Effect of dietary phosphorus, phytase, and 25-hydroxycholecalciferol on broiler chicken bone mineralization, litter phosphorus, and processing yields

Effects of dietary calcium and phosphorus restrictions on growth performance, intestinal morphology, nutrient retention, and tibia characteristics in broiler chickens

1. This study evaluated the effects of dietary calcium (Ca)‎ and available phosphorus (aP) restrictions on growth performance, intestinal morphology, nutrient apparent total tract retention (ATTR), and tibia characteristics.2. A total of 1296, one-day-old male Ross-308 broilers were reared for 42 d. During the ‎starter phase (1-10 d), all birds were fed a nutrient-adequate diet (C). Diets fed during the grower phase (11-24 d) included: 1. C; 2. 15% of the Ca and aP in C; 3. 30% of the Ca and aP in C. At the beginning of the finisher phase (25 d), chickens fed the C diet were divided into two subgroups including C, and C+ phytase (500 FTU/kg). Restricted treatments were divided into eight subgroups as 1. C; 2. 10% of the Ca and aP in C; 3. 20% of the Ca and aP in C; 4. 30% of the Ca and aP in C; 5. C+ phytase; 6. 10% of the Ca and aP in C+ phytase; 7. 20% of the Ca and aP in C+ phytase and 8. 30% of the Ca and aP in C+ phytase.3. On d 24 and 42, ATTR of Ca and phytate phosphorus (pP) were linearly increased by decreasing Ca and aP levels (P<0.05). Birds receiving phytase showed higher nutrient ATTR ‎compared to those fed non-phytase supplemented diets (P<0.05). Tibia Ca and P were linearly decreased at 24 d (P<0.05) and tibial ash was linearly decreased (P<0.05) at 42 d by decreasing levels of Ca and aP in finisher diets (without phytase)‎. By decreasing the levels of Ca and aP in the finisher diets (with phytase) with a 30% reduction of Ca and aP in the grower phase, tibia ash linearly decreased (P <0.05). Using 500 FTU/kg phytase improved tibia traits compared to non-phytase supplemented treatments (P<0.05).4. In general, decreasing dietary Ca and aP (up to 30%) during grower and finisher phases increased ATTR of minerals and decreased Ca, P and breaking strength (BS) of tibia without any negative effect on growth performance or intestinal morphology. Reduced dietary Ca and aP decreased tibial ash content, although 500 FTU/kg phytase improved ATTR of minerals and tibia attributes.

Partial Replacement of Soybean Meal with Canola Meal or Corn DDGS in Low-Protein Diets Supplemented with Crystalline Amino Acids-Effect on Growth Performance, Whole-Body Composition, and Litter Characteristics

A 42-day study was conducted to explore the application of supplemental amino acids (AA) in low-protein diets with soybean meal (SBM), canola meal (CM) or corn distillers dried grain with solubles (cDDGS) as the main protein feedstuffs. The responses of interest were growth performance, carcass yield, whole-body composition, litter ammonia and litter N. On d 0, a total of 540 Cobb 500 (off-sex) male broilers were allocated to 36 floor pens. All the birds received one starter diet that met nutrient requirements during the first 10d. Thereafter, six experimental diets were provided in grower and finisher phases. The diets included a positive control (PC): a corn−SBM diet with adequate protein. The protein level of the negative control (NC) was decreased by 45 g/kg relative to the PC. The next two diets had the same protein levels as the NC but with cDDGS added at 50 or 125 g/kg. The last two diets had the same CP as the NC but with CM added at 50 or 100 g/kg. All the low-protein diets had the same level of standardized ileal digestible indispensable AA according to Cobb 500 recommended level. Gly and Ser were added as sources of non-specific N. The dietary protein reduction in corn−SBM diets at both phases decreased (p < 0.05) weight gain and increased (p < 0.05) feed conversion ratio (FCR). Increasing levels of cDDGS or CM, at a constant CP level, linearly decreased (p < 0.05) the weight gain and feed intake, whereas increasing CM level linearly increased (p < 0.05) FCR in the grower and finisher phases. The eviscerated and carcass yields decreased, whereas the fat yield increased (p < 0.05) with reduced protein in corn−SBM diet. Increasing levels of cDDGS and CM at a constant CP level quadratically decreased (p < 0.05) the eviscerated weight, whereas the fat weight linearly decreased (p < 0.05) with increasing levels of cDDGS and CM. The birds receiving the PC diet had a lower (p < 0.05) lean muscle (%) and a higher fat (%) compared to birds receiving the NC diet at d 21. However, on d42, birds receiving the PC diet had decreased (p < 0.05) bone mineral density, bone mineral content and lean weight compared to those receiving the NC diet. The litter ammonia increased (p < 0.05) with the increasing levels of protein in the SBM diets. In conclusion, 50 g/kg inclusion levels of CM and cDDGS at the same low-protein levels as SBM produced a similar growth response to the NC, whereas higher levels were detrimental. Hence under the conditions of the current experiment, complete replacement of SBM with DDGS or CM in low-protein diets was not feasible.

