensuring the stability of SCFAs-producing process are becoming the two major issues for popularizing the acidogenic fermentation (AF). The key controlling operating and influencing factors during anaerobic fermentation process were thoroughly reviewed to facilitate better process performance prediction and to optimize the process control of SCFAs promotion. The wide utilization of iron salt flocculants during wastewater treatment could result in iron accumulating in sewage sludge which influenced AF performance. Additionally, appropriate ferric chloride (FC) could promote the SCFAs accumulation, while poly ferric sulfate (PFS) inhibited the bioprocess. Iron/persulfate (PS) system was proved to effectively enhance the SCFAs production while mechanism analysis revealed that the strong oxidizing radicals remarkably enhanced the solubilization and hydrolysis. Moreover, the changes of oxidation-reduction potential (ORP) and pH caused by iron/PS system exhibited more negative effects on the methanogens, comparing to the acidogenic bacteria. Furthermore, performance and mechanisms of different iron species-activating PS, organic chelating agents and iron-rich biochar derived from sewage sludge were also elucidated to extend and strengthen understanding of the iron/PS system for enhancing SCFAs production. Considering the large amount of generated Fe-sludge and the multiple benefits of iron activating PS system, carbon neutral wastewater treatment plants (WWTPs) were proposed with Fe-sludge as a promising recycling composite to improve AF performance. It is expected that this review can deepen the knowledge of optimizing AF process and improving the iron/PS system for enhancing SCFAs production and provide useful insights to researchers in this field.

A hyperthermophilic anaerobic fermentation platform for highly efficient short chain fatty acids production from thermal hydrolyzed sludge

In this study, a carboxylate platform of hyperthermophilic (70 ℃) anaerobic fermentation (HAF) for short chain fatty acids (SCFAs) production from thermal hydrolyzed sludge (THS) was established. The long-term performance for SCFAs production and the microbial communities of this HAF under different SRTs were systematically investigated. Under the optimum SRT of 3 d, the HAF had the highest acetate production rate of 1.12 g COD/L/d which accounted for 60% in SCFAs. It also rendered a good performance in SCFAs production, with concentration, production rate and yield of 6.61 g COD/L, 1.86 g COD/L/d and 324 g COD/kg VSSin, respectively. Nearly no biogas produced from this system, which reduced the loss of carbon sources from the system. This was due to the inhibition of methanogenesis by the hyperthermophilic condition and the high content of total ammonia nitrogen (TAN) and free ammonia nitrogen (FAN). Tepidimicrobium, Bhargavaea and XBB1006 were the dominant genus-level biomarkers under the optimum SRT, which facilitated the decomposition of monosaccharides, amino acids, terpenoids and polyketides into SCFAs. This work provides an applicable anaerobic carboxylate platform for highly efficient SCFAs production from excess sludge.

EDTA-enhanced alkaline anaerobic fermentation of landfill leachate-derived waste activated sludge for short-chain fatty acids production: Metals chelation and EPSs destruction

Alkaline anaerobic fermentation (AAF) of waste activated sludge (WAS) has been demonstrated to be promising for short-chain fatty acids (SCFAs) recovery. However, high-strength metals and EPSs in the landfill leachate-derived WAS (LL-WAS) would stabilize its structure, suppressing AAF performance. To improve sludge solubilization and SCFAs production, AAF was coupled with EDTA addition for LL-WAS treatment. The results show that sludge solubilization at AAF-EDTA was promoted by 62.8% than AAF, releasing 21.8% more soluble COD. The maximal SCFAs production of 477.4 mg COD/g VSS was thus achieved, i.e., 1.21 and 6.13 times those at AAF and the control, respectively. SCFAs composition was also improved with more acetic and propionic acids (80.8% versus 64.3%). Metals bridging EPSs were chelated by EDTA, which significantly dissolved metals from sludge matrix (e.g., 23.28 times higher soluble Ca than AAF). EPSs tightly bound with microbial cells were thus destructed (e.g., 4.72 times more protein release than alkaline treatment), causing an easier sludge disruption and subsequently a higher SCFAs production by hydroxide ions. These findings suggest an effective EDTA-supported AAF for metals and EPSs-rich WAS to recover carbon source.

