1
|
Diao Y, Hao T, Liu X, Yang H. Advances in single ice crystal shaping materials: From nature to synthesis and applications in cryopreservation. Acta Biomater 2024; 174:49-68. [PMID: 38040076 DOI: 10.1016/j.actbio.2023.11.035] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/02/2023] [Revised: 10/23/2023] [Accepted: 11/22/2023] [Indexed: 12/03/2023]
Abstract
Antifreeze (glyco) proteins [AF(G)Ps], which are widely present in various extreme microorganisms, can control the formation and growth of ice crystals. Given the significance of cryogenic technology in biomedicine, climate science, electronic energy, and other fields of research, scientists are quite interested in the development and synthesis high-efficiency bionic antifreeze protein materials, particularly to reproduce their dynamic ice shaping (DIS) characteristics. Single ice crystal shaping materials, a promising class of ice-controlling materials, can alter the morphology and growth rate of ice crystals at low temperatures. This review aims to highlight the development of single ice crystal shaping materials and provide a brief comparison between a series of natural and bionic synthetic materials with DIS ability, which include AF(G)Ps, polymers, salts, and nanomaterials. Additionally, we summarize their applications in cryopreservation. Finally, this paper presents the current challenges and prospects encountered in developing high-efficiency and practical single ice crystal shaping materials. STATEMENT OF SIGNIFICANCE: The formation and growth of ice crystals hold a significant importance to an incredibly broad range of fields. Therefore, the design and fabrication of the single ice crystal shaping materials have gained the increasing popularity due to its key role in dynamic ice shaping (DIS) characteristics. Especially, single ice crystal shaping materials are considered one of the most promising candidates as ice inhibitors, presenting tremendous prospects for enhancing cryopreservation. In this work, we focus on the molecular characteristics, structure-function relationships, and DIS mechanisms of typical natural and biomimetic synthetic materials. This review may provide inspiration for the design and preparation of single ice crystal shaping materials and give guidance for the development of effective cryopreservation agent.
Collapse
Affiliation(s)
- Yunhe Diao
- School of Materials Science and Engineering, Zhengzhou University, 450001 Zhengzhou, Henan, China
| | - Tongtong Hao
- School of Materials Science and Engineering, Beijing Institute of Technology, 100081 Beijing, China
| | - Xuying Liu
- School of Materials Science and Engineering, Zhengzhou University, 450001 Zhengzhou, Henan, China
| | - Huige Yang
- School of Materials Science and Engineering, Zhengzhou University, 450001 Zhengzhou, Henan, China..
| |
Collapse
|
2
|
Yang S, Ding Z, Chu L, Su M, Liu H. Quantified instant conjugation of peptides on a nanogold surface for tunable ice recrystallization inhibition. NANOSCALE 2023; 15:19746-19756. [PMID: 38047706 DOI: 10.1039/d3nr05019j] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/05/2023]
Abstract
The adverse effects of recrystallization limit the application of cryopreservation in many fields. Peptide-based materials play an essential role in the antifreezing area because of their excellent biocompatibility and abundant ice-binding sites. Peptide-gold nanoparticle conjugates can effectively reduce time and material costs through metal-thiol interactions, but controlled modification remains an outstanding issue, which makes it difficult to elucidate the antifreezing effects of antifreeze peptides at different densities and lengths. In this study, we developed an instant peptide capping on gold nanoparticles with butanol-assisted dehydration and provided a controllable quantitative coupling within a certain range. This chemical dehydration makes it possible to fabricate peptide-gold nanoparticle conjugates in large batches at minute levels. Based on this, the influence of the peptide density and sequence length on the antifreezing behaviors of the conjugates was investigated. The results evidenced that the antifreezing property of the flexible peptide conjugated on a rigid core is related to both the density and length of the peptide. In a certain range, the density is proportional to the antifreeze, while the length is negatively correlated with it. We proposed a rapidly controllable method for synthesizing peptide-gold nanoparticle conjugates, which may provide a universal approach for the development of subsequent recrystallization-inhibiting materials.
Collapse
Affiliation(s)
- Shixuan Yang
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Engineering Research Center of Bio-process, Ministry of Education, Hefei University of Technology, Hefei 230009, China.
| | - Zhongxiang Ding
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Engineering Research Center of Bio-process, Ministry of Education, Hefei University of Technology, Hefei 230009, China.
| | - Leiming Chu
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Engineering Research Center of Bio-process, Ministry of Education, Hefei University of Technology, Hefei 230009, China.
| | - Mengke Su
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Engineering Research Center of Bio-process, Ministry of Education, Hefei University of Technology, Hefei 230009, China.
| | - Honglin Liu
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Engineering Research Center of Bio-process, Ministry of Education, Hefei University of Technology, Hefei 230009, China.
| |
Collapse
|
3
|
Sun X, Guo R, Zhan T, Kou Y, Ma X, Song H, Song L, Li X, Zhang H, Xie F, Song Z, Yuan C, Wu Y. Self-assembly of tamarind seed polysaccharide via enzymatic depolymerization and degalactosylation enhanced ice recrystallization inhibition activity. Int J Biol Macromol 2023; 252:126352. [PMID: 37598826 DOI: 10.1016/j.ijbiomac.2023.126352] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/05/2023] [Accepted: 08/14/2023] [Indexed: 08/22/2023]
Abstract
Polysaccharides are becoming potential candidates for developing food-grade cryoprotectants due to their extensive accessibility and health-promoting effects. However, unremarkable ice recrystallization inhibition (IRI) activity and high viscosity limit their practical applications in some systems. Our previous study found a galactoxyloglucan polysaccharide from tamarind seed (TSP) showing moderate IRI activity. Herein, the enhancement of the IRI performance of TSP via enzymatic depolymerization and degalactosylation-induced self-assembly was reported. TSP was depolymerized and subsequently removed ∼40 % Gal, which induced the formation of supramolecular rod-like fiber self-assembles and exhibited a severalfold enhancement of IRI. Ice shaping assay did not show obvious faceting of ice crystals, indicating that both depolymerized and self-assembled TSP showed very weak binding to ice. Molecular dynamics simulation confirmed the absence of molecular complementarity with ice. Further, it highlighted that degalactosylation did not cause significant changes in local hydration properties of TSP from the view of a single oligomer. The inconsistency between molecular simulation and macroscopic IRI effect proposed that the formation of unique supramolecular self-assemblies may be a key requirement for enhancing IRI activity. The findings of this study provided a new opportunity to enhance the applied potential of natural polysaccharides in food cryoprotection.