The Growth Performance, Nutrient Digestibility, Gut Bacteria and Bone Strength of Broilers Offered Alternative, Sustainable Diets Varying in Nutrient Specification and Phytase Dose

This study assessed the use of locally sourced sustainable feed ingredients, rapeseed meal (RSM) and maize dried distiller grains with solubles (DDGS) in diets over traditional ingredients on the growth performance, bone strength and nutrient digestibility of broilers. This work also investigated the effects of supplementing exogenous phytase in two doses (500 vs. 1500 FTU/kg). Using male Ross 308 chicks (n = 320) assigned to receive one of four experimental diets: (1) Positive control diet 1 (PC1), a wheat, soya-based diet + 500 FTU/kg phytase. (2) Positive control diet 2, RSM/DDGS diet + 500 FTU/kg phytase (PC2). (3) Negative control (NC) reduced nutrient RSM/DDGS diet, no phytase. (4) The NC diet plus 1500 FTU/kg phytase (NC+). PC1 birds displayed higher feed intake and body weight gain consistently throughout the trial (p < 0.001) as well as increased body weight by 28 d and 42 d (p < 0.001). Whole-body dual emission X-ray absorptiometry (DXA) analysis revealed PC1 birds also had higher bone mineral density (BMD), bone mineral content (BMC), total bone mass, total lean mass and total fat mass than birds offered other treatments (p < 0.01). Diet had no significant effect on bone strength. Phytase superdosing improved the digestibility of dry matter (DM), neutral detergent fibre (NDF), gross energy (GE), calcium (Ca), potassium (K) and magnesium (Mg) compared to birds in other treatment groups. The phytase superdose also improved performance in comparison to birds offered the NC diet. Phytase superdosing increased the IP6 and IP5 degradation and increased the ileal inositol concentration of the birds. N excretion was lower for birds offered the traditional wheat−soya diet and highest for those offered the high-specification RSM/DDGS diet with a commercial dose of phytase. The addition of a phytase superdose to the negative control diet (NC+) reduced P excretion of birds by 15% compared to birds offered NC.

Dietary calcium requirements of broilers fed a conventional corn-soybean meal diet from 1 to 21 days of age

Background

The current calcium (Ca) recommendation for broilers is primarily based on studies conducted more than 30 years ago with birds of markedly different productive potentials from those which exist today. And the response indicators in these studies are mainly growth performance and bone ash percentage. Therefore, the present study was carried out to investigate the effect of dietary Ca level on growth performance, serum parameters, bone characteristics and Ca metabolism-related gene expressions, so as to estimate dietary Ca requirements of broilers fed a conventional corn-soybean meal diet from 1 to 21 days of age.

Methods

A total of 420 1-day-old Arbor Acres male broilers were randomly assigned to 1 of 7 treatments with 6 replicates (10 birds per cage) and fed the corn-soybean meal diets containing 0.60%, 0.70%, 0.80%, 0.90%, 1.00%, 1.10% or 1.20% Ca for 21 days. Each diet contained the constant non-phytate phosphorus content of about 0.39%.

Results

The average daily gain decreased linearly (P < 0.001) as dietary Ca level increased. The serum and tibia alkaline phosphatase (ALP) activities, tibia bone mineral density (BMD), middle toe BMD, tibia ash percentage, tibia breaking strength, and tibia ALP protein expression level were affected (P < 0.05) by dietary Ca level, and showed significant quadratic responses (P < 0.02) to dietary Ca levels. The estimates of dietary Ca requirements were 0.80 to 1.00% based on the best fitted broken-line or quadratic models (P < 0.03) of the above serum and bone parameters, respectively.

Conclusions

The results from the present study indicate that the Ca requirements would be about 0.60% to obtain the best growth rate, and 1.00% to meet all of the Ca metabolisms and bone development of broilers fed a conventional corn-soybean meal diet from 1 to 21 days of age.

Classic and Non-Classic Effects of the Duration of Supplementation of 25-Hydroxicholecalciferol in Broiler Chicken Diets

Simple Summary

Genetic programs of modern commercial-type broiler chickens are based on growth performance parameters associated with muscular growth, feed efficiency, and meat and breast yield. Therefore, highly bioavailable vitamin D₃ to sustain optimal muscle and bone development is necessary. In the present study the effect of different durations of supplementing of 25-hydroxycholecalciferol (25(OH)D₃) in broiler chickens was evaluated. Growth performance response, carcass and cuts yield, bone resistance, plasma concentration of 25(OH)D₃, and expression of the mTOR gene were evaluated. The use of 25(OH)D₃ in the diets for broilers during different feeding periods did not influence growth performance but increased the plasma concentration of 25(OH)D₃, and increased breast yield as the duration of the supplementation was extended. The supplementation of 25(OH)D₃ increased breast yield and protein deposition in the breast muscle which may have been a result of the epigenetic changes caused by this vitamin D (Vit D) metabolite.

Abstract

The present study aimed to determine the effect of different times of supplementation of 25-hydroxycholecalciferol (25(OH)D₃) in broiler chickens on the performance, carcass and cuts yield, bone resistance, plasma concentration of 25(OH)D₃, and expression of the mTOR gene. The treatments were a control diet (CD) supplemented with 3000 IU vitamin D₃/kg of feed from 1 to 46 d, or the CD + 2760 IU (69 mcg) of 25(OH)D₃/kg of feed from 1 to 21 d, from 1 to 35 d, or from 1 to 46 d. The period of supplementation of 25(OH)D₃ did not affect the growth performance of broilers, but the breast meat yield was linearly increased in response to increasing days of supplementation (p < 0.05). Birds supplemented with 25(OH)D₃ at the time of the analysis showed an increase (p < 0.05) in the plasma concentration of 25(OH)D₃ when compared to non-supplemented birds. The mTOR gene expression (p < 0.05), and breast protein deposition (p < 0.05) presented a quadratic response related to the supplementation period of 25(OH)D₃. The fat content of the breast linearly decreased (p < 0.05) as the period of supplementation was extended. The results also showed a positive linear correlation between mTOR expression and 25(OH)D₃ plasma levels (r = 0.593; p < 0.05).

