Effects of plasma chemistry on the interfacial performance of protein and polysaccharide in emulsion

The impacts of cold plasma on the taste and odor formation of dried silver carp products

This study investigated non-thermal pretreatment (cold plasma, CP) on the flavor (taste and odor) profiles of dried fish products. CP treatment of 5 min contributed to accumulation of umami nucleotides adenosine 5'-monophosphate (AMP) from 30.96 to 40.82 μg/g and inosine 5'-monophosphate (IMP) from 2009.29 to 2132.23 μg/g, and significant reduction of bitter hypoxanthine ribonucleoside (HxR) and hypoxanthine (Hx), respectively (P < 0.05) in the dried fish products. A noticeable enhancement in sweet glycine (from 429.41 to 490.03 mg/100 g) and umami glutamic acid (from 55.68 to 67.76 mg/100 g) accompanied with the CP treatment (P < 0.05) based on taste activity value (TAV > 1). And the characteristic odor volatiles (nonanal, hexanal and 1-octen-3-ol) were strengthened 2.13-, 2.16- and 2.17- folds, respectively (P < 0.05). The results of equivalent umami concentration and Gibbs free energy calculation, combining with the correlation analysis, indicate that nucleotides and free amino acids synergically enhanced the taste improvement of dried fish products. Moderate lipids oxidation favored the formation of characteristic volatiles. The CP pretreatment offered new strategies for enhancing flavor of dried fish products.

Phase behavior of the gelation process of myofibrillar protein-curdlan blended system: Discussion based on rheology and gel properties

The phase behavior in protein-polysaccharide blended systems is the main factor affecting the physical properties of composite gels; however, the phase behavior at room temperature and during heated gelation is lacking discussion. In this research, extracted grouper myofibrillar protein (MP) and curdlan (CUR) were used as models for the MP-CUR blended system. The phase behavior of the MP-CUR blended system was analyzed using rheology and microstructure analysis, and the accuracy of the phase behavior analysis was verified by measuring the physical indices such as gel properties of the MP-CUR composite gels. At room temperature, MP and CUR showed good co-solubility, so the blended system with 0.8% CUR content obtained the best apparent viscosity, structural recoverability, and other rheological properties. After heating gelation, MP and CUR had strong thermodynamic unaffinity leading to phase separation, and the best storage modulus was obtained for the MP-CUR blended system with 0.6% CUR content. Therefore, it is concluded that 0.6% CUR content is the critical concentration for the MP-CUR blended system. The results were also confirmed by the best gel properties of 0.6% CUR composite gel when the physical properties of the composite gel were determined. The phase behavior evaluation was used to determine the appropriate polysaccharide concentrations as a means to improve the physicochemical properties of the composite gels and to exploit the value of polysaccharides in protein-based food applications.

In vivo biological analysis of cold plasma on allergenicity reduction of tropomyosin in shrimp

In vivo biological regulations of the allergenicity of tropomyosin (TM) treated by cold plasma (CP) were investigated by in vivo mouse model. The sensitization models of Balb/c mice were successfully established. CP treatment reduced the allergic symptoms of mice and regulated the Th1/Th2 balance to prevent allergy by activating Treg cells, which was deduced by serum and cytokines analysis. For intestinal flora analysis, allergy occurrence was accompanied by the decreased species abundance and the increased species diversity of intestinal flora. The significant species composition difference between the TM group and the PBS group showed a possible connection between bacterial diversity and allergy. Furthermore, Firmicutes, Bacteroidetes, Parabacteroides, Alloprevotella, Bacteroides, and Lachnospiraceae could relate to allergy occurrence. Intestinal section analysis suggested that allergy occurrence was accompanied by the damaged intestinal structure, and CP treatment could relieve the damage caused by an allergy.

The Modification of Activated Carbon for the Performance Enhancement of a Natural-Rubber-Based Triboelectric Nanogenerator

Increasing energy demands and growing environmental concerns regarding the consumption of fossil fuels are important motivations for the development of clean and sustainable energy sources. A triboelectric nanogenerator (TENG) is a promising energy technology that harnesses mechanical energy from the ambient environment by converting it into electrical energy. In this work, the enhancement of the energy conversion performance of a natural rubber (NR)-based TENG has been proposed by using modified activated carbon (AC). The effect of surface modification techniques, including acid treatments and plasma treatment for AC material on TENG performance, are investigated. The TENG fabricated from the NR incorporated with the modified AC using N2 plasma showed superior electrical output performance, which was attributed to the modification by N2 plasma introducing changes in the surface chemistry of AC, leading to the improved dielectric property of the NR-AC composite, which contributes to the enhanced triboelectric charge density. The highest power density of 2.65 mW/m2 was obtained from the NR-AC (N2 plasma-treated) TENG. This research provides a key insight into the modification of AC for the development of TENG with high energy conversion performance that could be useful for other future applications such as PM2.5 removal or CO2 capture.

