The effect of phytase enzyme and level on nutrient extraction by broilers

Effect of Microbial Phytase on Ileal Digestibility of Minerals, Plasma and Urine Metabolites, and Bone Mineral Concentrations in Growing-Finishing Pigs

The study was conducted to evaluate the effects of added phytase in the diet of pigs on utilization of minerals and to determine the essential levels of this supplement in compound feed. An additional aim of the study was a critical assessment of current recommendations regarding the level of phosphorus in the diet of pigs, taking into account the use of phytase. A total of 432 pigs were allotted to six dietary treatments, with nine replicate pens per treatment according to body weight (BW) and sex. The treatments included a negative control (NC) with reduced content of digestible phosphorus; the NC diet supplemented with 6-phytase produced by a genetically modified strain of Aspergillus oryzae in the amount of 250 (NC + 250), 500 (NC + 500), 1000 (NC + 1000), or 1500 (NC + 1500) FTU/kg of feed; and a positive control (PC) diet formulated to meet NCR nutrient requirements for pigs. The results showed that, the higher the phytase activity in the diet (NC+), the lower the concentration of P, Ca, and Mg in the chyme (p < 0.05). Pigs fed the PC and NC+ diets had higher plasma levels of P and Ca than group NC in both fattening periods (p < 0.05). The content of phosphorus in the femur of pigs increased with the level of phytase added to the diet (p < 0.05). The content of Cu and Zn in the femur of pigs in the growing period was higher in groups NC + 500 and NC + 1000 than in the remaining experimental groups (p < 0.001). The content of P and Ca in the feces was higher in pigs fed the PC diet in comparison to the remaining experimental groups in both fattening periods (p < 0.001). There was a decrease in the content of P, Ca, and Mg in the excreta of pigs fed NC+ diets in both fattening periods (p < 0.05). A linear decrease in excretion of zinc in the feces was noted in the case of high levels of phytase, i.e., 1000 and 1500 FTU (p < 0.001). Increasing the level of phytase decreased the Cu (p < 0.001) content in the urine of growing−finishing pigs. In conclusion, the analysis of the effects of the use of phytase in a range of 0−1500 FTU/kg in low-phosphorus diets for fattening pigs indicates that 1000 FTU is the most effective level of phytase for increasing utilization of minerals and reducing excretion of elements into the environment.

Endogenous enzyme activities and tibia bone development of broiler chickens fed wheat-based diets supplemented with xylanase, β-glucanase and phytase

Objective

This study assessed the effect of different levels of xylanase, β-glucanase and phytase on intestinal enzyme activities and tibia bone development in broiler chickens fed wheat-based diets.

Methods

Twelve experimental diets were formulated using a 3×2×2 factorial design (three doses of phytase and two doses of both xylanase and β-glucanase) and offered to 648 day-old Ross 308 male chicks having 6 replicates groups with 9 birds per replicate and lasted for 35 days.

Results

An interaction between the enzymes products improved (p<0.01) the activity of chymotrypsin. Protein content at d 10 was highest (p<0.001) with addition of phytase while general proteolytic activity (GPA) (p<0.02) and lipase activity (p<0.001) were decreased. At d 24, there were improvements in protein content (p<0.01) and lipase (p<0.04) with supplementation of superdose phytase. Addition of superdose phytase decreased in chymotrypsin (p<0.02), trypsin (p<0.01) and GPA (p<0.001). The optimum dose of xylanase decreased the chymotrypsin activity (p = 0.05), while the GPA (p<0.001) was increased with the optimum level of β-glucanase. Superdose phytase supplementation at d 10 improved maltase (p = 0.05), sucrase (p<0.001) and alkaline phosphatase (p<0.001) activities in the jejunum while aminopeptidase activity was highest (p<0.005) with the low level of phytase. Protein content of jejunum mucosa was bigger (p<0.001) in birds fed superdose phytase while maltase activity (p<0.001) at d 24 was reduced by this treatment. Sucrase (p<0.04) and aminopeptidase activities (p<0.001) improved when diets supplemented with low levels of phytase. Tibia bone breaking strength was highest (p<0.04) with addition of low level of superdose phytase or optimum level of β-glucanase. Bone dry matter content decreased (p<0.04) when diets supplemented with phytase.