Early-life conditioning strategies to reduce dietary phosphorus in broilers: underlying mechanisms

Chickens adapt to P and Ca restriction during the very first days of life by improving P utilisation efficiency. The present study was built to identify the mechanisms underlying this adaptive capacity, and to identify the optimal window of application of the restriction (depletion). A total of 1600 Cobb 500^TM male broilers were used. During each phase (from age 0 to 4 d, 5 to 8 d, 9 to 18 d and 19 to 33 d), the animals received either a control diet (H) or a restricted diet (L) with reduced levels of non-phytate P (nPP) and Ca (between −14 and −25 % for both) with four dietary sequences: HHHH, HLHL, LHHL and LLHL. None of the feeding strategies affected growth. Tibia ash content at day 4 and 8 was impaired when the L diet was fed from 0 to 4 and 5 to 8 d, respectively (P = 0⋅038 and P = 0⋅005). Whatever the early restriction period or length between 0 and 8 d of age, the mineralisation delay was compensated by day 18. This was accompanied by an increased mRNA expression of the Ca transporter, CALB1, and an increased apparent ileal digestibility of Ca at day 8 (P < 0⋅001). This adaptation was limited to the starter phase in restricted birds. No effect was seen on P transporters mRNA or protein expression. In conclusion, birds adapted to mineral restriction by increasing Ca and nPP utilisation efficiencies. Depletion−repletion strategies are promising in improving the sustainability of broiler production but need to be validated in phytase-supplemented diets.

Ileal Transcriptome Profiles of Japanese Quail Divergent in Phosphorus Utilization

Phosphorus (P) is an essential component for all living beings. Low P diets prompt phenotypic and molecular adaptations to maintain P homeostasis and increase P utilization (PU). Knowledge of the molecular mechanisms of PU is needed to enable targeted approaches to improve PU efficiency and thus lower P excretion in animal husbandry. In a previous population study, Japanese quail were subjected to a low P diet lacking mineral P and exogenous phytase. Individual PU was determined based on total P intake and excretion. A subset of 20 extreme siblings discordant for PU was selected to retrieve gene expression patterns of ileum (n = 10 per PU group). Sequencing reads have been successfully mapped to the current Coturnix japonica reference genome with an average mapping rate of 86%. In total, 640 genes were found to be differentially abundant between the low and high PU groups (false discovery rate ≤ 0.05). Transcriptional patterns suggest a link between improved PU and mitochondrial energy metabolism, accelerated cell proliferation of enterocytes, and gut integrity. In assessing indicators of the efficient use of macro- and micronutrients, further research on turnover and proliferation rates of intestinal cells could provide an approach to improve P efficiency in poultry species.

Effects of Adding Phytase from Aspergillus niger to a Low Phosphorus Diet on Growth Performance, Tibia Characteristics, Phosphorus Excretion, and Meat Quality of Broilers 35 days after hatching

This study was designed to determine the effect of phytase extracted from Aspergillus niger (Natuphos^® E) on growth performance, bone mineralization, phosphorous excretion, and meat quality parameters in broilers fed available phosphorous (aP)-deficient diet. In total, 810 one-day-old Indian River broilers were randomly allotted into one of three dietary treatments, with six replicates per treatment. The three dietary treatments were 1) control group (CON: basal diet with sufficient aP), 2) low phytase (LPY: available phosphorus-deficient diet supplemented with 0.01% phytase), and 3) high phytase (HPY: available phosphorus-deficient diet supplemented with 0.02% phytase). Average daily gain and, feed intake, and feed conversion ratio were measured for 35 days. Excreta were collected from each pen on day 35. One broiler from each cage was euthanized to collect visceral organs and tibia samples. Broiler chickens fed LPY and HPY showed improved (P<0.05) growth performance compared to broilers fed CON on day 35. The tibia length of HPY-fed broilers was more than those of broilers fed other diets on day 35 (P<0.05). However, tibia calcium and phosphorous contents in LPY-fed broilers was higher (P<0.05) than in CON and HPY-fed broilers. Tibia length and calcium and phosphorous content showed a positive correlation (P<0.05) with the weight gain of broilers on day 35. Phosphorous level in the excreta of LPY- and HPY-fed broilers was lesser than those of CON broilers on day 35 (P<0.05). Furthermore, HPY-fed broilers showed lower (P<0.05) phosphorous content in the excreta than LPY-fed broilers. LPY- and HPY-fed broilers showed higher (P<0.05) liver weight than the CON broilers. In conclusion, broilers fed aP-deficient diet supplemented with phytase from Aspergillus excreted less phosphorus, which enhanced growth performance and tibia development from time of hatching to day 35 post-hatching.