Enhanced properties of non-starch polysaccharide and protein hydrocolloids through plasma treatment: A review

Hydrocolloids are important ingredients in food formulations and their modification can lead to novel ingredients with unique functionalities beyond their nutritional value. Cold plasma is a promising technology for the modification of food biopolymers due to its non-toxic and eco-friendly nature. This review discusses the recent published studies on the effects of cold plasma treatment on non-starch hydrocolloids and their derivatives. It covers the common phenomena that occur during plasma treatment, including ionization, etching effect, surface modification, and ashing effect, and how they contribute to various changes in food biopolymers. The effects of plasma treatment on important properties such as color, crystallinity, chemical structure, rheological behavior, and thermal properties of non-starch hydrocolloids and their derivatives are also discussed. In addition, this review highlights the potential of cold plasma treatment to enhance the functionality of food biopolymers and improve the quality of food products. The mechanisms underlying the effects of plasma treatment on food biopolymers, which can be useful for future research in this area, are also discussed. Overall, this review paper presents a comprehensive overview of the current knowledge in the field of cold plasma treatment of non-starch hydrocolloids and their derivatives and highlights the areas that require further investigation.

Characterization of polysaccharide from Lonicera japonica Thunb leaves and its application in nano-emulsion

The polysaccharides in honeysuckle leaves (PHL) were separated and characterized for the first time. The nano-emulsion stabilized by PHL and whey protein isolate (WPI) were also fabricated based on the ultrasonic method. The results indicated that PHL was mainly composed of glucose (47.40 mol%), galactose (19.21 mol%) and arabinose (20.21 mol%) with the weight-average molecular weight of 137.97 ± 4.31 kDa. The emulsifier concentration, WPI-to-PHL ratio, ultrasound power and ultrasound time had significant influence on the droplet size of PHL-WPI nano-emulsion. The optimal preparation conditions were determined as following: emulsifier concentration, 1.7%; WPI/PHL ratio, 3:1; ultrasonic power, 700 W; ultrasonic time, 7 min. Under the above conditions, the median diameter of the obtained nano-emulsion was 317.70 ± 5.26 nm, close to the predicted value of 320.20 nm. The protective effect of PHL-WPI emulsion on β-carotene against UV irradiation was superior to that of WPI emulsion. Our results can provide reference for the development of honeysuckle leaves.

Inhibition of cell wall pectin metabolism by plasma activated water (PAW) to maintain firmness and quality of postharvest blueberry

Blueberry is a class of berries with high nutritional and economic value but has short shelf life due to its rapid softening at room temperature. This study investigated the effects of plasma-activated water (PAW) treatment on the softening quality and cell wall pectin metabolism of blueberries stored for 10 d at 25 °C after being immersed in PAW for 10 min. PAW was generated by plasma with different times (1 and 2 min), fixed frequency (10 kHz) and fixed voltage (50 kV). The analysis showed that the firmness of PAW-treated fruit significantly increased (P < 0.05) by 36.4% after 10 d storage. PAW treatment controlled the solubilization of pectin from water-insoluble to water-soluble. The activities of cell wall pectin-degrading enzymes like polygalacturonase (PG), β-galactosidase (β-Gal) and pectin methylesterase (PME) in PAW-treated blueberries decreased by 15.7%, 18.3%, and 27.9%, respectively, on day 10. After PAW treatment, blueberries also maintained better postharvest quality (firmness, colour, soluble solid content and anthocyanin content) and intact epidermal waxy and cell wall structure. These results suggested that PAW showed great potential for postharvest fresh-keeping of blueberry.

Effect of atmospheric pin-to-plate cold plasma on oat protein: Structural, chemical, and foaming characteristics

The impact of novel pin-to-plate atmospheric cold plasma was investigated with input voltage (170 V, 230 V) and exposure time (15 & 30 min) on oat protein by studying structural (FTIR, circular dichroism (CD), UV-vis, Fluorescence), morphological (particle size analysis, SEM, turbidity), chemical (pH, redox potential (ORP), ζ potential, carbonyl, sulfhydryl, surface hydrophobicity), and foaming characteristics. The plasma treatment reduced the pH while increasing the ORP of the dispersions. These ionic environment changes affected the ζ potential and particle size leading to the formation of larger aggregates (170-15; 230-15) and distorted smaller ones (170-30; 230-30) as confirmed by SEM. The FTIR spectra showed reduced intensity at specific amide bands (1600-1700 cm^-1) and also an increase in carbonyl stretching (1743 cm^-1) representing oxidative carbonylation (increase in carbonyl content). Thus, the partial exposure of hydrophobic amino acids increases surface hydrophobicity. The altered secondary structure (rise in α-helix, decrement in β-sheets and turns), and tertiary structures were observed in circular dichroism (CD) and UV absorbance and fluorescence characteristics of proteins respectively. Furthermore, the increase in free sulfhydryl content and disulfide content was highly affected by the plasma treatments due to observed protein unfolding and aggregations. Besides, the increased solubility and reduced surface tension contributed to the improved foaming characteristics. Thus, plasma processing influences protein structure affecting their characteristics and other functionalities.

