Efficient extracellular production of recombinant Escherichia coli heat-labile enterotoxin B subunit by using the expression/secretion system of Bacillus brevis and its mucosal immunoadjuvanticity

Expression of Escherichia coli Heat-Labile Enterotoxin B Subunit in Centella (Centella asiatica (L.) Urban) via Biolistic Transformation

BACKGROUND

Heat-Labile enterotoxin B subunit (LTB) produced by Escherichia coli, a non-toxic protein subunit with potential biological properties, is a powerful mucosal and parenteral adjuvant which can induce a strong immune response against co-administered antigens.

OBJECTIVE

In the present study, LTB protein, encoded by the optimized ltb (also known synthetic ltb, s-ltb) gene in centella plant (Centella asiatica) for use as an antigen, has been discussed.

METHODS

The s-ltb gene was cloned into a plant expression vector, pMYO51, adjacent to the CaMV 35S promoter and was then introduced into centella plant by biolistic transformation. PCR amplification was conducted to determine the presence of s-ltb gene in the transgenic centella plant. The expression of s-ltb gene was analyzed by immunoblotting and quantified by ELISA. In vitro activity of LTB protein was determined by GM1-ELISA.

RESULTS

PCR amplification has found seven transgenic centella individuals. However, only five of them produced LTB protein. ELISA analysis showed that the highest amount of LTB protein detected in transgenic centella leaves was about 0.8% of the total soluble protein. GM1-ELISA assay indicated that plant LTB protein bound specifically to GM1-ganglioside, suggesting that the LTB subunits formed active pentamers.

CONCLUSION

The s-ltb gene that was successfully transformed into centella plants by the biolistic method has produced a relatively high amount of plant LTB protein in the pentameric quaternary structure that has GM1-ganglioside binding affinity, a receptor on the intestinal epithelial membrane.

Controlled expression of cholera toxin B subunit from Vibrio cholerae in Escherichia coli

The ctxB gene, the causative agent of cholera epidemic was successfully cloned from V. cholerae in E. coli. The insertion of the gene was confirmed by PCR as well as restriction digestion analyses. The sequencing results for the gene confirmed that the insert was in the correct orientation and in-frame with the P(BAD) promoter and it showed that the gene was 99% homologous to the published ctxB sequence. The CTB protein was successfully expressed in E. coli using the pBAD/His vector system. The expected protein of approximately 14 kDa was detected by SDS-PAGE and Western blot. The use of pBAD/His vector to express the cholera toxin gene in E. coli would facilitate future study of toxin gene products.

Bacillus subtilis as a tool for vaccine development: from antigen factories to delivery vectors

Bacillus subtilis and some of its close relatives have a long history of industrial and biotechnological applications. Search for antigen expression systems based on recombinant B. subtilis strains sounds attractive both by the extensive genetic knowledge and the lack of an outer membrane, which simplify the secretion and purification of heterologous proteins. More recently, genetically modified B. subtilis spores have been described as indestructible delivery vehicles for vaccine antigens. Nonetheless both production and delivery of antigens by B. subtilis strains face some inherent obstacles, as unstable gene expression and reduced immunogenicity that, otherwise, can be overcome by already available gene technology approaches. In the present review we present the status of B. subtilis-based vaccine research, either as protein factories or delivery vectors, and discuss some alternatives for a better use of genetically modified strains.

Expression of the B subunit of E. coli heat-labile enterotoxin in the chloroplasts of plants and its characterization

Transgenic chloroplasts have become attractive systems for heterologous gene expressions because of unique advantages. Here, we report a feasibility study for producing the nontoxic B subunit of Escherichia coli heat-labile enterotoxin (LTB) via chloroplast transformation of tobacco. Stable site-specific integration of the LTB gene into chloroplast genome was confirmed by PCR and genomic Southern blot analysis in transformed plants. Immunoblot analysis indicated that plant-derived LTB protein was oligomeric, and dissociated after boiling. Pentameric LTB molecules were the dominant molecular species in LTB isolated from transgenic tobacco leaf tissues. The amount of LTB protein detected in transplastomic tobacco leaf was approximately 2.5% of the total soluble plant protein, approximately 250-fold higher than in plants generated via nuclear transformation. The GM1-ELISA binding assay indicated that chloroplast-synthesized LTB protein bound to GM1-ganglioside receptors. LTB protein with biochemical properties identical to native LTB protein in the chloroplast of edible plants opens the way for inexpensive, safe, and effective plant-based edible vaccines for humans and animals.