Conclusion

From the results obtained in this study, supplementation of superdose phytase was the most effective, however, the cost-benefit analysis of the use of such a dose needs to be evaluated.

Effect of phytase on phosphorous balance in 20-kg barrows fed low or adequate phosphorous diets

The effects of phytase on phosphorus (P) digestibility are well established. However, there are few studies that report P balance, particularly when phytase is used in diets that have adequate or deficient P. The main objective of the study was to determine the effect of dietary P levels and exogenous phytase on P balance in growing pigs. The first part of the experiment was a 14-d metabolism study conducted with 80 barrows (initial body weight 18.5 ± 0.5 kg) with a 2 × 5 factorial arrangement of treatments and main effects of available P (0.13% available P, low P [Low-P] diet; 0.35% available P, adequate P [Adeq-P] diet) and phytase (0, 250, 500, 2,500, and 12,500 U/kg). A portion of the pigs (n = 24) fed the Low-P diet, with 0, 500, 2,500, 12,500 U/kg phytase, and those fed the Adeq-P diet, with 0 and 12,500 U/kg phytase, remained on test diets for another 4 d, and tissues were collected for determination of bone characteristics and tissue P concentration. There was a P × phytase interaction for P retention that was accounted for by a lack of response to phytase in pigs fed the Adeq-P diet. Retention of P was greater with incremental levels of phytase in pigs fed Low-P diets as compared to those fed Adeq-P diets (P level × phytase, P < 0.01), but calcium (Ca) retention was greater in pigs fed Adeq-P diets (P level × phytase P < 0.01). Apparent total tract digestibility (ATTD) of P was improved by phytase (P < 0.001) and was greater in pigs fed Adeq-P diets as compared to those fed Low-P diets (P = 0.006). Metatarsal bone ash (quadratic, P = 0.01) and strength (linear, P = 0.03) was increased by phytase addition to the Low-P diets. There were no phytase or dietary P effects on P concentrations of the heart, kidney, liver, muscle, and spleen. These results suggest that as compared to the effects in an Adeq-P diet, adding phytase to a Low-P diet was more effective at reducing the P and Ca excretion and restoring average daily gain (ADG). The P released by phytase is absorbed and contributes to improved bone growth, greater rates of tissue accretion, and increased body weight, but does not change tissue P concentrations. There is, however, a threshold for P retention, beyond which it is excreted in the urine.

Evaluation of a new generation phytase on phytate phosphorus release for egg production and tibia strength in hens fed a corn-soybean meal diet

To test the effect of several inclusion levels of Citrobacter braakii phytase (CBP), on phytate P release, 420 50-wk-old-Bovans White hens were randomly allocated to 7 treatments with 5 replicates of 12 hens each. The experimental period lasted 12 weeks, first 8 for adaptation and last 4 for data collection. Feed and water were provided ad libitum. Treatments were: (1) a 0.12% basal corn-soybean meal diet deficient only in non-phytate P. Treatments 2 and 3 were added with constant increases of 0.11% inorganic P, to get a linear hen response to P addition. Treatments 4 to 7 were the addition of 300; 600; 1,200; and 1,800 phytase units (FYT)/kg to the basal diet. Variables analyzed were hen productive performance (HPP) and tibia resistance to fracture (TRF), and mineral content. Data were analyzed as a Complete Randomized Design (CRD). The results from treatments 1 to 3 were analyzed by a regression model to test for a significant linear response (P < 0.05). Then for every level of CBP added (treatments 4 to 7), the linear regression equation was solved to find out the equivalent value of released P. Based on hen health and welfare, the response variables that yielded realistic P equivalence values for the CBP levels used in the present trial were the tibia data. Following the significant (P < 0.001) linear response, the equations; TRF, kg (Y = 28.16X + 17.42 R² = 0.84); Tibia Ca, % (Y = 11.6X + 14.2 R² = 0.80); Tibia P, % (Y = 11.6X + 6.1 R² = 0.81); and T ash, % (Y = 33.3X + 38.1 R² = 0.80). Under the experimental conditions of this trial, the HPP variables were not a sensitive parameter to measure P release; whereas, tibia parameters showed the following average P release values per level of CBP inclusion in the corn- soybean meal diet; 300 FYT/kg = 0.099%, 600 FYT/kg = 0.141%, 1,200 FYT/kg = 0.182%, and 1,800 FYT/kg = 0.198%.

