1
|
Sylvers J, Wang Y, Yuan F. Nuclear Entry of DNA and Transgene Expression in Dividing and Non-dividing Cells. Cell Mol Bioeng 2023; 16:459-474. [PMID: 38099212 PMCID: PMC10716082 DOI: 10.1007/s12195-023-00784-w] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/02/2023] [Accepted: 09/03/2023] [Indexed: 12/17/2023] Open
Abstract
Introduction Plasmid DNA (pDNA) must be delivered into the nucleus for transgene expression in mammalian cells. The entry may happen passively during the nuclear envelope breakdown and reformation in dividing cells or actively through the nuclear pore complexes. The goal of this study was to investigate the relative importance of these two pathways for pDNA nuclear entry and subsequent gene expression. Methods To measure nuclear entry of pDNA encoding enhanced green florescence protein (EGFP) in electrotransfected cells, we developed a sensitive technique for quantitative analysis of pDNA in the nuclei, based on a hybridization probe for pDNA detection at the single molecule level and automatic image analysis. In matched experiments, we used an mRNA targeted hybridization probe to quantify reporter mRNA expression per cell, and flow cytometry to quantify expression of EGFP. Results We discovered two distinct patterns of pDNA distribution in the nuclei: punctate and diffuse, which were dominant in arrested and unarrested cells, respectively. The cell cycle arrest decreased diffuse pDNA and increased punctate pDNA. Its net effect was a decrease in the total intranuclear pDNA. Additionally, the cell cycle arrest increased the reporter mRNA synthesis but had no substantial impact on reporter protein expression. Conclusion Results from the study demonstrated that the efficient nuclear entry of pDNA during cell division did not necessarily lead to a high level of transgene expression. They also suggested that the punctate pDNA was more transcriptionally active than diffuse pDNA in the nuclei. These data will be useful in future studies for understanding mechanisms of nonviral gene delivery.
Collapse
Affiliation(s)
- Justin Sylvers
- Department of Biomedical Engineering, Duke University, Durham, NC 27708 USA
| | - Yifei Wang
- Department of Biomedical Engineering, Duke University, Durham, NC 27708 USA
| | - Fan Yuan
- Department of Biomedical Engineering, Duke University, Durham, NC 27708 USA
| |
Collapse
|
2
|
Guo J, Guo C, Xu L, Jia J, Jia R. Enhanced transfection efficiency by using a novel semi-attachment method in cell line and primary cells. Anal Biochem 2019; 587:113465. [PMID: 31585099 DOI: 10.1016/j.ab.2019.113465] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/11/2019] [Revised: 09/24/2019] [Accepted: 09/27/2019] [Indexed: 10/25/2022]
Abstract
DNA transfection in cells is a key technique in biological studies. Cationic liposomes can form nanoparticle complexes with DNA and are widely used for gene delivery in mammalian cells. However, the major drawback of cationic liposomes is their low transfection efficiency in hard-to-transfect cells, such as primary cultured cells. In this study, we established a novel semi-attachment transfection method that showed remarkably improved transfection efficiency compared with traditional forward transfection method.
Collapse
Affiliation(s)
- Jihua Guo
- The State Key Laboratory Breeding Base of Basic Science of Stomatology (Hubei-MOST) & Key Laboratory of Oral Biomedicine Ministry of Education, School & Hospital of Stomatology, Wuhan University, Wuhan, PR China; Department of Endodontics, School & Hospital of Stomatology, Wuhan University, Wuhan, PR China.
| | - Chen Guo
- The State Key Laboratory Breeding Base of Basic Science of Stomatology (Hubei-MOST) & Key Laboratory of Oral Biomedicine Ministry of Education, School & Hospital of Stomatology, Wuhan University, Wuhan, PR China.
| | - Lingfeng Xu
- The State Key Laboratory Breeding Base of Basic Science of Stomatology (Hubei-MOST) & Key Laboratory of Oral Biomedicine Ministry of Education, School & Hospital of Stomatology, Wuhan University, Wuhan, PR China.
| | - Jun Jia
- The State Key Laboratory Breeding Base of Basic Science of Stomatology (Hubei-MOST) & Key Laboratory of Oral Biomedicine Ministry of Education, School & Hospital of Stomatology, Wuhan University, Wuhan, PR China.
| | - Rong Jia
- The State Key Laboratory Breeding Base of Basic Science of Stomatology (Hubei-MOST) & Key Laboratory of Oral Biomedicine Ministry of Education, School & Hospital of Stomatology, Wuhan University, Wuhan, PR China.