Low digestibility of phytate phosphorus, their impacts on the environment, and phytase opportunity in the poultry industry

Phosphorus is an essential macro-mineral nutrient for poultry, needed for the body growth, development of bones, genomic function, good quality flesh, and eggs production. The imbalance of organic phosphorus sources in the diet mostly affect the phosphorus digestibility, reduces the poultry performance and health, and increases the environmental pollution burden. A study was reviewed to estimate the low phytate phosphorus digestibility of ingredients in poultry diet and their impacts on environmental ecosystem and opportunity of phytase supplementation. Plant ingredients mostly used in poultry diets are rich in phytate phosphorus. The phytate phosphorus digestibility and utilization is low in the gut of birds which leads to decrease other nutrients digestibility and increase excessive excretion of phosphorus with additional nutrients in the manure. When that manure applied to the lands containing excessive residual phosphorus and additional nutrients which pollute soil, groundwater disturbed the entire ecosystem. This issue is developed by poultry due to lack of digestive enzyme phytase which promotes the phytate phosphorus during digestion and reduces the excessive losses of phosphorus in excreta. To overcome this matter, the addition of mostly exogenous phospho-hydrolytic phytase enzymes in the diet, i.e. Escherichia coli, Peniophora lycii, Aspergillus niger, and Ficum, are the possible ways to increase the digestibility and utilization of phytate phosphorus and promote the stepwise release of phosphorus from phytate and significantly decrease phosphorus excretion. The aim of this review is to highlight the role of phytase supplementation in the poultry feeding, improvement of phytate phosphorus digestibility with performance, and reduction of phosphorus pollution from the environment.

Evaluation of high dietary phytase supplementation on performance, bone mineralization, and apparent ileal digestible energy of growing broilers

The present study was conducted to evaluate four commercially available phytase sources supplemented at regular (R) and super-dose (S) levels on live performance, bone mineralization, and apparent ileal digestible energy. Broiler chickens were allocated in stainless steel battery brooders (six birds per cage and eight pen replicates per treatment). A basal diet formulated to contain 0.2% non-phytate phosphorus (NPP) and 0.7% Ca was subdivided to create 11 dietary treatments: (1) basal diet was kept as the negative control (NC); (2) NC + limestone and monoclacium phosphate to create positive controls 1 and 2 formulated to yield 0.3% and 0.4% NPP; (3) NC + phytase A (250 and 1,500 FTU/kg); (4) NC + phytase B (500 and 1,500 FTU/kg); (5) NC + phytase C (500 and 1,000 FTU/kg); (6) NC + phytase D (1,000 and 2,000 FYT/kg). Performance was evaluated on d 7, 14, and 22. Tibia bone ash, tibia breaking strength, bone mineral content, and bone mineral density were evaluated on d 22. Apparent energy digestibility was evaluated on d 24. At d 7, phytases A and C supplemented at S level improved (P < 0.05) body weight and weight gain when compared to the NC. At d 14 and 22, all phytase sources improved (P < 0.05) body weight, weight gain, and bone mineralization when compared to the chicks under the NC diet. Overall, phytase supplementation at S level improved 17% apparent ileal digestibility at 24 d. Throughout the grow out period, phytase super-dose yield (P < 0.05) better performance, bone characteristics, and energy digestibility than the regular dietary level. In conclusion, all phytase sources were able to compensate the phosphorus deficiency and promote performance and bone mineralization. High levels of phytase showed a higher response when compared to the lower levels of supplementation.

A reassessment of the vitamin D requirements of modern broiler genotypes

We hypothesized that performance and bone mineralization of 2 broiler lines will benefit from increasing vitamin D (vitD) supplementation above current commercial levels and by partial substitution of D3 by 25-OH-D3. Male Ross 308 and 708 chicks (n = 576), were offered diets with low (LD; 1,000), medium (MD; 4,000) or high levels of D3 (HD; 7,000 IU/kg), and medium levels of vitD where the majority of D3 was substituted by 25-OH-D3 (25MD; 1,000 D3+3,000 25-OH-D3 IU/kg). Performance was measured at the end of starter (day 10), grower (day 24), and finisher periods (day 38). Three birds per pen were dissected at the end of each period to assess tibia and femur ash percentage (%), ash weight, bone breaking strength (BBS), and serum levels of 25-OH-D3. Remaining birds were gait scored (GS) at day 37 of age. Genotype and diet did not interact for any trait, whilst performance was not affected by diet. Ross 708 had lower body weight (P < 0.005), higher feed conversion ratio over the grower period (P < 0.05), similar levels of 25-OH-D3, but higher GS (P < 0.05) than Ross 308. Serum 25-OH-D3 levels were affected by diet at the end of the starter and grower periods (P < 0.05), being lowest for LD and highest for 25MD. Diet affected GS (P < 0.01), being higher in LD than 25MD. Femur ash % was higher at the end of the starter and grower periods for 25MD than LD and for both HD and 25MD than LD (P < 0.05). Femur and tibia ash weight were higher for 25MD in comparison to LD birds (P < 0.05) at the end of the grower period. Femur and tibia BBS were higher (P < 0.05) for 25MD in comparison to LD at the end of the grower and finisher periods, respectively. Overall, effects of vitD supply were more pronounced for femur than for tibia mineralization. Results do not suggest supplementation of vitD above current maximum levels and support partial substitution by 25-OH-D3.