Low digestibility of phytate phosphorus, their impacts on the environment, and phytase opportunity in the poultry industry

Phosphorus is an essential macro-mineral nutrient for poultry, needed for the body growth, development of bones, genomic function, good quality flesh, and eggs production. The imbalance of organic phosphorus sources in the diet mostly affect the phosphorus digestibility, reduces the poultry performance and health, and increases the environmental pollution burden. A study was reviewed to estimate the low phytate phosphorus digestibility of ingredients in poultry diet and their impacts on environmental ecosystem and opportunity of phytase supplementation. Plant ingredients mostly used in poultry diets are rich in phytate phosphorus. The phytate phosphorus digestibility and utilization is low in the gut of birds which leads to decrease other nutrients digestibility and increase excessive excretion of phosphorus with additional nutrients in the manure. When that manure applied to the lands containing excessive residual phosphorus and additional nutrients which pollute soil, groundwater disturbed the entire ecosystem. This issue is developed by poultry due to lack of digestive enzyme phytase which promotes the phytate phosphorus during digestion and reduces the excessive losses of phosphorus in excreta. To overcome this matter, the addition of mostly exogenous phospho-hydrolytic phytase enzymes in the diet, i.e. Escherichia coli, Peniophora lycii, Aspergillus niger, and Ficum, are the possible ways to increase the digestibility and utilization of phytate phosphorus and promote the stepwise release of phosphorus from phytate and significantly decrease phosphorus excretion. The aim of this review is to highlight the role of phytase supplementation in the poultry feeding, improvement of phytate phosphorus digestibility with performance, and reduction of phosphorus pollution from the environment.

Effects of thermo-resistant non-starch polysaccharide degrading multi-enzyme on growth performance, meat quality, relative weights of body organs and blood profile in broiler chickens

This research was conducted to study the performance and carcass parameters of broiler chickens fed diets supplemented with heat-treated non-starch polysaccharide degrading enzyme. A total of 432 one-day old Ross 308 broiler chickens were allocated to five treatments: (i) CON (basal diet), (ii) E1: CON + 0.05% multi-enzyme, (iii) E2: CON + 0.1% multi-enzyme, (iv) E3: CON + 0.05% thermo-resistant multi-enzyme and (v) E4: CON + 0.1% thermo-resistant multi-enzyme, each treatment consisted of six replications and 12 chickens in each replication. The chickens were housed in three floor battery cages during 28-day experimental period. On days 1-7, gain in body weight (BWG) improved by feeding the diets supplemented with thermo-resistant multi-enzyme. On days 7-21 and 1-28, chickens fed the diets containing thermo-resistant multi-enzyme showed improved (p < 0.05) BWG and feed conversion ratio (FCR) compared to CON group. Supplementing the diets with multi-enzyme or thermo-resistant multi-enzyme affected the percentage of drip loss on d 1 (p < 0.05). Drip loss percentage on days 3 and 5 and also meat colour were not affected significantly. Supplementing the diets with multi-enzyme or thermo-resistant multi-enzyme did not affect the relative weights of organs but compared to CON group, relative weight of breast muscle increased and abdominal fat decreased (p < 0.05). Among measured blood constituents, chickens fed supplemented diets with thermo-resistant multi-enzyme showed higher (p < 0.05) IgG. Counts of red and white blood cells and lymphocyte percentage were not affected. In conclusion, the results demonstrated that supplementing pelleted diets with thermo-resistant multi-enzyme improved performance of broiler chickens.