Comparison of plasma technology for the study of herbicide degradation

The study aimed to investigate the effects of two different plasma systems, including pinhole plasma jet and gliding arc (GA) plasma, for the degradation of herbicide, diuron, in plasma activated solutions (PAS). In the GA plasma system, air was used to generate plasma, however, Ar, oxygen and nitrogen at different gas compositions were compared in the pinhole plasma jet system. The Taguchi design model was used to study the effects of gas compositions. Results revealed that the pinhole plasma jet system was able to degrade over 50% of the diuron in 60 minutes. The optimal plasma generation condition for the highest degradation of diuron used pure Ar gas. The highest degradation percentage of herbicide in PAS corresponded to the lowest hydrogen peroxide (H₂O₂) content, nitrite concentration and electrical conductivity (EC) of the PAS. The diuron degradation products were identified as 3,4-dichloro-benzenamine, 1-chloro-3-isocyanato-benzene and 1-chloro-4-isocyanato-benzene via gas chromatography-mass spectrometry (GC-MS). The GA plasma system was not adequate for the degradation of herbicide in PAS.

Conjugation of soy protein isolate with carboxymethyl cellulose through dielectric barrier discharge (DBD) plasma

The present study aimed to evaluate the physicochemical properties of dielectric barrier discharge (DBD) plasma grafted carboxymethyl cellulose (CMC) and soy protein isolate (SPI). Therefore, the mixture of SPI and CMC was treated at 16, 18 and 20 kV for 5, 10 and 15 min with DBD plasma. The results of FTIR, XRD, FESEM and SDS-PAGE confirmed the SPI-CMC conjugate formation after plasma treatment, and a glycation degree of about 21 % was obtained after 15 min treatment at 18 kV. Significantly higher levels of emulsifying activity and stability, as well as solubility, were obtained for the conjugates, as compared with the SPI-CMC mixture. Also, the smaller droplet sizes were observed in emulsions obtained from conjugate produced at 18 kV for 5 min, which had the most stability after 14 days of storage at 4 °C. Eventually, it was detected that DBD plasma could graft SPI and CMC in a short time.

Insight into the IgE-binding sites of allergenic peptides of tropomyosin in shrimp (Penaeus chinensis) induced by cold plasma active particles

Tropomyosin (TM) is a major allergen in crustaceans, and its allergenicity mainly depends on epitopes. In this study, the locations of IgE-binding sites between plasma active particles and allergenic peptides of TM in shrimp (Penaeus chinensis) during cold plasma (CP) treatment were explored. Results showed that the IgE-binding ability of two critical peptides (P1 and P2) increased and then decreased by 9.97 % and 19.50 % after 15 min of CP treatment. It was the first time to show that the contribution rate of target active particles was •O > e_(aq)^- > •OH for reducing IgE-binding ability by 23.51 %-45.40 %, and the contribution rates of other long-lived particles including NO₃^- and NO₂^- was about 54.60 %-76.49 %. In addition, Glu131 and Arg133 in P1 and Arg255 in P2 were certified as the IgE sites. These results were helpful for accurately controlling TM allergenicity, shedding more light on allergenicity mitigation during food processing.

Degradation of deoxynivalenol in wheat by double dielectric barrier discharge cold plasma: identification and pathway of degradation products

BACKGROUND

Deoxynivalenol (DON) produced during the onset of fusarium head blight not only affects the quality and safety of wheat but also causes serious harm to human and livestock health. However, due to the high stability of DON, it is difficult to eliminate it or reduce it naturally after it has been produced. Cold plasma technology is a non-thermophysical processing technology that has been widely used for microbial inactivation and mycotoxin degradation. In this study, the degradation efficiency of double dielectric barrier discharge (DDBD) cold plasma on DON in aqueous solution and wheat was studied; the structures of degradation products of DON and its pathway were clarified, and the effect of DDBD plasma on wheat quality was evaluated.

RESULTS

Double dielectric barrier discharge cold plasma was used for efficient degradation of DON (0.5 ~ 5 μgmL^-1) solution and achieved a degradation rate of 98.94% within 25 min under the optimal conditions (voltage 100 V, frequency 200 Hz, duty cycle 80%). Furthermore, 10 degradation products (C₁₅ H₂₄ O₅ , C₁₅ H₂₂ O₆ , C₁₅ H₂₂ O₉ , C₁₆ H₂₂ O₇ , C₁₅ H₂₀ O₇ , C₁₅ H₂₀ O₉ , C₁₅ H₁₈ O₈ , C₁₅ H₂₂ O₅ , C₁₆ H₂₄ O₅ , and C₁₅ H₁₈ O₉ ) were identified by ultra-performance liquid chromatography-time of flight-mass spectrometry (UPLC-TOF-MS/MS) combined with Metabolitepilot and Peakview software. The degradation pathway of DON was obtained based on the chemical structures and accurate mass of these products. The DON degradation rate of 61% in wheat was achieved after treatment for 15 min, which slightly affects the moisture content, proteins, and wheat starch.

CONCLUSION

Applying DDBD to wheat could effectively reduce the level of DON contamination, which provides a theoretical basis for applying cold plasma to the degradation of DON in wheat. © 2022 Society of Chemical Industry.