Effects of dietary calcium and phosphorus deficiency and subsequent recovery on broiler chicken growth performance and bone characteristics

The ability of birds to modify dietary phosphorus utilisation when fed with low-phosphorus and calcium (Ca) diets was studied using different sequences of dietary phosphorus and Ca restriction (depletion) and recovery (repletion) during the grower and the finisher phases. A total of 3600 Ross 708 broilers were randomly divided into 10 replicate pens per treatment (60 per pen, six pens per block). Chicks were fed a common starter diet from days 0 to 10, then a grower control diet (C: 0.90% Ca, 0.39% non-phytate phosphorus, nPP), mid-level diet (M: 0.71% Ca, 0.35% nPP) or low Ca and nPP diet (L: 0.60% Ca, 0.30% nPP) from days 11 to 21, followed by a finisher diet C, M or L containing, respectively, 0.85%, 0.57% or 0.48% Ca and 0.35%, 0.29% or 0.24% nPP from days 22 to 37. Six treatment sequences were tested: CC, MM, LL, ML, LC and LM. Bone mineral content by dual-energy X-ray, tibia ash, toe ash weight and tibia breaking strength were measured on days 21 and 37. No significant effect was observed on growth performance throughout the experiment. Diet L reduced bone mineral content, breaking strength, tibia and toe ash by 9%, 13%, 11% and 10%, respectively, on day 21 (compared with diet C, for linear effect, P<0.05). On day 37, bone mineral content, breaking strength, tibia and toe ash remained lower compared with control values (CC v. MM v. LL, P<0.05 for linear and quadratic effects). Mineral depletion duration (ML v. LL) did not affect bone mineral status. Replenishing with the C diet during the finisher phase (LC) restored bone mineral content, tibia ash and toe ash weight better than the M diet did, but not to control levels (CC v. LC v. LM, for linear effect, P<0.05). These results confirm that dietary Ca and nPP may be reduced in the grower phase without affecting final growth performance or breaking strength as long as the finisher diet contains sufficient Ca and nPP. The practical applications of this strategy require further study in order to optimise the depletion and repletion steps.

Calcium and phosphorus metabolism and nutrition of poultry: are current diets formulated in excess?

Calcium (Ca) and phosphorus (P) are important nutrients in poultry diet formulations. In the present review, we discuss recent advances in our understanding of the metabolism of Ca and P in poultry. Recent data are provided in support of the proposition that current poultry diets are formulated in excess for Ca and P. The quantities of Ca and P available for metabolism reflect rates of intestinal absorption, bone accretion and resorption, glomerular filtration, renal tubular reabsorption, and intestinal endogenous losses. Ca and P homeostasis is largely under endocrine control. Parathyroid hormone and the hormonal form of vitamin D3 are the two hormones credited with this role. However, a novel hormonal axis involving Fibroblast Growth Factor 23 and Klotho has been recently delineated, which, in conjunction with parathyroid hormone and vitamin D3, tightly regulates Ca and P homeostasis. Recent studies have suggested that current commercial diets for both broilers and layers contain excess Ca and P, the content of which could be reduced without affecting production or bird welfare. The challenge in reducing Ca and P concentrations in poultry diets is the uncertainty about what concentrations of Ca and P can be fed without compromising bird welfare. This is because there are limited data on the available P and Ca concentrations in poultry feedstuffs determined biologically. This is further complicated by the need for agreement on evaluation systems for evaluation of Ca and P bioavailability. We conclude that direct ileal or pre-caecal digestible Ca and P values are preferred.

Effect of feeding broilers diets differing in susceptible phytate content

Measurements of total phytate phosphorus content of diets may be deceptive as they do not indicate substrate availability for phytase; it may be that measurements of phytate susceptible to phytase effects are a more accurate measure of phosphorus (P) availability to the bird. To verify this hypothesis, an experiment was conducted to compare diets formulated to contain either high or low susceptible phytate, supplemented with either 0 or 500 FTU/kg phytase. Susceptible phytate was determined by exposing the feed samples to conditions that mimicked the average pH of the proximal gastrointestinal tract (pH 4.5) and the optimum temperature for phytase activity (37 °C) and then measuring phytate dissolved. Ross 308 birds (n = 240) were fed one of 4 dietary treatments in a 2 × 2 factorial design; 2 diets with high (8.54 g/kg, 57.90% of total phytate) or low (5.77 g/kg, 46.33% of total phytate) susceptible phytate, containing 0 or 500 FTU/kg phytase. Diets were fed to broilers (12 replicate pens of 5 birds per pen) from d 0 to 28 post hatch. Birds fed diets high in susceptible phytate had greater phytate hydrolysis in the gizzard (P < 0.001), jejunum (P < 0.001) and ileum (P < 0.001) and resulting greater body weight gain (BWG) (P = 0.015) and lower FCR (P = 0.003) than birds fed the low susceptible phytate diets, irrespective of phytase presence. Birds fed the high susceptible diets also had greater P solubility in the gizzard and Ca and P solubility in the jejunum and ileum (P < 0.05) and resulting greater tibia and femur Ca and P (P < 0.05) content than those fed the low susceptible diets. All the susceptible phytate was fully degraded in the tract in the absence of added phytase, suggesting the assay used in this study was able to successfully estimate the amount of total dietary phytate that was susceptible to the effects of phytase when used at standard levels. No interactions were observed between susceptible phytate and phytase on phytate hydrolysis. Hydrolysis of phytate was greater (P < 0.05) in the gizzard of birds fed the diets supplemented with phytase, regardless of the concentration of susceptible phytate in the diet. Phytase supplementation resulted in improved BWG (P < 0.001) and FCR (P = 0.001), increased P solubility (P < 0.001) in the gizzard, Ca and P solubility (P < 0.001) in the jejunum and ileum and Ca and P concentration (P < 0.001) and strength (P < 0.001) in the tibia and femur. Pepsin activity was higher in birds fed the diets supplemented with phytase (P < 0.001) and was greater (P = 0.031) in birds fed the high susceptible phytate diets compared with the low susceptible phytate diets. Findings from this study suggest that there may be a measure more meaningful to animal nutritionists than measurements of total phytate.