| |
Collapse
|
3
|
Chen P, Demirji J, Ivleva VB, Horwitz J, Schwartz R, Arnold F. The transient expression of CHIKV VLP in large stirred tank bioreactors. Cytotechnology 2019; 71:1079-1093. [PMID: 31560090 DOI: 10.1007/s10616-019-00346-x] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/05/2019] [Accepted: 09/19/2019] [Indexed: 01/06/2023] Open
Abstract
Transient gene expression (TGE) bioprocesses have been difficult to scale up in large stirred tank bioreactors with volumes of more than 1.5 L. Low production levels are often observed, but the causes have not been investigated (Gutierrez-Granados et al. in Crit Rev Biotechnol 38:918-940, 2018). Chikungunya Virus-like particle (VLP), expressed by DNA-PEI transient transfection, is a representative case study for these difficulties. Clinical materials were produced in shake flasks, but the process suffered when transferred to large stirred tank bioreactors. The resulting process was not operationally friendly nor cost effective. In this study, a systematic approach was used to investigate the root causes of the poor scale up performance. The transfection conditions were first screened in ambr® 15 high throughput mini bioreactors then examined in 3 L stirred-tank systems. The studies found that production level was negatively correlated with inoculum cell growth status (P < 0.05). The pH range, DNA and PEI levels, order of the reagent addition, and gas-sparging systems were also studied and found to affect process performance. Further hydromechanical characterizations (Re, energy dissipation rates, and P/V, etc.) of shake flasks, ambr® 15, and 3-L stirred tank systems were performed. Overall, the study discovered that the shear stress (caused by a microsparger) and PEI toxicity together were the root causes of scale-up failure. Once the microsparger was replaced by a macrosparger, the scale-up was successful.
Collapse
Affiliation(s)
- Peifeng Chen
- Vaccine Production Program, Vaccine Research Center, National Institute of Allergy and Infectious Diseases, National Institutes of Health, 9 West Watkins Mill Rd, Gaithersburg, MD, 20878, USA.
| | - Jacob Demirji
- Vaccine Production Program, Vaccine Research Center, National Institute of Allergy and Infectious Diseases, National Institutes of Health, 9 West Watkins Mill Rd, Gaithersburg, MD, 20878, USA
| | - Vera B Ivleva
- Vaccine Production Program, Vaccine Research Center, National Institute of Allergy and Infectious Diseases, National Institutes of Health, 9 West Watkins Mill Rd, Gaithersburg, MD, 20878, USA
| | - Joe Horwitz
- Amicus Therapeutics, 1 Cedarbrook Dr, Cranbury, NJ, 08512, USA
| | | | - Frank Arnold
- Tunnell Consulting, 900 E. 8th Ave, King of Prussia, PA, 19406, USA
| |
Collapse
|
4
|
Novel chitosan based nanoparticles as gene delivery systems to cancerous and noncancerous cells. Int J Pharm 2019; 560:306-314. [PMID: 30797073 DOI: 10.1016/j.ijpharm.2019.02.016] [Citation(s) in RCA: 33] [Impact Index Per Article: 6.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/29/2018] [Revised: 01/14/2019] [Accepted: 02/08/2019] [Indexed: 11/22/2022]
Abstract
The present study aimed to investigate in vitro DNA transfection efficiency of three novel chitosan derivatives: thiolated trimethyl chitosan (TMC-Cys), methylated 4-N,N dimethyl aminobenzyl N,O carboxymethyl chitosan(MABCC) and thiolated trimethyl aminobenzyl chitosan(MABC-Cys). After polymer synthesis and characterization, nanoparticles were prepared using these polymers and their size, zeta potential and DNA condensing ability were measured. After that, cytotoxicity and transfection efficiency of nanocomplexes were carried out in three different cells. The results showed that all polymers could condense DNA plasmid strongly from N/P 2 and nanocomplexes had eligible sizes and zeta potentials. Moreover, the nanocomplexes had negligible cytotoxicity and MABC-Cys was the most effective vehicle for gene delivery in HEK-293T cells. In the two other cell lines, SKOV-3 and MCF-7, TMC-Cys exhibited the highest transfection efficiency. This study indicated that chemical structure of these novel chitosan derivatives in the interaction with the cell type can lead to successful gene delivery.
Collapse
|
5
|
Abstract
The widespread interest in cell synchronization is maintained by the studies of control mechanism involved in cell cycle regulation. During the synchronization distinct subpopulations of cells are obtained representing different stages of the cell cycle. These subpopulations are then used to study regulatory mechanisms of the cycle at the level of macromolecular biosynthesis (DNA synthesis, gene expression, protein synthesis), protein phosphorylation, development of new drugs, etc. Although several synchronization methods have been described, it is of general interest that scientists get a compilation and an updated view of these synchronization techniques. This introductory chapter summarizes: (1) the basic concepts and principal criteria of cell cycle synchronizations, (2) the most frequently used synchronization methods, such as physical fractionation (flow cytometry, dielectrophoresis, cytofluorometric purification), chemical blockade, (3) synchronization of embryonic cells, (4) synchronization at low temperature, (5) comparison of cell synchrony techniques, (6) synchronization of unicellular organisms, and (7) the effect of synchronization on transfection.