Mucosal and systemic antibody responses against an acellular pertussis vaccine in mice after intranasal co-administration with recombinant cholera toxin B subunit as an adjuvant

To investigate the possibility of intranasal immunization with an acellular pertussis vaccine, groups of mice were administered intranasally with aluminium-non-adsorbed pertussis toxoid (PTd; 0.5 or 5 microg) and formalin-treated filamentous hemagglutinin (fFHA; 5 microg) with and without recombinant cholera toxin B subunit (rCTB; 10 microg) as a mucosal adjuvant. At a low concentration of PTd, the following things became clear: (1) earlier and higher elevation of serum anti-PTd and anti-FHA IgG antibody titres in the presence of rCTB than in its absence, (2) higher serum anti-PTd and anti-FHA IgG antibody titres than 200 and 100 ELISA units ml(-1) (EU ml(-1)) in all mice, respectively, in the presence of rCTB, which were obtained by calibration against a reference anti-pertussis mouse serum, and (3) in an intranasal challenge experiment with Bordetella pertussis, slightly more rapid elimination of the bacteria from the lungs of mice intranasally immunized in the presence of rCTB, suggesting the effectiveness of rCTB as a mucosal adjuvant. However, irrespective of rCTB and dose of PTd, mice which were immunized four times and sacrificed on day 35 developed high levels of anti-PTd serum IgG antibodies, high or moderate levels of anti-FHA serum IgG antibodies and mucosal anti-PTd IgA antibodies in the lungs; only a slight or no increase of anti-FHA mucosal IgA antibodies was observed in the lung. These facts suggested the immunogenicity and mucosal adjuvanticity of PTd, and therefore, the mucosal adjuvanticity of rCTB seemed to be inconspicuous. Moreover, the addition of rCTB induced higher anti-PTd serum IgE antibody responses than no addition of it depending on dose of PTd. These results show that dose of PTd included in an acellular pertussis vaccine had better be low as possible and the addition of rCTB may not be always necessary in case of this nasal vaccine alone unlike tetanus and diphtheria toxoids and hepatitis B virus vaccine reported before.

Mucosal immunoadjuvant activity of the low toxic recombinant Escherichia coli heat-labile enterotoxin produced by Bacillus brevis for the bacterial subunit or component vaccine in pigs and cattle

A gene encoding the mature Escherichia coli heat-labile enterotoxin (LT) lacking the nick site in the A subunit by deleting tripeptides was introduced in a vector pNH301 and expressed extracellularly as mutant molecule of holotoxin at high levels in Bacilus brevis HPD31-S5 of the host bacterium. The mucosal adjuvant activities of the produced mutant LT (mLT) preparation were studied in pigs and cattle. Intranasal immunization of pigs with the recombinant subunit vaccine of Erysipelothrix rhusiopathiae or the component vaccine of Bordetella bronchiseptica mixed with the mLT resulted in a substantial enhancement of both mucosal and serum-specific antibody levels. The immunized pigs were also protected when challenge-exposed intradermally with a highly virulent E. rhusiopathiae strain or challenge-exposed intranasally with a highly virulent strain of B. bronchiseptica. The mLT intranasally administered with recombinant intimin (an outer membrane adhesin) of E. coli O157:H7 also induced an elevation of IgA-specific antibody in the nasal secretion and saliva of calves as well as an elevation of IgG1-specific antibody level against the intimin in the sera and colostrum of cows. The three kinds tested protein antigens were poorly immunogenic when antigen administered intranasally alone. The mLT intranasally administered at a higher effective dose did not induce local adverse reactions or diarrhea in pigs and cattle. The present study demonstrates that the recombinant mLT produced using the B. brevis expression system might represent promising immunoadjuvants for the potential application of intranasal vaccines directed against infectious diseases in pigs and cattle.

Mucosal immunization against hepatitis B virus by intranasal co-administration of recombinant hepatitis B surface antigen and recombinant cholera toxin B subunit as an adjuvant

Recombinant cholera toxin B subunit (rCTB) produced by Bacillus brevis carrying pNU212-CTB has been previously found to be a potent mucosal adjuvant to aluminium-non-adsorbed tetanus toxoid (nTT) and diphtheria toxoid (nDT) co-administered intranasally, and the possibility of needle-free inoculation of these vaccines with rCTB has been suggested. In this paper we examined the potentiality of rCTB as a mucosal adjuvant to aluminium-non-adsorbed yeast-derived recombinant hepatitis B surface antigen (rHBs) being a particulate antigen when administered intranasally with rCTB. In-house ELISA showed that a mixture of rHBs (1 or 5 microg) and rCTB (10 microg) elevated not only systemic responses but also mucosal immune responses at the nasal cavity, the lung, the saliva, the small intestine and the vagina against rHBs, and these could be further increased with higher doses of antigen. With antibody isotypes of IgG, there were equally high levels of serum HBs-specific IgG1, IgG2a and IgG2b antibodies and induction of mixed Th1- and Th2-type responses was considered to occur in combination of rHBs and rCTB. Serum anti-HBs titres in almost all mice obtained from sandwich EIA using a commercial kit were higher than 1000 milli-international units ml(-1) (mIU ml(-1)). These results show that rCTB is also very effective as a mucosal adjuvant for a particulate antigen like rHBs, as well as soluble antigens like nTT and nDT reported previously, suggesting the possibility of intranasal immunization with rHBs plus rCTB in humans.