Effects of administration of four different doses of Escherichia coli phytase on femur properties of 16-week-old turkeys

Background

The enzyme phytase is able to initiate the release of phosphates from phytic acid, making it available for absorption within gastrointestinal tract and following utilization. The aim of the study was to determine effects of Escherichia coli phytase administration on morphological, densitometric and mechanical properties of femur in 16-week-old turkeys. One-day-old BUT Big-6 males were assigned to six weight-matched groups. Turkeys receiving diet with standard phosphorus (P) and calcium (Ca) content belonged to the positive control group (Group I). Negative control group (Group II) consisted of birds fed diet with lowered P and Ca content. Turkeys belonging to the remaining groups have received the same diet as group II but enriched with graded levels of Escherichia coli phytase: 125 (Group III), 250 (Group IV), 500 (Group V) and 1000 (Group VI) FTU/kg. At the age of 112 days of life, the final body weights were determined and the turkeys were sacrificed to obtain right femur for analyses. Geometric and densitometric properties of femur were determined using quantitative computed tomography (QCT) technique, while mechanical evaluation was performed in three-point bending test.

Results

Phytase administration increased cross-sectional area, second moment of inertia, mean relative wall thickness, cortical bone mineral density and maximum elastic strength decreasing cortical bone area of femur (P < 0.05). Reduced dietary Ca and P content decreased final body weight of turkeys by 6.5% (P = 0.006). The most advantageous effects of Escherichia coli phytase administration on geometric, densitometric and mechanical properties of femur were observed in turkeys receiving 125 and 250 FTU/kg of the diet. Phytase administration at the dosages of 500 and 1000 FTU/kg of the diet improved the final body weight in turkeys.

Conclusions

The results obtained in this study indicate a possible practical application of Escherichia coli phytase in turkey feeding to improve skeletal system properties and function.

Assessing changes in the composition of broiler litters from commercial poultry units in Northern Ireland following the adoption of phytase in diets

Microbial phytases increase the bioavailability of phytate P in poultry diets, and a survey was undertaken to determine if their use had lowered the P composition of broiler litter in Northern Ireland compared with standard values of litter composition listed in the current United Kingdom fertilizer recommendations. Litter samples were collected from a total of 20 units across Northern Ireland in 2010 and analyzed for DM, N, phosphate (P2O5), potash (K2O), magnesium oxide (MgO), water-soluble P (WSP), ammonium N (NH4N), and uric acid N. Dry matter of litter was positively correlated (P < 0.001) with N (r(2) = 0.65), P2O5 (r(2) = 0.63), K2O (r(2) = 0.56), and MgO (r(2) = 0.58). Negative correlations were observed between litter DM and WSP (r(2) = 0.45, P < 0.001) and NH4N (r(2) = 0.22, P = 0.038) contents. A standardized litter composition with a 60% DM gave a phosphate content of 13.7 kg/t that was 45% lower than the fertilizer book value (RB209), but there were only slight differences (<3%) between book values and DM standardized values for N and potash contents. Uric acid and NH4 contents were similar to published values. Mean N:P ratio (by weight) of litter increased from 3.7 in 2004 to 5.0 in 2010, lowering the risk of oversupply of P if land applications are targeted to meet N supply. Using the standard RB209 values to plan land applications of broiler litter to meet crop P demands risks undersupplying P, and there is a need for the regulatory values to be modified in light of the changing composition of broiler litter.

Effect of a by-product of solid state fermentation (Synergen™) on broiler performance

The trial was conducted to evaluate the effect of a by-product of solid state fermentation (Synergen™ (SGN), Alltech Inc, Nicholasville KY, USA) on broiler performance and health. One thousand two hundred and eighty male Ross 308 broilers were used in a 42 day pen trial. The trial was designed as a 2 × 2 factorial, with two diet specifications (standard and reformulated) plus or minus SGN (0 and 200 g/t, SGN replaced with commercial enzyme Ronozyme™ at 150 g/t) to give four dietary treatments in total in a corn-soy based diet formulated to commercial standards. Birds fed the reduced energy diets had significantly lower cumulative feed intakes at 42 d (P < 0.01) compared to those on the full specification standard diet. There were no significant differences in broiler body weight due to treatments at any age. Significant improvements (P < 0.05) in FCR, primarily due to SGN inclusion in the feed, were observed for all weekly reported data. There were no significant differences in either mortality or EPEF for any of the treatment diets. The present study indicates that SGN, a by-product of solid state fermentation (SSF) can improve feed conversion of broilers fed a corn-soy diet.