Collapse
|
6
|
Gutiérrez-Granados S, Cervera L, Kamen AA, Gòdia F. Advancements in mammalian cell transient gene expression (TGE) technology for accelerated production of biologics. Crit Rev Biotechnol 2018; 38:918-940. [DOI: 10.1080/07388551.2017.1419459] [Citation(s) in RCA: 32] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/13/2022]
Affiliation(s)
- Sonia Gutiérrez-Granados
- Departament d’Enginyeria Química, Biològica i Ambiental, Universitat Autònoma de Barcelona, Barcelona, Spain
| | - Laura Cervera
- Department of Bioengineering, McGill University, Montréal, Canada
| | - Amine A. Kamen
- Department of Bioengineering, McGill University, Montréal, Canada
| | - Francesc Gòdia
- Departament d’Enginyeria Química, Biològica i Ambiental, Universitat Autònoma de Barcelona, Barcelona, Spain
| |
Collapse
|
7
|
An integrated system for synchronous culture of animal cells under controlled conditions. Biotechniques 2016; 61:129-36. [PMID: 27625207 DOI: 10.2144/000114451] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/08/2016] [Accepted: 06/14/2016] [Indexed: 11/23/2022] Open
Abstract
The cell cycle has fundamental effects on cell cultures and their products. Tools to synchronize cultured cells allow the study of cellular physiology and metabolism at particular cell cycle phases. However, cells are most often arrested by methods that alter their homeostasis and are then cultivated in poorly controlled environments. Cell behavior could then be affected by the synchronization method and culture conditions used, and not just by the particular cell cycle phase under study. Moreover, only a few viable cells are recovered. Here, we designed an integrated system where a large number of cells from a controlled bioreactor culture is separated by centrifugal elutriation at high viabilities. In contrast to current elutriation methods, cells are injected directly from a bioreactor into an injection loop, allowing the introduction of a large number of cells into the separation chamber without stressful centrifugation. A low pulsation peristaltic pump increases the stability of the elutriation chamber. Using this approach, a large number of healthy cells at each cell cycle phase were obtained, allowing their direct inoculation into fully instrumented bioreactors. Hybridoma cells synchronized and cultured in this system behaved as expected for a synchronous culture.
Collapse
|
8
|
Merčun T, Žumer M, Aalberg T. Presenting bibliographic families using information visualization: Evaluation of FRBR-based prototype and hierarchical visualizations. J Assoc Inf Sci Technol 2016. [DOI: 10.1002/asi.23659] [Citation(s) in RCA: 15] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/10/2022]
Affiliation(s)
- Tanja Merčun
- Department of Library and Information Science and Book Studies; University of Ljubljana; Askerceva 2 1000 Ljubljana Slovenia
| | - Maja Žumer
- Department of Library and Information Science and Book Studies; University of Ljubljana; Askerceva 2 1000 Ljubljana Slovenia
| | - Trond Aalberg
- Department of Computer and Information Science; Norwegian University of Science and Technology; Sem Saelands vei 9 Trondheim Norway
| |
Collapse
|
9
|
Fiume G, Di Rienzo C, Marchetti L, Pozzi D, Caracciolo G, Cardarelli F. Single-cell real-time imaging of transgene expression upon lipofection. Biochem Biophys Res Commun 2016; 474:8-14. [DOI: 10.1016/j.bbrc.2016.03.088] [Citation(s) in RCA: 5] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/15/2016] [Accepted: 03/18/2016] [Indexed: 10/22/2022]
|
10
|
The heterogeneous nature of polyethylenimine-DNA complex formation affects transient gene expression. Cytotechnology 2016; 60:63. [PMID: 19649718 DOI: 10.1007/s10616-009-9215-y] [Citation(s) in RCA: 24] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/13/2009] [Accepted: 07/20/2009] [Indexed: 10/20/2022] Open
Abstract
Polyethylenimine has been used widely in transient gene expression with mammalian cells. To further understand its mediation of gene transfer, the transfection of HEK 293-F cells with dynamically prepared PEI/DNA complexes was studied with the help of fluorescent labeling. The efficiency of complex endocytosis/phagocytosis was found to correlate with the average sizes of complexes applied and complexes greater than 1 μm in diameter were likely excluded by the cells. Coupled with complex growth in size, the degree of association between PEI and DNA increased with the time of complex formation in the presence of competing ions. The blocking of transcription by complex formation necessitated complex dissociation in the nuclear environment for transcription to happen. Intracellularly, the fates of PEI complexed DNA therefore may be mostly determined by the degree of association. Results also suggested that the uptake of PEI/DNA complexes and subsequent protein expression were independent of the cell cycle stages of HEK 293-F cells.