Integrated microbial electrolysis with high-alkali pretreated sludge digestion: Insight into the effect of voltage on methanogenesis and substrate metabolism

Integrated microbial electrolysis with anaerobic digestion is proved to be an effective way to improve methanogenesis efficiency of waste activated sludge (WAS). WAS requires pretreatment for efficient improvement of acidification or methanogenesis efficiency, but excessive acidification may inhibit the methanogenesis. In order to balance these two stages, a method for efficient WAS hydrolysis and methanogenesis has been proposed in this study by high-alkaline pretreatment integrated with microbial electrolysis system. The effects of pretreatment methods and voltage on the normal temperature digestion of WAS have also been further investigated with emphasis on the effects of voltage and substrate metabolism. The results show that compared to low-alkaline pretreatment (pH = 10), high-alkaline pretreatment (pH > 14) can double the SCOD release and promote the VFAs accumulation to 5657 ± 392 mg COD/L, but inhibit the methanogenesis process. Microbial electrolysis can alleviate this inhibition effectively through the rapid consumption of VFAs and speeding up of the methanogenesis process. The optimal methane yield of the integrated system is 120.4 ± 8.4 mL/g VSS at the voltage of 0.5 V. Enzyme activities, high-throughput and gene function prediction analysis reveal that the cathode and anode maintain the activity of methanogens under high substrate concentrations. Voltage positively responded to improved methane yield from 0.3 to 0.8 V, but higher than 1.1 V is found to be unfavorable for cathodic methanogenesis and results in additional power loss. These findings provide a perspective idea for rapid and maximum biogas recovery from WAS.

Zinc pyrithione induced volatile fatty acids promotion derived from sludge anaerobic digestion: Interrelating the affected steps with microbial metabolic regulation and adaptive responses

The massive use of zinc pyrithione (ZPT, as broad-spectrum bactericides) resulted in its high levels in waste activated sludge (WAS) and affected subsequent WAS treatment. This work revealed the effects of ZPT on the volatile fatty acids (VFAs) during WAS anaerobic digestion, in which VFAs yield was enhanced by approximately 6-9 folds (from 353 mg COD/L in control to 2526-3318 mg COD/L with low level of ZPT (20-50 mg/g TSS)). The ZPT occurred in WAS enabled the acceleration of solubilization, hydrolysis and acidification processes while inhibited the methanogenesis. Also, the low ZPT contributed to the enrichment of functional hydrolytic-acidifying microorganisms (e.g., Ottowia and Acinetobacter) but caused the reduction of methanogens (e.g., Methanomassiliicoccus and Methanothrix). Meta-transcriptomic analysis demonstrated that the critical genes relevant to extracellular hydrolysis (i.e. CLPP and ZapA), membrane transport (i.e. gltI, and gltL), substrates metabolisms (i.e. fadj, and acd), and VFAs biosynthesis (i.e. porB and porD) were all upregulated by 25.1-701.3% with low level of ZPT. Specifically, the ZPT stimulus on amino acids metabolism for VFAs transformation was prominent over carbohydrates. Moreover, the functional species enabled to regulate the genes in QS and TCS systems to maintain favorable cell chemotaxis to adapt the ZPT stress. The cationic antimicrobial peptide resistance pathway was upregulated to blunt ZPT with the secretion of more lipopolysaccharide and activate proton pumps to maintain ions homeostasis to antagonize the ZPT toxicity for high microbial activities, the abundance of related genes was up-regulated by 60.5 to 524.5%. This work enlightened environmental behaviors of emerging pollutants on WAS anaerobic digestion process with interrelations of microbial metabolic regulation and adaptive responses.

The coupling system of magnetite-enhanced thermophilic hydrolysis-acidification and denitrification for refractory organics removal from anaerobic digestate food waste effluent (ADFE)

The aim of this study was to remove the refractory organics from high-temperature anaerobic digestate food waste effluent by the coupling system of hydrolysis-acidification and denitrification. Iron-based materials (magnetite, zero-valent iron, and iron-carbon) were used to enhance the performance of thermophilic hydrolysis-acidification. Compared with the control group, magnetite had the best strengthening effect, increasing volatile fatty acids concentration and fluorescence intensity of easily biodegradable organics in the effluent by 47.6 % and 108.4 %, respectively. The coupling system of magnetite-enhanced thermophilic hydrolysis-acidification and denitrification achieved a nitrate removal efficiency of 91.2 % (influent NO₃^--N was 150 mg L^-1), and reduced the fluorescence intensity of refractory organics by 33.8 %, compared with influent. Microbiological analysis indicated that magnetite increased the relative abundance of thermophilic hydrolytic acidifying bacteria, and coupling system enriched some genera simultaneously removing nitrate and refractory organics. This study provided fresh information on refractory organics and nitrogen removal of thermophilic wastewater biologically.