Plasma-activated liquids for mitigating biofilms on food and food contact surfaces

Plasma-activated liquids (PALs) are emerging and promising alternatives to traditional decontamination technologies and have evolved as a new technology for applications in food, agriculture, and medicine. Contamination caused by foodborne pathogens and their biofilms has posed challenges and concerns to the food industry in terms of safety and quality. The nature of the food and the food processing environment are major factors that contribute to the growth of various microorganisms, followed by the biofilm characteristics that ensure their survival in severe environmental conditions and against traditional chemical disinfectants. PALs show an efficient impact against microorganisms and their biofilms, with various reactive species (short- and long-lived ones), physiochemical properties, and plasma processing factors playing a crucial role in mitigating biofilms. Moreover, there is potential to improve and optimize disinfection strategies using a combination of PALs with other technologies for the inactivation of biofilms. The overarching aim of this study is to build a better understanding of the parameters that govern the liquid chemistry generated in a liquid exposed to plasma and how these translate into biological effects on biofilms. This review provides a current understanding of PALs-mediated mechanisms of action on biofilms; however, the precise inactivation mechanism is still not clear and is an important part of the research. Implementation of PALs in the food industry could help overcome the disinfection hurdles and can enhance biofilm inactivation efficacy. Future perspectives in this field to expand existing state of the art to seek breakthroughs for scale-up and implementation of PALs technology in the food industry are also discussed.

Correlation between interfacial layer properties and physical stability of food emulsions: current trends, challenges, strategies, and further perspectives

Emulsions are thermodynamically unstable systems that tend to separate into two immiscible phases over time. The interfacial layer formed by the emulsifiers adsorbed at the oil-water interface plays an important role in the emulsion stability. The interfacial layer properties of emulsion droplets have been considered the cutting-in points that influence emulsion stability, a traditional motif of physical chemistry and colloid chemistry of particular significance in relation to the food science and technology sector. Although many attempts have shown that high interfacial viscoelasticity may contribute to long-term emulsion stability, a universal relationship for all cases between the interfacial layer features at the microscopic scale and the bulk physical stability of the emulsion at the macroscopic scale remains to be established. Not only that, but integrating the cognition from different scales of emulsions and establishing a unified single model to fill the gap in awareness between scales also remain challenging. In this review, we present a comprehensive overview of recent progress in the general science of emulsion stability with a peculiar focus on interfacial layer characteristics in relation to the formation and stabilization of food emulsions, where the natural origin and edible safety of emulsifiers and stabilizers are highly requested. This review begins with a general overview of the construction and destruction of interfacial layers in emulsions to highlight the most important physicochemical characteristics of interfacial layers (formation kinetics, surface load, interactions among adsorbed emulsifiers, thickness and structure, and shear and dilatational rheology), and their roles in controlling emulsion stability. Subsequently, the structural effects of a series of typically dietary emulsifiers (small-molecule surfactants,proteins, polysaccharides, protein-polysaccharide complexes, and particles) on oil-water interfaces in food emulsions are emphasized. Finally, the main protocols developed for modifying the structural characteristics of adsorbed emulsifiers at multiple scales and improving the stability of emulsions are highlighted. Overall, this paper aims to comprehensively study the literature findings in the past decade and find out the commonality of multi-scale structures of emulsifiers, so as to deeply understand the common characteristics and emulsification stability behaviour of adsorption emulsifiers with different interfacial layer structures. It is difficult to say that there has been significant progress in the underlying principles and technologies in the general science of emulsion stability over the last decade or two. However, the correlation between interfacial layer properties and physical stability of food emulsions promotes revealing the role of interfacial rheological properties in emulsion stability, providing guidance on controlling the bulk properties by tuning the interfacial layer functionality.

EFFECTS OF COLD PLASMA ON CHLOROPHYLLS, CAROTENOIDS, ANTHOCYANINS, AND BETALAINS

Plasma is considered by several researchers to be the fourth state of matter. Cold plasma has been highlighted as an alternative to thermal treatments because heat induces less degradation of thermolabile bioactive compounds, such as natural pigments. In this review, we provide a compilation of the current information about the effects of cold plasma on natural pigments, such as the changes caused by plasma to the molecules of chlorophylls, carotenoids, anthocyanins, and betalains. As a result of the literature review, it is noted that can degrade cell membrane and promote damage to pigment storage sites; thereby releasing pigments and increasing their content in the extracellular space. However, the reactive species contained in the cold plasma can cause degradation of the pigments. Cold plasma is a promising technology for extracting pigments; however, case-by-case optimization of the extraction process is required.