Collapse
Affiliation(s)
- Xianbao Sun
- Department of Food Science and Engineering, School of Agriculture and Biology, Shanghai Jiao Tong University, Shanghai 200240, China
| | - Rui Guo
- Department of Food Science and Engineering, School of Agriculture and Biology, Shanghai Jiao Tong University, Shanghai 200240, China
| | - Taijie Zhan
- School of Health Science and Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China
| | - Yuxing Kou
- Department of Food Science and Engineering, School of Agriculture and Biology, Shanghai Jiao Tong University, Shanghai 200240, China
| | - Xuan Ma
- Department of Food Science and Engineering, School of Agriculture and Biology, Shanghai Jiao Tong University, Shanghai 200240, China
| | - Hong Song
- Department of Food Science and Engineering, School of Agriculture and Biology, Shanghai Jiao Tong University, Shanghai 200240, China
| | - Lihua Song
- Department of Food Science and Engineering, School of Agriculture and Biology, Shanghai Jiao Tong University, Shanghai 200240, China
| | - Xujiao Li
- Department of Food Science and Engineering, School of Agriculture and Biology, Shanghai Jiao Tong University, Shanghai 200240, China; Institute for Agro-food Standards and Testing Technology, Laboratory of Quality and Safety Risk Assessment for Agro-products (Shanghai), Ministry of Agriculture and Rural Affairs, Shanghai Academy of Agricultural Sciences, Shanghai 201403, China
| | - Hui Zhang
- School of Health Science and Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China
| | - Fan Xie
- School of Health Science and Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China
| | - Zibo Song
- Yunnan Maoduoli Group Food Co., Ltd., Yuxi 653100, China
| | - Chunmei Yuan
- Yunnan Maoduoli Group Food Co., Ltd., Yuxi 653100, China
| | - Yan Wu
- Department of Food Science and Engineering, School of Agriculture and Biology, Shanghai Jiao Tong University, Shanghai 200240, China.
| |
Collapse
|
4
|
William N, Mangan S, Ben RN, Acker JP. Engineered Compounds to Control Ice Nucleation and Recrystallization. Annu Rev Biomed Eng 2023; 25:333-362. [PMID: 37104651 DOI: 10.1146/annurev-bioeng-082222-015243] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 04/29/2023]
Abstract
One of the greatest concerns in the subzero storage of cells, tissues, and organs is the ability to control the nucleation or recrystallization of ice. In nature, evidence of these processes, which aid in sustaining internal temperatures below the physiologic freezing point for extended periods of time, is apparent in freeze-avoidant and freeze-tolerant organisms. After decades of studying these proteins, we now have easily accessible compounds and materials capable of recapitulating the mechanisms seen in nature for biopreser-vation applications. The output from this burgeoning area of research can interact synergistically with other novel developments in the field of cryobiology, making it an opportune time for a review on this topic.
Collapse
Affiliation(s)
- Nishaka William
- Department of Laboratory Medicine and Pathology, University of Alberta, Edmonton, Alberta, Canada;
| | - Sophia Mangan
- Department of Chemistry and Biomolecular Sciences, University of Ottawa, Ottawa, Ontario, Canada
| | - Rob N Ben
- Department of Chemistry and Biomolecular Sciences, University of Ottawa, Ottawa, Ontario, Canada
| | - Jason P Acker
- Department of Laboratory Medicine and Pathology, University of Alberta, Edmonton, Alberta, Canada;
- Innovation and Portfolio Management, Canadian Blood Services, Edmonton, Alberta, Canada
| |
Collapse
|
5
|
Judge N, Georgiou PG, Bissoyi A, Ahmad A, Heise A, Gibson MI. High Molecular Weight Polyproline as a Potential Biosourced Ice Growth Inhibitor: Synthesis, Ice Recrystallization Inhibition, and Specific Ice Face Binding. Biomacromolecules 2023. [DOI: 10.1021/acs.biomac.2c01487] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/24/2023]
Affiliation(s)
- Nicola Judge
- Department of Chemistry, RCSI University of Medicine and Health Sciences, Dublin 2, Ireland
| | | | - Akalabya Bissoyi
- Division of Biomedical Sciences, Warwick Medical School, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Ashfaq Ahmad
- Division of Biomedical Sciences, Warwick Medical School, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Andreas Heise
- Department of Chemistry, RCSI University of Medicine and Health Sciences, Dublin 2, Ireland
- Science Foundation Ireland (SFI) Centre for Research in Medical Devices (CURAM), RCSI, Dublin 2, Ireland
- AMBER, The SFI Advanced Materials and Bioengineering Research Centre, RCSI, Dublin D02, Ireland
| | - Matthew I. Gibson
- Department of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
- Division of Biomedical Sciences, Warwick Medical School, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| |
Collapse
|
6
|
Georgiou PG, Kinney NLH, Kontopoulou I, Baker AN, Hindmarsh SA, Bissoyi A, Congdon TR, Whale TF, Gibson MI. Poly(vinyl alcohol) Molecular Bottlebrushes Nucleate Ice. Biomacromolecules 2022; 23:5285-5296. [PMID: 36441868 DOI: 10.1021/acs.biomac.2c01097] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
Abstract
Ice binding proteins (IBP) have evolved to limit the growth of ice but also to promote ice formation by ice-nucleating proteins (INPs). IBPs, which modulate these seemingly distinct processes, often have high sequence similarities, and molecular size/assembly is hypothesized to be a crucial determinant. There are only a few synthetic materials that reproduce INP function, and rational design of ice nucleators has not been achieved due to outstanding questions about the mechanisms of ice binding. Poly(vinyl alcohol) (PVA) is a water-soluble synthetic polymer well known to effectively block ice recrystallization, by binding to ice. Here, we report the synthesis of a polymeric ice nucleator, which mimics the dense assembly of IBPs, using confined ice-binding polymers in a high-molar-mass molecular bottlebrush. Poly(vinyl alcohol)-based molecular bottlebrushes with different side-chain densities were synthesized via a combination of ring-opening metathesis polymerization (ROMP) and reversible addition-fragmentation chain-transfer (RAFT) polymerization, using "grafting-to" and "grafting-through" approaches. The facile preparation of the PVA bottlebrushes was performed via selective hydrolysis of the acetate of the poly(vinyl acetate) (PVAc) side chains of the PVAc bottlebrush precursors. Ice-binding polymer side-chain density was shown to be crucial for nucleation activity, with less dense brushes resulting in colder nucleation than denser brushes. This bio-inspired approach provides a synthetic framework for probing heterogeneous ice nucleation and a route toward defined synthetic nucleators for biotechnological applications.