Trehalose hydrogels for stabilization of enzymes to heat

Enzymes can catalyze various reactions with high selectivity and are involved in many important biological processes. However, the general instability of enzymes against high temperature often limits their application. To address this, we synthesized a trehalose-based hydrogel in two steps from commercial starting materials with minimal purification procedures. Mono- and multi-functional trehalose monomers were cross-linked by redox-initiated radical polymerization to form a hydrogel. Phytase, an important enzyme utilized in animal feedstock, was employed to study the effectiveness of the trehalose hydrogel to stabilize proteins against heat. Addition of the phytase solution to the hydrogel resulted in enzyme internalization as confirmed by confocal microscopy. The phytase in the hydrogel retained 100% activity upon heating at 90 °C compared to 39% when the hydrogel was absent. The enzyme could also be recovered from the hydrogel. The trehalose hydrogel synthesis reported herein should be readily scalable for thermal stabilization of a wide variety of enzymes.

Effect of high phytase inclusion rates on performance of broilers fed diets not severely limited in available phosphorus

Phytate is not only an unavailable source of phosphorus (P) for broilers but it also acts as an anti-nutrient, reducing protein and mineral absorption, increasing endogenous losses and reducing broiler performance. The objective of this study was to investigate the anti-nutritional effects of phytate by including high levels of phytase in diets not severely limited in available P. A total of 768 male Arbor Acres broilers were distributed in six treatments of eight replicate pens of 16 birds each consisting of a positive control diet (PC), positive control with 500 FTU/kg phytase, negative control (NC) diet with lower available P and calcium (Ca) levels and the same NC diet with 500, 1,000 or 1,500 FTU/kg phytase. Body weight gain (BWG), feed intake (FI), feed conversion ratio (FCR) and mortality were determined at 21 and 35 d of age while foot ash was determined in four birds per pen at 21 d of age. FI, FCR and foot ash where not affected by the lower mineral diets at 21 d of age nor by the enzyme inclusion but broilers fed lower Ca and available P diets had lower BWG. At 35 d of age no difference was observed between broilers fed the positive or NC diets but broilers fed 500, 1,000 and 1,500 FTU/kg on top of the NC diet had better FCR than broilers fed the positive control diet. When compared to birds fed a diet adequate in P, birds fed the same diet included with 500, 1,000 and 1,500 FTU/kg of phytase in marginally deficient available P and Ca diets had an improvement of performance. These results support the concept that hydrolysing phytate and reducing the anti-nutritional effects of phytate improves bird performance on marginally deficient diets that were not covering the P requirement of birds.

Review: Supplementation of phytase and carbohydrases to diets for poultry

Woyengo, T. A. and Nyachoti, C. M. 2011. Review: Supplementation of phytase and carbohydrases to diets for poultry. Can. J. Anim. Sci. 91: 177–192. Feedstuffs of plant origin contain anti-nutritional factors such as phytic acid (PA) and non-starch polysaccharides (NSP), which limit nutrient utilization in poultry. Phytic acid contains phosphorus, which is poorly digested by poultry, and has the capacity to bind to and reduce the utilisation of other nutrients, whereas NSP are indigestible and have the capacity to reduce nutrient utilisation by encapsulation. Supplemental phytase and NSP-degrading enzymes (carbohydrases) can, respectively, hydrolyze PA and NSP, alleviating the negative effects of these anti-nutritional factors. In feedstuffs of plant origin, PA is located within the cells, whereas NSP are located in cell walls, and hence it has been hypothesized that phytase and carbohydrases can act synergistically in improving nutrient utilization because the carbohydrases can hydrolyze the NSP in cell walls to increase the accessibility of phytase to PA. However, the response to supplementation of a combination of these enzymes is variable and dependent on several factors, including the type of carbohydrase supplement used, dietary NSP composition, calcium and non-phytate phosphorus contents, and endogenous phytase activity. These factors are discussed, and areas that need further research for optimising the use of a combination of phytase and carbohydrases in poultry diets are suggested.