Toxic reactive oxygen species stresses for reconfiguring central carbon metabolic fluxes in foodborne bacteria: Sources, mechanisms and pathways

The toxic reactive oxygen species (toxROS) is the reactive oxygen species (ROS) beyond the normal concentration of cells, which has inactivation and disinfection effects on foodborne bacteria. However, foodborne bacteria can adapt and survive by physicochemical regulation of antioxidant systems, especially through central carbon metabolism (CCM), which is a significant concern for food safety. It is thus necessary to study the antioxidant regulation mechanisms of CCM in foodborne bacteria under toxROS stresses. Therefore, the purpose of this review is to provide an update and comprehensive overview of the reconfiguration of CCM fluxes in foodborne bacteria that respond to different toxROS stresses. In this review, two key types of toxROS including exogenous toxROS (exo-toxROS) and endogenous toxROS (endo-toxROS) are introduced. Exo-toxROS are produced by disinfectants, such as H₂O₂ and HOCl, or during food non-thermal processing such as ultraviolet (UV/UVA), cold plasma (CP), ozone (O₃), electrolyzed water (EW), pulsed electric field (PEF), pulsed light (PL), and electron beam (EB) processing. Endo-toxROS are generated by bioreagents such as antibiotics (aminoglycosides, quinolones, and β-lactams). Three main pathways for CCM in foodborne bacteria under the toxROS stress are also highlighted, which are glycolysis (EMP), pentose phosphate pathway (PPP), and tricarboxylic acid cycle (TCA). In addition, energy metabolisms throughout these pathways are discussed. Finally, challenges and future work in this area are suggested. It is hoped that this review should be beneficial in providing insights for future research on bacterial antioxidant CCM defence under both exo-toxROS stresses and endo-toxROS stresses.

Changing the IgE Binding Capacity of Tropomyosin in Shrimp through Structural Modification Induced by Cold Plasma and Glycation Treatment

Tropomyosin (TM) is the major allergen of shrimp (Penaeus chinensis). Previous studies showed that separate cold plasma or glycation have their drawback in reducing allergenicity of TM, including effectiveness and reliability. In the current study, a new processing combining cold plasma (CP) and glycation was proposed and its effect on changing IgE binding capacity of TM from shrimp was investigated. Obtained results showed the IgE binding capacity of TM was reduced by up to 40% after CP (dielectric barrier discharge, 60 kV, 1.0 A) combined with glycation treatment (4 h, 80 °C), compared with the less than 5% reduction after single CP or glycation treatment. Notably, in contrast to the general way of CP prompting glycation, this study devised a new mode of glycation with ribose after CP pretreatment. The structural changes of TM were explored to explain the decreased IgE binding reactivity. The results of multi-spectroscopies showed that the secondary and tertiary structures of TM were further destroyed after combined treatment, including the transformation of 50% α-helix to β-sheet and random coils, the modification and exposure of aromatic amino acids, and the increase of surface hydrophobicity. The morphology analysis using atomic force microscope revealed that the combined processing made the distribution of TM particles tend to disperse circularly, while it would aggregate after either processing treatment alone. These findings confirmed the unfolding and reaggregation of TM during combined processing treatment, which may result in the remarkable reduction of IgE binding ability. Therefore, the processing of CP pretreatment combined with glycation has the potential to reduce or even eliminate the allergenicity of seafood.

Degradation of Alternaria mycotoxins by UV-C irradiation: Effect of selected process and exposure to food components

Alternariol (AOH) and alternariol monomethyl ether (AME) are two Alternaria mycotoxins with high occurrence rates in food systems. This study aimed to investigate the photodegradation of AOH and AME by ultraviolet-C (UV-C) irradiation. The effect of UV-C intensity, pH, treatment time, solvents and the exposure of food components were evaluated. After treated by UV-C irradiation at 3500 μW/cm² for 90 min, AOH samples in methanol, aqueous solution and solid state were degraded by 89.1%, 72.9% and 53.2%, respectively, while the degradation percentages of AME were 86.6%, 50.1% and 11.1%, respectively. Increasing irradiation intensity and prolonging irradiation time could significantly facilitate the degradation of AOH and AME. An alkaline environment (pH = 11) was more conducive to the degradation of toxins. In addition, 2.5 mg mL^-1 citric acid or malic acid increased the photodegradation of AOH and AME to 94.6% and 95.3%, 93.2% and 70.5%, respectively. However, protein, polyphenols and vitamin C exerted inhibitory effects on the degradation, while 10% glucose or sucrose reduced the photodegradation of AOH and AME to 65.9% and 40.3%. UV-C treatment could effectively reduce the content of AOH and AME, with the highest efficiency achieved in methanol and alkaline environment. By contrast, UV-C irradiation is more effective in degrading toxins in some liquid foods rich in organic acids but lacking in protein. The utilization of UV-C radiation appears to be a potentially useful approach for decreasing the underlying risk of Alternaria mycotoxin contamination in foods.

Enhancement of Wheat Seed Germination, Seedling Growth and Nutritional Properties of Wheat Plantlet Juice by Plasma Activated Water

Previous studies have shown the great potential of using plasma-activated water (PAW) on improving agriculture seed germination, however, information on the influence of PAW on crop plantlet juice remains scanty. In this research, the effect of PAW generated by atmosphere pressure Ar-O₂ plasma jet for 1-5 min on wheat seed germination, seedling growth and nutritional properties of wheat plantlet juice was investigated. Results revealed that all PAWs could enhance wheat seed germination and seedling growth in 7 days by improving the germination rate, germination index, fresh weight, dry weight and vigour index, and especially that PAW activated for 3 min (PAW-3) showed the best overall performance. In addition, the application of PAWs enhanced the nutritional properties of wheat plantlet juice from those grown for 14 days by improving total soluble solids, protein content, photosynthetic pigments, total phenolic content, antioxidant activity, enzyme activity, free amino acids and minerals content, and the best enhancement was also observed in PAW-3. It was concluded that PAWs would be an effective technique to enhance the growth and nutritional properties of crop sprouts, which could be served as functional foods in many forms.

