Bioconversion of swine manure into high-value products of medium chain fatty acids

Enhancement of caproate production via carboxylate chain elongation with sequential fermentation facilitated by biochar: A corn stover full-component utilization perspective

In this study, caproate was synthesized from corn stover through sequential fermentation, and biochar was prepared from unhydrolyzable corn stover by pyrolysis to utilize full-component of corn stover. The results indicate that the caproate concentration in the unhydrolyzable corn stover biochar (UCSB) group was 2.2 times higher than that of the control group, and the fermentation start-up time was shortened by 18 days. Mechanistic analysis suggested that the rough surface of UCSB facilitated microbial colonization and reduced product inhibition. Genes expression analysis further demonstrated that UCSB significantly upregulated crucial functional genes responsible for ethanol oxidation and the reverse β-oxidation pathway, ultimately resulting in enhanced caproate production. The successful utilization of UCSB derived from unhydrolyzable solid residue effectively boosted fermentation, leading to a 37 % increase in the carbon utilization efficiency of corn stover. This study offering valuable insights for the high-value and full-component utilization of lignocellulosic biomass.

Anaerobic co-biodegradation of polyhydroxyalkanoate and swine manure for volatile fatty acid production: The impact of C/N ratios and microbial dynamics

Polyhydroxyalkanoate (PHA) is the important biodegradable plastic, however, biodegradation of PHA waste in anaerobic environments emits more CH4, a potent greenhouse gas. Bioconversion of PHA waste to useful byproducts - volatile fatty acids (VFAs) is a practical method to upcycle carbon from PHA. In this study, PHA waste was anaerobically co-digested with swine manure (SM) (the typical high nitrogen waste) at different C/N ratios. The results indicate that co-digestion of PHA and SM with a C/N ratio of 32.1 achieved VFA production of 5488 mg COD/L and 0.20 g COD/g VS. No significant differences were found in terms of the highest VFA concentrations between treatments with C/N ratios of 43.4 and 32.1. VFA produciton of 3655 mg COD/L and 0.14 g COD/g VS was achieved at 19 days by adjusting the C/N ratio to 19.2. Four bacteria were identified as dominant microorganisms responsible for converting PHA and SM to VFA.

Caproic acid production from short-chained carboxylic acids produced by arrested anaerobic digestion of green waste: Development and optimization of a mixed caproic acid producing culture

Caproic acid is an important compound for producing a variety of chemicals and a potential precursor for Sustainable Aviation Fuels (SAF). This study aimed at developing a stable mixed culture producing caproic acid using short-chain carboxylic acids (SCCAs) derived from arrested anaerobic digestion (AAD) of green waste and optimizing chain elongation (CE) conditions. The results showed that the mixed culture was dominated by Clostridium sensu stricto 12 (53.09 %), optimally producing caproic acid at 37 °C, pH 7.20, with a 15 % inoculum concentration. Under these conditions, 75.59 % of the consumed electrons contributed to caproic acid formation. Gradual ethanol feeding in bioreactor experiments resulted in caproic acid titer of 13.36 g/L, with carbon conversion efficiency (CCE) of 81.91 % and electron transfer efficiency (ETE) of 76.39 %, surpassing batch experiments without gradual ethanol addition. These findings demonstrate that the effectiveness of a mixed culture can be improved, resulting in increased caproic acid production.

Conversion of wine lees and waste activated sludge into caproate and heptanoate: Thermodynamic and microbiological insights

In this study, wine lees and waste activated sludge (WAS) were co-fermented for the first time in a 4:1 ratio (COD basis) at 20, 40, 70 and 100 gCOD/L, in batch at 37 °C and pH 7.0. The substrates were successfully converted to caproate (C6) and heptanoate (C7) with a high selectivity (40.2 % at 40 gCOD/L). The rapidly-growing chain-elongating microbiome was enriched inClostridiaceaeandOscillospiraceae, representing together 3.4-8.8 % of the community. Substrate concentrations higher than 40 gCOD/L negatively affected C6 and C7 selectivities and yields, probably due to microbial inhibition by high ethanol concentrations (15.82-22.93 g/L). At 70 and 100 gCOD/L, chain elongation shifted from ethanol-based to lactate-based, with a microbiome enriched in the lactic acid bacteriaRoseburia intestinalis(27.3 %) andEnterococcus hirae(13.8 %). The partial pressure of H2(pH2) was identified by thermodynamic analysis as a fundamental parameter for controlling ethanol oxidation and improving C6 and C7 selectivities.