Collapse
|
11
|
Optimized production of HIV-1 virus-like particles by transient transfection in CAP-T cells. Appl Microbiol Biotechnol 2015; 100:3935-47. [PMID: 26685677 DOI: 10.1007/s00253-015-7213-x] [Citation(s) in RCA: 26] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/27/2015] [Revised: 11/26/2015] [Accepted: 12/01/2015] [Indexed: 02/07/2023]
Abstract
HIV-1 virus-like particles (VLPs) have great potential as new-generation vaccines. The novel CAP-T cell line is used for the first time to produce Gag-GFP HIV-1 VLPs by means of polyethylenimine (PEI)-mediated transient transfection. CAP-T cells are adapted to grow to high cell densities in serum-free medium, and are able to express complex recombinant proteins with human post-translational modifications. Furthermore, this cell line is easily transfected with PEI, which offers the flexibility to rapidly generate and screen a number of candidates in preclinical studies. Transient transfection optimization of CAP-T cells has been performed systematically in this work. It is determined that for optimal production, cells need to be growing at mid-exponential phase, Protein Expression Medium (PEM) medium has to be added post-transfection, and cells can be transfected by independent addition of DNA and PEI with no prior complexation. A Box-Behnken experimental design is used to optimize cell density at time of transfection, DNA/cell and PEI/cell ratios. The optimal conditions determined are transfection at a density of 3.3E + 06 cells/mL with 0.5 pg of DNA/cell and 3 pg of PEI/cell. Using the optimized protocol, 6 × 10(10) VLP/mL are obtained, demonstrating that CAP-T is a highly efficient cell line for the production of HIV-1 VLPs and potentially other complex viral-based biotherapeutics.
Collapse
|
12
|
Kostyrko K, Bosshard S, Urban Z, Mermod N. A role for homologous recombination proteins in cell cycle regulation. Cell Cycle 2015; 14:2853-61. [PMID: 26125600 PMCID: PMC4614994 DOI: 10.1080/15384101.2015.1049784] [Citation(s) in RCA: 19] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/10/2015] [Accepted: 05/06/2015] [Indexed: 10/23/2022] Open
Abstract
Eukaryotic cells respond to DNA breaks, especially double-stranded breaks (DSBs), by activating the DNA damage response (DDR), which encompasses DNA repair and cell cycle checkpoint signaling. The DNA damage signal is transmitted to the checkpoint machinery by a network of specialized DNA damage-recognizing and signal-transducing molecules. However, recent evidence suggests that DNA repair proteins themselves may also directly contribute to the checkpoint control. Here, we investigated the role of homologous recombination (HR) proteins in normal cell cycle regulation in the absence of exogenous DNA damage. For this purpose, we used Chinese Hamster Ovary (CHO) cells expressing the Fluorescent ubiquitination-based cell cycle indicators (Fucci). Systematic siRNA-mediated knockdown of HR genes in these cells demonstrated that the lack of several of these factors alters cell cycle distribution, albeit differentially. The knock-down of MDC1, Rad51 and Brca1 caused the cells to arrest in the G2 phase, suggesting that they may be required for the G2/M transition. In contrast, inhibition of the other HR factors, including several Rad51 paralogs and Rad50, led to the arrest in the G1/G0 phase. Moreover, reduced expression of Rad51B, Rad51C, CtIP and Rad50 induced entry into a quiescent G0-like phase. In conclusion, the lack of many HR factors may lead to cell cycle checkpoint activation, even in the absence of exogenous DNA damage, indicating that these proteins may play an essential role both in DNA repair and checkpoint signaling.
Collapse
Affiliation(s)
- Kaja Kostyrko
- Institute of Biotechnology; University of Lausanne; and Center for Biotechnology UNIL-EPFL; Lausanne, Switzerland
| | - Sandra Bosshard
- Institute of Biotechnology; University of Lausanne; and Center for Biotechnology UNIL-EPFL; Lausanne, Switzerland
| | - Zuzanna Urban
- Institute of Biotechnology; University of Lausanne; and Center for Biotechnology UNIL-EPFL; Lausanne, Switzerland
| | - Nicolas Mermod
- Institute of Biotechnology; University of Lausanne; and Center for Biotechnology UNIL-EPFL; Lausanne, Switzerland
| |
Collapse
|
13
|
|
14
|
Boscolo S, Mion F, Licciulli M, Macor P, De Maso L, Brce M, Antoniou MN, Marzari R, Santoro C, Sblattero D. Simple scale-up of recombinant antibody production using an UCOE containing vector. N Biotechnol 2012; 29:477-84. [DOI: 10.1016/j.nbt.2011.12.005] [Citation(s) in RCA: 34] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/04/2011] [Revised: 07/20/2011] [Accepted: 12/17/2011] [Indexed: 01/25/2023]
|
15
|
Effect of addition of 'carrier' DNA during transient protein expression in suspension CHO culture. Cytotechnology 2012; 64:613-22. [PMID: 22415736 DOI: 10.1007/s10616-012-9435-4] [Citation(s) in RCA: 9] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/12/2011] [Accepted: 02/01/2012] [Indexed: 10/28/2022] Open
Abstract
Transient protein expression using polyethyleneimine as a transfection agent is useful for the rapid production of small amounts of recombinant proteins. It is known that an increase in extracellular DNA concentration during transfection can lead to a nonlinear increase in intracellular DNA concentration. We present an approach that hypothesizes that this nonlinearity can be used to decrease the amount of plasmid required for productive transfections. Through addition of non coding 'carrier' DNA to increase total DNA concentration during transfection, we report a statistically significant increase in protein (IgG) expression per unit plasmid used for transfection. This approach could be useful to increase protein yields for large scale transfections under conditions where plasmid availability is limited.