SUPPLEMENTARY INFORMATION

The online version contains supplementary material available at 10.1007/s00344-022-10677-3.

Clindamycin removal from aqueous solution by non-thermal air plasma treatment: performance, degradation pathway and ensuing antimicrobial activity

The present study set out to investigate clindamycin (CLN) removal from aqueous solution using non-thermal plasma (NTP) under atmospheric air conditions and to address the effects of some variables including pH, initial concentration of CLN, and working voltage on CLN degradation. The result showed that the NTP system exhibited excellent degradation rate and mineralization efficiency on CLN in 15 min under neutral conditions, which exceeded 90 and 45%, respectively, demonstrating its conversion to other organic by-products. Furthermore, CLN degradation was largely dependent upon the initial pH of solution, applied voltage, and reaction time. Specifically, under acidic conditions (pH = 3), working voltage of 24 kV and after 15 min of reaction, almost 100% of CLN was degraded. NTP-initiated CLN degradation products through LC-MS/MS analysis, determined within 10 min of reaction, inferred that the complex structure of CLN has undergone deterioration by active radical species which subsequently generated small molecular organic compounds. Chemical processes involved in CLN degradation were found to be demethylation, desulfonylation, dechlorination, hydroxylation and deamination. Lastly, antimicrobial susceptibility tests revealed that the activity of CLN was reduced following NTP treatment, which is also in good agreement with the minimum inhibitory concentration (MIC) values obtained from microdilution analyses.

Oxidative lesions and post-treatment viability attenuation of listeria monocytogenes triggered by atmospheric non-thermal plasma

AIMS

The aim of the current study was to investigate the effect of plasma-mediated oxidative stress on the post-treatment viability of Listeria monocytogenes at the physiological and molecular levels.

METHODS AND RESULTS

10⁷  CFU/ml L. monocytogenes in 10 ml phosphate-buffered saline (PBS) was treated with atmospheric non-thermal plasma for 0, 30, 60, 90 and 120 s respectively. Optical diagnostics using optical emission spectroscopy (OES) confirmed that dielectric barrier discharge (DBD) plasma was a significant source of ample exogenous reactive oxygen and nitrogen species (RONS). The development of extracellular main long-lived species was associated with plasma exposure time, accompanied by a massive accumulation of intracellular ROS in L. monocytogenes (p < 0.01). With the exception of virulence genes (hly), most oxidation resistance genes (e.g. sigB, perR, lmo2344, lmo2770 and trxA) and DNA repair gene (recA) were upregulated significantly (p < 0.05). A visible fragmentation in genomic DNA and a decline in the secretion of extracellular proteins and haemolytic activity (p < 0.01) were noticed. The quantitate oxygen consumption rates (OCRs) and extracellular acidification rates (ECARs) confirmed the viability attenuation from the aspect of energy metabolism. Survival assay in a real food system (raw milk) further suggested not only the viability attenuation, but also the resuscitation potential and safety risk of mild plasma-treated cells during post-treatment storage.

CONCLUSION

DBD plasma had the potential to inactivate and attenuate the virulence of L. monocytogenes, and it was recommended that plasma exposure time longer than 120 s was more suitable for attenuating viability and avoiding the recovery possibility of L. monocytogenes in raw milk within 7 days.

SIGNIFICANCE AND IMPACT OF THE STUDY

The current results presented a strategy to inactivate and attenuate the viability of L. monocytogenes, which could serve as a theoretical basis for better application of non-thermal plasma in food in an effort to effectively combat foodborne pathogens.

Influence of mild oxidation induced through DBD-plasma treatment on the structure and gelling properties of glycinin

The effects of dielectric-barrier discharge (DBD) plasma treatment (20 s to 120 s treatment time with 40 kV, 12 kHz) induced mild oxidation on the gelling properties, and related structural changes of glycinin were investigated. The gelling ability of glycinin was improved by the mild oxidation induced by the plasma treatment. Treated glycinin gels exhibited a continuous and uniform network microstructure. Samples treated for 120 s had a 2.07-, 3.99- and 2.03-fold increase in hardness, chewiness, and resilience compared to the 20 s treated samples. Structural analyses showed that primary and secondary structures of glycinin were unaffected. The tertiary structure was shifted, accompanied by a decrease in free sulfhydryl (-SH) content. At the same time, carbonyl content and average particle diameter were increased by DBD treatment. The DBD treatment facilitated the generation/exchange of intermolecular disulfide bonds and enhanced gelling properties of glycinin. It is concluded that controlled plasma-induced protein oxidation can improve protein functionality.