Simultaneous recovery of vivianite and produce short-chain fatty acids from waste activated sludge using potassium ferrate as pre-oxidation treatment

Recovery resources from waste active sludge (WAS) is an effective way to alleviate the predicament of WAS disposal, and it is also conducive to the carbon neutralization of wastewater treatment systems. This study discussed the strategy of WAS anaerobic fermentation after pre-oxidation with potassium ferrate (K₂FeO₄, PF), which can simultaneously recover vivianite and enhance SCFAs production. The results showed that PF pre-oxidation considerably shortened the fermentation time of SCFAs to 2 days, and the main Fe-P mineral was vivianite. The optimal PF dosage of 0.06 g Fe (VI)/g TSS for pre-oxidation WAS resulted in the maximum SCFAs production and vivianite recovery rate of 3698.2 ± 118.98 mg COD/g VSS and 32.39%, respectively. The mechanism analysis showed that the oxidizing properties of PF significantly accelerated the disintegration of tight EPS, release of protein and sludge acidification efficiency. Moreover, the PF strengthened the transfer of P to the solid phase, forming the Fe-P mineral and unsaturated coordination state of phosphate group. Then the key microorganism Geobacter reduced the Fe³⁺ in Fe-P state to Fe²⁺ and combined unsaturated phosphate to form vivianite. This study provides an alternative method for resource recovery and environmentally friendly disposal of WAS and contributes to the carbon neutrality of urban water systems.

Stepwise freezing-thawing treatment promotes short-chain fatty acids production from waste activated sludge

Waste activated sludge (WAS), as the byproducts of wastewater treatment plants, has been greatly produced. With high cost and environmental risk of WAS disposal, to explore a low-cost and environment-friendly technology has been a great challenge. Considering that WAS is a collection of organic matters, anaerobic fermentation has been selected as a sustainable way to simultaneously recover resources and reduce environmental pollution. To recover short-chain fatty acids (SCFAs) has gained great concern because of the high value-added application and high-efficiency production process. Considering the temperature in some areas of the world can reach to below 0 °C, this study proposed an efficient strategy, i.e., stepwise freezing and thawing treatment, to promote SCFAs production. The maximal production of SCFAs, i.e., 246 mg COD/g volatile suspended solid, was obtained with the shortened retention time of five days. Mechanistic studies showed that the solubilization of both extracellular polymeric substances (EPSs) and microbial cells could be accelerated, with the EPSs removal of 58.3% for proteins and 59.0% for polysaccharides. Also, the hydrolysis process was promoted to provide more substrates for subsequent acidogenisis, and the functional microorganisms, such as Romboutsia, Paraclostridium, Macellibacteroides and Conexibacter, were greatly enriched, with a total abundance of 26.2%. Moreover, compared to control, methanogenesis was inhibited at a shortened sludge retention time (e.g., five days), which benefited to the accumulation of SCFAs, but the methane production was increased by 25.2% at a longer sludge retention time (e.g., ten days). Thus, these findings of this work may provide some new solutions for the enhanced resource recovery from WAS, and further for carbon-neutral operation of wastewater treatment plants.

Efficient methane production from waste activated sludge and Fenton-like pretreated rice straw in an integrated bio-electrochemical system

Integrated microbial electrolysis cell-anaerobic digestion (MEC-AD) systems have demonstrated potential advantages for methane production in the presence of small amounts of residual inhibitors. In this study, a series of tests were conducted to analyse the acidification and methanogenesis performance of pretreated rice straw (RS) in anaerobic digestion (AD) and MEC-AD systems after the addition of Fenton-like reagents. The results indicated that the short-chain acids (SCFAs) accumulations reached 2284.64 ± 21.57 mg COD/L with a dosage ratio of 1/4 (g RS/g VSS sludge) in the MEC-AD system and that methane production increased by 63.8% compared with that of an individual AD system. In the interim, the net energy output reached 1.09 × 10³ J/g TCOD, which was 1.23 times higher than that of the AD system. The residual Fe³⁺/Fe²⁺ in the pretreatment reagent was capable of promoting acidification and methanogenesis in sludge and RS fermentation. The RS hydrolysis products could constrain methanogenesis, which can be mitigated by introducing an MEC. The microbiological analyses revealed that the MEC strongly increased the enrichment of hydrogenotrophic methanogens, especially Methanobacterium (61.16%). Meanwhile, the Syntrophomonas and Acetobacterium abundances increased to 2.81% and 2.65%, respectively, which suggested the reinforcement of acetogenesis and methanogenesis. Therefore, the enhanced hydrogenotrophic methanogens might have served as the key for enhancing the efficiency of methanogenesis due to the introduction of an MEC.

Stepwise alkaline treatment coupled with ammonia stripping to enhance short-chain fatty acids production from waste activated sludge

To recover resource from waste activated sludge (WAS) is of great significance. This study proposed a promising way, i.e., stepwise alkaline treatment coupled with ammonia stripping, to remarkably enhance short-chain fatty acids (SCFAs) production from WAS anaerobic digestion. The maximal production of SCFAs, with the value of 323 mg COD/g volatile suspended solid, was obtained with first initial pH = 10 adjustment followed by second initial pH = 10 adjustment on third day coupled with ammonia stripping. Mechanistic studies showed that solubilization of both extracellular polymeric substances and cells could be accelerated by stepwise initial pH = 10 adjustment. However, without ammonia stripping, the activities of either acidogens or methanogens could be inhibited by free ammonia formed under alkaline conditions; positively, anaerobes related to SCFAs production were enriched with ammonia stripping. Moreover, the proposed strategy can simultaneously achieve nitrogen and carbon recovery, providing some solutions for the carbon-neutral operation of wastewater treatment plants.