Collapse
|
16
|
Abstract
Widespread interest in cell synchronization is maintained by the studies of control mechanisms involved in cell cycle regulation. During the synchronization distinct subpopulations of cells are obtained representing different stages of the cell cycle. These subpopulations are then used to study regulatory mechanisms of the cycle at the level of macromolecular biosynthesis (DNA synthesis, gene expression, protein synthesis), protein phosphorylation, development of new drugs, etc. Although several synchronization methods have been described, it is of general interest that scientists get a compilation and an updated view of these synchronization techniques. This introductory chapter summarizes: (1) the basic concepts and principal criteria of cell cycle synchronizations, (2) the most frequently used synchronization methods, such as physical fractionation (flow cytometry, dielectrophoresis, cytofluorometric purification), chemical blockade, (3) synchronization of embryonic cells, (4) synchronization at low temperature, (5) comparison of cell synchrony techniques, (6) synchronization of unicellular organisms, and (7) the effect of synchronization on transfection.
Collapse
Affiliation(s)
- Gaspar Banfalvi
- Department of Microbial Biotechnology and Cell Biology, University of Debrecen, 4010, Debrecen, Hungary.
| |
Collapse
|
17
|
Broll S, Oumard A, Hahn K, Schambach A, Bode J. Minicircle performance depending on S/MAR-nuclear matrix interactions. J Mol Biol 2009; 395:950-65. [PMID: 20004666 DOI: 10.1016/j.jmb.2009.11.066] [Citation(s) in RCA: 33] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/09/2009] [Revised: 11/14/2009] [Accepted: 11/30/2009] [Indexed: 12/12/2022]
Abstract
The ideal vector for cell and tissue modification does not depend on integration but rather behaves as an independent functional unit that replicates as an episome. Based on a scaffold/matrix attachment region (S/MAR), we have introduced, in 2006, an approximately 4-kb replicating nonviral minicircle able to exploit the cellular replication machinery in a way reminiscent of ARS vectors. Consisting of only one active transcription unit and the S/MAR, it resists silencing as it is free of prokaryotic vector parts and drug selection markers. The rate of final establishment in the nuclear architecture is moderate but comparable to Epstein-Barr virus-based episomes (<5%). Here, we demonstrate that this parameter can be improved if the host cell chromatin is opened by histone hyperacetylation prior to transfection. It remains unaffected, however, by cell cycle position. Still, this class of episomes revealed intrinsic instability and integration after 5 months of continuous culture. In vivo evolution enabled the effective reduction of S/MAR size from 2 kb to 733 bp (resulting in a minicircle of approximately 3 kb) with largely improved stability and cloning capacity. Investigation of individual clones served to prove persistent and homogenous expression, which is ascribed to stable association with nuclear attachment sites. Optimum expression levels were shown to depend on the authentic usage of a polyadenylation site 3' from the S/MAR as anticipated by the stress-induced duplex destabilization algorithm, which finds increasing use to predict the functional parameters of these systems.
Collapse
Affiliation(s)
- Sandra Broll
- Department Molecular Biotechnology/Epigenetic Regulation, Helmholtz Center for Infection Research, Inhoffenstrasse 7, D-38124 Braunschweig, Germany
| | | | | | | | | |
Collapse
|
18
|
Chenuet S, Derouazi M, Hacker D, Wurm F. DNA delivery by microinjection for the generation of recombinant mammalian cell lines. Methods Mol Biol 2009; 518:99-112. [PMID: 19085129 DOI: 10.1007/978-1-59745-202-1_8] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/06/2023]
Abstract
Gene transfer methods for producing recombinant cell lines are often not very efficient. One reason is that the recombinant DNA is delivered into the cell cytoplasm and only a small fraction reaches the nucleus. This chapter describes a method for microinjecting DNA directly into the nucleus. Direct injection has several advantages including the ability to deliver a defined copy number into the nucleus, the avoidance of DNAses that are present in the cell cytoplasm, and the lack of a need for extensive subcloning to find the recombinant cells. The procedure is described for two cell lines, CHO DG44 and BHK-21, using green fluorescent protein as a reporter gene. However, this method could easily be adapted to other cells lines and using other recombinant genes.