Growth performance and nutrient utilization of broiler chickens fed diets supplemented with phytase alone or in combination with citric acid and multicarbohydrase

An experiment was conducted to determine the effect of supplementing a corn-soybean meal-based diet with phytase alone or in combination with citric acid (CA) or multicarbohydrase, a preparation containing nonstarch polysaccharide-degrading enzymes, or both, on growth performance, nutrient utilization, and bone mineralization. A total of 360 one-day-old broiler chicks were assigned to 6 dietary treatments, consisting of 12 pens of 5 birds each, and were fed experimental diets from 1 to 21 d of age. The diets included a positive control (0.46% nonphytate P; 1.1% Ca) and a negative control (NC; 0.26% nonphytate P; 0.89% Ca) without or with phytase (600 U/kg) alone, phytase plus CA (5 g/kg), phytase plus multicarbohydrase (Superzyme OM; 0.6 g/kg), or phytase (Ronozyme P-CT) plus CA and multicarbohydrase. Birds fed the positive control diet had higher (P<0.05) BW gain (764 vs. 594 g/21 d) and tibia ash content (50.0 vs. 38.3%) than those fed the NC diet. Phytase improved (P<0.05) BW gain (632 g/21 d), which increased further (P<0.05) to 673 g/21 d for the phytase plus multicarbohydrase diet. In contrast to phytase alone, phytase plus multicarbohydrase supplementation improved (P<0.05) feed conversion ratio of the NC diet from 1.37 to 1.32. Tibia ash content for the NC diet increased (P<0.05) from 38.3 to 42.4% due to phytase addition. Phytase improved (P<0.05) ileal digestibility of P from 29.5 to 43%, and the addition of CA or multicarbohydrase, or both, to a phytase-supplemented diet further increased (P<0.05) P digestibility to 51.5, 53.4, and 54.3%, respectively. Phytase addition improved (P<0.05) diet AMEn content from 2,959 to 3,068 kcal/kg, which tended (P<0.06) to increase further with CA (3,150 kcal/kg) or multicarbohydrase (3,142 kcal/kg) addition. No beneficial interactions were detected between CA and multicarbohydrase for all response criteria measured. Results show that addition of multicarbohydrase to the phytase-supplemented broiler diets improved nutrient utilization and growth performance.

Non-phytate phosphorus requirements and efficacy of a genetically engineered yeast phytase in male Lingnan Yellow broilers from 1 to 21 days of age

This experiment was conducted to investigate the requirement of non-phytate phosphorus (nPP) and efficacy of a genetically engineered yeast phytase in performance and tibia characteristics by male Lingnan Yellow broilers from 1 to 21 days of age. A total of 2640 1-day-old male chicks were randomly allotted to one of 11 dietary treatments, which consisted of six replicate floor pens with 40 birds per pen. All treatments had the same levels of all nutrients except for phosphorus and phytase. The control group (treatment 1) was fed the basal diet without dicalcium phosphate or phytase supplementation. Dietary concentrations of nPP were 0.11%, 0.19%, 0.27%, 0.35%, 0.43%, 0.51% and 0.59% respectively for treatments 1, 2, 3, 4, 5, 6 and 7, through addition of dicalcium phosphate (chemistry grade) to the basal diet. Diets 8-11 were supplemented with a genetically engineered yeast phytase 250, 500, 750 U/kg and a commercial phytase product 500 U/kg in basal diet respectively. The results showed that 0.46% and 0.51% nPP were required for maximum body-weight gain and optimum tibia development indicators respectively. However, 0.59% nPP had a negative effect on bird growth. The equivalency value of the genetically engineered yeast phytase was estimated to be 874 U/kg to liberate 0.1% nPP.