Enhanced degradation of glucocorticoids, a potential COVID-19 remedy, by co-fermentation of waste activated sludge and animal manure: The role of manure type and degradation mechanism

Waste activated sludge (WAS) and animal manure are two significant reservoirs of glucocorticoids (GCs) in the environment. However, GC degradation during anaerobic digestion (AD) of WAS or animal manure has rarely been investigated. In this study, co-fermentation of WAS and animal manure was conducted to investigate the performance of AD in controlling GC dissemination. Effects of manure type on GC degradation and sludge acidification were investigated. The results showed that co-fermentation of WAS and chicken manure (CM) significantly enhanced the degradation of hydrocortisone (HC) to 99%, betamethasone (BT) to 99%, fluocinolone acetonide (FA) to 98%, and clobetasol propionate (CP) to 82% in 5 days with a mixing ratio of 1:1 (g TS sludge/g dw manure) at 55 °C and initial pH of 7. Simultaneously, sludge reduction was increased by 30% and value-added volatile fatty acid (VFA) production was improved by 40%. Even a high GC content of biomass (3.6 mg/g TS) did not impact both sludge hydrolysis and acidification. The amendment of WAS with CM increased soluble organic carbon, Ca²⁺, and relative abundance of anaerobes (Eubacterium) associated with organic compound degradation. Furthermore, 44 transformation products of HC, BT, FA, and CP with lower lipophilicity and toxicity were identified, indicating possible degradation pathways including hydroxylation, ketonization, ring cleavage, defluorination, hydrogenation, methylation, and de-esterification. Overall, this study provides a practical way to control GC pollution and simultaneously promote waste reduction and VFA production. Animal manure type as an overlooked factor for influencing co-fermentation performance and pollutant degradation was also highlighted.

Synergistic pretreatment of CaO and freezing/thawing to enhance volatile fatty acids recycling and dewaterability of waste activated sludge via anaerobic fermentation

To avoid the generally deteriorated dewaterability of sludge in waste activated sludge (WAS) anaerobic acidogenesis, the combination of varied calcium oxide (CaO) dosage (i.e., 0.01-0.07 g/g TS) and freezing/thawing pretreatment (5 F/T cycles) was investigated for concurrently improving the production of volatile fatty acids (VFAs) and dewatering performance of sludge. The highest release of soluble chemical oxygen demand (SCOD) (1836 ± 96 mg/L) and accumulation of VFAs (448.0 mg COD/g VS) were reached through the co-pretreatment of CaO (0.07 g/g TS) and F/T (50 h at -24 °C) (i.e., 0.07 CaO-F/T). Meanwhile, optimal dewaterability of sludge was also achieved in 0.07 CaO-F/T co-pretreated WAS fermentation, which was reflected by large particle size (98.32 μm), low capillary suction time (41.6 s), decreased specific resistance to filtration (SRF, reduced 47.5% against blank) and high zeta potential (-9.59 mV). Co-pretreatment of CaO and F/T reduced the species number of total microbial population, but improved the abundance of acid-producing bacteria. Increased abundance of Bacteroides, Macellibacteroides, Petrimonas, Prevotella, Clostridium, and Megasphaera was positively relevant to the high yields of VFAs. The economic analysis indicated that CaO-F/T was economically acceptable with considerable estimated net profits, which provided a feasible and efficient alternative for further WAS treatment at large scale.

Response of anaerobic digestion of waste activated sludge to residual ferric ions

This study was conducted to investigate the effects of residual ferric ions (FI), released from iron or its oxides for wastewater or waste activated sludge (WAS) treatment, on anaerobic digestion of WAS. Herein it was found that the anaerobic digestion process was greatly affected by FI dosages as well as FI distributions. The responses of performance and microorganism suggested that a low FI (e.g., 0.125 mmol/g volatile suspended solid (VSS)) enhanced methane production by 29.3%, and a medium FI (e.g., 0.3 mmol/g VSS) promoted short chain fatty acids accumulation to reach the maximum of 247 mg chemical oxygen demand /g VSS, conversely, a high FI (e.g., 0.9 mmol/g VSS) led to severe inhibition on acidogenesis and methanogenesis. The findings may provide some new insights for mechanism understanding on anaerobic digestion process influenced by iron or its oxides, as well as the disposal of WAS contained FI.