Effect of two microbial phytases on mineral availability and retention and bone mineral density in low-phosphorus diets for broilers

1. The efficacy of supplementation of a low-phosphorus (low-P) maize-soyabean meal diet for broiler chickens with two different microbial (fungal and bacterial) phytases was examined. 2. Broiler chickens received a low-P maize-soyabean meal diet containing either no phytase or one of the two phytases included at one and two times the manufacturer's recommended inclusion level for 21 d. 3. Titanium dioxide was included in the diets as an indigestible marker. Excreta were collected quantitatively from d 18 to 21, and at the end of the study the birds were killed and ileal digesta and leg bone samples collected. 4. No differences were observed for body weight gain and feed intake or apparent metabolisable energy (AME) among all dietary treatment groups. 5. Dietary phytase supplementation improved the apparent retention of Ca, Na and Cu and ileal phytate P absorption from 32% to 44% across inclusion levels. 6. Bone mineral density (BMD) was improved for both phytases across inclusion levels by, on average, 9% for the tibia and 13% for the femur. 7. Dietary phytase supplementation of the low-P diet improved apparent ileal digestibility of serine, glycine, valine, isoleucine, tyrosine, histidine, lysine and arginine. 8. When the results from the present study were combined with the results from other similar published studies and analysed statistically, factors such as dietary P and Ca concentration, as well as bird breed and age, rather than the type or activity of microbial phytase, had the greatest impact on the extent to which dietary supplementation improved P and Ca retention. 9. More work is required to explain the interrelationships between the multiple factors influencing the efficacy of phytase on the availability of dietary minerals.

Effect of a novel phytase on growth performance, apparent metabolizable energy, and the availability of minerals and amino acids in a low-phosphorus corn-soybean meal diet for broilers

The addition of microbial phytase to diets for broiler chickens has been shown to improve the availability of phytate P, total P, some other minerals, and amino acids. In this study, the effect of a novel microbial phytase expressed by synthetic genes in Aspergillus oryzae on amino acid and mineral availability was assessed. Phytase was incorporated (1,000 and 2,000 U/kg) into low-P corn-soybean meal-based diets for broilers. Broilers received the experimental diets for 3 wk, and excreta were collected from d 18 to 21 for the determination of AME and mineral retention. On the 22nd day, the broilers were killed and the left leg removed and ileal digesta collected. Ileal phytate P and total P absorption, ileal amino acid digestibility, as well as the bone mineral content and bone mineral density were determined. Ileal phytate P absorption and absorbed phytate P content of the low-P corn-soybean meal diet were significantly (P < 0.05) higher after dietary inclusion of the novel phytase (49-60% and 65-77% higher, respectively). Apparent ileal total P absorption and apparent total P retention was 12 to 16% and 14 to 19% higher (P < 0.05), respectively, after dietary inclusion of phytase. The bone mineral content and bone mineral density in the tibia were 32 to 35% and 19 to 21% higher (P < 0.05), respectively, after dietary phytase inclusion. The apparent ileal digestibility of threonine, tyrosine, and histidine increased significantly (P < 0.05) by 14, 9, and 7%, respectively, after dietary inclusion of microbial phytase. Overall, the inclusion of a novel microbial phytase into a low-P corn-soybean meal diet for broiler chickens greatly increased phytate P and total P absorption, bone mineral content and density, as well as the digestibility of some amino acids.

Recent advances in research on enzymes for poultry diets

Exogenous enzymes have been used extensively in the diets of poultry to improve productive performance. Further research, however, is needed to evaluate the efficacy of enzyme use and for the expansion of the use of enzymes to accommodate the wide array of dietary constituents used in poultry feeding programs. The use of effective phytase preparations to improve bird performance and to reduce environmental P pollution has shown less than optimum results, partly due to the potential negative effects of nontargeted dietary fiber components and to confounding influence of inadequate knowledge of accurate P requirements and the tendency for the use of excessive safety margins in diet formulation. Targeting specific nonstarch polysaccharides (NSP) of wheat, barley, or rye with enzyme preparations has proven effective for diets based on these cereals but not for corn- and soybean meal-based diets, primarily due to the differences in constituent NSP. The increased use of whole flaxseed in poultry diets represents an additional research area for effective enzyme development to alleviate potential negative effects of constituent NSP components. Such challenges of the enzyme development process and their outcomes are presented in this publication.

Review: Supplementation of phytase and carbohydrases to diets for poultry

Woyengo, T. A. and Nyachoti, C. M. 2011. Review: Supplementation of phytase and carbohydrases to diets for poultry. Can. J. Anim. Sci. 91: 177–192. Feedstuffs of plant origin contain anti-nutritional factors such as phytic acid (PA) and non-starch polysaccharides (NSP), which limit nutrient utilization in poultry. Phytic acid contains phosphorus, which is poorly digested by poultry, and has the capacity to bind to and reduce the utilisation of other nutrients, whereas NSP are indigestible and have the capacity to reduce nutrient utilisation by encapsulation. Supplemental phytase and NSP-degrading enzymes (carbohydrases) can, respectively, hydrolyze PA and NSP, alleviating the negative effects of these anti-nutritional factors. In feedstuffs of plant origin, PA is located within the cells, whereas NSP are located in cell walls, and hence it has been hypothesized that phytase and carbohydrases can act synergistically in improving nutrient utilization because the carbohydrases can hydrolyze the NSP in cell walls to increase the accessibility of phytase to PA. However, the response to supplementation of a combination of these enzymes is variable and dependent on several factors, including the type of carbohydrase supplement used, dietary NSP composition, calcium and non-phytate phosphorus contents, and endogenous phytase activity. These factors are discussed, and areas that need further research for optimising the use of a combination of phytase and carbohydrases in poultry diets are suggested.

