Characteristics and antioxidant activity of water-soluble Maillard reaction products from interactions in a whey protein isolate and sugars system

Formation of low environment-sensitive whey protein isolate-dextran/chondroitin sulfate nanoparticles for cinnamaldehyde encapsulation and food preservation

Cinnamaldehyde is regarded as a secure antibacterial agent for various food matrices, but the volatility and insolubility restrict its application. Biopolymer nanoencapsulation was emerging as an effective tool to address these drawbacks. However, current nanoparticle fabrication methods enabled cinnamaldehyde protection and sustained release only under narrow pH ranges and low ionic strength, failing to provide simultaneous compatibility with the diverse pH and ionic strength variations encountered in complex food systems. Herein, whey protein isolates-dextran/ chondroitin sulfate (WPI-dextran/ChS) nanoparticles applicable to most of the food systems with varied pH (1-10) and salt level (0-2 mol/L) were obtained based on Maillard reaction and heat-induced gelation. Dynamic light scattering, encapsulation efficiency and loading capacity indicated that the nanoparticles prepared from WPI-dextran conjugates with 3-day incubation exhibited relatively better dispersity and loading ability for cinnamaldehyde. Better antioxidant and antibacterial ability were also observed, with DPPH and ABTS radical scavenging rates of 55.08 % and 47.42 %, lipid peroxidation inhibiting activity of 48.24 %, and the antibacterial efficiency of 83 % and 89 % against E. coli and S. aureus, respectively. The excellent performance of cinnamaldehyde-loaded nanoparticles in preservation of sauced pork was corroborated by multiparametric analysis, which showed that the deterioration of sauced pork was significantly retarded.

A superior binary matrix of maltodextrin and whey protein concentrate for chia seed oil encapsulation through freeze-drying

The present study was designed to evaluate and compare the efficiency of two wall material (WM) matrices-maltodextrin (MD) and gum Arabic (GA) in combination with whey protein concentrate (WPC) for encapsulating chia seed oil (CSO). RSM, a robust and widely recognized optimization tool, was employed to optimize independent parameters: WM ratio (MD-WPC or GA-WPC) (0 to 100%), homogenization pressure (69-207 MPa), and oil content (6-10%). A modified rotatable central composite design with replicated factorial points ensured non-fractional factor levels to study variable interactions on encapsulation efficiency (EE) and α-Linolenic acid (ALA) retention. Optimized CSO microcapsule [OCSO I (MD-WPC)] exhibited EE (81.23%), higher ALA (61.85%) and Ω-3: Ω-6 ratio (3.44) than OCSO II (GA-WPC) under the same optimized conditions. The optimal conditions were; MD/GA:WPC ratio (25%), pressure (172.5 MPa), and oil content (9%). Microcapsule OCSO I demonstrated superior oxidative stability with a significantly (p < 0.05) longer shelf life (24-26 days) compared to OCSO II (16-18 days) and achieved significantly (p < 0.05) higher CSO delivery in the intestinal phase. FTIR analysis confirmed encapsulation integrity, showing low or no peaks associated with free CSO. These findings provide valuable insights for the industry in selecting innovative, economical, and effective WMs for encapsulating bioactive CSO.

Changes in the flavor formation and sensory attributes of Maillard reaction products by different oxidation degrees of beef tallow via cold plasma

It remains unclear how the oxidation degree of animal fat affects the flavor formation and sensory attributes of Maillard reaction products (MRPs). To oxidize beef tallow differentially under mild conditions, an atmospheric pressure cold plasma (APCP) was applied due to its easy, economical, and controllable manipulation and effectiveness. As the duration of APCP increased after 10 min, the oxidation degree of beef tallow increased significantly (p < 0.05). The beef tallow was incorporated into the cysteine-xylose model system and heated at 120 °C for 90 min. Volatiles from lipid oxidation products increased, whereas sulfur-containing compounds decreased significantly when the model included APCP-treated beef tallow (p < 0.05). MRPs with 10-min APCP-treated beef tallow showed reduced off-odor (p < 0.05). Thus, moderate APCP treatment to beef tallow may be beneficial for sensory attributes of MRPs. It suggests the potential of APCP to improve the flavor of heat-sensitive foods by controlling lipid oxidation.

Effect of ultrasound-assisted Maillard reaction on glycosylation of goat whey protein: Structure and functional properties

Goat whey protein (GWP) has a rich amino acid profile and good techno-functional attributes but still has limited functional performance for certain applications. This study introduces an innovative ultrasound-assisted Maillard reaction to enhance GWP's functional properties by conjugating it with either gum Arabic (GA) or citrus pectin (CP). Sonication accelerated the Maillard reaction, and the glycosylation of GWP was significantly enhanced after optimization of the conjugation conditions. Gel electrophoresis examination verified the creation of GWP-polysaccharide conjugates, while scanning electron microscopy analysis revealed structural modifications caused by polysaccharide grafting and sonication. The use of ultrasound in the Maillard reaction notably enhanced the solubility, foaming capacity, and emulsifying attributes of the GWPs. Among the conjugates, the GWP-GA ones exhibited the best functional properties. Our findings suggest that this approach can notably improve the functional attributes of GWPs, thus broadening their potential uses in the food sector and beyond.

Pulsed electric field enhances glucose glycation and emulsifying properties of bovine serum albumin: Focus on polarization and ionization effects at a high reaction temperature

Previous studies demonstrated that the non-thermal effects of pulsed electric fields can promote protein glycation below 40 °C, but it does not always enhance the emulsifying properties of proteins, such as in the bovine serum albumin/glucose model. Therefore, the aim of this study was to investigate the impact of non-thermal effects on the glucose glycation and emulsification properties of bovine serum albumin at 90 °C. The results of circular dichroism, surface hydrophobicity, and molecular dynamics simulations showed that the polarization effect increased the degree of glycation of bovine serum albumin-glucose conjugates from 12.82 % to 21.10 % by unfolding protein molecule, while the emulsifying stability index was increased from 79.17 to 100.73 compared with the control. Furthermore, the results of principal component analysis and Pearson correlation analysis indicated that the ionization effect and the free radicals generated by pulsed electric fields significantly (p < 0.05) inhibited browning and reduced free sulfhydryl content. This study demonstrated that pulsed electric fields combined with heating can prepare glycated proteins with good emulsifying properties in a short period of time and at temperatures lower than conventional heating while reducing energy consumption. This processing strategy has potential applications in improving the emulsifying performance of highly stable proteins.