Effect of nanobubble water on medium chain carboxylic acids production in anaerobic digestion of cow manure

Nanobubble water promotes the degradation of difficult-to-degrade organic matter, improves the activity of electron transfer systems during anaerobic digestion, and optimizes the composition of anaerobic microbial communities. Therefore, this study proposes the use of nanobubble water to improve the yield of medium chain carboxylic acids produced from cow manure by chain elongation. The experiment was divided into two stages: the first stage involved the acidification of cow manure to produce volatile acidic fatty acids as electron acceptors, and the second phase involved the addition of lactic acid as an electron donor for the chain elongation. Three experimental groups were established, and air, H2, and N2 nanobubble water were added in the second stage. Equal amounts of deionized water were added in the control group. The results showed that nanobubble water supplemented with air significantly increased the caproic acid concentration to 15.10 g/L, which was 55.03 % greater than that of the control group. The relative abundances of Bacillus and Caproiciproducens, which are involved in chain elongation, and Syntrophomonas, which is involved in electron transfer, increased. The unique ability of air nanobubble water supplemented to break down the cellulose matrix resulted in further decomposition of the recalcitrant material in cow manure. This effect subsequently increased the number of microorganisms associated with lignocellulose degradation, increasing carbohydrate metabolism and ATP-binding cassette transporter protein activity and enhancing fatty acid cycling pathways during chain elongation. Ultimately, this approach enabled the efficient production of medium chain carboxylic acids.

Influence of pH and temperature on the performance and microbial community during the production of medium-chain carboxylic acids using winery effluents as substrate

Winery effluents containing high ethanol concentrations and diverse organic matter are ideal substrates for producing medium-chain carboxylic acids via fermentation and chain elongation. However, the process needs to be better understood. This study presents novel insights into the bioconversion mechanisms of medium-chain carboxylic acids by correlating fermentation and chain elongation kinetic profiles with the study of microbial communities at different pH (5 to 7) conditions and temperatures (30 to 40 °C). It was found that high productivities of MCCA were obtained using a native culture and winery effluents as a natural substrate. Minor pH variations significantly affected the metabolic pathway of the microorganisms for MCCA production. The maximal productivities of hexanoic (715 mg/L/d) and octanoic (350 mg/L/d) acids were found at pH 6 and 35 °C. Results evidence that the presence of Clostridium, Bacteroides, and Negativicutes promotes the high productions of MCCA. The formation of heptanoic acid was favor when Mogibacterium and Burkholderia were present.

Co-electron donors driven medium-chain fatty acids production: Roles of electron donors, reaction kinetics and metabolic pathways

Energy conversion of waste activated sludge alkaline fermentation liquor (WASAFL) to medium-chain fatty acids (MCFAs) is promising for sludge treatment and carbon recovery. However, the single electron donor (ED) fermentation for MCFAs production has irreparable defects. To resolve the respective shortcomings of single electron donor (ED) and improve the MCFAs production efficiency from WASAFL, a novel biotechnical process utilizing ethanol and lactate as co-EDs within different combination ratios were investigated. The results verified that MCFAs production was highest with ethanol to lactate ratio of 1:3 (6988.54 ± 208.18 mg COD/L), being 1.46 and 1.87 times of that with ethanol and lactate as single ED. The kinetic analysis results confirmed that ethanol to lactate ratio of 1:3 resulted in the highest MCFAs yield and formation rate. The microbial taxa results uncovered that the relative abundance of Sphaerochaeta and Haloimpatiens showed positive correlation with MCFAs production. The metabolic pathway analysis indicated that the ethanol oxidization, lactate oxidization, acrylate pathway, reverse β oxidization and fatty acid biosynthesis pathway might take place in the WASAFL fermentation system, contributing to the WASAFL-to-MCFAs conversion.