Growth performance and nutrient utilization of broiler chickens fed diets supplemented with phytase alone or in combination with citric acid and multicarbohydrase

An experiment was conducted to determine the effect of supplementing a corn-soybean meal-based diet with phytase alone or in combination with citric acid (CA) or multicarbohydrase, a preparation containing nonstarch polysaccharide-degrading enzymes, or both, on growth performance, nutrient utilization, and bone mineralization. A total of 360 one-day-old broiler chicks were assigned to 6 dietary treatments, consisting of 12 pens of 5 birds each, and were fed experimental diets from 1 to 21 d of age. The diets included a positive control (0.46% nonphytate P; 1.1% Ca) and a negative control (NC; 0.26% nonphytate P; 0.89% Ca) without or with phytase (600 U/kg) alone, phytase plus CA (5 g/kg), phytase plus multicarbohydrase (Superzyme OM; 0.6 g/kg), or phytase (Ronozyme P-CT) plus CA and multicarbohydrase. Birds fed the positive control diet had higher (P<0.05) BW gain (764 vs. 594 g/21 d) and tibia ash content (50.0 vs. 38.3%) than those fed the NC diet. Phytase improved (P<0.05) BW gain (632 g/21 d), which increased further (P<0.05) to 673 g/21 d for the phytase plus multicarbohydrase diet. In contrast to phytase alone, phytase plus multicarbohydrase supplementation improved (P<0.05) feed conversion ratio of the NC diet from 1.37 to 1.32. Tibia ash content for the NC diet increased (P<0.05) from 38.3 to 42.4% due to phytase addition. Phytase improved (P<0.05) ileal digestibility of P from 29.5 to 43%, and the addition of CA or multicarbohydrase, or both, to a phytase-supplemented diet further increased (P<0.05) P digestibility to 51.5, 53.4, and 54.3%, respectively. Phytase addition improved (P<0.05) diet AMEn content from 2,959 to 3,068 kcal/kg, which tended (P<0.06) to increase further with CA (3,150 kcal/kg) or multicarbohydrase (3,142 kcal/kg) addition. No beneficial interactions were detected between CA and multicarbohydrase for all response criteria measured. Results show that addition of multicarbohydrase to the phytase-supplemented broiler diets improved nutrient utilization and growth performance.

Nutrient release from bisulfate-amended phytase-diet poultry litter under simulated weathering conditions

Poultry litter generated on the Delmarva Peninsula is from phytase-modified bird diet and bisulfate amendment. To establish agronomic application rates in conservation tillage systems, bisulfate-amended phytase-diet poultry litter was investigated for its nutrient release kinetics and supply capacity under simulated weathering conditions. Delmarva poultry litter was packed in PVC columns (15 cm i.d. x 25 cm height) to a depth of 5 cm and leached intermittently with 600 mm of water for 190 days. Concentrations of various nutrients in leachate were analyzed and nutrient release kinetics were modelled. Poultry litter leachate contained high contents of dissolved organic carbon (DOC, 35-11,800 mg L(-1)), nitrogen (N 6-2690 mg L(-1)), phosphorus (P 45-225 mg L(-1)), potassium (K 20-6060 mg L(-1)), and other nutrients. Release of the nutrients occurred primarily in the starting 5 weeks and mostly followed a first order Exponential-Rise-to-Maximum model. Under the specified conditions, the poultry litter demonstrated a nutrient supply capacity of 11.7 kg N Mg(-1), 5.4 kg P Mg(-1), and 36.8 kg K Mg(-1). Release of the potentially plant-available N and K was nearly finalized within 190 days of leaching/weathering, but it would require two years for full release of the leachable P. The results indicate that with consideration of field conditions, surface application of bisulfate-amended phytase-diet Delmarva poultry litter at recommended 6.6 Mg ha(-1) to conservation tillage systems would largely provide P 25.0 kg ha(-1), N 106.6 kg ha(-1), and K 245.5 kg ha(-1) to seasonal crops.

Influence of enzyme supplementation of maize-soyabean meal diets on carcase composition, whole-body nutrient accretion and total tract nutrient retention of broilers

1. Carcase composition, whole body nutrient accretion rates and total tract nutrient retention of broilers in response to supplemental phytase or carbohydrase and protease from 0 to 21 d of age were investigated. 2. A total of 480 broilers were allocated to 4 slaughter groups (SG) of 30, 150, 150 and 150 broilers. Thirty broilers, in 6 replicates of 5 birds, comprised the initial SG killed at d 0; 150 broilers were allocated to each of the d 7, 14 and 21 final SG. Broilers in the final SG were allocated to 5 treatments in a randomised complete block design; each treatment had 6 replicate cages of 5 broilers per replicate cage. 3. The diets were maize-wheat-soyabean based and the treatments were: (1) positive control which met NRC (1994) energy and nutrients requirements for broiler, (2) negative control (NC) deficient in metabolisable energy (ME) and P, (3) NC plus phytase added at 1000 FTU/kg, (4) NC plus cocktail of xylanase, amylase and protease (XAP), and (5) NC plus phytase and XAP. 4. Except for ash and Ca, the treatments had no effect on carcase composition. Phytase or XAP individually or combined had variable effects on body nutrient accretion rates at various age periods of the broilers compared with the NC diet. Phytase alone or combined with XAP consistently improved body accretion rates of DM, protein, fat, ash, Ca, and P. 5. Addition of phytase alone or combined with XAP to the NC diet improved total tract N and P retention compared with the NC diet. Cocktail of XAP alone or combined with phytase improved Ca retention. Combination of phytase and XAP improved metabolisable energy (ME) and dry matter retention. 6. Overall, the results showed that the exogenous enzymes used had greater effects on the rates of nutrient accumulation in the carcase rather than on the proportion of nutrients deposited in the carcase.