Collapse
Affiliation(s)
- Panagiotis G Georgiou
- Department of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Nina L H Kinney
- Department of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Ioanna Kontopoulou
- Department of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Alexander N Baker
- Department of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Steven A Hindmarsh
- Department of Physics, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Akalabya Bissoyi
- Department of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Thomas R Congdon
- Department of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Thomas F Whale
- Department of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| | - Matthew I Gibson
- Department of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K.,Division of Biomedical Sciences, Warwick Medical School, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K
| |
Collapse
|
7
|
Wu X, Qiu Y, Chen C, Gao Y, Wang Y, Yao F, Zhang H, Li J. Polysaccharide-Derived Ice Recrystallization Inhibitors with a Modular Design: The Case of Dextran-Based Graft Polymers. LANGMUIR : THE ACS JOURNAL OF SURFACES AND COLLOIDS 2022; 38:14097-14108. [PMID: 36342971 DOI: 10.1021/acs.langmuir.2c02032] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/16/2023]
Abstract
Ice recrystallization inhibitors inspired from antifreeze proteins (AFPs) are receiving increasing interest for cryobiology and other extreme environment applications. Here, we present a modular strategy to develop polysaccharide-derived biomimetics, and detailed studies were performed in the case of dextran. Poly(vinyl alcohol) (PVA) which has been termed as one of the most potent biomimetics of AFPs was grafted onto dextran via thiol-ene click chemistry (Dex-g-PVA). This demonstrated that Dex-g-PVA is effective in IRI and its activity increases with the degree of polymerization (DP) (sizes of ice crystals were 18.846 ± 1.759 and 9.700 ± 1.920 μm with DPs of 30 and 80, respectively) and fraction of PVA. By means of the dynamic ice shaping (DIS) assay, Dex-g-PVA is found to engage on the ice crystal surfaces, thus the ice affinity accounts for their IRI activity. In addition, Dex- g-PVA displayed enhanced IRI activity compared to that of equivalent PVA alone. We speculate that the hydrophilic nature of dextran would derive PVA in a stretch conformation that favors ice binding. The modular design can not only offer polysaccharides IRI activity but also favor the ice-binding behavior of PVA.
Collapse
|
8
|
Häkkinen S, Tanaka J, Garcia Maset R, Hall SCL, Huband S, Rho JY, Song Q, Perrier S. Polymerisation-Induced Self-Assembly of Graft Copolymers. Angew Chem Int Ed Engl 2022; 61:e202210518. [PMID: 36002384 PMCID: PMC9828155 DOI: 10.1002/anie.202210518] [Citation(s) in RCA: 6] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/20/2022] [Indexed: 01/12/2023]
Abstract
We report the polymerisation-induced self-assembly of poly(lauryl methacrylate)-graft-poly(benzyl methacrylate) copolymers during reversible addition-fragmentation chain transfer (RAFT) grafting from polymerisation in a backbone-selective solvent. Electron microscopy images suggest the phase separation of grafts to result in a network of spherical particles, due to the ability of the branched architecture to freeze chain entanglements and to bridge core domains. Small-angle X-ray scattering data suggest the architecture promotes the formation of multicore micelles, the core morphology of which transitions from spheres to worms, vesicles, and inverted micelles with increasing volume fraction of the grafts. A time-resolved SAXS study is presented to illustrate the formation of the inverted phase during a polymerisation. The grafted architecture gives access to unusual morphologies and provides exciting new handles for controlling the polymer structure and material properties.