Physicochemical and functional property of the Maillard reaction products of soy protein isolate with L-arabinose/D-galactose

BACKGROUND

Soy protein isolate (SPI) is widely used in the food industry because of its nutritional and functional properties. During food processing and storage, the interaction with co-existing sugars can cause changes in the structural and functional properties of SPI. In this study, SPI-l-arabinose conjugate (SPI:Ara) and SPI-d-galactose conjugate (SPI:Gal) were prepared using Maillard reaction (MR), and the effects of five-carbon/six-carbon sugars on the structural information and function of SPI were compared.

RESULTS

MR unfolded and stretched the SPI, changing its ordered conformation into disorder. Lysine and arginine of SPI were bonded with the carbonyl group of sugar. The MR between SPI and l-arabinose has a higher degree of glycosylation compared to d-galactose. MR of SPI enhanced its solubility, emulsifying property and foaming property. Compared with SPI:Ara, SPI:Gal exhibited better aforementioned properties. The functionalities of amphiphilic SPI were enhanced by MR, SPI:Gal possessed better hypoglycemic effect, fat binding capacity and bile acid binding ability than SPI:Ara. MR endowed SPI with enhanced biological activities, SPI:Ara showed higher antioxidant activities, and SPI:Gal exhibited stronger antibacterial activities.

CONCLUSION

Our work revealed that l-arabinose/d-galactose exhibited different effects on the structural information of SPI, and further affected its physicochemical and functional property. © 2023 Society of Chemical Industry.

Formation, Evolution, and Antioxidant Activity of Melanoidins in Black Garlic under Different Storage Conditions

Melanoidins (MLDs) are formed through the reaction of carbonyl compounds and amino compounds in the Maillard reaction (MR) during the heating or storage of food. In this study, the formation, chemical composition, and structural characteristics of black garlic (BG) MLDs stored at different temperatures (4 °C, 20 °C, and 35 °C) over a period of 6 months were investigated. The initial products of the MR formed more often at 4 °C and 20 °C, while higher temperatures (35 °C) promoted the reaction in the middle and late stages of the MR. The higher temperature promoted an increase in molecular weight and MLD content, which can be attributed to the increase in protein and phenolic content. Elemental analysis confirmed an increase in nitrogen (N) content and the continuous incorporation of nitrogen-rich substances into the skeleton. Amino acids, particularly aspartic acid and threonine, were the primary N-containing compounds involved in MLD formation. Additionally, the infrared analysis revealed that the changes in MLDs during storage were characterized by amide I and amide II groups. The MR enhanced the yields of heterocyclic compounds (from 56.60% to 78.89%), especially that of O-heterocyclic compounds, at the higher temperature according to Py-GC-MS analysis. Furthermore, the higher temperature enhanced the molecular weight, maximum height, and roughness of MLDs compared to the control. The antioxidant ability of MLDs was positively correlated with storage temperatures. In summary, temperature had an impact on the formation, evolution, and antioxidant activity of MLDs.

Effect of Maillard Reaction Products Derived from Cysteine on the Formation of Dimethyl Disulfide and Dimethyl Trisulfide during Storage

The effect of Maillard reaction products derived from cysteine on dimethyl disulfide (DMDS) and dimethyl trisulfide (DMTS) was evaluated in the ternary mixture (methionine, cysteine, and xylose) and binary mixture (methionine and 2-threityl-thiazolidine-4-carboxylic acid) during 56 days storage. Changes in concentrations revealed that the methionine/cysteine/xylose model showed lower concentrations of DMDS and DMTS than those of the binary mixture. Antioxidant ability and labeled isotopomer proportion information indicated that low levels of DMDS and DMTS in the ternary mixture were attributed to not only 2-furfurylthiol and 2-methyl-3-furanthiol (MFT) reacting with methanethiol but also the ternary mixture having stronger antioxidant activity. Correlation analysis demonstrated that MFT reacting with methanethiol and strong antioxidant ability are considered major factors controlling the formation of DMTS and DMDS, respectively. Research on the reaction mechanism of the rate-limiting step would provide the basis for preventing the development of DMDS and DMTS during storage.

Effect of Preheating Whey Protein Concentrate on the Stability of Purple Sweet Potato Anthocyanins

Anthocyanins (ANs) have strong antioxidant activities and can inhibit chronic diseases, but the instability of ANs limits their applications. The conservation of preheating whey protein concentrate (WPC) on the stability of purple sweet potato ANs was investigated. The retention of ANs in WPC-ANs was 85.88% after storage at 25 °C for 5 h. WPC-ANs had higher retention of ANs in heating treatment. The retention rates of ANs in WPC-ANs exposed to light and UV lamps for 6 h were 78.72% and 85.76%, respectively. When the concentration of H2O2 was 0.50%, the retention rate of ANs in the complexes was 62.04%. WPC-ANs' stability and antioxidant activity were improved in simulated digestive juice. The WPC-ANs connection was static quenching, and the binding force between them was a hydrophobic interaction at one binding site, according to the fluorescence quenching spectroscopy. UV-visible absorption spectroscopy and Fourier transform infrared spectroscopy (FTIR) analysis further indicated that the secondary structure and microenvironment of amino acid residues in WPC can be impacted by the preheating temperature and preheating times of WPC. In conclusion, preheating WPC can successfully preserve the stability of purple sweet potato ANs by binding to them through a non-covalent interaction.

Characteristics and Functional Properties of Maillard Reaction Products from α-Lactalbumin and Polydextrose

The characteristics and the functions of Maillard reaction products (MRPs) produced by polydextrose (PD), a new type of prebiotic, and α-lactalbumin (α-LA) were valued. PD and α-LA were incubated at 60 °C and 79% relative humidity for up to 72 h to prepare MRPs. The results showed that the absorbance and fluorescence intensity of heated α-LA-PD increased, and the amount of free amino groups reduced as the reaction progressed, which confirmed the formation of different stages of MRPs. Electrophoresis revealed an increase in molecular mass and the degree of covalent cross-linking. The secondary structure of MRPs experienced no significant changes with the measurement of circular dichroism (CD), while the tertiary structure gradually unfolded, exposing hydrophobic groups. Furthermore, a significant increase was detected in the radical-scavenging activity of 2,2-diphenyl-1-picrylhydrazyl (DPPH) and the ferric reducing/antioxidant power (FRAP) of MRPs. The findings offer a foundation for understanding the structural and functional features of MRPs in formula milk powder.