Advances in understanding entire process of medium chain carboxylic acid production from organic wastes via chain elongation

Chain elongation is an environmentally friendly biological technology capable of converting organic wastes into medium chain carboxylic acids (MCCAs). This review aims to offer a comprehensive analysis of MCCA production from organic wastes via chain elongation. Seven kinds of organic wastes are introduced and classified as easily degradable and hardly degradable. Among them, food waste, fruit and vegetable waste are the most potential organic wastes for MCCA production. Combined pretreatment technologies should be encouraged for the pretreatment of hardly degradable organic wastes. Furthermore, the mechanisms during MCCA production are analyzed, and the key influencing factors are evaluated, which affect the MCCA production and chain elongation efficiency indirectly. Extracting MCCA simultaneously is the most important way to improve MCCA production efficiency, and technologies for sequentially extracting different kinds of MCCAs are recommended. Finally, some perspectives for future chain elongation researches are proposed to promote the large-scale application of chain elongation.

From trash to treasure: Sourcing high-value, sustainable cellulosic materials from living bioreactor waste streams

The appreciation of how conventional and fossil-based materials could be harmful to our planet is growing, especially when considering single-use and non-biodegradable plastics manufactured from fossil fuels. Accordingly, tackling climate change and plastic waste pollution entails a more responsible approach to sourcing raw materials and the adoption of less destructive end-of-life pathways. Livestock animals, in particular ruminants, process plant matter using a suite of mechanical, chemical and biological mechanisms through the act of digestion. The manure from these "living bioreactors" is ubiquitous and offers a largely untapped source of lignocellulosic biomass for the development of bio-based and biodegradable materials. In this review, we assess recent studies made into manure-based cellulose materials in terms of their material characteristics and implications for sustainability. Despite the surprisingly diverse body of research, it is apparent that progress towards the commercialisation of manure-derived cellulose materials is hindered by a lack of truly sustainable options and robust data to assess the performance against conventional materials alternatives. Nanocellulose, a natural biopolymer, has been successfully produced by living bioreactors and is presented as a candidate for future developments. Life cycle assessments from non-wood sources are however minimal, but there are some initial indications that manure-derived nanocellulose would offer environmental benefits over traditional wood-derived sources.

A novel strategy for efficiently transforming waste activated sludge into medium-chain fatty acid using free nitrous acid

The global energy crisis is approaching due to rapid population growth and overexploitation of fossil fuels. Therefore, the development and use of new and renewable energy sources is already in the extreme urgency. This work developed a novel technology to efficiently produce renewable liquid bioenergy from discarded wastes, by effectively transforming sewage sludge into high-value medium chain fatty acids (MCFA). The maximum MCFA yield in the anaerobic sludge fermentation was revealed to be 10.6 times of control when utilizing sewage sludge with 1.78 mg-N/L free nitrous acid (FNA) pretreatment. The carbon flow from sewage sludge into MCFA in the fermentation system was significantly enhanced with appropriate levels (0.71-1.78 mg-N/L) of FNA pretreatment. Compared to FNA pretreatment, however, its direct addition severely inhibited total products (i.e., carboxylates and complex alcohols) generation because of the toxicity on live cells (decreasing to 8.3 %-13.9 %) in sludge. Kinetic models (one-substrate and two-substrate) were utilized to investigate the mechanism of MCFA promotion by FNA pretreatment on anaerobic sludge fermentation, in which linear relationship analysis between FNA-derived organic release and the fitted parameters were also performed. The results indicated that the conversion of refractory materials into rapidly bioavailable substrates for MCFA production contributed to increasing MCFA production rate and potential. Moreover, the relative abundances of functional microorganisms related to hydrolysis-acidification and chain elongation process increased under FNA pretreatment, further favoring the MCFA production. This study provides a novel and effective technology of sludge energy recovery that can achieve the next-generation sustainable sewage sludge management.

Revealing mechanism of micro-aeration for enhancing volatile fatty acids production from swine manure

Micro-aeration is considered a new strategy for improving volatile fatty acids (VFAs) production of agricultural waste. This study investigated the effect and mechanism of micro-aeration of air and oxygen (O₂) on VFAs production from swine manure. The results showed that Air-micro-aeration had the most significant improvement effect, with the highest VFAs of 8.21 g/L, which was increased by 22.4%. Moreover, the mixing effects of different micro-aeration were limited, and the microbial communities significantly varied. Firmicutes and Bacteroidota were the dominant hydrolytic and acidogenic bacteria, and Air-micro-aeration preferentially promoted electron transfer activity and energy generation. Methanosarcina, Methanocorpusculum, and Methanobrevibacter can adapt to environmental changes according to their different oxygen tolerance, and the consumption and conversion of VFAs by methanogens were slow under Air-micro-aeration condition. This study revealed mechanism of micro-aeration for improving VFAs production from swine manure, providing a theoretical basis for micro-aeration regulation optimization.