Hybridising plasma functionalized water and ultrasound pretreatment for enzymatic protein hydrolysis of Larimichthys polyactis: Parametric screening and optimization

Hybridising plasma functionalized water and ultrasound pretreatment for the enzymatic hydrolysis (HPUEH) of Larimichthys polyactis was evaluated by adopting Plackett-Burman design for parametric screening of six key variables, and Box-Behnken design for optimizing three most significant variables including plasma generating voltage (P_V), ultrasound treatment time (U_T), and enzyme concentration (E_C). The models developed for predicting the degree of hydrolysis (DoH), protein recovery (PVY), and soluble protein content (SPC) were sufficiently fitted to the experimental data (R² ≥ 0.966) with non-significant lack of fit and used for determining the optimum conditions as P_V of 70 V, U_T of 15 min, and E_C of 1.787%, with predictive values of 27.74%, 85.62%, and 3.28 mg/mL for DoH, PVY, and SPC, respectively. HPUEH presented hydrolysates with smaller peptide sizes and molecular weights, enhanced DoH, PVY, SPC, amino acids and antioxidant activity, but reduced emulsifying and foaming properties when compared with conventional enzymatic hydrolysis.

Modelling of inactivation kinetics of Escherichia coli and Listeria monocytogenes on grass carp treated by combining ultrasound with plasma functionalized buffer

Linear (first-order) and non-linear (Weibull, biphasic, and log-logistic) models were evaluated for predicting the inactivation kinetics of Escherichia coli and Listeria monocytogenes on grass carp treated by a novel technique (UPFB) combining ultrasound (US) with plasma functionalized buffer (PFB). Results showed that UPFB was more effective for inactivating bacteria when compared with individual applications of US or PFB with reductions of 3.92 and 3.70 log CFU/g for Escherichia coli and Listeria monocytogenes, respectively. Compared with the linear model, the three non-linear models presented comparable performances and were more suitable for describing the inactivation kinetics with superior adj-R² (0.962-0.999), accuracies (0.970-1.006) and bias factors (0.995-1.031), and by assessing the strengths of evidence, weights of evidence and evidence ratios for the models, the biphasic model was identified as the best fit model. The current study provided new insights into the effective evaluation of decontamination methods.

Removal of Alternaria mycotoxins exposed to different food components by cold plasma

Alternariol (AOH) and alternariol monomethyl ether (AME), the two Alternaria mycotoxins with the highest outbreak rates in food systems, could be effectively reduced by cold plasma. This research evaluated the impact of food components on the plasma removal of AOH and AME. The results showed that 6% whey protein or ovalbumin almost completely inhibited the reduction of AOH or AME. Polyphenols inhibited the removal of AOH and AME by up to 90.8% and 83.4%, respectively. Organic acids and Vc reduced AME removal by up to 43.4% and 31.9%, respectively, but had little effect on AOH removal. Sugars and amino acids could decrease both toxin removal by less than 10%. Proteins exhibited the most inhibitory effect on plasma removal of AOH and AME, followed by polyphenols, while the effect of other components was relatively small. AOH and AME removal by cold plasma was highly related to H₂O₂ produced during plasma discharge.

Subcellular damages of Colletotrichum asianum and inhibition of mango anthracnose by dielectric barrier discharge plasma

Colletotrichum asianum (C. asianum) is a new pathogenic fungus that causes mango anthracnose. Cold plasma is a novel non-thermal decontamination technology, which has been proven to be effective in controlling postharvest fungus. Herein, dielectric barrier discharge (DBD) plasma was used to treat C. asianum spores in sterile phosphate-buffered saline, the damages in subcellular structures of C. asianum and inhibition of mango anthracnose were evaluated. Results showed that after 9 min treatment, the spore germination rate and spore viability were decreased by 95.48% and 98.82%, respectively, and the subcellular structures were damaged (P < 0.05), leading to spores death. Besides, DBD plasma treatments could control mango anthracnose and maintain mango quality, and the disease incidence and lesion diameter of mango treated for 9 min were decreased by 48.00% and 62.95%, respectively. Therefore DBD plasma inactivated C. asianum spore, providing an alternative technique for preventing and controlling mango anthracnose.

Liquid-type plasma-controlled in situ crosslinking of silk-alginate injectable gel displayed better bioactivities and mechanical properties

Silk is a promising biomaterial for injectable hydrogel, but its long-gelation time and cytotoxic crosslinking methods are the main obstacles for clinical application. Here, we purpose a new in situ crosslinking technique of silk-alginate (S-A) injectable hydrogel using liquid-type non-thermal atmospheric plasma (LTP) in vocal fold (VF) wound healing. We confirmed that LTP induces the secondary structure of silk in a dose-dependent manner, resulting in improved mechanical properties. Significantly increased crosslinking of silk was observed with reduced gelation time. Moreover, controlled release of nitrate, an LTP effectors, from LTP-treated S-A hydrogel was detected over 7 days. In vitro experiments regarding biocompatibility showed activation of fibroblasts beyond the non-cytotoxicity of LTP-treated S-A hydrogels. An in vivo animal model of VF injury was established in New Zealand White rabbits. Full-thickness injury was created on the VF followed by hydrogel injection. In histologic analyses, LTP-treated S-A hydrogels significantly reduced a scar formation and promoted favorable wound healing. Functional analysis using videokymography showed eventual viscoelastic recovery. The LTP not only changes the mechanical structures of a hydrogel, but also has sustained biochemical effects on the damaged tissue due to controlled release of LTP effectors, and that LTP-treated S-A hydrogel can be used to enhance wound healing after VF injury.