Changes in Physicochemical Characteristics and Antioxidant Activities of Dried Shiitake Mushroom in Dry-Moist-Heat Aging Process

Shiitake mushrooms are prized for their unique flavor and bioactive properties. While there has been extensive research on drying methods, a comprehensive investigation of the effects of drying parameters in the dry-moist-heat system on shiitake quality is still needed. This study aimed to investigate the effects of dry-moist-heat aging on dried shiitake mushrooms comprehensively. Four aging temperatures, specifically 50, 60, 70, and 80 °C, were applied to the mushrooms, maintaining a constant humidity level of 75% RH and aging duration of 20 days. Color analysis revealed a progressive decrease in measured values as aging temperature increased, indicating noticeable changes in visual characteristics. Regarding amino acid composition, glutamic acid was found to be the predominant amino acid in shiitake mushrooms in the range of 90.29-467.42 mg/100 g. However, aging led to a reduction in overall amino acid content, with higher aging temperatures resulting in greater decline. Similarly, the equivalent umami content (EUC) also decreased (from 123.99 to 7.12 g MSG/100 g) with the increase in aging temperatures up to 80 °C, suggesting a decline in the overall umami taste sensation. Interestingly, despite the reduction in amino acid levels and umami content, the aging process positively impacted the phenolic compounds and the antioxidant activity of dried shiitake mushrooms. The antioxidative abilities of all aged mushroom extracts for DPPH, ABTS, and FRAP ranged from 65.01 to 81.39 µg TE/mL, 87.04 to 258.33 µg GAE/mL, and 184.50 to 287.68 µg FeSO₄/mL, respectively. The utilization of aged temperature at 60 °C for 20 days with controlled relative humidity (~75%) should be a suitable aging condition of this edible mushroom with both antioxidant and umami qualities. Nevertheless, the control sample demonstrated higher levels of amino acid content and EUC compared to the aged samples. Conversely, the aged samples exhibited higher polyphenol content and greater antioxidant activity. Depending on specific requirements, these powders can be used in food formulation as flavor enhancers for control samples or as enriching agents for polyphenols and antioxidant activity in matured samples. Therefore, all of the powders obtained have potential applications in the field of nutrition.

Ultrasound-assisted formation of chitosan-glucose Maillard reaction products to fabricate nanoparticles with enhanced antioxidant activity

The influence of ultrasonic processing parameters including reaction temperature (60, 70 and 80 °C), time (0, 15, 30, 45 and 60 min) and amplitude (70, 85 and 100%) on the formation and antioxidant activity of Maillard reaction products (MRPs) in a solution of chitosan and glucose (1.5 wt% at mass ratio of 1:1) was investigated. Selected chitosan-glucose MRPs were further studied to determine the effects of solution pH on the fabrication of antioxidative nanoparticles by ionic crosslinking with sodium tripolyphosphate. Results from FT-IR analysis, zeta-potential determination and color measurement indicated that chitosan-glucose MRPs with improved antioxidant activity were successfully produced using an ultrasound-assisted process. The highest antioxidant activity of MRPs was observed at the reaction temperature, time and amplitude of 80 °C, 60 min and 70%, respectively, with ∼ 34.5 and ∼20.2 μg Trolox mL^-1 for DPPH scavenging activity and reducing power, respectively. The pH of both MRPs and tripolyphosphate solutions significantly influenced the fabrication and characteristics of the nanoparticles. Using chitosan-glucose MRPs and tripolyphosphate solution at pH 4.0 generated nanoparticles with enhanced antioxidant activity (∼1.6 and ∼ 1.2 μg Trolox mg^-1 for reducing power and DPPH scavenging activity, respectively) with the highest percentage yield (∼59%), intermediate particle size (∼447 nm) and zeta-potential ∼ 19.6 mV. These results present innovative findings for the fabrication of chitosan-based nanoparticles with enhanced antioxidant activity by pre-conjugation with glucose via the Maillard reaction aided by ultrasonic processing.

The Antioxidant Activity and Protection of Probiotic Bacteria in the In Vitro Gastrointestinal Digestion of a Blueberry Juice and Whey Protein Fermentation System

Blueberries have received great attention due to the health effects of their bioactive compounds, such as antioxidant, antitumor, and anti-obesity properties. Probiotics also have these health-promoting benefits. However, these biological activities may be affected by the processs of gastrointestinal digestion, which decreases their functionality. This study aimed to use a more convenient method to improve the blueberries’ antioxidant activity and protective effects on probiotic cells by fermentation with whey protein, and to explore the possible mechanisms underlying these effects. This result showed that the total phenolic content, anthocyanin content, reducing power, DPPH radical scavenging capacity, and probiotic cells’ survival in a blueberry juice and whey protein fermentation system were enhanced in a model of in vitro gastrointestinal digestion. The bioactive compounds in blueberry juice interacted with whey protein, as shown through FTIR. The stability of phenolic compounds was enhanced, and the release of functional compounds in the mixture fermentation system was delayed through CLSM. Interactions between bioactive compounds in blueberries, whey protein, and bacterial surface proteins, glycoproteins or polysaccharides during fermentation were studied by SDS-PAGE. Thus, the stability of bioactive activities in the mixed system after fermentation was strengthened by the interaction. The mixed fermentation system has promising potential for improving antioxidant activity and protecting probiotic cells.