Collapse
Affiliation(s)
- Satu Häkkinen
- Department of ChemistryUniversity of WarwickCoventryCV4 7ALUK
| | - Joji Tanaka
- Department of ChemistryUniversity of WarwickCoventryCV4 7ALUK,Department of ChemistryUniversity of North Carolina at Chapel HillChapel HillNC 27599-3290USA
| | - Ramón Garcia Maset
- Department of ChemistryUniversity of North Carolina at Chapel HillChapel HillNC 27599-3290USA
| | - Stephen C. L. Hall
- Department of ChemistryUniversity of WarwickCoventryCV4 7ALUK,ISIS Neutron and Muon SourceRutherford Appleton LaboratoryDidcotOX11 0QXUK
| | - Steven Huband
- Department of ChemistryUniversity of North Carolina at Chapel HillChapel HillNC 27599-3290USA
| | - Julia Y. Rho
- Department of ChemistryUniversity of North Carolina at Chapel HillChapel HillNC 27599-3290USA
| | - Qiao Song
- Department of ChemistryUniversity of North Carolina at Chapel HillChapel HillNC 27599-3290USA
| | - Sébastien Perrier
- Department of ChemistryUniversity of WarwickCoventryCV4 7ALUK,Warwick Medical SchoolUniversity of WarwickCoventryCV4 7ALUK
| |
Collapse
|
9
|
Yang S, Zhang L, Chen Y, Tan J. Combining Green Light-Activated Photoiniferter RAFT Polymerization and RAFT Dispersion Polymerization for Graft Copolymer Assemblies. Macromolecules 2022. [DOI: 10.1021/acs.macromol.2c01529] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
Affiliation(s)
- Shuaiqi Yang
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou 510006, China
| | - Li Zhang
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou 510006, China
- Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou 510006, China
| | - Ying Chen
- Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou 510006, China
| | - Jianbo Tan
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou 510006, China
- Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou 510006, China
| |
Collapse
|
10
|
Hakkinen S, Tanaka J, Garcia Macet R, Hall S, Huband S, Rho J, Song Q, Perrier S. Polymerisation‐Induced Self‐Assembly of Graft Copolymers. Angew Chem Int Ed Engl 2022. [DOI: 10.1002/ange.202210518] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022]
Affiliation(s)
| | - Joji Tanaka
- University of Warwick Chemistry UNITED KINGDOM
| | | | | | | | - Julia Rho
- University of Warwick Chemistry UNITED KINGDOM
| | - Qiao Song
- University of Warwick Chemistry UNITED KINGDOM
| | - Sebastien Perrier
- University of Warwick Department of Chemistry Library Road CV4 7AL Coventry UNITED KINGDOM
| |
Collapse
|
11
|
Ding Z, Wang C, Zhou B, Su M, Yang S, Li Y, Qu C, Liu H. Antifreezing Hydroxyl Monolayer of Small Molecules on a Nanogold Surface. NANO LETTERS 2022; 22:5307-5315. [PMID: 35695804 DOI: 10.1021/acs.nanolett.2c01267] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/15/2023]
Abstract
The rational design of ice recrystallization inhibition (IRI) materials is challenging due to the poor understanding of the IRI mechanism at the molecular level. Here we report several new findings about IRI. (1) A dense hydroxyl monolayer of small molecules, e.g. 6-aza-2-thiothymine (ATT), adsorbed on a nanogold surface was demonstrated, for the first time, to have IRI activity. Five structural analogues adsorbed on groups nanogold with outward hydroxyl or methyl were created to evidence the origin of IRI activity. (2) Their IRI mechanism is closely related to the density of hydroxyls on a nanogold surface. However, the hydrophobic interaction in our model is not essential for macroscopic IRI activity. (3) A molecular dynamics simulation elucidates the hydroxyl density dependent IRI trajectories underlying the experimental observations, and the radial distribution function reveals that the methyl even slightly hinders the formation of hydrogen bonding due to a hydrophobic interaction. This work sheds more light on the IRI mechanism that should help in the customization of novel IRI materials.
Collapse
Affiliation(s)
- Zhongxiang Ding
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Hefei University of Technology, Hefei 230009, People's Republic of China
| | - Chao Wang
- National Synchrotron Radiation Laboratory, University of Science and Technology of China, Hefei 230027, People's Republic of China
| | - Baomei Zhou
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Hefei University of Technology, Hefei 230009, People's Republic of China
| | - Mengke Su
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Hefei University of Technology, Hefei 230009, People's Republic of China
| | - Shixuan Yang
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Hefei University of Technology, Hefei 230009, People's Republic of China
| | - Yuzhu Li
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Hefei University of Technology, Hefei 230009, People's Republic of China
| | - Cheng Qu
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Hefei University of Technology, Hefei 230009, People's Republic of China
| | - Honglin Liu
- China Light Industry Key Laboratory of Meat Microbial Control and Utilization, School of Food and Biological Engineering, Hefei University of Technology, Hefei 230009, People's Republic of China
| |
Collapse
|
12
|
Kontopoulou I, Congdon TR, Bassett S, Mair B, Gibson MI. Synthesis of poly(vinyl alcohol) by blue light bismuth oxide photocatalysed RAFT. Evaluation of the impact of freeze/thaw cycling on ice recrystallisation inhibition. Polym Chem 2022; 13:4692-4700. [PMID: 36092983 PMCID: PMC9379775 DOI: 10.1039/d2py00852a] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/01/2022] [Accepted: 07/23/2022] [Indexed: 11/21/2022]
Abstract