Effects of different dietary phytase activities on the concentration of antioxidants in the liver of growing broilers

One-hundred and fifty male chickens were used to evaluate the effects of different activities (0, 250, 500, 12 500 FTU/kg) of phytase on their performance and antioxidant concentration in the liver. The chicks were housed in 30 cages and were allocated to six replicates of five dietary treatments. All diets were formulated to be adequate in energy and protein (12.90 MJ/kg metabolizable energy, 214 g/kg crude protein), however, the negative control (NC) was lower in available P compared with the positive control (PC) (2.5 vs. 4.5 g/kg diet). The other three diets were the NC supplemented with phytase at 250, 500 and 12 500 FTU/kg (NC + 250, NC + 500 and NC + 12 500 FTU respectively). The concentration of antioxidants in the liver of the birds was determined using HPLC at 21 days of age. Low P diets (NC) reduced weight gain, however, supplementation with phytase improved weight gain to the extent that it was better than the PC at the 12 500 FTU treatment (p < 0.05). Feed conversion ratio was also improved by the high level of phytase supplement more than other treatments (p < 0.05). Feed consumption was not affected either by dietary phosphorus concentration or by different phytase supplementation. The antioxidant data showed that the unsupplemented diet with low phosphorus (NC) decreased the concentration of coenzyme Q(10) and retinol-linoleate in the liver compared with that of birds on the adequate phosphorus treatment (PC). Phytase supplementation, especially at the higher doses (500 and 12 500 FTU) increased the level of coenzyme Q(10) to the same level as the PC treatment. In addition, the highest dose (12 500 FTU) of phytase increased retinol concentration in the liver of chickens compared with those on the NC treatment. The highest inclusion level of phytase increased the alpha-tocopherol level in the liver compared with the lower levels of phytase (NC + 250 and NC + 500 FTU).

Effect of Quantum phytase on nutrient digestibility and bone ash in White Leghorn laying hens fed corn-soybean meal-based diets

The efficacy of an Escherichia coli 6-phytase supplementation (Quantum) on nutrient digestibility-retention and bone ash in laying hens fed corn-soybean meal (CSM) diets was investigated. White Leghorn hens (Shaver and Bovan strains) were fed CSM diets containing 0.35% (positive control, PC), 0.25% (negative control 1, NC1), or 0.15% (negative control 2, NC2) nonphytate P from 21 to 61 wk of age. Six more diets were manufactured by supplementing the negative control diets with 200, 400, and 600 units per kilogram of exogenous phytase resulting in a total of 9 treatments. Each dietary treatment x strain subclass was replicated twice with 6 hens per replication. Fecal and ileal digesta samples were collected at 42 wk of age to determine apparent nutrient digestibility or retention. Left tibiae were collected at 42 and 61 wk of age to determine bone ash. The coefficients for ileal digestibility and fecal retention for protein were higher (P < 0.05) for the unsupplemented negative control treatments compared with the PC. A linear reduction in phytate digestibility and ileal protein digestibility was reported with increasing levels of phytase to the NC1 diet. Phytase addition to the NC1 treatment resulted in a linear decrease in the digestibility of amino acids except for methionine and proline. Significantly higher phytate digestibility was demonstrated with the NC2 treatment containing 400 units per kilogram of phytase compared with the PC. Tibial bone ash percentage was higher (P < 0.05) in 61-wk-old hens fed 200 or 400 units per kilogram of phytase-supplemented NC2 diets. Significantly higher diet AME and fecal protein retention were demonstrated for Shaver hens in comparison to the Bovan hens. Overall, the Quantum phytase was not efficacious at improving nutrient digestibility-retention in laying hens fed CSM diets deficient in nonphytate P.