Antibiotic removal potential for low greenhouse gas emission process of anaerobic digestion (AD) producing volatile fatty acids (VFAs)

This study aimed to investigate the antibiotic of sulfachloropyridazine (SCP) reduction and its effects on volatile fatty acids (VFAs) accumulation and microbial community structures during the process of anaerobic digestion (AD) producing VFA. Results showed that initial SCP concentrations have a positive correlation with reduction of SCP and accumulation of VFAs. The removal rates of SCP were 22.21%, 30.00%, 39.31% and 42.59% and the maximum production of VFAs were 3947, 6180, 6462 and 6032 mg/L for initial SCP concentrations of 25, 50, 75 and 100 mg/kg·TS, respectively. SCP only altered bacterial composition by hastening growth of specific bacterial taxa, but didn't increase bacterial α-diversity.

Medium-chain fatty acids production from carbohydrates-rich wastewater through two-stage yeast biofilm processes without external electron donor addition: Biofilm development and pH impact

The production of medium-chain fatty acids (MCFAs) is considered promising for carbon resource recovery from waste streams. However, a large quantity of external electron donors are often required, causing great cost and environmental impact. Therefore, in this study, a two-stage technology was developed to produce MCFAs from carbohydrate-rich wastewater without external electron donor addition, with the biofilm development and pH impact being explored. Stage I aimed at converting organics into ethanol and a yeast biofilm reactor is innovatively applied. The results showed that the yeast biofilm could quickly form on carriers with steady-state thickness reaching 50-200 μm. However, the attachment of yeast biofilm was weak at the initial stage so that the violent turbulence should be avoided during operation. The polyurethane foam was the most suitable for yeast biofilm development among the tested carriers, as evidenced by the highest ethanol production, accounting for 74.2% of soluble organics. The Nakaseomyces was the main fungal genus in the steady-state biofilm, while lactic acid bacteria were also developed, resulting in lactate and acetate production. In Stage II, the yeast biofilm reactor effluent was applied for MCFA production at different pH (5-8). However, the MCFA production selectivity was significantly affected by pH, with 65.2% at pH of 5 but decreasing substantially to 3.0% at pH of 8. Both the microbial and electron transfer efficiency analysis suggested that mildly acidic pH can promote the electron transfer from ethanol toward the chain elongation process instead of its excessive oxidation. Thus, if conditions of online extraction or microbial tolerance permit, a lower pH should be recommended for Stage II in the developed technology as well as other ethanol-based MCFA production process. This is a conceptual study that eliminated external electron donor addition in MCFAs production and provide a sustainable and reliable way in carbon resources recovery.

Produce individual medium chain carboxylic acids (MCCA) from swine manure: Performance evaluation and economic analysis

Environmental issues caused by untreated animal manure require the development of resource recovery from waste through a circular economy approach. Producing medium chain carboxylic acids (MCCA) with higher value than biogas from manure has become promising. The objective of this study was to develop an effective individual MCCA produce process utilizing manure. In this study, animal manure was firstly anaerobic fermentation into short chain fatty acids (SCFA), then acidified manure and ethanol were fed into the chain elongation reactor with gradually increasing the organic loading rate (OLR) from 7.0 to 18.5 gCOD/L/d, and the mixed MCCA was separated individually via a fractional distillation process. The SCFA fermentation occurred mainly at the first 10 days, and the optimum concentrations of SCFA for treatments at 2 %VS, 4 %VS and 6 %VS were 6.58, 10.40 and 14.10 g/L, respectively. For the chain elongation reactor, the maximum concentrations of n-caproate and n-caprylate were 10.25 and 0.63 g/L, respectively, which were comparable with that obtained from other complex wastes. Over 90% MCCA can be recovered from the fermentation broth via the optimized extractant of methyl tert-butyl ether (MTBE) and the fractional distillation system. Preliminary economic analysis shows that this MCCA production process presented a higher economic benefit (9.25 $/m³ manure) than traditional biogas production (2.65 $/m³ manure), making MCCA production from swine manure economically competitive. This work provides a new route for manure resource recovery besides the biogas process.