Poly(vinyl alcohol), PVA, is the most potent polymeric ice recrystallisation inhibitor (IRI), mimicking a complex function of ice binding proteins. The IRI activity of PVA scales with its molecular weight and hence broad molecular weight distributions in free radical-derived PVAs lead to activity measurements dominated by small amounts of heavier fractions. Well-defined PVA can be prepared by thermally initiated RAFT/MADIX polymerization using xanthates by the polymerization of the less activated monomer vinyl acetate. The low conversions and molecular weights obtained during this approach, often requires feeding of additional initiator and bulk polymerization. Here we employ bismuth oxide photo-RAFT in solution, using blue light (450 nm), rather than previously reported white light, to obtain a library of PVA's. The use of blue light enabled quantitative conversion and acceptable dispersities. Purple light (380 nm) was also used, but asymmetric molecular weight distributions were obtained in some cases. High concentrations of high molecular weight PVA is known to form cryogels during freeze/thaw which has led to speculation this might limit the use of PVA in environments where the temperature cycles e.g. the construction industry. After 4 freeze/thaw cycles there was only small changes in observable IRI for all synthesised PVAs and two commercial standards. In an extended test, activity was retained after 100 freeze/thaw cycles, mitigating concerns that PVA could not be used in situations where freeze/thaw cycles occur. This work presents a convenient method to obtain well-defined PVAs for cryoscience studies compared to conventional thermal-RAFT and indicates that cryogelation concerns may not prevent their use. Poly(vinyl alcohol) is synthesised using blue light bismuth oxide photo-RAFT, to high conversion. The ice recrystallisation inhibition activity of these polymers was shown to be retained over 100 freeze/thaw cycles.![]()
Collapse
Affiliation(s)
| | - Thomas R. Congdon
- Division of Biomedical Sciences, Warwick Medical School, University of Warwick, Coventry, CV4 7AL, UK
- Cryologyx Ltd, 71-75 Shelton Street, London, WC2H 9JQ, UK
| | - Simon Bassett
- Synthomer (UK) Ltd, Central Road, Templefields, Harlow, Essex, CM20 2BH, UK
| | - Ben Mair
- Synthomer (UK) Ltd, Central Road, Templefields, Harlow, Essex, CM20 2BH, UK
| | - Matthew I. Gibson
- Department of Chemistry, University of Warwick, Coventry, CV4 7AL, UK
- Division of Biomedical Sciences, Warwick Medical School, University of Warwick, Coventry, CV4 7AL, UK
| |
Collapse
|
13
|
Varlas S, Neal TJ, Armes SP. Polymerization-induced self-assembly and disassembly during the synthesis of thermoresponsive ABC triblock copolymer nano-objects in aqueous solution. Chem Sci 2022; 13:7295-7303. [PMID: 35799807 PMCID: PMC9214878 DOI: 10.1039/d2sc01611g] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/18/2022] [Accepted: 05/31/2022] [Indexed: 12/22/2022] Open
Abstract
Polymerization-induced self-assembly (PISA) has been widely utilized as a powerful methodology for the preparation of various self-assembled AB diblock copolymer nano-objects in aqueous media. Moreover, it is well-documented that chain extension of AB diblock copolymer vesicles using a range of hydrophobic monomers via seeded RAFT aqueous emulsion polymerization produces framboidal ABC triblock copolymer vesicles with adjustable surface roughness owing to microphase separation between the two enthalpically incompatible hydrophobic blocks located within their membranes. However, the utilization of hydrophilic monomers for the chain extension of linear diblock copolymer vesicles has yet to be thoroughly explored; this omission is addressed for aqueous PISA formulations in the present study. Herein poly(glycerol monomethacrylate)-poly(2-hydroxypropyl methacrylate) (G-H) vesicles were used as seeds for the RAFT aqueous dispersion polymerization of oligo(ethylene glycol) methyl ether methacrylate (OEGMA). Interestingly, this led to polymerization-induced disassembly (PIDA), with the initial precursor vesicles being converted into lower-order worms or spheres depending on the target mean degree of polymerization (DP) for the corona-forming POEGMA block. Moreover, construction of a pseudo-phase diagram revealed an unexpected copolymer concentration dependence for this PIDA formulation. Previously, we reported that PHPMA-based diblock copolymer nano-objects only exhibit thermoresponsive behavior over a relatively narrow range of compositions and DPs (see Warren et al., Macromolecules, 2018, 51, 8357–8371). However, introduction of the POEGMA coronal block produced thermoresponsive ABC triblock nano-objects even when the precursor G-H diblock copolymer vesicles proved to be thermally unresponsive. Thus, this new approach is expected to enable the rational design of new nano-objects with tunable composition, copolymer architectures and stimulus-responsive behavior. Chain extension of linear AB diblock copolymer vesicles by seeded RAFT aqueous dispersion polymerization using a hydrophilic monomer C leads to polymerization-induced disassembly to form lower-order thermoresponsive ABC triblock copolymer nano-objects.![]()
Collapse
Affiliation(s)
- Spyridon Varlas
- Department of Chemistry, University of Sheffield, Dainton Building, Brook Hill, Sheffield S3 7HF, UK
| | - Thomas J. Neal
- Department of Chemistry, University of Sheffield, Dainton Building, Brook Hill, Sheffield S3 7HF, UK
| | - Steven P. Armes
- Department of Chemistry, University of Sheffield, Dainton Building, Brook Hill, Sheffield S3 7HF, UK
| |
Collapse
|
14
|
Wu X, Yao F, Zhang H, Li J. Antifreeze proteins and their biomimetics for cell cryopreservation: Mechanism, function and application-A review. Int J Biol Macromol 2021; 192:1276-1291. [PMID: 34634336 DOI: 10.1016/j.ijbiomac.2021.09.211] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/12/2021] [Revised: 09/30/2021] [Accepted: 09/30/2021] [Indexed: 12/26/2022]
Abstract
Cell-based therapy is a promising technology for intractable diseases and health care applications, in which cryopreservation has become an essential procedure to realize the production of therapeutic cells. Ice recrystallization is the major factor that affects the post-thaw viability of cells. As a typical series of biomacromolecules with ice recrystallization inhibition (IRI) activity, antifreeze proteins (AFPs) have been employed in cell cryopreservation. Meanwhile, synthesized materials with IRI activity have emerged in the name of biomimetics of AFPs to expand their availability and practicality. However, fabrication of AFPs mimetics is in a chaotic period. There remains little commonality among different AFPs mimetics, then it is difficult to set guidelines on their design. With no doubt, a comprehensive understanding on the antifreezing mechanism of AFPs in molecular level will enable us to rebuild the function of AFPs, and provide convenience to clarify the relationship between structure and function of these early stage biomimetics. In this review, we would discuss those previously reported biomimetics to summarize their structure characteristics concerning the IRI activity and attempt to develop a roadmap for guiding the design of novel AFPs mimetics.