Utilização de nutrientes em frangos alimentados com dietas suplementadas com fitase e níveis reduzidos de fósforo não-fítico

Avaliaram-se a digestibilidade ileal, retenção de nutrientes e valores de energia metabolizável aparente (EMA) de dietas suplementadas com fitase e níveis reduzidos de fósforo não-fítico (FNF) para frangos de corte. Foram utilizados 330 pintos machos em delineamento em blocos ao acaso e esquema fatorial 2 x 3 com dois níveis de fitase (0 e 25U/kg) e três níveis de FNF (100, 85 e 70% das exigências da ave), totalizando seis tratamentos com cinco repetições de 11 aves cada. Não houve efeito da interação FNF vs fitase e dos níveis de FNF ou fitase sobre a retenção de matéria seca e de fósforo, e a interação FNF vs fitase foi significativa para retenção de proteína bruta e coeficiente de digestibilidade ileal da matéria seca. A suplementação com fitase, independente dos níveis de FNF, melhorou o coeficiente digestibilidade ileal da proteína bruta, do cálcio e do fósforo. A retenção de cálcio e a redução dos níveis de FNF diminuíam a metabolização da energia bruta das dietas com 85 e 70% das exigências de FNF. Dietas com nível de 70% das exigências de FNF, suplementadas com fitase, podem ser usadas para frangos de corte sem prejuízos à digestibilidade ileal e retenção da matéria seca, proteína bruta, cálcio e fósforo e à metabolização da energia bruta.

Low-phytate barley cultivars improve the utilization of phosphorus, calcium, nitrogen, energy, and dry matter in diets fed to young swine

A 28-d experiment was conducted using 45 crossbred barrows with an average initial BW of 9.5 kg and age of 35 d to evaluate low-phytate barley (LPB) mutants (M) M422, M635, and M955, which were hulled, near-isogenic progeny of the normal barley (NB) Harrington and had 47, 66, and 80% less phytic acid, respectively, than NB. A hull-less LPB, M422-H, which was not near-isogenic to the other cultivars, was also evaluated. Apparent nutrient balance, bone measurements, and growth performance were the response criteria evaluated. The barrows were fed the diets to appetite in meal form in individual metabolism crates. Barley and soybean meal were the only sources of phytic acid. Dietary protein supplementation and ME/kg were equalized in all diets. The treatments were diets containing NB, M422, M635, or M422-H without or with added inorganic P (iP), or M955 without added iP. Diets with added iP contained 0.30% available P (aP), the same concentration of aP provided by the diet containing M955 without added iP. There were linear increases (P < or = 0.02) in ADG, G:F, metacarpal and radius bone strength, and fat-free dry weight, and in the absorption and retention (g/d and % of intake) of P and Ca with increasing dietary concentration of aP from the near-isogenic cultivars NB, M422, M635, or M955 without added iP. There were linear decreases in the grams (P < or = 0.02) and percentages (P < 0.001) of P and Ca excreted per day with increasing dietary concentration of aP without added iP. There were no responses for N or energy balance. Growth performance and bone response criteria did not differ for barrows fed the diet containing M955 or the near-isogenic diets containing NB, M422, or M635 with added iP. However, barrows fed the diet containing M955 had greater (P < or = 0.02) percentages of P, N, and energy absorption and retention, Ca absorption, and DM digestibility and had less (P < or = 0.02, g/d and %) excretion of P, N, energy, and Ca (g) per day than barrows fed the diets containing the near-isogenic NB or LPB cultivars with added iP. When dietary aP was equalized with iP, the excretion of P in feces plus urine (g/d) was reduced by 20.2, 27.9, and 44.6%, respectively, in barrows fed the diets containing M422 + iP, M635 + iP, or M955 compared with barrows fed the diet containing NB + iP. Energy utilization did not differ for barrows fed the diets containing hulled or hull-less LPB when ME/kg was equalized with lard. In conclusion, the apparent utilization of P and Ca, the bone strength and fat-free dry weight, and growth performance increased with increasing dietary concentration of aP provided by LPB, in association with linear decreases in P and Ca excretion. Barrows fed the diet containing M955 also had greater utilization and less excretion of P, Ca, N, energy, and DM than barrows fed the diets containing the near-isogenic NB or LPB cultivars with added iP to equalize aP at 0.30%.