Performance and Mechanism of Fe3O4 Improving Biotransformation of Waste Activated Sludge into Liquid High-Value Products

This study demonstrated that Fe₃O₄ simultaneously improves the total production and formation rate of medium-chain fatty acids (MCFAs) and long-chain alcohols (LCAs) from waste activated sludge (WAS) in anaerobic fermentation. Results revealed that when Fe₃O₄ increased from 0 to 5 g/L, the maximal MCFA and LCA production increased significantly, and the optimal fermentation time was also remarkably shortened from 24 to 9 days. Moreover, Fe₃O₄ also enhanced WAS degradation, and the corresponding degradation rate in the fermentation system increased from 43.86 to 72.38% with an increase in Fe₃O₄ from 0 to 5 g/L. Further analysis showed that Fe₃O₄ promoted the microbe activities of all the bioprocesses (including hydrolysis, acidogenesis, and chain elongation processes) involved in the MCFA and LCA production from WAS. Microbial community analysis indicated that Fe₃O₄ increased the abundances of key microbes involved in abovementioned bioprocesses correspondingly. Mechanistic investigations showed that Fe₃O₄ increased the conductivity of the fermented sludge, providing a better conductive environment for the anaerobic microbes. The redox cycle of Fe(II) and Fe(III) existed in the fermentation system with Fe₃O₄, which was likely to act as electron shuttles to conduct electron transfer (ET) from the electron donor to the acceptor, thus increasing ET efficiency. This study provides an effective method for enhancing the biotransformation of WAS into high-value products, potentially bringing economic benefits to WAS treatment.

Metabolic cascade of complex organic wastes to medium-chain carboxylic acids: A review on the state-of-the-art multi-omics analysis for anaerobic chain elongation pathways

Medium-chain carboxylic acid (MCCA) production from organic wastes has attracted much attention because of their higher energy contents and diverse applications. Anaerobic reactor microbiomes are stable and resilient and have resulted in efficient performance during many years of operation for thousands of full-scale anaerobic digesters worldwide. The method underlying how the relevant microbial pathways contribute to elongate carbon chains in reactor microbiomes is important. In particular, the reverse β-oxidation pathway genes are critical to upgrading short-chain fermentation products to MCCAs via a chain elongation (CE) process. Diverse genomics and metagenomics studies have been conducted in various fields, ranging from intracellular metabolic pathways to metabolic cascades between different strains. This review covers taxonomic approach to culture processes depending on types of organic wastes and the deeper understanding of genome and metagenome-scale CE pathway construction, and the co-culture and multi-omics technology that should be addressed in future research.

Biological production of medium-chain carboxylates through chain elongation: An overview

Medium chain carboxylates (MCCs) have wide applications in various industries, but the traditional MCCs production methods are costly and unsustainable. Anaerobic fermentation offers a more scalable, economical and eco-friendly platform for producing MCCs through chain elongation which converts short chain carboxylates and electron donor into more valuable MCCs. However, the underlying microbial pathways are not well understood. In this review, biological production of MCCs through chain elongation is introduced elaborately, including the metabolic pathways, electron donor and substrates, microorganisms and influencing factors. Then, the strategies for enhancing MCCs production are extensively analyzed and summarized, along with the technologies for MCCs separation from the fermentation broth. Finally, challenges and perspectives concerning the large-scale MCCs production are proposed, providing suggestions for the future research. Extensive review demonstrated that anaerobic fermentation has great potential in achieving economical and sustainable MCCs production from complex organic substrates, including organic waste streams, which would significantly broaden the application of MCCs, especially in the renewable energy field. An interdisciplinary approach with knowledge from microbiology and biochemistry to chemical separations and environmental engineering is required to use this promising technology as a valorization method for converting organic biomass or organic wastes into valuable MCCs.

Opportunities and challenges in microbial medium chain fatty acids production from waste biomass

Medium chain fatty acids (MCFAs) that produced from affordable waste biomass via chain elongation (CE) technology are recognized as the potential alternatives to part fossil-derived chemicals, contributing to the sustainable development of economy and environment. The purpose of this review is to provide comprehensive analyses on the opportunities and challenges of MCFAs production and application. First, both two microbial MCFAs synthesis pathways of reverse β-oxidation and fatty acid biosynthesis were introduced/compared in detail to give readers a thorough understanding of the CE process, with the expectation of further boosting MCFAs production by well distinguishing them. Furthermore, the six key MCFAs production bottlenecks, corresponding research progresses, and possible solutions were analyzed. Five major MCFAs production strategies with their production mechanism, performances, and characteristics were also critically assessed. Additionally, the commercial production status was introduced, and future alternative production mode and research priorities were also recommended.