Collapse
Affiliation(s)
- Sebastien Chenuet
- Ecole Polytechnique Féderale de Lausanne, EPFL-SV-IBI-LBTC, Lausanne, Switzerland
| | | | | | | |
Collapse
|
19
|
Chenuet S, Martinet D, Besuchet-Schmutz N, Wicht M, Jaccard N, Bon AC, Derouazi M, Hacker DL, Beckmann JS, Wurm FM. Calcium phosphate transfection generates mammalian recombinant cell lines with higher specific productivity than polyfection. Biotechnol Bioeng 2008; 101:937-45. [DOI: 10.1002/bit.21972] [Citation(s) in RCA: 26] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/11/2022]
|
20
|
The importance of particle size and DNA condensation salt for calcium phosphate nanoparticle transfection. Biomaterials 2008; 29:3384-92. [PMID: 18485472 DOI: 10.1016/j.biomaterials.2008.04.043] [Citation(s) in RCA: 55] [Impact Index Per Article: 3.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/22/2008] [Accepted: 04/23/2008] [Indexed: 11/20/2022]
Abstract
Calcium phosphate has been used for over 30 years to deliver genetic material to mammalian cells. This vector has proven advantages over other transfection species such as viruses and dendrimers in terms of superior biocompatibility and reduced immune response. However, clinical application of calcium phosphate based transfection techniques is hampered by poor understanding of the key factors underlying its action. Despite widespread in vitro use, little attention has been given to the physico-chemical characteristics of the calcium phosphate particles mediating transfection. In this study parameters were optimised to produce calcium phosphate nanoparticles onto which plasmid DNA (pDNA) was adsorbed that were more effective than a commercial dendrimer vector in delivering pDNA to an osteoblastic cell line and compared favourably in a fibroblastic cell line without the need for special culture conditions such as cell cycle synchronization or glycerol shock treatment. Addition of the pDNA after nanoparticle synthesis allowed for characterisation of particle morphology, size, surface charge and composition. We found that the key parameters for effective calcium phosphate nanoparticle transfection were an optimal concentration of calcium and chloride ions and a nanosized non-agglomerated precipitate.
Collapse
|
21
|
Sun X, Hia HC, Goh PE, Yap MGS. High-density transient gene expression in suspension-adapted 293 EBNA1 cells. Biotechnol Bioeng 2007; 99:108-16. [PMID: 17630648 DOI: 10.1002/bit.21537] [Citation(s) in RCA: 38] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022]
Abstract
Large-scale transient gene expression (TGE) in mammalian cells is an attractive method to rapidly produce recombinant proteins for pre-clinical studies, with some processes reported to reach 100 L. However, the yield remains low, hardly over 20 mg protein/L, mainly because the current TGEs have been performed at low cell density (approximately 5 x 10(5) cells/mL). In this study, the strategy to improve TGE focuses on facilitating transfection at high cell density. A high-density perfusion culture of 293 EBNA1 cells was established in 2-L bioreactor using Freestyle 293 expression medium (Invitrogen, Singapore) to grow the cells for transfection. Transfection was then carried out at 1 x 10(7) cells/mL using polyethylenimine (PEI) as DNA carrier, at the optimized conditions of 6 microg DNA/10(7) cells and 1:3 DNA to PEI mass ratio. During the post-transfection phase, 80.8 mg/L of the model protein, EPO was obtained at day 5.5 post-transfection (130 mg total EPO production) using a fed-batch culture mode. In comparison, perfusion cultures using an enriched SFM II medium resulted in a longer post-transfection production phase (8 days), and 227 mg of EPO was produced in 10.7 L medium, showing that high-density TGE enables the production of several hundreds of milligrams of protein in a 2 L bioreactor. In addition, a protocol for economical plasmid preparation based on anion exchange was also established to satisfy TGE's demand in terms of quality and quantity. To the best of our knowledge, this is the first report of transient transfections at a high cell density of up to 1 x 10(7) cells/mL.
Collapse
Affiliation(s)
- Xiangming Sun
- Bioprocessing Technology Institute, 20 Biopolis Way, Centros 138668, Singapore.
| | | | | | | |
Collapse
|
22
|
Grosjean F, Bertschinger M, Hacker DL, Wurm FM. Multiple glycerol shocks increase the calcium phosphate transfection of non-synchronized CHO cells. Biotechnol Lett 2006; 28:1827-33. [PMID: 17009090 DOI: 10.1007/s10529-006-9167-7] [Citation(s) in RCA: 13] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/12/2006] [Accepted: 07/14/2006] [Indexed: 10/24/2022]
Abstract
The exposure of CHO DG44 cells to an osmotic shock, after DNA uptake, results in a cellular volume decrease of approx. 55%. Repetitive osmotic shocks targeted different sub-populations of cells as was demonstrated using two different fluorescent reporter genes. Also the exposure of a calcium phosphate-DNA coprecipitate to high osmolarity in vitro caused the release of the DNA from the precipitate. The results demonstrate the importance of the osmotic shock on the efficient delivery of plasmid DNA to the nucleus of CHO cells following calcium phosphate-mediated transfection.