A genetically engineered Escherichia coli phytase improves nutrient utilization, growth performance, and bone strength of young swine fed diets deficient in available phosphorus1

A 28-d experiment was conducted using 126 crossbred barrows to evaluate the addition of a genetically engineered Escherichia coli phytase to diets that were 0.15% deficient in available P. Growth performance, bone strength, ash weight, and the apparent absorption of P, Ca, Mg, N, energy, DM, Zn, Fe, and Cu were the response criteria. The pigs (2 pigs/pen) averaged 7.61 kg of BW and 30 d of age initially. The low-P basal diet was supplemented with 0, 100, 500, 2,500, or 12,500 units (U) of E. coli phytase/kg of diet, or 500 U of Peniophora lycii phytase/kg of diet. The positive control (PC) diet was adequate in available P. Pigs were fed the diets in meal form. Fecal samples were collected from each pig from d 22 to 27 of the experiment. There were linear and quadratic increases (P < 0.001) in 28-d growth performance (ADFI, ADG, and G:F), bone breaking strength and ash weight, and the apparent absorption (g/d and %) of P, Ca, and Mg (P < or = 0.01 for quadratic) with increasing concentrations of E. coli phytase. Pigs fed the low-P diets containing 2,500 or 12,500 U/kg of E. coli phytase had greater (P < or = 0.01 or P < 0.001, respectively) values for growth performance, bone breaking strength and ash weight, and the apparent absorption (g/d and %) of P, Ca, and Mg than pigs fed the PC diet. The addition of E. coli phytase did not increase the apparent percentage absorption of N, GE, DM, Zn, Fe, or Cu. There were no differences in the efficacy of the E. coli or P. lycii phytase enzymes at 500 U/kg of low-P diet for any criterion measured. In conclusion, there were linear increases in growth performance, bone breaking strength and ash weight, and the apparent absorption of P, Ca, and Mg with increasing addition of E. coli phytase up to 12,500 U/kg of diet. Also, all of these criteria were greater for pigs fed the low-P diets containing 2,500 or 12,500 U of E. coli phytase/kg than for pigs fed the PC diet. The addition of 500, 2,500, or 12,500 U of E. coli phytase/kg of low-P diet reduced P excretion (g/d) in manure by 35, 42, and 61%, respectively, compared with pigs fed the PC diet.

A Study on the Interaction of Xylanase and Phytase Enzymes in Wheat-Based Diets Fed to Commercial White and Brown Egg Laying Hens

A trial was conducted to investigate potential interactions between phytase and xylanase enzymes in wheat-based laying diets. Hens (480 ISA-White and 480 ISA-Brown) were distributed into 160 experimental units and fed one of 10 diets containing 75 to 77% wheat from 33 to 64 wk of age with a diet change at 49 wk. Two diets were adequate in P content (0.3 and 0.25% available P in the 2 phases) with or without xylanase (0 or 2,000 U/kg; Avizyme 2300, Danisco Animal Nutrition, Marlborough, Wiltshire, United Kingdom), and 8 diets had reduced P (0.2 and 0.15% available P) with or without xylanase and phytase (0, 300, 500, and 700 ppu/kg; Phyzyme 5000G, Danisco Animal Nutrition). Egg production was higher for ISA-Brown than for ISA-White hens, and ISA-Brown hens were larger. Eggs from ISA-Brown hens had lower albumen height; higher egg, shell, and albumen weights; and lower yolk weight than those from ISA-White hens. Egg production was not affected by the diet. In P-reduced diets without xylanase, phytase significantly increased BW gain in the first period with no change in feed intake or feed efficiency. In P-adequate diets, xylanase increased egg and albumen weight and albumen height. In P-reduced diets with xylanase, increasing levels of phytase increased egg and albumen weight. This trial demonstrated no negative interactions between these enzymes for production traits and no interactions between the diet and strain of hen. These data suggest that poultry producers can use these enzymes individually or together in feed for the Brown and White egg layers used in this study without concern for the strain of hen.