Collapse
Affiliation(s)
- Xiaojun Wu
- School of Chemical Engineering and Technology, Tianjin University, Tianjin 300350, China
| | - Fanglian Yao
- School of Chemical Engineering and Technology, Tianjin University, Tianjin 300350, China; Frontiers Science Center for Synthetic Biology, Key Laboratory of Systems Bioengineering (Ministry of Education), Tianjin University, Tianjin 300350, China
| | - Hong Zhang
- School of Chemical Engineering and Technology, Tianjin University, Tianjin 300350, China; Frontiers Science Center for Synthetic Biology, Key Laboratory of Systems Bioengineering (Ministry of Education), Tianjin University, Tianjin 300350, China.
| | - Junjie Li
- School of Chemical Engineering and Technology, Tianjin University, Tianjin 300350, China; Frontiers Science Center for Synthetic Biology, Key Laboratory of Systems Bioengineering (Ministry of Education), Tianjin University, Tianjin 300350, China.
| |
Collapse
|
15
|
Cao J, Tan Y, Chen Y, Zhang L, Tan J. Expanding the Scope of Polymerization-Induced Self-Assembly: Recent Advances and New Horizons. Macromol Rapid Commun 2021; 42:e2100498. [PMID: 34418199 DOI: 10.1002/marc.202100498] [Citation(s) in RCA: 33] [Impact Index Per Article: 11.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/30/2021] [Revised: 08/18/2021] [Indexed: 12/26/2022]
Abstract
Over the past decade or so, polymerization-induced self-assembly (PISA) has become a versatile method for rational preparation of concentrated block copolymer nanoparticles with a diverse set of morphologies. Much of the PISA literature has focused on the preparation of well-defined linear block copolymers by using linear macromolecular chain transfer agents (macro-CTAs) with high chain transfer constants. In this review, a recent process is highlighted from an unusual angle that has expanded the scope of PISA including i) synthesis of block copolymers with nonlinear architectures (e.g., star block copolymer, branched block copolymer) by PISA, ii) in situ synthesis of blends of polymers by PISA, and iii) utilization of macro-CTAs with low chain transfer constants in PISA. By highlighting these important examples, new insights into the research of PISA and future impact these methods will have on polymer and colloid synthesis are provided.
Collapse
Affiliation(s)
- Junpeng Cao
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou, 510006, China
| | - Yingxin Tan
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou, 510006, China
| | - Ying Chen
- Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou, 510006, China
| | - Li Zhang
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou, 510006, China.,Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou, 510006, China
| | - Jianbo Tan
- Department of Polymeric Materials and Engineering, School of Materials and Energy, Guangdong University of Technology, Guangzhou, 510006, China.,Guangdong Provincial Key Laboratory of Functional Soft Condensed Matter, Guangzhou, 510006, China
| |
Collapse
|
16
|
Fan Q, Dou M, Mao J, Hou Y, Liu S, Zhao L, Lv J, Liu Z, Wang Y, Rao W, Jin S, Wang J. Strong Hydration Ability of Silk Fibroin Suppresses Formation and Recrystallization of Ice Crystals During Cryopreservation. Biomacromolecules 2021; 23:478-486. [PMID: 34378928 DOI: 10.1021/acs.biomac.1c00700] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
Abstract
The cryopreservation (CP) of cell/tissue is indispensable in medical science. However, the formation of ice during cooling and ice recrystallization/growth in time of thawing present significant risk of cell/tissue damage upon analysis of CP process. Herein, the natural and biocompatible silk fibroin (SF) with regular hydrophobic and hydrophilic domains, were first employed as a cryoprotectant (CPA), to the CP of human bone-derived mesenchymal stem cells (hBMSCs), which has been routinely cyropreserved for cell-based therapies. Addtion of SF can regulate the formation of ice crystals during cooling process because of its strong hydration ability in the comparation to the cryopreservation medium (CM) without SF. Moreover, the devitrification-induced recrystallization/growth of ice during the thawing process is suppressed. Most importantly, the addition of 10 mg mL-1 SF can achieve 81.28% cell viability of cryopreserved hBMSCs as similar as those with the addition of 180 mg mL-1 Ficoll 70 (commercial CPA), and the functions of the cryopreserved hBMSCs are maintained as good as that of the fresh ones. This work is not only significant for meeting the ever-increasing demand of cell therapy, but also trailblazing for designing materials in controlling ice formation and growth during the CP of other cells and tissues.