Characterization and utilization of soy protein isolate-(-)-epigallocatechin gallate-maltose ternary conjugate as an emulsifier for nanoemulsions: Enhanced physicochemical stability of the β-carotene nanoemulsion

In this study, a ternary conjugate was prepared by covalent bonding of protein, polysaccharide, and polyphenol via ultrasound and the Maillard reaction. Subsequently, the β-carotene nanoemulsion was prepared with the soy protein isolate-(-)-epigallocatechin gallate-maltose (SPI-EGCG-maltose) conjugate as the emulsifiers via ultrasound. The SPI-EGCG-maltose conjugate showed superior solubility, emulsification and foaming properties at 4 h reaction time. Meanwhile, the retention rates of β-carotene in the nanoemulsion after 30 d of storage, 8 h of light, and 55 °C of heat were >60%, >75%, and >60%, respectively. Furthermore, ultrasound treatment at 500 W for 10 min produced an inhibitory effect on the degradation of β-carotene. This study indicates that the nanoemulsion based on the ternary conjugate can effectively inhibit the β-carotene degradation by the external environment and prevent the oxidation and degradation of β-carotene in the nanoemulsion.

Partial substitution of whey protein concentrate by zein in high-protein nutrition bars: An effective method to reduce hardening during storage

Whey protein concentrate-based high-protein nutrition bars (WPC-based HPN bars) are prone to hardening during storage, which limits their shelf life. In this study, zein was introduced to partially substitute WPC in the WPC-based HPN bars. The result of storage experiment revealed that the hardening of WPC-based HPN bars was significantly reduced with increasing zein content from 0% to 20% (mass ratio, zein:WPC-based HPN bar). Subsequently, the possible anti-hardening mechanism of zein substitution was studied in detail by determining the change in microstructure, patterns, free sulfhydryl group, color, free amino group, and Fourier transform infrared spectra of WPC-based HPN bars during storage. The results showed that zein substitution significantly blocked protein aggregation by inhibiting cross-linking, the Maillard reaction, and protein secondary structure transformation from α-helix to β-sheet, which reduced the hardening of WPC-based HPN bars. This work provides insight into the potential utilization of zein substitution to improve the quality and shelf life of WPC-based HPN bars. PRACTICAL APPLICATION: In the preparation of whey protein concentrate-based high-protein nutrition bars, the introduction of zein to partially replace WPC can effectively reduce the hardening of WPC-based HPN bars during storage by preventing protein aggregation between WPC macromolecules. Therefore, zein could act as an agent to reduce the hardening of WPC-based HPN bars.

Investigation of Structural Characteristics and Solubility Mechanism of Edible Bird Nest: A Mucin Glycoprotein

In this study, the possible solubility properties and water-holding capacity mechanism of edible bird nest (EBN) were investigated through a structural analysis of soluble and insoluble fractions. The protein solubility and the water-holding swelling multiple increased from 2.55% to 31.52% and 3.83 to 14.00, respectively, with the heat temperature increase from 40 °C to 100 °C. It was observed that the solubility of high-Mw protein increased through heat treatment; meanwhile, part of the low-Mw fragments was estimated to aggregate to high-Mw protein with the hydrophobic interactions and disulfide bonds. The increased crystallinity of the insoluble fraction from 39.50% to 47.81% also contributed to the higher solubility and stronger water-holding capacity. Furthermore, the hydrophobic interactions, hydrogen bonds, and disulfide bonds in EBN were analyzed and the results showed that hydrogen bonds with burial polar group made a favorable contribution to the protein solubility. Therefore, the crystallization area degradation under high temperature with hydrogen bonds and disulfide bonds may be the main reasons underlying the solubility properties and water-holding capacity of EBN.

Changes in partial properties of glycosylated egg white powder during storage

BACKGROUND

Glycosylation is an effective method to modify protein. However, there is a lack of research on the property changes of glycosylated protein during storage. In the present study, the changes in the physicochemical, functional, and structural properties of xylo-oligosaccharide (XOS) glycosylated egg white powder (EWP) (XOS-EWP conjugates) prepared with different glycosylation conditions (XOS/EWP ratio and reaction time) were investigated when stored at 25 °C and 60% relative humidity.

RESULTS

In the 12 weeks of storage, the degree of grafting, browning, and the formation of Maillard reaction products of XOS-EWP conjugates increased. The increase in XOS/EWP ratio and reaction time led to an increase in protein aggregation, though a decrease in solubility, due to increased degree of glycosylation and structural changes. Furthermore, improved gel hardness of XOS-EWP conjugates deteriorated, while improved emulsification ability was kept stable during storage. For the sample with a lower XOS/EWP ratio and reaction time, the gel hardness and emulsifying properties underwent little or no deterioration even improving during storage. The results could be attributed to the limited degree of glycosylation, further unfolding of the protein structure, increased surface hydrophobicity of protein, and improved thermal characteristics.

CONCLUSION

During storage, the Maillard reaction would continue to occur in the glycosylated EWP, further affecting the performance of modified EWP. Modified EWP prepared under different glycosylation conditions performed differently during storage. Modified EWP with a larger XOS/EWP ratio and reaction time meant it was harder to maintain good performance. Modified EWP with a smaller XOS/EWP ratio and reaction time changed significantly to better performances. © 2022 Society of Chemical Industry.

Antioxidant Activity and Cell Protection of Glycosylated Products in Different Reducing Sugar Duck Liver Protein Systems

Duck liver is an important by-product of duck food. In this study, we investigated the effects of glucose, fructose, and xylose on the antioxidant properties of glycosylated products of duck liver protein and their protective effects on HepG2 cells. The results show that the glycosylation products of the three duck liver proteins (DLP-G, DLP-F, and DLP-X) all exhibit strong antioxidant activity; among three groups, DLP-X shows the strongest ability to scavenge DPPH, ·OH free radicals, and ABTS⁺ free radicals. The glycosylated products of duck liver protein are not toxic to HepG2 cells and significantly increase the activity of antioxidant enzymes such as SOD, CAT, and GSH-Px in HepG2 cells at the concentration of 2.0 g/L, reducing oxidative stress damage of cells (p < 0.05). DLP-X has a better effect in reducing oxidative damage and increasing cellular activity in HepG2 cells than DLP-G and DLP-F (p < 0.05). In this study, the duck liver protein glycosylated products by glucose, fructose, and xylose were named as DLP-G, DLP-F, and DLP-X, respectively.