Collapse
Affiliation(s)
- Frederic Grosjean
- Institute of Biochemistry, Chemin des Boveresses 155, 1066, Epalinges, Switzerland.
| | | | | | | |
Collapse
|
23
|
Park JY, Lim BP, Lee K, Kim YG, Jo EC. Scalable production of adeno-associated virus type 2 vectors via suspension transfection. Biotechnol Bioeng 2006; 94:416-30. [PMID: 16622883 DOI: 10.1002/bit.20776] [Citation(s) in RCA: 41] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022]
Abstract
Vectors derived from adeno-associated virus type 2 (AAV2) are promising gene delivery vehicles, but it is still challenging to get the large number of recombinant adeno-associated virus (rAAV) particles required for large animal and clinical studies. Current transfection technology requires adherent cultures of HEK 293 cells that can only be expanded by preparing multiple culture plates. A single large-scale suspension culture could replace these multiple culture preparations, but there is currently no effective co-transfection scheme for generating rAAV from cells in suspension culture. Here, we weaned HEK 293 cells to suspension culture using hydrogel-coated six-well culture plates and established an efficient transfection strategy suitable for these cells. Then the cultures were gradually scaled up. We used linear polyethylenimine (PEI) to mediate transfection and obtained high transfection efficiencies ranging from 54% to 99%, thereby allowing efficient generation of rAAV vectors. Up to 10(13) rAAV particles and, more importantly, up to 10(11) infectious particles were generated from a 2-L bioreactor culture. The suspension-transfection strategy of this study facilitates the homogeneous preparation of rAAV at a large scale, and holds further potential as the basis for establishing a manufacturing process in a larger bioreactor.
Collapse
Affiliation(s)
- Joon Young Park
- MOGAM Biotechnology Research Institute, 341 Pojung-Ri Koosung-Eup Yongin, Kyonggi-Do 449-913, Republic of Korea
| | | | | | | | | |
Collapse
|
24
|
Derouazi M, Flaction R, Girard P, de Jesus M, Jordan M, Wurm FM. Generation of Recombinant Chinese Hamster Ovary Cell Lines by Microinjection. Biotechnol Lett 2006; 28:373-82. [PMID: 16614902 DOI: 10.1007/s10529-005-6062-6] [Citation(s) in RCA: 14] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/06/2005] [Accepted: 12/13/2005] [Indexed: 10/24/2022]
Abstract
Microinjection is a gene transfer technique enabling partial control of plasmid delivery into the nucleus or cytoplasm of cultured animal cells. Here this method was used to establish various recombinant mammalian cell lines. The injection volume was estimated by fluorescence quantification of injected fluorescein isothyocynate (FITC)-dextran. The DNA concentration and injection pressure were then optimized for microinjection into the nucleus or cytoplasm using a reporter plasmid encoding the green fluorescent protein (GFP). Nuclear microinjection was more sensitive to changes in these two parameters than was cytoplasmic microinjection. Under optimal conditions, 80-90% of the cells were GFP-positive 1 day after microinjection into the nucleus or the cytoplasm. Recombinant cell lines were recovered following microinjection or calcium phosphate transfection and analyzed for the level and stability of recombinant protein production. In general, the efficiency of recovery of recombinant cell lines and the stability of reporter protein expression over time were higher following microinjection as compared to CaPi transfection. The results demonstrate the feasibility of using microinjection as a method to generate recombinant cell lines.
Collapse
Affiliation(s)
- Madiha Derouazi
- Laboratory of Cellular Biotechnology, Institute of Biological Engineering and Biotechnology, Ecole Polytechnique Fédérale de Lausanne, Lausanne, CH-1015, Switzerland
| | | | | | | | | | | |
Collapse
|
25
|
Hunt L, Hacker DL, Grosjean F, De Jesus M, Uebersax L, Jordan M, Wurm FM. Low-temperature pausing of cultivated mammalian cells. Biotechnol Bioeng 2005; 89:157-63. [PMID: 15584025 DOI: 10.1002/bit.20320] [Citation(s) in RCA: 26] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022]
Abstract
There are currently two methods for maintaining cultured mammalian cells, continuous passage at 37 degrees C and freezing in small batches. We investigated a third approach, the "pausing" of cells for days or weeks at temperatures below 37 degrees C in a variety of cultivation vessels. High cell viability and exponential growth were observed after pausing a recombinant Chinese hamster ovary cell line (CHO-Clone 161) in a temperature range of 6-24 degrees C in microcentrifuge tubes for up to 3 weeks. After pausing in T-flasks at 4 degrees C for 9 days, adherent cultures of CHO-DG44 and human embryonic kidney (HEK293 EBNA) cells resumed exponential growth when incubated at 37 degrees C. Adherent cultures of CHO-DG44 cells paused for 2 days at 4 degrees C in T-flasks and suspension cultures of HEK293 EBNA cells paused for 3 days at either 4 degrees C or 24 degrees C in spinner flasks were efficiently transfected by the calcium phosphate-DNA coprecipitation method, yielding reporter protein levels comparable to those from nonpaused cultures. Finally, cultures of a recombinant CHO cell line (CHO-YIgG3) paused for 3 days at 4 degrees C, 12 degrees C, or 24 degrees C in bioreactors achieved the same cell mass and recombinant protein productivity levels as nonpaused cultures. The success of this approach to cell storage with rodent and human cell lines points to a general biological phenomenon which may have a wide range of applications for cultivated mammalian cells.