Collapse
Affiliation(s)
- Qingrui Fan
- Key Laboratory of Green Printing, Beijing National Laboratory for Molecular Science, Institute of Chemistry, Chinese Academy of Sciences, Beijing, 100190, China
| | - Mengjia Dou
- CAS Key Laboratory of Cryogenics, Technical Institute of Physics and Chemistry, Chinese Academy of Sciences, Beijing, 100190, China.,Beijing Key Laboratory of Cryo-Biomedical Engineering, Beijing, 100190, China.,School of Engineering Science, University of Chinese Academy of Sciences, Beijing, 100049, China
| | - Junqiang Mao
- Key Laboratory of Green Printing, Beijing National Laboratory for Molecular Science, Institute of Chemistry, Chinese Academy of Sciences, Beijing, 100190, China
| | - Yi Hou
- CAS Key Laboratory of Cryogenics, Technical Institute of Physics and Chemistry, Chinese Academy of Sciences, Beijing, 100190, China.,Beijing Key Laboratory of Cryo-Biomedical Engineering, Beijing, 100190, China.,School of Future Technology, University of Chinese Academy of Sciences, Beijing, 100049, China
| | - Shuo Liu
- Key Laboratory of Green Printing, Beijing National Laboratory for Molecular Science, Institute of Chemistry, Chinese Academy of Sciences, Beijing, 100190, China
| | - Lishan Zhao
- Songshan Lake Materials Laboratory, Dongguan, Guangdong 523808, China
| | - Jianyong Lv
- Songshan Lake Materials Laboratory, Dongguan, Guangdong 523808, China
| | - Zhang Liu
- Key Laboratory of Green Printing, Beijing National Laboratory for Molecular Science, Institute of Chemistry, Chinese Academy of Sciences, Beijing, 100190, China
| | - Yilin Wang
- Key Laboratory of Green Printing, Beijing National Laboratory for Molecular Science, Institute of Chemistry, Chinese Academy of Sciences, Beijing, 100190, China
| | - Wei Rao
- CAS Key Laboratory of Cryogenics, Technical Institute of Physics and Chemistry, Chinese Academy of Sciences, Beijing, 100190, China.,Beijing Key Laboratory of Cryo-Biomedical Engineering, Beijing, 100190, China.,School of Future Technology, University of Chinese Academy of Sciences, Beijing, 100049, China
| | - Shenglin Jin
- Key Laboratory of Green Printing, Beijing National Laboratory for Molecular Science, Institute of Chemistry, Chinese Academy of Sciences, Beijing, 100190, China.,Songshan Lake Materials Laboratory, Dongguan, Guangdong 523808, China
| | - Jianjun Wang
- Key Laboratory of Green Printing, Beijing National Laboratory for Molecular Science, Institute of Chemistry, Chinese Academy of Sciences, Beijing, 100190, China.,School of Future Technology, University of Chinese Academy of Sciences, Beijing, 100049, China.,Songshan Lake Materials Laboratory, Dongguan, Guangdong 523808, China
| |
Collapse
|
17
|
Georgiou P, Marton HL, Baker AN, Congdon TR, Whale TF, Gibson MI. Polymer Self-Assembly Induced Enhancement of Ice Recrystallization Inhibition. J Am Chem Soc 2021; 143:7449-7461. [PMID: 33944551 PMCID: PMC8154521 DOI: 10.1021/jacs.1c01963] [Citation(s) in RCA: 46] [Impact Index Per Article: 15.3] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/19/2021] [Indexed: 02/07/2023]
Abstract
Ice binding proteins modulate ice nucleation/growth and have huge (bio)technological potential. There are few synthetic materials that reproduce their function, and rational design is challenging due to the outstanding questions about the mechanisms of ice binding, including whether ice binding is essential to reproduce all their macroscopic properties. Here we report that nanoparticles obtained by polymerization-induced self-assembly (PISA) inhibit ice recrystallization (IRI) despite their constituent polymers having no apparent activity. Poly(ethylene glycol), poly(dimethylacrylamide), and poly(vinylpyrrolidone) coronas were all IRI-active when assembled into nanoparticles. Different core-forming blocks were also screened, revealing the core chemistry had no effect. These observations show ice binding domains are not essential for macroscopic IRI activity and suggest that the size, and crowding, of polymers may increase the IRI activity of "non-active" polymers. It was also discovered that poly(vinylpyrrolidone) particles had ice crystal shaping activity, indicating this polymer can engage ice crystal surfaces, even though on its own it does not show any appreciable ice recrystallization inhibition. Larger (vesicle) nanoparticles are shown to have higher ice recrystallization inhibition activity compared to smaller (sphere) particles, whereas ice nucleation activity was not found for any material. This shows that assembly into larger structures can increase IRI activity and that increasing the "size" of an IRI does not always lead to ice nucleation. This nanoparticle approach offers a platform toward ice-controlling soft materials and insight into how IRI activity scales with molecular size of additives.
Collapse
Affiliation(s)
- Panagiotis
G. Georgiou
- Department
of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K.
| | - Huba L. Marton
- Department
of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K.
| | - Alexander N. Baker
- Department
of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K.
| | - Thomas R. Congdon
- Department
of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K.
| | - Thomas F. Whale
- Department
of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K.
| | - Matthew I. Gibson
- Department
of Chemistry, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K.
- Warwick
Medical School, University of Warwick, Gibbet Hill Road, CV4 7AL Coventry, U.K.
| |
Collapse
|
18
|
Sun Y, Liu J, Li Z, Wang J, Huang Y. Nonionic and Water-Soluble Poly(d/l-serine) as a Promising Biomedical Polymer for Cryopreservation. ACS APPLIED MATERIALS & INTERFACES 2021; 13:18454-18461. [PMID: 33856763 DOI: 10.1021/acsami.0c22308] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/12/2023]
Abstract
Water-soluble, biodegradable, nonionic, and biocompatible polymers with multiple functional groups are highly desired for biomedical applications. Here, we report that water-soluble nonionic poly(d/l-serine) is chirality-controllable, biodegradation-controllable, and non-cytotoxic. Hence, it can be a highly sought-after alternative to the widely used poly(ethylene glycol), with an additional advantage of having multiple hydroxyl groups for further functionalization. As one example of its biomedical applications, poly(d/l-serine) demonstrated an obvious cryoprotective effect on the red blood cells. The usage of poly(d/l-serine) in the cryopreservation field would be of great promise to resolve the difficulties in separating cryoprotectants due to toxicity.