Insights into the effects of extractable phenolic compounds and Maillard reaction products on the antioxidant activity of roasted wheat flours with different maturities

Experiments were performed to determine the effect of roasting whole wheat flours at 80 °C, 100 °C and 120 °C for 30 min on four forms of phenolics, Maillard reaction products (MRPs), and the DPPH scavenging activity (DSA) at 15, 30 and 45 days after flowering (15-DAF, 30-DAF, and 45-DAF). Roasting increased the phenolic content and antioxidant activity of the wheat flours, which were the dominant contributions to the formation of Maillard reaction products. The highest total phenolic content (TPC) and total phenolic DSA (TDSA) were determined in the DAF-15 flours at 120 °C/30 min. The DAF-15 flours exhibited the highest browning index and fluorescence of free intermediate compounds and advanced MRPs, suggesting that a substantial quantity of MRPs were formed. Four forms of phenolic compounds were detected with significantly different DSAs in the roasted wheat flours. The insoluble-bound phenolic compounds exhibited the highest DSA, followed by the glycosylated phenolic compounds.

Formation of Amadori compounds in LIGAO (concentrated pear juice) processing and the effects of Fru-Asp on cough relief and lung moisturization in mice

LIGAO (concentrated pear juice) has been used for more than 1000 years to treat respiratory complaints such as cough and expectoration in China, but the study of the mechanism of its antitussive effects and ability to moisten the lungs is limited. This study found that the content of Amadori compounds (ACs) and other nutrients changed during LIGAO processing. Furthermore, N-(1-deoxy-D-fructos-1-yl)-aspartic acid (Fru-Asp), the most abundant and characteristic AC in LIGAO, was prepared and studied. The antitussive test revealed that Fru-Asp could significantly reduce the frequency of cough and prolong the cough latent period in mice. A high dose of Fru-Asp (250 mg kg^-1) in mice provided better therapeutic activities than that of dextromethorphan hydrobromide tablets (30 mg kg^-1). In the Fru-Asp pretreated group, Fru-Asp significantly alleviated inflammation in LPS-induced acute lung injury mice. Fru-Asp can significantly decrease the levels of TNF-α and IL-β in mice by 11%. Additionally, Fru-Asp exhibited angiotensin-converting enzyme (ACE) inhibitor activity (IC₅₀ = 0.242 mM). The contribution and health benefits of Fru-Asp on cough relief were first reported in this study, which also substantiated it as a functional component of LIGAO. The results provided the basis for future research on the health effects of ACs and a method to improve the added value of LIGAO and other pear products.

Dextran Conjugation Improves the Structural and Functional Properties of Heat-Treated Protein Isolate from Cinnamomum camphora Seed Kernel

The Cinnamomum camphora seed kernel (CCSK), with high contents of medium-chain oil (~59%) and protein (~19%), is an excellent source for a plant-based food ingredient. To broaden the application of the protein isolate (PI) from CCSK in the food industry, the Maillard reaction products (MRPs) were prepared by PI and dextran (DX) under mild wet-heating conditions (60 °C, 5 h), and the structural and functional properties of the PI-DX conjugates were investigated. The covalent bond between PI and DX was confirmed by the degree of grafting and sodium dodecyl sulfate-polyacrylamide gel electrophoresis. Compared with the heated PI, the PI-DX conjugates had more ordered structure, with the decreased random coil content. The changes in tertiary structure of PI-DX conjugates were reflected by the results of intrinsic fluorescence and surface hydrophobicity. Moreover, PI-DX conjugates showed better solubility, emulsifying properties, thermal stability and antioxidant activities. These results provided a theoretical basis for the development of PI-based MRPs with desirable characteristics.

Lactose crystallization and Maillard reaction in simulated milk powder based on the change in water activity

Maillard reaction (MR) and lactose crystallization (LC) are important reactions in the storage of milk powder. In this study, three models with different proteins based on skimmed milk powder were established to investigate the relationship between MR and LC at different water activities (a_w ). Moisture sorption isotherm, glass transition temperature (T_g ), and glycation products were evaluated, and the protein structure and lactose crystallinity were determined. The results indicated that MR product content, browning, and LC subsequently enhanced with the increase in a_w . The T_g value dropped lower than 0 at a_w 0.43 in whey protein isolate-lactose (WP-Lac) model and at a_w 0.54 in casein-whey protein isolate-lactose (CN-WP-Lac) model and casein-lactose (CN-Lac) model. The crystallinity of α-lactose monohydrate and anhydrous β-lactose in WP-Lac model was more significant than CN-WP-Lac and CN-Lac models (p < 0.05). The molecular band of whey protein gradually blurred in the Sodium dodecyl-sulfate polyacrylamide gel electrophoresis image, and the content of α-helix of WP-Lac model increased by 45.15% from a_w 0.33 to 0.53 (p < 0.05), while that of CN-WP-Lac model increased by only 3.95% (p < 0.05). With the increase in a_w , WP-Lac model formed more browning and crystallization products than CN-WP-Lac model, indicating that the presence of micelle macromolecules and the interaction between casein and whey proteins limited the browning and crystallization in CN-WP-Lac model. Practical Application Maillard reaction and lactose crystallization are important reactions in the storage of milk powder, and the result will provide theoretical guidance for the development of milk powder in the food industry.

Changes in the structural and physicochemical properties of wheat gliadin and maize amylopectin conjugates induced by dry-heating

The Maillard reaction (MR) has been known to modify proteins and optimize their physicochemical properties by conjugating with reducing sugars. The structure and physicochemical properties of wheat gliadin and maize amylopectin conjugates induced by MR were investigated under different gliadin-amylopectin ratios (2:1, 1:1, 1:2, 1:4, and 1:8). The formation of conjugates was indicated by sodium dodecyl sulfate-polyacrylamide gel electrophoresis, degree of conjugation, and browning development analyses. The Fourier transform infrared and fluorescence spectroscopy analyses suggested changes in the structures of conjugates and the microenvironment of amino acids. A remarkable decrease in the β-turn structure content and an increase in the free sulfhydryl group content were observed at a ratio of 1:8, leading to decreased allergenicity. The reaction process was commendably controlled at a ratio of 1:1 with a 59.7% degree of conjugation in this group, contributing to the amelioration of solubility and foaming properties. Meanwhile, improvements in the oil holding capacity, surface hydrophobicity, and emulsifying properties were observed at a ratio of 1:4. PRACTICAL APPLICATION: The study revealed that the conjugates produced by MR might have various degrees of improved functional properties and reduced allergenicity at different ratios of substrates. Our study might be helpful for conjugates to assist in improving the texture of products and its potential in expanding the industrial application of products with gliadin.