Functional and bioactive properties of Larimichthys polyactis protein hydrolysates as influenced by plasma functionalized water-ultrasound hybrid treatments and enzyme types

The effects of plasma functionalized water (PFW) and its combination with ultrasound (UPFW) on the functional and bioactive properties of small yellow croaker protein hydrolysates (SYPHs) produced from three enzymes were investigated. Fluorescence and UV-Vis spectroscopy indicated that SYPHs tended to unfold with increasing intensity and shift in wavelengths to more flexible conformations under PFW and UPFW treatments. Particle size distribution and microstructure analysis revealed that treatments could disrupt aggregation of protein molecules to increase the roughness, specific surface area, and decrease the particle size of peptides during hydrolysis. The partially denatured structure of SYPHs induced by treatments increased the susceptibility of the fish proteins to exogenous enzymes, thereby accelerating the hydrolytic process to yield peptides with improved solubility, decreased emulsifying and foaming properties, and improved enzyme-specific antioxidant properties. The results revealed that the functionality of SYPHs was influenced by the treatment method and the enzyme type employed.

Effects of combined treatment of plasma activated liquid and ultrasound for degradation of chlorothalonil fungicide residues in tomato

The effects of combined treatment (PAL-U) of plasma-activated liquid (PAL) including plasma-activated water (PAW) and plasma-activated buffer solution (PABS) and ultrasound (U) for the degradation of chlorothalonil fungicide on tomato fruit was investigated. Distilled water and buffer solution were activated by radiofrequency plasma jet for durations of 1, 3, 5, and 10 min to obtain PAL₁ to PAL₁₀. Fruits were immersed in PAL for 15 min and also in distilled water with sonication for 15 min for individual treatments, and in PAL with sonication for 15 min for combined treatments. The maximum chlorothalonil fungicide residues were reduced by 89.28 and 80.23% for PAW₁₀-U and PABS₁₀-U, respectively. HPLC-MS characterization revealed chlorothalonil degradation pathway and formation of 2,4,5-trichloroisophthalonitrile, 2,4-dichloroisophthalonitrile, 4-chloroisophthalonitrile, isophthalonitrile and phenylacetonitrile as degradation products. Treatments also showed no negative effects on tomato quality. Therefore, PAL and PAL-U treatments could serve as effective methods for degrading pesticides on tomatoes.

Faba bean protein: A promising plant-based emulsifier for improving physical and oxidative stabilities of oil-in-water emulsions

Faba bean is a protein-rich, sustainable, but understudied legume. Faba bean protein isolates (FBPIs) can serve as promising emulsifiers. This review aims to summarize the research on FBPIs as emulsifiers and various modification methods to improve the emulsifying functionalities. The emulsifying activities of FBPIs depend on several physiochemical characteristics (e.g. solubility, surface hydrophobicity, surface charge, interfacial activity). Physical modifications, especially via linking FBPIs electrostatically to polysaccharides can effectively increase the interfacial layer thickness/compactness and maintain the interfacial protein adsorption. Chemical modifications of FBPIs (e.g. acetylation and Maillard reaction) could improve the interfacial activity and affect the droplet-size distribution. Enzymatic modifications, usually either via hydrolysis or cross-linking, help to optimize the molecular size, solubility, and surface hydrophobicity of FBPIs. It is critical to consider the lipid/protein oxidative stability and physical stability when optimizing the emulsifying functionality of FBPIs. With suitable modifications, FBPI can serve as a promising emulsifier in food production.

An overview of tropomyosin as an important seafood allergen: Structure, cross-reactivity, epitopes, allergenicity, and processing modifications

Tropomyosin (TM) is a major allergen in crustaceans, which often causes allergy and is fatal to some consumers. Currently, the most effective treatment is to avoid ingesting TM, although most adverse events occur in accidental ingestion. In this review, the molecular characterization, epitopes, cross-reactivity, and pathogenesis of TM are introduced and elucidated. Modification of TM by traditional processing methods such as heat treatment and enzymatic hydrolysis, and innovative processing technologies including high-pressure treatment, cold plasma (CP), ultrasound, pulsed electric field (PEF), pulsed ultraviolet, microwave and irradiation are discussed in detail. Particularly, enzymolysis, PEF, and CP technologies show great potential for modifying TM and more studies are needed to verify their effectiveness for the seafood industry. Possible mechanisms and the advantages/disadvantages of these technologies for the mitigation of TM allergenicity are also highlighted. Further work should be conducted to investigate the allergenicity caused by protein segments such as epitopes, examine the interaction sites between the allergen and the processing techniques and reveal the reduction mechanism of allergenicity.