Optimization of lactate production from co-fermentation of swine manure with apple waste and dynamics of microbial communities

Co-anaerobic fermentation (co-AF) of swine manure (SM) and apple waste (AW) has been proved to be beneficial for lactic acid (LA) production. In order to further improve the LA production, three important parameters, namely AW in feedstock, temperature, volatile solids (VS) of feedstock, were evaluated using Box-Behnken design and response surface methodology. The quadratic regression model was developed and interactive effects was found between the three parameters. Results showed that the maximum concentration, 31.18 g LA/L (with LA yield of 0.62 g/g VS), was obtained under optimum conditions of 60.4% AW in feedstock, 34.7 ℃, and 5.0% VS. At the optimum conditions, the solubilization of organic matter was enhanced compared with mono-fermentation of SM. Microbial community structure of the reactor diverged greatly with fermentation time. Clostridium and Lactobacillus were dominant bacteria in the fermentation process, resulting in a remarkably LA accumulation.

Adaptability of a caproate-producing bacterium contributes to its dominance in an anaerobic fermentation system

The transformation of diverse feedstocks into medium-chain fatty acids (MCFAs) by mixed cultures is a promising biorefinery route because of the high value of MCFAs. A particular concern is how to maintain the microbial consortia in mixed cultures to achieve stable MCFA production. Chinese strong aroma-type liquor (Baijiu) fermentation system continually produces caproic acid for decades through a spontaneous inoculation of anaerobes from pit mud into fermented grains. Therefore, illuminating the dominant caproate-producing bacterium (CPB) in pit mud and how the CPB sustains in the spontaneous fermentation system will benefit to reveal the microbiological mechanisms of the stable caproate production. Here, we examined pit mud samples across four Chinese strong aroma-type Baijiu producing areas and found that a caproate-producing Caproicibacterium sp. was widely distributed in these distilleries with relative abundance ranging from 1.4% to 35.5% and an average abundance of 11.4%. Through controlling carbon source availability, we achieved different simplified caproate-producing consortia and found that the growth advantage of Caproicibacterium sp. was highly dependent on glucose. Then two strains, named Caproicibacterium sp. LBM19010 and Caproicibacterium sp. JNU-WLY1368, were isolated from pit mud of two regions. The metabolic versatility of this bacterium utilizing starch, maltose, glucose and lactate reflected its adaptability to the fermentation environment where these carbon sources coexist. The simultaneous utilization of glucose and lactate contributed to the balance between cell growth and pH homeostasis. This study reveals that multiple adaptation strategies employed by the predominant CPB promotes its stability and dominance in a saccharide- and lactate-rich anaerobic habitat. IMPORTANCE Chinese strong aroma-type liquor (Baijiu) fermentation environment is a typical medium-chain fatty acid producing system with complex nutrients. Although several studies have revealed the correlation between microbial community composition and abiotic factors, the adaptation mechanisms of dominant species to abiotic environment are still unknown in this special anaerobic habitat. This study identified the predominant CPB in Chinese strong aroma-type Baijiu fermentation system. Metabolic versatility and flexibility of the dominant CPB with a small-size genome indicated that this bacterium can effectively exploit available carbon and nitrogen sources, which could be a key factor to promote its ecological success in a multi-species environment. The understanding of growth and metabolic features of CPB responsible for its dominance in microbial community will not only contribute to the improvement of Chinese strong aroma-type Baijiu production but also expand its potential industrial applications in caproate production.

Fermentation of Organic Residues to Beneficial Chemicals: A Review of Medium-Chain Fatty Acid Production

Medium-chain fatty acids (MCFAs) have a variety of uses in the production of industrial chemicals, food, and personal care products. These compounds are often produced through palm refining, but recent work has demonstrated that MCFAs can also be produced through the fermentation of complex organic substrates, including organic waste streams. While “chain elongation” offers a renewable platform for producing MCFAs, there are several limitations that need to be addressed before full-scale implementation becomes widespread. Here, we review the history of work on MCFA production by both pure and mixed cultures of fermenting organisms, and the unique metabolic features that lead to MCFA production. We also offer approaches to address the remaining challenges and increase MCFA production from renewable feedstocks.