Glycosylation with bioactive polysaccharide obtained from Rosa roxburghii Tratt fruit to enhance the oxidative stability of whey protein isolate emulsion

Whey protein isolate (WPI) is an excellent source of emulsifier, but its function is limited for oxidative unstable in emulsion. In this study, WPI was glycated with Rosa roxburghii Tratt fruit polysaccharides (RTFP) by Maillard reaction under optimum conditions. The sodium dodecyl sulfate-polyacrylamide gel electrophoresis profile confirmed the formation of WPI-RTFP conjugates. The intrinsic fluorescence spectrum, CD and FT-IR indicated that the structure of WPI was affected after glycated with RTFP. In addition, the antioxidant activity of WPI-RTFP conjugates and WPI-RTFP emulsion were 3.5-fold and 1.5-fold stronger than that of WPI and WPI emulsion, respectively. Furthermore, the emulsion coated by conjugates demonstrated better oxidative stability than WPI with less peroxides produced after accelerated oxidation for 7 days. The results lay good foundation for the modification of protein by natural bioactive polysaccharides as well as for the application in healthy foods.

Maillard reaction products-based encapsulant system formed between chitosan and corn syrup solids: Influence of solution pH on formation kinetic and antioxidant activity

Maillard reaction products (MRPs) between chitosan and various sugars with enhanced antioxidant activity were previously produced. However, few reports address the chitosan and corn syrup solids system that has been successfully used to encapsulate nutraceutical oils. Maillard reaction is pH-responsive, the influence of solution pH on the formation kinetic and antioxidant activity of MRPs was therefore evaluated in this work. FT-IR and zeta-potential results confirmed the formation of MRPs between chitosan and corn syrup solids. Possible Amadori compounds signals were observed clearly in the ¹H NMR spectrum. Brown color development depended on initial solution pH, following a zero-order kinetic regression. Antioxidant activity of reaction products was higher than the native system and increased with an increase in the initial pH of the solution. Developed MRPs with a dual function as antioxidant and encapsulant can possibly be used to protect emulsified oil from oxidation.

Nano-Sized Antioxidative Trimetallic Complex Based on Maillard Reaction Improves the Mineral Nutrients of Apple (Malus domestica Borkh.)

The metallic complex is widely used in agricultural applications. Due to the oxidation of the metal and environmental unfriendliness of ligand, maintaining an efficient mineral supply for plants without causing environmental damage is difficult. Herein, an antioxidative trimetallic complex with high stability was synthesized by interacting Ca²⁺, Fe²⁺, and Zn²⁺ with the biocompatible ligands from the Maillard reaction. The composite structure elucidation was carried out by transmission electron microscopy (TEM), scanning electron microscopy (SEM), X-ray photoelectron spectroscopy (XPS), and Fourier transform infrared (FTIR). Thermal stability was measured by thermogravimetric (TG). Antioxidative activities were evaluated by ferric reducing antioxidant power and radical scavenging activity assays. The three metals were successfully fabricated on the Maillard reaction products (MRPs) with contents of Ca (9.01%), Fe (8.25%), and Zn (9.67%). Microscopy images revealed that the three metals were uniformly distributed on the MRPs with partial aggregation of <30 nm. FTIR and XPS results revealed that the metals were interacted with MRPs by metal-O and metal-N bonds. TG and antioxidative activity assays showed that the trimetallic complex meets the requirements of thermodynamics and oxidation resistance of horticultural applications. Additionally, the results of the exogenous spraying experiment showed that the trimetallic complex significantly increased the mineral contents of the "Fuji" apple. By treatment with the complex, the concentrations of Ca, Fe, and Zn were increased by 85.4, 532.5, and 931.1% in the leaf; 16.0, 225.2, and 468.6% in the peel; and 117.6, 217.9, and 19.5% in the flesh, respectively. The MRP-based complexes offered a higher growth rate of the mineral content in apples than ones based on sugars or amino acids. The results of the spraying experiment carried out in 2 years show that the method has high reproducibility. This study thus promotes the development of green metallic complexes and expands the scope of agrochemical strategy.

Characterization of β-Glucan-Peanut Protein Isolate/Soy Protein Isolate Conjugates and Their Application on Low-Fat Sausage

Polysaccharide-protein conjugates can improve the functional properties and expand the application field. The emulsifying, thermal properties of WSG-PPI conjugates and WSG-SPI conjugates were improved, compared to WSG, PPI and SPI. The Maillard reaction was confirmed by Fourier transform infrared spectroscopy (FT-IR). Circular dichroism (CD) exhibited that the structure of the conjugates was more expanded. Cryo-SEM and AFM demonstrated that the WSG, WSG-PPI and WSG-SPI conjugates had a morphology of a chain. When the conjugates were added as fat substitutes to low-fat sausage, the cooking yield, hardness and chewiness increased. The objective of this research was to study the emulsifying property, thermal property and structural changes of β-glucan-peanut protein isolate (WSG-PPI) conjugates and β-glucan-soy protein isolate (WSG-SPI) conjugates prepared through wet-heated Maillard reaction, and their effect on the texture of low-fat sausage.

Structuring functional mayonnaise incorporated with Himalayan walnut oil Pickering emulsions by ultrasound assisted emulsification

Nowadays Pickering emulsions have attracted immense attention due to their enhanced stability and numerous food applications. In this context, the present study was aimed to introduce Pickering emulsions stabilized by soy protein isolate (SPI)-maltodextrin (MD)-pectin complex incorporated with Himalayan walnut oil (HWO) for development of novel mayonnaise by ultrasound assisted emulsification. The functional mayonnaise was characterised for its stability, structural, textural, rheological and morphological properties. The rheological and microstructure measurements indicated that use of SPI-pectin HWO emulsions had a viscoelastic solid behaviour (G' > G″) with highly interconnected gel-like network structure leading to diffused oil droplet distribution. An increase in particle size diameter (1.86-5.09 µm) and hardness values (43.16-69.08 N) was seen with increase in the SPI-pectin wall material concentration. A significant reduction in whiteness (L* value) from 91.12 to 53.52 was noted during storage for encapsulated samples. Mayonnaise formulations containing encapsulated HWO depicted significantly lower peroxide value (2.65 meqO₂/kg) after extended storage period in comparison to free oil (8.33 meqO₂/kg). FTIR analysis of mayonnaise formulations depicted successful complexation of HWO with SPI-MD-pectin matrix. These findings would be of immense importance in designing of Pickering emulsions stabilized by protein-polysaccharide particles with aim of delivering nutraceuticals associated with myriad health benefits.