Collapse
Affiliation(s)
- Lisa Hunt
- Swiss Federal Institute of Technology Lausanne, Faculty of Basic Sciences, Institute of Biological and Chemical Process Sciences, CH1015 Lausanne, Switzerland
| | | | | | | | | | | | | |
Collapse
|
26
|
Hacker DL, Derow E, Wurm FM. The CELO adenovirus Gam1 protein enhances transient and stable recombinant protein expression in Chinese hamster ovary cells. J Biotechnol 2005; 117:21-9. [PMID: 15831244 DOI: 10.1016/j.jbiotec.2005.01.006] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/05/2004] [Revised: 12/21/2004] [Accepted: 01/07/2005] [Indexed: 10/25/2022]
Abstract
The Gam1 protein of the avian CELO adenovirus activates transcription through inhibition of histone deacetylase 1 (HDAC1). We investigated the effect of Gam1 on both transient and stable transgene expression in Chinese hamster ovary (CHO) cells, one of the most commonly used mammalian hosts for the large-scale production of recombinant proteins. Transient expression of Gam1 increased reporter protein levels up to 4-fold in suspension cultures of CHO DG44 cells co-transfected with a reporter gene and up to 20-fold in recombinant CHO DG44-derived cell lines. The highest levels of activation were observed when the transgene was under the control of the human cytomegalovirus (HCMV) immediate early promoter/enhancer. Increases in recombinant protein expression in the presence of Gam1 were not accompanied by an enhancement of cell growth or viability. We conclude that Gam1 may serve as a useful genetic tool for increasing recombinant protein expression in CHO DG44 cells.
Collapse
Affiliation(s)
- David L Hacker
- Ecole Polytechnique Fédérale de Lausanne (EPFL), Laboratory of Cellular Biotechnology, CH-1015 Lausanne, Switzerland.
| | | | | |
Collapse
|
27
|
Derouazi M, Girard P, Van Tilborgh F, Iglesias K, Muller N, Bertschinger M, Wurm FM. Serum-free large-scale transient transfection of CHO cells. Biotechnol Bioeng 2005; 87:537-45. [PMID: 15286991 DOI: 10.1002/bit.20161] [Citation(s) in RCA: 159] [Impact Index Per Article: 8.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022]
Abstract
To date, methods for large-scale transient gene expression (TGE) in cultivated mammalian cells have focused on two transfection vehicles: polyethylenimine (PEI) and calcium phosphate (CaPi). Both have been shown to result in high transfection efficiencies at scales beyond 10 L. Unfortunately, both approaches yield higher levels of recombinant protein (r-protein) in the presence of serum than in its absence. Since serum is a major cost factor and an obstacle to protein purification, our goal was to develop a large-scale TGE process for Chinese hamster ovary (CHO) cells in the absence of serum. CHO-DG44 cells were cultivated and transfected in a chemically defined medium using linear 25 kDa PEI as a transfection vehicle. Parameters that were optimized included the DNA amount, the DNA-to-PEI ratio, the timing and solution conditions for complex formation, the transfection medium, and the cell density at the time of transfection. The highest levels of r-protein expression were observed when cultures at a density of 2.0 x 10(6) cells/ml were transfected with 2.5 microg/ml DNA in RPMI 1640 medium containing 25 mM HEPES at pH 7.1. The transfection complex was formed at a DNA:PEI ratio of 1:2 (w/w) in 150 mM NaCl with a 10-min incubation at room temperature prior to addition to the culture. The procedure was scaled up for a 20-L bioreactor, yielding expression levels of 10
Collapse
Affiliation(s)
- Madiha Derouazi
- Laboratory of Cellular Biotechnology, IGBB, Faculty of Life Science, Swiss Federal Institute of Technology, 1015 Lausanne, Switzerland
| | | | | | | | | | | | | |
Collapse
|