Collapse
Affiliation(s)
- Yuling Sun
- Key Laboratory of Advanced Materials (MOE), Department of Chemical Engineering, Tsinghua University, Beijing 100084, China
- Key Laboratory of Green Printing, Institute of Chemistry, Chinese Academy of Sciences, Beijing 100190, China
- Max Planck Institute for Polymer Research, Mainz 55128, Germany
| | - Jie Liu
- Key Laboratory of Green Printing, Institute of Chemistry, Chinese Academy of Sciences, Beijing 100190, China
| | - Zhibo Li
- School of Polymer Science and Engineering, Qingdao University of Science and Technology, Qingdao 266042, China
| | - Jianjun Wang
- Key Laboratory of Advanced Materials (MOE), Department of Chemical Engineering, Tsinghua University, Beijing 100084, China
| | - Yanbin Huang
- Key Laboratory of Advanced Materials (MOE), Department of Chemical Engineering, Tsinghua University, Beijing 100084, China
| |
Collapse
|
19
|
Huang J, Guo J, Zhou L, Zheng G, Cao J, Li Z, Zhou Z, Lei Q, Brinker CJ, Zhu W. Advanced Nanomaterials-Assisted Cell Cryopreservation: A Mini Review. ACS APPLIED BIO MATERIALS 2021; 4:2996-3014. [PMID: 35014388 DOI: 10.1021/acsabm.1c00105] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/12/2022]
Abstract
Cell cryopreservation is of vital significance both for transporting and storing cells before experimental/clinical use. Cryoprotectants (CPAs) are necessary additives in the preserving medium in cryopreservation, preventing cells from freeze-thaw injuries. Traditional organic solvents have been widely used in cell cryopreservation for decades. Given the obvious damage to cells due to their undesirable cytotoxicity and the burdensome post-thaw washing cycles before use, traditional CPAs are more and more likely to be replaced by modern ones with lower toxicity, less processing, and higher efficiency. As materials science thrives, nanomaterials are emerging to serve as potent vehicles for delivering nontoxic CPAs or inherent CPAs comparable to or even superior to conventional ones. This review will introduce some advanced nanomaterials (e.g., organic/inorganic nanoCPAs, nanodelivery systems) utilized for cell cryopreservation, providing broader insights into this developing field.
Collapse
Affiliation(s)
- Junda Huang
- MOE International Joint Research Laboratory on Synthetic Biology and Medicines, School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, P. R. China
| | - Jimin Guo
- Center for Micro-Engineered Materials, Department of Chemical and Biological Engineering, The University of New Mexico, Albuquerque, New Mexico 87131, United States.,Department of Internal Medicine, Molecular Medicine, The University of New Mexico, Albuquerque, New Mexico 87131, United States
| | - Liang Zhou
- MOE International Joint Research Laboratory on Synthetic Biology and Medicines, School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, P. R. China
| | - Guansheng Zheng
- MOE International Joint Research Laboratory on Synthetic Biology and Medicines, School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, P. R. China
| | - Jiangfan Cao
- MOE International Joint Research Laboratory on Synthetic Biology and Medicines, School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, P. R. China
| | - Zeyu Li
- MOE International Joint Research Laboratory on Synthetic Biology and Medicines, School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, P. R. China
| | - Zhuang Zhou
- MOE International Joint Research Laboratory on Synthetic Biology and Medicines, School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, P. R. China
| | - Qi Lei
- MOE International Joint Research Laboratory on Synthetic Biology and Medicines, School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, P. R. China
| | - C Jeffrey Brinker
- Center for Micro-Engineered Materials, Department of Chemical and Biological Engineering, The University of New Mexico, Albuquerque, New Mexico 87131, United States
| | - Wei Zhu
- MOE International Joint Research Laboratory on Synthetic Biology and Medicines, School of Biology and Biological Engineering, South China University of Technology, Guangzhou 510006, P. R. China
| |
Collapse
|
20
|
Fayter AE, Hasan M, Congdon TR, Kontopoulou I, Gibson MI. Ice recrystallisation inhibiting polymers prevent irreversible protein aggregation during solvent-free cryopreservation as additives and as covalent polymer-protein conjugates. Eur Polym J 2020; 140:110036. [PMID: 33311718 PMCID: PMC7709485 DOI: 10.1016/j.eurpolymj.2020.110036] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/18/2020] [Revised: 09/11/2020] [Accepted: 09/15/2020] [Indexed: 01/11/2023]
Abstract
Protein storage and transport is essential to deliver therapies (biologics), enzymes for biotechnological applications, and underpins fundamental structural and molecular biology. To enable proteins to be stored and transported it is often essential to freeze them, requiring cryoprotectants such as glycerol or trehalose. Here we explore the mechanisms by which poly(vinyl alcohol), PVA, a potent ice recrystallisation inhibitor protects proteins during freeze/thaw to enable solvent-free cryopreservation with a focus on comparing mixing, verses polymer-protein conjugation. A panel of poly(vinyl alcohol)s are investigated including commercial, well-defined (from RAFT), and PVA-protein conjugates, to map out PVA's efficacy. Enzymatic activity recovery of lactate dehydrogenase was found to correlate with post-thaw aggregation state (less aggregated protein had greater activity), which was modulated by PVA's ice recrystallisation inhibition activity. This macromolecular cryoprotectant matched the performance of glycerol, but at lower additive concentrations (as low as 1 mg.mL-1). It was also demonstrated that storage at -20 °C, rather than -80 °C was possible using PVA as a cryoprotectant, which is not possible with glycerol storage. A second protein, green-fluorescent protein (GFP), was used to enable screening of molecular weight effects and to obtain PVA-GFP bioconjugates. It was observed that covalent attachment of RAFT-derived PVA showed superior cryoprotectant activity compared to simple mixing of the polymer and protein. These results show that PVA is a real alternative to solvent-based protein storage with potential in biotechnology, food and therapeutics. PVA is already approved for many biomedical applications, is low cost and available on a large scale, making it an ideal cryoprotectant formulation enhancer.
Collapse
Affiliation(s)
- Alice E.R. Fayter
- Department of Chemistry, University of Warwick, Coventry CV4 7AL, UK
| | - Muhammad Hasan
- Department of Chemistry, University of Warwick, Coventry CV4 7AL, UK
| | - Thomas R. Congdon
- Department of Chemistry, University of Warwick, Coventry CV4 7AL, UK
| | | | - Matthew I. Gibson
- Department of Chemistry, University of Warwick, Coventry CV4 7AL, UK
- Warwick Medical School, University of Warwick, Coventry CV4 7AL, UK
| |
Collapse
|