Biomimetic biphasic curdlan-based scaffold for osteochondral tissue engineering applications - Characterization and preliminary evaluation of mesenchymal stem cell response in vitro

Osteochondral defects remain a huge problem in medicine today. Biomimetic bi- or multi-phasic scaffolds constitute a very promising alternative to osteochondral autografts and allografts. In this study, a new curdlan-based scaffold was designed for osteochondral tissue engineering applications. To achieve biomimetic properties, it was enriched with a protein component - whey protein isolate as well as a ceramic ingredient - hydroxyapatite granules. The scaffold was fabricated via a simple and cost-efficient method, which represents a significant advantage. Importantly, this technique allowed generation of a scaffold with two distinct, but integrated phases. Scanning electron microcopy and optical profilometry observations demonstrated that phases of biomaterial possessed different structural properties. The top layer of the biomaterial (mimicking the cartilage) was smoother than the bottom one (mimicking the subchondral bone), which is beneficial from a biological point of view because unlike bone, cartilage is a smooth tissue. Moreover, mechanical testing showed that the top layer of the biomaterial had mechanical properties close to those of natural cartilage. Although the mechanical properties of the bottom layer of scaffold were lower than those of the subchondral bone, it was still higher than in many analogous systems. Most importantly, cell culture experiments indicated that the biomaterial possessed high cytocompatibility towards adipose tissue-derived mesenchymal stem cells and bone marrow-derived mesenchymal stem cells in vitro. Both phases of the scaffold enhanced cell adhesion, proliferation, and chondrogenic differentiation of stem cells (revealing its chondroinductive properties in vitro) as well as osteogenic differentiation of these cells (revealing its osteoinductive properties in vitro). Given all features of the novel curdlan-based scaffold, it is worth noting that it may be considered as promising candidate for osteochondral tissue engineering applications.

Impact of alkaline electro-activation treatment on physicochemical and functional properties of sweet whey

The impact of alkaline electro-activation (EA) on the protein solubility, foaming, and emulsifying characteristics of whey was investigated. EA caused protein aggregation and conjugation. At low electric current and holding time, proteins aggregation through disulfide bonds was observed, whereas increasing currents and holding times caused proteins to conjugate with sugars such as lactose, lactulose and galactose. The EA process improved the protein solubility at the pH range of 4.0-7.0. Compared to untreated whey, which produced micron-sized and unstable emulsions at pH 3, whey samples treated under 750 mA and 24-48 h holding time formed nano-sized and stable emulsions at this pH. Furthermore, although both untreated and EA-whey produced stable emulsions at pH 7, those emulsions prepared with EA-whey had smaller particle size and were more stable against droplet flocculation. EA-treated whey tended to generate foams with significantly higher overrun and stability. The present study demonstrated that EA can enhance the functionality of whey.

Comparison of the interactions of flupyrimin and nitenpyram with serum albumins via multiple analysis methods

Flupyrimin and nitenpyram are emerging neonicotinoid insecticides that may cause potential harm to the human body. In the present work, the interactions of flupyrimin/nitenpyram with serum albumins under normal physiological conditions were thoroughly studied by using multiple spectroscopic techniques, DFT calculations and molecular docking. Flupyrimin/nitenpyram can quench the endogenous fluorescence of HSA/BSA and form a complex with HSA/BSA through a static process, causing conformational and secondary structure changes of HSA/BSA. Thermodynamic analysis shows that the combination of flupyrimin/nitenpyram with HSA/BSA is a spontaneous process, mainly driven by hydrogen bonds and hydrophobic forces. Site marking and molecular docking experiments indicated that flupyrimin/nitenpyram binds with HSA/BSA at site II (subdomain IIIA). The binding constant K_a in HSA-flupyrimin, HSA-nitenpyram, BSA-flupyrimin and BSA-nitenpyram systems at 298 K was 2.11 × 10⁵ M^-1, 2.35 × 10⁵ M^-1, 1.91 × 10⁵ M^-1 and 2.11 × 10⁵ M^-1, respectively. The binding constant K_a of nitenpyram with HSA/BSA was greater than flupyrimin, indicating that nitenpyram binds HSA/BSA was more stable than that of flupyrimin, which was consistent with the DFT calculation. In addition, the acute toxicity bioassay showed that flupyrimin and nitenpyram exhibited low toxicity to zebrafish, with 96 h LC₅₀ values of 181.662 and 250.658 mg a. i. L^-1, respectively. These results can help understand the interactions of flupyrimin/nitenpyram with HSA/BSA.

Enhanced In Vitro Functionality and Food Application of Lactobacillus acidophilus Encapsulated in a Whey Protein Isolate and (-)-Epigallocatechin-3-Gallate Conjugate

The present study investigated the potential of free radical grafting conjugation of whey protein isolate (WPI) and (-)-epigallocatechin-3-gallate (EGCG), followed by freeze-drying, for the safe delivery of probiotic Lactobacillus acidophilus (LA) upon digestion and in food systems. WPI-EGCG-LA microspheres presented higher encapsulation efficiency (97%) than native WPI-LA (70%) and maltodextrin (MD-LA 75%). The physicochemical characteristics of all microspheres, including moisture content, water activity, and hygroscopicity, were within the acceptable range for the stability of industrial powders. Scanning electron microscopy of WPI-EGCG-LA revealed a glass-like structure, with a smoother and less porous surface area than WPI-LA and MD-LA, as a result of the strong binding affinity between WPIs and EGCG. Particle sizes ranged from 438.4 to 453.3 μm. The structural stability of WPI-EGCG-LA was further confirmed by Fourier transform infrared spectra, which revealed some changes in the protein secondary structure. Thermogravimetric and differential scanning calorimetry analysis showed that WPI-EGCG conjugates had higher thermal stability than native WPIs and MD. Additionally, cells encapsulated in WPI-EGCG conjugates demonstrated higher in vitro survivability and surface hydrophobicity compared to free or WPI- and MD-encapsulated cells. Furthermore, WPI-EGCG-LA microspheres exerted enhanced in vitro antioxidant (78%) and antidiabetic (52%) activities. Finally, the WPI-EGCG conjugates remarkably improved probiotic viability (8.55 ± 0.1 log cfu/g) during 30 days of storage in an apple juice drink of pH (3.2 ± 0.01). Hence, the WPI-EGCG conjugate represents a propitious carrier to enhance probiotic functional properties upon digestion and during storage in low-pH food products.

A Literature Review on Maillard Reaction Based on Milk Proteins and Carbohydrates in Food and Pharmaceutical Products: Advantages, Disadvantages, and Avoidance Strategies

Milk has two main components that have high nutritional value—milk protein (casein and whey protein), and lactose. These components are extensively used in various areas, especially in food, i.e., as sweeteners, stabilizers, functional food ingredients, nutritional fortifiers, etc. Non-enzymatic browning refers to a series of chemical reactions between sugars and proteins that make food more appetizing. Non-enzymatic browning reactions include degradation of ascorbic acid, lipid peroxidation, caramel reaction, and the Maillard reaction (MR). The MR, as one of the four non-enzymatic browning reactions, has been well studied and utilized in food fields. Milk protein and lactose, as two main components of milk, have high chemical activities; they are used as reactants to participate in the MR, generating Maillard reaction products (MRPs). The MR involves a condensation reaction between carbonyl groups of various sugars and amino groups of amino acids/proteins. These MRPs have different applications in various areas, including food flavor, food oxidation resistance, drug carriers, etc. This work presents the positive and negative effects of the MR, based on the two main components of milk, used in food and medicine, as well as avoidance approaches to prevent the occurrence of negative effects.

Structural properties of native and conjugated black soldier fly (Hermetia illucens) larvae protein via Maillard reaction and classification by SIMCA

Black soldier fly (Hermetia illucens) has received considerable interest as an alternative protein source. Aqueous solutions of black soldier fly larvae (BSFL) protein and glucose (2:1 w.w⁻¹, pH 9) were heated at 50, 70 and 90 °C, for 2–10 h at 2 h intervals, respectively. The zeta-potential (ζ) of BSFL-Glu conjugates heat-treated at 70 °C ranged from -10.25 to -25.25 mV while the native BSFL protein ranged from -12.84 to -16.70 mV. The ζ-potential analysis revealed that the glycation reaction modified the surface charge density of the BSFL protein as a function of reaction time and temperature. In addition, an increase in thermal stability of the BSFL-Glu conjugates was observed by means of Thermo-gravimetric analysis (TGA) and differential scanning calorimetry (DSC). Fourier transform infrared spectroscopy (FT-IR) analysis indicated that the most apparent structural changes in the BSFL protein were in the amide I and amide II region. Well-separated clusters permitting differentiation between native BSFL and BSFL-Glu conjugates were observed by using principal component analysis (PCA) on FT-IR spectra. At 50, 70 and 90 °C the first two principal components (PC1 and PC2) showed an accumulated total variance of 91, 96 and 95%, respectively. A classification efficiency of 91% was obtained when using soft independent modelling of class analogy (SIMCA). Infrared spectroscopy combined with SIMCA is a powerful tool to monitor the formation of edible insect protein–sugar conjugates by Maillard reaction. As a result, combining FT-IR spectroscopy with multivariate techniques (PCA and SIMCA) exhibited a strong potential to differentiate between native and glycated protein samples from black soldier fly larvae.

Maillard conjugates of whey protein isolate-xylooligosaccharides for the microencapsulation of Lactobacillus rhamnosus: protective effects and stability during spray drying, storage and gastrointestinal digestion

The Maillard reaction products (MRPs) of whey protein isolate (WPI) and xylooligosaccharides (XOS) were prepared by a moist heat method for use as protectants to encapsulate Lactobacillus rhamnosus via spray drying. The protective effects of MRPs on bacterial cells during drying, storage, and in vitro digestion were explored. FTIR results indicated that MRPs were successfully prepared. All MRPs showed good thermo-protective effect on the bacteria, and the survival ratio achieved with 1 : 2 XOS-WPI as a wall material reached 99.83 ± 8.44%, which was around 2 times as high as that of the WPI wall material and 1.5 times as high as that of the 1 : 2 XOS-WPI mixture. The dried lactobacilli showed similar growth curves to the fresh culture. After 10 weeks of storage at 4 °C, the decrease in the bacterial activity was less than 1 log CFU g-1 for all types of microcapsules, while the microcapsules composed of all MRPs had better storage stability. MRPs improved the stability of microcapsules during in vitro digestion. The number of viable bacteria in 1 : 2 XOS-WPI MRPs microcapsules was maintained at 4.09 ± 0.59 × 109 CFU g-1 after simulated gastrointestinal digestion for 4 hours, which only decreased by 0.20 log CFU g-1.

Whey Protein Isolate Microgel Properties Tuned by Crosslinking with Organic Acids to Achieve Stabilization of Pickering Emulsions

Whey protein isolate (WPI) can be used effectively to produce food-grade particles for stabilizing Pickering emulsions. In the present study, crosslinking of WPI microgels using organic acids (tannic and citric acids) is proposed to improve their functionality in emulsions containing roasted coffee oil. It was demonstrated that crosslinking of WPI by organic acids reduces the microgels’ size from ≈1850 nm to 185 nm and increases their contact angle compared to conventional WPI microgels, achieving values as high as 60°. This led to the higher physical stability of Pickering emulsions: the higher contact angle and smaller particle size of acid-crosslinked microgels contribute to the formation of a thinner layer of particles on the oil/water (O/W) interface that is located mostly in the water phase, thus forming an effective barrier against droplet coalescence. Particularly, emulsions stabilized by tannic acid-crosslinked WPI microgels presented neither creaming nor sedimentation up to 7 days of storage. The present work demonstrates that the functionality of these crosslinked WPI microgels can be tweaked considerably, which is an asset compared to other food-grade particles that mostly need to be used as such to comply with the clean-label policy. In addition, the applications of these particles for an emulsion are much more diverse as of the starting material.